IllustrationTL* THE CONTACT OWNS A 2005 FORD F-450 SD. WHILE DRIVING 35 MPH, THE ENGINE STALLED. THE VEHICLE WAS TAKEN TO AN INDEPENDENT MECHANIC, WHO DIAGNOSED THAT THE FUEL INJECTION AND MOTOR NEEDED TO BE REPLACED. THE VEHICLE WAS NOT REPAIRED. THE MANUFACTURER WAS NOTIFIED OF THE FAILURE. THE APPROXIMATE FAILURE MILEAGE WAS 34,772.
2005 Ford F-450 Sd
Owner reports · Recalls · Investigations
Limited comparison data
There is not enough comparable history to draw a useful model-year comparison.
About this comparison →How this year compares
Owner complaints by model year
Compare all F-450 Sd years →Counts vary with age, sales and reporting. They are not failure rates.
What owners reported most
All reported categories
Tap a category to read its complaints. One report may name several components.
When problems were reported
Mileage at the reported incident
50–25K
1125–50K
1050–75K
675–100K
6100–150K
0150K+
38 reports with mileage · 2 unknown
NHTSA’s mileage field refers to the reported incident, not necessarily the filing date. This shows report counts, not the likelihood of a failure.
What to inspect
Issues worth paying extra attention to based on owner reports.
- Fuel System, Diesel. Review the 13 owner reports in this category and discuss these concerns during a pre-purchase inspection. Read reports →
- Fuel/propulsion System. Review the 7 owner reports in this category and discuss these concerns during a pre-purchase inspection. Read reports →
- Fuel System, Gasoline. Review the 6 owner reports in this category and discuss these concerns during a pre-purchase inspection. Read reports →
NHTSA owner reports · September 18, 2026 snapshot.
0 crash reports0 fire reports0 injury reports
Fuel System, Gasoline complaints
6 reportsTL* THE CONTACT OWNS A 2005 FORD F-450 SD. THE CONTACT WAS DRIVING 45 MPH WHEN THE VEHICLE STALLED WITHOUT WARNING. THE VEHICLE WAS TOWED HOME AND THE DEALER WAS NOTIFIED WHO INFORMED HIM TO CHECK THE FUEL FILTER DRAIN PLUG AND THEN DRAIN THE FUEL OUT. THE DEALER STATED THAT IF HE SHOULD NOTICE PAINT FLAKES, WHICH WOULD BE THE L…
Read full complaint
TL* THE CONTACT OWNS A 2005 FORD F-450 SD. THE CONTACT WAS DRIVING 45 MPH WHEN THE VEHICLE STALLED WITHOUT WARNING. THE VEHICLE WAS TOWED HOME AND THE DEALER WAS NOTIFIED WHO INFORMED HIM TO CHECK THE FUEL FILTER DRAIN PLUG AND THEN DRAIN THE FUEL OUT. THE DEALER STATED THAT IF HE SHOULD NOTICE PAINT FLAKES, WHICH WOULD BE THE LAMINATION OF THE INSIDE OF THE FUEL TANK, HE WOULD HAVE TO REPLACE THE FUEL TANK, PUMP AND CLEAN OUT THE FUEL LINES. THE MANUFACTURER WAS NOT NOTIFIED OF THE FAILURE. THE FAILURE MILEAGE WAS 85,000.
MY 2005 F-450 BEGAN LOSING POWER. I TOOK IT IN TO A DEALERSHIP TO GET IT FIXED,(STILL UNDER WARRANTY). THE PROBLEM IS THAT THE FUEL TANK IS COMING APART INSIDE. THE TANK IS LINED INSIDE WITH A SHEET OF ALUMINUM. THE ALUMINUM IS COMING APART INSIDE THE TANK AND CLOGGING THE FUEL SYSTEM. SO THE DEALERSHIP SAID I NEED A NEW FUEL T…
Read full complaint
MY 2005 F-450 BEGAN LOSING POWER. I TOOK IT IN TO A DEALERSHIP TO GET IT FIXED,(STILL UNDER WARRANTY). THE PROBLEM IS THAT THE FUEL TANK IS COMING APART INSIDE. THE TANK IS LINED INSIDE WITH A SHEET OF ALUMINUM. THE ALUMINUM IS COMING APART INSIDE THE TANK AND CLOGGING THE FUEL SYSTEM. SO THE DEALERSHIP SAID I NEED A NEW FUEL TANK, FUEL PUMP, INJECTOR PUMP, AND NEW FUEL INJECTORS. THIS TANK IS DEFECTIVE. THIS HAS BEEN A PROBLEM IN THESE TRUCKS SINCE 1999-2008. FORD KNEW THIS WAS HAPPENING. FORD HAS HAD THOUSANDS OF COMPLAINTS ABOUT THIS PROBLEM. NOW THE DEALERSHIP WANTS TO CHARGE ME $4200.00 TO FIX, EVEN UNDER WARRANTY. DEALERSHIP SAYS FORD WILL NOT COVER THERE DEFECTIVE PART. I'M THE ONLY ONE WHO DRIVES THIS TRUCK, ALWAYS USE PUMP FUEL NO BIODIESEL EVER.
TL*THE CONTACT OWNS A 2005 FORD F450. WHILE DRIVING AT AN UNKNOWN SPEED, THE CONTACT NOTICED THAT THE FUEL GAUGE STOPPED WORKING. HE EXAMINED THE VEHICLE AND NOTICED THAT THE TOP OF THE FUEL TANK HAD COLLAPSED. THE VEHICLE WAS TAKEN TO THE DEALER AND SERVICED FOR THE FAILURE. THE FAILURE MILEAGE WAS 28,000. UPDATED 09/15/…
Read full complaint
TL*THE CONTACT OWNS A 2005 FORD F450. WHILE DRIVING AT AN UNKNOWN SPEED, THE CONTACT NOTICED THAT THE FUEL GAUGE STOPPED WORKING. HE EXAMINED THE VEHICLE AND NOTICED THAT THE TOP OF THE FUEL TANK HAD COLLAPSED. THE VEHICLE WAS TAKEN TO THE DEALER AND SERVICED FOR THE FAILURE. THE FAILURE MILEAGE WAS 28,000. UPDATED 09/15/08 *BF UPDATED 09/18/08. *JB
TL*THE CONTACT OWNS A 2005 FORD F450. WHEN THE CONTACT ATTEMPTED TO FILL THE GAS TANK, ALL OF THE FUEL BEGAN TO COME OUT OF THE TOP OF THE TANK. HE EXAMINED THE VEHICLE AND NOTICED THAT THE FUEL TANK HAD COLLAPSED AND SLIT AT THE SEAM. THE VEHICLE WAS TAKEN TO THE DEALER FOR A DIAGNOSIS. THE FAILURE MILEAGE WAS 9,119. UPD…
Read full complaint
TL*THE CONTACT OWNS A 2005 FORD F450. WHEN THE CONTACT ATTEMPTED TO FILL THE GAS TANK, ALL OF THE FUEL BEGAN TO COME OUT OF THE TOP OF THE TANK. HE EXAMINED THE VEHICLE AND NOTICED THAT THE FUEL TANK HAD COLLAPSED AND SLIT AT THE SEAM. THE VEHICLE WAS TAKEN TO THE DEALER FOR A DIAGNOSIS. THE FAILURE MILEAGE WAS 9,119. UPDATED 09/15/08 *BF THE CARBON CANISTER WAS MOUNTER BETWEEN FRAME RAILS AND DIRT AND DEBRIS BECAME TRAPPED INSIDE. UPDATED 09/18/08. *JB
FUEL INJECTORS CAUSING THE ENGINE TO FAIL AND SHUTDOWN - MULTIPLE VEHICLES. *NM
Official recalls
411V352000 · Exterior Lighting:brake Lights; Exterior Lighting:tail Lights
Jul 13, 2011
FORD IS RECALLING CERTAIN MODEL YEAR 2011 RANGER TRUCKS BUILT FROM JANUARY 25, 2011, THROUGH APRIL 25, 2011 AT THE TWIN CITIES ASSEMBLY PLANT, AND SERVICE PARTS DISTRIBUTED TO DEALERS FOR CERTAIN 2004 THROUGH 2011 MODEL YEAR RANGER TRUCKS, 2002 THROUGH 2005 MODEL YEAR EXCURSION VEHICLES, AND 2002 THROUGH 2007 MODEL YEAR F-250, F-350, F-450, AND F-550 TRUCKS FOR FAILING TO COMPLY WITH THE REQUIREMENTS OF FEDERAL MOTOR VEHICLE SAFETY STANDARD NO. 108, "LAMPS, REFLECTIVE DEVICES, AND ASSOCIATED EQUIPMENT." THE MULTI-FUNCTION SWITCH WAS SHIPPED WITH A SUBCOMPONENT (SLIDER) THAT MAY EXPERIENCE DEFORMATION. A MULTI-FUNCTION SWITCH WITH A DEFORMED SLIDER MAY MALFUNCTION CAUSING THE TURN SIGNAL, TAIL LIGHTS, HAZARD WARNING SIGNAL FLASHERS AND/OR BRAKE LIGHTS NOT TO ACTIVATE.
Consequence & remedy
Consequence: NON-FUNCTIONING LIGHTS COULD INCREASE THE RISK OF A CRASH.
Remedy: DEALERS WILL REPLACE THE SWITCHES FREE OF CHARGE. THE SAFETY RECALL BEGAN ON AUGUST 15, 2011. OWNERS MAY CONTACT FORD MOTOR COMPANY CUSTOMER RELATIONSHIP CENTER AT 1-866-436-7332.
Additional source detail variants (2)
Exterior Lighting:brake Lights
FORD IS RECALLING CERTAIN MODEL YEAR 2011 RANGER TRUCKS BUILT FROM JANUARY 25, 2011, THROUGH APRIL 25, 2011 AT THE TWIN CITIES ASSEMBLY PLANT, AND SERVICE PARTS DISTRIBUTED TO DEALERS FOR CERTAIN 2004 THROUGH 2011 MODEL YEAR RANGER TRUCKS, 2002 THROUGH 2005 MODEL YEAR EXCURSION VEHICLES, AND 2002 THROUGH 2007 MODEL YEAR F-250, F-350, F-450, AND F-550 TRUCKS FOR FAILING TO COMPLY WITH THE REQUIREMENTS OF FEDERAL MOTOR VEHICLE SAFETY STANDARD NO. 108, "LAMPS, REFLECTIVE DEVICES, AND ASSOCIATED EQUIPMENT." THE MULTI-FUNCTION SWITCH WAS SHIPPED WITH A SUBCOMPONENT (SLIDER) THAT MAY EXPERIENCE DEFORMATION. A MULTI-FUNCTION SWITCH WITH A DEFORMED SLIDER MAY MALFUNCTION CAUSING THE TURN SIGNAL, TAIL LIGHTS, HAZARD WARNING SIGNAL FLASHERS AND/OR BRAKE LIGHTS NOT TO ACTIVATE.
Consequence: NON-FUNCTIONING LIGHTS COULD INCREASE THE RISK OF A CRASH.
Remedy: DEALERS WILL REPLACE THE SWITCHES FREE OF CHARGE. THE SAFETY RECALL BEGAN ON AUGUST 15, 2011. OWNERS MAY CONTACT FORD MOTOR COMPANY CUSTOMER RELATIONSHIP CENTER AT 1-866-436-7332.
Exterior Lighting:tail Lights
FORD IS RECALLING CERTAIN MODEL YEAR 2011 RANGER TRUCKS BUILT FROM JANUARY 25, 2011, THROUGH APRIL 25, 2011 AT THE TWIN CITIES ASSEMBLY PLANT, AND SERVICE PARTS DISTRIBUTED TO DEALERS FOR CERTAIN 2004 THROUGH 2011 MODEL YEAR RANGER TRUCKS, 2002 THROUGH 2005 MODEL YEAR EXCURSION VEHICLES, AND 2002 THROUGH 2007 MODEL YEAR F-250, F-350, F-450, AND F-550 TRUCKS FOR FAILING TO COMPLY WITH THE REQUIREMENTS OF FEDERAL MOTOR VEHICLE SAFETY STANDARD NO. 108, "LAMPS, REFLECTIVE DEVICES, AND ASSOCIATED EQUIPMENT." THE MULTI-FUNCTION SWITCH WAS SHIPPED WITH A SUBCOMPONENT (SLIDER) THAT MAY EXPERIENCE DEFORMATION. A MULTI-FUNCTION SWITCH WITH A DEFORMED SLIDER MAY MALFUNCTION CAUSING THE TURN SIGNAL, TAIL LIGHTS, HAZARD WARNING SIGNAL FLASHERS AND/OR BRAKE LIGHTS NOT TO ACTIVATE.
Consequence: NON-FUNCTIONING LIGHTS COULD INCREASE THE RISK OF A CRASH.
Remedy: DEALERS WILL REPLACE THE SWITCHES FREE OF CHARGE. THE SAFETY RECALL BEGAN ON AUGUST 15, 2011. OWNERS MAY CONTACT FORD MOTOR COMPANY CUSTOMER RELATIONSHIP CENTER AT 1-866-436-7332.
05V270000 · Electrical System:wiring
Jun 10, 2005
CERTAIN PICKUP TRUCKS, SPORT UTILITY VEHICLES AND VANS EQUIPPED WITH 6.0L DIESEL ENGINES MAY EXPERIENCE STALLING WITHOUT WARNING WHILE DRIVING AND MAY OR MAY NOT RESTART.
Consequence & remedy
Consequence: SHOULD THE ENGINE STALL, A VEHICLE CRASH COULD OCCUR.
Remedy: DEALERS WILL UPGRADE THE FUEL INJECTION CONTROL MODULE (FICM) WIRE HARNESS OR REPLACED, AND/OR HAVE A NEW INJECTION CONTROL PRESSURE (ICP)) SENSOR CONNECTOR INSTALLED FREE OF CHARGE. THE RECALL BEGAN ON JULY 22, 2005. OWNERS MAY CONTACT FORD AT 1-800-392-3673.
05V266000 · Fuel System, Gasoline:delivery:hoses, Lines/piping, And Fittings
Jun 9, 2005
ON CERTAIN PICKUP TRUCKS AND CHASSIS CAB VEHICLES EQUIPPED WITH 5.4L OR 6.8L GASOLINE ENGINES, THE FUEL JUMPER LINE MAY HAVE AN INCORRECT END FORM.
Consequence & remedy
Consequence: THE FUEL LINE MAY SEPARATE AT THE CONNECTION TO THE MAIN FUEL BUNDLE. IF THE FUEL LINE SEPARATES, AN OPERATOR MAY NOTICE A GASOLINE ODOR AND/OR FUEL ON THE GROUND, LOSS OF POWER, AND THE ENGINE WILL EVENTUALLY STALL. FUEL LEAKAGE IN THE PRESENCE OF AN IGNITION SOURCE COULD RESULT IN A FIRE.
Remedy: DEALERS WILL INSTALL AN EXTERNAL RETENTION CLIP AT THE FUEL JUMPER LINE TO THE MAIN FUEL BUNDLE CONNECTION. THE RECALL BEGAN ON JUNE 20, 2005. OWNERS MAY CONTACT FORD AT 1-800-392-3673.
05V135000 · Steering:gear Box:shaft Pitman
Apr 6, 2005
ON CERTAIN CHASSIS CAB TRUCKS, THE STEERING GEAR MAY HAVE SOME GEARS WITH A GEAR PISTON THAT WAS ASSEMBLED WITH AN INCORRECT RE-CIRCULATING BALL TUBE RETAINER. AN INCORRECT RETAINER MAY RESULT IN AN IMPROPERLY RETAINED RE-CIRCULATING BALL TUBE, WHICH MAY NOT KEEP THE RE-CIRCULATING BALLS IN PLACE DURING STEERING GEAR ACTUATION.
Consequence & remedy
Consequence: IF THE RE-CIRCULATING BALLS BECOME DISLODGED A VEHICLE OPERATOR MAY NOTICE NOISE AND INCREASED STEERING EFFORTS THAT MAY EVENTUALLY PROGRESS TO IMPAIRED STEERING OR POTENTIAL LOSS OF STEERING WHICH COULD RESULT IN A CRASH.
Remedy: DEALERS WILL INSPECT THE STEERING GEAR FOR A SPECIFIC DATE CODE AND REPLACE IF NECESSARY FREE OF CHARGE. THE RECALL BEGAN ON APRIL 4, 2005. OWNERS MAY CONTACT AT 1-800-392-3673.
Model-level recall history does not show whether a particular VIN is affected or has received a repair. Check a VIN with NHTSA ↗
NHTSA investigations
0No exact-year investigations in this snapshot.