I OWN A 2006 FORD F-350 KING RANCH CREW CAB FOUR WHEEL DRIVE TRUCK. I AM THE ORIGINAL OWNER. A FEW TIMES THROUGH OUT THE YEARS THERE HAD BEEN A SHAKE AFTER HITTING A BUMP IN THE ROAD AT 60MPH+. WE RECEIVED A LETTER NOTING A POTENTIAL PROBLEM. WE BROUGHT THE TRUCK TO THE DEALER AND THEY REPLACED BRAKES AND 2 TIRES (OTHER 2 HAD B…
Read full complaint
I OWN A 2006 FORD F-350 KING RANCH CREW CAB FOUR WHEEL DRIVE TRUCK. I AM THE ORIGINAL OWNER. A FEW TIMES THROUGH OUT THE YEARS THERE HAD BEEN A SHAKE AFTER HITTING A BUMP IN THE ROAD AT 60MPH+. WE RECEIVED A LETTER NOTING A POTENTIAL PROBLEM. WE BROUGHT THE TRUCK TO THE DEALER AND THEY REPLACED BRAKES AND 2 TIRES (OTHER 2 HAD BEEN REPLACED PREVIOUSLY) AND WHEN WE DROVE IT HOME IT STARTED "THE DEATH WOBBLE" (AS THE DEALER CALLS IT-AND AS I SEE MANY OTHERS ON THE INTERNET). THE TRUCK STARTED EXPERIENCING VIOLENT FRONT-END SHAKING. DURING AN EPISODE OF LEFT-TO-RIGHT SHAKING, THE TRUCK IS VERY DIFFICULT TO CONTROL. WITH MY HAND PLACED ON THE 12:00 POSITION ON THE STEERING WHEEL, THE SHAKING VIOLENTLY TURNS THE STEERING WHEEL TO WHERE MY HAND IS GOING BACK AND FORTH BETWEEN 10:00 AND 2:00. SLOWING DOWN TO 30MPH HAS STOPPED EACH OF THE THREE EPISODES. THIS TRUCK HAS DEALER INSTALLED TIRES AND DOES NOT HAVE A LIFT KIT ON IT. AIR PRESSURE IN THE TIRES EQUAL MANUFACTURERS RECOMMENDATION. THEY ACTED AS IF THIS IS AN UNCOMMON PROBLEM AT FIRST, AND SAID THEY HAVE NEVER HEARD OF A LETTER THAT WENT OUT. THEN THE NEXT VISIT THEY SAY SO COMMONLY, THAT IT IS THE DEATH WOBBLE AND WILL COST $1500. IT APPEARS THAT FORD MOTOR COMPANY HAS BLAMED TIRE PRESSURE, GIANT AFTERMARKET TIRES, AND LIFT KITS FOR THIS PROBLEM. MY TRUCK HAS NONE OF THESE POSSIBLE CAUSES. *TR
NHTSA ODI #10498268
165,700 miles · Jun 23, 2012
SteeringSuspensionWheels
I WAS TRAVELING NORTH ON I59 THROUGH MERIDIAN MISSISSIPPI AT APPROXIMATELY 8:00 PM YESTERDAY ON 06/22/2012. I CAME ACROSS AN OVERPASS AT ABOUT 70 MPH WHEN THE ROUGH SURFACE OF THE BRIDGE CAUSED THE TRUCK TO SHAKE VERY VIOLENTLY IN THE FRONT END. I IMMEDIATELY TRIED TO CONTROL/CORRECT IT BY HOLDING THE STEERING WHEEL FIRMLY AND B…
Read full complaint
I WAS TRAVELING NORTH ON I59 THROUGH MERIDIAN MISSISSIPPI AT APPROXIMATELY 8:00 PM YESTERDAY ON 06/22/2012. I CAME ACROSS AN OVERPASS AT ABOUT 70 MPH WHEN THE ROUGH SURFACE OF THE BRIDGE CAUSED THE TRUCK TO SHAKE VERY VIOLENTLY IN THE FRONT END. I IMMEDIATELY TRIED TO CONTROL/CORRECT IT BY HOLDING THE STEERING WHEEL FIRMLY AND BRAKING. IT STARTED TO SUBSIDE AND THEN STARTED AGAIN. I HELD THE STEERING WHEEL STRAIGHT AND FIRM, AND BRAKED HARDER UNTIL THE SHAKING STOPPED. I HAD SLOWED TO APPROXIMATELY 40 TO 50 MPH BEFORE IT HAD STOPPED. THIS ALL TOOK PLACE IN MATTER OF SECONDS. THOUGH FRUSTRATED BECAUSE I HAD JUST PURCHASED THE TRUCK EARLIER ON THIS DAY, I FEEL FORTUNATE THAT IT HAPPENED WITH LITTLE TRAFFIC. I HAD RECENTLY CROSSED OVER LAKE PONTCHARTRAIN BRIDGE IN LOUISIANA JUST HOURS EARLIER. *TT
NHTSA ODI #10462846
100,000 miles · Jun 4, 2012
SteeringSuspension
THE INITIAL OCCURRENCE IN DECEMBER 2011 WAS A STEERING STICK IN THE DIRECTION OF THE TURN AND REQUIRED FORCE TO TURN OPPOSITE THE DIRECTION OF THE TURN. THE PROBLEM CEASED AND DID NOT REOCCUR UNTIL MID-MAY OF 2012. THE PROBLEM MANIFESTED ITSELF AS A SEVERE OSCILLATION OF THE VEHICLE STEERING ACCOMPANIED BY DIRECTIONAL STICKING A…
Read full complaint
THE INITIAL OCCURRENCE IN DECEMBER 2011 WAS A STEERING STICK IN THE DIRECTION OF THE TURN AND REQUIRED FORCE TO TURN OPPOSITE THE DIRECTION OF THE TURN. THE PROBLEM CEASED AND DID NOT REOCCUR UNTIL MID-MAY OF 2012. THE PROBLEM MANIFESTED ITSELF AS A SEVERE OSCILLATION OF THE VEHICLE STEERING ACCOMPANIED BY DIRECTIONAL STICKING AND "INDEXING" IN THE STEERING. THE FIRST ATTEMPT AT REPAIR WAS TO FLUSH THE POWER STEERING SYSTEM. THIS ACTUALLY RESULTED IN A WORSE OSCILLATION. THE PROBLEM WAS STILL INTERMITTENT BUT OCCURRING MORE FREQUENTLY. THE DEALER WAS UNABLE TO DUPLICATE THE PROBLEM AND I ASKED FOR THE STEERING GEAR TO BE REPLACED. THIS DID NOT SOLVE THE PROBLEM. THE NEXT STEP WAS TO REPLACE THE STEERING DAMPER. THIS ALSO DID NOT RESULT IN ELIMINATION OF THE PROBLEM. DURING THE DAMPER REPLACEMENT IT WAS NOTED THAT THERE EXISTED A VERY SMALL AMOUNT OF PLAY IN THE DRAGLING BALL JOINT. WHILE NOT PARTICULAR OUT OF THE ACCEPTABLE RANGE WE AGREED TO REPLACE THE DRAG LINK. THE DRAG LINK HAS BEEN REPLACED AND THE VEHICLE CONTINUES TO DEMONSTRATE A "WALKING" MOTION REQUIRING THE OPERATOR TO ACTIVELY STEER THE VEHICLE TO REMAIN IN A LANE. IN ADDITION, THE VEHICLE WILL DEMONSTRATE RELATIVELY GOOD STABILITY IN A SWEEPING TURN UNTIL THE WHEEL IS DISPLACED BEYOND ROUGHLY 5 DEGREES AT WHICH POINT THE STEERING DISPLAYS AN ACTIVE PULL IN THE DIRECTION OF THE TURN. THE VEHICLE IS BEING RETURNED TO THE DEALER FOR CONTINUED EVALUATION. THE FORD TECHNICIANS HAVE EXAMINED AND PASSED THE POWER STEERING PUMP, THE HYDROSLAVE SYSTEM, FRONT TIRES, FRONT TIRE PRESSURE, FRONT BALL JOINTS AS WELL AS THE FRONT AXLE U-JOINTS. AT THIS POINT, THEY HAVE NO FURTHER SUGGESTIONS AS TO THE CAUSE OF THE PROBLEM. *TR
NHTSA ODI #10460501
125,000 miles · Jan 30, 2012
Steering
I PURCHASED THE TRUCK USED MAY 2011. THE VERY DAY I PURCHASED THE TRUCK I GOT A WOOBLE WHEN I HIT A BUMP. THIS IS A DAILY OCCURANCE. WHEN I HIT A BUMP JUST RIGHT OR WHEN I APPLY MEDIUM TO HARD BREAKING IT BEGINS TO WOBBLE TO GET IT UNDER CONTROL I HAVE TO BREAK HARD AND COME ALMOST TO A COMPLETE STOP. I HAVE HAD IT IN THE DEALE…
Read full complaint
I PURCHASED THE TRUCK USED MAY 2011. THE VERY DAY I PURCHASED THE TRUCK I GOT A WOOBLE WHEN I HIT A BUMP. THIS IS A DAILY OCCURANCE. WHEN I HIT A BUMP JUST RIGHT OR WHEN I APPLY MEDIUM TO HARD BREAKING IT BEGINS TO WOBBLE TO GET IT UNDER CONTROL I HAVE TO BREAK HARD AND COME ALMOST TO A COMPLETE STOP. I HAVE HAD IT IN THE DEALERSHIP 3 TIMES I WAS TOLD THERE WAS NOTHING WRONG WITH THE FRONT END, AND WAS TOLD TO ADJUST MY AIR PRESSURE LOWER, THEY ADJUSTED IT, IT CORRECTED NOTHING. I HAVE BEGAN TO JUST DRIVE AND DEAL WITH IT TILL TODAY. IT SHOOK ME INTO AN ONCOMING LANE BEFORE I GOT IT UNDER CONTROL. I REALIZE THIS IS NOT A NEW TRUCK, THIS PROBLEM SEEMS TO BE BEING SWEPT UNDER THE RUG. SOME WILL GET INJURED OR KILLED IF THIS IS NOT RESOLVED. I DON'T DARE LET MY WIFE DRIVE THE TRUCK BECAUSE I KNOW SHE DOES NOT HAVE THE SKILLS TO CONTROL THIS. *TT
NHTSA ODI #10445958
10,500 miles · Dec 6, 2011
Electronic Stability Control (esc)SteeringWheels
EXPERIENCED SEVERE VIBRATIONS AND SHIMMING AFTER HITTING A BUMP IN THE ROAD. HAD TO BRING THE TRUCK TO A COMPLETE STOP BEFORE I COULD GO ON. I THOUGH I MUST OF HAD A FLAT TIRE, BUT NO. TOOK THE TRUCK TO THE DEALER, THEY SAID THEY TIGHTENED SOME THINGS AND ADJUSTED THE TIRE PRESSURE. A COUPLE OF MONTHS LATER IT HAPPENED AGAIN…
Read full complaint
EXPERIENCED SEVERE VIBRATIONS AND SHIMMING AFTER HITTING A BUMP IN THE ROAD. HAD TO BRING THE TRUCK TO A COMPLETE STOP BEFORE I COULD GO ON. I THOUGH I MUST OF HAD A FLAT TIRE, BUT NO. TOOK THE TRUCK TO THE DEALER, THEY SAID THEY TIGHTENED SOME THINGS AND ADJUSTED THE TIRE PRESSURE. A COUPLE OF MONTHS LATER IT HAPPENED AGAIN. I WENT STRAIGHT TO THE LOCAL GARAGE TO HAVE THE TIRES CHECKED, BUT THE TIRE PRESSURE WAS FINE. IT CONTINUES TO HAPPEN ABOUT TWICE A YEAR WITH NO REASON, JUST DEPENDS HOW I HIT A BUMP ON THE ROAD. IT USUALLY HAPPENS WHEN CROSSING A BRIDGE ON THE INTERSTATE. THIS LAST TIME IN OCTOBER 2011, I WAS CROSSING A BRIDGE ON INTERSTATE PA 80 IN THE PASSING LANE, WHEN IT HAPPENED. I WAS ALL OVER THE ROAD BEFORE I COULD STOP. I WAS FORTUNATE THAT THERE WERE NO OTHER VEHICLES AROUND, OR IT WOULD HAVE BEEN A DISASTER. I WAS READY TO TAKE THE TRUCK BACK TO THE DEALER, AND TELL THEM, ITS TO DANGEROUS TO DRIVE ON THE INTERSTATE. I GOT THIS LETTER FROM FORD DISCUSSING THIS ISSUE. THEY ARE CORRECT STATING "A SEVERE" VIBRATION, BUT TOTALLY WRONG SAYING THIS CONDITION RESULTS FROM SIGNIFICANT TIRE UNDER-INFLATION. I'VE NEVER DRIVEN MY TRUCK WITH SIGNIFICANT TIRE UNDER-INFLATION. THIS SHIMMING CANNOT BE TAKEN LIGHTLY, BUT THAT WAS THE IMPRESSION I GOT FROM THE DEALER. I WONDER HOW LONG FORD REALLY NEW ABOUT THIS ISSUE. I SHOULD BE ON RECORD BACK AT MY DEALER SOON AFTER I GOT THE TRUCK WITH THIS EXACT ISSUE. *TR
NHTSA ODI #10438804
Mileage unknown · Sep 21, 2011
SteeringSuspension
CPSC#I1190270A. 2006 FORD F350. CONSUMER STATED THE STEERING WHEEL BEGAN TO OSCILLATE BACK AND FORTH VIOLENTLY WHEN HE HIT A SMALL BUMP IN THE ROAD. I WAS UNABLE TO CONTROL THE STEERING WHEEL UNTIL MY SPEED WAS REDUCED TO BELOW 40 MPH. I LEARNED THIS PROBLEM IS VERY COMMONLY REFERRED TO AS THE "DEATH WOBBLE" AND THE FIX IS $ 875…
Read full complaint
CPSC#I1190270A. 2006 FORD F350. CONSUMER STATED THE STEERING WHEEL BEGAN TO OSCILLATE BACK AND FORTH VIOLENTLY WHEN HE HIT A SMALL BUMP IN THE ROAD. I WAS UNABLE TO CONTROL THE STEERING WHEEL UNTIL MY SPEED WAS REDUCED TO BELOW 40 MPH. I LEARNED THIS PROBLEM IS VERY COMMONLY REFERRED TO AS THE "DEATH WOBBLE" AND THE FIX IS $ 875. *LN THE CONSUMER VEERED OFF THE PAVEMENT AND WENT DOWN A GRASSY EMBANKMENT. *JB
NHTSA ODI #10427395
92,000 miles · Oct 27, 2010
SteeringSuspensionCrash
I HAVE A 2006 FORD F350 4 WHEEL DRIVE SINGLE WHEEL LONG BED KING RANCH. I WILL BE DRIVING DOWN THE ROAD OR INTERSTATE ANYWHERE BETWEEN 30 AND 80 MILES AN HOUR, AND IF YOU HIT THE SMALLEST IMPERFECTIONS IN THE ROAD THE TRUCK WILL START SHAKING VIOLENTLY, UNCONTROLLABLE, THE STEERING WHEEL MOVES ABOUT 14 INCHES SIDE TO SIDE SO FA…
Read full complaint
I HAVE A 2006 FORD F350 4 WHEEL DRIVE SINGLE WHEEL LONG BED KING RANCH. I WILL BE DRIVING DOWN THE ROAD OR INTERSTATE ANYWHERE BETWEEN 30 AND 80 MILES AN HOUR, AND IF YOU HIT THE SMALLEST IMPERFECTIONS IN THE ROAD THE TRUCK WILL START SHAKING VIOLENTLY, UNCONTROLLABLE, THE STEERING WHEEL MOVES ABOUT 14 INCHES SIDE TO SIDE SO FAST AND HARD, THAT IT TAKES ILL I'VE GOT TO HOLD ON TO THE WHEEL. YOU CAN HEAR THE TIRES CHIRP SIDE TO SIDE ON THE PAVEMENT IT WOBBLES SO SEVERELY. I'VE REPLACED THE STEERING DAMPENER, THE POWER STEERING PUMP, HAD IT ALIGNED 4 TIMES, BRAND NEW TIRES, I HAVE ADJUSTED THE CASTOR ACCORDINGLY TO FORDS TSB FORUM, HAD MY ROTORS TURNED, AND WHEELS AND TIRES BALANCED SO MANY TIMES. ITS SO BAD, IT SHAKES THE STUFF IN THE BED OF MY TRUCK ONTO THE HIGHWAY. MY TRUCK ONLY HAS 92,000 MILES ON IT. IM AFRAID TO DRIVE IT. ALL I KNOW IS THAT I DIDN'T PAY 64,000 DOLLARS FOR A TRUCK THAT I CANT DRIVE. I WILL SPEND THE MONEY TO FIX IT, BUT FORD SAYS ITS A NORMAL CONDITION. *TR
NHTSA ODI #10362727
229,000 miles · Apr 6, 2010
Steering
TL*THE CONTACT OWNS A 2006 FORD F-350 SUPERDUTY. THE CONTACT WAS DRIVING AT APPROXIMATELY 35 MPH AND NOTICED THAT THE WHEELS BEGAN TO SHAKE VIOLENTLY FROM LEFT TO RIGHT AFTER THE VEHICLE WENT OVER A SMALL POTHOLE. HE STATED THAT THE STEERING ALSO FELT LOOSE. THE CONTACT STOPPED THE VEHICLE, WAITED AND ATTEMPTED TO CONTINUE DRIVI…
Read full complaint
TL*THE CONTACT OWNS A 2006 FORD F-350 SUPERDUTY. THE CONTACT WAS DRIVING AT APPROXIMATELY 35 MPH AND NOTICED THAT THE WHEELS BEGAN TO SHAKE VIOLENTLY FROM LEFT TO RIGHT AFTER THE VEHICLE WENT OVER A SMALL POTHOLE. HE STATED THAT THE STEERING ALSO FELT LOOSE. THE CONTACT STOPPED THE VEHICLE, WAITED AND ATTEMPTED TO CONTINUE DRIVING. THE CONTACT CALLED THE DEALERSHIP BUT NO REPAIRS WERE PERFORMED ON THE VEHICLE AT THE TIME OF THE COMPLAINT. THE FAILURE MILEAGE WAS APPROXIMATELY 22,900. THE CURRENT MILEAGE WAS 22,915.
NHTSA ODI #10323973
109,000 miles · Nov 26, 2009
SteeringSuspension
WHILE DRIVING ALONG THE HWY AT APPROX 65MPH I RAN ACROSS A PATCH OF UNEVEN ROAD AT WHICH CAUSED MY 2006 F350 4X4 STEERING TO SHAKE VIOLENTLY I HAD TO CAREFULLY PULL OVER TO THE SHOULDER WHICH WAS NO SMALL TASK AS THERE WAS A LOT OF TRAFFIC THE SHAKING WOULD NOT STOP UNTIL I WAS ALMOST STOPPED THIS HAPPENED 4 TIMES ON DIFFEREN…
Read full complaint
WHILE DRIVING ALONG THE HWY AT APPROX 65MPH I RAN ACROSS A PATCH OF UNEVEN ROAD AT WHICH CAUSED MY 2006 F350 4X4 STEERING TO SHAKE VIOLENTLY I HAD TO CAREFULLY PULL OVER TO THE SHOULDER WHICH WAS NO SMALL TASK AS THERE WAS A LOT OF TRAFFIC THE SHAKING WOULD NOT STOP UNTIL I WAS ALMOST STOPPED THIS HAPPENED 4 TIMES ON DIFFERENT ROADS . THE VEHICLE IS STOCK NOT LIFTED AND HAS OEM TIRES. I AM TRYING TO FIND A FIX BUT I AM FINDING OUT THIS IS A COMMON PROBLEM FOR FORD AND THEY ARE UNWILLING TO HELP FIX. *TR
NHTSA ODI #10293635
41,000 miles · Nov 13, 2009
SteeringSuspension
VEHICLE CONTROL COMPROMISED WHEN INCURRING SHARP CHANGES IN ROAD SURFACE (POTHOLES, EXPANSION JOINTS, ETC). *TR
FORD IS RECALLING CERTAIN MODEL YEAR 2011 RANGER TRUCKS BUILT FROM JANUARY 25, 2011, THROUGH APRIL 25, 2011 AT THE TWIN CITIES ASSEMBLY PLANT, AND SERVICE PARTS DISTRIBUTED TO DEALERS FOR CERTAIN 2004 THROUGH 2011 MODEL YEAR RANGER TRUCKS, 2002 THROUGH 2005 MODEL YEAR EXCURSION VEHICLES, AND 2002 THROUGH 2007 MODEL YEAR F-250, F-350, F-450, AND F-550 TRUCKS FOR FAILING TO COMPLY WITH THE REQUIREMENTS OF FEDERAL MOTOR VEHICLE SAFETY STANDARD NO. 108, "LAMPS, REFLECTIVE DEVICES, AND ASSOCIATED EQUIPMENT." THE MULTI-FUNCTION SWITCH WAS SHIPPED WITH A SUBCOMPONENT (SLIDER) THAT MAY EXPERIENCE DEFORMATION. A MULTI-FUNCTION SWITCH WITH A DEFORMED SLIDER MAY MALFUNCTION CAUSING THE TURN SIGNAL, TAIL LIGHTS, HAZARD WARNING SIGNAL FLASHERS AND/OR BRAKE LIGHTS NOT TO ACTIVATE.
Consequence & remedy
Consequence: NON-FUNCTIONING LIGHTS COULD INCREASE THE RISK OF A CRASH.
Remedy: DEALERS WILL REPLACE THE SWITCHES FREE OF CHARGE. THE SAFETY RECALL BEGAN ON AUGUST 15, 2011. OWNERS MAY CONTACT FORD MOTOR COMPANY CUSTOMER RELATIONSHIP CENTER AT 1-866-436-7332.
Additional source detail variants (2)
Exterior Lighting:brake Lights
FORD IS RECALLING CERTAIN MODEL YEAR 2011 RANGER TRUCKS BUILT FROM JANUARY 25, 2011, THROUGH APRIL 25, 2011 AT THE TWIN CITIES ASSEMBLY PLANT, AND SERVICE PARTS DISTRIBUTED TO DEALERS FOR CERTAIN 2004 THROUGH 2011 MODEL YEAR RANGER TRUCKS, 2002 THROUGH 2005 MODEL YEAR EXCURSION VEHICLES, AND 2002 THROUGH 2007 MODEL YEAR F-250, F-350, F-450, AND F-550 TRUCKS FOR FAILING TO COMPLY WITH THE REQUIREMENTS OF FEDERAL MOTOR VEHICLE SAFETY STANDARD NO. 108, "LAMPS, REFLECTIVE DEVICES, AND ASSOCIATED EQUIPMENT." THE MULTI-FUNCTION SWITCH WAS SHIPPED WITH A SUBCOMPONENT (SLIDER) THAT MAY EXPERIENCE DEFORMATION. A MULTI-FUNCTION SWITCH WITH A DEFORMED SLIDER MAY MALFUNCTION CAUSING THE TURN SIGNAL, TAIL LIGHTS, HAZARD WARNING SIGNAL FLASHERS AND/OR BRAKE LIGHTS NOT TO ACTIVATE.
Consequence: NON-FUNCTIONING LIGHTS COULD INCREASE THE RISK OF A CRASH.
Remedy: DEALERS WILL REPLACE THE SWITCHES FREE OF CHARGE. THE SAFETY RECALL BEGAN ON AUGUST 15, 2011. OWNERS MAY CONTACT FORD MOTOR COMPANY CUSTOMER RELATIONSHIP CENTER AT 1-866-436-7332.
Exterior Lighting:tail Lights
FORD IS RECALLING CERTAIN MODEL YEAR 2011 RANGER TRUCKS BUILT FROM JANUARY 25, 2011, THROUGH APRIL 25, 2011 AT THE TWIN CITIES ASSEMBLY PLANT, AND SERVICE PARTS DISTRIBUTED TO DEALERS FOR CERTAIN 2004 THROUGH 2011 MODEL YEAR RANGER TRUCKS, 2002 THROUGH 2005 MODEL YEAR EXCURSION VEHICLES, AND 2002 THROUGH 2007 MODEL YEAR F-250, F-350, F-450, AND F-550 TRUCKS FOR FAILING TO COMPLY WITH THE REQUIREMENTS OF FEDERAL MOTOR VEHICLE SAFETY STANDARD NO. 108, "LAMPS, REFLECTIVE DEVICES, AND ASSOCIATED EQUIPMENT." THE MULTI-FUNCTION SWITCH WAS SHIPPED WITH A SUBCOMPONENT (SLIDER) THAT MAY EXPERIENCE DEFORMATION. A MULTI-FUNCTION SWITCH WITH A DEFORMED SLIDER MAY MALFUNCTION CAUSING THE TURN SIGNAL, TAIL LIGHTS, HAZARD WARNING SIGNAL FLASHERS AND/OR BRAKE LIGHTS NOT TO ACTIVATE.
Consequence: NON-FUNCTIONING LIGHTS COULD INCREASE THE RISK OF A CRASH.
Remedy: DEALERS WILL REPLACE THE SWITCHES FREE OF CHARGE. THE SAFETY RECALL BEGAN ON AUGUST 15, 2011. OWNERS MAY CONTACT FORD MOTOR COMPANY CUSTOMER RELATIONSHIP CENTER AT 1-866-436-7332.
Model-level recall history does not show whether a particular VIN is affected or has received a repair. Check a VIN with NHTSA ↗
NHTSA investigations
2
EA08007 · Violent Front End Oscillation
Opened Mar 14, 2008 · Closed Mar 31, 2009
Status: closed (inferred from source dates) · Suspension; Suspension:front
THIS INVESTIGATION WAS OPENED BASED ON 78 CONSUMER COMPLAINTS OF SEVERE SUSPENSION AND STEERING WHEEL OSCILLATIONS AFTER THE SUBJECT VEHICLES TRAVELED OVER AN UNEVEN SURFACE.ODI WAS CONCERNED ABOUT THESE COMPLAINTS BECAUSE MANY OF THEM ALLEGED LOSS OF CONTROL AND THE LOSS OF CONTROL OCCURREDAT SPEEDS ABOVE 50 MILES PER HOUR.AT THE TIME THESE COMPLAINTS WERE RECEIVED, ODI WAS ALSO AWARE OF THE TSB 07-10-10 AND EARLY WARNING FIELD REPORTS THAT DISCUSSED THE SHIMMY CONDITION ON THE SUBJECT VEHICLES.SINCE OPENING THIS INVESTIGATION, ODI HAS CONFIRMED, BASED ON CONSUMER COMPLAINTS, WARRANTY DATA, TESTING CONDUCTED BY VRTC, AND ODI INSPECTION OF COMPLAINT VEHICLES, THAT THE OWNERS OF THE SUBJECT VEHICLES ARE EXPERIENCING SHIMMY EVENTS ON THEIR VEHICLES.HOWEVER, ODI HAS ALSO CONFIRMED THAT OWNERS TYPICALLY DO NOT MAINTAIN THEIR TIRES AT THE PRESSURES RECOMMENDED BY FORD ON THE TIRE LABEL.FURTHER, ODI HAS FOUND THAT IN ORDER FOR SHIMMY TO OCCUR, TIRE PRESSURES MUST BE SUBSTANTIALLY BELOW (AT LEAST 20%) THOSE SPECIFIED ON THE VEHICLE TIRE LABEL.ODI CONSIDERS THESE UNSAFE TIRE CONDITIONS TO BE THE RESULT OF ONE OF THREE TYPICAL SITUATIONS.THE TIRES ARE BEING IMPROPERLY MAINTAINED, THE OWNERS ARE INTENTIONALLY SETTING THE TIRE PRESSURES LOW TO ENHANCE RIDE QUALITY, OR AFTERMARKET TIRES (NOT DESIGNED FOR USE ON THE VEHICLE) ARE INSTALLED TO CHANGE THE APPEARANCE OR FUNCTION OF THE VEHICLE.THE SUBJECT VEHICLES ARE INTENDED AND DESIGNED TO BE USED AS HEAVY DUTY VEHICLES AND AS SUCH REQUIRE THAT THE TIRES BE CAPABLE OF HANDLING THE LOADS FOR WHICH THE VEHICLE IS DESIGNED AND MARKETED.IN ORDER FOR THE TIRES TO BE CAPABLE OF HANDLING THESE LOADS, THE PROPER TIRE PRESSURE MUST BE MAINTAINED.IN LIGHT OF THE INFORMATION GATHERED IN THIS INVESTIGATION AND FORD'S AGREEMENT TO NOTIFY SUBJECT VEHICLE OWNERS (NOW AND EVERY TWO YEARS UNTIL THE VEHICLES REACH TEN YEARS FROM THEIR PRODUCTION DATE) ABOUT THE IMPORTANCE OF MAINTAINING PROPER TIRE PRESSURES ON THEIR VEHICLES, FURTHER USE OF AGENCY RESOURCES DOES NOT APPEAR TO BE WARRANTED.THE CLOSING OF THIS INVESTIGATION DOES NOT CONSTITUTE A FINDING BY NHTSA THAT NO SAFETY-RELATED DEFECT EXISTS.THE AGENCY RESERVES THE RIGHT TO TAKE FURTHER ACTION IF WARRANTED BY THE CIRCUMSTANCES.FOR ADDITIONAL INFORMATION, SEE THE ATTACHED CLOSING REPORT.
Additional source detail variants (2)
Suspension
THIS INVESTIGATION WAS OPENED BASED ON 78 CONSUMER COMPLAINTS OF SEVERE SUSPENSION AND STEERING WHEEL OSCILLATIONS AFTER THE SUBJECT VEHICLES TRAVELED OVER AN UNEVEN SURFACE.ODI WAS CONCERNED ABOUT THESE COMPLAINTS BECAUSE MANY OF THEM ALLEGED LOSS OF CONTROL AND THE LOSS OF CONTROL OCCURREDAT SPEEDS ABOVE 50 MILES PER HOUR.AT THE TIME THESE COMPLAINTS WERE RECEIVED, ODI WAS ALSO AWARE OF THE TSB 07-10-10 AND EARLY WARNING FIELD REPORTS THAT DISCUSSED THE SHIMMY CONDITION ON THE SUBJECT VEHICLES.SINCE OPENING THIS INVESTIGATION, ODI HAS CONFIRMED, BASED ON CONSUMER COMPLAINTS, WARRANTY DATA, TESTING CONDUCTED BY VRTC, AND ODI INSPECTION OF COMPLAINT VEHICLES, THAT THE OWNERS OF THE SUBJECT VEHICLES ARE EXPERIENCING SHIMMY EVENTS ON THEIR VEHICLES.HOWEVER, ODI HAS ALSO CONFIRMED THAT OWNERS TYPICALLY DO NOT MAINTAIN THEIR TIRES AT THE PRESSURES RECOMMENDED BY FORD ON THE TIRE LABEL.FURTHER, ODI HAS FOUND THAT IN ORDER FOR SHIMMY TO OCCUR, TIRE PRESSURES MUST BE SUBSTANTIALLY BELOW (AT LEAST 20%) THOSE SPECIFIED ON THE VEHICLE TIRE LABEL.ODI CONSIDERS THESE UNSAFE TIRE CONDITIONS TO BE THE RESULT OF ONE OF THREE TYPICAL SITUATIONS.THE TIRES ARE BEING IMPROPERLY MAINTAINED, THE OWNERS ARE INTENTIONALLY SETTING THE TIRE PRESSURES LOW TO ENHANCE RIDE QUALITY, OR AFTERMARKET TIRES (NOT DESIGNED FOR USE ON THE VEHICLE) ARE INSTALLED TO CHANGE THE APPEARANCE OR FUNCTION OF THE VEHICLE.THE SUBJECT VEHICLES ARE INTENDED AND DESIGNED TO BE USED AS HEAVY DUTY VEHICLES AND AS SUCH REQUIRE THAT THE TIRES BE CAPABLE OF HANDLING THE LOADS FOR WHICH THE VEHICLE IS DESIGNED AND MARKETED.IN ORDER FOR THE TIRES TO BE CAPABLE OF HANDLING THESE LOADS, THE PROPER TIRE PRESSURE MUST BE MAINTAINED.IN LIGHT OF THE INFORMATION GATHERED IN THIS INVESTIGATION AND FORD'S AGREEMENT TO NOTIFY SUBJECT VEHICLE OWNERS (NOW AND EVERY TWO YEARS UNTIL THE VEHICLES REACH TEN YEARS FROM THEIR PRODUCTION DATE) ABOUT THE IMPORTANCE OF MAINTAINING PROPER TIRE PRESSURES ON THEIR VEHICLES, FURTHER USE OF AGENCY RESOURCES DOES NOT APPEAR TO BE WARRANTED.THE CLOSING OF THIS INVESTIGATION DOES NOT CONSTITUTE A FINDING BY NHTSA THAT NO SAFETY-RELATED DEFECT EXISTS.THE AGENCY RESERVES THE RIGHT TO TAKE FURTHER ACTION IF WARRANTED BY THE CIRCUMSTANCES.FOR ADDITIONAL INFORMATION, SEE THE ATTACHED CLOSING REPORT.
Suspension:front
THIS INVESTIGATION WAS OPENED BASED ON 78 CONSUMER COMPLAINTS OF SEVERE SUSPENSION AND STEERING WHEEL OSCILLATIONS AFTER THE SUBJECT VEHICLES TRAVELED OVER AN UNEVEN SURFACE.ODI WAS CONCERNED ABOUT THESE COMPLAINTS BECAUSE MANY OF THEM ALLEGED LOSS OF CONTROL AND THE LOSS OF CONTROL OCCURREDAT SPEEDS ABOVE 50 MILES PER HOUR.AT THE TIME THESE COMPLAINTS WERE RECEIVED, ODI WAS ALSO AWARE OF THE TSB 07-10-10 AND EARLY WARNING FIELD REPORTS THAT DISCUSSED THE SHIMMY CONDITION ON THE SUBJECT VEHICLES.SINCE OPENING THIS INVESTIGATION, ODI HAS CONFIRMED, BASED ON CONSUMER COMPLAINTS, WARRANTY DATA, TESTING CONDUCTED BY VRTC, AND ODI INSPECTION OF COMPLAINT VEHICLES, THAT THE OWNERS OF THE SUBJECT VEHICLES ARE EXPERIENCING SHIMMY EVENTS ON THEIR VEHICLES.HOWEVER, ODI HAS ALSO CONFIRMED THAT OWNERS TYPICALLY DO NOT MAINTAIN THEIR TIRES AT THE PRESSURES RECOMMENDED BY FORD ON THE TIRE LABEL.FURTHER, ODI HAS FOUND THAT IN ORDER FOR SHIMMY TO OCCUR, TIRE PRESSURES MUST BE SUBSTANTIALLY BELOW (AT LEAST 20%) THOSE SPECIFIED ON THE VEHICLE TIRE LABEL.ODI CONSIDERS THESE UNSAFE TIRE CONDITIONS TO BE THE RESULT OF ONE OF THREE TYPICAL SITUATIONS.THE TIRES ARE BEING IMPROPERLY MAINTAINED, THE OWNERS ARE INTENTIONALLY SETTING THE TIRE PRESSURES LOW TO ENHANCE RIDE QUALITY, OR AFTERMARKET TIRES (NOT DESIGNED FOR USE ON THE VEHICLE) ARE INSTALLED TO CHANGE THE APPEARANCE OR FUNCTION OF THE VEHICLE.THE SUBJECT VEHICLES ARE INTENDED AND DESIGNED TO BE USED AS HEAVY DUTY VEHICLES AND AS SUCH REQUIRE THAT THE TIRES BE CAPABLE OF HANDLING THE LOADS FOR WHICH THE VEHICLE IS DESIGNED AND MARKETED.IN ORDER FOR THE TIRES TO BE CAPABLE OF HANDLING THESE LOADS, THE PROPER TIRE PRESSURE MUST BE MAINTAINED.IN LIGHT OF THE INFORMATION GATHERED IN THIS INVESTIGATION AND FORD'S AGREEMENT TO NOTIFY SUBJECT VEHICLE OWNERS (NOW AND EVERY TWO YEARS UNTIL THE VEHICLES REACH TEN YEARS FROM THEIR PRODUCTION DATE) ABOUT THE IMPORTANCE OF MAINTAINING PROPER TIRE PRESSURES ON THEIR VEHICLES, FURTHER USE OF AGENCY RESOURCES DOES NOT APPEAR TO BE WARRANTED.THE CLOSING OF THIS INVESTIGATION DOES NOT CONSTITUTE A FINDING BY NHTSA THAT NO SAFETY-RELATED DEFECT EXISTS.THE AGENCY RESERVES THE RIGHT TO TAKE FURTHER ACTION IF WARRANTED BY THE CIRCUMSTANCES.FOR ADDITIONAL INFORMATION, SEE THE ATTACHED CLOSING REPORT.
PE07057 · Violent Front End Oscillation
Opened Nov 15, 2007 · Closed Mar 14, 2008
Status: closed (inferred from source dates) · Suspension; Suspension:front
ODI HAS RECEIVED 78 CONSUMER COMPLAINTS OF SEVERE SUSPENSION AND STEERING WHEEL SHIMMY AND OSCILLATIONS COMMENCING AFTER THE SUBJECT VEHICLES TRAVELED OVER AN UNEVEN ROAD SURFACE. THE MAJORITY OF THESE INCIDENTS OCCURRED AT SPEEDS OF 50 MPH OR GREATER.THIRTEEN OF THE COMPLAINTS RECEIVED BY ODI ALLEGE LOSS OF STEERING CONTROL AND THAT THE VEHICLE CHANGED DRIVING LANES UNCONTROLLABLY.FOUR OF THE COMPLAINTS RECEIVED BY ODI ALLEGE THAT THE VEHICLE LEFT THE ROAD SURFACE AS A RESULT OF THE VIOLENT SUSPENSION AND STEERING WHEEL OSCILLATIONS.IN ONE CASE THE CONSUMER ALLEGES THAT AFTER THE VEHICLE LEFT THE ROAD SURFACE, IT CRASHED INTO A WOODED AREA.ADDITIONALFACTORS CONTRIBUTING TO THE OPENING OF THIS EA WERE EARLY WARNING FIELD REPORTS,SUBMITTED BY FORD, DESCRIBING SUSPENSION SHIMMY / OSCILLATIONSAND A FORD TSB (07-10-10) DESCRIBING THE SUSPENSION SHIMMY ISSUE AND HOW TO REPAIR THE PROBLEM.FORD HAS DESCRIBED SHIMMY AS SELF-EXCITED OSCILLATION OF THE STEERING WHEELS WITH ACCOMPANYING WHEEL TRAMP.THIS PE HAS BEEN UPGRADED TO AN ENGINEERING ANALYSIS (EA) TO DETERMINE IF THE SHIMMY CONDITION THAT OCCURS ON THE SUBJECT VEHICLES CREATES A CONDITION WHERE THE VEHICLE BECOMES DIFFICULT TO CONTROL OR STARTLES THE DRIVER, THUS PRESENTING A SAFETY RISK.
Additional source detail variants (2)
Suspension
ODI HAS RECEIVED 78 CONSUMER COMPLAINTS OF SEVERE SUSPENSION AND STEERING WHEEL SHIMMY AND OSCILLATIONS COMMENCING AFTER THE SUBJECT VEHICLES TRAVELED OVER AN UNEVEN ROAD SURFACE. THE MAJORITY OF THESE INCIDENTS OCCURRED AT SPEEDS OF 50 MPH OR GREATER.THIRTEEN OF THE COMPLAINTS RECEIVED BY ODI ALLEGE LOSS OF STEERING CONTROL AND THAT THE VEHICLE CHANGED DRIVING LANES UNCONTROLLABLY.FOUR OF THE COMPLAINTS RECEIVED BY ODI ALLEGE THAT THE VEHICLE LEFT THE ROAD SURFACE AS A RESULT OF THE VIOLENT SUSPENSION AND STEERING WHEEL OSCILLATIONS.IN ONE CASE THE CONSUMER ALLEGES THAT AFTER THE VEHICLE LEFT THE ROAD SURFACE, IT CRASHED INTO A WOODED AREA.ADDITIONALFACTORS CONTRIBUTING TO THE OPENING OF THIS EA WERE EARLY WARNING FIELD REPORTS,SUBMITTED BY FORD, DESCRIBING SUSPENSION SHIMMY / OSCILLATIONSAND A FORD TSB (07-10-10) DESCRIBING THE SUSPENSION SHIMMY ISSUE AND HOW TO REPAIR THE PROBLEM.FORD HAS DESCRIBED SHIMMY AS SELF-EXCITED OSCILLATION OF THE STEERING WHEELS WITH ACCOMPANYING WHEEL TRAMP.THIS PE HAS BEEN UPGRADED TO AN ENGINEERING ANALYSIS (EA) TO DETERMINE IF THE SHIMMY CONDITION THAT OCCURS ON THE SUBJECT VEHICLES CREATES A CONDITION WHERE THE VEHICLE BECOMES DIFFICULT TO CONTROL OR STARTLES THE DRIVER, THUS PRESENTING A SAFETY RISK.
Suspension:front
ODI HAS RECEIVED 78 CONSUMER COMPLAINTS OF SEVERE SUSPENSION AND STEERING WHEEL SHIMMY AND OSCILLATIONS COMMENCING AFTER THE SUBJECT VEHICLES TRAVELED OVER AN UNEVEN ROAD SURFACE. THE MAJORITY OF THESE INCIDENTS OCCURRED AT SPEEDS OF 50 MPH OR GREATER.THIRTEEN OF THE COMPLAINTS RECEIVED BY ODI ALLEGE LOSS OF STEERING CONTROL AND THAT THE VEHICLE CHANGED DRIVING LANES UNCONTROLLABLY.FOUR OF THE COMPLAINTS RECEIVED BY ODI ALLEGE THAT THE VEHICLE LEFT THE ROAD SURFACE AS A RESULT OF THE VIOLENT SUSPENSION AND STEERING WHEEL OSCILLATIONS.IN ONE CASE THE CONSUMER ALLEGES THAT AFTER THE VEHICLE LEFT THE ROAD SURFACE, IT CRASHED INTO A WOODED AREA.ADDITIONALFACTORS CONTRIBUTING TO THE OPENING OF THIS EA WERE EARLY WARNING FIELD REPORTS,SUBMITTED BY FORD, DESCRIBING SUSPENSION SHIMMY / OSCILLATIONSAND A FORD TSB (07-10-10) DESCRIBING THE SUSPENSION SHIMMY ISSUE AND HOW TO REPAIR THE PROBLEM.FORD HAS DESCRIBED SHIMMY AS SELF-EXCITED OSCILLATION OF THE STEERING WHEELS WITH ACCOMPANYING WHEEL TRAMP.THIS PE HAS BEEN UPGRADED TO AN ENGINEERING ANALYSIS (EA) TO DETERMINE IF THE SHIMMY CONDITION THAT OCCURS ON THE SUBJECT VEHICLES CREATES A CONDITION WHERE THE VEHICLE BECOMES DIFFICULT TO CONTROL OR STARTLES THE DRIVER, THUS PRESENTING A SAFETY RISK.
2006 Ford F-350 Sd Problems, Complaints & Recalls | Skip That Year
Illustration