IllustrationWHEN HITTING A BUMP WHILE TRAVELING ABOVE 65MPH, THE TRUCK WILL GO INTO AN UNCONTROLLABLE SHAPE (DEATH WOBBLE) UNTIL YOU SLOW TO BELOW 50MPH
2013 Ford F-350
Owner reports · Recalls · Investigations
Similar to other model years
Owner complaints for the 2013 Ford F-350 do not stand out strongly from the model-year median of 93.
About this comparison →How this year compares
Owner complaints by model year
Compare all F-350 years →Counts vary with age, sales and reporting. They are not failure rates.
What owners reported most
All reported categories
Tap a category to read its complaints. One report may name several components.
When problems were reported
Mileage at the reported incident
60–25K
525–50K
850–75K
1175–100K
11100–150K
2150K+
43 reports with mileage · 33 unknown
NHTSA’s mileage field refers to the reported incident, not necessarily the filing date. This shows report counts, not the likelihood of a failure.
What to inspect
Issues worth paying extra attention to based on owner reports.
- Steering. Review the 30 owner reports in this category and discuss these concerns during a pre-purchase inspection. Read reports →
- Suspension. Review the 30 owner reports in this category and discuss these concerns during a pre-purchase inspection. Read reports →
- Engine. Review the 15 owner reports in this category and discuss these concerns during a pre-purchase inspection. Read reports →
NHTSA owner reports · September 18, 2026 snapshot.
1 crash reports4 fire reports1 injury reports
What owners actually said
76 reportsSTEERING STARTS TO SHAKE ANYWHERE FROM 30 MPH TO 70MPH
2 WEEKS AGO I GOT THE TERRIBLE "DEATH WOBBLE" AND ALMOST WRECKED THE TRUCK AS WELL AS ME ALMOST HAVING A HEART ATTACK . I WAS GOING 60 MPH (SPEED LIMIT IS 65) ON A DUAL LANE HIGHWAY AND HIT A SMALL POTHOLE AND HIT THE BRAKES MAKING IT 10 TIMES WORSE. I PULLED OVER TO THE SIDE OF THE ROAD AND CHECKED EVERYTHING OUT AND IT SEEMED …
Read full complaint
2 WEEKS AGO I GOT THE TERRIBLE "DEATH WOBBLE" AND ALMOST WRECKED THE TRUCK AS WELL AS ME ALMOST HAVING A HEART ATTACK . I WAS GOING 60 MPH (SPEED LIMIT IS 65) ON A DUAL LANE HIGHWAY AND HIT A SMALL POTHOLE AND HIT THE BRAKES MAKING IT 10 TIMES WORSE. I PULLED OVER TO THE SIDE OF THE ROAD AND CHECKED EVERYTHING OUT AND IT SEEMED TO BE OK. HAD IT CHECKED OUT BY A MECHANIC FRIEND AND WE REPLACED THE STEERING STABILIZER. DID GOOD FOR 2 WEEKS AND RAN UP ON STOPPED TRAFFIC AND THE WORST HAPPENED TWICE AS BAD AS THE FIRST TIME. TRUCK HAS 57,000 MILES AND I AM THE 2ND OWNER AND HAD NEVER EXPERIENCED THIS UNTIL NOW. I RESEARCHED THIS AND FOUND OUT ABOUT THE DEATH WOBBLE AND IT SEEMS LIKE THERE ARE MANY OTHERS WITH THE SAME PROBLEM AND SEEMS TO BE NO REPAIR FOR IT. MAYBE THE BEST FIX IS TO BUY A NEW OTHER BRAND TYPE OF TRUCK. I HAVE BEEN A FAITHFUL FORD BUYER UNTIL THIS HAS COME UP UNLESS THERE IS A RECALL OR REPAIR TO BE MADE
MY WIFE WAS DRIVING FROM A DOCTOR'S APPOINTMENT WHEN THE TRUCK JUST DIED. SHE PULLED TO THE SIDE THEN SHE CALLED ME. THE TRUCK CRANKED BUT WOULDN'T START SO IT WAS TOWED TO HEALEY /FORD LINCOLN IN GOSHEN, N.Y.. AFTER A WEEK OR SO THEY CALL ME GAVE SOME CODES R/REFUEL SYSTEM, THEY SAID THEY NEEDE MY APPROVAL TO DIAGNOSE IT BUT I …
Read full complaint
MY WIFE WAS DRIVING FROM A DOCTOR'S APPOINTMENT WHEN THE TRUCK JUST DIED. SHE PULLED TO THE SIDE THEN SHE CALLED ME. THE TRUCK CRANKED BUT WOULDN'T START SO IT WAS TOWED TO HEALEY /FORD LINCOLN IN GOSHEN, N.Y.. AFTER A WEEK OR SO THEY CALL ME GAVE SOME CODES R/REFUEL SYSTEM, THEY SAID THEY NEEDE MY APPROVAL TO DIAGNOSE IT BUT I DECLINED BECAUSE JUST FOR THAT WAS GOING TO COST ME 300. TO 500.DOLLARS SO I TOWED THE CAR TO BEDROCK AUTO MATBROOK NY
SEVERAL DIFFERENT TIMES WHILE DRIVING ON THE HIGHWAY AT HIGHWAY SPEEDS RANGING FROM 55 TO 65 MPH I HAVE HIT A SMALL BUMP OR UNEVEN PAVEMENT WHICH HAS CAUSED MY TRUCK TO GO INTO AN UNCONTROLLABLE DEATH WOBBLE. IT SHAKES SO VIOLENTLY THAT I ALMOST LOSE CONTROL AND HAVE TO SLOW TO ALMOST A STOP BEFORE IT QUITS.
A FORD TRUCK "DEATH WOBBLE" ALLEGES F-250 AND F-350 TRUCKS HAVE PROBLEMS WITH THE STEERING LINKAGE AND SUSPENSION SYSTEMS. THE PROPOSED CLASS ACTION LAWSUIT INCLUDES CURRENT AND FORMER OWNERS AND LESSEES OF 2005-2019 FORD F-250 AND F-350 TRUCKS. HOWEVER, THE PLAINTIFF SAYS THE FORD DEALERSHIP DENIED THE WOBBLE PROBLEM AND …
Read full complaint
A FORD TRUCK "DEATH WOBBLE" ALLEGES F-250 AND F-350 TRUCKS HAVE PROBLEMS WITH THE STEERING LINKAGE AND SUSPENSION SYSTEMS. THE PROPOSED CLASS ACTION LAWSUIT INCLUDES CURRENT AND FORMER OWNERS AND LESSEES OF 2005-2019 FORD F-250 AND F-350 TRUCKS. HOWEVER, THE PLAINTIFF SAYS THE FORD DEALERSHIP DENIED THE WOBBLE PROBLEM AND REFUSED TO REPAIR THE TRUCK UNDER WARRANTY. THE FORD TRUCK DEATH WOBBLE LAWSUIT WAS FILED IN THE U.S. DISTRICT COURT FOR THE SOUTHERN DISTRICT OF CALIFORNIA - WILLIAM LESSIN, ET AL., V. FORD MOTOR COMPANY.
TL* THE CONTACT OWNS A 2013 FORD F-350. WHILE DRIVING 75-80 MPH, THE VEHICLE LOST POWER AND STALLED WITHOUT WARNING. THE VEHICLE WAS ABLE TO RESTART. THE VEHICLE WAS TAKEN TO AUTONATION FORD BROOKSVILLE (7200 SOUTH BROAD STREET, BROOKSVILLE, FL 34601, (866) 483-4606), NICK NICHOLAS FORD INC (2901 FL-44, INVERNESS, FL 34453,(352…
Read full complaint
TL* THE CONTACT OWNS A 2013 FORD F-350. WHILE DRIVING 75-80 MPH, THE VEHICLE LOST POWER AND STALLED WITHOUT WARNING. THE VEHICLE WAS ABLE TO RESTART. THE VEHICLE WAS TAKEN TO AUTONATION FORD BROOKSVILLE (7200 SOUTH BROAD STREET, BROOKSVILLE, FL 34601, (866) 483-4606), NICK NICHOLAS FORD INC (2901 FL-44, INVERNESS, FL 34453,(352) 726-1231), AND CRYSTAL FORD (2440 NW, US-19, CRYSTAL RIVER, FL 34428, (352) 795-7371); HOWEVER, THEY WERE UNABLE TO DUPLICATE THE FAILURE. THE VEHICLE WAS NOT DIAGNOSED OR REPAIRED. THE MANUFACTURER WAS CONTACTED AND PROVIDED CASE NUMBER: 24710433W3G5B1. THE CONTACT WAS REFERRED TO A LOCAL DEALER. THE FAILURE MILEAGE WAS 96,000.
WOBBLE VIOLENT SHAKING
I WAS DRIVING APPROXIMATELY 56 MILES PER HOUR ON A HIGHWAY WHEN I EXPERIENCED A HORRIBLE WOBBLE OF THE FRONT END OF THE TRUCK. I IMMEDIATELY STOPPED AND TOOK IT TO THE NEAREST DEALER WHO TOLD ME THAT THEY DID NOT KNOW WHAT COULD HAVE CAUSED THIS. THEY REPLACED ALMOST ALL COMPONENTS IN THE FRONT END OF THE TRUCK INCLUDING THE TRA…
Read full complaint
I WAS DRIVING APPROXIMATELY 56 MILES PER HOUR ON A HIGHWAY WHEN I EXPERIENCED A HORRIBLE WOBBLE OF THE FRONT END OF THE TRUCK. I IMMEDIATELY STOPPED AND TOOK IT TO THE NEAREST DEALER WHO TOLD ME THAT THEY DID NOT KNOW WHAT COULD HAVE CAUSED THIS. THEY REPLACED ALMOST ALL COMPONENTS IN THE FRONT END OF THE TRUCK INCLUDING THE TRACK BAR, STABILIZER, BEARINGS, AND ALL ASSOCIATED BUSHINGS. SEVERAL DAYS LATER I WAS DRIVING ON A DIFFERENT ROAD AROUND 60 MILES PER HOUR AND EXPERIENCED THE SAME ISSUE.
WHEN RUNNING OVER ANY BUMP AT SPEEDS ABOVE 30 MPH, THE FRONT END SHAKES VIOLENTLY. I'VE RECENTLY HAD THE FRONT END ALIGNED BUT THE PROBLEM CONTINUES.
Official recalls
114V498000 · Equipment
Aug 13, 2014
PJ's Truck Bodies & Equipment Co., (PJ's) is recalling certain 2009-2013 Ford F-350, F-450, and F-550 Super Duty chassis modified by PJ's and equipped with certain Muncie Power Products PTO Assemblies. In the affected vehicles, oil may leak from the PTO pressure switch onto a thermal blanket covering the exhaust.
Consequence & remedy
Consequence: The leaking oil may soak into the thermal blanket covering the exhaust, which when combined with heat from exhaust, may result in an increased risk of fire.
Remedy: PJ's has notified owners and dealers will install a new pressure switch kit that moves the switch away from the exhaust system, free of charge. The recall began on August 28, 2014. Owners may contact PJ's customer service at 1-866-475-8782.
Model-level recall history does not show whether a particular VIN is affected or has received a repair. Check a VIN with NHTSA ↗
NHTSA investigations
1RQ14005 · Vehicle Commanded Engine Shutdown
Opened Jan 13, 2015 · Closed Mar 15, 2016
Status: closed (inferred from source dates) · Electrical System:software; Engine; Engine And Engine Cooling:engine:diesel; Engine And Engine Cooling:exhaust System; Engine And Engine Cooling:exhaust System:emission Control
The Office of Defects Investigation (ODI) opened this RQ to investigate allegations that the scope and remedy of safety recall 13V-535 were inadequate. Recall 13V-535 was limited to a relatively small population of Ambulance Package vehicles and ODI received complaints of pickup trucks and Fire Engine Prep Package vehicles being affected by the same defect. Ford manufactured approximately 555,985 subject vehicles between February 22, 2010 and January 30, 2015 that may be affected by defective EGT sensors and Powertrain Control Module (PCM) software calibration. The subject vehicles are equipped with four (4) EGT sensors to monitor engine operating conditions. An EGT sensor fault may produce false exhaust over-temperature signals. If these signals are produced, the Powertrain Control Module (PCM) implements a Failure Management Effects Mode (FMEM) and the driver receives a Stop Safely Now (SSN) system warning on the instrument cluster message center. The FMEM triggers a 70% reduction in available engine power over a period of no more than 45 seconds, during which it may not be possible to accelerate or maintain vehicle speed. The PCM then commands the engine to shut down when vehicle speed reaches approximately 1 mph. There is no immediate restart capability. Depending on the PCM software calibration, ignition key position and ambient temperature conditions, the engine may not restart until the end of a 10-60 minute cool down period.Ford and its component supplier(s) made numerous changes to the PCM software calibration and the design, material and manufacture of the EGT sensors over the period of subject vehicle production. This continuous product improvement affected vehicle performance regarding the alleged defect. Ford acknowledges the defect condition in the subject vehicles but argues that an unreasonable risk to motor vehicle safety is limited to Ambulance Package and Fire Engine Prep Package vehicles where commanded shutdown could impact emergency response and patient care. Ford also argues that the defect trend is in decline. Ford also initiated a new safety recall (15V-175) to address the 13V-535 remedy concerns in the Ambulance Package vehicles and Fire Engine Prep Package vehicles. The 15V-175 remedy reprograms the PCM with a new software calibration that stops a single EGT sensor fault to cause the vehicle to enter the FMEM shutdown mode.Ford also initiated an EPA emissions recall (14E03) for all subject vehicles that reprograms the PCM with the software calibration employed in safety recall 15V-175. Finally, Ford initiated a Customer Satisfaction Program (15M01) providing extended warranty coverage of 8 years or 80,000 miles for the the EGT sensors on certain MY2011-2012 subject vehicles.Due to the EPA emissions recall, that had a 66.6% completion rate in Ford's December 2015 progress report to the EPA, the defect trend is in decline. ODI is not aware of any crashes, deaths or injuries related to the alleged defect.ODI believes the alleged defect poses a safety risk but notes that the EPA emissions recall is addressing the safety problem.Compelling issuance of a duplicate recall would not represent a wise use of agency resources.Accordingly, this Recall Query is closed.This action is not a finding that no defect exists and NHTSA will take further action if such action is warranted.
Additional source detail variants (5)
Electrical System:software
The Office of Defects Investigation (ODI) opened this RQ to investigate allegations that the scope and remedy of safety recall 13V-535 were inadequate. Recall 13V-535 was limited to a relatively small population of Ambulance Package vehicles and ODI received complaints of pickup trucks and Fire Engine Prep Package vehicles being affected by the same defect. Ford manufactured approximately 555,985 subject vehicles between February 22, 2010 and January 30, 2015 that may be affected by defective EGT sensors and Powertrain Control Module (PCM) software calibration. The subject vehicles are equipped with four (4) EGT sensors to monitor engine operating conditions. An EGT sensor fault may produce false exhaust over-temperature signals. If these signals are produced, the Powertrain Control Module (PCM) implements a Failure Management Effects Mode (FMEM) and the driver receives a Stop Safely Now (SSN) system warning on the instrument cluster message center. The FMEM triggers a 70% reduction in available engine power over a period of no more than 45 seconds, during which it may not be possible to accelerate or maintain vehicle speed. The PCM then commands the engine to shut down when vehicle speed reaches approximately 1 mph. There is no immediate restart capability. Depending on the PCM software calibration, ignition key position and ambient temperature conditions, the engine may not restart until the end of a 10-60 minute cool down period.Ford and its component supplier(s) made numerous changes to the PCM software calibration and the design, material and manufacture of the EGT sensors over the period of subject vehicle production. This continuous product improvement affected vehicle performance regarding the alleged defect. Ford acknowledges the defect condition in the subject vehicles but argues that an unreasonable risk to motor vehicle safety is limited to Ambulance Package and Fire Engine Prep Package vehicles where commanded shutdown could impact emergency response and patient care. Ford also argues that the defect trend is in decline. Ford also initiated a new safety recall (15V-175) to address the 13V-535 remedy concerns in the Ambulance Package vehicles and Fire Engine Prep Package vehicles. The 15V-175 remedy reprograms the PCM with a new software calibration that stops a single EGT sensor fault to cause the vehicle to enter the FMEM shutdown mode.Ford also initiated an EPA emissions recall (14E03) for all subject vehicles that reprograms the PCM with the software calibration employed in safety recall 15V-175. Finally, Ford initiated a Customer Satisfaction Program (15M01) providing extended warranty coverage of 8 years or 80,000 miles for the the EGT sensors on certain MY2011-2012 subject vehicles.Due to the EPA emissions recall, that had a 66.6% completion rate in Ford's December 2015 progress report to the EPA, the defect trend is in decline. ODI is not aware of any crashes, deaths or injuries related to the alleged defect.ODI believes the alleged defect poses a safety risk but notes that the EPA emissions recall is addressing the safety problem.Compelling issuance of a duplicate recall would not represent a wise use of agency resources.Accordingly, this Recall Query is closed.This action is not a finding that no defect exists and NHTSA will take further action if such action is warranted.
Engine And Engine Cooling:engine:diesel
The Office of Defects Investigation (ODI) opened this RQ to investigate allegations that the scope and remedy of safety recall 13V-535 were inadequate. Recall 13V-535 was limited to a relatively small population of Ambulance Package vehicles and ODI received complaints of pickup trucks and Fire Engine Prep Package vehicles being affected by the same defect. Ford manufactured approximately 555,985 subject vehicles between February 22, 2010 and January 30, 2015 that may be affected by defective EGT sensors and Powertrain Control Module (PCM) software calibration. The subject vehicles are equipped with four (4) EGT sensors to monitor engine operating conditions. An EGT sensor fault may produce false exhaust over-temperature signals. If these signals are produced, the Powertrain Control Module (PCM) implements a Failure Management Effects Mode (FMEM) and the driver receives a Stop Safely Now (SSN) system warning on the instrument cluster message center. The FMEM triggers a 70% reduction in available engine power over a period of no more than 45 seconds, during which it may not be possible to accelerate or maintain vehicle speed. The PCM then commands the engine to shut down when vehicle speed reaches approximately 1 mph. There is no immediate restart capability. Depending on the PCM software calibration, ignition key position and ambient temperature conditions, the engine may not restart until the end of a 10-60 minute cool down period.Ford and its component supplier(s) made numerous changes to the PCM software calibration and the design, material and manufacture of the EGT sensors over the period of subject vehicle production. This continuous product improvement affected vehicle performance regarding the alleged defect. Ford acknowledges the defect condition in the subject vehicles but argues that an unreasonable risk to motor vehicle safety is limited to Ambulance Package and Fire Engine Prep Package vehicles where commanded shutdown could impact emergency response and patient care. Ford also argues that the defect trend is in decline. Ford also initiated a new safety recall (15V-175) to address the 13V-535 remedy concerns in the Ambulance Package vehicles and Fire Engine Prep Package vehicles. The 15V-175 remedy reprograms the PCM with a new software calibration that stops a single EGT sensor fault to cause the vehicle to enter the FMEM shutdown mode.Ford also initiated an EPA emissions recall (14E03) for all subject vehicles that reprograms the PCM with the software calibration employed in safety recall 15V-175. Finally, Ford initiated a Customer Satisfaction Program (15M01) providing extended warranty coverage of 8 years or 80,000 miles for the the EGT sensors on certain MY2011-2012 subject vehicles.Due to the EPA emissions recall, that had a 66.6% completion rate in Ford's December 2015 progress report to the EPA, the defect trend is in decline. ODI is not aware of any crashes, deaths or injuries related to the alleged defect.ODI believes the alleged defect poses a safety risk but notes that the EPA emissions recall is addressing the safety problem.Compelling issuance of a duplicate recall would not represent a wise use of agency resources.Accordingly, this Recall Query is closed.This action is not a finding that no defect exists and NHTSA will take further action if such action is warranted.
Engine And Engine Cooling:exhaust System:emission Control
The Office of Defects Investigation (ODI) opened this RQ to investigate allegations that the scope and remedy of safety recall 13V-535 were inadequate. Recall 13V-535 was limited to a relatively small population of Ambulance Package vehicles and ODI received complaints of pickup trucks and Fire Engine Prep Package vehicles being affected by the same defect. Ford manufactured approximately 555,985 subject vehicles between February 22, 2010 and January 30, 2015 that may be affected by defective EGT sensors and Powertrain Control Module (PCM) software calibration. The subject vehicles are equipped with four (4) EGT sensors to monitor engine operating conditions. An EGT sensor fault may produce false exhaust over-temperature signals. If these signals are produced, the Powertrain Control Module (PCM) implements a Failure Management Effects Mode (FMEM) and the driver receives a Stop Safely Now (SSN) system warning on the instrument cluster message center. The FMEM triggers a 70% reduction in available engine power over a period of no more than 45 seconds, during which it may not be possible to accelerate or maintain vehicle speed. The PCM then commands the engine to shut down when vehicle speed reaches approximately 1 mph. There is no immediate restart capability. Depending on the PCM software calibration, ignition key position and ambient temperature conditions, the engine may not restart until the end of a 10-60 minute cool down period.Ford and its component supplier(s) made numerous changes to the PCM software calibration and the design, material and manufacture of the EGT sensors over the period of subject vehicle production. This continuous product improvement affected vehicle performance regarding the alleged defect. Ford acknowledges the defect condition in the subject vehicles but argues that an unreasonable risk to motor vehicle safety is limited to Ambulance Package and Fire Engine Prep Package vehicles where commanded shutdown could impact emergency response and patient care. Ford also argues that the defect trend is in decline. Ford also initiated a new safety recall (15V-175) to address the 13V-535 remedy concerns in the Ambulance Package vehicles and Fire Engine Prep Package vehicles. The 15V-175 remedy reprograms the PCM with a new software calibration that stops a single EGT sensor fault to cause the vehicle to enter the FMEM shutdown mode.Ford also initiated an EPA emissions recall (14E03) for all subject vehicles that reprograms the PCM with the software calibration employed in safety recall 15V-175. Finally, Ford initiated a Customer Satisfaction Program (15M01) providing extended warranty coverage of 8 years or 80,000 miles for the the EGT sensors on certain MY2011-2012 subject vehicles.Due to the EPA emissions recall, that had a 66.6% completion rate in Ford's December 2015 progress report to the EPA, the defect trend is in decline. ODI is not aware of any crashes, deaths or injuries related to the alleged defect.ODI believes the alleged defect poses a safety risk but notes that the EPA emissions recall is addressing the safety problem.Compelling issuance of a duplicate recall would not represent a wise use of agency resources.Accordingly, this Recall Query is closed.This action is not a finding that no defect exists and NHTSA will take further action if such action is warranted.
Engine And Engine Cooling:exhaust System
The Office of Defects Investigation (ODI) opened this RQ to investigate allegations that the scope and remedy of safety recall 13V-535 were inadequate. Recall 13V-535 was limited to a relatively small population of Ambulance Package vehicles and ODI received complaints of pickup trucks and Fire Engine Prep Package vehicles being affected by the same defect. Ford manufactured approximately 555,985 subject vehicles between February 22, 2010 and January 30, 2015 that may be affected by defective EGT sensors and Powertrain Control Module (PCM) software calibration. The subject vehicles are equipped with four (4) EGT sensors to monitor engine operating conditions. An EGT sensor fault may produce false exhaust over-temperature signals. If these signals are produced, the Powertrain Control Module (PCM) implements a Failure Management Effects Mode (FMEM) and the driver receives a Stop Safely Now (SSN) system warning on the instrument cluster message center. The FMEM triggers a 70% reduction in available engine power over a period of no more than 45 seconds, during which it may not be possible to accelerate or maintain vehicle speed. The PCM then commands the engine to shut down when vehicle speed reaches approximately 1 mph. There is no immediate restart capability. Depending on the PCM software calibration, ignition key position and ambient temperature conditions, the engine may not restart until the end of a 10-60 minute cool down period.Ford and its component supplier(s) made numerous changes to the PCM software calibration and the design, material and manufacture of the EGT sensors over the period of subject vehicle production. This continuous product improvement affected vehicle performance regarding the alleged defect. Ford acknowledges the defect condition in the subject vehicles but argues that an unreasonable risk to motor vehicle safety is limited to Ambulance Package and Fire Engine Prep Package vehicles where commanded shutdown could impact emergency response and patient care. Ford also argues that the defect trend is in decline. Ford also initiated a new safety recall (15V-175) to address the 13V-535 remedy concerns in the Ambulance Package vehicles and Fire Engine Prep Package vehicles. The 15V-175 remedy reprograms the PCM with a new software calibration that stops a single EGT sensor fault to cause the vehicle to enter the FMEM shutdown mode.Ford also initiated an EPA emissions recall (14E03) for all subject vehicles that reprograms the PCM with the software calibration employed in safety recall 15V-175. Finally, Ford initiated a Customer Satisfaction Program (15M01) providing extended warranty coverage of 8 years or 80,000 miles for the the EGT sensors on certain MY2011-2012 subject vehicles.Due to the EPA emissions recall, that had a 66.6% completion rate in Ford's December 2015 progress report to the EPA, the defect trend is in decline. ODI is not aware of any crashes, deaths or injuries related to the alleged defect.ODI believes the alleged defect poses a safety risk but notes that the EPA emissions recall is addressing the safety problem.Compelling issuance of a duplicate recall would not represent a wise use of agency resources.Accordingly, this Recall Query is closed.This action is not a finding that no defect exists and NHTSA will take further action if such action is warranted.
Engine
The Office of Defects Investigation (ODI) opened this RQ to investigate allegations that the scope and remedy of safety recall 13V-535 were inadequate. Recall 13V-535 was limited to a relatively small population of Ambulance Package vehicles and ODI received complaints of pickup trucks and Fire Engine Prep Package vehicles being affected by the same defect. Ford manufactured approximately 555,985 subject vehicles between February 22, 2010 and January 30, 2015 that may be affected by defective EGT sensors and Powertrain Control Module (PCM) software calibration. The subject vehicles are equipped with four (4) EGT sensors to monitor engine operating conditions. An EGT sensor fault may produce false exhaust over-temperature signals. If these signals are produced, the Powertrain Control Module (PCM) implements a Failure Management Effects Mode (FMEM) and the driver receives a Stop Safely Now (SSN) system warning on the instrument cluster message center. The FMEM triggers a 70% reduction in available engine power over a period of no more than 45 seconds, during which it may not be possible to accelerate or maintain vehicle speed. The PCM then commands the engine to shut down when vehicle speed reaches approximately 1 mph. There is no immediate restart capability. Depending on the PCM software calibration, ignition key position and ambient temperature conditions, the engine may not restart until the end of a 10-60 minute cool down period.Ford and its component supplier(s) made numerous changes to the PCM software calibration and the design, material and manufacture of the EGT sensors over the period of subject vehicle production. This continuous product improvement affected vehicle performance regarding the alleged defect. Ford acknowledges the defect condition in the subject vehicles but argues that an unreasonable risk to motor vehicle safety is limited to Ambulance Package and Fire Engine Prep Package vehicles where commanded shutdown could impact emergency response and patient care. Ford also argues that the defect trend is in decline. Ford also initiated a new safety recall (15V-175) to address the 13V-535 remedy concerns in the Ambulance Package vehicles and Fire Engine Prep Package vehicles. The 15V-175 remedy reprograms the PCM with a new software calibration that stops a single EGT sensor fault to cause the vehicle to enter the FMEM shutdown mode.Ford also initiated an EPA emissions recall (14E03) for all subject vehicles that reprograms the PCM with the software calibration employed in safety recall 15V-175. Finally, Ford initiated a Customer Satisfaction Program (15M01) providing extended warranty coverage of 8 years or 80,000 miles for the the EGT sensors on certain MY2011-2012 subject vehicles.Due to the EPA emissions recall, that had a 66.6% completion rate in Ford's December 2015 progress report to the EPA, the defect trend is in decline. ODI is not aware of any crashes, deaths or injuries related to the alleged defect.ODI believes the alleged defect poses a safety risk but notes that the EPA emissions recall is addressing the safety problem.Compelling issuance of a duplicate recall would not represent a wise use of agency resources.Accordingly, this Recall Query is closed.This action is not a finding that no defect exists and NHTSA will take further action if such action is warranted.