IllustrationMY 2005 FORD 500 SOME TIMES THE DASH QUITS WORKING RADIO HEAT THAT STUFF IS FINE BUT THE DASH IT'S SELF RPM SPEEDOMETOR GAS GAUGE ALL THE DASH QUITS AND WHEN THAT HAPPENS THE AIRBAG LIGHT COMES ON BECAUSE WHEN THE DASH QUITS SO DOES THE AIRBAGS THAT IS A SAFTEY AND SHOULD BE A RECALL
2005 Ford Five Hundred
Owner reports · Recalls · Investigations
Limited comparison data
There is not enough comparable history to draw a useful model-year comparison.
About this comparison →How this year compares
Owner complaints by model year
Compare all Five Hundred years →Counts vary with age, sales and reporting. They are not failure rates.
What owners reported most
All reported categories
Tap a category to read its complaints. One report may name several components.
When problems were reported
Mileage at the reported incident
640–25K
7625–50K
8750–75K
8875–100K
79100–150K
49150K+
443 reports with mileage · 67 unknown
NHTSA’s mileage field refers to the reported incident, not necessarily the filing date. This shows report counts, not the likelihood of a failure.
What to inspect
Issues worth paying extra attention to based on owner reports.
- Power Train. Review the 136 owner reports in this category and discuss these concerns during a pre-purchase inspection. Read reports →
- Vehicle Speed Control. Review the 104 owner reports in this category and discuss these concerns during a pre-purchase inspection. Read reports →
- Electrical System. Review the 95 owner reports in this category and discuss these concerns during a pre-purchase inspection. Read reports →
NHTSA owner reports · September 18, 2026 snapshot.
20 crash reports6 fire reports10 injury reports
Air Bags complaints
15 reportsWHILE DRIVING AIRBAG LIGHT CAME ON SEVERAL TIMES AND THEN MADE 1 BONG. FORD DEALER SAID I HAVE A BAD CONTROL MODULE AND PART IS NOT COVERED. IF THIS IS A SAFETY ITEM SHOULD IT BE COVERED? SHOULD THIS MODULE BE RECALLED?
THE VEHICLE WAS IN A FRONT END COLLISION WITH THE FRONT DRIVER SIDE PRIMARILY DAMAGED. THE VEHICLE WAS TRAVELING DOWN A CITY STREET AT ROUGHLY 35 TO 40 MPH UPHILL. THE VEHICLE REAR ENDED A STATIONARY VEHICLE THAT WAS ATTEMPTING TO TURN. THE AIRBAG SENSOR WAS LOCATED ON THE VEHICLE AND WAS HIT, HOWEVER, THE AIRBAGS DID NOT DEPLOY…
Read full complaint
THE VEHICLE WAS IN A FRONT END COLLISION WITH THE FRONT DRIVER SIDE PRIMARILY DAMAGED. THE VEHICLE WAS TRAVELING DOWN A CITY STREET AT ROUGHLY 35 TO 40 MPH UPHILL. THE VEHICLE REAR ENDED A STATIONARY VEHICLE THAT WAS ATTEMPTING TO TURN. THE AIRBAG SENSOR WAS LOCATED ON THE VEHICLE AND WAS HIT, HOWEVER, THE AIRBAGS DID NOT DEPLOY. CAUSING DAMAGE TO THE DRIVER IN THE ACCIDENT. THEY CLEARLY SHOULD HAVE DEPLOYED BY THE APPEARANCE OF THE SENSOR.
LEAVING A GROCER AT 13:15 ON 9/7/2015 STARTED TO BACK OUT OF PARKING SPOT WHEN AUTO SUDDENLY ACCELERATED BACKWARD, ACROSS THE AISLE AND SLAMMED INTO PARKED VEHICLE WITH IMPACT SENDING THAT AUTO INTO A 3RD. DAMAGES TO BOTH VEHICLES. WHEN I WENT TO PULL INTO MY ORIGINAL SLOT TO DEAL WITH SITUATION, AS SOON AS I REMOVED FOOT FROM…
Read full complaint
LEAVING A GROCER AT 13:15 ON 9/7/2015 STARTED TO BACK OUT OF PARKING SPOT WHEN AUTO SUDDENLY ACCELERATED BACKWARD, ACROSS THE AISLE AND SLAMMED INTO PARKED VEHICLE WITH IMPACT SENDING THAT AUTO INTO A 3RD. DAMAGES TO BOTH VEHICLES. WHEN I WENT TO PULL INTO MY ORIGINAL SLOT TO DEAL WITH SITUATION, AS SOON AS I REMOVED FOOT FROM BRAKE, AUTO LUNGED FORWARD AT HIGH RATE OF SPEED, JUMPED A 6" LANDSCAPE CURB AND PLOWED INTO THE FRONT END OF A CADILLAC SRX CAUSING MAJOR DAMAGE TO THAT VEHICLE, STILL UNK TOTAL DAMAGE TO MINE. IT WAS A VERY HOT DAY AND THE AC WAS RUNNING. NO OTHER VEHICLES WERE OCCUPIED OTHER THAN MINE, AND I WAS SOLE OCCUPANT. MY AIRBAG DID NOT DEPLOY AND PASSENGER'S WAS NOT TURNED ON. I DID RECEIVE A SIGNIFICANT BRUISE ON MY STERNUM FROM THE SHOULDER COMPONENT OF MY SEAT BELT. MY FOOT WAS NOT ON THE ACCELERATOR FOR EITHER "LUNGE". CRASHES WERE WITNESSED AND PEORIA AZ POLICE DID RESPOND WITH 2 UNITS. OFFICERS DID TAKE INFORMATION, BUT WHEN I INQUIRED ABOUT INCIDENT # FOR MY RECORDS OFFICER RESPONDED THAT THERE WOULD BE NO REPORT AND NO CITATIONS AS IT OCCURRED ON PRIVATE PROPERTY. MY INSURANCE CARRIER WAS CONTACTED FROM SITE, BUT BEING A HOLIDAY, I WAS NOT ABLE TO SPEAK WITH ADJUSTER AT THAT TIME. KNOWING THAT IT WAS NOT MY ACTIONS THAT CAUSED THIS INCIDENT, I CHECKED THE NEXT DAY AND DISCOVERED THAT THIS IDENTICAL SITUATION HAD BEEN UNDER INVESTIGATION WITH NHTSA AT THE TIME I PURCHASED THE CAR ON OR ABOUT 11/16/12 AT WHICH A SERVICE PROGRAM TO RETIFY WAS IN EFFECT. WITH MY INCIDENT THOUGH, MAJOR DAMAGE OCCURRED. NEITHER AT THE TIME OF PURCHASE, NOR THROUGHOUT THE INVESTIGATION & TENURE OF MY OWNERSHIP (CURRENT) WAS I NOTIFIED OF THE KNOWN SAFETY PROBLEM NOR IT'S PROGRAM TO MITIGATE. ATTACHED AERIAL PHOTO SHOWS BACK TO BACK DIMENSION TO FIRST IMPACT AND BACK TO FRONT DIMENSION OF 2ND. I WAS PARKED IN POSITION OF WHITE VEHICLE.
INSTRUMENT CLUSTER INTERMITTENTLY WENT DARK AND/OR GAUGES WENT TO ZERO/OFF POSITIONS, WE PULLED OVER TO SEE IF EXTERIOR LIGHTS WORKED AND ALL DID, AS WELL AS BLINKERS AND FLASHERS, BUT WE NOTED THAT REVERSE LIGHTS WERE NOW ON. IT HAS RECURRED A FEW TIMES, ITS MOST NOTICEABLE AFTER DARK AS DASH LIGHTS GO BLACK. ONLY LIGHT ON DA…
Read full complaint
INSTRUMENT CLUSTER INTERMITTENTLY WENT DARK AND/OR GAUGES WENT TO ZERO/OFF POSITIONS, WE PULLED OVER TO SEE IF EXTERIOR LIGHTS WORKED AND ALL DID, AS WELL AS BLINKERS AND FLASHERS, BUT WE NOTED THAT REVERSE LIGHTS WERE NOW ON. IT HAS RECURRED A FEW TIMES, ITS MOST NOTICEABLE AFTER DARK AS DASH LIGHTS GO BLACK. ONLY LIGHT ON DASH WAS THE AIRBAG LIGHT. I WENT ONLINE & FOUND INFO ON A TECHNICAL SERVICE BULLETIN "TSB 06-17-9 09/04/06 - INTERMITTENT INSTRUMENT CLUSTER", IT DOES NOT APPEAR TO BE A RECALL ITEM SO ASSUMING ANY REPAIRS ARE ENTIRELY OWNER COST ? *TR
DRIVING AT HE RATE OF SPEED OF ABOUT 55-65 MPH HEADING SOUTHBOUND ON THE DAN RYAN EXPRESSWAY IN CHICAGO WHEN MY 2005 FORD FIVE HUNDRED WAS INVOLVED IN A FRONT-END COLLISION WITH A MEDIAN AND MY AIRBAG DID NOT DEPLOY. THERE COULD BE A LOSS OF LIFE IF THIS PROBLEM IS NOT RESOLVED. *TR
WHILE DRIVING MY 2005 FORD 500, I T-BONED ANOTHER VEHICLE. I WAS DRIVING ABOUT 35MPH. MY DRIVER SIDE AIRBAG DIDN'T DEPLOY. MY SEAT BELT DIDN'T PREVENT ME FROM HITTING THE STEERING WHEEL. *TR
TL* THE CONTACT OWNS A 2005 FORD FIVE HUNDRED. WHILE DRIVING DOWN-HILL AT SPEEDS LESS THAN 50 MPH IN SNOWY AND ICY CONDITIONS THE VEHICLE SLID INTO AN EMBANKMENT HEAD-ON. NEXT THE VEHICLE CRASHED INTO A TELEPHONE POLE AND CAUSED THE REAR BUMPER TO BECOME SUBMERGED IN A DITCH. NEITHER THE FRONTAL DRIVER'S OR PASSENGER'S SIDE AIRB…
Read full complaint
TL* THE CONTACT OWNS A 2005 FORD FIVE HUNDRED. WHILE DRIVING DOWN-HILL AT SPEEDS LESS THAN 50 MPH IN SNOWY AND ICY CONDITIONS THE VEHICLE SLID INTO AN EMBANKMENT HEAD-ON. NEXT THE VEHICLE CRASHED INTO A TELEPHONE POLE AND CAUSED THE REAR BUMPER TO BECOME SUBMERGED IN A DITCH. NEITHER THE FRONTAL DRIVER'S OR PASSENGER'S SIDE AIRBAGS DEPLOYED. SHE SUFFERED INJURIES TO HER BACK AND CHEST. THE POLICE ARRIVED ON THE SCENE AND A POLICE REPORT WAS FILED. NO REPAIRS WERE MADE TO DATE. THE CURRENT AND FAILURE MILEAGES WERE 104,000.
IT STARTED WITH MY INSTRUMENT CLUSTER GOING OUT (NO LIGHTS, GAUGES, ANYTHING) AND IT CAN LAST ANYWHERE FROM 15 MINUTES TO HOURS. THE OTHER NIGHT MY BOYFRIEND AND I HIT A DEER AND WE WENT FROM 70 TO 50 ON IMPACT (WHICH WAS HEAD ON) AND OUR AIRBAGS DID NOT DEPLOY. HOWEVER A FEW MINUTES AFTER THE IMPACT, THE LIGHT CAME ON SAYING SO…
Read full complaint
IT STARTED WITH MY INSTRUMENT CLUSTER GOING OUT (NO LIGHTS, GAUGES, ANYTHING) AND IT CAN LAST ANYWHERE FROM 15 MINUTES TO HOURS. THE OTHER NIGHT MY BOYFRIEND AND I HIT A DEER AND WE WENT FROM 70 TO 50 ON IMPACT (WHICH WAS HEAD ON) AND OUR AIRBAGS DID NOT DEPLOY. HOWEVER A FEW MINUTES AFTER THE IMPACT, THE LIGHT CAME ON SAYING SOMETHING WAS WRONG WITH THE AIRBAGS. *TR
STARTED DRIVING MY 2005 FORD FIVE HUNDRED SEL FRONT WHEEL DRIVE AS I NORMALLY DO, EXCEPT THE INSTRUMENT CLUSTER AND LIGHTS STARTED FLICKERING, MY A/C TURNED OFF AND CHECK ENGINE LIGHT CAME ON. AFTER STOPPING ON THE SIDE OF THE ROAD EVERYTHING RETURNED TO NORMAL. ABOUT 40 MINUTES LATER A SIMILAR SITUATION OCCURRED, ONLY THIS TI…
Read full complaint
STARTED DRIVING MY 2005 FORD FIVE HUNDRED SEL FRONT WHEEL DRIVE AS I NORMALLY DO, EXCEPT THE INSTRUMENT CLUSTER AND LIGHTS STARTED FLICKERING, MY A/C TURNED OFF AND CHECK ENGINE LIGHT CAME ON. AFTER STOPPING ON THE SIDE OF THE ROAD EVERYTHING RETURNED TO NORMAL. ABOUT 40 MINUTES LATER A SIMILAR SITUATION OCCURRED, ONLY THIS TIME JUST THE INSTRUMENT PANEL FAILED. MY CRUISE CONTROL STILL WORKED BUT MY TACH, SPEED, BATTERY AND POWER GAUGE ALL DROPPED TO ZERO, HOWEVER THE LIGHTS REMAINED ON. I AM WRITING TODAY BECAUSE I SAW ONLINE THAT OTHER OWNERS OF THE SAME MAKE AND MODEL ARE HAVING IDENTICAL PROBLEMS. THIS IS A MAJOR SAFETY ISSUE AND COULD CAUSE AN ACCIDENT, ESPECIALLY IF THE LIGHTS CUT OFF AT RANDOM. I'M SURPRISED THERE HASN'T BEEN A RECALL ISSUED OR AN ACCIDENT YET AS A RESULT OF THIS. *TR
Official recalls
206V383000 · Latches/locks/linkages:doors:latch
Oct 5, 2006
ON CERTAIN PASSENGER VEHICLES CURRENTLY REGISTERED IN THE FOLLOWING STATES: ALASKA, COLORADO, CONNECTICUT, DELAWARE, IDAHO, ILLINOIS, INDIANA, IOWA, KANSAS, KENTUCKY, MAINE, MARYLAND, MASSACHUSETTS, MICHIGAN, MINNESOTA, MISSOURI, MONTANA, NEBRASKA, NEW HAMPSHIRE, NEW JERSEY, NEW YORK, NORTH DAKOTA, OHIO, PENNSYLVANIA, RHODE ISLAND, SOUTH DAKOTA, UTAH, VERMONT, WEST VIRGINIA, WISCONSIN, AND WYOMING. THE SIDE DOOR LATCH MECHANISMS MAY EXPERIENCE WATER INTRUSION ALLOWING THE LATCH MECHANISM TO FREEZE IN COLD WEATHER.
Consequence & remedy
Consequence: AS A RESULT, THE DOOR LATCH PAWL MAY NOT RETURN TO THE LATCH POSITION WHEN THE DOOR IS CLOSED, AND THE DOOR COULD OPEN WHILE THE VEHICLE IS MOVING.
Remedy: DEALERS WILL INSTALL A SHIELD OVER THE FRONT LATCHES; SEAL A DRAIN HOLE IN THE REAR WINDOW TRIM MOLDING ON THE FREESTYLE REAR SIDE DOORS; AND APPLY GREASE TO ALL FRONT AND REAR SIDE-DOOR LATCH MECHANISMS FREE OF CHARGE. THE RECALL BEGAN ON NOVEMBER 8, 2006. OWNERS MAY CONTACT FORD AT 1-800-392-3673.
05V515000 · Fuel System, Gasoline:storage:tank Assembly:mounting
Nov 9, 2005
ON CERTAIN PASSENGER VEHICLES, THE STRAPS THAT SECURE THE FUEL TANK TO THE VEHICLE BODY MAY BREAK, CAUSING THE FUEL TANK AND FUEL TANK HEAT SHIELD TO DROP ON THE DRIVESHAFT (ALL WHEEL DRIVE VEHICLES) OR EXHAUST SYSTEM (FRONT WHEEL DRIVE VEHICLES).
Consequence & remedy
Consequence: IF THIS HAPPENS, DRIVERS MAY NOTICE A NOISE OR A FUEL LEAK. A FUEL LEAK IN THE PRESENCE OF AN IGNITION SOURCE COULD RESULT IN A FIRE.
Remedy: DEALERS WILL REPLACE BOTH FUEL TANK STRAPS. THE RECALL BEGAN ON DECEMBER 1, 2005. OWNERS MAY CONTACT FORD AT 1-800-392-3673.
Model-level recall history does not show whether a particular VIN is affected or has received a repair. Check a VIN with NHTSA ↗
NHTSA investigations
2PE11018 · Idle Instability
Opened May 11, 2011 · Closed Feb 7, 2013
Status: closed (inferred from source dates) · Vehicle Speed Control
On November 29, 2012, Ford Motor Company (Ford) initiated Customer Satisfaction Program 12N03 to extend warranty coverage terms for repair of engine idle RPM surge caused by throttle body deposits in all model year (MY) 2005 through 2007 Ford Freestyle, Five Hundred and Mercury Montego vehicles.The program extends the coverage for up to 10 years of service or 150,000 miles from the warranty start date of the vehicle (all vehicles are eligible for the program through May 31, 2013, regardless of mileage).Dealers will repair vehicles exhibiting the condition by removing and cleaning the throttle body and reprogramming the PCM with software containing an updated idle speed control strategy.According to Ford, some of the affected vehicles may experience momentary, intermittent engine idle RPM surge (idle flare) when stopped or during low speed driving maneuvers such as in a parking lot or driveway.Unstable idle speed control (dips and flares) around the target engine speed (700 rpm) can occur in vehicles with deposit build-up in the throttle body when the system adjusts engine speed in response to changes in engine load, typically from power steering application or air-conditioner compressor cycling.Idle speed control logic is only active at vehicle speeds below 3.5 mph and when the accelerator pedal is not applied.Ford testing of a vehicle with a worst case throttle body measured a maximum idle flare of 1360 RPM lasting approximately 1 second, which Ford indicated was consistent with system design to limit vehicle speed and acceleration in idle control mode.Ford indicated that the test vehicle was held in place with normal brake effort and that vehicle speed remained under 4 mph without the brake pedal applied.In addition to throttle body deposit accumulation, symptoms associated with the condition may include Check Engine lamp illumination and diagnostic trouble codes (DTCs) P0505, P0506 or P061B.Ford attributed the surge condition to changes in idle air flow resulting from the progressive buildup of deposits in the throttle body from normal Positive Crankcase Ventilation (PCV) system operation.This condition was not adequately compensated for in the original Powertrain Control Module (PCM) calibration.Ford issued a technical service bulletin on August 15, 2011 (TSB 11-8-5), releasing an updated powertrain control calibration for vehicles with CVT transmissions.On October 19, 2011, Ford issued a second bulletin (TSB 11-10-21) superseding TSB 11-8-5 and including updated powertrain control calibration for vehicles with 6-speed transmissions.Prior to Ford issuing the TSB?s, owner?s experiencing the alleged defect either received no repairs, if dealers could not duplicate the condition, or had the throttle body cleaned or replaced, which only provided temporary correction until the throttle deposit build-up returned.Ford?s revised powertrain calibrations appear to be effective remedies for the idle instability caused by build-up of throttle body deposits.However, even after the TSB?s were released, many owners experiencing the condition continued to have difficulty with proper diagnosis and repair as dealers were often either unable to duplicate the condition or were unfamiliar with the new repair procedures.Ford's new program addresses those concerns.NHTSA's testing and complaint analysis indicate that the idle speed control issue in the subject vehicles can only occur at very low speeds, are very brief events, are easily controlled by moderate brake pedal forces and result in minor increases in vehicle speed even with no braking.This investigation is closed.The closing of this in
PE07058 · Instrument Cluster Failure
Opened Nov 16, 2007 · Closed Mar 11, 2008
Status: closed (inferred from source dates) · Electrical System: Instrument Cluster/panel
THE SUBJECT VEHICLES EXPERIENCE A LOSS OF PROPER INSTRUMENT CLUSTER OPERATION.TYPICALLY, THE PROBLEM APPEARS AS THE NEEDLE ON THE GAUGE (SPEEDOMETER, TACHOMETER, FUEL, AND/OR TEMPERATURE) SWEEPS AND RESETS INTERMITTENTLY.FORD REPORTS THE PROBLEM AS MOMENTARY POWER INTERRUPTION CAUSES THE GAUGES TO SWEEP AND THEN RECOVER TO NORMAL FUNCTION.IN AUGUST 2006, FORD ISSUED A TECHNICAL SERVICE BULLETIN (TSB 06-17-9) TO PROVIDE GUIDELINES TO SERVICE TECHNICIANS FOR DIAGNOSIS AND REPAIR OF THIS CONDITION.ODI'S REVIEW OF FORD'S RESPONSE TO THE AGENCY'S INFORMATIONREQUEST LETTER REVEALS THAT THE MAJORITY OF THE REPORTS TO FORD (63%) INDICATE THAT THE INSTRUMENT CLUSTER WOULD EXPERIENCE INTERMITTENT LOSS OF POWER.FORD REPORTS THAT THISLASTS FOR ONLY A FEW SECONDS.ALSO FORD STATES, THE VEHICLE'S EXTERIOR LIGHTING WOULD NOT FAIL TO ILLUMINATE EVEN IN THE EVENT OF POWER INTERRUPTION TO THE CLUSTER BECAUSE THE EXTERIOR LIGHTS ARE POWERED SEPARATELY AND DO NOT RELY ON ANY SIGNAL FROM THE CLUSTER.ADDITIONALLY, ODI CONTACTED COMPLAINANTS WHO AFFIRMED THE INTERMITTENT CONDITION AND THAT NONE OF THE EXTERIOR LIGHTS ON THE SUBJECT VEHICLES WOULD BE AFFECTED BY POWER INTERRUPTIONS TO THE INSTRUMENT CLUSTER.ODI LAST RECEIVED A REPORT REGARDING THIS ISSUE IN AUGUST OF 2007.THE CLOSING OF THIS INVESTIGATION DOES NOT CONSTITUTE A FINDING BY NHTSA THAT A SAFETY-RELATED DEFECT DOES NOT EXIST.FURTHER USE OF AGENCY RESOURCES DOES NOT APPEAR TO BE WARRANTED AT THIS TIME.ODI WILL HOWEVER CONTINUE TO MONITOR THE ISSUE AND WILL TAKE FURTHER ACTION IF WARRANTED BY THE CIRCUMSTANCES.