NHTSA owner reports · September 18, 2026 snapshot.
Power Train complaints
19 reportsClear category filterMileage unknown · Aug 28, 2025
Power Train
CV axles failed at 30,000 miles, repaired under warranty. Replaced axles have failed again at 60,000 miles, no warranty. No hard driving, simply highway miles. This seems to be common in these vehicles and need to be recalled for defective parts. This has caused me poor fuel mileage, damage to new tires, instability while drivin…
Read full complaint
CV axles failed at 30,000 miles, repaired under warranty. Replaced axles have failed again at 60,000 miles, no warranty. No hard driving, simply highway miles. This seems to be common in these vehicles and need to be recalled for defective parts. This has caused me poor fuel mileage, damage to new tires, instability while driving, and possible unknown damage to transaxle.
NHTSA ODI #11683637
Mileage unknown · Jul 6, 2025
EnginePower TrainVehicle Speed Control
While driving on the highway at normal speed in normal conditions, I suddenly lost ABS, traction control, downhill assist, hold assist, AdvanceTrac, Cruise control, and a severe reduction of power. The engine went into limp mode and would not rev past 3k RPM. This made driving on the highway very dangerous as I could not keep up…
Read full complaint
While driving on the highway at normal speed in normal conditions, I suddenly lost ABS, traction control, downhill assist, hold assist, AdvanceTrac, Cruise control, and a severe reduction of power. The engine went into limp mode and would not rev past 3k RPM. This made driving on the highway very dangerous as I could not keep up speed and risked getting rear-ended. The wrench icon came on, as well as ABS and traction control. Cruise control would not work. Messages appeared stating "Service engine soon", "Service AdvanceTrac", "Downhill assist issue", "Hold assist issue", and a few more I can't recall. Sometimes they go away on its own and the vehicle works fine, sometimes restarting the vehicle clears the issue. The issues will appear randomly, sometimes very soon after starting the car and driving, sometimes 100 miles later.
NHTSA ODI #11671480
50,000 miles · Jun 10, 2025
Power Train
The contact owns a 2023 Ford Maverick. The contact stated while driving at various speeds and attempting to depress the brake pedal, the brakes made a loud screeching sound and the vehicle surged forward before coming to a complete stop. There was no warning light illuminated. The vehicle was taken to a local dealer where the ve…
Read full complaint
The contact owns a 2023 Ford Maverick. The contact stated while driving at various speeds and attempting to depress the brake pedal, the brakes made a loud screeching sound and the vehicle surged forward before coming to a complete stop. There was no warning light illuminated. The vehicle was taken to a local dealer where the vehicle was diagnosed, and the contact was advised that the passenger’s side axle was faulty and needed to be replaced. The vehicle was repaired, however the failure persisted. The manufacturer was notified of the failure. The approximate failure mileage was 50,000.
NHTSA ODI #11666056
Mileage unknown · May 14, 2025
Power Train
I bought a pre-owned "Gold Certified" 2023 Ford Maverick from a Ford dealer. The vehicle had around 32,000 or so miles at purchase. Soon after purchase, discovered that while accelerating from around 50-60 mph, the front end of the vehicle started heavily shaking without warning. The vehicle was taken to the Ford dealer who info…
Read full complaint
I bought a pre-owned "Gold Certified" 2023 Ford Maverick from a Ford dealer. The vehicle had around 32,000 or so miles at purchase. Soon after purchase, discovered that while accelerating from around 50-60 mph, the front end of the vehicle started heavily shaking without warning. The vehicle was taken to the Ford dealer who informed us that both front axles needed to be replaced. They informed us that they have seen this issue with other Ford Mavericks. The repairs were covered under warranty, and nobody was injured. This is an unsettling, since I have seen on this website numerous complaints about this same issue. Yet there has not been a TSB or recall to my knowledge.
NHTSA ODI #11660997
Mileage unknown · Apr 3, 2025
Power TrainSuspension
Bad CV axles causing vibration while accelerating.
NHTSA ODI #11652687
Mileage unknown · Mar 5, 2025
Power TrainSuspension
I recently reported my Ford maverick for the failure of the front right CV joint/axle at 22k miles. Well when I picked it up from Ford. They notified me that the front left is also bad. And I'm at 23k miles. These are clearly an issue that's happening everywhere.
NHTSA ODI #11646623
Mileage unknown · Feb 27, 2025
Power TrainSuspension
The cv joint axles are failing. No axles on a new car or truck should EVER fail under 100k miles. Ford maverick axles are failing at under 50k miles. And mine failed at 22k miles. And Ford will only replace 1 at a time. Not only is this a manufacturer defect that can cause accidents or injury but Ford needs to yet again be held …
Read full complaint
The cv joint axles are failing. No axles on a new car or truck should EVER fail under 100k miles. Ford maverick axles are failing at under 50k miles. And mine failed at 22k miles. And Ford will only replace 1 at a time. Not only is this a manufacturer defect that can cause accidents or injury but Ford needs to yet again be held accountable. No one pays good money for a factory faulty vehicle.
NHTSA ODI #11645445
Mileage unknown · Jan 5, 2025
Power Train
23,450 miles today for an oil change. Both CV are bad. Drivers side is terrible with no parts eta. Passages is leaking grease and about to go as well per the tech. That is not the first I’ve heard of this but at 23,000 miles is insane. This could cause an accident if failing while turning.
NHTSA ODI #11634149
Mileage unknown · Jun 4, 2024
Power Train
Traveling 350 miles for work, my Maverick was at 2400 miles when both of my front cv boots were spewing grease all over the underside of the truck, stranding me away from home. The truck would shake violently when accelerating to the point I had to pull over. With all the destruction on the underside of the truck, the local deal…
Read full complaint
Traveling 350 miles for work, my Maverick was at 2400 miles when both of my front cv boots were spewing grease all over the underside of the truck, stranding me away from home. The truck would shake violently when accelerating to the point I had to pull over. With all the destruction on the underside of the truck, the local dealer (not preferred) informed me that “they didn’t know who or when” but a missing clamp on one side and a torn boot on the other and denied me from claiming my warranty at 2400 miles. There were no warning lights on the dash at any time.
NHTSA ODI #11592535
Official recalls
21May 27, 2026
Ford Motor Company (Ford) is recalling certain 2021-2026 Bronco Sport and 2022-2026 Maverick vehicles. The front lower control arm ball joints may have been incorrectly installed or incorrectly repaired at the vehicle assembly plant, allowing the control arm to disconnect from the front wheel knuckle.
Consequence & remedy
Consequence: A detached control arm can cause a loss of vehicle control, increasing the risk of a crash.
Remedy: Owners are advised not to drive their vehicles until the remedy is completed. Dealers will inspect and repair the front lower control arm ball joints as necessary, free of charge.Owner notification letters were mailed September 2, 2026. Owners may contact Ford customer service at 1-866-436-7332. Ford's number for this recall is 26S36. Vehicle Identification Numbers (VINs) involved in this recall became searchable on NHTSA.gov on May 29, 2026.
Feb 20, 2026
Ford Motor Company (Ford) is recalling certain 2021-2026 F-150, 2022-2026 F-250 SD, F-350 SD, F-450 SD, F-550 SD, Maverick, 2024-2026 Ranger, 2023-2026 F-600 SD, 2022-2027 Lincoln Navigator, Expedition, and 2026 E-Transit vehicles. When towing a trailer, the integrated trailer module (ITRM) may lose communication with the vehicle, possibly causing a loss of brake and turn signal lights, or a loss of brake function. As such, these vehicles fail to comply with the requirements of Federal Motor Vehicle Safety Standard number 108, " Lamps, Reflective Devices, and Associated Equipment."
Consequence & remedy
Consequence: Trailer lights or brakes that do not function can reduce the driver’s ability to control the trailer and decrease the trailers visibility to other road users, increasing the risk of a crash.
Remedy: The integrated trailer module software will be updated by a dealer, or through an over-the-air (OTA) update, free of charge. Owner notification letters were mailed March 25, 2026. Owners may contact Ford customer service at 1-866-436-7332. Ford's number for this recall is 26C10. Vehicle Identification Numbers (VINs) involved in this recall will be searchable on NHTSA.gov beginning March 17, 2026.
Additional source detail variants (2)
Exterior Lighting:tail Lights
Ford Motor Company (Ford) is recalling certain 2021-2026 F-150, 2022-2026 F-250 SD, F-350 SD, F-450 SD, F-550 SD, Maverick, 2024-2026 Ranger, 2023-2026 F-600 SD, 2022-2027 Lincoln Navigator, Expedition, and 2026 E-Transit vehicles. When towing a trailer, the integrated trailer module (ITRM) may lose communication with the vehicle, possibly causing a loss of brake and turn signal lights, or a loss of brake function. As such, these vehicles fail to comply with the requirements of Federal Motor Vehicle Safety Standard number 108, " Lamps, Reflective Devices, and Associated Equipment."
Consequence: Trailer lights or brakes that do not function can reduce the driver’s ability to control the trailer and decrease the trailers visibility to other road users, increasing the risk of a crash.
Remedy: The integrated trailer module software will be updated by a dealer, or through an over-the-air (OTA) update, free of charge. Owner notification letters were mailed March 25, 2026. Owners may contact Ford customer service at 1-866-436-7332. Ford's number for this recall is 26C10. Vehicle Identification Numbers (VINs) involved in this recall will be searchable on NHTSA.gov beginning March 17, 2026.
Electrical System: Integrated Trailer Brake Control
Ford Motor Company (Ford) is recalling certain 2021-2026 F-150, 2022-2026 F-250 SD, F-350 SD, F-450 SD, F-550 SD, Maverick, 2024-2026 Ranger, 2023-2026 F-600 SD, 2022-2027 Lincoln Navigator, Expedition, and 2026 E-Transit vehicles. When towing a trailer, the integrated trailer module (ITRM) may lose communication with the vehicle, possibly causing a loss of brake and turn signal lights, or a loss of brake function. As such, these vehicles fail to comply with the requirements of Federal Motor Vehicle Safety Standard number 108, " Lamps, Reflective Devices, and Associated Equipment."
Consequence: Trailer lights or brakes that do not function can reduce the driver’s ability to control the trailer and decrease the trailers visibility to other road users, increasing the risk of a crash.
Remedy: The integrated trailer module software will be updated by a dealer, or through an over-the-air (OTA) update, free of charge. Owner notification letters were mailed March 25, 2026. Owners may contact Ford customer service at 1-866-436-7332. Ford's number for this recall is 26C10. Vehicle Identification Numbers (VINs) involved in this recall will be searchable on NHTSA.gov beginning March 17, 2026.
Oct 10, 2025
Ford Motor Company (Ford) is recalling certain 2016-2019 Lincoln MKC, 2016-2023 Explorer, 2019-2020 Fusion, 2019-2024 Ranger, 2020-2022 Lincoln Corsair, Escape, 2021-2024 Bronco, Bronco Sport, and 2022-2024 Maverick vehicles. The engine block heater may crack and develop a coolant leak, causing it to short circuit when the block heater is plugged in.
Consequence & remedy
Consequence: An electrical short circuit can increase the risk of a fire.
Remedy: Owners are advised not to plug in their block heater until the vehicle is remedied. Dealers will replace the block heater, free of charge. Owners will also have a alternative option to replace engine block heater element with a threaded blanking plug, and remove the block heater electrical cord. Interim letters, notifying owners of the safety risk, were mailed December 3, 2025. Additional letters will be sent once the final remedy is available, anticipated September 2026. Owners may contact Ford customer service at 1-866-436-7332. Ford's number for this recall is 25SA4. Vehicle Identification Numbers (VINs) involved in this recall became searchable on NHTSA.gov on October 15, 2025.
Jun 27, 2025
Ford Motor Company (Ford) is recalling certain 2018-2022 Transit Connect, 2019-2020 MKZ, MKX, Edge, Continental, F-150, Nautilus, Fusion, 2019-2023 Ranger, Mustang, 2020-2021 EcoSport, Expedition, Navigator, 2020-2022 Escape, F-250 SD, Corsair, 2020-2023 Aviator, Transit, 2020-2024 Explorer, 2021-2024 Bronco Sport, and 2022-2024 Maverick vehicles. A software error may cause the rearview camera to display a blank image, or the image may remain on the display after the backing event has ended.
Consequence & remedy
Consequence: A rearview camera that displays a blank image can reduce the driver's view behind the vehicle. A rearview image that continues to be displayed after the vehicle is shifted out of reverse may distract the driver. Both of these situations can increase the risk of a crash.
Remedy: Dealers will update the rearview camera software, free of charge. Owner notification letters were mailed September 4, 2025. Owners may contact Ford customer service at 1-866-436-7332. Ford's number for this recall is 25S72.
May 23, 2025
Ford Motor Company (Ford) is recalling certain 2020-2023 Escape, 2021-2023 Corsair, and 2022-2023 Maverick vehicles equipped with 2.5L HEV or PHEV engines that were repaired incorrectly under recall 23V380. In the event of an engine failure, engine oil and fuel vapor may be released into the engine compartment and accumulate near ignition sources such as hot engine or exhaust components, possibly resulting in an engine compartment fire.
Consequence & remedy
Consequence: An engine compartment fire increases the risk of injury.
Remedy: Owners are advised to park and shut off the engine as quickly as possible if they hear unexpected engine noises, notice a reduction in vehicle power, or see smoke. Dealers will update the powertrain control module software, free of charge. Owner notification letters were mailed June 27, 2025. Owners may contact Ford customer service at 1-866-436-7332. Ford's number for this recall is 25S54.
Mar 14, 2025
Ford Motor Company (Ford) is recalling certain 2021-2024 Bronco Sport and 2022-2023 Maverick vehicles previously repaired incorrectly under recall number 24V-267. The body and power train control modules may fail to detect a change in the 12-volt battery state of charge.
Consequence & remedy
Consequence: An undetected low battery charge can result in a loss of electrical accessories such as hazard lights, or cause a loss of drive power, increasing the risk of a crash.
Remedy: Dealers will recalibrate the body control module and power train control module, free of charge. Owner notification letters were mailed April 23, 2025. Owners may contact Ford customer service at 1-866-436-7332. Ford's number for this recall is 25S26.
Additional source detail variants (2)
Power Train:automatic Transmission:control Module (tcm/pcm/tecm)
Ford Motor Company (Ford) is recalling certain 2021-2024 Bronco Sport and 2022-2023 Maverick vehicles previously repaired incorrectly under recall number 24V-267. The body and power train control modules may fail to detect a change in the 12-volt battery state of charge.
Consequence: An undetected low battery charge can result in a loss of electrical accessories such as hazard lights, or cause a loss of drive power, increasing the risk of a crash.
Remedy: Dealers will recalibrate the body control module and power train control module, free of charge. Owner notification letters were mailed April 23, 2025. Owners may contact Ford customer service at 1-866-436-7332. Ford's number for this recall is 25S26.
Electrical System:body Control Module/bcm
Ford Motor Company (Ford) is recalling certain 2021-2024 Bronco Sport and 2022-2023 Maverick vehicles previously repaired incorrectly under recall number 24V-267. The body and power train control modules may fail to detect a change in the 12-volt battery state of charge.
Consequence: An undetected low battery charge can result in a loss of electrical accessories such as hazard lights, or cause a loss of drive power, increasing the risk of a crash.
Remedy: Dealers will recalibrate the body control module and power train control module, free of charge. Owner notification letters were mailed April 23, 2025. Owners may contact Ford customer service at 1-866-436-7332. Ford's number for this recall is 25S26.
Feb 28, 2025
Ford Motor Company (Ford) is recalling certain 2022-2023 Maverick Hybrid vehicles previously repaired incorrectly under recall number 24V-140. The instrument panel cluster may not properly illuminate warning lights or gauges. As such, these vehicles fail to comply with the requirements of Federal Motor Vehicle Safety Standard numbers 101, "Control and Displays," and 102, "Transmission shift position sequence, starter interlock, and transmission braking effect" as well as FMVSS numbers 105, 108, and 208.
Consequence & remedy
Consequence: An instrument panel that does not illuminate critical safety information, such as the speedometer or warning lights, can increase the risk of a crash.
Remedy: Dealers will update the instrument panel cluster software, free of charge. Owner notification letters were mailed April 9, 2025. Owners may contact Ford customer service at 1-866-436-7332. Ford's number for this recall is 25C06.
Feb 28, 2025
Ford Motor Company (Ford) is recalling certain 2022-2024 Maverick, 2022 Escape, and 2021-2022 Lincoln Corsair vehicles previously repaired incorrectly under recall number 24V-330. The Hybrid Powertrain Control Module (HPCM) software may cause the vehicle to shift into neutral unexpectedly, causing a loss of drive power.
Consequence & remedy
Consequence: A loss of drive power increases the risk of a crash.
Remedy: Dealers will update the HPCM software, free of charge. Owner notification letters were mailed April 11, 2025. Owners may contact Ford customer service at 1-866-436-7332. Ford's number for this recall is 25S16.
Feb 14, 2025
Ford Motor Company (Ford) is recalling certain 2022-2024 Maverick vehicles previously repaired incorrectly under recall number 23V-848. In the event that one of the rear turn signals stops working, the vehicle will not adjust the turn signal flash rate frequency to warn the driver that a turn signal has failed. As such, these vehicles fail to comply with the requirements of Federal Motor Vehicle Safety Standard number 108, "Lamps, Reflective Devices, and Associated Equipment."
Consequence & remedy
Consequence: A nonfunctioning exterior turn signal cannot notify other drivers that the vehicle is turning, increasing the risk of a crash.
Remedy: Dealers will update the body control module software, free of charge. Owner notification letters were mailed March 27, 2025. Owners may contact Ford customer service at 866-436-7332. Ford's number for this recall is 25C04.
Additional source detail variants (2)
Electrical System:body Control Module:software
Ford Motor Company (Ford) is recalling certain 2022-2024 Maverick vehicles previously repaired incorrectly under recall number 23V-848. In the event that one of the rear turn signals stops working, the vehicle will not adjust the turn signal flash rate frequency to warn the driver that a turn signal has failed. As such, these vehicles fail to comply with the requirements of Federal Motor Vehicle Safety Standard number 108, "Lamps, Reflective Devices, and Associated Equipment."
Consequence: A nonfunctioning exterior turn signal cannot notify other drivers that the vehicle is turning, increasing the risk of a crash.
Remedy: Dealers will update the body control module software, free of charge. Owner notification letters were mailed March 27, 2025. Owners may contact Ford customer service at 866-436-7332. Ford's number for this recall is 25C04.
Exterior Lighting:turn Signal
Ford Motor Company (Ford) is recalling certain 2022-2024 Maverick vehicles previously repaired incorrectly under recall number 23V-848. In the event that one of the rear turn signals stops working, the vehicle will not adjust the turn signal flash rate frequency to warn the driver that a turn signal has failed. As such, these vehicles fail to comply with the requirements of Federal Motor Vehicle Safety Standard number 108, "Lamps, Reflective Devices, and Associated Equipment."
Consequence: A nonfunctioning exterior turn signal cannot notify other drivers that the vehicle is turning, increasing the risk of a crash.
Remedy: Dealers will update the body control module software, free of charge. Owner notification letters were mailed March 27, 2025. Owners may contact Ford customer service at 866-436-7332. Ford's number for this recall is 25C04.
Feb 14, 2025
Ford Motor Company (Ford) is recalling certain 2022-2024 Maverick vehicles previously repaired incorrectly under recall number 24V-293. The body control module (BCM) may inadvertently deactivate one or both rear tail lights.
Consequence & remedy
Consequence: Rear tail lights that fail to illuminate can reduce the vehicle's visibility to other drivers, increasing the risk of a crash.
Remedy: Dealers will update the body control module software, free of charge. Owner notification letters were mailed March 28, 2025. Owners may contact Ford customer service at 866-436-7332. Ford's number for this recall is 25S07.
Additional source detail variants (2)
Electrical System:body Control Module:software
Ford Motor Company (Ford) is recalling certain 2022-2024 Maverick vehicles previously repaired incorrectly under recall number 24V-293. The body control module (BCM) may inadvertently deactivate one or both rear tail lights.
Consequence: Rear tail lights that fail to illuminate can reduce the vehicle's visibility to other drivers, increasing the risk of a crash.
Remedy: Dealers will update the body control module software, free of charge. Owner notification letters were mailed March 28, 2025. Owners may contact Ford customer service at 866-436-7332. Ford's number for this recall is 25S07.
Exterior Lighting:tail Lights
Ford Motor Company (Ford) is recalling certain 2022-2024 Maverick vehicles previously repaired incorrectly under recall number 24V-293. The body control module (BCM) may inadvertently deactivate one or both rear tail lights.
Consequence: Rear tail lights that fail to illuminate can reduce the vehicle's visibility to other drivers, increasing the risk of a crash.
Remedy: Dealers will update the body control module software, free of charge. Owner notification letters were mailed March 28, 2025. Owners may contact Ford customer service at 866-436-7332. Ford's number for this recall is 25S07.
Jan 17, 2025
Ford Motor Company (Ford) is recalling certain 2021-2023 Bronco Sport and 2022-2023 Maverick vehicles. The 12-volt battery may experience degradation and suddenly fail.
Consequence & remedy
Consequence: Battery failure can result in a loss of electrical accessories, including the hazard lights, or cause a loss of drive power, increasing the risk of a crash.
Remedy: Dealers will inspect and if necessary, replace the 12-volt battery, free of charge. Owner notification letters were mailed May 2, 2025. Owners may contact Ford customer service at 1-866-436-7332. Ford's number for this recall is 25S02. Vehicles in this recall were previously repaired under 24V-267 and will need to have the new remedy completed.
Sep 13, 2024
Ford Motor Company (Ford) is recalling certain 2022-2024 Ford Maverick vehicles equipped with Connected Touch Radios (CTR). The rearview camera image may freeze when the vehicle is in reverse.
Consequence & remedy
Consequence: An inoperative rearview camera display can reduce the driver's rear visibility, increasing the risk of a crash.
Remedy: Dealers will update the Connected Touch Radio (CTR) software, free of charge. Owner notification letters were mailed on March 21, 2025. Owners may contact Ford customer service at 1-866-436-7332. Ford's number for this recall is 24S59.
Aug 9, 2024
Ford Motor Company (Ford) is recalling certain 2023-2024 Maverick, Ford Bronco Sport, and Mustang Mach-E vehicles. The front windshield wiper motor may become inoperative, causing the wipers to fail.
Consequence & remedy
Consequence: Inoperative windshield wipers can reduce visibility in certain conditions, increasing the risk of a crash.
Remedy: Dealers will inspect and replace the windshield wiper motor as necessary, free of charge. Owner notification letters were mailed on December 6, 2024. Owners may contact Ford customer service at 1-866-436-7332. Ford's number for this recall is 24S51.
May 10, 2024
Ford Motor Company (Ford) is recalling certain 2022-2024 Maverick, 2020-2022 Escape, and 2021-2022 Lincoln Corsair vehicles. The Hybrid Powertrain Control Module (HPCM) software may cause the vehicle to shift into neutral unexpectedly, causing a loss of drive power.
Consequence & remedy
Consequence: A loss of drive power increases the risk of a crash.
Remedy: Dealers will update the HPCM software, free of charge. Owner notification letters were mailed May 22, 2024. Owners may contact Ford customer service at 1-866-436-7332. Ford's number for this recall is 24S33.
Apr 26, 2024
Ford Motor Company (Ford) is recalling certain 2022-2024 Maverick vehicles. The Body Control Module (BCM) may inadvertently deactivate one or both rear tail lights.
Consequence & remedy
Consequence: Rear tail lights that fail to illuminate can reduce the vehicle's visibility to other drivers, increasing the risk of a crash.
Remedy: Dealers will update the BCM software, free of charge. Owner notification letters were mailed May 10, 2024. Owners may contact Ford customer service at 1-866-436-7332. Ford's number for this recall is 24S24.
Additional source detail variants (2)
Electrical System:body Control Module:software
Ford Motor Company (Ford) is recalling certain 2022-2024 Maverick vehicles. The Body Control Module (BCM) may inadvertently deactivate one or both rear tail lights.
Consequence: Rear tail lights that fail to illuminate can reduce the vehicle's visibility to other drivers, increasing the risk of a crash.
Remedy: Dealers will update the BCM software, free of charge. Owner notification letters were mailed May 10, 2024. Owners may contact Ford customer service at 1-866-436-7332. Ford's number for this recall is 24S24.
Exterior Lighting:tail Lights
Ford Motor Company (Ford) is recalling certain 2022-2024 Maverick vehicles. The Body Control Module (BCM) may inadvertently deactivate one or both rear tail lights.
Consequence: Rear tail lights that fail to illuminate can reduce the vehicle's visibility to other drivers, increasing the risk of a crash.
Remedy: Dealers will update the BCM software, free of charge. Owner notification letters were mailed May 10, 2024. Owners may contact Ford customer service at 1-866-436-7332. Ford's number for this recall is 24S24.
Apr 12, 2024
Ford Motor Company (Ford) is recalling certain 2021-2024 Bronco Sport and 2022-2023 Maverick vehicles. The body and power train control modules may fail to detect a change in the 12-volt battery state of charge.
Consequence & remedy
Consequence: An undetected low battery charge can result in a loss of electrical accessories such as hazard lights, or cause a loss of drive power, increasing the risk of a crash.
Remedy: Dealers will recalibrate the body control module and power train control module, free of charge. Owner notification letters were mailed on June 4, 2024. Owners may contact Ford customer service at 1-866-436-7332. Ford's number for this recall is 24S24.
Additional source detail variants (2)
Electrical System:body Control Module/bcm
Ford Motor Company (Ford) is recalling certain 2021-2024 Bronco Sport and 2022-2023 Maverick vehicles. The body and power train control modules may fail to detect a change in the 12-volt battery state of charge.
Consequence: An undetected low battery charge can result in a loss of electrical accessories such as hazard lights, or cause a loss of drive power, increasing the risk of a crash.
Remedy: Dealers will recalibrate the body control module and power train control module, free of charge. Owner notification letters were mailed on June 4, 2024. Owners may contact Ford customer service at 1-866-436-7332. Ford's number for this recall is 24S24.
Power Train:automatic Transmission:control Module (tcm/pcm/tecm)
Ford Motor Company (Ford) is recalling certain 2021-2024 Bronco Sport and 2022-2023 Maverick vehicles. The body and power train control modules may fail to detect a change in the 12-volt battery state of charge.
Consequence: An undetected low battery charge can result in a loss of electrical accessories such as hazard lights, or cause a loss of drive power, increasing the risk of a crash.
Remedy: Dealers will recalibrate the body control module and power train control module, free of charge. Owner notification letters were mailed on June 4, 2024. Owners may contact Ford customer service at 1-866-436-7332. Ford's number for this recall is 24S24.
Mar 22, 2024
Ford Motor Company (Ford) is recalling certain 2023 Maverick and Bronco Sport vehicles. The tires may have been manufactured incorrectly, which may result in a loss of vehicle handling and control.
Consequence & remedy
Consequence: A loss of vehicle handling and control increases the risk of a crash.
Remedy: Dealers will inspect and replace the tires, as necessary, free of charge. Owner notification letters were mailed April 5, 2024. Owners may contact Ford customer service at 1-866-436-7332. Ford's number for this recall is 24S20.
Feb 23, 2024
Ford Motor Company (Ford) is recalling certain 2022-2023 Maverick Hybrid vehicles. The Instrument Panel Cluster may not properly illuminate warning lights or gauges. As such, these vehicles fail to comply with the requirements of Federal Motor Vehicle Safety Standard numbers 101, "Control and Displays," and 102, "Transmission shift position sequence, starter interlock, and transmission braking effect" as well as FMVSS numbers 105, 108, and 208.
Consequence & remedy
Consequence: An instrument panel that does not illuminate critical safety information, such as the speedometer or warning lights, can increase the risk of a crash.
Remedy: Dealers will update the instrument panel cluster software, free of charge. Owner notification letters were mailed March 26, 2024. Owners may contact Ford customer service at 1-866-436-7332. Ford's number for this recall is 24C01.
Dec 15, 2023
Ford Motor Company (Ford) is recalling certain 2022-2024 Maverick vehicles. In the event that one of the rear turn signals stops working, the vehicle will not adjust the turn signal flash rate frequency to warn the driver that a turn signal is not working correctly. As such, these vehicles fail to comply with the requirements of Federal Motor Vehicle Safety Standard number 108, "Lamps, Reflective Devices, and Associated Equipment."
Consequence & remedy
Consequence: A nonfunctioning exterior turn signal will not notify other drivers that the vehicle is turning, increasing the risk of a crash.
Remedy: Dealers will update the body control module software, free of charge. Owner notification letters were mailed January 16, 2024. Owners may contact Ford customer service at 1-866-436-7332. Ford's number for this recall is 23C41.
Additional source detail variants (2)
Exterior Lighting:turn Signal:bulbs
Ford Motor Company (Ford) is recalling certain 2022-2024 Maverick vehicles. In the event that one of the rear turn signals stops working, the vehicle will not adjust the turn signal flash rate frequency to warn the driver that a turn signal is not working correctly. As such, these vehicles fail to comply with the requirements of Federal Motor Vehicle Safety Standard number 108, "Lamps, Reflective Devices, and Associated Equipment."
Consequence: A nonfunctioning exterior turn signal will not notify other drivers that the vehicle is turning, increasing the risk of a crash.
Remedy: Dealers will update the body control module software, free of charge. Owner notification letters were mailed January 16, 2024. Owners may contact Ford customer service at 1-866-436-7332. Ford's number for this recall is 23C41.
Electrical System:body Control Module:software
Ford Motor Company (Ford) is recalling certain 2022-2024 Maverick vehicles. In the event that one of the rear turn signals stops working, the vehicle will not adjust the turn signal flash rate frequency to warn the driver that a turn signal is not working correctly. As such, these vehicles fail to comply with the requirements of Federal Motor Vehicle Safety Standard number 108, "Lamps, Reflective Devices, and Associated Equipment."
Consequence: A nonfunctioning exterior turn signal will not notify other drivers that the vehicle is turning, increasing the risk of a crash.
Remedy: Dealers will update the body control module software, free of charge. Owner notification letters were mailed January 16, 2024. Owners may contact Ford customer service at 1-866-436-7332. Ford's number for this recall is 23C41.
May 26, 2023
Ford Motor Company (Ford) is recalling certain 2020-2023 Escape, 2022-2023 Maverick, and 2021-2023 Corsair vehicles equipped with 2.5L HEV or PHEV engines. In the event of an engine failure, engine oil and fuel vapor may be released into the engine compartment and accumulate near ignition sources such as hot engine or exhaust components, possibly resulting in an engine compartment fire.
Consequence & remedy
Consequence: An engine compartment fire increases the risk of injury.
Remedy: Owners are advised to park and shut off the engine as quickly as possible if they hear unexpected engine noises, notice a reduction in vehicle power, or see smoke. Dealers will replace the engine long-block in 2023 Escape and Corsair vehicles. For the other vehicles, dealers will update the powertrain control module software. If a connecting rod bearing failure is detected, dealers will replace the engine long-block. All inspections and repairs will be performed free of charge. Owner notification letters were mailed on June 14, 2024. Owners may contact Ford customer service at 1-866-436-7332. Ford's number for this recall is 23S27. This recall expands and replaces recall number 22V-484. Vehicles previously repaired under 22V-484 will need to have the new remedy completed.
Mar 10, 2023
Ford Motor Company (Ford) is recalling certain 2023 Maverick vehicles. A missing electrical circuit may cause the trailer taillights to not illuminate as intended when utilizing the vehicle trailer tow electrical connector. As such, these vehicles fail to comply with the requirements of Federal Motor Vehicle Safety Standard number 108, " Lamps, Reflective Devices, and Associated Equipment."
Consequence & remedy
Consequence: Trailer taillights that do not illuminate as intended can increase the risk of a crash.
Remedy: Dealers will add an electrical circuit to the engine bay wiring harness, free of charge. Owner notification letters were mailed June 9, 2023. Owners may contact Ford customer service at 1-866-436-7332. Ford's number for this recall is 23C04.
Model-level recall history does not show whether a particular VIN is affected or has received a repair. Check a VIN with NHTSA ↗
Illustration