2021 Ford Mustang

The contact owns a 2021 Ford Mustang. The contact received notification of NHTSA Campaign Number: 25V455000 (Fuel System, Gasoline). The contact stated that while the vehicle was stopped and the accelerator pedal was depressed on several occasions, the vehicle hesitated to accelerate as intended. The contact stated that there were no warning lights illuminated. The vehicle was not diagnosed or repaired. The manufacturer was not notified of the failure. The contact stated that the manufacturer had exceeded a reasonable amount of time for the recall repair. The failure mileage was approximately 5.

The contact owns a 2021 Ford Mustang. The contact received notification of NHTSA Campaign Number: 25V455000 (FUEL SYSTEM, GASOLINE); however, the part to do the recall repair was not yet available. The contact stated that while driving in stop-and-go traffic, the vehicle hesitated. The contact pulled into a gas station where the vehicle experienced vapor lock. The vehicle failed to restart, with an abnormal cranking sound coming from the vehicle. After several attempts, the contact was able to restart the vehicle. No warning lights were illuminated. The contact stated that on a separate occasion, the failure persisted. The contact called the dealer and was informed that the failure might be caused by the purge valve. The vehicle was not repaired. The contact stated that the failures occurred when the vehicle had a half tank to a full tank of fuel. The contact stated that the manufacturer had exceeded a reasonable amount of time for the recall repair. The manufacturer was not made aware of the issue. The failure mileage was approximately 5,000.

The contact owns a 2021 Ford Mustang. The contact received notification of NHTSA Campaign Number: 25V455000 (Fuel System, Gasoline); however, parts were not yet available for the recall repair. The contact stated that parts had not yet been available for six months. The contact was concerned that the vehicle could lose motive power while driving at 65 MPH. The contact stated that if the failure occurred while driving, he could be killed. The contact was informed by two dealers that the parts were not yet available, and there was no available date for the parts' availability. The manufacturer was not contacted. The contact had not experienced a failure.

I RECENTLY PURCHASED THIS CAR. THE REAR BACK-UP CAMERA WAS IN A FLIP FLOPPED STATE. MEANING, WHAT WAS DISPLAYED ON THE CABIN SCREEN ON THE LEFT, WAS ACTUALLY ON THE RIGHT PLUS THE GUIDING LINES ON THE SCREEN WERE MISSING. I PURCHASED AND INSTALLED A NEW CAMERA FROM FORD. THIS FIXED THE FLIP FLOPPED IMMAGE , BUT, NOT THE MISSING LINES ON THE SCREEN. SECURING THE WIRES I NOTICED THE WIRING HARNESS AT THE BEND AT THE DECK AND LID WAS FULLY EXPOSED TO BEING FRAYED BY THE METAL DECK LID. I DID NOT SEE ANY COPPER WIRE SHOWING. BUT, I WONDER HOW LONG IT WILL TAKE TO FRAY TO RAW WIRE? I ALSO OWN A 2015 MUSTANG GT THAT WAS RECALLED FOR THE EXACT SAME CONDITION. THAT WIRING HARNESS WAS REPLACED BY MY LOCAL FORD DEALERSHIP IN 2024.

The contact owns a 2021 Ford Mustang. The contact stated that while depressing the accelerator pedal, the vehicle hesitated and then vibrated. The contact stated that the failure only occurred while attempting to accelerate. There was no warning light illuminated. The contact received notification of NHTSA Campaign Number: 25V455000 (Fuel System, Gasoline). However, when the dealer was contacted, the contact was informed that parts were not yet available. The contact stated that the manufacturer had exceeded a reasonable amount of time for the recall repair. The manufacturer was not informed of the failure. The failure mileage was approximately 44,000.

While entering an on-ramp and just before merging onto the freeway the vehicle failed to accelerate and I lost complete power from the engine. The vehicle was still powered on, but produced no combustion from the engine. The check engine light illuminated and a message appeared on the dash stating to shift the vehicle into neutral. I pulled off on the shoulder and shifted the vehicle into park. I shut the vehicle off and started it back up. After doing so I had full power once again. This is the sixth time this has happened.

The contact owns 2021 Ford Mustang. The contact stated that while her husband was attempting to make a right turn, the vehicle stalled. The vehicle was turned off however, while attempting to restart the vehicle the vehicle failed to respond as needed. No warning light was illuminated. A dealer was contacted. The vehicle was towed to a dealer where it was diagnosed and determined that the fuel pump and battery needed to be replaced. The vehicle was repaired. The contact related the failure to NHTSA Campaign Number: 25V455000 (FUEL SYSTEM, GASOLINE); however, the VIN was not included in the recall. The manufacturer was notified of the failure and informed the contact that the VIN was not included in the recall. The failure mileage was 4,855.

The contact owns a 2021 Ford Mustang. The contact received notification of NHTSA Campaign Number:25V455000 (Fuel System, Gasoline); however, the part to do the recall repair was not yet available. The contact stated that the manufacturer had exceeded a reasonable amount of time for the recall repair. The contact stated that after storing the vehicle in storage for the winter and connecting a battery retainer, the check engine warning light temporarily illuminated for one day. The dealer was contacted and was unsure when parts would be available. The contact called another dealer, Evansville Ford (428 N Union Rd, Evansville, WI 53536); who was unable to confirm when parts would be available. The manufacturer was not made aware of the failure. The failure mileage was approximately 21,000. VIN tool confirms parts not available.

My 2021 Ford Mustang EcoBoost is currently experiencing an ongoing issue with the EVAP purge valve, a critical emissions component. The vehicle suffers from stuttering, rough idle, and a check engine light, especially immediately after refueling, where the engine has stalled multiple times—posing a serious safety risk during traffic re-entry and acceleration.The purge valve has not been replaced, and the issue remains unresolved. I contacted Ford Customer Relations and three separate Ford dealerships, all of which refused to service the vehicle under warranty, despite the fact that it is still covered under the federal emissions warranty (8 years/80,000 miles) and the powertrain warranty.This refusal contradicts federal warranty guidelines, as the purge valve is clearly part of the evaporative emissions control system. The failure disrupts vapor flow and fuel trim stability, leading to erratic engine behavior and emissions system malfunction.I previously owned another Ford Mustang EcoBoost while living in a different part of the state, and that vehicle experienced the exact same purge valve issue, including stalling after refueling and triggering the check engine light. This recurring failure across multiple vehicles suggests a design flaw or supplier defect that Ford has failed to address.There are hundreds of documented complaints and videos online, including on YouTube and Mustang forums, showing other owners experiencing the same purge valve failure and warranty denial. This suggests a systemic issue that Ford is aware of but continues to ignore.I believe this issue warrants investigation for warranty non-compliance, emissions system reliability, and potential recall consideration due to the safety and environmental risks involved.