2020 Ford Fusion

The contact owns a 2020 Ford Fusion. The contact stated while starting the vehicle, the vehicle made an abnormal rattling sound. The contact stated that the failure had been recurring. The vehicle was taken to an independent mechanic, where it was diagnosed that there was a rattling sound coming from the transmission bell housing area, and the flex plate was cracked. The vehicle was not repaired. The manufacturer was notified of the failure and informed the contact that the failure was related to Ford Campaign Number: 22N12. The manufacturer assisted the contact in scheduling an appointment with the dealer for diagnostic testing. The manufacturer also referred the contact to the NHTSA Hotline for assistance. The vehicle was not repaired. The failure mileage was approximately 95,755.

The contact owns a 2020 Ford Fusion. The contact stated that while driving at an undisclosed speed, the vehicle failed to accelerate as intended. The contact stated that the vehicle was shaking, and the vehicle lost motive power. In addition, the contact heard an abnormal rattling sound, and the transmission was slipping. The vehicle was taken to the dealer and the contact was advised to flush the transmission fluid. The contact stated that after flushing the transmission fluid, the failure ceased but later returned. The vehicle was not diagnosed or repaired by an independent mechanic or the dealer. The contact stated that after researching the failure, the contact discovered TSB: 22N12. The contact informed the dealer of TSB: 22N12 and the contact was informed that the repair was not eligible to be covered under TSB: 22N12. The vehicle was not diagnosed or repaired by an independent mechanic or the dealer. The manufacturer was made aware of the failure but did not assist. The failure mileage was approximately 45,000.

The flexplate was cracking and rusted which caused starting and acceleration problems. Yes, it's available per request. It's currently with the transmission shop that fixed my vehicle. There was a rattling noise found in neutral and park by the transmission shop I took it to. My safety was put at risk because my ability to control my car's power was affected. I was at risk of a loss of power to the wheels which could have caused a major accident, especially because most of my driving happens on the interstate at speeds of 65-7 mph. The issue has been confirmed by an independent service center. Yes, they inspected by the techs at the transmission shop. There were no warning lamps or messages before the failure. The symptoms were a rattling noise and reduced power. This issue is well documented online and is known to happen in the 60-90k mile range which I can confirm based on my personal experience and others. References: [XXX] [XXX] [XXX] [XXX] [XXX] INFORMATION REDACTED PURSUANT TO THE FREEDOM OF INFORMATION ACT (FOIA), 5 U.S.C. 552(B)(6)

The contact owns a 2020 Ford Fusion. The contact stated that on several occasions while driving at various speeds, the gear was shifted, and the vehicle reverted to park. The vehicle was restarted approximately five to ten times on all but one occasion, and the vehicle failed to start. The vehicle was towed to a dealer where it was diagnosed that the shifter cable bushing needed to be replaced. The vehicle was repaired. The manufacturer was notified of the failure. The failure mileage was approximately 93,200.

The contact owns a 2020 Ford Fusion. The contact stated while driving approximately 60 MPH, the vehicle changed lanes independently. The vehicle was steered to the side of the road. The vehicle was taken to a dealer where it was diagnosed that the steering control module was informing the steering wheel to turn to the left while the vehicle was to the right and vice-versa. The contact was informed that the steering control module needed to be replaced. The vehicle was not repaired. The manufacturer was notified of the failure. The failure mileage was approximately 66,620.

On hot days the Forward Collision will show as unavailable, but there is no notification saying when it will be available again. This is dangerous in that a safety feature on the vehicle is unavailable when it is hot outside and has been sitting in the sun. Outer door panel skins are becoming unattached from the door frame, which could cause an issue if the skin fails elsewhere that it would be totally unattached to the door frame and fall off when driving. The rear package tray trim (carpeted trim piece behind the rear seats covering the speakers) disintegrates when it is touched due to it being exposed to the sun. Discovered when attempting to clean inside of my rear window. This has caused black particulate to be scattered throughout the vehicles interior. They are small enough that you could be breathing them in as the debris has been found all over the dashboard, seats, infotainment console, and trim all around the car. This is a health hazard due to breathing in fabric/carpet particulate that can irritate the lungs. Link to forum of other people having the same issue: https://www.fordfusionforum.com/index.php?app=forums&module=forums&controller=topic&id=20981#comments