2018 Ford Fusion

Bought 2018 fusion used with 20k miles. Driving to work the check engine light came on. Took it to auto zone they ran codes and said misfire cylinder 3. Replace plugs and coil packs. Next day check engine light came on again. This time had rough idle at start up. Turned car off and contacted closest ford dealer. Upon inspection told me coolant leaking into head with no blown head gasket. Said to be common problem with ecoboost engines. Need to replace engine for over $7800. Not under warranty and Ford knows of issue and won't stand behind their product. I'm a single mom with no car to get to work now and no way to fix this. It would take me years to save enough to fix this car. Completely hopeless at this point. No car=no way to work. No job=no home or food. This is a common problem and well known issue but tough luck? How can this be right? How can I feed my children or pay rent? What am I supposed to do? This is not fair. You made a faulty product so you should stand behind it and make it right. This has literally destroyed my life.

I was driving to work one day and my car's engine light came on and then the overheating light signaled and would drop and then signal again randomly one morning, with no sign of smoke or overheating. Unfortunately, I was crossing a bridge when this happened. My car started to slow down and eventually just stopped moving ON THE BRIDGE. I finally got it to a mechanic who thought that the codes ran could be fixed with a tuneup. Got a tuneup and the Engine light came right back on. He then looked further into the issue and found out about the eco engine issue. I could not drive my car for two weeks until ford could fit me in their schedule because they were booked two weeks out. I get it to the dealer and they tell me the car is leaking coolant into my engine and now my engine needs to be replaced and that this is a common issue but I must pay for this fix myself. This is wrong and completely unsafe to put people on the road in these cars knowing this can happen.

The contact owns a 2018 Ford Fusion. The contact stated while driving 25 MPH, the check engine warning light illuminated. The vehicle was taken to the dealer where it was diagnosed that there was coolant intrusion in the cylinder and the engine block needed to be replaced. The vehicle was not repaired. The manufacturer was notified of the failure and referred the contact to the NHTSA. The failure mileage was approximately 67,000.

Never had a problem with car no leaks nothing than starting to overheat checked coolant was empty refilled next day was empty again yet no leaks had it looked at all coolant is in engine block but no blown head or other way saw in other complaints lots with same car had same problem and said it’s a flaw engine where coolant gets into cylinder still owe more money then car is worth now and can’t drive

Upon entering off ramp to highway , upon acceleration car shudders and goes into limp mode, can't accelerate and forced to try and pull over to stop vehicle and re-start. Very dangerous as it is random, can't re-create and has happened at highway speeds, very unsafe. Took it to dealer, Ford could not recreate and said there were no codes present and subsequently found nothing wrong.

Electrical: My car’s radio was going out and I took to Ford for a check while getting oil change. They said normal don’t worry about it. At this time I was still in warranty. When taken to Ford the 2nd time,they “reset” my SYNC & then the radio/touchscreen complete stopped working within 48 hours. When I told them, I just happened to be out of warranty then. Touch screen is completely blank! It will not turn on or allow controls for heat nor a/c. Cannot see backup camera nor can I hear the beeps. The USB plugs and outlets are also not working! This began in January 2020. I have a 7 month old at the time and it was a very cold winter. Engine: Fast forward to August 2020, my car just shut down in the middle of the highway and started shaking with my then 15 month old! Pulled over and had it towed to Ford. Ford told me it needed a new Engine and would cost $7500 to get it fixed. I had never issues before and each oil change received the multi point inspection and I was never informed of any issues prior to.