NHTSA owner reports · September 18, 2026 snapshot.
What owners actually said
74 reports50,000 miles · Jul 24, 2019
Power Train
TL* THE CONTACT OWNS A 2017 FORD FIESTA. WHILE DRIVING VARIOUS SPEEDS, THE VEHICLE LOST POWER WITHOUT WARNING AND WAS DIFFICULT TO RESTART. THE VEHICLE WAS TAKEN TO HERITAGE FORD (LOCATED AT 2075 EDSEL LN NW, CORYDON, IN 47112, (812) 738-3284) TO BE DIAGNOSED. THE DEALER STATED THAT THERE WAS EVIDENCE OF A FAULT CODE; HOWEVER, T…
Read full complaint
TL* THE CONTACT OWNS A 2017 FORD FIESTA. WHILE DRIVING VARIOUS SPEEDS, THE VEHICLE LOST POWER WITHOUT WARNING AND WAS DIFFICULT TO RESTART. THE VEHICLE WAS TAKEN TO HERITAGE FORD (LOCATED AT 2075 EDSEL LN NW, CORYDON, IN 47112, (812) 738-3284) TO BE DIAGNOSED. THE DEALER STATED THAT THERE WAS EVIDENCE OF A FAULT CODE; HOWEVER, THE TRANSMISSION CONTROL MODULE NEEDED TO BE REPLACED. THE VEHICLE WAS NOT REPAIRED. THE MANUFACTURER WAS NOT CONTACTED ABOUT THE FAILURE. THE APPROXIMATE FAILURE MILEAGE WAS 50,000. THE VIN WAS NOT AVAILABLE.
NHTSA ODI #11234539
3,200 miles · Jul 17, 2019
Electronic Stability Control (esc)Vehicle Speed ControlCrashInjury
ON JULY 15TH 2019, MY SON WAS GOING AROUND A SHARP RIGHT CORNER WHEN THE CAR SPED UP OUT OF CONTROL AND CRASHED INTO A UTILITY POLE HEAD ON. MY SON WAS DRIVING ON A CITY STREET AND WAS GOING APPROXIMATELY 30 MILES AN HOUR. HE'S UNCERTAIN WHAT CAUSED THE SUDDEN ACCELERATION. THE CAR WAS TOTALED AND MY SON HAS A SEVERELY BROKEN FO…
Read full complaint
ON JULY 15TH 2019, MY SON WAS GOING AROUND A SHARP RIGHT CORNER WHEN THE CAR SPED UP OUT OF CONTROL AND CRASHED INTO A UTILITY POLE HEAD ON. MY SON WAS DRIVING ON A CITY STREET AND WAS GOING APPROXIMATELY 30 MILES AN HOUR. HE'S UNCERTAIN WHAT CAUSED THE SUDDEN ACCELERATION. THE CAR WAS TOTALED AND MY SON HAS A SEVERELY BROKEN FOOT.
NHTSA ODI #11232774
43,000 miles · Jul 9, 2019
SeatsUnknown Or Other
SEATS ARE POORLY MADE. THE HARD PLASTIC PIECE WHERE THE SEAT ADJUSTMENT IS LOCATED BROKE ON MY 2 YEAR OLD VEHICLE. BROKE WHILE STATIONARY.
NHTSA ODI #11230492
79,000 miles · Jun 4, 2019
Power Train
TAKATA RECALL THE CLUTCH IS GOING OUT OF THE TRANSMISSION
NHTSA ODI #11217873
26,000 miles · May 15, 2019
Wheels
WHILE DRIVING DOWN THE HIGHWAY THE WHEEL TO MY CAR SPLIT IN TWO. IT WAS NOT CAUSED FROM HITTING ANYTHING, THERE WAS NO POTHOLES, ETC IN THE ROAD. I WAS TRAVELING AT APPROX. 60MPH ON A STRAIGHT ROAD WHEN THIS HAPPENED AND THANKFULLY NOBODY WAS INJURED. THE TIRE WAS NOT INVOLVED. THE WHEEL JUST SPLIT INTO TWO PIECES!!!
NHTSA ODI #11207704
2,000 miles · Apr 20, 2019
EngineService BrakesSteeringCrashInjury
TURNING A CURVATURE ON A MOUNTAIN ROAD STEERING LOCKED AND BRAKES FAILED CAR WENT OVER THE MOUNTAIN AS A RESULT PASSANGERS THREE WERE INJURED AND ONE FATALITY.
NHTSA ODI #11202706
14,000 miles · Mar 19, 2019
Power TrainService BrakesStructure
VEHICLE SWERVED IN RIGHT REAR QUARTER PANEL WITH NO WIND, AIR, OR OTHER SOURCE OF PRESSURE ON INTERSTATE.TIRES, ESPECIALLY RIGHT REAR, SPUN WITHOUT MOVEMENT WHEN CLUTCH ENGAGED IN DRIVEWAY; ENTIRE VEHICLE FAILED TO MOVE OR GAIN TRACTION WHEN CLUTCH FULLY ENGAGED IN FRIENDS DIRT YARD; AT ODD TIMES, VEHICLE MADE NOISE IN RIGHT RE…
Read full complaint
VEHICLE SWERVED IN RIGHT REAR QUARTER PANEL WITH NO WIND, AIR, OR OTHER SOURCE OF PRESSURE ON INTERSTATE.TIRES, ESPECIALLY RIGHT REAR, SPUN WITHOUT MOVEMENT WHEN CLUTCH ENGAGED IN DRIVEWAY; ENTIRE VEHICLE FAILED TO MOVE OR GAIN TRACTION WHEN CLUTCH FULLY ENGAGED IN FRIENDS DIRT YARD; AT ODD TIMES, VEHICLE MADE NOISE IN RIGHT REAR AXLE/WHEEL AREA FAILING TO RESPOND TO CLUTCH RELEASE--MOST NOTICEABLY ON CONCRETE PAD IN FRONT OF GARAGE WITH TWO MECHANICS QUESTIONING. RETURNED VEHICLE TO DEALER AS UNSAFE TO OPERATE WITH REQUEST THAT IT BE TRASHED RATHER THAN SOLD TO UNSUSPECTING BUYER WHO MIGHT FIND THEMSELVES MAROONED OR WRECKED WITHOUT KNOWING HOW OR WHY IT HAPPENED.
NHTSA ODI #11190079
42,000 miles · Feb 18, 2019
Engine
I RECENTLY PURCHASED THE 2017 FORD FIESTA, (JUST HIT THE 30 DAY MARK), AND ABOUT A WEEK IN I NOTICED THE CAR DO THIS JOLT THING WHILE ACCELERATING. I THOUGHT I MAY HAVE BEEN JUST LAYING MY FOOT TOO HARD ON THE GAS BY ACCIDENT BUT NOW, ON A FEW DIFFERENT OCCASIONS, WHILE SLOWING THE CAR DOWN IT HAS VIOLENTLY JUMPED FORWARD. IT ST…
Read full complaint
I RECENTLY PURCHASED THE 2017 FORD FIESTA, (JUST HIT THE 30 DAY MARK), AND ABOUT A WEEK IN I NOTICED THE CAR DO THIS JOLT THING WHILE ACCELERATING. I THOUGHT I MAY HAVE BEEN JUST LAYING MY FOOT TOO HARD ON THE GAS BY ACCIDENT BUT NOW, ON A FEW DIFFERENT OCCASIONS, WHILE SLOWING THE CAR DOWN IT HAS VIOLENTLY JUMPED FORWARD. IT STARTED AS SEEMING TO HAVE A HARD TIME SWITCHING GEARS ON ACCELERATION BUT THESE FEW TIMES I WAS SLOWING WITH MY PUT ON THE BRAKE AND IT THRUSTED FORWARD, VIOLENTLY.
NHTSA ODI #11180719
30,000 miles · Jan 17, 2019
Power Train
THE CAR JERKS AND SHUTTERS WHEN PRESSING ON THE GAS. THE CAR LOSES POWER AND WILL NOT GO OVER 40-50 MILES A HOURS, WHICH IS VERY DANGEROUS WHEN DRIVING ON THE INTERSTATE. THE CAR IS NOT CHANGING GEAR PROPERLY.
NHTSA ODI #11170576
18,000 miles · Jan 2, 2019
Power Train
TL* THE CONTACT OWNS A 2017 FORD FIESTA. ON SEVERAL OCCASIONS, WHILE DRIVING VARIOUS SPEEDS, THE VEHICLE JERKED ABNORMALLY AND STALLED. THE VEHICLE WAS TAKEN TO VISTA FORD WOODLAND HILLS (LOCATED AT 21501 VENTURA BLVD, WOODLAND HILLS, CA 91364, (818) 884-7600) WHERE IT WAS DIAGNOSED THAT THE TRANSMISSION CONTROL MODULE WAS FAULT…
Read full complaint
TL* THE CONTACT OWNS A 2017 FORD FIESTA. ON SEVERAL OCCASIONS, WHILE DRIVING VARIOUS SPEEDS, THE VEHICLE JERKED ABNORMALLY AND STALLED. THE VEHICLE WAS TAKEN TO VISTA FORD WOODLAND HILLS (LOCATED AT 21501 VENTURA BLVD, WOODLAND HILLS, CA 91364, (818) 884-7600) WHERE IT WAS DIAGNOSED THAT THE TRANSMISSION CONTROL MODULE WAS FAULTY; HOWEVER, THE MANAGER STATED THAT THERE WAS NO FAILURE WITH THE VEHICLE. THE VEHICLE WAS NOT REPAIRED. THE MANUFACTURER WAS NOTIFIED OF THE FAILURE. THE APPROXIMATE FAILURE MILEAGE WAS 18,000.
NHTSA ODI #11164590
NHTSA investigations
2EA26004 · Timing Belt Failure
Opened Jul 31, 2026 · No close date supplied
Status: open (inferred from source dates) · Engine; Engine And Engine Cooling:engine:gasoline:belts And Associated Pulleys
On December 18, 2025, the Office of Defects Investigation (ODI) opened PE25020 to investigate instances of timing belt failure in model year (MY) 2015-2017 Ford Fiesta and MY 2015-2018 Ford Focus vehicles manufactured by Ford Motor Company (Ford), equipped with a 1.0L engine and manual transmission (subject vehicles). Additionally, MY 2018-2021 Ford EcoSport and MY 2016-2018 Focus vehicles with a 1.0L engine and automatic transmission were analyzed as peer vehicles because they utilize a wet timing belt comprised of similar material as the timing belt in the subject vehicles. Through the PE, ODI investigated a potential failure/degradation of the timing belt that may affect oil pump function resulting in a lack of engine lubrication and potential loss of motive power. The complaints commonly allege a low engine oil pressure warning lamp immediately preceding a complete loss or reduction of motive power while the vehicle is in motion. Some complaints allege that a sudden loss of motive power or engine seizure occurred without warning or prior detectable symptoms. ODI’s analysis supports that this failure can occur without sufficient and advanced warning to the driver that a loss of motive power/engine seizure is imminent. ODI found that the timing belt material may degrade and create debris that clogs the mesh oil pump pick-up screen, resulting in reduced oil pressure in the engine. As additional debris accumulates on the screen, this can progress to a loss of motive power while driving due to a lack of engine lubrication. The failure data provided in response to this investigation revealed an average failure mileage of approximately 70,000 miles, and that 98% of the failures occurred prior to the 150,000 mile timing belt replacement interval per the vehicles’ maintenance schedule. Based on evidence collected via consumer surveys and an engine teardown, failures have occurred despite evidence of proper and routine oil maintenance. The oil pump pick-up screen is not serviceable, so debris accumulation cannot be inspected or manually removed without removing the engine from the vehicle. On June 2, 2026, Ford informed ODI of a non-safety customer satisfaction program for global vehicles with the 1.0L Fox Classic Timing Belt. This program will notify customers globally of a revised maintenance interval for the timing belt, reducing the original 150,000 mile interval down to 100,000 miles/6 years. This customer satisfaction program will also offer reimbursement to eligible customers who previously paid to have their engine repaired or replaced due to a timing belt related issue. Based on NHTSA’s analysis of the data, failure rates, information provided by Ford, preliminary engine teardown analysis, and precedent recalls regarding loss of engine oil pressure with the presence of driver facing warnings, ODI believes there is an unreasonable risk to motor vehicle safety. ODI is opening this Engineering Analysis to perform component-level and vehicle testing. To review the reports cited in the Closing Resume ODI Report Identification Number document, go to NHTSA.gov.
Additional source detail variants (2)
Engine And Engine Cooling:engine:gasoline:belts And Associated Pulleys
On December 18, 2025, the Office of Defects Investigation (ODI) opened PE25020 to investigate instances of timing belt failure in model year (MY) 2015-2017 Ford Fiesta and MY 2015-2018 Ford Focus vehicles manufactured by Ford Motor Company (Ford), equipped with a 1.0L engine and manual transmission (subject vehicles). Additionally, MY 2018-2021 Ford EcoSport and MY 2016-2018 Focus vehicles with a 1.0L engine and automatic transmission were analyzed as peer vehicles because they utilize a wet timing belt comprised of similar material as the timing belt in the subject vehicles. Through the PE, ODI investigated a potential failure/degradation of the timing belt that may affect oil pump function resulting in a lack of engine lubrication and potential loss of motive power. The complaints commonly allege a low engine oil pressure warning lamp immediately preceding a complete loss or reduction of motive power while the vehicle is in motion. Some complaints allege that a sudden loss of motive power or engine seizure occurred without warning or prior detectable symptoms. ODI’s analysis supports that this failure can occur without sufficient and advanced warning to the driver that a loss of motive power/engine seizure is imminent. ODI found that the timing belt material may degrade and create debris that clogs the mesh oil pump pick-up screen, resulting in reduced oil pressure in the engine. As additional debris accumulates on the screen, this can progress to a loss of motive power while driving due to a lack of engine lubrication. The failure data provided in response to this investigation revealed an average failure mileage of approximately 70,000 miles, and that 98% of the failures occurred prior to the 150,000 mile timing belt replacement interval per the vehicles’ maintenance schedule. Based on evidence collected via consumer surveys and an engine teardown, failures have occurred despite evidence of proper and routine oil maintenance. The oil pump pick-up screen is not serviceable, so debris accumulation cannot be inspected or manually removed without removing the engine from the vehicle. On June 2, 2026, Ford informed ODI of a non-safety customer satisfaction program for global vehicles with the 1.0L Fox Classic Timing Belt. This program will notify customers globally of a revised maintenance interval for the timing belt, reducing the original 150,000 mile interval down to 100,000 miles/6 years. This customer satisfaction program will also offer reimbursement to eligible customers who previously paid to have their engine repaired or replaced due to a timing belt related issue. Based on NHTSA’s analysis of the data, failure rates, information provided by Ford, preliminary engine teardown analysis, and precedent recalls regarding loss of engine oil pressure with the presence of driver facing warnings, ODI believes there is an unreasonable risk to motor vehicle safety. ODI is opening this Engineering Analysis to perform component-level and vehicle testing. To review the reports cited in the Closing Resume ODI Report Identification Number document, go to NHTSA.gov.
Engine
On December 18, 2025, the Office of Defects Investigation (ODI) opened PE25020 to investigate instances of timing belt failure in model year (MY) 2015-2017 Ford Fiesta and MY 2015-2018 Ford Focus vehicles manufactured by Ford Motor Company (Ford), equipped with a 1.0L engine and manual transmission (subject vehicles). Additionally, MY 2018-2021 Ford EcoSport and MY 2016-2018 Focus vehicles with a 1.0L engine and automatic transmission were analyzed as peer vehicles because they utilize a wet timing belt comprised of similar material as the timing belt in the subject vehicles. Through the PE, ODI investigated a potential failure/degradation of the timing belt that may affect oil pump function resulting in a lack of engine lubrication and potential loss of motive power. The complaints commonly allege a low engine oil pressure warning lamp immediately preceding a complete loss or reduction of motive power while the vehicle is in motion. Some complaints allege that a sudden loss of motive power or engine seizure occurred without warning or prior detectable symptoms. ODI’s analysis supports that this failure can occur without sufficient and advanced warning to the driver that a loss of motive power/engine seizure is imminent. ODI found that the timing belt material may degrade and create debris that clogs the mesh oil pump pick-up screen, resulting in reduced oil pressure in the engine. As additional debris accumulates on the screen, this can progress to a loss of motive power while driving due to a lack of engine lubrication. The failure data provided in response to this investigation revealed an average failure mileage of approximately 70,000 miles, and that 98% of the failures occurred prior to the 150,000 mile timing belt replacement interval per the vehicles’ maintenance schedule. Based on evidence collected via consumer surveys and an engine teardown, failures have occurred despite evidence of proper and routine oil maintenance. The oil pump pick-up screen is not serviceable, so debris accumulation cannot be inspected or manually removed without removing the engine from the vehicle. On June 2, 2026, Ford informed ODI of a non-safety customer satisfaction program for global vehicles with the 1.0L Fox Classic Timing Belt. This program will notify customers globally of a revised maintenance interval for the timing belt, reducing the original 150,000 mile interval down to 100,000 miles/6 years. This customer satisfaction program will also offer reimbursement to eligible customers who previously paid to have their engine repaired or replaced due to a timing belt related issue. Based on NHTSA’s analysis of the data, failure rates, information provided by Ford, preliminary engine teardown analysis, and precedent recalls regarding loss of engine oil pressure with the presence of driver facing warnings, ODI believes there is an unreasonable risk to motor vehicle safety. ODI is opening this Engineering Analysis to perform component-level and vehicle testing. To review the reports cited in the Closing Resume ODI Report Identification Number document, go to NHTSA.gov.
PE25020 · Timing Belt Failure
Opened Dec 18, 2025 · Closed Jul 31, 2026
Status: closed (inferred from source dates) · Engine; Engine And Engine Cooling:engine:gasoline:belts And Associated Pulleys
On December 18, 2025, the Office of Defects Investigation (ODI) opened PE25020 to investigate instances of timing belt failure in model year (MY) 2015-2017 Ford Fiesta and MY 2015-2018 Ford Focus vehicles manufactured by Ford Motor Company (Ford), equipped with a 1.0L engine and manual transmission (subject vehicles). Additionally, MY 2018-2021 Ford EcoSport and MY 2016-2018 Focus vehicles with a 1.0L engine and automatic transmission were analyzed as peer vehicles because they utilize a wet timing belt comprised of similar material as the timing belt in the subject vehicles. Through the PE, ODI investigated a potential failure/degradation of the timing belt that may affect oil pump function resulting in a lack of engine lubrication and potential loss of motive power. The complaints commonly allege a low engine oil pressure warning lamp immediately preceding a complete loss or reduction of motive power while the vehicle is in motion. Some complaints allege that a sudden loss of motive power or engine seizure occurred without warning or prior detectable symptoms. ODI’s analysis supports that this failure can occur without sufficient and advanced warning to the driver that a loss of motive power/engine seizure is imminent. ODI found that the timing belt material may degrade and create debris that clogs the mesh oil pump pick-up screen, resulting in reduced oil pressure in the engine. As additional debris accumulates on the screen, this can progress to a loss of motive power while driving due to a lack of engine lubrication. The failure data provided in response to this investigation revealed an average failure mileage of approximately 70,000 miles, and that 98% of the failures occurred prior to the 150,000 mile timing belt replacement interval per the vehicles’ maintenance schedule. Based on evidence collected via consumer surveys and an engine teardown, failures have occurred despite evidence of proper and routine oil maintenance. The oil pump pick-up screen is not serviceable, so debris accumulation cannot be inspected or manually removed without removing the engine from the vehicle. On June 2, 2026, Ford informed ODI of a non-safety customer satisfaction program for global vehicles with the 1.0L Fox Classic Timing Belt. This program will notify customers globally of a revised maintenance interval for the timing belt, reducing the original 150,000 mile interval down to 100,000 miles/6 years. This customer satisfaction program will also offer reimbursement to eligible customers who previously paid to have their engine repaired or replaced due to a timing belt related issue. Based on NHTSA’s analysis of the data, failure rates, information provided by Ford, preliminary engine teardown analysis, and precedent recalls regarding loss of engine oil pressure with the presence of driver facing warnings, ODI believes there is an unreasonable risk to motor vehicle safety. Therefore, this Preliminary Evaluation is being upgraded to an Engineering Analysis (EA26004). During this Engineering Analysis, the agency plans to perform component-level and vehicle testing. To review the reports cited in the Closing Resume ODI Report Identification Number document, go to NHTSA.gov.
Additional source detail variants (2)
Engine And Engine Cooling:engine:gasoline:belts And Associated Pulleys
On December 18, 2025, the Office of Defects Investigation (ODI) opened PE25020 to investigate instances of timing belt failure in model year (MY) 2015-2017 Ford Fiesta and MY 2015-2018 Ford Focus vehicles manufactured by Ford Motor Company (Ford), equipped with a 1.0L engine and manual transmission (subject vehicles). Additionally, MY 2018-2021 Ford EcoSport and MY 2016-2018 Focus vehicles with a 1.0L engine and automatic transmission were analyzed as peer vehicles because they utilize a wet timing belt comprised of similar material as the timing belt in the subject vehicles. Through the PE, ODI investigated a potential failure/degradation of the timing belt that may affect oil pump function resulting in a lack of engine lubrication and potential loss of motive power. The complaints commonly allege a low engine oil pressure warning lamp immediately preceding a complete loss or reduction of motive power while the vehicle is in motion. Some complaints allege that a sudden loss of motive power or engine seizure occurred without warning or prior detectable symptoms. ODI’s analysis supports that this failure can occur without sufficient and advanced warning to the driver that a loss of motive power/engine seizure is imminent. ODI found that the timing belt material may degrade and create debris that clogs the mesh oil pump pick-up screen, resulting in reduced oil pressure in the engine. As additional debris accumulates on the screen, this can progress to a loss of motive power while driving due to a lack of engine lubrication. The failure data provided in response to this investigation revealed an average failure mileage of approximately 70,000 miles, and that 98% of the failures occurred prior to the 150,000 mile timing belt replacement interval per the vehicles’ maintenance schedule. Based on evidence collected via consumer surveys and an engine teardown, failures have occurred despite evidence of proper and routine oil maintenance. The oil pump pick-up screen is not serviceable, so debris accumulation cannot be inspected or manually removed without removing the engine from the vehicle. On June 2, 2026, Ford informed ODI of a non-safety customer satisfaction program for global vehicles with the 1.0L Fox Classic Timing Belt. This program will notify customers globally of a revised maintenance interval for the timing belt, reducing the original 150,000 mile interval down to 100,000 miles/6 years. This customer satisfaction program will also offer reimbursement to eligible customers who previously paid to have their engine repaired or replaced due to a timing belt related issue. Based on NHTSA’s analysis of the data, failure rates, information provided by Ford, preliminary engine teardown analysis, and precedent recalls regarding loss of engine oil pressure with the presence of driver facing warnings, ODI believes there is an unreasonable risk to motor vehicle safety. Therefore, this Preliminary Evaluation is being upgraded to an Engineering Analysis (EA26004). During this Engineering Analysis, the agency plans to perform component-level and vehicle testing. To review the reports cited in the Closing Resume ODI Report Identification Number document, go to NHTSA.gov.
Engine
On December 18, 2025, the Office of Defects Investigation (ODI) opened PE25020 to investigate instances of timing belt failure in model year (MY) 2015-2017 Ford Fiesta and MY 2015-2018 Ford Focus vehicles manufactured by Ford Motor Company (Ford), equipped with a 1.0L engine and manual transmission (subject vehicles). Additionally, MY 2018-2021 Ford EcoSport and MY 2016-2018 Focus vehicles with a 1.0L engine and automatic transmission were analyzed as peer vehicles because they utilize a wet timing belt comprised of similar material as the timing belt in the subject vehicles. Through the PE, ODI investigated a potential failure/degradation of the timing belt that may affect oil pump function resulting in a lack of engine lubrication and potential loss of motive power. The complaints commonly allege a low engine oil pressure warning lamp immediately preceding a complete loss or reduction of motive power while the vehicle is in motion. Some complaints allege that a sudden loss of motive power or engine seizure occurred without warning or prior detectable symptoms. ODI’s analysis supports that this failure can occur without sufficient and advanced warning to the driver that a loss of motive power/engine seizure is imminent. ODI found that the timing belt material may degrade and create debris that clogs the mesh oil pump pick-up screen, resulting in reduced oil pressure in the engine. As additional debris accumulates on the screen, this can progress to a loss of motive power while driving due to a lack of engine lubrication. The failure data provided in response to this investigation revealed an average failure mileage of approximately 70,000 miles, and that 98% of the failures occurred prior to the 150,000 mile timing belt replacement interval per the vehicles’ maintenance schedule. Based on evidence collected via consumer surveys and an engine teardown, failures have occurred despite evidence of proper and routine oil maintenance. The oil pump pick-up screen is not serviceable, so debris accumulation cannot be inspected or manually removed without removing the engine from the vehicle. On June 2, 2026, Ford informed ODI of a non-safety customer satisfaction program for global vehicles with the 1.0L Fox Classic Timing Belt. This program will notify customers globally of a revised maintenance interval for the timing belt, reducing the original 150,000 mile interval down to 100,000 miles/6 years. This customer satisfaction program will also offer reimbursement to eligible customers who previously paid to have their engine repaired or replaced due to a timing belt related issue. Based on NHTSA’s analysis of the data, failure rates, information provided by Ford, preliminary engine teardown analysis, and precedent recalls regarding loss of engine oil pressure with the presence of driver facing warnings, ODI believes there is an unreasonable risk to motor vehicle safety. Therefore, this Preliminary Evaluation is being upgraded to an Engineering Analysis (EA26004). During this Engineering Analysis, the agency plans to perform component-level and vehicle testing. To review the reports cited in the Closing Resume ODI Report Identification Number document, go to NHTSA.gov.
Illustration