2020 Ford Fusion

The contact owns a 2020 Ford Fusion. The contact stated while driving at an undisclosed speed, the front passenger's side low beam headlight failed to illuminate as needed. Upon inspecting the vehicle, the contact noticed that the front passenger's side low beam headlight assembly wiring harness was burnt, and there was light smoke coming from the wiring harness. The vehicle was taken to the local dealer, where it was diagnosed that the low beam headlight assembly needed to be replaced. The vehicle was not repaired. The manufacturer was notified of the failure, but no assistance was provided. The failure mileage was 53,000.

There was a recall on 2020 Ford Fusions in 2022 on flex plate. My car miles at 90,000 and I started to hear the ticking noise. I did my research and I seen that it has the same noise that my car is making now. I called the dealership and the dealership said that I had no active recalls on my car and that the recall was specific to certain cars. Even though my car wasn’t apart of the specific VIN. I had a mechanic check it out and it was the flex plate. I’m still having issues with my flex plate but they want me to come out of pocket , I never had a engine light or anything come on I just started hearing this loud noise and it progressively has gotten worse.

On Saturday, October 5th, 2024, at around 5AM I was sitting in the Starbucks parking lot outside of the Detroit Metro (DTW) airport when this issue began. I had just started my car and could feel it was sluggish and was making a significant amount of noise, which was present in park and neutral, but not so much while in gear, unless I was stopped at a stop sign or stationary. After getting home, and each day after when I started the vehicle to go to work, I could hear that the noise was progressively getting worse. So, I determined that it was not a fluke and took my car into a Ford dealership to have the oil changed and a full inspection done. They explained to me that the water pump had failed and was leaking, very slowly, but externally through the "weep hole". They were going to charge me $1,300 to repair. So, I called a local shop that I know is reputable and they confirmed the water pump leak but determined that the noise I was hearing was not the water pump, but actually a cracked flexplate. The noise originated near the starter, and the shop ran a camera through the inspection hole confirming this. After I found that the flexplate was cracked, I did not continue to drive it, but scheduled a repair to begin on Thursday, October 24th at the reputable shop I mentioned above. To complete the repair, they needed to drop the cradle, remove the transmission and support the engine. This in total cost me $1,729.60. The flexplate has not been inspected by the mfg., police, insurance, etc., as there was no need. I did not have an extended warranty and though my car is only 4 years old, it was beyond the warranty in miles. No lights appeared on the dash, and there were no error codes present. The flexplate cracking could have resulted in catastrophic failure of the engine or transmission, and I could have very well lost control of my vehicle. If I was driving on the highway during a failure, my safety as well as others would have been put in serious danger.

The contact owns a 2020 Ford Fusion. The contact stated that the hood latch was no longer functioning and the hood was not able to be raised. The contact stated that he had taken the vehicle to an independent mechanic who was unable to repair the failure. The manufacturer was informed of the failure and referred to the NHTSA Hotline. The failure mileage was approximately 103,000.

The contact owns a 2020 Ford Fusion. The contact stated while driving 30 MPH, the vehicle hesitated and stalled while depressing the accelerator pedal. The check engine warning light was illuminated. The dealer was contacted and notified of the failure. The vehicle was diagnosed with an internal engine failure. The vehicle was not repaired. The manufacturer was notified of the failure. The approximate failure mileage was 65,000.

The contact owns a 2020 Ford Fusion. The contact stated while attempting to start the vehicle, smoke and an abnormal odor was coming from the rear of the vehicle. The check engine warning light was illuminated. The vehicle was driven to the dealer. The dealer determined that the failure was caused by a purge control valve failure. The vehicle was not repaired. The manufacturer was notified of the failure. The approximate failure mileage was 40,000.

On [XXX] I backed my 2020 Ford Fusion out of my driveway. I stopped and tried to shift from reverse to drive and the transmission locked up in Park, the engine died and the parking brake was engaged. I was sitting across the street with no way to move the car. I had the car towed to a Ford dealer and they replaced the transmission cable bushing and cover. These parts are the same as those used in Fords recall 22S43. Ford continued to use inferior parts on cars built after the dates mentioned in the recall. This is a safety issue as it could happen at any time. Thanks [XXX] [XXX] INFORMATION REDACTED PURSUANT TO THE FREEDOM OF INFORMATION ACT (FOIA), 5 U.S.C. 552(B)(6)

My flex plate cracked on my 2020 Ford Fusion. Ford has a customer satisfaction program stating that they have a one time repair for cracked flex plates, torque converter, and transmission pump and are refusing to honor it. Once the dealership confirmed my flex plate was cracked they were notified that the repairs were not going to be approved I was giving a quote for $4700 to pay out of pocket. I did not have the money and went to pick my car up until I figured out a solution. While in the process of waiting to figure out my next step of action I was informed by one of the service writers that they were going to approve my repairs by this time my vehicle had completely stopped on me while on the highway with my child in the car. Once it was towed to the dealership my car sat for 2 weeks untouched because of other repairs and I was later informed that Ford is wanting to overturn their decision and not repair my car.