TL* THE CONTACT OWNS A 1994 FORD MUSTANG. THE CONTACT STATED THAT THE FUEL TANK SEPARATED FROM THE STRAP. THE CONTACT INSPECTED THE VEHICLE HIMSELF AND FOUND THAT THE FUEL TANK AND STRAPS FAILED DUE TO CORROSION. THE CONTACT WAS UNABLE TO INSTALL THE NEW FUEL TANK DUE TO SEVERE CORROSION TO THE FUEL TANK MOUNTING AREA. THE MANUF…
Read full complaint
TL* THE CONTACT OWNS A 1994 FORD MUSTANG. THE CONTACT STATED THAT THE FUEL TANK SEPARATED FROM THE STRAP. THE CONTACT INSPECTED THE VEHICLE HIMSELF AND FOUND THAT THE FUEL TANK AND STRAPS FAILED DUE TO CORROSION. THE CONTACT WAS UNABLE TO INSTALL THE NEW FUEL TANK DUE TO SEVERE CORROSION TO THE FUEL TANK MOUNTING AREA. THE MANUFACTURER WAS NOT NOTIFIED. THE FAILURE MILEAGE WAS 124,000.
EQUIPMENT DESCRIPTION: PASSENGER VEHICLES THAT HAVE HAD THE DRIVER'S AIR BAG MODULE REPLACED AFTER APRIL 5, 2000. THE REPLACEMENT DRIVER'S AIR BAG MODULE INFLATOR MAY HAVE INSUFFICIENT WELDS THAT COULD PREVENT PROPER INFLATION OF THE AIR BAG.
Consequence & remedy
Consequence: IN THE EVENT OF A CRASH, THE DRIVER'S AIR BAG MAY NOT PROPERLY DEPLOY WHICH COULD POTENTIALLY RESULT IN LESS THAN THE INTENDED LEVEL OF OCCUPANT PROTECTION.
Remedy: DEALERS WILL INSPECT AND, IF NECESSARY, REPLACE THE DRIVER'S AIR BAG MODULE. OWNER NOTIFICATION BEGAN OCTOBER 5, 2001. OWNERS WHO TAKE THEIR VEHICLES TO AN AUTHORIZED DEALER ON AN AGREED UPON SERVICE DATE AND DO NOT RECEIVE THE FREE REMEDY WITHIN A REASONABLE TIME SHOULD CONTACT FORD AT 1-866-436-7332.
VEHICLE DESCRIPTION: PASSENGER VEHICLES EQUIPPED WITH MANUAL TRANSMISSIONS. IF A VEHICLE IS PARKED WITH THE PARKING BRAKE NOT FULLY APPLIED AND NOT IN FIRST GEAR, AS DIRECTED IN THE OWNER GUIDE, AND THE SELF ADJUSTMENT PAWL SUBSEQUENTLY SKIPS ONE OR TWO TEETH, THE VEHICLE COULD MOVE ON SOME GRADES.
Consequence & remedy
Consequence: THIS COULD RESULT IN UNINTENDED VEHICLE MOVEMENT AND A VEHICLE CRASH WITHOUT PRIOR WARNING.
Remedy: DEALERS WILL MODIFY THE PARKING BRAKE CONTROL AND INSTALL A PLATE OR OVER-BRACKET TO THE CONTROL TO LOCK THE SELF ADJUST MECHANISM IN POSITION FOLLOWING ADJUSTMENT.
VEHICLE DESCRIPTION: PASSENGER VEHICLES AND MINI VANS. TEARING OF THE BOND BETWEEN THE INNER AND OUTER HOOD PANELS DURING MINOR FRONT END COLLISIONS CAN RESULT IN A GAP AT THE LEADING EDGE OF THE HOOD. AIR FORCED BETWEEN THE INNER AND OUTER PANELS CAN PRODUCE ENOUGH PRESSURE TO FORCE THE OUTER PANEL UPWARD.
Consequence & remedy
Consequence: THIS CONDITION CAN RESULT IN TOTAL SEPARATION OF THE OUTER HOOD PANEL.
Remedy: DEALERS WILL INSPECT THE HOOD AREA FOR ANY DAMAGE ALONG THE LEADING EDGE OF THE HOOD. IF THERE IS ANY EVIDENCE OF BOND SEPARATION, THE HOOD WILL BE REPLACED. IF THERE IS NO EVIDENCE OF BOND SEPARATION, ADDITIONAL ADHESIVE WILL BE APPLIED BETWEEN THE INNER AND OUTER HOOD PANELS.
THE WIRE HARNESS ON THESE SEATS IS BANDED TO THE FRONT SEAT CUSHION SUPPORTS. THE END OF ONE OF THE SUPPORTS CAN PUNCTURE THE HARNESS, RESULTING IN A HIGH RESISTANCE ELECTRICAL SHORT.
Consequence & remedy
Consequence: OVERHEATING CAN RESULT, AND MELTING, SMOKE AND POSSIBLE IGNITION OF THE SURROUNDING MATERIALS CAN OCCUR.
Remedy: DEALERS WILL REMOVE THE TIE STRAP FROM EACH OF THE FRONT SEATS.
Model-level recall history does not show whether a particular VIN is affected or has received a repair. Check a VIN with NHTSA ↗
NHTSA investigations
4
EA98013 · Parking Brake
Opened May 27, 1998 · Closed Oct 31, 2000
Status: closed (inferred from source dates) · Service Brakes, Hydraulic
There is no summary currently available
PE97051 · Parking Brake Failure
Opened Dec 23, 1997 · Closed May 27, 1998
Status: closed (inferred from source dates) · Service Brakes, Hydraulic
THE NUMBER OF CRASHES REPORTED TOT HE MANUFACTURER WARRANTS FURTHER THIS INVESTIGATION
EA97018 · Outer Hood Panel Detachment
Opened Sep 30, 1997 · Closed Oct 22, 1997
Status: closed (inferred from source dates) · Structure
There is no summary currently available
PE97011 · Outer Hood Panel Detachment
Opened Mar 13, 1997 · Closed Sep 30, 1997
Status: closed (inferred from source dates) · Structure
THE OFFICE OF DEFECTS INVESTIGATION HAS RECEIVED 6 REPORTS INDICATING THE OUTER HOOD PANEL SEPARATED FROM THE VEHICLES AS THEY WERE BEING DRIVEN.FORD HAS PROVIDE 39 ADDITIONAL REPORTS THAT ARE CONSISTENT WITH ODI REPORTS.FORD INDICATES THAT THE LIKELY CAUSE IS PRIOR COLLISION DAMAGE.THIS INVESTIGATION IS BEING UPGRADED TO FURTHER STUDY THIS ISSUE.
1994 Ford Mustang Problems, Complaints & Recalls | Skip That Year
Illustration