2019 Ford Fusion

My daughters’s 2019 ford fusion/4dr sdn/sel/fwd began to run hot and my son checked and notice low on coolant. He filled back up and vehicle ran with no problems. A day or so later noticed again and my husband checked again and realized again and low again and checked all and no apparant leak in lines or hoses but short drive again to check it began to overheat and check engine light came on and he read up and becoming aware of issue with this coolant leak into cylinder. He took to Sullivan Ford dealership and confirmed pressure test of coolant in cylinder # 1 and had to replace engine assembly. No offer by Ford to assist. Total cost 10,115.66 For know issue per faulty engine design that was risk for fire and safety issue.

Known issue with flex plate: rattle noise that gets progressively worse over time and especially when in colder weather, the cold start & when idling causes the rattle noise to be worse, over the past two years the rattle noise is still there but now with some vibration as well. In 2023, took in to ford dealership & told rattle noise was normal & not significant enough to replace (mentioned the Ford CSP notice of the issue), progressively over the last two years rattling has been getting worse (especially when idling), took it to different ford dealer and they confirmed it has been the flex plate (but now is outside of the CSP coverage). No engine warning lights were on, which is more concerning as the rattling and vibrations worsen over time. Was told that if not fixed the whole car could stop & break down, which poses a safety risk. Multiple other customer complaints about safety issues and concerns with this known issue of flex plates cracking that ford is not taking responsibility for as the CSP doesn’t cover vehicles over 10yrs old or over 100,000 miles— leaving drivers with unsafe vehicles with crack flex plates.

The rear view camera operates intermittently. Sometimes it works fine, other times the picture is blank or is extremely blurry with horizontal lines through it or the screen just displays snow. Sometimes it works, other times it doesn't. it can work in the morning, but not when I leave to go home after work. It can works for days, then not work for days. I called Ford due to an article that came across my news feed about rear camera recalls, but Ford said I'm not covered. This has been going on for several months now. A dealer wanted to charge several hundred dollars to check it out, but I didn't want to pay. To me this should be covered under warranty.

10/2024 We noticed coolant was low. filled and kept watch. around 95,000 miles 6/2025 Just hit over 100,000 miles. engine misfire cylinder 3. brought it in, coolant was low, filled and replaced spark plug. 8/2025 engine misfire cylinder 3. brought it back in completed cleaning kit 8/2025 engine misfire cylinder 3. brought back in (2 weeks later). checked further and recommended a valve replace, and we needed to take it to a Ford dealership to replace 10/2025 brought into Ford dealership, coolant leaking into engine, need new engine. Ford will not cover. This is a safety issues as engine could cause fire, if coolant runs to low.

I am reporting a serious safety defect involving the transmission system of my Ford Fusion, specifically related to the valve body and torque converter. The malfunction of these components causes sudden, unpredictable surges or lunges in acceleration, even when the vehicle is being driven at steady speeds or when lightly applying the accelerator. The issue appears to stem from improper pressure regulation or fluid flow within the transmission valve body, which causes erratic shifting and delayed engagement. When this malfunction occurs, the torque converter can fail to properly manage torque transfer, resulting in sudden and forceful forward motion of the vehicle. While driving on a highway at approximately 65 mph, my vehicle suddenly lurched forward aggressively, as if it had downshifted or received a surge of power without any change in throttle input. This caused the car to rapidly accelerate momentarily, nearly causing me to lose control. The unexpected forward thrust startled me and forced me to take immediate corrective action to maintain my lane and prevent a collision with a nearby vehicle. In another instance, while slowing down to a stop, the car lunged forward again instead of decelerating smoothly, nearly causing me to roll into an intersection. This created a dangerous situation for myself, my passengers, and surrounding traffic. This defect creates a significant risk of collision due to the vehicle’s unpredictable acceleration behavior. The driver cannot reliably control speed or anticipate when the car may suddenly surge forward. The issue compromises both vehicle stability and driver reaction time, particularly at higher speeds or in traffic. If this problem were to occur in a congested area, at a stoplight, or near pedestrians, it could result in a serious crash, injury, or fatality. The failure of the valve body and torque converter in the Ford Fusion represents a critical mechanical defect that directly impacts safe operation of the vehicle.

Drove home from work 10/7/25 no issues. Parked the car no issues. Son went to leave and the car just stopped functioning. OEM issues I believe is what my son stated with the computer system. Brake is down and won’t release. Won’t start, sounds like it is even when we aren’t touching anything. Asking for goodwill / Good faith extension on the recall for this vehicle

The contact owns a 2019 Ford Fusion. The contact received notification of NHTSA Campaign Number: 23V440000 (Electrical System); however, the part to do the recall repair was not yet available. The vehicle was taken to the dealer but was not diagnosed or repaired. The dealer confirmed that parts were not yet available, and the recall was put on hold. The contact stated that the manufacturer had exceeded a reasonable amount of time for the recall repair. The manufacturer was made aware of the issue and referred the contact to the dealer for further assistance. The contact had not experienced a failure.

According to Auto Zone, after being placed on scanner, the power train system (P0456) has a evaporative emissions system leak (very small leak) diagnosed at 76,919miles. Ford dealership says they cannot find a problem. When I put gas in the car I have to sit and wait at least 10 minutes before my car will start again. It takes a couple of tries and much hesitation, but it will start. Once you get started it has difficulty accelerating or may slow down on its own. Again, Ford dealership reports they can't seem to find a problem. When I told them the problem, they came up with a price to charge me to fix something they could not find. Ridiculous!! My ford app clearly states check engine problem detected, but nooooo they cannot find anything wrong. Two different dealerships. Thank God I keep my paperwork because others are complaining of the same thing. They have to put the pen to the paper or we will never get a recall.