IllustrationTL*THE CONTACT OWNS A 2005 FORD FIVE HUNDRED. WHILE DRIVING 30 MPH, THE CONTACT REAR ENDED ANOTHER VEHICLE. THE AIR BAGS FAILED TO DEPLOY. THERE WERE NO INJURIES AND THE VEHICLE HAS NOT BEEN DIAGNOSED BY THE DEALER. A POLICE REPORT WAS FILED. THE FAILURE MILEAGE WAS 34,500.
2005 Ford Five Hundred
Owner reports · Recalls · Investigations
Limited comparison data
There is not enough comparable history to draw a useful model-year comparison.
About this comparison →How this year compares
Owner complaints by model year
Compare all Five Hundred years →Counts vary with age, sales and reporting. They are not failure rates.
What owners reported most
All reported categories
Tap a category to read its complaints. One report may name several components.
When problems were reported
Mileage at the reported incident
640–25K
7625–50K
8750–75K
8875–100K
79100–150K
49150K+
443 reports with mileage · 67 unknown
NHTSA’s mileage field refers to the reported incident, not necessarily the filing date. This shows report counts, not the likelihood of a failure.
What to inspect
Issues worth paying extra attention to based on owner reports.
- Power Train. Review the 136 owner reports in this category and discuss these concerns during a pre-purchase inspection. Read reports →
- Vehicle Speed Control. Review the 104 owner reports in this category and discuss these concerns during a pre-purchase inspection. Read reports →
- Electrical System. Review the 95 owner reports in this category and discuss these concerns during a pre-purchase inspection. Read reports →
NHTSA owner reports · September 18, 2026 snapshot.
20 crash reports6 fire reports10 injury reports
Air Bags complaints
15 reportsTL*THE CONTACT OWNS A 2005 FORD FIVE HUNDRED. THE CONTACT STATED THAT THE PASSENGER SIDE AIR BAG OFF LIGHT WAS ILLUMINATED. THE DEALER SEEMED TO IGNORE THE ISSUE AND STATED THAT IT WAS MINIMAL. THE CONTACT'S HUSBAND ATTEMPTED TO BUCKLE HIS SEAT BELT IN THE FRONT PASSENGER SEAT, AND NOTICED THAT THE SEAM AT THE BELT WAS LOOSE.…
Read full complaint
TL*THE CONTACT OWNS A 2005 FORD FIVE HUNDRED. THE CONTACT STATED THAT THE PASSENGER SIDE AIR BAG OFF LIGHT WAS ILLUMINATED. THE DEALER SEEMED TO IGNORE THE ISSUE AND STATED THAT IT WAS MINIMAL. THE CONTACT'S HUSBAND ATTEMPTED TO BUCKLE HIS SEAT BELT IN THE FRONT PASSENGER SEAT, AND NOTICED THAT THE SEAM AT THE BELT WAS LOOSE. THE AIR BAG OFF LIGHT WOULD NOT DIM. THE CONTACT WAS INFORMED THAT THE SEAT BELT WAS CONNECTED TO THE AIR BAG SENSOR. THE VEHICLE WAS REPAIRED AT THE COST OF $129. THE CURRENT MILEAGE WAS 77,000 AND FAILURE MILEAGE WAS 34,000. UPDATED 05/07/08 *BF UPDATED 05/07/08
TL*THE CONTACT'S CLIENT OWNS A 2005 FORD FIVE HUNDRED. WHILE THE CLIENT WAS DRIVING 35 MPH, SHE REMOVED HER FOOT FROM THE ACCELERATOR PEDAL; HOWEVER, THE VEHICLE CONTINUED TO ACCELERATE. SHE ATTEMPTED TO APPLY THE BRAKES, BUT THE SPEED CONTINUED TO INCREASE. THE CLIENT ALSO APPLIED THE EMERGENCY BRAKE AND ENCOUNTERED A PICKUP…
Read full complaint
TL*THE CONTACT'S CLIENT OWNS A 2005 FORD FIVE HUNDRED. WHILE THE CLIENT WAS DRIVING 35 MPH, SHE REMOVED HER FOOT FROM THE ACCELERATOR PEDAL; HOWEVER, THE VEHICLE CONTINUED TO ACCELERATE. SHE ATTEMPTED TO APPLY THE BRAKES, BUT THE SPEED CONTINUED TO INCREASE. THE CLIENT ALSO APPLIED THE EMERGENCY BRAKE AND ENCOUNTERED A PICKUP TRUCK TRAVELING IN THE SAME DIRECTION. SHE CROSSED OVER THE DOUBLE-YELLOW LINE ON A 2-LANE ROAD AND PASSED THE PICKUP TRUCK. THE DRIVER OF THE PICKUP INFORMED POLICE THAT HE NOTICED BRAKES BEING APPLIED, SMELLED, AND SAW BLUE SMOKE COMING FROM THE VEHICLE. THE VEHICLE CONTINUED ACCELERATING. THE AIR BAGS DEPLOYED. THE CLIENT THEN SIDE SWIPED A GUARDRAIL FOR APPROXIMATELY 40 FEET. THE FRONT TIRE BLEW OUT AND THE VEHICLE WAS PUSHED ACROSS THE ROADWAY. A POLICE REPORT WAS FILED. TWO PASSENGERS SUSTAINED INJURIES. THE FRONT END OF THE VEHICLE STRUCK AN EMBANKMENT ON THE OTHER SIDE OF THE ROAD. THE VEHICLE BECAME AIRBORNE FOR APPROXIMATELY 70 FEET AND LANDED ON ITS SIDE. AT THAT TIME, ONLY THE DRIVER'S SIDE AIR BAG DEPLOYED. THE VEHICLE ROLLED OVER TWICE AND LANDED AT A RECENTLY PLANTED FLOWER BED. THE DRIVER SEAT BELT DISENGAGED AS WELL. PART OF THE CRASH WAS CAUGHT ON TAPE BY A PENNSYLVANIA DOT SURVEILLANCE CAMERA. THE CURRENT AND FAILURE MILEAGES WERE 22,000. UPDATED 04/29/08. *LJ
TL* THE CONTACT OWNS A 2005 FORD FIVE HUNDRED. THE AIR BAG INDICATOR LIGHT REMAINED ILLUMINATED. IN MARCH 2007 THE VEHICLE WAS TAKEN TO THE DEALER FOR A DIAGNOSTIC, BUT THE RESULTS SHOWED NO AIR BAG FAILURE. THE VEHICLE HAD BEEN AT THE DEALER SINCE MARCH 27, 2007, AND THEY WERE STILL UNABLE TO DUPLICATE THE FAILURE. THE …
Read full complaint
TL* THE CONTACT OWNS A 2005 FORD FIVE HUNDRED. THE AIR BAG INDICATOR LIGHT REMAINED ILLUMINATED. IN MARCH 2007 THE VEHICLE WAS TAKEN TO THE DEALER FOR A DIAGNOSTIC, BUT THE RESULTS SHOWED NO AIR BAG FAILURE. THE VEHICLE HAD BEEN AT THE DEALER SINCE MARCH 27, 2007, AND THEY WERE STILL UNABLE TO DUPLICATE THE FAILURE. THE CONTACT CALLED THE DEALER ON APRIL 23, 2007, AND WAS INFORMED THAT A PART HAD BEEN ORDERED. THE DEALER DID NOT MENTION THAT THE FAILURE WAS COMMON WITH THE FORD FIVE HUNDREDS. THE VEHICLE WAS TAKEN TO THE DEALER ON THREE OCCASIONS , AND DEALER DETERMINED THAT THE AIR BAG INDICATOR LIGHT DID INDEED REMAIN ILLUMINATED. THE CURRENT MILEAGE IS 23,445, AND FAILURE MILEAGE WAS 23,261.*AK
PURCHASED A NEW FORD FIVE HUNDRED IN OCTOBER OF 2005. I WAS UNFORTUNATELY INVOLVED IN AN ACCIDENT, THAT CAUSED EXTENSIVE DAMAGE TO THE FRONT END OF THE VEHICLE. MY CONCERN IS THAT THE AIR BAGS NEVER DEPLOYED. WITH THE AMOUNT OF DAMAGE I WOULD HAVE THOUGHT THEY WOULD HAVE DEPLOYED. *JB
Official recalls
206V383000 · Latches/locks/linkages:doors:latch
Oct 5, 2006
ON CERTAIN PASSENGER VEHICLES CURRENTLY REGISTERED IN THE FOLLOWING STATES: ALASKA, COLORADO, CONNECTICUT, DELAWARE, IDAHO, ILLINOIS, INDIANA, IOWA, KANSAS, KENTUCKY, MAINE, MARYLAND, MASSACHUSETTS, MICHIGAN, MINNESOTA, MISSOURI, MONTANA, NEBRASKA, NEW HAMPSHIRE, NEW JERSEY, NEW YORK, NORTH DAKOTA, OHIO, PENNSYLVANIA, RHODE ISLAND, SOUTH DAKOTA, UTAH, VERMONT, WEST VIRGINIA, WISCONSIN, AND WYOMING. THE SIDE DOOR LATCH MECHANISMS MAY EXPERIENCE WATER INTRUSION ALLOWING THE LATCH MECHANISM TO FREEZE IN COLD WEATHER.
Consequence & remedy
Consequence: AS A RESULT, THE DOOR LATCH PAWL MAY NOT RETURN TO THE LATCH POSITION WHEN THE DOOR IS CLOSED, AND THE DOOR COULD OPEN WHILE THE VEHICLE IS MOVING.
Remedy: DEALERS WILL INSTALL A SHIELD OVER THE FRONT LATCHES; SEAL A DRAIN HOLE IN THE REAR WINDOW TRIM MOLDING ON THE FREESTYLE REAR SIDE DOORS; AND APPLY GREASE TO ALL FRONT AND REAR SIDE-DOOR LATCH MECHANISMS FREE OF CHARGE. THE RECALL BEGAN ON NOVEMBER 8, 2006. OWNERS MAY CONTACT FORD AT 1-800-392-3673.
05V515000 · Fuel System, Gasoline:storage:tank Assembly:mounting
Nov 9, 2005
ON CERTAIN PASSENGER VEHICLES, THE STRAPS THAT SECURE THE FUEL TANK TO THE VEHICLE BODY MAY BREAK, CAUSING THE FUEL TANK AND FUEL TANK HEAT SHIELD TO DROP ON THE DRIVESHAFT (ALL WHEEL DRIVE VEHICLES) OR EXHAUST SYSTEM (FRONT WHEEL DRIVE VEHICLES).
Consequence & remedy
Consequence: IF THIS HAPPENS, DRIVERS MAY NOTICE A NOISE OR A FUEL LEAK. A FUEL LEAK IN THE PRESENCE OF AN IGNITION SOURCE COULD RESULT IN A FIRE.
Remedy: DEALERS WILL REPLACE BOTH FUEL TANK STRAPS. THE RECALL BEGAN ON DECEMBER 1, 2005. OWNERS MAY CONTACT FORD AT 1-800-392-3673.
Model-level recall history does not show whether a particular VIN is affected or has received a repair. Check a VIN with NHTSA ↗
NHTSA investigations
2PE11018 · Idle Instability
Opened May 11, 2011 · Closed Feb 7, 2013
Status: closed (inferred from source dates) · Vehicle Speed Control
On November 29, 2012, Ford Motor Company (Ford) initiated Customer Satisfaction Program 12N03 to extend warranty coverage terms for repair of engine idle RPM surge caused by throttle body deposits in all model year (MY) 2005 through 2007 Ford Freestyle, Five Hundred and Mercury Montego vehicles.The program extends the coverage for up to 10 years of service or 150,000 miles from the warranty start date of the vehicle (all vehicles are eligible for the program through May 31, 2013, regardless of mileage).Dealers will repair vehicles exhibiting the condition by removing and cleaning the throttle body and reprogramming the PCM with software containing an updated idle speed control strategy.According to Ford, some of the affected vehicles may experience momentary, intermittent engine idle RPM surge (idle flare) when stopped or during low speed driving maneuvers such as in a parking lot or driveway.Unstable idle speed control (dips and flares) around the target engine speed (700 rpm) can occur in vehicles with deposit build-up in the throttle body when the system adjusts engine speed in response to changes in engine load, typically from power steering application or air-conditioner compressor cycling.Idle speed control logic is only active at vehicle speeds below 3.5 mph and when the accelerator pedal is not applied.Ford testing of a vehicle with a worst case throttle body measured a maximum idle flare of 1360 RPM lasting approximately 1 second, which Ford indicated was consistent with system design to limit vehicle speed and acceleration in idle control mode.Ford indicated that the test vehicle was held in place with normal brake effort and that vehicle speed remained under 4 mph without the brake pedal applied.In addition to throttle body deposit accumulation, symptoms associated with the condition may include Check Engine lamp illumination and diagnostic trouble codes (DTCs) P0505, P0506 or P061B.Ford attributed the surge condition to changes in idle air flow resulting from the progressive buildup of deposits in the throttle body from normal Positive Crankcase Ventilation (PCV) system operation.This condition was not adequately compensated for in the original Powertrain Control Module (PCM) calibration.Ford issued a technical service bulletin on August 15, 2011 (TSB 11-8-5), releasing an updated powertrain control calibration for vehicles with CVT transmissions.On October 19, 2011, Ford issued a second bulletin (TSB 11-10-21) superseding TSB 11-8-5 and including updated powertrain control calibration for vehicles with 6-speed transmissions.Prior to Ford issuing the TSB?s, owner?s experiencing the alleged defect either received no repairs, if dealers could not duplicate the condition, or had the throttle body cleaned or replaced, which only provided temporary correction until the throttle deposit build-up returned.Ford?s revised powertrain calibrations appear to be effective remedies for the idle instability caused by build-up of throttle body deposits.However, even after the TSB?s were released, many owners experiencing the condition continued to have difficulty with proper diagnosis and repair as dealers were often either unable to duplicate the condition or were unfamiliar with the new repair procedures.Ford's new program addresses those concerns.NHTSA's testing and complaint analysis indicate that the idle speed control issue in the subject vehicles can only occur at very low speeds, are very brief events, are easily controlled by moderate brake pedal forces and result in minor increases in vehicle speed even with no braking.This investigation is closed.The closing of this in
PE07058 · Instrument Cluster Failure
Opened Nov 16, 2007 · Closed Mar 11, 2008
Status: closed (inferred from source dates) · Electrical System: Instrument Cluster/panel
THE SUBJECT VEHICLES EXPERIENCE A LOSS OF PROPER INSTRUMENT CLUSTER OPERATION.TYPICALLY, THE PROBLEM APPEARS AS THE NEEDLE ON THE GAUGE (SPEEDOMETER, TACHOMETER, FUEL, AND/OR TEMPERATURE) SWEEPS AND RESETS INTERMITTENTLY.FORD REPORTS THE PROBLEM AS MOMENTARY POWER INTERRUPTION CAUSES THE GAUGES TO SWEEP AND THEN RECOVER TO NORMAL FUNCTION.IN AUGUST 2006, FORD ISSUED A TECHNICAL SERVICE BULLETIN (TSB 06-17-9) TO PROVIDE GUIDELINES TO SERVICE TECHNICIANS FOR DIAGNOSIS AND REPAIR OF THIS CONDITION.ODI'S REVIEW OF FORD'S RESPONSE TO THE AGENCY'S INFORMATIONREQUEST LETTER REVEALS THAT THE MAJORITY OF THE REPORTS TO FORD (63%) INDICATE THAT THE INSTRUMENT CLUSTER WOULD EXPERIENCE INTERMITTENT LOSS OF POWER.FORD REPORTS THAT THISLASTS FOR ONLY A FEW SECONDS.ALSO FORD STATES, THE VEHICLE'S EXTERIOR LIGHTING WOULD NOT FAIL TO ILLUMINATE EVEN IN THE EVENT OF POWER INTERRUPTION TO THE CLUSTER BECAUSE THE EXTERIOR LIGHTS ARE POWERED SEPARATELY AND DO NOT RELY ON ANY SIGNAL FROM THE CLUSTER.ADDITIONALLY, ODI CONTACTED COMPLAINANTS WHO AFFIRMED THE INTERMITTENT CONDITION AND THAT NONE OF THE EXTERIOR LIGHTS ON THE SUBJECT VEHICLES WOULD BE AFFECTED BY POWER INTERRUPTIONS TO THE INSTRUMENT CLUSTER.ODI LAST RECEIVED A REPORT REGARDING THIS ISSUE IN AUGUST OF 2007.THE CLOSING OF THIS INVESTIGATION DOES NOT CONSTITUTE A FINDING BY NHTSA THAT A SAFETY-RELATED DEFECT DOES NOT EXIST.FURTHER USE OF AGENCY RESOURCES DOES NOT APPEAR TO BE WARRANTED AT THIS TIME.ODI WILL HOWEVER CONTINUE TO MONITOR THE ISSUE AND WILL TAKE FURTHER ACTION IF WARRANTED BY THE CIRCUMSTANCES.