Under carriage is completely rotten floor boards ,shock mounts, rear frame. Garage on lunenburg st.in Fitchburg,MA said that it was so rotten that he couldn't find a safe spot to put the car on the lift to do exhaust work. Put in a complaint in Sept 2023 with NHTSA ID number 11544728. I explained to them that I had contacted F…
Read full complaint
Under carriage is completely rotten floor boards ,shock mounts, rear frame. Garage on lunenburg st.in Fitchburg,MA said that it was so rotten that he couldn't find a safe spot to put the car on the lift to do exhaust work. Put in a complaint in Sept 2023 with NHTSA ID number 11544728. I explained to them that I had contacted Ford Motor Co. and Ford didn't want to hear it. This car is problematic.Transmission does not shift properly. This vehicle never had a recall. There is dozens of consumer complaints. This vehicle is a hazard on the road and is very expensive to repair. Under carriage is unrepairable making this vehicle junk.
NHTSA ODI #11561385
Mileage unknown · Sep 15, 2023
Power TrainStructure
The contact owns a 2007 Ford Freestyle. The contact stated while driving at various speeds, the transmission failed to shift properly. The contact stated that the transmission warning light was illuminated. Additionally, the contact stated that the floorboard, undercarriage, and shock mounts were rusted. The vehicle was not dia…
Read full complaint
The contact owns a 2007 Ford Freestyle. The contact stated while driving at various speeds, the transmission failed to shift properly. The contact stated that the transmission warning light was illuminated. Additionally, the contact stated that the floorboard, undercarriage, and shock mounts were rusted. The vehicle was not diagnosed or repaired. The manufacturer was made aware of the failure and determined that the VIN was not under recall. The failure mileage was unknown.
NHTSA ODI #11544728
161,000 miles · Sep 11, 2020
Structure
WHILE DRIVING ON THE HIGHWAY, THE FORD FREESTYLE HAD A SUDDEN JOLT/WIGGLE DURING A LONG SWEEPING TURN TO THE LEFT. CONTINUED DRIVING HOME FOR 200 MILES WITHOUT ISSUES. THE DRIVER'S REAR WHEEL APPEARED CROOKED (SPLAYING OUT) AFTERWARDS. CAR WAS BROUGHT IN FOR INSPECTION AND THE REAR SUBFRAME WAS BROKEN. MECHANIC NOTICED LARGE AM…
Read full complaint
WHILE DRIVING ON THE HIGHWAY, THE FORD FREESTYLE HAD A SUDDEN JOLT/WIGGLE DURING A LONG SWEEPING TURN TO THE LEFT. CONTINUED DRIVING HOME FOR 200 MILES WITHOUT ISSUES. THE DRIVER'S REAR WHEEL APPEARED CROOKED (SPLAYING OUT) AFTERWARDS. CAR WAS BROUGHT IN FOR INSPECTION AND THE REAR SUBFRAME WAS BROKEN. MECHANIC NOTICED LARGE AMOUNT OF RUST. CAR HAS 161K MILES.
NHTSA ODI #11354391
116,000 miles · Feb 12, 2018
Structure
TL* THE CONTACT OWNS A 2007 FORD FREESTYLE. WHILE DRIVING APPROXIMATELY 35 MPH, THE REAR DRIVER AND PASSENGER DOORS BECAME AJAR. THE CONTACT WAS UNABLE TO SECURELY CLOSE THE DOORS. THE CONTACT STATED THAT IT WAS NOT UNTIL THE CABIN TEMPERATURE WARMED UP BEFORE THE DOORS COULD BE SECURELY CLOSED. THE VEHICLE WAS NOT TAKEN TO A DE…
Read full complaint
TL* THE CONTACT OWNS A 2007 FORD FREESTYLE. WHILE DRIVING APPROXIMATELY 35 MPH, THE REAR DRIVER AND PASSENGER DOORS BECAME AJAR. THE CONTACT WAS UNABLE TO SECURELY CLOSE THE DOORS. THE CONTACT STATED THAT IT WAS NOT UNTIL THE CABIN TEMPERATURE WARMED UP BEFORE THE DOORS COULD BE SECURELY CLOSED. THE VEHICLE WAS NOT TAKEN TO A DEALER TO BE DIAGNOSED OR REPAIRED. THE MANUFACTURER WAS NOTIFIED OF THE FAILURE AND ADVISED THE CONTACT TO CALL NHTSA. THE APPROXIMATE FAILURE MILEAGE WAS 116,000.
NHTSA ODI #11072234
72,703 miles · Oct 30, 2015
Structure
FAILED INSPECTION DUE TO RUST AND CORROSION ON SUB FRAME. ENGINE LIGHT ON CONSISTENT WITH RECENT RECALL OF FORD EDGE DUE TO RUST AND CORROSION. CAR HAS ONLY 72,703 MILES AND IS IN VERY GOOD CONDITION. OTHER FREESTYLE OWNERS HAVE NOTED SIMILAR DANGEROUS CORROSION ON SUB FRAME DUE TO "SUBSTANDARD STEEL AND ALLOYS."
NHTSA ODI #10787205
27,000 miles · Sep 30, 2013
Structure
TL* THE CONTACT OWNS A 2007 FORD FREESTYLE. THE CONTACT ENTERED THE VEHICLE AND NOTICED IT WAS DAMP. THE VEHICLE WAS INSPECTED BY AN INDEPENDENT MECHANIC, WHO DISCOVERED THAT WATER HAD LEAKED INSIDE OF THE VEHICLE. THE VEHICLE WAS NOT REPAIRED AND THE MANUFACTURER WAS NOTIFIED OF THE INCIDENT. THE APPROXIMATE FAILURE MILEAGE WAS…
Read full complaint
TL* THE CONTACT OWNS A 2007 FORD FREESTYLE. THE CONTACT ENTERED THE VEHICLE AND NOTICED IT WAS DAMP. THE VEHICLE WAS INSPECTED BY AN INDEPENDENT MECHANIC, WHO DISCOVERED THAT WATER HAD LEAKED INSIDE OF THE VEHICLE. THE VEHICLE WAS NOT REPAIRED AND THE MANUFACTURER WAS NOTIFIED OF THE INCIDENT. THE APPROXIMATE FAILURE MILEAGE WAS 27,000.
NHTSA ODI #10546209
75,000 miles · Aug 26, 2012
Power TrainStructure
LOUD WHIRRING NOISE WHICH GETS LOUDER WITH ACCELERATION AND IS REALLY LOUD GOING DOWNHILL WHEN THE ENGINE IS HOLDING BACK. ALSO HAVE TWO RUST SPOTS ON THE HOOD AND THE CAR IS ONLY 5 YEARS OLD AND HAS BEEN KEPT CLEAN AND IS WAXED AT LEAST ONCE PER YEAR. *TR
OUR CAR WAS QUITE NEW. MY DAUGHTERS AND I WERE IN THE CAR AT A STOP LIGHT. SOMEONE WAS IN FRONT OF ME AT THE TIME AND THEY WERE MAKING A RIGHT HAND TURN. WHEN I WAS SLIGHTLY ROLLING FORWARD I APPLIED PRESSURE TO THE BRAKE AND MY CAR JUMPED OR LUNGED FORWARD-CAUSING AN ACCIDENT WITH 4 KIDS AND 2 ADULTS INVOLVED. THIS IS THE FI…
Read full complaint
OUR CAR WAS QUITE NEW. MY DAUGHTERS AND I WERE IN THE CAR AT A STOP LIGHT. SOMEONE WAS IN FRONT OF ME AT THE TIME AND THEY WERE MAKING A RIGHT HAND TURN. WHEN I WAS SLIGHTLY ROLLING FORWARD I APPLIED PRESSURE TO THE BRAKE AND MY CAR JUMPED OR LUNGED FORWARD-CAUSING AN ACCIDENT WITH 4 KIDS AND 2 ADULTS INVOLVED. THIS IS THE FIRST OF MANY INCIDENTS WITH MY CAR PROACTIVELY MOVING. *TR
NHTSA ODI #10464415
Mileage unknown · Jan 14, 2010
Structure
2007 FORD FREESTYLE CAR RIDDLED WITH MOLD FROM CONSTANT WATER LEAKS EVERYWHERE IN THE BODY FRAME. NEVER BEEN IN ACCIDENT, OUT OF WARRANTY. I'M 3 MONTHS PREGNANT WITH A 2 YR OLD. I CAN NOT EVEN DRIVE CAR MAKES ME SICK. DEALER WANTS ALOT OF MONEY TO TRY AND FIX THE PROBLEM, BUT CONSIDERING THE MOLD IS EVERYWHERE I'M NOT SO SURE …
Read full complaint
2007 FORD FREESTYLE CAR RIDDLED WITH MOLD FROM CONSTANT WATER LEAKS EVERYWHERE IN THE BODY FRAME. NEVER BEEN IN ACCIDENT, OUT OF WARRANTY. I'M 3 MONTHS PREGNANT WITH A 2 YR OLD. I CAN NOT EVEN DRIVE CAR MAKES ME SICK. DEALER WANTS ALOT OF MONEY TO TRY AND FIX THE PROBLEM, BUT CONSIDERING THE MOLD IS EVERYWHERE I'M NOT SO SURE IT WILL SOLVE PROBLEM, I HAVE HAD THE CAR FOR 10 MONTHS AND PAID 17,500 FOR IT. IT IS CLEARLY A DESIGN FLAW I'M NOT THE ONLY ONE WITH THIS PROBLEM. IT IS A HUGE HEALTH ISSUE, AND I CAN NOT UNDERSTAND WHY FORD HAS NOT ISSUED A RECALL. *TR
NHTSA ODI #10299728
33,198 miles · Dec 5, 2009
Structure
2007 FORD FREESTYLE LEAKING WATER FROM MOONROOF WHEN BRAKES ARE APPLIED OR ESPECIALLY DOWNHILL WATER COMES DOWN FROM THE HEADLINER SPLASHING OFF THE DASHBOARD. *TR
NHTSA ODI #10294609
Official recalls
0
No recalls in this snapshot.
Model-level recall history does not show whether a particular VIN is affected or has received a repair. Check a VIN with NHTSA ↗
NHTSA investigations
2
PE11018 · Idle Instability
Opened May 11, 2011 · Closed Feb 7, 2013
Status: closed (inferred from source dates) · Vehicle Speed Control
On November 29, 2012, Ford Motor Company (Ford) initiated Customer Satisfaction Program 12N03 to extend warranty coverage terms for repair of engine idle RPM surge caused by throttle body deposits in all model year (MY) 2005 through 2007 Ford Freestyle, Five Hundred and Mercury Montego vehicles.The program extends the coverage for up to 10 years of service or 150,000 miles from the warranty start date of the vehicle (all vehicles are eligible for the program through May 31, 2013, regardless of mileage).Dealers will repair vehicles exhibiting the condition by removing and cleaning the throttle body and reprogramming the PCM with software containing an updated idle speed control strategy.According to Ford, some of the affected vehicles may experience momentary, intermittent engine idle RPM surge (idle flare) when stopped or during low speed driving maneuvers such as in a parking lot or driveway.Unstable idle speed control (dips and flares) around the target engine speed (700 rpm) can occur in vehicles with deposit build-up in the throttle body when the system adjusts engine speed in response to changes in engine load, typically from power steering application or air-conditioner compressor cycling.Idle speed control logic is only active at vehicle speeds below 3.5 mph and when the accelerator pedal is not applied.Ford testing of a vehicle with a worst case throttle body measured a maximum idle flare of 1360 RPM lasting approximately 1 second, which Ford indicated was consistent with system design to limit vehicle speed and acceleration in idle control mode.Ford indicated that the test vehicle was held in place with normal brake effort and that vehicle speed remained under 4 mph without the brake pedal applied.In addition to throttle body deposit accumulation, symptoms associated with the condition may include Check Engine lamp illumination and diagnostic trouble codes (DTCs) P0505, P0506 or P061B.Ford attributed the surge condition to changes in idle air flow resulting from the progressive buildup of deposits in the throttle body from normal Positive Crankcase Ventilation (PCV) system operation.This condition was not adequately compensated for in the original Powertrain Control Module (PCM) calibration.Ford issued a technical service bulletin on August 15, 2011 (TSB 11-8-5), releasing an updated powertrain control calibration for vehicles with CVT transmissions.On October 19, 2011, Ford issued a second bulletin (TSB 11-10-21) superseding TSB 11-8-5 and including updated powertrain control calibration for vehicles with 6-speed transmissions.Prior to Ford issuing the TSB?s, owner?s experiencing the alleged defect either received no repairs, if dealers could not duplicate the condition, or had the throttle body cleaned or replaced, which only provided temporary correction until the throttle deposit build-up returned.Ford?s revised powertrain calibrations appear to be effective remedies for the idle instability caused by build-up of throttle body deposits.However, even after the TSB?s were released, many owners experiencing the condition continued to have difficulty with proper diagnosis and repair as dealers were often either unable to duplicate the condition or were unfamiliar with the new repair procedures.Ford's new program addresses those concerns.NHTSA's testing and complaint analysis indicate that the idle speed control issue in the subject vehicles can only occur at very low speeds, are very brief events, are easily controlled by moderate brake pedal forces and result in minor increases in vehicle speed even with no braking.This investigation is closed.The closing of this in
PE08060 · Tire Valve Cracking
Opened Oct 14, 2008 · Closed Apr 9, 2009
Status: closed (inferred from source dates) · Tires:valve
ON OCTOBER 14, 2008, ODI OPENED PE08-060 TO INVESTIGATE ALLEGATIONS OF CRACKED AND LEAKING SNAP-IN TIRE VALVES IN MODEL YEAR (MY) 2007 VEHICLES MANUFACTURED BY FORD MOTOR COMPANY.THE VALVES WERE SUPPLIED TO FORD BY TOPSEAL AUTO-PARTS, A SUBSIDIARY OF THE SHANGHAI BAOLONG AUTOMOTIVE CORPORATION IN CHINA.VALVES MADE BY TOPSEAL FOR AFTERMARKET SALE WERE THE SUBJECT OF TWO RECENT SAFETY RECALLS BY TECH INTERNATIONAL (08T-018) AND DILL AIR CONTROLS (08T-028), THE LATTER OF WHICH WAS INVESTIGATED BY ODI IN PE08-036 AND EA08-022.THE DEFECT CONDITIONS ADDRESSED BY THE AFTERMARKET TIRE VALVE RECALLS BOTH INVOLVED INADEQUATE RESISTANCE TO OZONE CRACKING DUE TO ISSUES WITH THE SUPPLY OF ANTI-OZONANT CHEMICALS TO TOPSEAL FOR A PERIOD FROM JULY TO MID-NOVEMBER 2006.THE AFTERMARKET VALVES WERE COMPOUNDED WITH A BLEND OF EPDM AND NATURAL RUBBER, USING A RELATIVELY LOW PERCENTAGE OF EPDM (EPDM PROVIDES INHERENT RESISTANCE TO OZONE CRACKING).HENCE, THE NEED FOR ANTI-OZONANT CHEMICALS AND THE PROBLEMS WITH CRACKING WHEN THOSE CHEMICALS WERE MISSING OR OUT OF SPECIFICATION IN SOME LOTS OF VALVES.BOTH RECALL CAMPAIGNS INVOLVED INSPECTION PROGRAMS TO IDENTIFY AND REPLACE VALVES WITH VISIBLE SURFACE CRACKING.ALTHOUGH THE TOPSEAL VALVES SUPPLIED TO FORD ALSO APPEAR TO HAVE BEEN AFFECTED BY THE ANTI-OZONANT SUPPLY ISSUES IN MID TO LATE-2006, FORD INDICATED THAT ITS VALVES WERE MADE AT A DIFFERENT TOPSEAL PRODUCTION LINE AND WERE COMPOUNDED WITH A HIGHER PERCENTAGE OF EPDM RUBBER TO MEET MORE STRINGENT SPECIFICATIONS FROM FORD.ODI'S ANALYSIS OF COMPLAINT AND WARRANTY DATA PROVIDED BY FORD SHOWED THAT PROBLEMS WITH CRACKED TIRE VALVES WERE SIGNIFICANTLY HIGHER FOR MY 2007 VEHICLES PRODUCED FROM DECEMBER 2006 THROUGH MARCH 2007.FORD RESPONDED BY IMPLEMENTING CHANGES IN ITS MATERIAL SPECIFICATIONS FOR SNAP-IN RUBBER TIRE VALVES AND ALSO INCREASING THE QUALITY AND ACCEPTANCE STANDARDS FOR VALVES IMPORTED FOR USE IN ITS VEHICLES.WHILE THE COMPLAINT AND WARRANTY CLAIM RATES ARE ELEVATED FOR SUBJECT VEHICLES PRODUCED FROM DECEMBER 2006 THROUGH MARCH 2007, THE RATES OF LEAKING VALVES ARE WELL BELOW ONE PERCENT OF PRODUCTION FOR EACH OF THE PEAK MONTHS FOR ALL OF THE AFFECTED MODELS.A SUBSTANTIAL MAJORITY OF THE SUBJECT VEHICLES ARE EQUIPPED WITH TIRE PRESSURE MONITORING SYSTEMS (TPMS) WHICH WARN THE DRIVER WHEN ANY TIRE PRESSURES DROPS BELOW 25 PERCENT OF RECOMMENDED INFLATION PRESSURE. AS OUTLINED IN A LETTER TO ODI DATED APRIL 6, 2009, FORD HAS AGREED TO SEND LETTERS TO OWNERS OF CERTAIN MY 2007 AND 2008 FORD, LINCOLN AND MERCURY VEHICLES TO PROVIDE INFORMATION ABOUT THE CRACKING CONCERN. LETTERS WILL BE SENT TO OWNERS OF VEHICLES BUILT FROM NOVEMBER 2006 THROUGH MAY 2007.OWNERS CAN OPT FOR A FREE DEALER INSPECTION.VALVES EXHIBITING SURFACE CRACKS OR AIR LEAKAGE RELATED TO OZONE ATTACK WILL BE REPLACED BY FORD UNDER ITS NORMAL WARRANTY TERMS.FORD EXPECTS TO SEND THE LETTER BY APPROXIMATELY MID-MAY 2009. BASED ON THE USE OF TPMS IN THE MAJORITY OF SUBJECT VEHICLES AND THE RELATIVELY LOW RATES OF REPAIRS ASSOCIATED WITH LEAKING VALVES AND RESULTANT TIRE DAMAGE, ODI BELIEVES THAT THE ACTIONS FORD HAS AGREED TO TAKE WILL PROVIDE EFFECTIVE AND EXPEDITIOUS RESOLUTION FOR VEHICLES THAT WERE BUILT DURING THE PERIOD WHEN VALVES WITH INADEQUATE RESISTANCE TO OZONE CRACKING WERE MOST LIKELY TO HAVE BEEN USED IN VEHICLE PRODUCTION.FURTHER INVESTIGATION OF THIS MATTER WOULD NOT BE AN EFFICIENT ALLOCATION OF AGENCY RESOURCES.ACCORDINGLY, THIS INVESTIGATION IS CLOSED.THE CLOSING OF THIS INVESTIGATION DOES NOT CONSTITUTE A FINDING BY NHTSA THAT A SAFETY-RELATED DEFECT DOES NOT EXIST.THE AGENCY WILL CONTINUE TO
2007 Ford Freestyle Problems, Complaints & Recalls | Skip That Year
Illustration