2022 Ford F-350 Sd

While traveling with my fifth-wheel camper attached, my 2022 Ford F-350 Super Duty (6.7L Power Stroke) suddenly developed a complete no-crank condition. Prior to the failure, the vehicle displayed multiple electrical warnings, including U0100 (Lost Communication with PCM), High Engine Temperature, AdvanceTrac, Blind Spot System Fault, Hill Start Assist, and Pre-Collision Assist warnings. The vehicle ultimately became disabled and would not crank or start, leaving me stranded away from home while towing a trailer. Repair Description After troubleshooting the vehicle, I discovered severe internal corrosion inside the under-hood Battery Junction Box (BJB). The corrosion appeared consistent with Ford Technical Service Bulletin 23-2133 regarding moisture intrusion into the Battery Junction Box on certain 2020–2022 Super Duty trucks. I purchased a genuine Ford replacement Battery Junction Box from a Ford dealership and installed it. Immediately after replacement, the vehicle started normally and all warning messages disappeared. I retained the failed Battery Junction Box and have photographs documenting the internal corrosion. Safety Concern My concern is not simply the repair cost but the safety implications of this failure. The vehicle became completely disabled while towing a fifth-wheel trailer during travel. A sudden electrical failure affecting the Battery Junction Box can leave occupants stranded and may create hazardous situations if it occurs in remote locations or during travel. Because Ford has issued a Technical Service Bulletin addressing moisture intrusion into the Battery Junction Box, I believe this condition should be evaluated to determine whether additional action is warranted.

The contact owns a 2022 Ford F-350. The contact stated while driving at an undisclosed speed, the trailor lights and the brake lights failed to function as intended. No warning lights were ullimunated. The vehicle was taken to the dealer where it was diagnosed with a malfunction with the trailor brakes and service brakes. The contact was informed that the parts were unavailable. The vehicle was not repaired. The contact received a recall notification, NHTSA Campaign Number 22V193000 Electrical System) however the parts were unavailable.

Charging System Fault. Caused multiple error messages like Forward camera not available, collision avoidance not available. Then Radio goes black and reboots. Several cycles later the dash board goes DARK. No speed or RPM anything visible for 5-10 secs, and on some reboots this Dark dash lasted 30 seconds. Thankfully while traveling at midnight the head lights and tail lights remain on, just no interior lights during these Reboots. New batteries made no difference.

While flat towing my 2022 Ford F‑350 behind a motorhome using Ford’s Neutral Tow Mode procedure, the vehicle suffered a catastrophic transmission failure. The Ford dealer documented this clearly on the service invoice: “HAPPENED WHILE THE VEHICLE WAS FLAT TOWED.” After the tow, the truck had severe slipping, delayed engagement, high RPM with no movement, and a wrench light. The dealer confirmed fault codes P0741, P1744, and P27B4. The dealer found catastrophic internal damage: “fluid is burnt with metal debris… filter is packed with metal debris… torque converter has came apart and filled transmission with metal debris… it is catastrophic failure.” These components are available for inspection. The dealer also documented a low battery condition: “batteries. low state of charge.” Ford’s Neutral Tow Mode relies on electronic control modules that require stable voltage, but Ford provides no warning that low voltage can cause the transfer case to exit Neutral Tow Mode. This creates a safety risk because the transmission can be rotated internally without lubrication while being towed, which can lead to sudden drivetrain lockup or loss of control. The problem was confirmed by the Ford dealer, and the vehicle was fully inspected by them. The only warning symptom occurred after towing: wrench light, slipping, and no movement. There were no warnings during the tow itself. This failure mode is not disclosed by Ford and cannot be detected or prevented by the owner.

The contact owns a 2022 Ford F-350 SD. The contact stated that while attempting to accelerate from a complete stop, the vehicle lost power. There was no warning light illuminated. The vehicle was able to restart. The contact received notification of NHTSA Campaign Numbers: 25V455000 (Fuel System, Gasoline), 25V686000 (Back Over Prevention), 26V104000 (Electrical System, Exterior Lighting), and 26V204000 (Visibility); however, the parts to do the recall repairs were not yet available. The vehicle was taken to the dealer but was not diagnosed or repaired. The dealer stated that parts were not yet available. The contact stated that the manufacturer had exceeded a reasonable amount of time for the recall repair. The manufacturer was not made aware of the failure. The failure mileage was approximately 30,000.

The contact owns a 2022 Ford F-350 SD. While driving at an undisclosed speed and hauling a trailer, there was a delay with the trailer brakes before the trailer brakes engaged, causing the braking distance to be extended. Occasionally, the trailer brakes failed to engage, causing the electric brakes to activate and stop the vehicle. The contact became aware of NHTSA Campaign Number: 25V132000 (Electrical System) on the NHTSA.GOV website, which referenced a similar failure. The dealer was made aware of the failure. The dealer informed the contact that the VIN was not included in the recall. The vehicle was not diagnosed or repaired. The manufacturer was made aware of the failure and confirmed that the VIN was not included in the recall. The manufacturer opened a case for the failure; however, no assistance was provided. The failure mileage was approximately 94,000.

Synce 4 infotainment center with loose connection to phone causing phone to connect and disconnect and become statickey while driving. Ford dealerships when contacted do not have a fix and two dealers have said its a very common issue but no fix for it. safety risk is that while you think your hands free on the phone when it goes in and out of connection can cause a major distraction while driving. I have had two dealers provide feedback that this is an issue but not one that has a fix that they can do. It has not been inspected by police or insurance agent there is no warning lamps that have gone off

The contact owns a 2022 Ford F-350. The contact stated that while stopped at a traffic signal with his foot on the brake pedal, the vehicle suddenly accelerated as if he had applied the accelerator. The contact stated that his vehicle front end crashed into the rear end of the vehicle. The contact stated that he turned the vehicle off to stop it from continuing to gain forward momentum. The contact stated that he was able to restart the vehicle and pulled over. The contact stated that his lower front bumper was dented and had scratches. The contact stated that the vehicle he had crashed into had damage to the tail gate and rear bumper. The contact stated that no one was injured and both vehicles were able to drive away. The police were not called. The contact stated that prior to the crash the vehicle was having multiple electrical failures and numerous warning lights had illuminated. The contact had taken the vehicle to a local dealer, where it was diagnosed and determined that the transmission needed to be rebuilt. The vehicle repaired, however the contact stated that he was still having warning lights and that the vehicle was shifting roughly from park (P) to drive (D) or from park (P) to reverse (R). Additionally, the contact stated that the accelerator pedal was failing to respond when he applied the pedal. The contact had taken the vehicle back to the same dealer who replaced the battery junction box. The contact stated that the dealer had replaced the battery junction box according to a manufacturer technical service bulletin number 23-2133 (Electrical System). The contact stated that prior to the crash, again the accelerator pedal failed to respond when he applied the pedal. The contact stated that he had used a hand held scanner and was getting codes for electrical system failures, ignition cylinder codes, ABS faults, Body Control Module throttle control codes. The vehicle was taken back to the same dealer and was not repaired. The manufacturer was informed of the failure and advised the dealer not conti