AS I WAS TOWING A TRAILER IN THE 2012 FORD F-350 ON A TWO-LANE HIGHWAY (US-95 NORTH OF LAS VEGAS), THE TRUCK SUDDENLY CHIMED AND SAID TO PULL OVER AND SHUTTING DOWN. IT SHUT OFF BEFORE I COULD REACT. I HAD ENOUGH MOMENTUM TO CLEAR A BRIDGE AND PULL OVER WHILE COASTING. THE STRETCH OF ROAD THAT I WAS ON IS DESOLATE AND USED BY…
Read full complaint
AS I WAS TOWING A TRAILER IN THE 2012 FORD F-350 ON A TWO-LANE HIGHWAY (US-95 NORTH OF LAS VEGAS), THE TRUCK SUDDENLY CHIMED AND SAID TO PULL OVER AND SHUTTING DOWN. IT SHUT OFF BEFORE I COULD REACT. I HAD ENOUGH MOMENTUM TO CLEAR A BRIDGE AND PULL OVER WHILE COASTING. THE STRETCH OF ROAD THAT I WAS ON IS DESOLATE AND USED BY BIG RIGS ALL THE TIME. LUCKILY, THERE WAS LITTLE TRAFFIC AT THE TIME OF THE INCIDENT, BUT IT COULD HAVE CAUSED AN ACCIDENT DUE TO THE POWERING OFF OF THE VEHICLE. I HAD NO POWER STEERING OR POWER BRAKES. I CHECKED THE CODE AND FOUND THAT ONE OF THE EGT SENSORS WAS BAD. DUE TO BEING AN INFORMED OWNER, I KNEW THAT THESE TRUCKS HAVE HAD EGT SENSOR ISSUES AND I HAD PURCHASED 2 FOR BACKUP PURPOSES. I WAITED A WHILE FOR THE TRUCK TO COOL DOWN, REPLACED THE FAILED SENSOR. I CLEARED THE CODES AND THE TRUCK STARTED UP WITHOUT ANY ISSUES. I WAS ABLE TO CONTINUE MY JOURNEY. THE REPLACEMENT SENSOR LASTED LONG ENOUGH TO TRADE IN THE TRUCK IN ON NOVEMBER 2014. *TR
NHTSA ODI #10677010
77,000 miles · Oct 3, 2014
Engine And Engine CoolingFuel/propulsion System
HELLO, I WOULD LIKE TO REPORT A MAJOR SAFETY PROBLEM WITH THE 2012 F350 FORD SUPER DUTY TRUCKS WITH THE 6.7 POWER STROKE DIESEL MOTOR. WE WERE TRAVELING ON HIGHWAY 72 IN ATHENS, LIMESTONE COUNTY, ALABAMA. A MESSAGE CAME UP ON DISPLAY THAT SAID "STOP SAFELY NOW". BEFORE I COULD EVEN STOP THE TRUCK SHUT ITSELF OFF IN THE MIDDL…
Read full complaint
HELLO, I WOULD LIKE TO REPORT A MAJOR SAFETY PROBLEM WITH THE 2012 F350 FORD SUPER DUTY TRUCKS WITH THE 6.7 POWER STROKE DIESEL MOTOR. WE WERE TRAVELING ON HIGHWAY 72 IN ATHENS, LIMESTONE COUNTY, ALABAMA. A MESSAGE CAME UP ON DISPLAY THAT SAID "STOP SAFELY NOW". BEFORE I COULD EVEN STOP THE TRUCK SHUT ITSELF OFF IN THE MIDDLE OF THE HIGHWAY. THERE WE SAT, IN THE MIDDLE OF THE HIGHWAY WITH A TRUCK THAT WOULD NOT RUN. WE HAD TO GET OUT AND PUSH THE THING OUT OF THE ROAD. PLEASE REFER TO SAFETY RECALL NOTICE 13S10 / NHTSA RECALL 13V525. THIS RECALL DESCRIBES THE PROBLEM WE ARE HAVING, BUT THIS RECALL IS FOR AMBULANCES ONLY. WHY WOULD FORD ONLY RECALL AMBULANCES WHEN ALL OF THEIR 2012 F350 SUPER DUTY POWER STROKES MOTORS HAVE THIS SAME MAJOR SAFETY PROBLEM. OUR SAFETY WAS A RISK HERE AND I WANT SOME ANSWERS. THE TRUCK HAS A DEFECT THAT NEEDS TO BE CORRECTED, NOW BEFORE SOMEONE IS KILLED. I WOULD RATHER HAVE THE TRUCK MOTOR MELT DOWN AS TO BE STUCK IN THE MIDDLE OF THE HIGHWAY. A CORRECTION HAVE BEEN MADE TO THE 2013 MODELS TO PREVENT THIS FROM HAPPENING WITH THOSE MODELS, BUT NOTHING HAS BEEN DONE TO CORRECT THIS ISSUE WITH OUR TRUCK. [XXX] INFORMATION REDACTED PURSUANT TO THE FREEDOM OF INFORMATION ACT (FOIA), 5 U.S.C. 552(B)(6). *TR
Jerr-Dan Corporation (Jerr-Dan) is recalling certain model year 2009-2014 Ford F-350 Super Duty, F-450 Super Duty, and F-550 Superduty chassis modified by Jerr-Dan and equipped with certain Muncie Power Products PTO Assemblies. In the affected vehicles, oil may leak from the PTO pressure switch onto a thermal blanket covering the exhaust.
Consequence & remedy
Consequence: The leaking oil may soak into the thermal blanket covering the exhaust, which when combined with heat from exhaust, may result in an increased risk of fire.
Remedy: Jerr-Dan will notify owners, and dealers will install a new pressure switch kit that moves away from the exhaust system, free of charge. The recall began in October 2014. Owners may contact Jerr-Dan customer service at 1-800-926-9666.
Versalift East, LLC (Versalift) is recalling certain Aerial devices manufactured on 2009-2013 Ford, F-350, F-450, and F-550 Super Duty 6.8L gas engine chassis, modified by Versalift and equipped with certain Muncie Power Products FR67 PTO Assemblies. In the affected vehicles, oil may leak from the PTO pressure switch onto a thermal blanket covering the exhaust.
Consequence & remedy
Consequence: The leaking oil may soak into the thermal blanket covering the exhaust, which when combined with heat from exhaust, may result in an increased risk of fire.
Remedy: Versalift will notify owners, and dealers will install a new pressure switch kit that moves the switch away from the exhaust system, free of charge. The recall began on September 14, 2014. Owners may contact Versalift customer service at 1-888-866-1400.
Vanair Manufacturing, Inc. (Vanair) is recalling certain model year 2009-2013 Ford F-350, F-450, and F-550 SuperDuty chassis modified by Vanair and equipped with certain Muncie Power Products PTO Assemblies used with model 60-85 UDSM, 125-185 USDM, and Genair 125-185 driven air compressor systems. In the affected vehicles, oil may leak from the PTO pressure switch onto a thermal blanket covering the exhaust.
Consequence & remedy
Consequence: The leaking oil may soak into the thermal blanket covering the exhaust, which when combined with heat from exhaust, may result in an increased risk of fire.
Remedy: Vanair will notify owners, and dealers will inspect and install a new pressure switch kit that moves the switch away from the exhaust system, free of charge. The recall began in November 2014. Owners may contact Vanair customer service at 1-800-526-8817.
Model-level recall history does not show whether a particular VIN is affected or has received a repair. Check a VIN with NHTSA ↗
NHTSA investigations
0
No exact-year investigations in this snapshot.
2012 Ford F-350 Super Duty Problems, Complaints & Recalls | Skip That Year
Illustration