2018 Ford Fusion

I purchase this car on XXX Clinton Ford Dealership and engine need replacement Jan 2020 . I at that time did many replacement until the final diagnostic said engine replacement confirm by dealership Ford Dealership Fayetteville NC . The purge valve canister went out in 2022 and was replaced by Ed’sTire in Hope Mills Rd 11/19–11/22/2022 and now mechanic said it is in need of replacement again . Car problems started 2026 Feb and three pieces were replaced because the system was reading those code now to find out the purge valve canister needs replacement again. These hardship have cost me financial difficulties that a new car should never have had within 2 years . I believe no consumer should have to go through this.

Formal Complaint – 2018 Ford Fusion 1.5L EcoBoost – Engine Block Defect Statement of Issue:I am writing to report a premature engine failure on my 2018 Ford Fusion 1.5L. The vehicle is exhibiting all symptoms of the well-documented "coolant intrusion" defect described in Ford Technical Service Bulletin (TSB) 22-2222. Despite following all recommended maintenance intervals, the engine block has failed, allowing coolant to enter the combustion chamber.Observations:Confirmed coolant loss with no external leakage found via pressure test.Significant white smoke and rough idle upon cold start. Desired Resolution: Since this is a known manufacturing defect involving the engine block's cooling channels—and not a result of wear and tear—I am requesting a "Goodwill Repair" for a long-block replacement. The current TSB denial based on [8 years] is unacceptable for a known catastrophic design flaw that compromises vehicle safety.

- There is a crack in the engine block; coolant is leaking into cylinder 3. I am having the car taken by carvana on 3/30 and it will no longer be available for inspection, but I have record of the mechanical issues from taking the vehicle into the dealership on 3/18. - My/others safety was not immediately at risk, but I know that my engine could have blown while driving, causing an accident or even an engine fire. - As stated, issue was confirmed by dealer, and I have records of this - N/A - Check engine light appeared on approximately 3/5; was unable to have car inspected right away and continued driving. Started to get intermittent errors stating that the engine was overheating/coolant was low on 3/12. Stopped driving car more than 2 miles at a time after this. Boyfriend correctly diagnosed issue on 3/15 and I had the issue confirmed by dealer on 3/18.

2018 Ford Fusion SE 1.5L EcoBoost, just purchased the car 10 days ago and I already have antifreeze that's mixing with the oil causing the car to overheat and white smoke coming from the back cannot drive the car took it to three mechanics they told me it needs a new turbo and a head gasket which will cost well over $4,000 which I don't have the money that I bought the car with I borrowed from family members so I can go back to work and I don't have money to fix it so at the moment I am unemployed because I have no vehicle to get to work this is a major problem. My father before he passed away had a 2017 Ford Escape with the same engine and he had the same problem he sold it for $1500 lost 14 Grand on it

I would like to respectfully request that my 2018 Ford Fusion, with the 1.5L EcoBoost engine, be considered for inclusion in the customer satisfaction programs related to the engine issues I'm experiencing. Despite my vehicle not being initially listed, the problems I've encountered, including the diagnostic trouble code P0302 and the coolant leak into cylinder #2, suggest that it may be suffering from a similar defect or design flaw that the program aims to address. Given the safety risks associated with the current condition of my vehicle, I believe it would be fair and reasonable to include it in the program and provide the necessary repairs or replacements to ensure the vehicle is safe to operate. I would appreciate your assistance in facilitating this process and exploring options for resolving this issue in a manner consistent with the treatment of similar vehicles.

At approximately 67,180 miles, a Ford dealership performed a multi-point inspection on my 2018 Ford Fusion SE with the 1.5L EcoBoost engine due to a check engine light on. The Ford dealership diagnosed the vehicle with a coolant intrusion into cylinder 2. The Ford dealership recommended the replacement of the short block and gasket kit, with an estimated repair cost of $7,465. This type of issue diagnosed for my vehicle is a known failure issue for 1.5L Ford EcoBoost engines documented in Customer Satisfaction Program 21N12, which covers coolant intrusion and engine damage in this engine type. Despite the Ford dealership diagnosis of my vehicle matching what is described in Customer Satisfaction Program 21N12, I was informed that my vehicle is not eligible. The Coolant intrusion into cylinder 2 is an issue that poses a safety risk due to engine misfires, stalling, overheating, and possible sudden loss of engine power while driving. In my case, my vehicle has become unreliable and unsafe for regular driving. A Ford dealership inspected the vehicle, confirmed and documented the issue, and the repair quote, diagnostic report and diagnostic payment receipt are available upon request. Ford has declined assistance despite the vehicle’s low mileage and clear alignment with known engine defects. I mailed a formal appeal letter to Ford Motor Company and I am filing a complaint with my state attorney general. This widespread issue affects customer safety, and vehicle safety standards and deserves further investigation, as many other Ford owners of vehicles with 1.5L EcoBoost engines have reported similar failures.

Coolant intrusion, coolant and oil is mixing causing my car to run hot. Engine light keeps coming on, repairs to multiple pumps replaced, water pump replaced, spark plugs replaced, radiator replaced, thermostat replaced. Ford dealership tried replacing all the above vehicle is still running hot. Now claiming I need a new engine.

My car had a bad shifting linkage which I paid for out of pocket. My 2.0 Ecoboost engine is leaking coolant into my oil and makes a very loud concerning ticking noise, along with reduced engine power and sporadic/random loss of brakes. There has been recalls for these issues on most other Ford Fusion models and this one NEEDS TO BE RECALLED. My engine is going to blow any day now and I will be stuck paying for the rest of my car loan for a vehicle I cannot drive. All of the Ecoboost engines should be recalled for poor design.