NHTSA owner reports · September 18, 2026 snapshot.
Electrical System complaints
95 reportsClear category filterMileage unknown · Mar 9, 2024
Electrical SystemEngine
I am having problem with the reset button in my 2005 five hundred ford, the oil light stays on after oil changes, no one does not know how to reset, the reset button does not work, several mechanic told me not to worry about it , but the car can't pass the smog, it reads not ready, they told my to take a ride for about 50 mil…
Read full complaint
I am having problem with the reset button in my 2005 five hundred ford, the oil light stays on after oil changes, no one does not know how to reset, the reset button does not work, several mechanic told me not to worry about it , but the car can't pass the smog, it reads not ready, they told my to take a ride for about 50 miles and drive up to sixty miles per hour. . On going problem and I am running out of money, can you help, please
NHTSA ODI #11576414
Mileage unknown · Jul 8, 2023
Electrical SystemEngineFuel/propulsion System
The engine keep going into limp mode. The car stalls out while at lights an stop signs, power steering goes out on highway an other roads making it impossible to steer or steer out of others ways, limp mode causes car to not be able to keep up with traffic on highway and other roads. Engine jerks forward an shifts irractically…
Read full complaint
The engine keep going into limp mode. The car stalls out while at lights an stop signs, power steering goes out on highway an other roads making it impossible to steer or steer out of others ways, limp mode causes car to not be able to keep up with traffic on highway and other roads. Engine jerks forward an shifts irractically an shifts an downshifts hard.
NHTSA ODI #11531091
170,000 miles · Feb 16, 2021
Electrical SystemEngineVehicle Speed Control
I WAS AT RED LIGHT PERSON CROSSING ROAD I WAS I. DRIVE FOOT ON BRAKE, RPMS SHOT UP ENGINE REEVES CAT LUNGED FORWARD I PRESSED HARDER IN BRAKE ALMOST HIT PERSON. AT THE TIME NO WARNING LIGHTS. THEN AT PHARMACY DRIVE THRU W CAR I. FROM AND I. BACK OF ME CAR DID SAME THING. I HAD TO PRESS BRAKE HARD TO PREVENT MOVING HITTING CAR IN…
Read full complaint
I WAS AT RED LIGHT PERSON CROSSING ROAD I WAS I. DRIVE FOOT ON BRAKE, RPMS SHOT UP ENGINE REEVES CAT LUNGED FORWARD I PRESSED HARDER IN BRAKE ALMOST HIT PERSON. AT THE TIME NO WARNING LIGHTS. THEN AT PHARMACY DRIVE THRU W CAR I. FROM AND I. BACK OF ME CAR DID SAME THING. I HAD TO PRESS BRAKE HARD TO PREVENT MOVING HITTING CAR IN FROM OF ME. I WAS IN DRIVE BUT FOOT ON BRAKE! NO WARNING LIGHTS AT TIME. HAD THROTTLE BODY REPLACED STILL HAD SIMILAR PROBLEMS PROGRESSING LITTLE DID I KNOW WHEN THROTTLE BODY IS REPLACED HAS TO BE REPROGRAMMED BY FORD! SPENT SO MUCH MONEY AND TIME TRYING TO FIGURE OUT PROBLEM. THIS IS A FLAW W FORD 500 2005 THROTTLE BODY MANY COMPLAINTS AND TEST DOES NEVER ISSUES RECALL, UNSAFE. I COULD HAVE KILLED SOMEONE.
NHTSA ODI #11396488
237,232 miles · Oct 26, 2020
Electrical SystemEnginePower Train
I PURCHASED THE CAR USED WITH THE UNDERSTANDING THAT IT HAD SOME ISSUES WITH A MISFIRE. UPON INITIAL INSPECTION I FOUNT THE CAR WAS THROWING THE CODE P0351 I CLEARED ALL FAULTS AND PROBLEM WENT AWAY WEKS WENT BY AND PROBLEM STARTED AGAIN BUT MORE SEVER DURING NORMAL OPERATION THE CAR STARTED SHAKING AND SHIFTING ERRATIC I THEN C…
Read full complaint
I PURCHASED THE CAR USED WITH THE UNDERSTANDING THAT IT HAD SOME ISSUES WITH A MISFIRE. UPON INITIAL INSPECTION I FOUNT THE CAR WAS THROWING THE CODE P0351 I CLEARED ALL FAULTS AND PROBLEM WENT AWAY WEKS WENT BY AND PROBLEM STARTED AGAIN BUT MORE SEVER DURING NORMAL OPERATION THE CAR STARTED SHAKING AND SHIFTING ERRATIC I THEN CAME UPON SOME K FORMATION AS TO A RECALL FORD PUT IN PLACE STATING IMPROPER CALIBRATION OF PCM AND TCM CAUSE UNNECESSARY INTERACTION I THE ELECTRICAL SYSTEM AND MALFUNCTION OF THE VEHICLE
NHTSA ODI #11366459
Mileage unknown · Feb 18, 2020
Electrical SystemSuspensionUnknown Or Other
I WAS DRIVING MY CAR IT STARTED TO SHAKE VERY HARD WELL I HEARD A SNAP SOUND AND MY CAR STARTED TO DRAG I GOT OUT MY FRAME ABOVE MY RIGHT LOWER CONTROL HAD SNAPPED IVE READ THAT MANY OTHER PEOPLE ARE HAVING THE SAME PROBLEM I CONTACTES FORD ABOUT THE ISSUE AND THEY SAID THERE IS NOTHING THEY CAN DO WELL I'M OUT OF A VEHICLE BUT …
Read full complaint
I WAS DRIVING MY CAR IT STARTED TO SHAKE VERY HARD WELL I HEARD A SNAP SOUND AND MY CAR STARTED TO DRAG I GOT OUT MY FRAME ABOVE MY RIGHT LOWER CONTROL HAD SNAPPED IVE READ THAT MANY OTHER PEOPLE ARE HAVING THE SAME PROBLEM I CONTACTES FORD ABOUT THE ISSUE AND THEY SAID THERE IS NOTHING THEY CAN DO WELL I'M OUT OF A VEHICLE BUT VEFORE ALL OF THIS I KEPT GOING THROUGH FUEL RELAY ISSUES AND EVENTUALLY STARTED LOSING MY INSTRUMENT CLUSTER SO NOW I'M FIGHTING WITH THEM TO DO THE REPAIRS
NHTSA ODI #11309959
172,940 miles · Jul 8, 2019
Electrical SystemFuel/propulsion System
TAKATA RECALL MY CAR HAS A FUEL LEAK PROBLEM AND FUEL TANK IS DAMAGE TO WELD DEFECT CIDE: P04442. ALSO PREVIOUS OWN INSTALLED A AFTERMARKET REMOTE CAR STARTER. NOW MY CAR HAS TROUBLE STARTING EVER AFTER I REPLACED THE STARTER. PROBLEM MIGHT BE THE (ECU) ENGINE CONTROL UNIT NOW WORKING PROPERLY.
NHTSA ODI #11229975
244,141 miles · Jul 12, 2018
Electrical SystemEngine
GAUGES DROP CHECK ENGINE LIGHT COMES ON THEN WRENCH LIGHT THEN ONE SHAPED LIKE A CAR N STARTS LOOSEN POWER
NHTSA ODI #11111035
250,000 miles · Feb 26, 2018
Electrical SystemEngineFire
TL* THE CONTACT OWNS A 2005 FORD FIVE HUNDRED. AFTER PLACING FUEL IN THE VEHICLE, WHITE SMOKE EMERGED FROM THE ENGINE COMPARTMENT. THE CONTACT OPENED THE HOOD AND FLAMES EMERGED FROM THE ENGINE AND THE SMOKE TURNED BLACK. THE FIRE DEPARTMENT EXTINGUISHED THE FIRE; HOWEVER, THE FIRE ERUPTED AGAIN AND WOULD NOT STOP UNTIL THE BATT…
Read full complaint
TL* THE CONTACT OWNS A 2005 FORD FIVE HUNDRED. AFTER PLACING FUEL IN THE VEHICLE, WHITE SMOKE EMERGED FROM THE ENGINE COMPARTMENT. THE CONTACT OPENED THE HOOD AND FLAMES EMERGED FROM THE ENGINE AND THE SMOKE TURNED BLACK. THE FIRE DEPARTMENT EXTINGUISHED THE FIRE; HOWEVER, THE FIRE ERUPTED AGAIN AND WOULD NOT STOP UNTIL THE BATTERY WAS DISCONNECTED. THE VEHICLE WAS TOWED TO THE CONTACT'S RESIDENCE. THE DEALER WAS NOT CONTACTED AND THE MANUFACTURER WAS NOT NOTIFIED OF THE FAILURE. THE APPROXIMATE FAILURE MILEAGE WAS 250,000.
NHTSA ODI #11075023
60,000 miles · Jan 11, 2018
Electrical SystemElectronic Stability Control (esc)Vehicle Speed Control
I HAVE RESEARCHED ONLINE AND A LOT OF PEOPLE WITH MY SAME CAR ARE HAVING THE SAME PROBLEM. WHILE DRIVING MY WHOLE DASH BOARD GOES OUT . I CAN NO LONGER SEE HOW FAST I'M GOING. EVERYTHING GOES TO 0 THE GAS GOES TO E AND MY REVERSE LIGHTS STAY ON UNTIL THE DASH BOARD COMES BACK UP. IF AND WHEN IT COMES BACK ON MY CHECK ENGINE LIGH…
Read full complaint
I HAVE RESEARCHED ONLINE AND A LOT OF PEOPLE WITH MY SAME CAR ARE HAVING THE SAME PROBLEM. WHILE DRIVING MY WHOLE DASH BOARD GOES OUT . I CAN NO LONGER SEE HOW FAST I'M GOING. EVERYTHING GOES TO 0 THE GAS GOES TO E AND MY REVERSE LIGHTS STAY ON UNTIL THE DASH BOARD COMES BACK UP. IF AND WHEN IT COMES BACK ON MY CHECK ENGINE LIGHT WILL BE ON. THIS HAS BEEN HAPPENING EVERY SINCE I PURCHASED THE CAR 3YEARS AGO ON AND OFF.
NHTSA ODI #11062307
177,000 miles · Jul 20, 2016
Electrical SystemEngineFuel/propulsion System
I WILL NEVER BUY ANOTHER FORD VEHICLE EVER AGAIN!!!!!! I OWN A 2005 FORD FIVE HUNDRED THERE WAS A RECALL IN 2012 ON THE THROTTLE BODY, A FORD DEALER SUPPOSABLY CLEANED THE THROTTLE BODY, WELL NOW ITS NOT DRIVEABLE. WE HAVE SINCE TALKED TO SEVERAL FORD DEALERS INCLUDING FORD MOTOR COMPANY , THEY ALL SAID IT WAS OUR RESPONSIBILIT…
Read full complaint
I WILL NEVER BUY ANOTHER FORD VEHICLE EVER AGAIN!!!!!! I OWN A 2005 FORD FIVE HUNDRED THERE WAS A RECALL IN 2012 ON THE THROTTLE BODY, A FORD DEALER SUPPOSABLY CLEANED THE THROTTLE BODY, WELL NOW ITS NOT DRIVEABLE. WE HAVE SINCE TALKED TO SEVERAL FORD DEALERS INCLUDING FORD MOTOR COMPANY , THEY ALL SAID IT WAS OUR RESPONSIBILITY TO FIX THE PROBLEM. I DO NOT THINK IT SHOULD BE MY RESPONSIBILITY TO PAY FOR THIS SINCE THE PART WAS RECALLED !!! THE CAR COULD STALL AT ANYTIME WHILE DRIVING PUTTING MYSELF AND MY FAMILY AT RISK, I DON'T THINK MUCH OF THIS AUTOMOBILE COMPANY FOR NOT STANDING BEHIND THERE PRODUCT, I WILL NEVER RECOMMEND A FORD VEHICLE TO FRIENDS,FAMILY OR EVEN MY WORST ENEMY NEVER NEVER AGAIN!!!!
NHTSA ODI #10886221
Official recalls
2Oct 5, 2006
ON CERTAIN PASSENGER VEHICLES CURRENTLY REGISTERED IN THE FOLLOWING STATES: ALASKA, COLORADO, CONNECTICUT, DELAWARE, IDAHO, ILLINOIS, INDIANA, IOWA, KANSAS, KENTUCKY, MAINE, MARYLAND, MASSACHUSETTS, MICHIGAN, MINNESOTA, MISSOURI, MONTANA, NEBRASKA, NEW HAMPSHIRE, NEW JERSEY, NEW YORK, NORTH DAKOTA, OHIO, PENNSYLVANIA, RHODE ISLAND, SOUTH DAKOTA, UTAH, VERMONT, WEST VIRGINIA, WISCONSIN, AND WYOMING. THE SIDE DOOR LATCH MECHANISMS MAY EXPERIENCE WATER INTRUSION ALLOWING THE LATCH MECHANISM TO FREEZE IN COLD WEATHER.
Consequence & remedy
Consequence: AS A RESULT, THE DOOR LATCH PAWL MAY NOT RETURN TO THE LATCH POSITION WHEN THE DOOR IS CLOSED, AND THE DOOR COULD OPEN WHILE THE VEHICLE IS MOVING.
Remedy: DEALERS WILL INSTALL A SHIELD OVER THE FRONT LATCHES; SEAL A DRAIN HOLE IN THE REAR WINDOW TRIM MOLDING ON THE FREESTYLE REAR SIDE DOORS; AND APPLY GREASE TO ALL FRONT AND REAR SIDE-DOOR LATCH MECHANISMS FREE OF CHARGE. THE RECALL BEGAN ON NOVEMBER 8, 2006. OWNERS MAY CONTACT FORD AT 1-800-392-3673.
Nov 9, 2005
ON CERTAIN PASSENGER VEHICLES, THE STRAPS THAT SECURE THE FUEL TANK TO THE VEHICLE BODY MAY BREAK, CAUSING THE FUEL TANK AND FUEL TANK HEAT SHIELD TO DROP ON THE DRIVESHAFT (ALL WHEEL DRIVE VEHICLES) OR EXHAUST SYSTEM (FRONT WHEEL DRIVE VEHICLES).
Consequence & remedy
Consequence: IF THIS HAPPENS, DRIVERS MAY NOTICE A NOISE OR A FUEL LEAK. A FUEL LEAK IN THE PRESENCE OF AN IGNITION SOURCE COULD RESULT IN A FIRE.
Remedy: DEALERS WILL REPLACE BOTH FUEL TANK STRAPS. THE RECALL BEGAN ON DECEMBER 1, 2005. OWNERS MAY CONTACT FORD AT 1-800-392-3673.
Model-level recall history does not show whether a particular VIN is affected or has received a repair. Check a VIN with NHTSA ↗
NHTSA investigations
2PE11018 · Idle Instability
Opened May 11, 2011 · Closed Feb 7, 2013
Status: closed (inferred from source dates) · Vehicle Speed Control
On November 29, 2012, Ford Motor Company (Ford) initiated Customer Satisfaction Program 12N03 to extend warranty coverage terms for repair of engine idle RPM surge caused by throttle body deposits in all model year (MY) 2005 through 2007 Ford Freestyle, Five Hundred and Mercury Montego vehicles.The program extends the coverage for up to 10 years of service or 150,000 miles from the warranty start date of the vehicle (all vehicles are eligible for the program through May 31, 2013, regardless of mileage).Dealers will repair vehicles exhibiting the condition by removing and cleaning the throttle body and reprogramming the PCM with software containing an updated idle speed control strategy.According to Ford, some of the affected vehicles may experience momentary, intermittent engine idle RPM surge (idle flare) when stopped or during low speed driving maneuvers such as in a parking lot or driveway.Unstable idle speed control (dips and flares) around the target engine speed (700 rpm) can occur in vehicles with deposit build-up in the throttle body when the system adjusts engine speed in response to changes in engine load, typically from power steering application or air-conditioner compressor cycling.Idle speed control logic is only active at vehicle speeds below 3.5 mph and when the accelerator pedal is not applied.Ford testing of a vehicle with a worst case throttle body measured a maximum idle flare of 1360 RPM lasting approximately 1 second, which Ford indicated was consistent with system design to limit vehicle speed and acceleration in idle control mode.Ford indicated that the test vehicle was held in place with normal brake effort and that vehicle speed remained under 4 mph without the brake pedal applied.In addition to throttle body deposit accumulation, symptoms associated with the condition may include Check Engine lamp illumination and diagnostic trouble codes (DTCs) P0505, P0506 or P061B.Ford attributed the surge condition to changes in idle air flow resulting from the progressive buildup of deposits in the throttle body from normal Positive Crankcase Ventilation (PCV) system operation.This condition was not adequately compensated for in the original Powertrain Control Module (PCM) calibration.Ford issued a technical service bulletin on August 15, 2011 (TSB 11-8-5), releasing an updated powertrain control calibration for vehicles with CVT transmissions.On October 19, 2011, Ford issued a second bulletin (TSB 11-10-21) superseding TSB 11-8-5 and including updated powertrain control calibration for vehicles with 6-speed transmissions.Prior to Ford issuing the TSB?s, owner?s experiencing the alleged defect either received no repairs, if dealers could not duplicate the condition, or had the throttle body cleaned or replaced, which only provided temporary correction until the throttle deposit build-up returned.Ford?s revised powertrain calibrations appear to be effective remedies for the idle instability caused by build-up of throttle body deposits.However, even after the TSB?s were released, many owners experiencing the condition continued to have difficulty with proper diagnosis and repair as dealers were often either unable to duplicate the condition or were unfamiliar with the new repair procedures.Ford's new program addresses those concerns.NHTSA's testing and complaint analysis indicate that the idle speed control issue in the subject vehicles can only occur at very low speeds, are very brief events, are easily controlled by moderate brake pedal forces and result in minor increases in vehicle speed even with no braking.This investigation is closed.The closing of this in
PE07058 · Instrument Cluster Failure
Opened Nov 16, 2007 · Closed Mar 11, 2008
Status: closed (inferred from source dates) · Electrical System: Instrument Cluster/panel
THE SUBJECT VEHICLES EXPERIENCE A LOSS OF PROPER INSTRUMENT CLUSTER OPERATION.TYPICALLY, THE PROBLEM APPEARS AS THE NEEDLE ON THE GAUGE (SPEEDOMETER, TACHOMETER, FUEL, AND/OR TEMPERATURE) SWEEPS AND RESETS INTERMITTENTLY.FORD REPORTS THE PROBLEM AS MOMENTARY POWER INTERRUPTION CAUSES THE GAUGES TO SWEEP AND THEN RECOVER TO NORMAL FUNCTION.IN AUGUST 2006, FORD ISSUED A TECHNICAL SERVICE BULLETIN (TSB 06-17-9) TO PROVIDE GUIDELINES TO SERVICE TECHNICIANS FOR DIAGNOSIS AND REPAIR OF THIS CONDITION.ODI'S REVIEW OF FORD'S RESPONSE TO THE AGENCY'S INFORMATIONREQUEST LETTER REVEALS THAT THE MAJORITY OF THE REPORTS TO FORD (63%) INDICATE THAT THE INSTRUMENT CLUSTER WOULD EXPERIENCE INTERMITTENT LOSS OF POWER.FORD REPORTS THAT THISLASTS FOR ONLY A FEW SECONDS.ALSO FORD STATES, THE VEHICLE'S EXTERIOR LIGHTING WOULD NOT FAIL TO ILLUMINATE EVEN IN THE EVENT OF POWER INTERRUPTION TO THE CLUSTER BECAUSE THE EXTERIOR LIGHTS ARE POWERED SEPARATELY AND DO NOT RELY ON ANY SIGNAL FROM THE CLUSTER.ADDITIONALLY, ODI CONTACTED COMPLAINANTS WHO AFFIRMED THE INTERMITTENT CONDITION AND THAT NONE OF THE EXTERIOR LIGHTS ON THE SUBJECT VEHICLES WOULD BE AFFECTED BY POWER INTERRUPTIONS TO THE INSTRUMENT CLUSTER.ODI LAST RECEIVED A REPORT REGARDING THIS ISSUE IN AUGUST OF 2007.THE CLOSING OF THIS INVESTIGATION DOES NOT CONSTITUTE A FINDING BY NHTSA THAT A SAFETY-RELATED DEFECT DOES NOT EXIST.FURTHER USE OF AGENCY RESOURCES DOES NOT APPEAR TO BE WARRANTED AT THIS TIME.ODI WILL HOWEVER CONTINUE TO MONITOR THE ISSUE AND WILL TAKE FURTHER ACTION IF WARRANTED BY THE CIRCUMSTANCES.
Illustration