2022 Ford F-350 Sd

The contact owns a 2022 Ford F-350 SD. The contact stated while starting the vehicle with the brake pedal depressed, the RPM rose to the RED line. The contact turned off the vehicle and then restarted the vehicle made sure that the accelerator pedal was not depressed. After restarting the vehicle with the brake pedal depressed, the RPMs increased immediately, and the vehicle lunged forward. The contact placed the vehicle into drive which had caused the RPMs to immediately decrease. The vehicle was taken to the dealer however, the mechanic was unable to determine the cause of the failure due to not being able to duplicate the failure. The dealer did not have the diesel mechanic-certified staff needed to repair the vehicle. The vehicle had not been repaired. The vehicle was towed to another dealer who had the diesel mechanic-certified staff needed for the repair. The second dealer was unable to determine the cause of the failure. The vehicle had not been repaired due to an aftermarket air intake. The manufacturer had not been made aware of the failure. The failure mileage was 7,420.

Driving down the highway, I noticed my steering wheel was loose. As I continued driving the steering wheel became more loose. It was difficult to steer, I had to hold the steering wheel tight to the column in order to keep control. I was 2 miles from home when it became this bad. I slowed downand was able to manuever into the driveway. I had the truck towed to Caskinette Ford in Carthage, NY. I am awaiting information on what part failed and allowed the steering wheel to become loose. I am lucky I was able to maintain the vehicle in the lane and was not towing at this time. I could have easily lost control and been in a serious situation with myself, my family, and other vehicles on the roadway. There were no warning lamps of any kind. There was no symptom prior to failure, it just happened going down the road.

I purchased this truck brand new in August 2022. I have performed routine preventive maintenance on it as prescribed by the manufacturer. (FORD) At just over 96,000 miles and just days after a professional oil change service, the truck began to misfire and the check engine light came on. I took it to the dealer that i purchased it from and they diagnosed a lifter and cam shaft failure. (A delamination problem.) I've researched it online and have discovered that it is a pretty common issue with this relatively new engine. I've contacted Ford consumer affairs and filed a complaint and as of yesterday Dec 14, 2023 they finally got an answer for me. They are offering to pay $5400.00 of a almost $15,000 repair. I cannot afford this! I take their offer as an admission of liabilty and that they know of the problem. As common as this is becoming I believe there should be a recall on this 7.3 litre gas engine. One blogger on the internet estimates that about 20,000 of these engines have had this same issue already. (So far) I believe it to be a defect in the parts and not a lubrication issue because its happening in different cylinders. Mine is cylinder #2. I know for a fact that this engine is being used in motor homes and RVs that won't have the 30 to 50 thousand miles on them to make this problem show itself for probably several years. Google; "Ford 7.3L problems" or "Ford 7.3L lifter and cam issues" and see for yourself what I have read. I use this truck to make a living, I paid $60,000.00 for it and expected it to last over 300,000 miles. I tried to upload photos and emails but it wouldn't allow me to. Please help!

What component or system failed or malfunctioned, and is it available for inspection upon request? Transfer case shift motor failure, transmission slipping in 3,2,1 gear and when accelerating from 7-8 gear. Electronics on dash have gone out while driving multiple times. Tailgate opened up while driving multiple times. Trailer brake. Drivers side faulty window (glass) fracture across entire window when not moving. Yes, all can be inspected or paper work reviewed for repairs complete. How was your safety or the safety of others put at risk? Could not use 4 wheel drive in icy/snowy conditions to get to destination. Transmission slipping caused my foot to come off brake pedal and immediately had to reengage brake pedal due to the force of the transmission slipping (like the transmission was falling out from under the truck), nearly hitting the car in front of me on both occasions. Has the problem been reproduced or confirmed by a dealer or independent service center? Yes. All issues have been confirmed by local Ford dealer and fixed by certified Ford mechanic, but once issue is repaired, the electronics issues and transmission issue continue to arise (exact same issues). Has the vehicle or component been inspected by the manufacturer, police, insurance representatives or others? Yes, by the dealership (Ford representatives). Were there any warning lamps, messages or other symptoms of the problem prior to the failure, and when did they first appear? No, no warning signs for any of the defects other than a letter for the tailgate recall, brake recall and wiper recall.

Well, driving truck at speeds of 60 mph developed wobble. After slowing down wobble went away after about a 10th of a mile. Incident does not happen when I travel under 50 mph. Has happened several times. I researched this topic on Internet and Ford claims to fix this problem in the year 2020. They claim vehicles after that year will not have this.

The contact owns a 2022 Ford F-350 SD. The contact stated while driving at approximately 45 MPH, the temperature gauge started rising quickly. The engine overheated message was displayed. The vehicle had been taken to the dealer who diagnosed and determined that there was coolant leaking into the cylinders and might have been caused by a defective head gasket. The dealer was unable to identify the exact location of the leak. The contact was informed that the engine needed to be replaced. The vehicle had not been repaired. The manufacturer was made aware of the failure. The approximate failure mileage was 317.

25X12.00B9 IMP. THE TIRE WENT FLAT WITH NO SIGNS OF DAMAGE. REMOVED TIRE AND TOOK TO BELLE TIRE, BROWNSBURG, IN IN WHICH DAMEON THOMAS, MANAGER STATED THAT THERE WERE CRAKES INSIDE THE TIRE WHICH WAS A MANUFACTURING DEFECT. IN THE LAST 30 DAYS HE HAD SEEN OVER 70 TIRES WITH THIS PROBLEM. HE CONTACTED YOKOHAMA DIRECTLY AND THEY REFUSED TO DO ANYTHING. THESE TIRES HAVE LESS THAN 4000 MILES. WAITED A TOTAL 5 WEEKS FOR THEM TO TELL US THEY WILL DO NOTHING. TOOK VEHICLE TO COSTCO AND HAD 4 NEW FIRESTONE TIRES MOUNTED FOR A COST OF $1815.79. COSTCO STATED THAT ALL OF THE TIRES ARE DEFECTIVE AND COULD HAVE BLOWN WHILE DRIVING. WE HAVE THE 4 TIRES IN OUR POSSION. WE ARE ASKING FOR A REFUND OF THE COST OF NEW TIRES AND LOSS OF USE OF THE VEHICLE.

The contact owns a 2022 Ford F-350 SD. The contact stated while driving 20 MPH and hauling a trailer, the transmission shifted rough. The vehicle was taken to the dealer and the contact was informed that the transmission was failing and needed to be repaired. The vehicle was not repaired. The vehicle was taken to another dealer and the contact was informed that the transmission control module needed to be rebooted. The TCM was rebooted, but the failure reoccurred. The vehicle was taken to the dealer, but no failure was found. The vehicle was not repaired. The manufacturer was contacted, and the contact was informed that the failure might be due to the trailer that was being towed. The failure mileage was 22,327.

Today 9/6/23 at 9:20pm I was driving 65mph on the highway and hit a medium sized pot hole. This caused my front end to violently shake back and forth over a prolonged period of time causing me to loose control of my vehicle. I was able to brake and the shaking stopped around 20mph while I was on the highway. This has happened to me once before almost causing an accident. Neither time was I speeding, over loaded, or driving erratically. The pot holes were things I had seen but not avoided as were are not something that has ever caused a problem for me while driving any other vehicle. I have driven daily for over 10 years.