Vehicle Speed Control. Review the 428 owner reports in this category and discuss these concerns during a pre-purchase inspection. Read reports →
Power Train. Review the 360 owner reports in this category and discuss these concerns during a pre-purchase inspection. Read reports →
Engine. Review the 93 owner reports in this category and discuss these concerns during a pre-purchase inspection. Read reports →

NHTSA owner reports · September 18, 2026 snapshot.

27 crash reports1 fire reports4 injury reports

What owners actually said

893 reports

Mileage unknown · Jun 24, 2016

Power Train

Read full complaint

I AM HAVING TROUBLE WITH THE CVT TRANSMISSION IN MY CAR WHEN I PUT IT IN GEAR IT LUNGES ALMOST OVER POWERING THE BREAKS. IT ALSO WILL STALL IF I HAVE TO HIT THE BREAKS HARD TO COME TO A STOP REAL FAST. I WILL BE GETTING IN THE HIGHWAY AND EVERY SO OFTEN IT WILL NOT SHIFT IT JUST RUNS AT REALLY HIGH RPM. IT WILL ALSO LOOSE POWER SUDDENLY AND A WRENCH LIGHT WILL COME ON THAT LIMITS ME TO 2000 RPM AND I HAVE HAD TO PULL OFF TO THE SIDE OF THE HIGHWAY MANY TIMES BECAUSE OF THIS. I HAVE BEEN DOING SOME RESEARCH AND I HAVE COME TO FIND OUT THAT THOUSANDS OF PEOPLE HAVE HAD SOME OF THESE SAME PROBLEMS AND FORD WON'T DO ANYTHING ABOUT THEM. I FEEL UNSAFE WHILE DRIVING MY CAR BUT IT IS MY ONLY TRANSPORTATION AT THE TIME SO I HAVE NO OTHER OPTION IS HAVE ALSO EXPERIENCED PROBLEMS WITH MY AWD AND I FEEL IT CAN'T WORK BECAUSE OF THE PROBLEMS OF MY TRANSMISSIO .

NHTSA ODI #10876520

126,000 miles · Jun 21, 2016

Power Train

Read full complaint

I WAS ATTEMPTING TO PASS A SLOW TRUCK ON A TWO LANE ROAD. AS ACCELERATED AND PULL ALONGSIDE THE TRUCK THE CTV TRANSMISSION FAILED AND THE ENGINE RACED. I WAS ABLE TO GET AROUND THE TRUCK AND GET TO THE SHOULDER OF THE ROAD. I CALL A TOW TRUCK AND MY CAR HAS BEEN IN THE REPAIR SHOP FOR 8 WEEKS. I AM CONCERNED REGARDING HEAD ON COLLISIONS THAT MAY HAVE NOT BEEN REPORTED AS A TRANSMISSION PROBLEM. IF A CAR WOULD HAVE BEEN APPROACHING IN THE OPPOSITE DIRECTION I WOULD HAVE SUFFERED A HEAD ON COLLISION.

NHTSA ODI #10875698

138,836 miles · Jun 6, 2016

Service BrakesVehicle Speed Control

TL* THE CONTACT OWNS A 2007 FORD FREESTYLE. THE CONTACT STATED THAT THE VEHICLE EXPERIENCED UNINTENDED ACCELERATION WHEN THE BRAKE PEDAL WAS DEPRESSED. THE FAILURE OCCURRED WITHOUT WARNING. THE VEHICLE WAS NOT DIAGNOSED NOR REPAIRED. THE MANUFACTURER WAS NOT MADE AWARE OF THE FAILURE. THE FAILURE MILEAGE WAS APPROXIMATELY 138,83…

Read full complaint

NHTSA ODI #10872687

141,404 miles · Jun 2, 2016

Vehicle Speed Control

TL* THE CONTACT OWNS A 2007 FORD FREESTYLE. WHEN THE CONTACT RELEASED THE BRAKE PEDAL WHILE AT A STOP, THE VEHICLE ACCELERATED UNCONTROLLABLY. THE VEHICLE WAS NOT DIAGNOSED NOR REPAIRED. THE MANUFACTURER WAS NOT NOTIFIED. THE VIN WAS UNKNOWN. THE FAILURE MILEAGE WAS 141,404.

NHTSA ODI #10872200

110,000 miles · May 28, 2016

Engine

ENGINE LOST ACCELERATION POWER WHILE DRIVING DUE TO A CLOGGED THROTTLE BODY WHILE ON A HIGHWAY. GOOGLE SEARCH INDICATES THIS IS A COMMON COMPLAINT WITH 2006 AND 2007 FREESTYLES.

NHTSA ODI #10871336

3 miles · Apr 28, 2016

EngineVehicle Speed Control

MY 2007 FORD FREESTYLE CUTS OFF REPEATEDLY AFTER ALMOST EVERY RED LIGHT STOP. I SAW A LOT OF COMPLAINTS ABOUT THIS MATTER WITH DIFFERENT FORD FREESTYLES AND NO ONE SEEMS TO KNOW THE CAUSE. MAINLY ANYTIME I APPLY THE BRAKES THE CUT SHUTS OFF AND PUTS MYSELF AND FAMILY IN LIFE- THREATENING SITUATIONS. ALSO, THE VEHICLE IDLES HIGH …

Read full complaint

NHTSA ODI #10861975

156,000 miles · Apr 25, 2016

EngineVehicle Speed Control

Read full complaint

TL* THE CONTACT OWNS A 2007 FORD FREESTYLE. THE CONTACT STATED THAT WHILE DEPRESSING THE BRAKE PEDAL, THE VEHICLE WAS ACCELERATING INDEPENDENTLY WITHOUT WARNING. IN ADDITION, THE VEHICLE STALLED WITHOUT WARNING. THE VEHICLE WAS ABLE TO RESTART. THE FAILURES RECURRED VARIOUS TIMES. THE VEHICLE WAS TAKEN TO INDEPENDENT MECHANIC WHERE THE FAILURE WAS UNDETERMINED. THE VEHICLE WAS NOT REPAIRED. THE MANUFACTURER WAS NOT NOTIFIED OF THE FAILURE. THE APPROXIMATE FAILURE MILEAGE WAS 156,000.

NHTSA ODI #10861192

102,000 miles · Feb 22, 2016

EngineVehicle Speed Control

Read full complaint

TL* THE CONTACT OWNS A 2007 FORD FREESTYLE. WHILE DRIVING APPROXIMATELY 30 MPH, THE ACCELERATOR PEDAL WAS DEPRESSED BUT THE VEHICLE FAILED TO ACCELERATE PAST 2 MPH. THE CHECK ENGINE WARNING INDICATOR ILLUMINATED. THE FAILURE RECURRED THREE TIMES. THE VEHICLE WAS TAKEN TO A DEALER WHERE IT WAS DIAGNOSED THAT THE THROTTLE BODY FAILED AND NEEDED TO BE REPLACED. THE VEHICLE WAS PREVIOUSLY REPAIRED UNDER A MANUFACTURER'S RECALL; HOWEVER, THE REMEDY FAILED TO PREVENT THE FAILURE. THE MANUFACTURER WAS MADE AWARE OF THE FAILURE. THE FAILURE MILEAGE WAS APPROXIMATELY 102,000. THE VIN WAS UNAVAILABLE.

NHTSA ODI #10837561

95,000 miles · Feb 18, 2016

Electrical System

Read full complaint

THE FRONT PASSENGER STRETCHED HIS LEGS AND MANAGED TO KICK THE EXPOSED FUEL SHUT OFF SWITCH UNDER THE GLOVE BOX AND ABOVE THE RIGHT SIDE KICK PANEL WHICH DISABLED THE CAR TRAFFIC AND IT WOULD NOT RESTART. THE DRIVER WAS ABLE TO COAST OF THE ROAD AND WAS PICKED UP BY AAA. HAVE THERE BEEN ANY OTHER REPORTS OF THIS EVENT. THE CAR WAS ON THE RIGHT SIDE OF AN INTERSTATE. HAD IT BEEN IN THE LEFT LANE THERE COULD HAVE BEEN A SERIOUS ACCIDENT. DO YOU HAVE ANY REPORTS OF SUCH AN EVENT. I HAVE NOT BEEN ABLE TO LOCATE ANY AT THIS POINT.

NHTSA ODI #10837048

Mileage unknown · Feb 8, 2016

Electrical System

I HAVE TWO 2007 FORD ONE IS A FREESTYLE AND THE OTHER IS A SPORT TRAC AND THEY ARE HAVING THE SAME PROBLEM. THE INSIDE LIGHTS COME ON AND OFF BY THEMSELVES. THEY STAY ON FOR A FEW MINUTES THEN THEY CLICK BACK OFF THEN BACK ON AND OFF AGAIN. THE FREESTYLE DOES NOT HAVE A AUTO SWITCH FOR THE LIGHTS BUT THE SPORT TRAC DOES. IT …

Read full complaint

NHTSA ODI #10824745

Official recalls

No recalls in this snapshot.

Model-level recall history does not show whether a particular VIN is affected or has received a repair. Check a VIN with NHTSA ↗

NHTSA investigations

PE11018 · Idle Instability

Opened May 11, 2011 · Closed Feb 7, 2013

Status: closed (inferred from source dates) · Vehicle Speed Control

On November 29, 2012, Ford Motor Company (Ford) initiated Customer Satisfaction Program 12N03 to extend warranty coverage terms for repair of engine idle RPM surge caused by throttle body deposits in all model year (MY) 2005 through 2007 Ford Freestyle, Five Hundred and Mercury Montego vehicles.The program extends the coverage for up to 10 years of service or 150,000 miles from the warranty start date of the vehicle (all vehicles are eligible for the program through May 31, 2013, regardless of mileage).Dealers will repair vehicles exhibiting the condition by removing and cleaning the throttle body and reprogramming the PCM with software containing an updated idle speed control strategy.According to Ford, some of the affected vehicles may experience momentary, intermittent engine idle RPM surge (idle flare) when stopped or during low speed driving maneuvers such as in a parking lot or driveway.Unstable idle speed control (dips and flares) around the target engine speed (700 rpm) can occur in vehicles with deposit build-up in the throttle body when the system adjusts engine speed in response to changes in engine load, typically from power steering application or air-conditioner compressor cycling.Idle speed control logic is only active at vehicle speeds below 3.5 mph and when the accelerator pedal is not applied.Ford testing of a vehicle with a worst case throttle body measured a maximum idle flare of 1360 RPM lasting approximately 1 second, which Ford indicated was consistent with system design to limit vehicle speed and acceleration in idle control mode.Ford indicated that the test vehicle was held in place with normal brake effort and that vehicle speed remained under 4 mph without the brake pedal applied.In addition to throttle body deposit accumulation, symptoms associated with the condition may include Check Engine lamp illumination and diagnostic trouble codes (DTCs) P0505, P0506 or P061B.Ford attributed the surge condition to changes in idle air flow resulting from the progressive buildup of deposits in the throttle body from normal Positive Crankcase Ventilation (PCV) system operation.This condition was not adequately compensated for in the original Powertrain Control Module (PCM) calibration.Ford issued a technical service bulletin on August 15, 2011 (TSB 11-8-5), releasing an updated powertrain control calibration for vehicles with CVT transmissions.On October 19, 2011, Ford issued a second bulletin (TSB 11-10-21) superseding TSB 11-8-5 and including updated powertrain control calibration for vehicles with 6-speed transmissions.Prior to Ford issuing the TSB?s, owner?s experiencing the alleged defect either received no repairs, if dealers could not duplicate the condition, or had the throttle body cleaned or replaced, which only provided temporary correction until the throttle deposit build-up returned.Ford?s revised powertrain calibrations appear to be effective remedies for the idle instability caused by build-up of throttle body deposits.However, even after the TSB?s were released, many owners experiencing the condition continued to have difficulty with proper diagnosis and repair as dealers were often either unable to duplicate the condition or were unfamiliar with the new repair procedures.Ford's new program addresses those concerns.NHTSA's testing and complaint analysis indicate that the idle speed control issue in the subject vehicles can only occur at very low speeds, are very brief events, are easily controlled by moderate brake pedal forces and result in minor increases in vehicle speed even with no braking.This investigation is closed.The closing of this in

PE08060 · Tire Valve Cracking

Opened Oct 14, 2008 · Closed Apr 9, 2009

Status: closed (inferred from source dates) · Tires:valve

ON OCTOBER 14, 2008, ODI OPENED PE08-060 TO INVESTIGATE ALLEGATIONS OF CRACKED AND LEAKING SNAP-IN TIRE VALVES IN MODEL YEAR (MY) 2007 VEHICLES MANUFACTURED BY FORD MOTOR COMPANY.THE VALVES WERE SUPPLIED TO FORD BY TOPSEAL AUTO-PARTS, A SUBSIDIARY OF THE SHANGHAI BAOLONG AUTOMOTIVE CORPORATION IN CHINA.VALVES MADE BY TOPSEAL FOR AFTERMARKET SALE WERE THE SUBJECT OF TWO RECENT SAFETY RECALLS BY TECH INTERNATIONAL (08T-018) AND DILL AIR CONTROLS (08T-028), THE LATTER OF WHICH WAS INVESTIGATED BY ODI IN PE08-036 AND EA08-022.THE DEFECT CONDITIONS ADDRESSED BY THE AFTERMARKET TIRE VALVE RECALLS BOTH INVOLVED INADEQUATE RESISTANCE TO OZONE CRACKING DUE TO ISSUES WITH THE SUPPLY OF ANTI-OZONANT CHEMICALS TO TOPSEAL FOR A PERIOD FROM JULY TO MID-NOVEMBER 2006.THE AFTERMARKET VALVES WERE COMPOUNDED WITH A BLEND OF EPDM AND NATURAL RUBBER, USING A RELATIVELY LOW PERCENTAGE OF EPDM (EPDM PROVIDES INHERENT RESISTANCE TO OZONE CRACKING).HENCE, THE NEED FOR ANTI-OZONANT CHEMICALS AND THE PROBLEMS WITH CRACKING WHEN THOSE CHEMICALS WERE MISSING OR OUT OF SPECIFICATION IN SOME LOTS OF VALVES.BOTH RECALL CAMPAIGNS INVOLVED INSPECTION PROGRAMS TO IDENTIFY AND REPLACE VALVES WITH VISIBLE SURFACE CRACKING.ALTHOUGH THE TOPSEAL VALVES SUPPLIED TO FORD ALSO APPEAR TO HAVE BEEN AFFECTED BY THE ANTI-OZONANT SUPPLY ISSUES IN MID TO LATE-2006, FORD INDICATED THAT ITS VALVES WERE MADE AT A DIFFERENT TOPSEAL PRODUCTION LINE AND WERE COMPOUNDED WITH A HIGHER PERCENTAGE OF EPDM RUBBER TO MEET MORE STRINGENT SPECIFICATIONS FROM FORD.ODI'S ANALYSIS OF COMPLAINT AND WARRANTY DATA PROVIDED BY FORD SHOWED THAT PROBLEMS WITH CRACKED TIRE VALVES WERE SIGNIFICANTLY HIGHER FOR MY 2007 VEHICLES PRODUCED FROM DECEMBER 2006 THROUGH MARCH 2007.FORD RESPONDED BY IMPLEMENTING CHANGES IN ITS MATERIAL SPECIFICATIONS FOR SNAP-IN RUBBER TIRE VALVES AND ALSO INCREASING THE QUALITY AND ACCEPTANCE STANDARDS FOR VALVES IMPORTED FOR USE IN ITS VEHICLES.WHILE THE COMPLAINT AND WARRANTY CLAIM RATES ARE ELEVATED FOR SUBJECT VEHICLES PRODUCED FROM DECEMBER 2006 THROUGH MARCH 2007, THE RATES OF LEAKING VALVES ARE WELL BELOW ONE PERCENT OF PRODUCTION FOR EACH OF THE PEAK MONTHS FOR ALL OF THE AFFECTED MODELS.A SUBSTANTIAL MAJORITY OF THE SUBJECT VEHICLES ARE EQUIPPED WITH TIRE PRESSURE MONITORING SYSTEMS (TPMS) WHICH WARN THE DRIVER WHEN ANY TIRE PRESSURES DROPS BELOW 25 PERCENT OF RECOMMENDED INFLATION PRESSURE. AS OUTLINED IN A LETTER TO ODI DATED APRIL 6, 2009, FORD HAS AGREED TO SEND LETTERS TO OWNERS OF CERTAIN MY 2007 AND 2008 FORD, LINCOLN AND MERCURY VEHICLES TO PROVIDE INFORMATION ABOUT THE CRACKING CONCERN. LETTERS WILL BE SENT TO OWNERS OF VEHICLES BUILT FROM NOVEMBER 2006 THROUGH MAY 2007.OWNERS CAN OPT FOR A FREE DEALER INSPECTION.VALVES EXHIBITING SURFACE CRACKS OR AIR LEAKAGE RELATED TO OZONE ATTACK WILL BE REPLACED BY FORD UNDER ITS NORMAL WARRANTY TERMS.FORD EXPECTS TO SEND THE LETTER BY APPROXIMATELY MID-MAY 2009. BASED ON THE USE OF TPMS IN THE MAJORITY OF SUBJECT VEHICLES AND THE RELATIVELY LOW RATES OF REPAIRS ASSOCIATED WITH LEAKING VALVES AND RESULTANT TIRE DAMAGE, ODI BELIEVES THAT THE ACTIONS FORD HAS AGREED TO TAKE WILL PROVIDE EFFECTIVE AND EXPEDITIOUS RESOLUTION FOR VEHICLES THAT WERE BUILT DURING THE PERIOD WHEN VALVES WITH INADEQUATE RESISTANCE TO OZONE CRACKING WERE MOST LIKELY TO HAVE BEEN USED IN VEHICLE PRODUCTION.FURTHER INVESTIGATION OF THIS MATTER WOULD NOT BE AN EFFICIENT ALLOCATION OF AGENCY RESOURCES.ACCORDINGLY, THIS INVESTIGATION IS CLOSED.THE CLOSING OF THIS INVESTIGATION DOES NOT CONSTITUTE A FINDING BY NHTSA THAT A SAFETY-RELATED DEFECT DOES NOT EXIST.THE AGENCY WILL CONTINUE TO