← New search

2020 Ford Fusion

Owner reports · Recalls · Investigations

Fewer warning signs than most model years

Owner complaints for the 2020 Ford Fusion are lower than the model-year median of 1,109.

About this comparison →

When problems were reported

Mileage at the reported incident

56 reports with mileage · 122 unknown

NHTSA’s mileage field refers to the reported incident, not necessarily the filing date. This shows report counts, not the likelihood of a failure.

What to inspect

Issues worth paying extra attention to based on owner reports.

  • Power Train. Review the 66 owner reports in this category and discuss these concerns during a pre-purchase inspection. Read reports →
  • Engine. Review the 49 owner reports in this category and discuss these concerns during a pre-purchase inspection. Read reports →
  • Electrical System. Review the 37 owner reports in this category and discuss these concerns during a pre-purchase inspection. Read reports →

NHTSA owner reports · September 18, 2026 snapshot.

10 crash reports3 fire reports5 injury reports

Lane Departure complaints

3 reports
Clear category filter
Mileage unknown · May 29, 2026
Lane DeparturePower TrainSteering

I’ve learned a while ago that the vehicle doesn’t have a working horn, I’ve replaced the fuse at least five times and it’s still not working. Yes the car was sold to me this way. Also I’ve been getting this warning to my ford app: “The Blind Spot Information System (BLIS)/Cross Traffic Alert (CTA) has detected a fault and may n…

Read full complaint

I’ve learned a while ago that the vehicle doesn’t have a working horn, I’ve replaced the fuse at least five times and it’s still not working. Yes the car was sold to me this way. Also I’ve been getting this warning to my ford app: “The Blind Spot Information System (BLIS)/Cross Traffic Alert (CTA) has detected a fault and may not function. What Should I Do? If either BLIND SPOT NOT AVAILABLE/SENSOR BLOCKED SEE MANUAL or CROSS TRAFFIC NOT AVAILABLE/SENSOR BLOCKED SEE MANUAL is in the information display, the system may not function. Check the exterior vehicle sensors for damage or debris covering them (see Owner's Manual for sensor locations). If the problem persists, please have the system checked by an authorized dealer.” For the last month my car has become hard to drive as if there’s a power steering issue.

NHTSA ODI #11740965

Mileage unknown · Jul 24, 2025
Electrical SystemLane DepartureSteering

RANDOMLY 'SERVICE ADVANCE TRAC', 'PRE-COLLISION ASSIST NOT AVAILABLE', LANE ASSIST NOT AVAILABLE', POWER ASSIST STEERING NOT AVAILABLE', HILL ASSIST NOT AVAILABLE', WARNING LIGHTS APPEAR. WHEN THEY DO I COMPLETELY LOSE POWER STEERING. WHICH IS EXTREMELY DANGEROUS WHILE DRIVING. MOST THE TIME I CAN TURN OFF AND RESTART THE CAR AN…

Read full complaint

RANDOMLY 'SERVICE ADVANCE TRAC', 'PRE-COLLISION ASSIST NOT AVAILABLE', LANE ASSIST NOT AVAILABLE', POWER ASSIST STEERING NOT AVAILABLE', HILL ASSIST NOT AVAILABLE', WARNING LIGHTS APPEAR. WHEN THEY DO I COMPLETELY LOSE POWER STEERING. WHICH IS EXTREMELY DANGEROUS WHILE DRIVING. MOST THE TIME I CAN TURN OFF AND RESTART THE CAR AND IT GOES AWAY. HOWEVER, NOW IT HAS BECOME MORE FREQUENT AND HAS STARTED LOSING COMPLETE POWER OF THE CAR TURNING OFF WHILE DRIVING. I ALMOST DIED ON THE INTERSTATE. FORD DEALERSHIPS ONLY RECOMMENDATION WAS A NEW CIRCUIT BOARD THAT WAS LIKE $5K, MORE THAN THE CAR IS WORTH. THEY SAID IT WAS SOMETHING COMMON WITH THE FORD FUSIONS, THATS WHY THEY WERE QUIT BEING MADE. I RESEARCHED AND IT IS A COMMON ISSUE, BUT NO RECALLS HAVE BEEN MADE???!!???

NHTSA ODI #11675920

Mileage unknown · Sep 20, 2022
EngineLane DepartureWheels

Constantly with this specific vehicle, especially with the lane assist. The vehicle continuously jerks either left or right even within the green parameters of the lane, especially when doing a slight turn on the highway. When it is raining the vehicle smart as go offline an cannot read the lane or the vehicle in front of it. …

Read full complaint

Constantly with this specific vehicle, especially with the lane assist. The vehicle continuously jerks either left or right even within the green parameters of the lane, especially when doing a slight turn on the highway. When it is raining the vehicle smart as go offline an cannot read the lane or the vehicle in front of it. When I first purchased the vehicle after driving for less than a year I had to take the vehicle in because the engine was warped. Constantly when I’m the vehicle the Apple car play system would either freeze or the screen would go black.

NHTSA ODI #11485409

Official recalls

3

25V685000 · Equipment:electrical:engine Block Heater

Oct 10, 2025

Ford Motor Company (Ford) is recalling certain 2016-2019 Lincoln MKC, 2016-2023 Explorer, 2019-2020 Fusion, 2019-2024 Ranger, 2020-2022 Lincoln Corsair, Escape, 2021-2024 Bronco, Bronco Sport, and 2022-2024 Maverick vehicles. The engine block heater may crack and develop a coolant leak, causing it to short circuit when the block heater is plugged in.

Consequence & remedy

Consequence: An electrical short circuit can increase the risk of a fire.

Remedy: Owners are advised not to plug in their block heater until the vehicle is remedied. Dealers will replace the block heater, free of charge. Owners will also have a alternative option to replace engine block heater element with a threaded blanking plug, and remove the block heater electrical cord. Interim letters, notifying owners of the safety risk, were mailed December 3, 2025. Additional letters will be sent once the final remedy is available, anticipated September 2026. Owners may contact Ford customer service at 1-866-436-7332. Ford's number for this recall is 25SA4. Vehicle Identification Numbers (VINs) involved in this recall became searchable on NHTSA.gov on October 15, 2025.

25V442000 · Back Over Prevention:software

Jun 27, 2025

Ford Motor Company (Ford) is recalling certain 2018-2022 Transit Connect, 2019-2020 MKZ, MKX, Edge, Continental, F-150, Nautilus, Fusion, 2019-2023 Ranger, Mustang, 2020-2021 EcoSport, Expedition, Navigator, 2020-2022 Escape, F-250 SD, Corsair, 2020-2023 Aviator, Transit, 2020-2024 Explorer, 2021-2024 Bronco Sport, and 2022-2024 Maverick vehicles. A software error may cause the rearview camera to display a blank image, or the image may remain on the display after the backing event has ended.

Consequence & remedy

Consequence: A rearview camera that displays a blank image can reduce the driver's view behind the vehicle. A rearview image that continues to be displayed after the vehicle is shifted out of reverse may distract the driver. Both of these situations can increase the risk of a crash.

Remedy: Dealers will update the rearview camera software, free of charge. Owner notification letters were mailed September 4, 2025. Owners may contact Ford customer service at 1-866-436-7332. Ford's number for this recall is 25S72.

23V440000 · Electrical System:propulsion System:traction Battery:management System/energy Control Module (bms/becm)

Jun 23, 2023

Ford Motor Company (Ford) is recalling certain 2019-2020 Fusion PHEV vehicles. The battery energy control module (BECM) may become damaged due to excessive voltage and current flow.

Consequence & remedy

Consequence: A damaged BECM can result in a loss of drive power or fire, increasing the risk of a crash.

Remedy: Owners are advised not to charge their vehicles until the remedy is completed. Dealers will replace the battery and update the BECM software for free, or Ford will repurchase the vehicle. If your vehicle is currently operating normally, Ford has authorized dealers to replace the fuse block and a software update as an interim repair before the availability of remedy parts for the final repair. This repair will be free of charge (parts and labor). As an alternative remedy, Ford is offering a vehicle refund. Please see Ford's owner notification letter or contact Ford for full details. Owner notification letters were mailed May 15, 2025. Owners may contact Ford customer service at 1-866-436-7332. Ford's number for this recall is 23S33.

Model-level recall history does not show whether a particular VIN is affected or has received a repair. Check a VIN with NHTSA ↗

NHTSA investigations

0

No exact-year investigations in this snapshot.