2005 Ford Five Hundred

AFTER IT RAINED, THE TEMPERATURE DROPPED BELOW FREEZING. MY DOOR WAS DIFFICULT TO OPEN, BUT WOULD NOT CLOSE OR LATCH. IT WAS FROZEN OPEN. THERE IS ALREADY A RECALL ON THIS, BUT FORD DEALERS IN THE AREA SAYS IT DOES NOT APPLY TO CARS IN THE SOUTH. A RECALL IS A RECALL. FIRST OF ALL, BOTH TN AND OK GET SNOW AND ICE, AND A RECALL IS A RECALL. IF I DECIDE TO MOVE BACK TO MAINE WITH THIS CAR, THEN I'LL BE ABLE TO GET IT FIXED FOR FREE? WHAT IF DECIDE TO GO SKIING IN COLORADO, BUT CANNOT LEAVE BECAUSE MY DOOR LATCHES FREEZE? *TR

CAR DRIVES ON ITS OWN! IF I DO NOT HAVE FOOT ON GAS ON BREAK IT WILL CONTINUE TO MOVE. SAID FAILSAFE MODE THEN CHECK ENGINE LIGHT ILLUMINATED, DASH BOARD SAID CHECK ENGINE CHECK TRANSMISSION THEN THE LIGHT WENT OUT THE FOLLOWING DAY. NOW DRIVING BACK TO NORMAL. I TOOK TO AUTO ZONE THE DAY IT WENT HAYWIRE & THEY ADVISED ME ITS A POSSIBLE RECALL SEVERAL PPL SAID THE SAME ISSUE WITH THEIR FORD.

VEHICLE WILL INTERMITTENTLY STALL WHEN ACCELERATING FROM A STOP. THE VEHICLE HAS STALLED NUMEROUS TIMES IN THE MIDDLE OF EXECUTING A TURN, LEAVING THE VEHICLE AND OCCUPANTS IN A DANGEROUS SITUATION. A FORD DEALERSHIP DIAGNOSED THE PROBLEM AS BEING THE THROTTLE BODY, HOWEVER, AFTER REPLACING THE VERY EXPENSIVE THROTTLE BODY, THE PROBLEM PERSISTS. A NON-FORD MECHANIC IS NOW SAYING IT IS MORE LIKELY LOOSE WIRING AND IS WORKING TO DIAGNOSE THE EXACT WIRING ISSUE CAUSING THE PROBLEM. THERE SEEM TO BE MANY PEOPLE ONLINE WITH THE SAME STALLING ISSUE. IN ADDITION TO THE STALLING, THE VEHICLE HAS ALSO BEEN SURGING SPORADICALLY. IT SURGES FORWARD (OR BACKWARD) WITHOUT THE ACCELERATOR BEING PRESSED. IT APPEARS THAT MY VEHICLE IS NOT THE ONLY ONE AFFECTED BY THIS PROBLEM. FORD NEEDS TO BE HELD ACCOUNTABLE FOR THE PRECARIOUS POSITION THEY ARE PUTTING VEHICLE OWNERS IN.

AS I WAS PARKING IN A PARKING GARAGE, THE CAR SURGED FORWARD. IT HAPPENED OCCASIONALLY OVER THE NEXT YEAR, BUT DURING THE PAST YEAR IT BECAME MORE FREQUENT AND PRONOUNCED. I WOULD NEED TO PUT IT IN PARK AT RED LIGHTS TO INSURE I DID NOT LURCH FORWARD INTO THE CAR IN FRONT OF ME. WE TOOK IT TO A FORD DEALERSHIP AND FOR ALMOST $900 THEY REPLACED THE THROTTLE CONTROL. THE PROBLEM STILL EXISTS, BUT NOT AS PRONOUNCED OR FREQUENT. HOWEVER NEW SYMPTOMS APPEARED INCLUDING INTERMITTENTLY DIMMING DASHBOARD LIGHTS AND THE AIR CONDITIONER BEGAN TO SURGE UP AND DOWN ALMOST AS IF IT WERE GASPING FOR AIR. THIS LUNGING FORWARD WHEN YOUR FOOT IS ON THE BRAKE OR YOU ARE AT A MINIMAL SPEED COULD BE DANGEROUS.

DEFECTIVE ELECTRONIC THROTTLE BODY (ETB) ON 2005 FORD 500, FREESTYLE, AND MERCURY MONTEGO. CAUSES CAR TO MOVE FORWARD OR BACKWARD IN DRIVE OR REVERSE WITHOUT USING ANY PRESSURE ON THE GAS PEDAL. MUST PLACE FOOT ON THE BRAKE TO AVOID RUNNING INTO SOMETHING, ESPECIALLY WHILE PARKING. FORD HAS A TECHNICAL SERVICE BULLETIN (TSB 05-25-13) ON THIS BUT HAS NOT NOTIFIED ANY OWNERS OF VEHICLES AFFECTED TO DATE. IT APPEARS THAT FORD HAS COME UP WITH A NEW REPLACEMENT PART FOR THE ETB UNLIKE THE ORIGINAL THAT WAS JUST MADE AVAILABLE IN JULY 2010. I PAID A LOCAL FORD DEALER $128.08 TO HAVE THIS PROBLEM DIAGNOSED AND ANOTHER $615.83 TO HAVE IT FIXED. I WAS TOLD THE ETB PART NUMBER WAS "5F9Z-9E926-AA". ANOTHER NUMBER FOR THE NEW ETB PART ON MY SALES SLIP DATED 07/30/10 WAS FMC 6F9Z 9E926 A. THEY CALLED IT A KIT FOR THE ELECTRONIC THROTTLE BODY. THE PRICE FOR THE KIT WAS $495.86. SINCE I HAVE HEARD OF THIS PROBLEM COMING UP ON MORE THAN ONE OCCASION, I THOUGHT I WOULD TURN IT IN FOR YOUR INVESTIGATION. SINCE THE AFFECT OF THE DEFECTIVE ETB ACTUALLY CAN CAUSE THE CAR TO MOVE ON ITS OWN, FORWARD OR REVERSE, AND REQUIRES YOU TO USE YOUR BRAKES SIMULTANEOUSLY TO KEEP IT FROM HITTING ADJOINING OBJECTS, I THOUGHT THIS IS A SAFETY HAZARD THAT SHOULD BE ADDRESSED ON SEVERAL FORD AND MERCURY 2005 PRODUCTS, IT IS NOT THE MONEY, IT IS THE SAFETY ISSUE I AM MOST INTERESTED IN. TO PARALLEL PARK OR GET INTO A PARKING STALL WITH THIS PROBLEM WAS A REAL CHORE KEEPING YOU FOOT ON THE BRAKE AS YOU TRIED TO MANEUVER IN AND OUT OF A PARKING SPACE. IF YOU DID NOT HOLD YOUR FOOT ON THE BRAKE, THE CAR WOULD MOVE IN ITS OWN EITHER IN DRIVE OR REVERSE. THIS IS NOT ACCEPTABLE AND A TRUE SAFETY HAZARD, BUT I HAVE NOT SEEN THE PROBLEM ON THE RECALL LISTS FOR MY CAR OR OTHERS AFFECTED IN THE FORD TSB. NOR HAVE AUTO OWNERS BEEN NOTIFIED BY FORD OR OFFERED COMPENSATION FOR THE EXPENSE TO HAVE THE KIT INSTALLED.

PURCHASED 2005 FORD 500 NEW ON OCT 11, 2005. AT FIRST OIL CHANGE 3000 MILES ON JAN 10, 2006 I REPORTED VIBRATION AND POPPING ON RIGHT FRONT OF CAR. THEY REPLACED UPPER STRUT MOUNTS/BEARINGS. VIBRATION CONTINUED. ON MARCH 7, 2006 A TIRE SPECIALIST STATED TIRES WERE SHOWING LIGHT CHOPPING ON THE OUTER EDGES AND THE RIGHT FRONT TIRE HAD IT. MARCH 8, 2006 RETURNED TO DEALERSHIP REPORTED THE VIBRATION AGAIN-NOTHING DONE. TIRES CHECKED. MAY 30, 2006 REPORTED VIBRATION. DID ROAD FORCE BALANCE . VIBRATION CONTINUED. AUG 8, 2006 TOLD THE MGR ABOUT THE VIBRATION AGAIN. WEEK OF OCT 9 THE MGR SAID NOTHING MORE COULD BE DONE. MGR SAID HIS SERVICE REP WOULD NOT BE BACK FOR 2-3 MONTHS. I ASKED THE MANAGER IF I COULD CONTACT HIS SERVICE REP AND HE SAID NO. OCT 19, 2006 CALLED BILL MCCORT, TOOK CAR TO THE GARAGE AGAIN. TEST DROVE WITH BILL MCCORT, JOE ESSEX, TECH, MY HUSBAND, AND MYSELF. TECH CONFIRMED THE VIBRATION. CAR LEFT AT DEALERSHIP.. SCOTT VASKO, ASST. SERVICE MGR. CALLED AND TOLD US ALL READINGS WERE WITHIN SPECS. SAID THEY DID FOUR HOOK-UPS FOR TESTING. STILL VIBRATING. OCT 19, 2006 BILL MCCORT AUTHORIZED THE CONTINENTAL TIRES BE REPLACED BY NEW MICHELIN TIRES. STILL VIBRATING AFTER NEW TIRES WERE PUT ON. OCT 20, 2006 MET PHYLLIS STOVES AND, OWNER OF DEALERSHIP. SHE DROVE MY CAR AND FELT VIBRATION. OCT 21, 2006 STOVES AND, MY HUSBAND , AND MYSELF DROVE TWO 2007 FORD FIVE HUNDREDS. THEY HAD THE SAME VIBRATION. STOVES SAID SHE WOULD E-MAIL AN ENGINEER AND WILL CONTACT US WEEK AFTER NEXT STOVES CALLED ME AND ASKED ME TO BRING THE CAR TO THE DEALERSHIP BECAUSE AN ENGINEER WAS COMING TO LOOK AT MY CAR. I WAS NOT ALLOWED TO SEE OR TALK TO THE ENGINEER. STOVES SAID CUSTOMERS ARE NOT ALLOWED TO MEET WITH OR TALK TO THE ENGINEER. LATER STOVES CALLED AND TOLD ME SHE AND THE ENGINEER DROVE MY CAR AND IT DROVE WONDERFULLY. VIBRATION CONTINUES. I ONCE AGAIN REPORTED JAN 4, 2007. *JB