I WAS DRIVING MY CAR IT STARTED TO SHAKE VERY HARD WELL I HEARD A SNAP SOUND AND MY CAR STARTED TO DRAG I GOT OUT MY FRAME ABOVE MY RIGHT LOWER CONTROL HAD SNAPPED IVE READ THAT MANY OTHER PEOPLE ARE HAVING THE SAME PROBLEM I CONTACTES FORD ABOUT THE ISSUE AND THEY SAID THERE IS NOTHING THEY CAN DO WELL I'M OUT OF A VEHICLE BUT …
Read full complaint
I WAS DRIVING MY CAR IT STARTED TO SHAKE VERY HARD WELL I HEARD A SNAP SOUND AND MY CAR STARTED TO DRAG I GOT OUT MY FRAME ABOVE MY RIGHT LOWER CONTROL HAD SNAPPED IVE READ THAT MANY OTHER PEOPLE ARE HAVING THE SAME PROBLEM I CONTACTES FORD ABOUT THE ISSUE AND THEY SAID THERE IS NOTHING THEY CAN DO WELL I'M OUT OF A VEHICLE BUT VEFORE ALL OF THIS I KEPT GOING THROUGH FUEL RELAY ISSUES AND EVENTUALLY STARTED LOSING MY INSTRUMENT CLUSTER SO NOW I'M FIGHTING WITH THEM TO DO THE REPAIRS
NHTSA ODI #11309959
Mileage unknown · May 23, 2019
Unknown Or Other
AS WE WERE DRIVING ON THE FREEWAY OUR SUNROOF EXPLODED CRACKING ALL THE GLASS. LUCKLEY THE PROTECTOR WAS CLOSED. IT SHOWED A BUMP LIKE SHAPE WITH THE CENTER CRACKED OPEN.
NHTSA ODI #11209461
87,414 miles · Mar 31, 2019
Unknown Or Other
"TAKATA RECALL" DRIVER SIDE FRONT DOOR WON'T LATCH CLOSE UNTIL CAR IS WARM UP I SPRAYED IT WITH WD40 THIS IS THE SECOND TIME IT DID IT TO ME. CAR WAS PARKED
NHTSA ODI #11192702
131,000 miles · Sep 13, 2018
Unknown Or Other
THE SHIFT CABLE IS BURNT AT THE END. THE GEAR SHIFT STARTED GOING FROM NETURAL AS DRIVE AND REVERSE WAS BETWEEN PARK N REVERSE. THE SHOP WAS GOING TO AJUST THE LINKAGE BUT UPON LOOKING FOUND THE CABLE WAS BURNT.. IT WAS ALSO MAKING A CLICKING SOUND WHEN IN PARK. WHICH WAS ACTUALLY SPARKING THE CABLE SOMEHOW. PARK WILL ROLL SO U …
Read full complaint
THE SHIFT CABLE IS BURNT AT THE END. THE GEAR SHIFT STARTED GOING FROM NETURAL AS DRIVE AND REVERSE WAS BETWEEN PARK N REVERSE. THE SHOP WAS GOING TO AJUST THE LINKAGE BUT UPON LOOKING FOUND THE CABLE WAS BURNT.. IT WAS ALSO MAKING A CLICKING SOUND WHEN IN PARK. WHICH WAS ACTUALLY SPARKING THE CABLE SOMEHOW. PARK WILL ROLL SO U HAVE TO USE PARKING BREAK.
NHTSA ODI #11129239
1,420,000 miles · Aug 27, 2017
Unknown Or Other
AC COMPRESS WENT OUT AT 99804, NOW WITH 1420000 THE AC COMPRESS IS BAD AGAIN.
NHTSA ODI #11019977
204,000 miles · Feb 9, 2017
Air BagsUnknown Or Other
MY 2005 FORD 500 SOME TIMES THE DASH QUITS WORKING RADIO HEAT THAT STUFF IS FINE BUT THE DASH IT'S SELF RPM SPEEDOMETOR GAS GAUGE ALL THE DASH QUITS AND WHEN THAT HAPPENS THE AIRBAG LIGHT COMES ON BECAUSE WHEN THE DASH QUITS SO DOES THE AIRBAGS THAT IS A SAFTEY AND SHOULD BE A RECALL
NHTSA ODI #10953663
Mileage unknown · Dec 9, 2016
Unknown Or OtherWheels
WHILE DRIVING ON THE FREEWAY GOING THE SPEED LIMIT I CHANGED LANES AND THE REAR OF THE CAR FISHED TAILED. IT HAPPENED SO FAST IT SCARED ME TO DEATH. I WAS VERY LUCKY TO GET THE CAR UNDER CONTROL. IT WAS NOT RAINING AND SOME WHAT HEAVY TRAFFIC AT THE TIME. THE CAR DOES NOT MANEUVER WELL. I HAVE TO BE CAREFUL WHILE CHANGING LAN…
Read full complaint
WHILE DRIVING ON THE FREEWAY GOING THE SPEED LIMIT I CHANGED LANES AND THE REAR OF THE CAR FISHED TAILED. IT HAPPENED SO FAST IT SCARED ME TO DEATH. I WAS VERY LUCKY TO GET THE CAR UNDER CONTROL. IT WAS NOT RAINING AND SOME WHAT HEAVY TRAFFIC AT THE TIME. THE CAR DOES NOT MANEUVER WELL. I HAVE TO BE CAREFUL WHILE CHANGING LANES AND DO IT SLOWLY OR THE CAR JERKS QUICKLY AND NOT SMOOTH AS MY OTHER CARS I'VE OWNED.
NHTSA ODI #10934280
139,000 miles · Sep 4, 2016
Unknown Or Other
DRIVING WHEN THE CALL RPM DROP AND ABS GOES OUT CAR WON'T EXCELERATE "FAILSAFE ENGINE MODE " IS WHAT IT SAYS N MY CHECK ENGINE LIGHT AND ABS LIGHT AND RENCH LIGHT ON, HAD TO PULL OVER AND SHUT OFF AND TURN BACK ON. CLEANED THE THROTTLE BODY AND REPROGRAMED THE COMPUTER AND IT CONTINUES TO HAPPEN AT RANDOM AND WILL RANDOMLY EXCE…
Read full complaint
DRIVING WHEN THE CALL RPM DROP AND ABS GOES OUT CAR WON'T EXCELERATE "FAILSAFE ENGINE MODE " IS WHAT IT SAYS N MY CHECK ENGINE LIGHT AND ABS LIGHT AND RENCH LIGHT ON, HAD TO PULL OVER AND SHUT OFF AND TURN BACK ON. CLEANED THE THROTTLE BODY AND REPROGRAMED THE COMPUTER AND IT CONTINUES TO HAPPEN AT RANDOM AND WILL RANDOMLY EXCELERATE ON ITS OWN WITH RPMS RISING AND YET I'M NO WHERE NEAR GAS PEDAL, I'M ON BRAKES. AS MY INSTRUMENT PANEL WILL MALFUNCTION AND ALL GAUGES WILL GO TO ZERO AND WIGGLE AND ALL WARNING LIGHTS WILL BE DISPLAYED THEM GOES COMPLETELY BLACK, THIS HAS ALSO BEEN VERY UNSAFE OF AN ISSUE BECAUSE AT NIGHT WHEN THIS HAPPENS YOU CAN'T SEE YOUR SPEND OR GAS OR ANYTHING. AND THE FAIL-SAFE MODE ALSO HAS ALMOST CAUSE ME TO HAVE CRASHED AS WELL AS BEEN CRASHED INTO OVER FOUR DOZEN TIMES. SEEING HOW I PAY FOR IT TO BE FIXED AND NOTHING CAN'T SEEM TO FIX IT ... IT'S VERY SCARY AND I WORRY FOR MY LIFE EACH TIME I DRIVE
NHTSA ODI #10903582
97,000 miles · Jun 4, 2016
Unknown Or Other
THE AIR CONDITIONING SYSTEM WILL ONLY BLOW WARM AIR IF THE RPM IS BELOW ABOUT 2000. THE HIGHER THE RPM THE COLDER THE AIR. IT IS NOT THE REFRIGERANT BEING LOW AS I HAVE CHECKED IT. I'VE HEARD FROM MANY ONLINE SOURCES THAT IT IS A VALVE INSIDE THE COMPRESSOR AND THAT IT SEEMS TO BE A COMMON PROBLEM WITH THE FIVE HUNDRED. GIVEN TH…
Read full complaint
THE AIR CONDITIONING SYSTEM WILL ONLY BLOW WARM AIR IF THE RPM IS BELOW ABOUT 2000. THE HIGHER THE RPM THE COLDER THE AIR. IT IS NOT THE REFRIGERANT BEING LOW AS I HAVE CHECKED IT. I'VE HEARD FROM MANY ONLINE SOURCES THAT IT IS A VALVE INSIDE THE COMPRESSOR AND THAT IT SEEMS TO BE A COMMON PROBLEM WITH THE FIVE HUNDRED. GIVEN THAT IT SEEMS TO BE A COMMON PROBLEM, FORD SHOULD ISSUE A RECALL TO FIX THE ISSUE.
NHTSA ODI #10872476
35,000 miles · Jan 11, 2016
Unknown Or Other
TAKATA RECALL DOOR LATCHES AND LINKS. AS LIKE ALL THE OTHER COMPLAINTS WHEN IT GETS COLD MY DOOR WILL OPEN BUT IT WILL NOT CLOSE. WHEN IT FIRST OCCURRED MY DOOR FLEW OPEN WHILE I WAS DRIVING. I LOOKED UP THE RECALL BUT MY VIN NUMBER WAS NOT INCLUDED THIS DOES NOT MAKE ANY SENSE TO ME.ON A CITY STREET AT 6:00 IN THE MORNING.
ON CERTAIN PASSENGER VEHICLES CURRENTLY REGISTERED IN THE FOLLOWING STATES: ALASKA, COLORADO, CONNECTICUT, DELAWARE, IDAHO, ILLINOIS, INDIANA, IOWA, KANSAS, KENTUCKY, MAINE, MARYLAND, MASSACHUSETTS, MICHIGAN, MINNESOTA, MISSOURI, MONTANA, NEBRASKA, NEW HAMPSHIRE, NEW JERSEY, NEW YORK, NORTH DAKOTA, OHIO, PENNSYLVANIA, RHODE ISLAND, SOUTH DAKOTA, UTAH, VERMONT, WEST VIRGINIA, WISCONSIN, AND WYOMING. THE SIDE DOOR LATCH MECHANISMS MAY EXPERIENCE WATER INTRUSION ALLOWING THE LATCH MECHANISM TO FREEZE IN COLD WEATHER.
Consequence & remedy
Consequence: AS A RESULT, THE DOOR LATCH PAWL MAY NOT RETURN TO THE LATCH POSITION WHEN THE DOOR IS CLOSED, AND THE DOOR COULD OPEN WHILE THE VEHICLE IS MOVING.
Remedy: DEALERS WILL INSTALL A SHIELD OVER THE FRONT LATCHES; SEAL A DRAIN HOLE IN THE REAR WINDOW TRIM MOLDING ON THE FREESTYLE REAR SIDE DOORS; AND APPLY GREASE TO ALL FRONT AND REAR SIDE-DOOR LATCH MECHANISMS FREE OF CHARGE. THE RECALL BEGAN ON NOVEMBER 8, 2006. OWNERS MAY CONTACT FORD AT 1-800-392-3673.
ON CERTAIN PASSENGER VEHICLES, THE STRAPS THAT SECURE THE FUEL TANK TO THE VEHICLE BODY MAY BREAK, CAUSING THE FUEL TANK AND FUEL TANK HEAT SHIELD TO DROP ON THE DRIVESHAFT (ALL WHEEL DRIVE VEHICLES) OR EXHAUST SYSTEM (FRONT WHEEL DRIVE VEHICLES).
Consequence & remedy
Consequence: IF THIS HAPPENS, DRIVERS MAY NOTICE A NOISE OR A FUEL LEAK. A FUEL LEAK IN THE PRESENCE OF AN IGNITION SOURCE COULD RESULT IN A FIRE.
Remedy: DEALERS WILL REPLACE BOTH FUEL TANK STRAPS. THE RECALL BEGAN ON DECEMBER 1, 2005. OWNERS MAY CONTACT FORD AT 1-800-392-3673.
Model-level recall history does not show whether a particular VIN is affected or has received a repair. Check a VIN with NHTSA ↗
NHTSA investigations
2
PE11018 · Idle Instability
Opened May 11, 2011 · Closed Feb 7, 2013
Status: closed (inferred from source dates) · Vehicle Speed Control
On November 29, 2012, Ford Motor Company (Ford) initiated Customer Satisfaction Program 12N03 to extend warranty coverage terms for repair of engine idle RPM surge caused by throttle body deposits in all model year (MY) 2005 through 2007 Ford Freestyle, Five Hundred and Mercury Montego vehicles.The program extends the coverage for up to 10 years of service or 150,000 miles from the warranty start date of the vehicle (all vehicles are eligible for the program through May 31, 2013, regardless of mileage).Dealers will repair vehicles exhibiting the condition by removing and cleaning the throttle body and reprogramming the PCM with software containing an updated idle speed control strategy.According to Ford, some of the affected vehicles may experience momentary, intermittent engine idle RPM surge (idle flare) when stopped or during low speed driving maneuvers such as in a parking lot or driveway.Unstable idle speed control (dips and flares) around the target engine speed (700 rpm) can occur in vehicles with deposit build-up in the throttle body when the system adjusts engine speed in response to changes in engine load, typically from power steering application or air-conditioner compressor cycling.Idle speed control logic is only active at vehicle speeds below 3.5 mph and when the accelerator pedal is not applied.Ford testing of a vehicle with a worst case throttle body measured a maximum idle flare of 1360 RPM lasting approximately 1 second, which Ford indicated was consistent with system design to limit vehicle speed and acceleration in idle control mode.Ford indicated that the test vehicle was held in place with normal brake effort and that vehicle speed remained under 4 mph without the brake pedal applied.In addition to throttle body deposit accumulation, symptoms associated with the condition may include Check Engine lamp illumination and diagnostic trouble codes (DTCs) P0505, P0506 or P061B.Ford attributed the surge condition to changes in idle air flow resulting from the progressive buildup of deposits in the throttle body from normal Positive Crankcase Ventilation (PCV) system operation.This condition was not adequately compensated for in the original Powertrain Control Module (PCM) calibration.Ford issued a technical service bulletin on August 15, 2011 (TSB 11-8-5), releasing an updated powertrain control calibration for vehicles with CVT transmissions.On October 19, 2011, Ford issued a second bulletin (TSB 11-10-21) superseding TSB 11-8-5 and including updated powertrain control calibration for vehicles with 6-speed transmissions.Prior to Ford issuing the TSB?s, owner?s experiencing the alleged defect either received no repairs, if dealers could not duplicate the condition, or had the throttle body cleaned or replaced, which only provided temporary correction until the throttle deposit build-up returned.Ford?s revised powertrain calibrations appear to be effective remedies for the idle instability caused by build-up of throttle body deposits.However, even after the TSB?s were released, many owners experiencing the condition continued to have difficulty with proper diagnosis and repair as dealers were often either unable to duplicate the condition or were unfamiliar with the new repair procedures.Ford's new program addresses those concerns.NHTSA's testing and complaint analysis indicate that the idle speed control issue in the subject vehicles can only occur at very low speeds, are very brief events, are easily controlled by moderate brake pedal forces and result in minor increases in vehicle speed even with no braking.This investigation is closed.The closing of this in
THE SUBJECT VEHICLES EXPERIENCE A LOSS OF PROPER INSTRUMENT CLUSTER OPERATION.TYPICALLY, THE PROBLEM APPEARS AS THE NEEDLE ON THE GAUGE (SPEEDOMETER, TACHOMETER, FUEL, AND/OR TEMPERATURE) SWEEPS AND RESETS INTERMITTENTLY.FORD REPORTS THE PROBLEM AS MOMENTARY POWER INTERRUPTION CAUSES THE GAUGES TO SWEEP AND THEN RECOVER TO NORMAL FUNCTION.IN AUGUST 2006, FORD ISSUED A TECHNICAL SERVICE BULLETIN (TSB 06-17-9) TO PROVIDE GUIDELINES TO SERVICE TECHNICIANS FOR DIAGNOSIS AND REPAIR OF THIS CONDITION.ODI'S REVIEW OF FORD'S RESPONSE TO THE AGENCY'S INFORMATIONREQUEST LETTER REVEALS THAT THE MAJORITY OF THE REPORTS TO FORD (63%) INDICATE THAT THE INSTRUMENT CLUSTER WOULD EXPERIENCE INTERMITTENT LOSS OF POWER.FORD REPORTS THAT THISLASTS FOR ONLY A FEW SECONDS.ALSO FORD STATES, THE VEHICLE'S EXTERIOR LIGHTING WOULD NOT FAIL TO ILLUMINATE EVEN IN THE EVENT OF POWER INTERRUPTION TO THE CLUSTER BECAUSE THE EXTERIOR LIGHTS ARE POWERED SEPARATELY AND DO NOT RELY ON ANY SIGNAL FROM THE CLUSTER.ADDITIONALLY, ODI CONTACTED COMPLAINANTS WHO AFFIRMED THE INTERMITTENT CONDITION AND THAT NONE OF THE EXTERIOR LIGHTS ON THE SUBJECT VEHICLES WOULD BE AFFECTED BY POWER INTERRUPTIONS TO THE INSTRUMENT CLUSTER.ODI LAST RECEIVED A REPORT REGARDING THIS ISSUE IN AUGUST OF 2007.THE CLOSING OF THIS INVESTIGATION DOES NOT CONSTITUTE A FINDING BY NHTSA THAT A SAFETY-RELATED DEFECT DOES NOT EXIST.FURTHER USE OF AGENCY RESOURCES DOES NOT APPEAR TO BE WARRANTED AT THIS TIME.ODI WILL HOWEVER CONTINUE TO MONITOR THE ISSUE AND WILL TAKE FURTHER ACTION IF WARRANTED BY THE CIRCUMSTANCES.
2005 Ford Five Hundred Problems, Complaints & Recalls | Skip That Year
Illustration