NHTSA owner reports · September 18, 2026 snapshot.
Vehicle Speed Control complaints
428 reportsClear category filter87,688 miles · Aug 4, 2011
Vehicle Speed Control
MY 2007 FOR FREESTYLE IS HAVING LUNGING ISSUES. I OFTEN NOTICE IT WHEN IT'S VERY HOT AND THE AIR CONDITIONER IS RUNNING AND/OR WHEN I'M PARKING. I'VE ALSO NOTICED THE WRENCH LITE APPEAR A FEW TIMES. OTHER TIMES, MY CAR LOOSES POWER COMPLETELY AND SHUTS OFF. OTHER TIMES, IT FEELS LIKE I AM LOOSING POWER WHEN I'M DRIVING. ALMOST A…
Read full complaint
MY 2007 FOR FREESTYLE IS HAVING LUNGING ISSUES. I OFTEN NOTICE IT WHEN IT'S VERY HOT AND THE AIR CONDITIONER IS RUNNING AND/OR WHEN I'M PARKING. I'VE ALSO NOTICED THE WRENCH LITE APPEAR A FEW TIMES. OTHER TIMES, MY CAR LOOSES POWER COMPLETELY AND SHUTS OFF. OTHER TIMES, IT FEELS LIKE I AM LOOSING POWER WHEN I'M DRIVING. ALMOST AS IF THE CAR IS DOWN SHIFTING TO A LOWER GEAR. *TR
NHTSA ODI #10417072
87,688 miles · Aug 4, 2011
Vehicle Speed Control
MY 2007 FOR FREESTYLE IS HAVING LUNGING ISSUES. I OFTEN NOTICE IT WHEN IT'S VERY HOT AND THE AIR CONDITIONER IS RUNNING AND/OR WHEN I'M PARKING. I'VE ALSO NOTICED THE WRENCH LITE APPEAR A FEW TIMES. OTHER TIMES, MY CAR LOOSES POWER COMPLETELY AND SHUTS OFF. OTHER TIMES, IT FEELS LIKE I AM LOOSING POWER WHEN I'M DRIVING. ALMOST A…
Read full complaint
MY 2007 FOR FREESTYLE IS HAVING LUNGING ISSUES. I OFTEN NOTICE IT WHEN IT'S VERY HOT AND THE AIR CONDITIONER IS RUNNING AND/OR WHEN I'M PARKING. I'VE ALSO NOTICED THE WRENCH LITE APPEAR A FEW TIMES. OTHER TIMES, MY CAR LOOSES POWER COMPLETELY AND SHUTS OFF. OTHER TIMES, IT FEELS LIKE I AM LOOSING POWER WHEN I'M DRIVING. ALMOST AS IF THE CAR IS DOWN SHIFTING TO A LOWER GEAR. *TR
NHTSA ODI #10417069
65,981 miles · Aug 3, 2011
Vehicle Speed Control
TL* THE CONTACT OWNS A 2007 FORD FREESTYLE. WHEN THE BRAKES WERE APPLIED, THE CONTACT STATED THAT THE VEHICLE WOULD LUNGE FORWARD WHILE DRIVING AND LUNGE BACKWARDS WHILE DRIVING IN REVERSE. THE VEHICLE STALLED AND THE WARNING LIGHT WOULD ILLUMINATE ON THE INSTRUMENT PANEL. THE DEALER WAS NOTIFIED, BUT DENIED ANY ASSISTANCE WIT…
Read full complaint
TL* THE CONTACT OWNS A 2007 FORD FREESTYLE. WHEN THE BRAKES WERE APPLIED, THE CONTACT STATED THAT THE VEHICLE WOULD LUNGE FORWARD WHILE DRIVING AND LUNGE BACKWARDS WHILE DRIVING IN REVERSE. THE VEHICLE STALLED AND THE WARNING LIGHT WOULD ILLUMINATE ON THE INSTRUMENT PANEL. THE DEALER WAS NOTIFIED, BUT DENIED ANY ASSISTANCE WITH REPAIRS TO THE FAILURE. THE MANUFACTURER WAS NOT NOTIFIED. THE VEHICLE WAS NOT REPAIRED. THE FAILURE MILEAGE WAS 65,981 AND THE CURRENT MILEAGE WAS 68,000.
NHTSA ODI #10416958
71,000 miles · Aug 3, 2011
Engine And Engine CoolingPower TrainVehicle Speed Control
VEHICLE EXPERIENCES SUDDEN UNEXPECTED ACCELERATION (OR LURCHING) WHEN IDLING OR MOVING AT A VERY SLOW SPEED. OCCURS IN FORWARD OR REVERSE DIRECTIONS, OCCURS MORE FREQUENTLY IN HOT WEATHER. *KB
NHTSA ODI #10416908
30,000 miles · Aug 3, 2011
Power TrainVehicle Speed Control
TL* THE CONTACT OWNS A 2007 FORD FREESTYLE. THE CONTACT STATED THAT THE VEHICLE WOULD SURGE FORWARD, WHILE THE AIR CONDITIONING UNIT WAS ACTIVATED, THEN THE VEHICLE WOULD SUDDENLY STALL AND HE WOULD NOTICE A WARNING LIGHT ON THE INSTRUMENT PANEL. THE DEALER INSPECTED THE VEHICLE AND INFORMED THE CONTACT TO HAVE THE THROTTLE BO…
Read full complaint
TL* THE CONTACT OWNS A 2007 FORD FREESTYLE. THE CONTACT STATED THAT THE VEHICLE WOULD SURGE FORWARD, WHILE THE AIR CONDITIONING UNIT WAS ACTIVATED, THEN THE VEHICLE WOULD SUDDENLY STALL AND HE WOULD NOTICE A WARNING LIGHT ON THE INSTRUMENT PANEL. THE DEALER INSPECTED THE VEHICLE AND INFORMED THE CONTACT TO HAVE THE THROTTLE BODY REPLACED. NO REPAIRS WERE PERFORMED. THE CURRENT MILEAGES WERE 30,000. THE APPROXIMATE FAILURE MILEAGE WAS 100,000. UPDATED 9/13/11 *CN THE CONSUMER ALSO STATED IF THE AC WAS ON, THE VEHICLE WOULD SURGE FORWARD. THE DEALER INFORMED THE CONSUMER MODELS STARTING FROM 2006 AND UP HAD A PROBLEM WITH THE TRANSMISSION BODY VALVE. UPDATED 10/05/11
NHTSA ODI #10416881
72,000 miles · Aug 3, 2011
Vehicle Speed Control
TL* THE CONTACT OWNS A 2007 FORD FREESTYLE. THE CONTACT STATED THAT THE VEHICLE WOULD SURGE FORWARD WHILE IN DRIVE AND WOULD SURGE BACKWARD WHILE IN REVERSE. THE DEALER ADVISED THE CONTACT TO HAVE THE THROTTLE BODY REPLACED. THE MANUFACTURER HAD NOT BEEN NOTIFIED. THE VEHICLE WAS REPAIRED. THE CURRENT MILEAGE WAS 75,000. T…
Read full complaint
TL* THE CONTACT OWNS A 2007 FORD FREESTYLE. THE CONTACT STATED THAT THE VEHICLE WOULD SURGE FORWARD WHILE IN DRIVE AND WOULD SURGE BACKWARD WHILE IN REVERSE. THE DEALER ADVISED THE CONTACT TO HAVE THE THROTTLE BODY REPLACED. THE MANUFACTURER HAD NOT BEEN NOTIFIED. THE VEHICLE WAS REPAIRED. THE CURRENT MILEAGE WAS 75,000. THE APPROXIMATE FAILURE MILEAGE WAS 72,000. UPDATED 2/22/12 *CN
NHTSA ODI #10416851
90,000 miles · Aug 2, 2011
Vehicle Speed Control
CAR LUNGES OR SURGES FORWARD OR BACKWARD UNEXPECTEDLY, ESPECIALLY WHEN AIR CONDITIONING UNIT IS OPERATING. CAN OCCUR WITH OR WITHOUT HAVING THE BRAKE PEDAL APPLIED.
NHTSA ODI #10417408
50,000 miles · Aug 2, 2011
Vehicle Speed Control
TL* THE CONTACT OWNS A 2007 FORD FREESTYLE. THE CONTACT STATED THAT WHILE WAITING AT A RED LIGHT WITH THE BRAKE PEDAL DEPRESSED, THE VEHICLE LUNGEG FORWARD. THE VEHICLE WAS TAKEN TO A LOCAL REPAIR SHOP WHERE THE CONTACT WAS INFORMED THAT THE THROTTLE BODY WAS DEFECTIVE AND NEEDED TO BE REPLACED. THE MANUFACTURER WAS MADE AWARE O…
Read full complaint
TL* THE CONTACT OWNS A 2007 FORD FREESTYLE. THE CONTACT STATED THAT WHILE WAITING AT A RED LIGHT WITH THE BRAKE PEDAL DEPRESSED, THE VEHICLE LUNGEG FORWARD. THE VEHICLE WAS TAKEN TO A LOCAL REPAIR SHOP WHERE THE CONTACT WAS INFORMED THAT THE THROTTLE BODY WAS DEFECTIVE AND NEEDED TO BE REPLACED. THE MANUFACTURER WAS MADE AWARE OF THE FAILURE, BUT DID NOT OFFER ANY ASSISTANCE. THE VEHICLE WAS NOT REPAIRED. THE FAILURE MILEAGE WAS 50,000 AND CURRENT MILEAGE WAS 96,000. THE VIN WAS NOT AVAILABLE.
NHTSA ODI #10416756
98,000 miles · Aug 2, 2011
Power TrainVehicle Speed Control
I HAVE A 2007 FORD FREESTYLE THAT LUNGES WITHOUT TOUCHING THE GAS , WHEN I PARK AND SIT FOR A MOMENT AS SOON AS I PUT IT IN DRIVE IT LUNGES FORWARD, SOMETIMES WHEN IM GOING TO PARK IN A PARKING LOT AND STOP AND LET OFF THE GAS IT LUNGES FORWARD , I DO NOT KNOW WHY IT DOES THIS BUT SOME ONE WILL GET HURT IF THIS IS NOT FIXED AND …
Read full complaint
I HAVE A 2007 FORD FREESTYLE THAT LUNGES WITHOUT TOUCHING THE GAS , WHEN I PARK AND SIT FOR A MOMENT AS SOON AS I PUT IT IN DRIVE IT LUNGES FORWARD, SOMETIMES WHEN IM GOING TO PARK IN A PARKING LOT AND STOP AND LET OFF THE GAS IT LUNGES FORWARD , I DO NOT KNOW WHY IT DOES THIS BUT SOME ONE WILL GET HURT IF THIS IS NOT FIXED AND FORD DEALER CANT TELL ME WHY IT DOES THIS . *KB
NHTSA ODI #10416728
52,000 miles · Aug 2, 2011
Power TrainVehicle Speed Control
OUR 2007 FORD FREESTYLE SURGES UNCONTROLLABLY WHEN IDLING. THE DEALER STATES THAT THE THROTTLE BODY IS DEFECTIVE AND NEEDS TO BE REPLACED. *KB
NHTSA ODI #10416708
NHTSA investigations
2PE11018 · Idle Instability
Opened May 11, 2011 · Closed Feb 7, 2013
Status: closed (inferred from source dates) · Vehicle Speed Control
On November 29, 2012, Ford Motor Company (Ford) initiated Customer Satisfaction Program 12N03 to extend warranty coverage terms for repair of engine idle RPM surge caused by throttle body deposits in all model year (MY) 2005 through 2007 Ford Freestyle, Five Hundred and Mercury Montego vehicles.The program extends the coverage for up to 10 years of service or 150,000 miles from the warranty start date of the vehicle (all vehicles are eligible for the program through May 31, 2013, regardless of mileage).Dealers will repair vehicles exhibiting the condition by removing and cleaning the throttle body and reprogramming the PCM with software containing an updated idle speed control strategy.According to Ford, some of the affected vehicles may experience momentary, intermittent engine idle RPM surge (idle flare) when stopped or during low speed driving maneuvers such as in a parking lot or driveway.Unstable idle speed control (dips and flares) around the target engine speed (700 rpm) can occur in vehicles with deposit build-up in the throttle body when the system adjusts engine speed in response to changes in engine load, typically from power steering application or air-conditioner compressor cycling.Idle speed control logic is only active at vehicle speeds below 3.5 mph and when the accelerator pedal is not applied.Ford testing of a vehicle with a worst case throttle body measured a maximum idle flare of 1360 RPM lasting approximately 1 second, which Ford indicated was consistent with system design to limit vehicle speed and acceleration in idle control mode.Ford indicated that the test vehicle was held in place with normal brake effort and that vehicle speed remained under 4 mph without the brake pedal applied.In addition to throttle body deposit accumulation, symptoms associated with the condition may include Check Engine lamp illumination and diagnostic trouble codes (DTCs) P0505, P0506 or P061B.Ford attributed the surge condition to changes in idle air flow resulting from the progressive buildup of deposits in the throttle body from normal Positive Crankcase Ventilation (PCV) system operation.This condition was not adequately compensated for in the original Powertrain Control Module (PCM) calibration.Ford issued a technical service bulletin on August 15, 2011 (TSB 11-8-5), releasing an updated powertrain control calibration for vehicles with CVT transmissions.On October 19, 2011, Ford issued a second bulletin (TSB 11-10-21) superseding TSB 11-8-5 and including updated powertrain control calibration for vehicles with 6-speed transmissions.Prior to Ford issuing the TSB?s, owner?s experiencing the alleged defect either received no repairs, if dealers could not duplicate the condition, or had the throttle body cleaned or replaced, which only provided temporary correction until the throttle deposit build-up returned.Ford?s revised powertrain calibrations appear to be effective remedies for the idle instability caused by build-up of throttle body deposits.However, even after the TSB?s were released, many owners experiencing the condition continued to have difficulty with proper diagnosis and repair as dealers were often either unable to duplicate the condition or were unfamiliar with the new repair procedures.Ford's new program addresses those concerns.NHTSA's testing and complaint analysis indicate that the idle speed control issue in the subject vehicles can only occur at very low speeds, are very brief events, are easily controlled by moderate brake pedal forces and result in minor increases in vehicle speed even with no braking.This investigation is closed.The closing of this in
PE08060 · Tire Valve Cracking
Opened Oct 14, 2008 · Closed Apr 9, 2009
Status: closed (inferred from source dates) · Tires:valve
ON OCTOBER 14, 2008, ODI OPENED PE08-060 TO INVESTIGATE ALLEGATIONS OF CRACKED AND LEAKING SNAP-IN TIRE VALVES IN MODEL YEAR (MY) 2007 VEHICLES MANUFACTURED BY FORD MOTOR COMPANY.THE VALVES WERE SUPPLIED TO FORD BY TOPSEAL AUTO-PARTS, A SUBSIDIARY OF THE SHANGHAI BAOLONG AUTOMOTIVE CORPORATION IN CHINA.VALVES MADE BY TOPSEAL FOR AFTERMARKET SALE WERE THE SUBJECT OF TWO RECENT SAFETY RECALLS BY TECH INTERNATIONAL (08T-018) AND DILL AIR CONTROLS (08T-028), THE LATTER OF WHICH WAS INVESTIGATED BY ODI IN PE08-036 AND EA08-022.THE DEFECT CONDITIONS ADDRESSED BY THE AFTERMARKET TIRE VALVE RECALLS BOTH INVOLVED INADEQUATE RESISTANCE TO OZONE CRACKING DUE TO ISSUES WITH THE SUPPLY OF ANTI-OZONANT CHEMICALS TO TOPSEAL FOR A PERIOD FROM JULY TO MID-NOVEMBER 2006.THE AFTERMARKET VALVES WERE COMPOUNDED WITH A BLEND OF EPDM AND NATURAL RUBBER, USING A RELATIVELY LOW PERCENTAGE OF EPDM (EPDM PROVIDES INHERENT RESISTANCE TO OZONE CRACKING).HENCE, THE NEED FOR ANTI-OZONANT CHEMICALS AND THE PROBLEMS WITH CRACKING WHEN THOSE CHEMICALS WERE MISSING OR OUT OF SPECIFICATION IN SOME LOTS OF VALVES.BOTH RECALL CAMPAIGNS INVOLVED INSPECTION PROGRAMS TO IDENTIFY AND REPLACE VALVES WITH VISIBLE SURFACE CRACKING.ALTHOUGH THE TOPSEAL VALVES SUPPLIED TO FORD ALSO APPEAR TO HAVE BEEN AFFECTED BY THE ANTI-OZONANT SUPPLY ISSUES IN MID TO LATE-2006, FORD INDICATED THAT ITS VALVES WERE MADE AT A DIFFERENT TOPSEAL PRODUCTION LINE AND WERE COMPOUNDED WITH A HIGHER PERCENTAGE OF EPDM RUBBER TO MEET MORE STRINGENT SPECIFICATIONS FROM FORD.ODI'S ANALYSIS OF COMPLAINT AND WARRANTY DATA PROVIDED BY FORD SHOWED THAT PROBLEMS WITH CRACKED TIRE VALVES WERE SIGNIFICANTLY HIGHER FOR MY 2007 VEHICLES PRODUCED FROM DECEMBER 2006 THROUGH MARCH 2007.FORD RESPONDED BY IMPLEMENTING CHANGES IN ITS MATERIAL SPECIFICATIONS FOR SNAP-IN RUBBER TIRE VALVES AND ALSO INCREASING THE QUALITY AND ACCEPTANCE STANDARDS FOR VALVES IMPORTED FOR USE IN ITS VEHICLES.WHILE THE COMPLAINT AND WARRANTY CLAIM RATES ARE ELEVATED FOR SUBJECT VEHICLES PRODUCED FROM DECEMBER 2006 THROUGH MARCH 2007, THE RATES OF LEAKING VALVES ARE WELL BELOW ONE PERCENT OF PRODUCTION FOR EACH OF THE PEAK MONTHS FOR ALL OF THE AFFECTED MODELS.A SUBSTANTIAL MAJORITY OF THE SUBJECT VEHICLES ARE EQUIPPED WITH TIRE PRESSURE MONITORING SYSTEMS (TPMS) WHICH WARN THE DRIVER WHEN ANY TIRE PRESSURES DROPS BELOW 25 PERCENT OF RECOMMENDED INFLATION PRESSURE. AS OUTLINED IN A LETTER TO ODI DATED APRIL 6, 2009, FORD HAS AGREED TO SEND LETTERS TO OWNERS OF CERTAIN MY 2007 AND 2008 FORD, LINCOLN AND MERCURY VEHICLES TO PROVIDE INFORMATION ABOUT THE CRACKING CONCERN. LETTERS WILL BE SENT TO OWNERS OF VEHICLES BUILT FROM NOVEMBER 2006 THROUGH MAY 2007.OWNERS CAN OPT FOR A FREE DEALER INSPECTION.VALVES EXHIBITING SURFACE CRACKS OR AIR LEAKAGE RELATED TO OZONE ATTACK WILL BE REPLACED BY FORD UNDER ITS NORMAL WARRANTY TERMS.FORD EXPECTS TO SEND THE LETTER BY APPROXIMATELY MID-MAY 2009. BASED ON THE USE OF TPMS IN THE MAJORITY OF SUBJECT VEHICLES AND THE RELATIVELY LOW RATES OF REPAIRS ASSOCIATED WITH LEAKING VALVES AND RESULTANT TIRE DAMAGE, ODI BELIEVES THAT THE ACTIONS FORD HAS AGREED TO TAKE WILL PROVIDE EFFECTIVE AND EXPEDITIOUS RESOLUTION FOR VEHICLES THAT WERE BUILT DURING THE PERIOD WHEN VALVES WITH INADEQUATE RESISTANCE TO OZONE CRACKING WERE MOST LIKELY TO HAVE BEEN USED IN VEHICLE PRODUCTION.FURTHER INVESTIGATION OF THIS MATTER WOULD NOT BE AN EFFICIENT ALLOCATION OF AGENCY RESOURCES.ACCORDINGLY, THIS INVESTIGATION IS CLOSED.THE CLOSING OF THIS INVESTIGATION DOES NOT CONSTITUTE A FINDING BY NHTSA THAT A SAFETY-RELATED DEFECT DOES NOT EXIST.THE AGENCY WILL CONTINUE TO
Illustration