IllustrationTL* THE CONTACT OWNS A 2005 FORD FREESTAR. THE CONTACT STATED THAT THE VEHICLE DECELERATED AND WOULD NOT ACCELERATE PAST 5 MPH. THE TRANSAXLE WARNING INDICATOR ILLUMINATED. THE VEHICLE WAS NOT DIAGNOSED NOR REPAIRED. THE MANUFACTURER WAS NOT NOTIFIED OF THE FAILURE. THE FAILURE MILEAGE WAS APPROXIMATELY 120,000.
2005 Ford Freestar
Owner reports · Recalls · Investigations
Limited comparison data
There is not enough comparable history to draw a useful model-year comparison.
About this comparison →How this year compares
Owner complaints by model year
Compare all Freestar years →Counts vary with age, sales and reporting. They are not failure rates.
What owners reported most
All reported categories
Tap a category to read its complaints. One report may name several components.
When problems were reported
Mileage at the reported incident
300–25K
8825–50K
22250–75K
18675–100K
200100–150K
78150K+
804 reports with mileage · 82 unknown
NHTSA’s mileage field refers to the reported incident, not necessarily the filing date. This shows report counts, not the likelihood of a failure.
What to inspect
Issues worth paying extra attention to based on owner reports.
- Power Train. Review the 677 owner reports in this category and discuss these concerns during a pre-purchase inspection. Read reports →
- Electrical System. Review the 85 owner reports in this category and discuss these concerns during a pre-purchase inspection. Read reports →
- Engine. Review the 53 owner reports in this category and discuss these concerns during a pre-purchase inspection. Read reports →
NHTSA owner reports · September 18, 2026 snapshot.
8 crash reports2 fire reports14 injury reports
Power Train complaints
677 reportsTL* THE CONTACT OWNS A 2005 FORD FREESTAR. WHILE DRIVING 25 MPH DOWN A STEEP DECLINE, THE TRANSMISSION FAILED TO OPERATE. THE CONTACT LOST SLIGHT STEERING CONTROL ON THE MOUNTAINOUS ROAD. AFTER REGAINING CONTROL, THE VEHICLE CAME TO A COMPLETE STOP AND FAILED TO RESTART. THE VEHICLE WAS TOWED TO AN INDEPENDENT MECHANIC WHO STAT…
Read full complaint
TL* THE CONTACT OWNS A 2005 FORD FREESTAR. WHILE DRIVING 25 MPH DOWN A STEEP DECLINE, THE TRANSMISSION FAILED TO OPERATE. THE CONTACT LOST SLIGHT STEERING CONTROL ON THE MOUNTAINOUS ROAD. AFTER REGAINING CONTROL, THE VEHICLE CAME TO A COMPLETE STOP AND FAILED TO RESTART. THE VEHICLE WAS TOWED TO AN INDEPENDENT MECHANIC WHO STATED THAT THE TRANSMISSION WOULD NEED TO BE REPLACED. ADDITIONALLY, WITHIN THE PAST EIGHT YEARS, THE TRANSMISSION WAS REPLACED TWICE. THE VEHICLE WAS NOT REPAIRED. THE MANUFACTURER WAS NOTIFIED. THE APPROXIMATE FAILURE MILEAGE WAS 60,000.
TL* THE CONTACT OWNS A 2005 FORD FREESTAR. WHILE DRIVING IN REVERSE AT APPROXIMATELY 5 MPH, THE VEHICLE STALLED WITHOUT WARNING. THE VEHICLE RESTARTED; HOWEVER, THE TRANSMISSION FAILED TO OPERATE IN THE DESIRED GEAR SELECTION UNTIL SEVERAL HOURS LATER. THE FAILURE RECURRED ON A SEPARATE OCCASION. THE VEHICLE WAS TAKEN TO THE DEA…
Read full complaint
TL* THE CONTACT OWNS A 2005 FORD FREESTAR. WHILE DRIVING IN REVERSE AT APPROXIMATELY 5 MPH, THE VEHICLE STALLED WITHOUT WARNING. THE VEHICLE RESTARTED; HOWEVER, THE TRANSMISSION FAILED TO OPERATE IN THE DESIRED GEAR SELECTION UNTIL SEVERAL HOURS LATER. THE FAILURE RECURRED ON A SEPARATE OCCASION. THE VEHICLE WAS TAKEN TO THE DEALER WHERE IT WAS DIAGNOSED THAT THE TORQUE CONVERTER AND TRANSMISSION WOULD NEED TO BE REPLACED. THE VIN WAS NOT INCLUDED IN NHTSA CAMPAIGN NUMBER: 12V006000 (POWER TRAIN). THE VEHICLE WAS NOT REPAIRED. THE MANUFACTURER WAS NOT NOTIFIED OF THE FAILURE. THE APPROXIMATE FAILURE MILEAGE WAS 62,000. THE VIN WAS UNAVAILABLE.
AN INCIDENT FROM ABOUT A MONTH AGO: AFTER TRAVELING ON THE FREEWAY AND COMING TO A STOP AT A RED LIGHT AT THE OFF RAMP AT 2AM, MY CAR BEGAN TO SPUTTER AND REV. I PROCEEDED TO THE NEXT RED LIGHT WHERE MY CAR SHUT OFF. EVERY TIME I STARTED IT, IT WOULD SHUT OFF RIGHT AWAY. I DRIVE FOR A TAXI SERVICE AND LUCKILY I DID NOT HAVE…
Read full complaint
AN INCIDENT FROM ABOUT A MONTH AGO: AFTER TRAVELING ON THE FREEWAY AND COMING TO A STOP AT A RED LIGHT AT THE OFF RAMP AT 2AM, MY CAR BEGAN TO SPUTTER AND REV. I PROCEEDED TO THE NEXT RED LIGHT WHERE MY CAR SHUT OFF. EVERY TIME I STARTED IT, IT WOULD SHUT OFF RIGHT AWAY. I DRIVE FOR A TAXI SERVICE AND LUCKILY I DID NOT HAVE PASSENGERS IN THE CAR WITH ME AT THE TIME. I CALLED A FAMILY MEMBER TO COME LOOK AND HELP. HE ENDED UP PUSHING MY CAR WITH HIS INTO A NEARBY PARKING LOT. AFTER SOME INVESTIGATION, I CONCLUDED IT WAS THE PCM. IT WAS TAKEN OUT TO DRY COMPLETELY AND THE WINDSHIELD AREA WHERE WATER MAY HAVE LEAKED INTO IT WAS SEALED WITH SILICONE. IT STARTED WORKING AGAIN FINE AND HAS BEEN SINCE THEN. NOW IT HAS RAINED AGAIN AND THE PROBLEM HAS REOCCURRED. TODAY, AFTER DRIVING ON THE FREEWAY AND ENTERING A NEIGHBORHOOD, MY TRANS-AXLE LIGHT STARTED BLINKING. THEN MY OIL AND BATTERY LIGHT APPEARED AND SECONDS AFTER MY STEERING WHEEL STOPPED TURNING AND THE CAR SHUT OFF. I WAS ABLE TO PARK IN THE STREET AND RESTART THE CAR, BUT ONCE I PUT IT IN DRIVE AND MOVED ABOUT 1 FOOT, THE CAR SHUT OFF AGAIN. IT WILL TURN ON AND STAY IDLE, BUT ONCE I START MOVING, IT SHUTS OFF AGAIN. IT HAS BEEN RAINING THE PAST 2 DAYS. I SUSPECT IT IS FROM THE SAME ISSUE AS BEFORE. I ALSO HAD MY CHILDREN IN THE CAR WITH ME AS I WAS TAKING THEM TO SCHOOL. I'M VERY LUCKY THIS DID NOT HAPPEN ON THE FREEWAY OR MAJOR STREET.
TL* THE CONTACT OWNS A 2005 FORD FREESTAR. WHILE DRIVING APPROXIMATELY 40 MPH, THE VEHICLE STALLED. THE VEHICLE RESTARTED, BUT WOULD NOT SHIFT INTO GEAR. THE VEHICLE WAS NOT DIAGNOSED NOR REPAIRED. THE MANUFACTURER WAS NOT NOTIFIED. THE VIN WAS UNKNOWN. THE APPROXIMATE FAILURE MILEAGE WAS 192,000.
TAKATA RECALL MY TRANSMISSION START SLIPPING WHEN 1ST GEAR TO 2ND GEAR. FEEL LIKE SOME TIMES LOOSING POWER.
TL* THE CONTACT OWNS A 2005 FORD FREESTAR. THE CONTACT STATED THAT THE VEHICLE EXPERIENCED A LOSS OF POWER. PRIOR TO THE FAILURE, THE VEHICLE HESITATED. THE FAILURE OCCURRED WITHOUT WARNING. THE VEHICLE WAS TAKEN TO AN INDEPENDENT MECHANIC, BUT THE FAILURE COULD NOT BE DUPLICATED. THE VEHICLE WAS NOT REPAIRED. THE MANUFACTURER W…
Read full complaint
TL* THE CONTACT OWNS A 2005 FORD FREESTAR. THE CONTACT STATED THAT THE VEHICLE EXPERIENCED A LOSS OF POWER. PRIOR TO THE FAILURE, THE VEHICLE HESITATED. THE FAILURE OCCURRED WITHOUT WARNING. THE VEHICLE WAS TAKEN TO AN INDEPENDENT MECHANIC, BUT THE FAILURE COULD NOT BE DUPLICATED. THE VEHICLE WAS NOT REPAIRED. THE MANUFACTURER WAS NOT MADE AWARE OF THE FAILURE. THE CONTACT REFERENCED NHTSA CAMPAIGN NUMBER: 12V006000 (POWER TRAIN); HOWEVER, THE VIN WAS NOT INCLUDED. THE FAILURE MILEAGE WAS APPROXIMATELY 151,206. UPDATED 04/07/16*LJ UPDATED 04/26/16*LJ *TR
IN 2014 WE BOUGHT A FORD FREESTAR, FOUND OUT LATER THE TORQUE CONV. WAS RECALLED AND REPLACED. I TOOK THE VAN TO FORD IN OUR AREA AND THEY FLUSHED OUT THE CONVERTER $185+ AND THAT WORKED FOR A MONTH OR SO AND IT DID IT AGAIN. TOOK IT BACK TO FORD AND THEY KEPT IT A WEEK BEFORE THEY TOLD ME I NEEDED A NEW TRANSMISSION. I REPORTED…
Read full complaint
IN 2014 WE BOUGHT A FORD FREESTAR, FOUND OUT LATER THE TORQUE CONV. WAS RECALLED AND REPLACED. I TOOK THE VAN TO FORD IN OUR AREA AND THEY FLUSHED OUT THE CONVERTER $185+ AND THAT WORKED FOR A MONTH OR SO AND IT DID IT AGAIN. TOOK IT BACK TO FORD AND THEY KEPT IT A WEEK BEFORE THEY TOLD ME I NEEDED A NEW TRANSMISSION. I REPORTED ABOUT THIS VAN BEFORE TO STEVE KENNER NVS-215KJS 12V-006 I BELIEVE THAT IT IS NOT JUST THE TORQUE CONVERTER THAT SHOULD HAVE BEEN RECALL BUT THE TRANSMISSION TOO.I HAD TO PAY ALAN JAY FORD OF WAUCHULA, FL $4.000.00 FOR THAT TRANSMISSION. THIS IS JUST NOT RIGHT.! FORD SAID PAY US THE MONEY HERE IS A 3 YEAR WARRANTY AND GOOD BYE. MY VAN COST ME $5300.00 AND NOW I HAVE $10,000. INTO THIS VEHICLE WHICH IS NOT ACCEPTABLE!!! MY TELE IS [XXX] I HAVE AN INVOICE/REQUEST #15-6151 TIS@NHTSA.GOV LETTER BY EMAIL CAME BACK. CAN YOU HELP ME. I REALLY THINK PEOPLE ARE IN DANGER WITH THIS TYPE OF VAN. FORD NEEDS TO TAKE A LOOK AT THESE TRANSMISSIONS BECAUSE THEY WOULD NOT EVEN REBUILD THAT PARTICULAR ONE SO I HAD TO GET ANOTHER NEW/REBUILT ONE. THAT'S NOT RIGHT. [XXX] [XXX] BOWLING GREEN, FL. 33834 INFORMATION REDACTED PURSUANT TO THE FREEDOM OF INFORMATION ACT (FOIA), 5 U.S.C. 552(B)(6).' *JB
ON FREEWAY, CAR LOST ALL FORWARD POWER. MOTOR RUNNING. MADE IT TO SHOULDER. SHUT ALL DOWN. STARTED MOTOR..PUT IN GEAR.. MANAGED TO GET HOME PLEASE SEE. CARCOMPLAINTS.COM
MY VAN WON'T GO INTO REVERSE AND SOMETIMES WON'T EVEN GO INTO DRIVE. THE TORQUE CONVERTER WAS FLUSHED OUT AGAIN AFTER IT WAS SUPPOSEDLY REPLACED DUE TO RECALL AND IS STILL SPUTTERING AND STALLING OUT. THEY TELL ME NOW I NEED A NEW TRANSMISSION AT 50K MILES ANOTHER $4K. THE VAN WAS IN THE DRIVEWAY WITH THE HEALTH DEPT. HERE TO DO…
Read full complaint
MY VAN WON'T GO INTO REVERSE AND SOMETIMES WON'T EVEN GO INTO DRIVE. THE TORQUE CONVERTER WAS FLUSHED OUT AGAIN AFTER IT WAS SUPPOSEDLY REPLACED DUE TO RECALL AND IS STILL SPUTTERING AND STALLING OUT. THEY TELL ME NOW I NEED A NEW TRANSMISSION AT 50K MILES ANOTHER $4K. THE VAN WAS IN THE DRIVEWAY WITH THE HEALTH DEPT. HERE TO DO WORK AND I COULDN'T GET IT IN REVERSE TO MOVE IT FOR THEM TO PUT IN MY SEPTIC. AFTER PUSHING IT BACKWARD I WAS ABLE TO PUT IT IN DRIVE TO GET AROUND THE HOUSE' IT HAS NOT WANTED TO GET OUT OF PARK AT THE DOCTOR'S OFFICE AND FINALLY WORKED WITH THE SHIFTER UNTIL IT FINALLY WENT TO REVERSE-BACKED OUT-THEN DRIVE. I WAS SITTING IN THE MIDDLE OF A BUSY LOT WHEN IT WOULDN'T GO INTO GEAR. TOOK IT TO FORD AND THEY SAY I EITHER NEEDED A TCM OR A NEW TRANSMISSION. HAD MY VAN FOR 2 DAYS BEFORE TELLING ME I NEEDED A NEW TRANSMISSION. I ONLY PAID $5300. FOR IT AND THEY WANT $4K FOR A TRANSMISSION. THE VAN IS A 2 OWNER VEHICLE AND I BOUGHT IT WITH 41K MILES. THEN FORD SAYS THAT THEY DON'T REBUILD THAT TRANSMISSION-BECAUSE IT IS CRAP AND I NEED A NEW ONE. THIS IS NOT RIGHT. OTHER PEOPLE HAVE COMPLAINED OF THIS SAME THING HAPPENING TO THEM. THEY NEED TO RECALL THIS TRANSMISSION BEFORE SOMEONE REALLY GETS HURT. IN DRIVING THE VAN STALLS FOR NO REASON GOING 30 TO 40MPH. PEOPLE WILL RUN YOU OVER. MY HUSBAND IS DISABLED AND WE CAN'T BE WORRIED ALL THE TIME IF THE VAN WILL GET US TO THE DOCTOR OR ANY PLACE ELSE SAFELY. NOW, WHILE THE VAN IS IN THE SHOP AGAIN FOR ANOTHER TRANSMISSION I HAVE NO WAY TO TRANSPORT MY HUSBANDS SCOOTER TO TAKE HIM TO THE DOCTOR. THE VAN WAS BOUGHT TO TRANSPORT HIM AND THE SCOOTER. WITHOUT A RELIABLE VAN I AM SCREWED! I WILL NEVER BUY A FORD EVER AGAIN. YOU NEED TO GET ON THIS RECALL FOR THE TRANNY. PLEASE HELP THESE PEOPLE LIKE ME. ANOTHER DEATH TRAP JUST LIKE THE PINTO. .WE SHOULD BE REIMBURSED FOR OUR TIME AND MONEY. IT ISN'T RIGHT.
Official recalls
313V081000 · Seats
Mar 7, 2013
Ford is recalling certain model year 2004-2007 Freestar and Mercury Monterey vehicles manufactured from March 24, 2003, through November 7, 2006, equipped with a third row seat and originally sold in, or currently registered in, Connecticut, Delaware, Illinois, Indiana, Iowa, Maine, Maryland, Massachusetts, Michigan, Minnesota, Missouri, New Hampshire, New Jersey, New York, Ohio, Pennsylvania, Rhode Island, Vermont, West Virginia, Wisconsin and the District of Columbia. The third row stowable seat can experience corrosion and structural degradation at the seat anchor mechanism mounted to the rear wheel wells. As a result of the corrosion, the third row seat may not fully latch into its seating position.
Consequence & remedy
Consequence: In the event that the vehicle is crashed into from the rear, an unlatched seat may increase the risk of personal injury.
Remedy: Ford will notify owners, and dealers will install new third row seat latch striker mounting brackets, free of charge. The recall began on March 28, 2013. Owners may contact Ford Motor Company Customer Relationship Center at 1-866-436-7332.
12V006000 · Power Train:automatic Transmission; Power Train:automatic Transmission:torque Converter
Jan 9, 2012
FORD IS RECALLING CERTAIN MODEL YEAR 2004 AND 2005 FORD FREESTAR AND MERCURY MONTEREY VEHICLES. THE TORQUE CONVERTER OUTPUT SHAFT MAY FAIL.
Consequence & remedy
Consequence: THIS CONDITION RESULTS IN A SUDDEN LOSS OF MOTIVE POWER WITH NO WARNING, INCREASING THE RISK OF A CRASH.
Remedy: FORD WILL NOTIFY OWNERS, AND DEALERS WILL REPLACE THE TORQUE CONVERTER FREE OF CHARGE. THE SAFETY RECALL BEGAN ON AUGUST 9, 2012. OWNERS MAY CONTACT THE FORD MOTOR COMPANY CUSTOMER RELATIONSHIP CENTER AT 1-866-436-7332.
Additional source detail variants (2)
Power Train:automatic Transmission:torque Converter
FORD IS RECALLING CERTAIN MODEL YEAR 2004 AND 2005 FORD FREESTAR AND MERCURY MONTEREY VEHICLES. THE TORQUE CONVERTER OUTPUT SHAFT MAY FAIL.
Consequence: THIS CONDITION RESULTS IN A SUDDEN LOSS OF MOTIVE POWER WITH NO WARNING, INCREASING THE RISK OF A CRASH.
Remedy: FORD WILL NOTIFY OWNERS, AND DEALERS WILL REPLACE THE TORQUE CONVERTER FREE OF CHARGE. THE SAFETY RECALL BEGAN ON AUGUST 9, 2012. OWNERS MAY CONTACT THE FORD MOTOR COMPANY CUSTOMER RELATIONSHIP CENTER AT 1-866-436-7332.
Power Train:automatic Transmission
FORD IS RECALLING CERTAIN MODEL YEAR 2004 AND 2005 FORD FREESTAR AND MERCURY MONTEREY VEHICLES. THE TORQUE CONVERTER OUTPUT SHAFT MAY FAIL.
Consequence: THIS CONDITION RESULTS IN A SUDDEN LOSS OF MOTIVE POWER WITH NO WARNING, INCREASING THE RISK OF A CRASH.
Remedy: FORD WILL NOTIFY OWNERS, AND DEALERS WILL REPLACE THE TORQUE CONVERTER FREE OF CHARGE. THE SAFETY RECALL BEGAN ON AUGUST 9, 2012. OWNERS MAY CONTACT THE FORD MOTOR COMPANY CUSTOMER RELATIONSHIP CENTER AT 1-866-436-7332.
06V069000 · Structure:body:hatchback/liftgate
Mar 9, 2006
ON CERTAIN VANS EQUIPPED WITH THE POWER LIFTGATE OPTION, THE POWER LIFTGATE MOTOR AUTOMATICALLY DISENGAGES AFTER THE LIFTGATE IS POWERED OPEN.
Consequence & remedy
Consequence: IN THE EVENT OF A LIFTGATE STRUT MALFUNCTION, THE LIFTGATE CAN FALL FREELY WITH NO PRIOR WARNING. ANYONE STANDING BENEATH THE LIFTGATE MAY BE INJURED IF THE LIFTGATE FALLS.
Remedy: DEALERS WILL REPROGRAM THE POWER LIFTGATE MODULE TO REDUCE THE LIKELIHOOD THAT THE LIFTGATE COULD FALL FREE OF CHARGE. THE RECALL BEGAN ON MARCH 15, 2006. OWNERS MAY CONTACT FORD AT 1-800-392-3673.
Model-level recall history does not show whether a particular VIN is affected or has received a repair. Check a VIN with NHTSA ↗
NHTSA investigations
6EQ12010 · Stabilus Rear Liftgate Struts Failing
Opened Sep 28, 2012 · Closed Dec 31, 2012
Status: closed (inferred from source dates) · Structure:body:hatchback/liftgate:support Device/strut
Please see the attached closing resume summary.It has been attached to this document as a PDF.
EA12003 · Corrosion Of Third-Row Seat Attachment
Opened Apr 23, 2012 · Closed May 2, 2013
Status: closed (inferred from source dates) · Seats; Seats:mid/rear Assembly; Structure; Structure:body
Ford is conducting a safety recall to repair the third-row seat's latch mechanisms in approximately 196,667 model year (MY) 2004 through 2007 Ford Freestar and Mercury Monterey vehicles (see NHTSA recall 13V-081 for more details).The recall covers vehicles originally sold, or currently registered, in the salt belt states or high corrosion areas of the United States: Connecticut, Delaware, the District of Columbia, Illinois, Indiana, Iowa, Maine, Maryland, Massachusetts, Michigan, Minnesota, Missouri, New Hampshire, New Jersey, New York, Ohio, Pennsylvania, Rhode Island, Vermont, West Virginia, and Wisconsin.Approximately 100,000 remaining MY 2004-2007 Freestar and Monterey vehicles--those vehicles that were not originally sold, or are not currently registered, in salt belt states--are not included in the recall action. Although these vehicles are the same as the ones described above, they experience significantly lower failure rates because of reduced road salt exposure.ODI is currently aware of only one complaint on vehicle outside of the recall scope.ODI will monitor complaints and take further action if warranted by the circumstances.For owners of vehicles that are outside of the recall scope but exhibit the defect condition, owners (and affected Ford dealers) can contact Ford to request the recall repair.This Engineering Analysis is closed.See attached report and associated recall file for additional information.The ODI reports cited above can be reviewed online at http://www-odi.nhtsa.dot.gov/owners/SearchNHTSAID under the following identification numbers: 10399896, 10410491, 10420028, 10424850, 10433928, 10436592, 10438529, 10440616, 10441489, 10441641, 10442809, 10446564, 10450295, 10450559, 10450587, 10452933, 10453826, 10454977, 10455545, 10456985, 10457423, 10457910, 10458738, 10459042, 10460511, 10461074, 10462910, 10463126, 10463262, 10463366, 10463600, 10464243, 10467003, 10467680, 10468429, 10469188, 10469200, 10470216, 10470510, 10471280, 10471520, 10471813, 10471978, 10472514, 10473087, 10473159, 10477025, 10477387, 10477954, 10478449, 10479247, 10479758, 10480611, 10480665, 10481054, 10481412, 10482213, 10482236, 10482613, 10482620, 10487872, 10489445, 10490515, 10490641, 10490663, 10490744, 10491495, 10492220, 10493470, 10493572, 10496348, 10497631, 10497976, 10498310, 10498433, 10499681, 10499861, 10500495.
Additional source detail variants (4)
Seats
Ford is conducting a safety recall to repair the third-row seat's latch mechanisms in approximately 196,667 model year (MY) 2004 through 2007 Ford Freestar and Mercury Monterey vehicles (see NHTSA recall 13V-081 for more details).The recall covers vehicles originally sold, or currently registered, in the salt belt states or high corrosion areas of the United States: Connecticut, Delaware, the District of Columbia, Illinois, Indiana, Iowa, Maine, Maryland, Massachusetts, Michigan, Minnesota, Missouri, New Hampshire, New Jersey, New York, Ohio, Pennsylvania, Rhode Island, Vermont, West Virginia, and Wisconsin.Approximately 100,000 remaining MY 2004-2007 Freestar and Monterey vehicles--those vehicles that were not originally sold, or are not currently registered, in salt belt states--are not included in the recall action. Although these vehicles are the same as the ones described above, they experience significantly lower failure rates because of reduced road salt exposure.ODI is currently aware of only one complaint on vehicle outside of the recall scope.ODI will monitor complaints and take further action if warranted by the circumstances.For owners of vehicles that are outside of the recall scope but exhibit the defect condition, owners (and affected Ford dealers) can contact Ford to request the recall repair.This Engineering Analysis is closed.See attached report and associated recall file for additional information.The ODI reports cited above can be reviewed online at http://www-odi.nhtsa.dot.gov/owners/SearchNHTSAID under the following identification numbers: 10399896, 10410491, 10420028, 10424850, 10433928, 10436592, 10438529, 10440616, 10441489, 10441641, 10442809, 10446564, 10450295, 10450559, 10450587, 10452933, 10453826, 10454977, 10455545, 10456985, 10457423, 10457910, 10458738, 10459042, 10460511, 10461074, 10462910, 10463126, 10463262, 10463366, 10463600, 10464243, 10467003, 10467680, 10468429, 10469188, 10469200, 10470216, 10470510, 10471280, 10471520, 10471813, 10471978, 10472514, 10473087, 10473159, 10477025, 10477387, 10477954, 10478449, 10479247, 10479758, 10480611, 10480665, 10481054, 10481412, 10482213, 10482236, 10482613, 10482620, 10487872, 10489445, 10490515, 10490641, 10490663, 10490744, 10491495, 10492220, 10493470, 10493572, 10496348, 10497631, 10497976, 10498310, 10498433, 10499681, 10499861, 10500495.
Seats:mid/rear Assembly
Ford is conducting a safety recall to repair the third-row seat's latch mechanisms in approximately 196,667 model year (MY) 2004 through 2007 Ford Freestar and Mercury Monterey vehicles (see NHTSA recall 13V-081 for more details).The recall covers vehicles originally sold, or currently registered, in the salt belt states or high corrosion areas of the United States: Connecticut, Delaware, the District of Columbia, Illinois, Indiana, Iowa, Maine, Maryland, Massachusetts, Michigan, Minnesota, Missouri, New Hampshire, New Jersey, New York, Ohio, Pennsylvania, Rhode Island, Vermont, West Virginia, and Wisconsin.Approximately 100,000 remaining MY 2004-2007 Freestar and Monterey vehicles--those vehicles that were not originally sold, or are not currently registered, in salt belt states--are not included in the recall action. Although these vehicles are the same as the ones described above, they experience significantly lower failure rates because of reduced road salt exposure.ODI is currently aware of only one complaint on vehicle outside of the recall scope.ODI will monitor complaints and take further action if warranted by the circumstances.For owners of vehicles that are outside of the recall scope but exhibit the defect condition, owners (and affected Ford dealers) can contact Ford to request the recall repair.This Engineering Analysis is closed.See attached report and associated recall file for additional information.The ODI reports cited above can be reviewed online at http://www-odi.nhtsa.dot.gov/owners/SearchNHTSAID under the following identification numbers: 10399896, 10410491, 10420028, 10424850, 10433928, 10436592, 10438529, 10440616, 10441489, 10441641, 10442809, 10446564, 10450295, 10450559, 10450587, 10452933, 10453826, 10454977, 10455545, 10456985, 10457423, 10457910, 10458738, 10459042, 10460511, 10461074, 10462910, 10463126, 10463262, 10463366, 10463600, 10464243, 10467003, 10467680, 10468429, 10469188, 10469200, 10470216, 10470510, 10471280, 10471520, 10471813, 10471978, 10472514, 10473087, 10473159, 10477025, 10477387, 10477954, 10478449, 10479247, 10479758, 10480611, 10480665, 10481054, 10481412, 10482213, 10482236, 10482613, 10482620, 10487872, 10489445, 10490515, 10490641, 10490663, 10490744, 10491495, 10492220, 10493470, 10493572, 10496348, 10497631, 10497976, 10498310, 10498433, 10499681, 10499861, 10500495.
Structure:body
Ford is conducting a safety recall to repair the third-row seat's latch mechanisms in approximately 196,667 model year (MY) 2004 through 2007 Ford Freestar and Mercury Monterey vehicles (see NHTSA recall 13V-081 for more details).The recall covers vehicles originally sold, or currently registered, in the salt belt states or high corrosion areas of the United States: Connecticut, Delaware, the District of Columbia, Illinois, Indiana, Iowa, Maine, Maryland, Massachusetts, Michigan, Minnesota, Missouri, New Hampshire, New Jersey, New York, Ohio, Pennsylvania, Rhode Island, Vermont, West Virginia, and Wisconsin.Approximately 100,000 remaining MY 2004-2007 Freestar and Monterey vehicles--those vehicles that were not originally sold, or are not currently registered, in salt belt states--are not included in the recall action. Although these vehicles are the same as the ones described above, they experience significantly lower failure rates because of reduced road salt exposure.ODI is currently aware of only one complaint on vehicle outside of the recall scope.ODI will monitor complaints and take further action if warranted by the circumstances.For owners of vehicles that are outside of the recall scope but exhibit the defect condition, owners (and affected Ford dealers) can contact Ford to request the recall repair.This Engineering Analysis is closed.See attached report and associated recall file for additional information.The ODI reports cited above can be reviewed online at http://www-odi.nhtsa.dot.gov/owners/SearchNHTSAID under the following identification numbers: 10399896, 10410491, 10420028, 10424850, 10433928, 10436592, 10438529, 10440616, 10441489, 10441641, 10442809, 10446564, 10450295, 10450559, 10450587, 10452933, 10453826, 10454977, 10455545, 10456985, 10457423, 10457910, 10458738, 10459042, 10460511, 10461074, 10462910, 10463126, 10463262, 10463366, 10463600, 10464243, 10467003, 10467680, 10468429, 10469188, 10469200, 10470216, 10470510, 10471280, 10471520, 10471813, 10471978, 10472514, 10473087, 10473159, 10477025, 10477387, 10477954, 10478449, 10479247, 10479758, 10480611, 10480665, 10481054, 10481412, 10482213, 10482236, 10482613, 10482620, 10487872, 10489445, 10490515, 10490641, 10490663, 10490744, 10491495, 10492220, 10493470, 10493572, 10496348, 10497631, 10497976, 10498310, 10498433, 10499681, 10499861, 10500495.
Structure
Ford is conducting a safety recall to repair the third-row seat's latch mechanisms in approximately 196,667 model year (MY) 2004 through 2007 Ford Freestar and Mercury Monterey vehicles (see NHTSA recall 13V-081 for more details).The recall covers vehicles originally sold, or currently registered, in the salt belt states or high corrosion areas of the United States: Connecticut, Delaware, the District of Columbia, Illinois, Indiana, Iowa, Maine, Maryland, Massachusetts, Michigan, Minnesota, Missouri, New Hampshire, New Jersey, New York, Ohio, Pennsylvania, Rhode Island, Vermont, West Virginia, and Wisconsin.Approximately 100,000 remaining MY 2004-2007 Freestar and Monterey vehicles--those vehicles that were not originally sold, or are not currently registered, in salt belt states--are not included in the recall action. Although these vehicles are the same as the ones described above, they experience significantly lower failure rates because of reduced road salt exposure.ODI is currently aware of only one complaint on vehicle outside of the recall scope.ODI will monitor complaints and take further action if warranted by the circumstances.For owners of vehicles that are outside of the recall scope but exhibit the defect condition, owners (and affected Ford dealers) can contact Ford to request the recall repair.This Engineering Analysis is closed.See attached report and associated recall file for additional information.The ODI reports cited above can be reviewed online at http://www-odi.nhtsa.dot.gov/owners/SearchNHTSAID under the following identification numbers: 10399896, 10410491, 10420028, 10424850, 10433928, 10436592, 10438529, 10440616, 10441489, 10441641, 10442809, 10446564, 10450295, 10450559, 10450587, 10452933, 10453826, 10454977, 10455545, 10456985, 10457423, 10457910, 10458738, 10459042, 10460511, 10461074, 10462910, 10463126, 10463262, 10463366, 10463600, 10464243, 10467003, 10467680, 10468429, 10469188, 10469200, 10470216, 10470510, 10471280, 10471520, 10471813, 10471978, 10472514, 10473087, 10473159, 10477025, 10477387, 10477954, 10478449, 10479247, 10479758, 10480611, 10480665, 10481054, 10481412, 10482213, 10482236, 10482613, 10482620, 10487872, 10489445, 10490515, 10490641, 10490663, 10490744, 10491495, 10492220, 10493470, 10493572, 10496348, 10497631, 10497976, 10498310, 10498433, 10499681, 10499861, 10500495.
PE11033 · Service Jack Failure
Opened Sep 13, 2011 · Closed Dec 7, 2012
Status: closed (inferred from source dates) · Equipment:mechanical:accessory Scissor/screw/bottle Jack/lift
The subject vehicles (SV) are all automatic transmission, front wheel drive vehicles with hand actuated mechanical park brakes. The investigation focused on allegations that the service jack failed and caused the vehicles to fall. The subject scissors-type jack appears to fail at the slotted hinge joints where the jack screw is located (bends at mid-point). The failures occur while the jack is in use, and vehicle movement (forward or backward) is typically reported coincident with the failure. Ford reported that most MY 2003 Windstar and all MY 2006-2007 Freestar/Monterey also use the subject jack, an additional 223,246 vehicles.NHTSA has received six consumer complaints (VOQs) involving three injury incidents and a fatality.Ford reported 26 complaints for the SVs involving an additional 4 injuries. In the fatal incident, the van fell on a person working on the engine under the otherwise unsupported vehicle; ODI was unable to determine whether the vehicle was adequately chocked or the park brake was properly set. Reported injuries include a broken arm, head and hand injuries, arm and rib bruises, and muscle strains. NHTSA has received just one new report since opening this investigation. The complaint trend in ODI and Ford data is flat if not declining.Ford provides instructions and warnings in the owner's manual, on a placard placed with the jack, and on the jack itself. These instruct consumers to put the vehicle gear selector in Park, properly set the parking brake, chock the opposite wheel, use the jack only for changing a tire, loosen the lug nuts prior to jacking, and to not get under a vehicle supported by the jack only (NHTSA also recommends that jacks only be used for tire changing).In the VOQs, roughly half the consumers were using the jack for something other than tire changing, half had not chocked a wheel, and half had not properly set the parking brake. ODI notes that since the front wheels are drive wheels (with an open center differential) the Park gear cannot provide vehicle stability (longitudinally) when a front wheel is raised. All NHTSA complaints and most of the complaints to Ford involved failures while a front wheel was raised.In response to ODI's inquiry, Ford conducted testing on a 2004 Freestar. Ford's tests showed that when a front tire was raised the service jack held without failing under various scenarios except when a rocking force was applied and the parking brake was not properly set. Based on its testing and its analysis of field data, Ford concluded that the type of jack failure evidenced in this investigation (bending at mid-point) was likely caused by vehicle movement due to an improperly secured vehicle, or other misuse of the jack. Ford notes that rates in this investigation were similar to those in another investigation (EA91-049) which ODI closed. ODI also analyzed jack data for MY 2003 and newer vehicles to compare to the SV population. To assist with this analysis, ODI requested data from the jack manufacturer (actually its successor company) who provided limited data but did identify other models using the same design jack. ODI was unable to identify a significant difference in the incidence of jack failures (including those involving bending failures) between the SVs, other vehicles which used the same jack, or other vehicles where the jack type was unknown or different.A safety-related defect has not been identified at this time and further use of agency resources does not appear to be warranted.Accordingly, investigation PE11-033 is closed. The closing of this investigation does not constitute a finding by NHTSA that a safety-related defect does not exist and ODI reserves
PE10033 · Engine Stalling
Opened Aug 23, 2010 · Closed Jul 15, 2011
Status: closed (inferred from source dates) · Power Train:automatic Transmission:control Module (tcm/pcm/tecm); Vehicle Speed Control
The subject vehicles suffered from a design issue whereby water could run down onto the cowling under the hood and located in the area of the windshield wipers and then drip onto a computer module, the Powertrain Control Module (PCM), which could be manifested in a variety of symptoms depending on which part of the circuit board became wet or which of the connector pins shorted out.In addition to causing an engine to stall, which may or may not then restart, the water intrusion could also cause the transmission to shift poorly, the vehicle to have erratic power, a malfunction indicator light to come on, or result in an inability to start the vehicle, an inability to shift the vehicle into either forward or reverse. Also the problem could cause a higher than normal idle RPM in Park, or for the radio to malfunction, or the interior lights to stay on.During this investigation ODI was concerned with the effect of the engine stalling or a drastic and sudden loss of power either of which may create a safety risk.In reviewing the actual number of these types of incidents, collectively referred to here as engine stalls, the number was found to be below what would be considered a defect trend.For example, the number of engine stalls identified in Ford's warranty claims for the model year (MY) 2004 subject vehicles, the MY with the most failures, was 200 out of population of 125,865, for a failure rate of 0.16%.The one crash recorded by a complainant to NHTSA, VOQ 10311522, alleged that the engine stalled, due to water intrusion into the PCM, while the road was turning causing her to go off the road and according to the police report the vehicle then hit an embankment and a tree stump. Ford reported in their response that there were three alleged crashes but none of these were validated as being caused by a problem with water intrusion into the PCM causing a stall.Accordingly this investigation is closed.The closing of this investigation does not constitute a finding by NHTSA that a safety-related defect does not exist.The agency will continue to monitor complaints and other information relating to the alleged defect in the subject vehicles and take further action in the future if warranted.
Additional source detail variants (2)
Power Train:automatic Transmission:control Module (tcm/pcm/tecm)
The subject vehicles suffered from a design issue whereby water could run down onto the cowling under the hood and located in the area of the windshield wipers and then drip onto a computer module, the Powertrain Control Module (PCM), which could be manifested in a variety of symptoms depending on which part of the circuit board became wet or which of the connector pins shorted out.In addition to causing an engine to stall, which may or may not then restart, the water intrusion could also cause the transmission to shift poorly, the vehicle to have erratic power, a malfunction indicator light to come on, or result in an inability to start the vehicle, an inability to shift the vehicle into either forward or reverse. Also the problem could cause a higher than normal idle RPM in Park, or for the radio to malfunction, or the interior lights to stay on.During this investigation ODI was concerned with the effect of the engine stalling or a drastic and sudden loss of power either of which may create a safety risk.In reviewing the actual number of these types of incidents, collectively referred to here as engine stalls, the number was found to be below what would be considered a defect trend.For example, the number of engine stalls identified in Ford's warranty claims for the model year (MY) 2004 subject vehicles, the MY with the most failures, was 200 out of population of 125,865, for a failure rate of 0.16%.The one crash recorded by a complainant to NHTSA, VOQ 10311522, alleged that the engine stalled, due to water intrusion into the PCM, while the road was turning causing her to go off the road and according to the police report the vehicle then hit an embankment and a tree stump. Ford reported in their response that there were three alleged crashes but none of these were validated as being caused by a problem with water intrusion into the PCM causing a stall.Accordingly this investigation is closed.The closing of this investigation does not constitute a finding by NHTSA that a safety-related defect does not exist.The agency will continue to monitor complaints and other information relating to the alleged defect in the subject vehicles and take further action in the future if warranted.
Vehicle Speed Control
The subject vehicles suffered from a design issue whereby water could run down onto the cowling under the hood and located in the area of the windshield wipers and then drip onto a computer module, the Powertrain Control Module (PCM), which could be manifested in a variety of symptoms depending on which part of the circuit board became wet or which of the connector pins shorted out.In addition to causing an engine to stall, which may or may not then restart, the water intrusion could also cause the transmission to shift poorly, the vehicle to have erratic power, a malfunction indicator light to come on, or result in an inability to start the vehicle, an inability to shift the vehicle into either forward or reverse. Also the problem could cause a higher than normal idle RPM in Park, or for the radio to malfunction, or the interior lights to stay on.During this investigation ODI was concerned with the effect of the engine stalling or a drastic and sudden loss of power either of which may create a safety risk.In reviewing the actual number of these types of incidents, collectively referred to here as engine stalls, the number was found to be below what would be considered a defect trend.For example, the number of engine stalls identified in Ford's warranty claims for the model year (MY) 2004 subject vehicles, the MY with the most failures, was 200 out of population of 125,865, for a failure rate of 0.16%.The one crash recorded by a complainant to NHTSA, VOQ 10311522, alleged that the engine stalled, due to water intrusion into the PCM, while the road was turning causing her to go off the road and according to the police report the vehicle then hit an embankment and a tree stump. Ford reported in their response that there were three alleged crashes but none of these were validated as being caused by a problem with water intrusion into the PCM causing a stall.Accordingly this investigation is closed.The closing of this investigation does not constitute a finding by NHTSA that a safety-related defect does not exist.The agency will continue to monitor complaints and other information relating to the alleged defect in the subject vehicles and take further action in the future if warranted.
EA09016 · Transmission Torque Converter Failure
Opened Nov 10, 2009 · Closed Feb 2, 2012
Status: closed (inferred from source dates) · Power Train:automatic Transmission; Power Train:automatic Transmission:torque Converter
On January 4, 2012 Ford Motor Company submitted a Defect Information Report (NHTSA Recall No. 12V-006) to NHTSA regarding a defect in the performance of the transmission torque converter for approximately 205,896 Ford Freestar and Mercury Monterey vehicles.The supplier of the torque converter manufactured converters containing a pump shaft spline that did not consistently meet the specified heat treatment requirements.In normal use, the spline may wear excessively and eventually fails without warning.If a torque converter malfunctions due to a sheared pump drive spline, the vehicle will abruptly lose motive power.This problem affected model year 2004 and 2005 Freestar and Monterey minivans.During the investigation NHTSA identified 532 complaints alleging incidents of vehicle stall while driving due to torque converter failure.These failures were sudden and without any prior warning.Of the 490 complaints that reported the speed at the time of the failure:218 (44%) occurred at or above 55 mph; and 344 (70%) occurred at or above 40 mph.Of the 382 complaints that reported the position of the vehicle relative to traffic after it came to a stop following the loss of motive power: 122 (32%) alleged that the vehicle came to a stop in the flow of traffic and remained in the flow of traffic until pushed or towed out of the way; 225 (59%) reported that the vehicle was maneuvered to the side of the roadway and remained there until towed; and 35 (9%) reported that they were able to maneuver to a location away from the flow of traffic, such as a parking lot.Two crashes were allegedly caused by torque converter failure, including an incident in which a Freestar suddenly lost power in 65 mph traffic in an area where there was no shoulder available.As a result, the Freestar stopped in a travel lane and when trailing traffic maneuvered to avoid the stalled vehicle, a four vehicle collision occurred.In these types of circumstances NHTSA believes the defect presents an unreasonable risk to motor vehicle safety and so advised Ford.In its Defect Information Report, Ford refers to its response to NHTSA's Preliminary Evaluation information request, which stated that a vehicle that loses motive power due to torque converter malfunction remains readily controllable; the vehicle will coast during which it can be safely maneuvered and stopped because the engine continues to run.Because the engine continues to run, steering and braking are unaffected, and the vehicle's electrical system and directional signals remain functional.In view of the foregoing, NHTSA does not agree with this statement.This investigation is closed based on Ford's recall.
Additional source detail variants (2)
Power Train:automatic Transmission
On January 4, 2012 Ford Motor Company submitted a Defect Information Report (NHTSA Recall No. 12V-006) to NHTSA regarding a defect in the performance of the transmission torque converter for approximately 205,896 Ford Freestar and Mercury Monterey vehicles.The supplier of the torque converter manufactured converters containing a pump shaft spline that did not consistently meet the specified heat treatment requirements.In normal use, the spline may wear excessively and eventually fails without warning.If a torque converter malfunctions due to a sheared pump drive spline, the vehicle will abruptly lose motive power.This problem affected model year 2004 and 2005 Freestar and Monterey minivans.During the investigation NHTSA identified 532 complaints alleging incidents of vehicle stall while driving due to torque converter failure.These failures were sudden and without any prior warning.Of the 490 complaints that reported the speed at the time of the failure:218 (44%) occurred at or above 55 mph; and 344 (70%) occurred at or above 40 mph.Of the 382 complaints that reported the position of the vehicle relative to traffic after it came to a stop following the loss of motive power: 122 (32%) alleged that the vehicle came to a stop in the flow of traffic and remained in the flow of traffic until pushed or towed out of the way; 225 (59%) reported that the vehicle was maneuvered to the side of the roadway and remained there until towed; and 35 (9%) reported that they were able to maneuver to a location away from the flow of traffic, such as a parking lot.Two crashes were allegedly caused by torque converter failure, including an incident in which a Freestar suddenly lost power in 65 mph traffic in an area where there was no shoulder available.As a result, the Freestar stopped in a travel lane and when trailing traffic maneuvered to avoid the stalled vehicle, a four vehicle collision occurred.In these types of circumstances NHTSA believes the defect presents an unreasonable risk to motor vehicle safety and so advised Ford.In its Defect Information Report, Ford refers to its response to NHTSA's Preliminary Evaluation information request, which stated that a vehicle that loses motive power due to torque converter malfunction remains readily controllable; the vehicle will coast during which it can be safely maneuvered and stopped because the engine continues to run.Because the engine continues to run, steering and braking are unaffected, and the vehicle's electrical system and directional signals remain functional.In view of the foregoing, NHTSA does not agree with this statement.This investigation is closed based on Ford's recall.
Power Train:automatic Transmission:torque Converter
On January 4, 2012 Ford Motor Company submitted a Defect Information Report (NHTSA Recall No. 12V-006) to NHTSA regarding a defect in the performance of the transmission torque converter for approximately 205,896 Ford Freestar and Mercury Monterey vehicles.The supplier of the torque converter manufactured converters containing a pump shaft spline that did not consistently meet the specified heat treatment requirements.In normal use, the spline may wear excessively and eventually fails without warning.If a torque converter malfunctions due to a sheared pump drive spline, the vehicle will abruptly lose motive power.This problem affected model year 2004 and 2005 Freestar and Monterey minivans.During the investigation NHTSA identified 532 complaints alleging incidents of vehicle stall while driving due to torque converter failure.These failures were sudden and without any prior warning.Of the 490 complaints that reported the speed at the time of the failure:218 (44%) occurred at or above 55 mph; and 344 (70%) occurred at or above 40 mph.Of the 382 complaints that reported the position of the vehicle relative to traffic after it came to a stop following the loss of motive power: 122 (32%) alleged that the vehicle came to a stop in the flow of traffic and remained in the flow of traffic until pushed or towed out of the way; 225 (59%) reported that the vehicle was maneuvered to the side of the roadway and remained there until towed; and 35 (9%) reported that they were able to maneuver to a location away from the flow of traffic, such as a parking lot.Two crashes were allegedly caused by torque converter failure, including an incident in which a Freestar suddenly lost power in 65 mph traffic in an area where there was no shoulder available.As a result, the Freestar stopped in a travel lane and when trailing traffic maneuvered to avoid the stalled vehicle, a four vehicle collision occurred.In these types of circumstances NHTSA believes the defect presents an unreasonable risk to motor vehicle safety and so advised Ford.In its Defect Information Report, Ford refers to its response to NHTSA's Preliminary Evaluation information request, which stated that a vehicle that loses motive power due to torque converter malfunction remains readily controllable; the vehicle will coast during which it can be safely maneuvered and stopped because the engine continues to run.Because the engine continues to run, steering and braking are unaffected, and the vehicle's electrical system and directional signals remain functional.In view of the foregoing, NHTSA does not agree with this statement.This investigation is closed based on Ford's recall.
PE09033 · Torque Converter Output Shaft Failure
Opened Jul 15, 2009 · Closed Nov 17, 2009
Status: closed (inferred from source dates) · Power Train:automatic Transmission; Power Train:automatic Transmission:torque Converter
ODI HAS RECEIVED 227 OWNER COMPLAINTS ALLEGING A SUDDEN AND UNEXPECTED LOSS OF MOTIVE POWER DUE TO AN INTERNAL TRANSMISSION FAILURE IN THE SUBJECT VEHICLES.OF THOSE COMPLAINTS, 124 CAN BE ATTRIBUTED TO THE TORQUE CONVERTER OUTPUT SHAFT SPLINES STRIPPING CAUSING A SUDDEN LOSS OF POWER TO THE DRIVETRAIN.THE REMAINING 103 COMPLAINTS EXPERIENCED A LOSS OF MOTIVE POWER BUT THE SPECIFIC INTERNAL FAILURE CAUSE WITHIN THE TRANSMISSION IS NOT KNOWN.ODI HAS UPGRADED THE INVESTIGATION TO AN ENGINEERING ANALYSIS (EA09-016) TO CONTINUE ITS ASSESSMENT OF THE SCOPE, FREQUENCY AND SAFETY-RELATED CONSEQUENCES OF THE ALLEGED DEFECT.
Additional source detail variants (2)
Power Train:automatic Transmission
ODI HAS RECEIVED 227 OWNER COMPLAINTS ALLEGING A SUDDEN AND UNEXPECTED LOSS OF MOTIVE POWER DUE TO AN INTERNAL TRANSMISSION FAILURE IN THE SUBJECT VEHICLES.OF THOSE COMPLAINTS, 124 CAN BE ATTRIBUTED TO THE TORQUE CONVERTER OUTPUT SHAFT SPLINES STRIPPING CAUSING A SUDDEN LOSS OF POWER TO THE DRIVETRAIN.THE REMAINING 103 COMPLAINTS EXPERIENCED A LOSS OF MOTIVE POWER BUT THE SPECIFIC INTERNAL FAILURE CAUSE WITHIN THE TRANSMISSION IS NOT KNOWN.ODI HAS UPGRADED THE INVESTIGATION TO AN ENGINEERING ANALYSIS (EA09-016) TO CONTINUE ITS ASSESSMENT OF THE SCOPE, FREQUENCY AND SAFETY-RELATED CONSEQUENCES OF THE ALLEGED DEFECT.
Power Train:automatic Transmission:torque Converter
ODI HAS RECEIVED 227 OWNER COMPLAINTS ALLEGING A SUDDEN AND UNEXPECTED LOSS OF MOTIVE POWER DUE TO AN INTERNAL TRANSMISSION FAILURE IN THE SUBJECT VEHICLES.OF THOSE COMPLAINTS, 124 CAN BE ATTRIBUTED TO THE TORQUE CONVERTER OUTPUT SHAFT SPLINES STRIPPING CAUSING A SUDDEN LOSS OF POWER TO THE DRIVETRAIN.THE REMAINING 103 COMPLAINTS EXPERIENCED A LOSS OF MOTIVE POWER BUT THE SPECIFIC INTERNAL FAILURE CAUSE WITHIN THE TRANSMISSION IS NOT KNOWN.ODI HAS UPGRADED THE INVESTIGATION TO AN ENGINEERING ANALYSIS (EA09-016) TO CONTINUE ITS ASSESSMENT OF THE SCOPE, FREQUENCY AND SAFETY-RELATED CONSEQUENCES OF THE ALLEGED DEFECT.