Power Train. Review the 136 owner reports in this category and discuss these concerns during a pre-purchase inspection. Read reports →
Vehicle Speed Control. Review the 104 owner reports in this category and discuss these concerns during a pre-purchase inspection. Read reports →
Electrical System. Review the 95 owner reports in this category and discuss these concerns during a pre-purchase inspection. Read reports →

NHTSA owner reports · September 18, 2026 snapshot.

20 crash reports6 fire reports10 injury reports

Service Brakes complaints

3 reports

Clear category filter

110,000 miles · May 18, 2016

Electrical SystemFuel/propulsion SystemService Brakes

I DONT FEEL SAFE DRIVING MY CAR I PUT 2000 DOLLARS OF WORK AND STILL DO NOT FEEL SAVE.

NHTSA ODI #10865576

74,000 miles · Aug 13, 2014

EngineService BrakesSteering

TRIED TO PULL OUT ON TO HWY. THE FAIL SAFE LIGHT CAME ON AND SHUT DOWN ENGINE. COULD NOT STEER OR CONTROL CAR AT ALL, WAS VERY CLOSE TO HAVING A BAD ACCIDENT. *TR

NHTSA ODI #10622073

95,000 miles · Jun 22, 2012

EngineService BrakesSteering

Read full complaint

WHILE STUCK IN RUSH HOUR TRAFFIC, CAR WAS AT A COMPLETE STOP AT A RED LIGHT. WHEN TRYING TO LET OFF THE GAS, THE CAR LURCHED FORWARD ALMOST PLOWING INTO THE CAR IN FRONT OF ME. THIS OCCURRED ON 06/20/2012. DURING SUMMER 2011, THIS SAME TYPE OF BEHAVIOR OCCURRED 4 DIFFERENT TIMES. THE ENTIRE PROCESS BEGINS WITH THE CAR BEING AT A COMPLETE STOP, THEN WHEN LETTING OFF THE GAS, THE CAR'S ENGINE REV'S AND THE CAR LURCHES FORWARD REQUIRING THE DRIVER TO SLAM ON THE BREAKS FROM HITTING OTHER DRIVERS/PEDESTRIANS. WHEN THE VEHICLE DOES THIS LURCHING FORWARD MOTION, SEVERAL RED LIGHTS COME ON THE INSTRUMENT PANEL AND ALSO THE COMPUTER READS AN ERROR OF "FAILSAFE ENGINE MODE". POWER STEERING, POWER BRAKES HAVE BEEN LOST WHILE THIS EVENT OCCURS AS WELL. SEEMS AS IF IT COULD BE AFFECTED BY WARMER WEATHER BECAUSE I HAVE OWNED THE VEHICLE TWO YEARS AND HAVE ONLY HAD THIS HAPPEN DURING WARMER (90 DEGREE OR MORE) WEATHER. DURING SUMMER 2011, TWO OCCURRENCES HAPPENED THAT ALSO ALMOST CAUSED COLLISIONS. THE FIRST TIME WAS ON A SUMMER NIGHT IN A PARKING GARAGE. AS I WAS COMING INTO A STOP IN A PARKING SPACE, THE ENGINE LURCHED FORWARD AND CAME APPROXIMATELY 4-5 INCHES FROM HITTING A CONCRETE WALL. DURING THE OTHER OCCURRENCE, I WAS STOPPING AT A RED LIGHT AND CAME CLOSE TO RUNNING OVER A PEDESTRIAN DUE TO LURCHING FROM CAR. WHEN CAR ENTERS "FAILSAFE ENGINE MODE' AND LURCHES FORWARD, CAR MUST BE PARKED AND RESTARTED FOR THE VEHICLE TO RUN NORMALLY AGAIN. ALSO, IT ONLY HAPPENS AT LOW SPEEDS (I.E. WHEN SLOWING THE CAR BELOW 5 MPH OR FIRST BEGINNING TO ACCELERATE THE CAR WHILE STILL BELOW 5 MPH). OTHER OWNERS THAT HAVE EXPERIENCED THIS SAME ISSUE CAN BE FOUND HERE: HTTP://WWW.FORDTAURUS.NET/FORUMS/VIEWTOPIC.PHP?F=5&T=9366 AND ALSO: HTTP://WWW.ABOUTAUTOMOBILE.COM/COMPLAINT/2007/FORD/FIVE+HUNDRED/10439966 *TT

NHTSA ODI #10462801

Official recalls

06V383000 · Latches/locks/linkages:doors:latch

Oct 5, 2006

ON CERTAIN PASSENGER VEHICLES CURRENTLY REGISTERED IN THE FOLLOWING STATES: ALASKA, COLORADO, CONNECTICUT, DELAWARE, IDAHO, ILLINOIS, INDIANA, IOWA, KANSAS, KENTUCKY, MAINE, MARYLAND, MASSACHUSETTS, MICHIGAN, MINNESOTA, MISSOURI, MONTANA, NEBRASKA, NEW HAMPSHIRE, NEW JERSEY, NEW YORK, NORTH DAKOTA, OHIO, PENNSYLVANIA, RHODE ISLAND, SOUTH DAKOTA, UTAH, VERMONT, WEST VIRGINIA, WISCONSIN, AND WYOMING. THE SIDE DOOR LATCH MECHANISMS MAY EXPERIENCE WATER INTRUSION ALLOWING THE LATCH MECHANISM TO FREEZE IN COLD WEATHER.

Consequence & remedy

Consequence: AS A RESULT, THE DOOR LATCH PAWL MAY NOT RETURN TO THE LATCH POSITION WHEN THE DOOR IS CLOSED, AND THE DOOR COULD OPEN WHILE THE VEHICLE IS MOVING.

Remedy: DEALERS WILL INSTALL A SHIELD OVER THE FRONT LATCHES; SEAL A DRAIN HOLE IN THE REAR WINDOW TRIM MOLDING ON THE FREESTYLE REAR SIDE DOORS; AND APPLY GREASE TO ALL FRONT AND REAR SIDE-DOOR LATCH MECHANISMS FREE OF CHARGE. THE RECALL BEGAN ON NOVEMBER 8, 2006. OWNERS MAY CONTACT FORD AT 1-800-392-3673.

05V515000 · Fuel System, Gasoline:storage:tank Assembly:mounting

Nov 9, 2005

ON CERTAIN PASSENGER VEHICLES, THE STRAPS THAT SECURE THE FUEL TANK TO THE VEHICLE BODY MAY BREAK, CAUSING THE FUEL TANK AND FUEL TANK HEAT SHIELD TO DROP ON THE DRIVESHAFT (ALL WHEEL DRIVE VEHICLES) OR EXHAUST SYSTEM (FRONT WHEEL DRIVE VEHICLES).

Consequence & remedy

Consequence: IF THIS HAPPENS, DRIVERS MAY NOTICE A NOISE OR A FUEL LEAK. A FUEL LEAK IN THE PRESENCE OF AN IGNITION SOURCE COULD RESULT IN A FIRE.

Remedy: DEALERS WILL REPLACE BOTH FUEL TANK STRAPS. THE RECALL BEGAN ON DECEMBER 1, 2005. OWNERS MAY CONTACT FORD AT 1-800-392-3673.

Model-level recall history does not show whether a particular VIN is affected or has received a repair. Check a VIN with NHTSA ↗

NHTSA investigations

PE11018 · Idle Instability

Opened May 11, 2011 · Closed Feb 7, 2013

Status: closed (inferred from source dates) · Vehicle Speed Control

On November 29, 2012, Ford Motor Company (Ford) initiated Customer Satisfaction Program 12N03 to extend warranty coverage terms for repair of engine idle RPM surge caused by throttle body deposits in all model year (MY) 2005 through 2007 Ford Freestyle, Five Hundred and Mercury Montego vehicles.The program extends the coverage for up to 10 years of service or 150,000 miles from the warranty start date of the vehicle (all vehicles are eligible for the program through May 31, 2013, regardless of mileage).Dealers will repair vehicles exhibiting the condition by removing and cleaning the throttle body and reprogramming the PCM with software containing an updated idle speed control strategy.According to Ford, some of the affected vehicles may experience momentary, intermittent engine idle RPM surge (idle flare) when stopped or during low speed driving maneuvers such as in a parking lot or driveway.Unstable idle speed control (dips and flares) around the target engine speed (700 rpm) can occur in vehicles with deposit build-up in the throttle body when the system adjusts engine speed in response to changes in engine load, typically from power steering application or air-conditioner compressor cycling.Idle speed control logic is only active at vehicle speeds below 3.5 mph and when the accelerator pedal is not applied.Ford testing of a vehicle with a worst case throttle body measured a maximum idle flare of 1360 RPM lasting approximately 1 second, which Ford indicated was consistent with system design to limit vehicle speed and acceleration in idle control mode.Ford indicated that the test vehicle was held in place with normal brake effort and that vehicle speed remained under 4 mph without the brake pedal applied.In addition to throttle body deposit accumulation, symptoms associated with the condition may include Check Engine lamp illumination and diagnostic trouble codes (DTCs) P0505, P0506 or P061B.Ford attributed the surge condition to changes in idle air flow resulting from the progressive buildup of deposits in the throttle body from normal Positive Crankcase Ventilation (PCV) system operation.This condition was not adequately compensated for in the original Powertrain Control Module (PCM) calibration.Ford issued a technical service bulletin on August 15, 2011 (TSB 11-8-5), releasing an updated powertrain control calibration for vehicles with CVT transmissions.On October 19, 2011, Ford issued a second bulletin (TSB 11-10-21) superseding TSB 11-8-5 and including updated powertrain control calibration for vehicles with 6-speed transmissions.Prior to Ford issuing the TSB?s, owner?s experiencing the alleged defect either received no repairs, if dealers could not duplicate the condition, or had the throttle body cleaned or replaced, which only provided temporary correction until the throttle deposit build-up returned.Ford?s revised powertrain calibrations appear to be effective remedies for the idle instability caused by build-up of throttle body deposits.However, even after the TSB?s were released, many owners experiencing the condition continued to have difficulty with proper diagnosis and repair as dealers were often either unable to duplicate the condition or were unfamiliar with the new repair procedures.Ford's new program addresses those concerns.NHTSA's testing and complaint analysis indicate that the idle speed control issue in the subject vehicles can only occur at very low speeds, are very brief events, are easily controlled by moderate brake pedal forces and result in minor increases in vehicle speed even with no braking.This investigation is closed.The closing of this in

PE07058 · Instrument Cluster Failure

Opened Nov 16, 2007 · Closed Mar 11, 2008

Status: closed (inferred from source dates) · Electrical System: Instrument Cluster/panel

THE SUBJECT VEHICLES EXPERIENCE A LOSS OF PROPER INSTRUMENT CLUSTER OPERATION.TYPICALLY, THE PROBLEM APPEARS AS THE NEEDLE ON THE GAUGE (SPEEDOMETER, TACHOMETER, FUEL, AND/OR TEMPERATURE) SWEEPS AND RESETS INTERMITTENTLY.FORD REPORTS THE PROBLEM AS MOMENTARY POWER INTERRUPTION CAUSES THE GAUGES TO SWEEP AND THEN RECOVER TO NORMAL FUNCTION.IN AUGUST 2006, FORD ISSUED A TECHNICAL SERVICE BULLETIN (TSB 06-17-9) TO PROVIDE GUIDELINES TO SERVICE TECHNICIANS FOR DIAGNOSIS AND REPAIR OF THIS CONDITION.ODI'S REVIEW OF FORD'S RESPONSE TO THE AGENCY'S INFORMATIONREQUEST LETTER REVEALS THAT THE MAJORITY OF THE REPORTS TO FORD (63%) INDICATE THAT THE INSTRUMENT CLUSTER WOULD EXPERIENCE INTERMITTENT LOSS OF POWER.FORD REPORTS THAT THISLASTS FOR ONLY A FEW SECONDS.ALSO FORD STATES, THE VEHICLE'S EXTERIOR LIGHTING WOULD NOT FAIL TO ILLUMINATE EVEN IN THE EVENT OF POWER INTERRUPTION TO THE CLUSTER BECAUSE THE EXTERIOR LIGHTS ARE POWERED SEPARATELY AND DO NOT RELY ON ANY SIGNAL FROM THE CLUSTER.ADDITIONALLY, ODI CONTACTED COMPLAINANTS WHO AFFIRMED THE INTERMITTENT CONDITION AND THAT NONE OF THE EXTERIOR LIGHTS ON THE SUBJECT VEHICLES WOULD BE AFFECTED BY POWER INTERRUPTIONS TO THE INSTRUMENT CLUSTER.ODI LAST RECEIVED A REPORT REGARDING THIS ISSUE IN AUGUST OF 2007.THE CLOSING OF THIS INVESTIGATION DOES NOT CONSTITUTE A FINDING BY NHTSA THAT A SAFETY-RELATED DEFECT DOES NOT EXIST.FURTHER USE OF AGENCY RESOURCES DOES NOT APPEAR TO BE WARRANTED AT THIS TIME.ODI WILL HOWEVER CONTINUE TO MONITOR THE ISSUE AND WILL TAKE FURTHER ACTION IF WARRANTED BY THE CIRCUMSTANCES.