NHTSA owner reports · September 18, 2026 snapshot.
What owners actually said
130 reports39,000 miles · Sep 6, 2011
Service Brakes, Hydraulic
TL* THE CONTACT OWNS A 2004 FORD F-350 SD. THE CONTACT STATED WHILE DRIVING 35 MPH HE APPLIED THE BRAKES, BUT THE VEHICLE CONTINUED TO MOVE FORWARD. THE CONTACT BEGAN TO APPLY REPEATED PRESSURE TO THE BRAKES AND ENGAGED THE EMERGENCY BRAKE IN ORDER TO STOP THE VEHICLE. THE VEHICLE WAS SAFELY DRIVEN HOME, WHERE IT WAS PARKED. TH…
Read full complaint
TL* THE CONTACT OWNS A 2004 FORD F-350 SD. THE CONTACT STATED WHILE DRIVING 35 MPH HE APPLIED THE BRAKES, BUT THE VEHICLE CONTINUED TO MOVE FORWARD. THE CONTACT BEGAN TO APPLY REPEATED PRESSURE TO THE BRAKES AND ENGAGED THE EMERGENCY BRAKE IN ORDER TO STOP THE VEHICLE. THE VEHICLE WAS SAFELY DRIVEN HOME, WHERE IT WAS PARKED. THE CONTACT NOTICED THAT THE BRAKE LINES WERE PUNCTURED AND LEAKING FLUID. THE MANUFACTURER WAS NOT NOTIFIED OF THE FAILURE. THE FAILURE MILEAGE WAS 39,000.
NHTSA ODI #10423886
228,000 miles · Jul 12, 2011
Electrical System
TL* THE CONTACT OWNS A 2004 FORD F-350 SD. THE CONTACT STATED THAT THE VEHICLE ABNORMALLY ACCELERATED WHILE SITTING AT A TRAFFIC STOP WITH THE BRAKES DEPRESSED. OCCASIONALLY, THE VEHICLE WOULD STALL WITHOUT WARNING. THE VEHICLE WAS TAKEN TO THE DEALER WHO DIAGNOSED THAT THE INJECTION CONTROL PRESSURE SENSOR MALFUNCTIONED AND NE…
Read full complaint
TL* THE CONTACT OWNS A 2004 FORD F-350 SD. THE CONTACT STATED THAT THE VEHICLE ABNORMALLY ACCELERATED WHILE SITTING AT A TRAFFIC STOP WITH THE BRAKES DEPRESSED. OCCASIONALLY, THE VEHICLE WOULD STALL WITHOUT WARNING. THE VEHICLE WAS TAKEN TO THE DEALER WHO DIAGNOSED THAT THE INJECTION CONTROL PRESSURE SENSOR MALFUNCTIONED AND NEEDED TO BE REPLACED. THE MANUFACTURER WAS MADE AWARE OF THE FAILURE BUT DID NOT OFFER ANY ASSISTANCE BECAUSE THE VEHICLE WAS NOT INCLUDED IN NHTSA CAMPAIGN ID NUMBER: 05V270000 (ELECTRICAL SYSTEM:WIRING). THE VEHICLE WAS NOT REPAIRED. THE FAILURE MILEAGE WAS 228,000 AND THE CURRENT MILEAGE WAS 230,000.
NHTSA ODI #10411965
95,000 miles · Jun 29, 2011
Fuel System, Diesel
VEHICLE LOSSES POWER AND DROPS IN FUEL MILEAGE. I WAS INFORMED THAT THE FUEL TANK NEEDED TO BE REPLACED DUE TO DELAMINATION. *TR
NHTSA ODI #10409393
160,000 miles · Jun 22, 2011
Fuel System, Diesel
TRUCK STARTED RUNNING A LITTLE SLUGGISH FIRST TWO DAYS AND THEN BEGAN RUNNING ROUGH AND SLUGGISH AT TIME OF ACCELERATION AND THEN BLOW BIG PUFF OF BLACK SMOKE OUT AND TAKE OFF WITH ALLOT MORE POWER THAN NORMAL.. IT IS AT FORD DEALERSHIP BEING REPAIRED NOW HAVING INJECTORS, FUEL PUMP AND FUEL TANK RECOATED BECAUSE THEY SAY FORD H…
Read full complaint
TRUCK STARTED RUNNING A LITTLE SLUGGISH FIRST TWO DAYS AND THEN BEGAN RUNNING ROUGH AND SLUGGISH AT TIME OF ACCELERATION AND THEN BLOW BIG PUFF OF BLACK SMOKE OUT AND TAKE OFF WITH ALLOT MORE POWER THAN NORMAL.. IT IS AT FORD DEALERSHIP BEING REPAIRED NOW HAVING INJECTORS, FUEL PUMP AND FUEL TANK RECOATED BECAUSE THEY SAY FORD HAS A NATIONAL BACK ORDER ON THESE TANKS AND WILL TAKE 6 MONTHS TO GET. THIS TELLS ME ALONG WITH THE PROBLEMS I AM FINDING OTHER PEOPLE ARE HAVING ONLINE THAT THIS IS A BIG PROBLEM. *TR
NHTSA ODI #10408443
98,000 miles · May 18, 2011
Engine And Engine Cooling
HEAD GASKET FAILURE AND OTHER PROBLEMS WITH THE 2004 F-350 6.0L POWERSTROKE DIESEL ENGINES. *TR
NHTSA ODI #10401381
68,000 miles · May 2, 2011
Tires
VEHICLE IS A 2004 F-350 CREW CAB. TIRES ARE DEFINITY DAKOTA A/T, 285/75 R16 APRIL 30TH 2011 WHILE TRAVELING NORTHBOUND ON INTERSTATE 95 AT APPROXIMATELY 65MPH I HAD THE PASSENGER REAR TIRE SEPARATE. THE TREAD APPEARS TO HAVE SEPARATE FROM THE TIRE CAUSING FAILURE. THE TREAD DID NOT COMPLETELY SEPARATE WHICH CAUSED SUBSTANTIA…
Read full complaint
VEHICLE IS A 2004 F-350 CREW CAB. TIRES ARE DEFINITY DAKOTA A/T, 285/75 R16 APRIL 30TH 2011 WHILE TRAVELING NORTHBOUND ON INTERSTATE 95 AT APPROXIMATELY 65MPH I HAD THE PASSENGER REAR TIRE SEPARATE. THE TREAD APPEARS TO HAVE SEPARATE FROM THE TIRE CAUSING FAILURE. THE TREAD DID NOT COMPLETELY SEPARATE WHICH CAUSED SUBSTANTIAL DAMAGE TO THE VEHICLE. *TR
NHTSA ODI #10398589
120,000 miles · Apr 20, 2011
Electrical SystemFuel System, Diesel
TL*THE CONTACT OWNS A 2004 FORD F-350 SD DIESEL. THE CONTACT WAS DRIVING APPROXIMATELY 60-70 MPH WITH A CAMPER IN TOW AS THE VEHICLE STALLED WITH THE ABS WARNING LIGHT ILLUMINATED. THE DASHBOARD ALSO BECAME ABNORMALLY DIM. AFTER INSPECTING THE VEHICLE, THE CONTACT DISCOVERED THAT THE VEHICLE BATTERY WAS DEAD AND REPLACED IT WI…
Read full complaint
TL*THE CONTACT OWNS A 2004 FORD F-350 SD DIESEL. THE CONTACT WAS DRIVING APPROXIMATELY 60-70 MPH WITH A CAMPER IN TOW AS THE VEHICLE STALLED WITH THE ABS WARNING LIGHT ILLUMINATED. THE DASHBOARD ALSO BECAME ABNORMALLY DIM. AFTER INSPECTING THE VEHICLE, THE CONTACT DISCOVERED THAT THE VEHICLE BATTERY WAS DEAD AND REPLACED IT WITH THE CAMPER BATTERY. THE VEHICLE WAS TAKEN TO A LOCAL REPAIR SHOP WHERE THEY PERFORMED A DIAGNOSTIC, BUT, THEY WERE UNABLE TO DETERMINE THE CAUSE OF THE FAILURE. THE VEHICLE BATTERY WAS RECHARGED AND THE FAILURE DID NOT RECUR FOR ANOTHER FOUR MONTHS. THE VEHICLE WAS THEN TAKEN TO THE SAME LOCAL MECHANIC WHERE THE MECHANIC REPLACED THE FUEL INJECTOR. THE COMPUTER WAS REMOVED FROM THE VEHICLE AND TAKEN TO AN AUTHORIZED DEALER FOR A RESET FLASH. THE VEHICLE PERFORMED AS NORMAL UNTIL THE FAILURE RECURRED ONE YEAR LATER. THE VEHICLE WAS TAKEN TO AN AUTHORIZED DEALER WHERE THE CONTACT WAS AWAITING THE REPLACEMENT OF THE FUEL INJECTOR. THE CONTACT REFERENCED RECALL 05V270000 (ELECTRICAL SYSTEM:WIRING) BUT DID NOT CONFIRM IF THE VEHICLE WAS INCLUDED IN THE RECALL. THE APPROXIMATE FAILURE MILEAGE WAS 120,000 AND THE CURRENT MILEAGE WAS APPROXIMATELY 150,000.
NHTSA ODI #10396969
85,000 miles · Mar 29, 2011
Engine And Engine Cooling
TL*THE CONTACT OWNS A 2004 FORD F350. THE CONTACT STATED THAT THE VEHICLE WOULD HESITATE WHEN ATTEMPTING TO START. HE NOTICED THAT THE FAILURE ONLY OCCURRED IN THE MORNING. THE DEALER ADVISED THE CONTACT TO BRING THE VEHICLE IN FOR DIAGNOSTIC TESTING. THE CONTACT DID NOT INFORM THE MANUFACTURER NOR WAS THE VEHICLE REPAIRED. T…
Read full complaint
TL*THE CONTACT OWNS A 2004 FORD F350. THE CONTACT STATED THAT THE VEHICLE WOULD HESITATE WHEN ATTEMPTING TO START. HE NOTICED THAT THE FAILURE ONLY OCCURRED IN THE MORNING. THE DEALER ADVISED THE CONTACT TO BRING THE VEHICLE IN FOR DIAGNOSTIC TESTING. THE CONTACT DID NOT INFORM THE MANUFACTURER NOR WAS THE VEHICLE REPAIRED. THE VEHICLE WAS TAKEN TO A LOCAL MECHANIC WHO ADVISED HIM THAT THE FUEL INJECTION AND OIL PRESSURE SENSORS WOULD NEED TO BE REPLACED. THE CURRENT AND FAILURE MILEAGE WAS 85,000.
NHTSA ODI #10393583
152,000 miles · Mar 16, 2011
Fuel System, Diesel
TL* THE CONTACT OWNS A 2004 FORD F-350 SD. WHILE THE CONTACT WAS DRIVING APPROXIMATELY 70 MPH, THE VEHICLE SUDDENLY DECELERATED TO 40 MPH AND WOULD NOT INCREASE IN SPEED. THE VEHICLE WAS TAKEN TO AN INDEPENDENT MECHANIC WHO REPLACED THE FUEL FILTERS AND ENGINE INJECTORS. WITHIN 1,500 MILES, THE IDENTICAL FAILURE RECURRED. THE VE…
Read full complaint
TL* THE CONTACT OWNS A 2004 FORD F-350 SD. WHILE THE CONTACT WAS DRIVING APPROXIMATELY 70 MPH, THE VEHICLE SUDDENLY DECELERATED TO 40 MPH AND WOULD NOT INCREASE IN SPEED. THE VEHICLE WAS TAKEN TO AN INDEPENDENT MECHANIC WHO REPLACED THE FUEL FILTERS AND ENGINE INJECTORS. WITHIN 1,500 MILES, THE IDENTICAL FAILURE RECURRED. THE VEHICLE WAS TAKEN BACK TO AN INDEPENDENT MECHANIC; AND THE FUEL TANK LINER WAS CLEANED AND THE FUEL PUMP WAS ALSO REPLACED. THE FAILURE MILEAGE WAS APPROXIMATELY 152,000. UPDATED 1/13/2012 *LN *TR
NHTSA ODI #10390350
Mileage unknown · Mar 4, 2011
Engine And Engine Cooling
2004 FORD F-350 SD. CONSUMER WRITES IN REGARDS TO VEHICLE ENGINE *TGW THE CONSUMER STATED TWO TURBOCHARGERS WERE REPLACED ON THE VEHICLE UNDER WARRANTY. THE TURBOCHARGER NEEDS TO BE REPLACED AGAIN. ALSO THE EGR COOLER, HEAD GASKET, OIL COOLER LINES AND THE INJECTORS ALL FAILED. *JB
NHTSA ODI #10387648
Official recalls
2Jul 13, 2011
FORD IS RECALLING CERTAIN MODEL YEAR 2011 RANGER TRUCKS BUILT FROM JANUARY 25, 2011, THROUGH APRIL 25, 2011 AT THE TWIN CITIES ASSEMBLY PLANT, AND SERVICE PARTS DISTRIBUTED TO DEALERS FOR CERTAIN 2004 THROUGH 2011 MODEL YEAR RANGER TRUCKS, 2002 THROUGH 2005 MODEL YEAR EXCURSION VEHICLES, AND 2002 THROUGH 2007 MODEL YEAR F-250, F-350, F-450, AND F-550 TRUCKS FOR FAILING TO COMPLY WITH THE REQUIREMENTS OF FEDERAL MOTOR VEHICLE SAFETY STANDARD NO. 108, "LAMPS, REFLECTIVE DEVICES, AND ASSOCIATED EQUIPMENT." THE MULTI-FUNCTION SWITCH WAS SHIPPED WITH A SUBCOMPONENT (SLIDER) THAT MAY EXPERIENCE DEFORMATION. A MULTI-FUNCTION SWITCH WITH A DEFORMED SLIDER MAY MALFUNCTION CAUSING THE TURN SIGNAL, TAIL LIGHTS, HAZARD WARNING SIGNAL FLASHERS AND/OR BRAKE LIGHTS NOT TO ACTIVATE.
Consequence & remedy
Consequence: NON-FUNCTIONING LIGHTS COULD INCREASE THE RISK OF A CRASH.
Remedy: DEALERS WILL REPLACE THE SWITCHES FREE OF CHARGE. THE SAFETY RECALL BEGAN ON AUGUST 15, 2011. OWNERS MAY CONTACT FORD MOTOR COMPANY CUSTOMER RELATIONSHIP CENTER AT 1-866-436-7332.
Additional source detail variants (2)
Exterior Lighting:brake Lights
FORD IS RECALLING CERTAIN MODEL YEAR 2011 RANGER TRUCKS BUILT FROM JANUARY 25, 2011, THROUGH APRIL 25, 2011 AT THE TWIN CITIES ASSEMBLY PLANT, AND SERVICE PARTS DISTRIBUTED TO DEALERS FOR CERTAIN 2004 THROUGH 2011 MODEL YEAR RANGER TRUCKS, 2002 THROUGH 2005 MODEL YEAR EXCURSION VEHICLES, AND 2002 THROUGH 2007 MODEL YEAR F-250, F-350, F-450, AND F-550 TRUCKS FOR FAILING TO COMPLY WITH THE REQUIREMENTS OF FEDERAL MOTOR VEHICLE SAFETY STANDARD NO. 108, "LAMPS, REFLECTIVE DEVICES, AND ASSOCIATED EQUIPMENT." THE MULTI-FUNCTION SWITCH WAS SHIPPED WITH A SUBCOMPONENT (SLIDER) THAT MAY EXPERIENCE DEFORMATION. A MULTI-FUNCTION SWITCH WITH A DEFORMED SLIDER MAY MALFUNCTION CAUSING THE TURN SIGNAL, TAIL LIGHTS, HAZARD WARNING SIGNAL FLASHERS AND/OR BRAKE LIGHTS NOT TO ACTIVATE.
Consequence: NON-FUNCTIONING LIGHTS COULD INCREASE THE RISK OF A CRASH.
Remedy: DEALERS WILL REPLACE THE SWITCHES FREE OF CHARGE. THE SAFETY RECALL BEGAN ON AUGUST 15, 2011. OWNERS MAY CONTACT FORD MOTOR COMPANY CUSTOMER RELATIONSHIP CENTER AT 1-866-436-7332.
Exterior Lighting:tail Lights
FORD IS RECALLING CERTAIN MODEL YEAR 2011 RANGER TRUCKS BUILT FROM JANUARY 25, 2011, THROUGH APRIL 25, 2011 AT THE TWIN CITIES ASSEMBLY PLANT, AND SERVICE PARTS DISTRIBUTED TO DEALERS FOR CERTAIN 2004 THROUGH 2011 MODEL YEAR RANGER TRUCKS, 2002 THROUGH 2005 MODEL YEAR EXCURSION VEHICLES, AND 2002 THROUGH 2007 MODEL YEAR F-250, F-350, F-450, AND F-550 TRUCKS FOR FAILING TO COMPLY WITH THE REQUIREMENTS OF FEDERAL MOTOR VEHICLE SAFETY STANDARD NO. 108, "LAMPS, REFLECTIVE DEVICES, AND ASSOCIATED EQUIPMENT." THE MULTI-FUNCTION SWITCH WAS SHIPPED WITH A SUBCOMPONENT (SLIDER) THAT MAY EXPERIENCE DEFORMATION. A MULTI-FUNCTION SWITCH WITH A DEFORMED SLIDER MAY MALFUNCTION CAUSING THE TURN SIGNAL, TAIL LIGHTS, HAZARD WARNING SIGNAL FLASHERS AND/OR BRAKE LIGHTS NOT TO ACTIVATE.
Consequence: NON-FUNCTIONING LIGHTS COULD INCREASE THE RISK OF A CRASH.
Remedy: DEALERS WILL REPLACE THE SWITCHES FREE OF CHARGE. THE SAFETY RECALL BEGAN ON AUGUST 15, 2011. OWNERS MAY CONTACT FORD MOTOR COMPANY CUSTOMER RELATIONSHIP CENTER AT 1-866-436-7332.
Jun 10, 2005
CERTAIN PICKUP TRUCKS, SPORT UTILITY VEHICLES AND VANS EQUIPPED WITH 6.0L DIESEL ENGINES MAY EXPERIENCE STALLING WITHOUT WARNING WHILE DRIVING AND MAY OR MAY NOT RESTART.
Consequence & remedy
Consequence: SHOULD THE ENGINE STALL, A VEHICLE CRASH COULD OCCUR.
Remedy: DEALERS WILL UPGRADE THE FUEL INJECTION CONTROL MODULE (FICM) WIRE HARNESS OR REPLACED, AND/OR HAVE A NEW INJECTION CONTROL PRESSURE (ICP)) SENSOR CONNECTOR INSTALLED FREE OF CHARGE. THE RECALL BEGAN ON JULY 22, 2005. OWNERS MAY CONTACT FORD AT 1-800-392-3673.
Model-level recall history does not show whether a particular VIN is affected or has received a repair. Check a VIN with NHTSA ↗
NHTSA investigations
2DP05005 · Spark Plug Ejection From Cylinder Head
Opened Sep 22, 2005 · Closed Jan 4, 2006
Status: closed (inferred from source dates) · Engine And Engine Cooling; Engine And Engine Cooling:engine; Engine And Engine Cooling:engine:gasoline
ON SEPTEMBER 6, 2005, ODI RECEIVED A PETITION REQUESTING THAT THE AGENCY INVESTIGATE ALLEGATIONS OF ENGINE SPARK PLUG EJECTION IN CERTAIN MODEL YEAR 1997 THROUGH 2004 FORD VEHICLES WITH TRITON V-8 AND V-10 ENGINES.ODI RECEIVED A TOTAL OF 474 NON-DUPLICATIVE COMPLAINTS ON THE SUBJECT VEHICLES WHERE THE COMPLAINANT, OR THE DEALER REPAIRING THE VEHICLE, REPORTED THAT A SPARK PLUG DETACHED FROM THE CYLINDER AND/OR EJECTED FROM THE ENGINE.AS OF DECEMBER 8, 2005, ODI IS NOT AWARE OF ANY ALLEGATIONS WHERE THE ALLEGED DEFECT RESULTED IN A LOSS OF VEHICLE CONTROL, A CRASH, AN INJURY, OR A FATALITY IN ANY OF THE 10,319,810 SUBJECT VEHICLES.IN ADDITION, ODI IS AWARE OF ONLY TWO INCIDENTS WHERE THE VEHICLE STALLED WITHOUT RESTART.INFORMATION CONTAINED IN THE ODI CONSUMER COMPLAINTS AND OBTAINED FROM 72 TELEPHONE INTERVIEWS WITH COMPLAINANTS SHOWED THE FOLLOWING:(1) 99% OF THE COMPLAINTS WERE ON MY 1997 TO 2002 SUBJECT VEHICLES.(2) MOST THE COMPLAINANTS REPORTED HEARING A LOUD POP WHILE DRIVING OR UPON STARTING UP THE VEHICLE FOLLOWED BY A LOUD, REPETITIVE CLICKING OR POPPING SOUND.(3) MANY OF THE COMPLAINANTS REPORTED THAT THE POPPING SOUND WAS ACCOMPANIED BY SOME LOSS OF VEHICLE POWER; HOWEVER, IN 99% OF THE INCIDENTS REPORTED, THE VEHICLE DID NOT STALL.IN THE VERY FEW INCIDENTS WHERE THE VEHICLE DID STALL, MOST VEHICLES COULD BE RESTARTED.(4) ONLY A SMALL PERCENTAGE OF THE COMPLAINANTS CITED THAT THEY SMELLED GAS OR A SLIGHT BURNING SMELL WHEN THE INCIDENT OCCURRED.(5) IN ALL BUT A VERY FEW INCIDENTS, VEHICLE DAMAGE WAS LIMITED TO THE ENGINE.IN ONE INCIDENT, THE COMPLAINT REPORTED THAT THE FUEL RAIL WAS DAMAGED AND REPLACED AFTER ONE OF THE SPARK PLUGS EJECTED FROM THE ENGINE; HOWEVER, THE COMPLAINANT REPORTED THAT THE DAMAGE DID NOT RESULT IN ANY TYPE OF FUEL LEAK OR FIRE.IN ANOTHER INCIDENT, THE ONLY INCIDENT WHERE A FIRE WAS ALLEGED, THE COMPLAINANT REPORTED THAT NO FLUID LEAK WAS OBSERVED, BUT THAT A FIRE RESULTED AFTER THE SPARK PLUG HAD EJECTED FROM THE ENGINE AND HE HAD RESTARTED THE VEHICLE AND DRIVEN TO ANOTHER LOCATION.NONE OF THE COMPLAINANTS REPORTED ANY DAMAGE TO THE VEHICLE HOOD.(6) ONLY TWO COMPLAINANTS REPORTED THAT THEY OBSERVED WHAT APPEARED TO BE SOME DROPS OF FUEL COMING FROM THE CYLINDER WHERE THE SPARK PLUG HAD FAILED OR ON THE SPARK PLUG ITSELF; HOWEVER, EACH OF THESE COMPLAINANTS REPORTED THAT THERE WAS NO SMOKE OR FLAMES AS A RESULT OF HIS INCIDENT.AS THE PETITIONER NOTED, AND ODI?S ANALYSIS SHOWED, IT IS POSSIBLE FOR A SPARK PLUG TO DETACH FROM THE ENGINE CYLINDER THREADS IN THE SUBJECT VEHICLES.HOWEVER, ODI?S ANALYSIS OF 474 COMPLAINTS DESCRIBING SUCH INCIDENTS FOUND ONLY A VERY FEW ALLEGED ANY SAFETY-RELATED CONSEQUENCES.NONE OF THESE SHOWED ANY EVIDENCE OF A SERIOUS SAFETY CONSEQUENCE.GIVEN THE LARGE POPULATION AND RELATIVELY LONG EXPOSURE TIME OF THE SUBJECT VEHICLES, THE COMPLAINT ANALYSIS INDICATES THAT THE RISK TO MOTOR VEHICLE SAFETY FROM THE ALLEGED DEFECT IS VERY LOW.IN VIEW OF THE FOREGOING, IT IS UNLIKELY THAT NHTSA WOULD ISSUE AN ORDER FOR THE NOTIFICATION AND REMEDY OF THE ALLEGED DEFECT AT THE CONCLUSION OF THE INVESTIGATION REQUESTED IN THE PETITION.THEREFORE, IN VIEW OF THE NEED TO ALLOCATE AND PRIORITIZE NHTSA?S LIMITED RESOURCES TO BEST ACCOMPLISH THE AGENCY?S SAFETY MISSION, THE PETITION IS DENIED.
Additional source detail variants (3)
Engine And Engine Cooling:engine
ON SEPTEMBER 6, 2005, ODI RECEIVED A PETITION REQUESTING THAT THE AGENCY INVESTIGATE ALLEGATIONS OF ENGINE SPARK PLUG EJECTION IN CERTAIN MODEL YEAR 1997 THROUGH 2004 FORD VEHICLES WITH TRITON V-8 AND V-10 ENGINES.ODI RECEIVED A TOTAL OF 474 NON-DUPLICATIVE COMPLAINTS ON THE SUBJECT VEHICLES WHERE THE COMPLAINANT, OR THE DEALER REPAIRING THE VEHICLE, REPORTED THAT A SPARK PLUG DETACHED FROM THE CYLINDER AND/OR EJECTED FROM THE ENGINE.AS OF DECEMBER 8, 2005, ODI IS NOT AWARE OF ANY ALLEGATIONS WHERE THE ALLEGED DEFECT RESULTED IN A LOSS OF VEHICLE CONTROL, A CRASH, AN INJURY, OR A FATALITY IN ANY OF THE 10,319,810 SUBJECT VEHICLES.IN ADDITION, ODI IS AWARE OF ONLY TWO INCIDENTS WHERE THE VEHICLE STALLED WITHOUT RESTART.INFORMATION CONTAINED IN THE ODI CONSUMER COMPLAINTS AND OBTAINED FROM 72 TELEPHONE INTERVIEWS WITH COMPLAINANTS SHOWED THE FOLLOWING:(1) 99% OF THE COMPLAINTS WERE ON MY 1997 TO 2002 SUBJECT VEHICLES.(2) MOST THE COMPLAINANTS REPORTED HEARING A LOUD POP WHILE DRIVING OR UPON STARTING UP THE VEHICLE FOLLOWED BY A LOUD, REPETITIVE CLICKING OR POPPING SOUND.(3) MANY OF THE COMPLAINANTS REPORTED THAT THE POPPING SOUND WAS ACCOMPANIED BY SOME LOSS OF VEHICLE POWER; HOWEVER, IN 99% OF THE INCIDENTS REPORTED, THE VEHICLE DID NOT STALL.IN THE VERY FEW INCIDENTS WHERE THE VEHICLE DID STALL, MOST VEHICLES COULD BE RESTARTED.(4) ONLY A SMALL PERCENTAGE OF THE COMPLAINANTS CITED THAT THEY SMELLED GAS OR A SLIGHT BURNING SMELL WHEN THE INCIDENT OCCURRED.(5) IN ALL BUT A VERY FEW INCIDENTS, VEHICLE DAMAGE WAS LIMITED TO THE ENGINE.IN ONE INCIDENT, THE COMPLAINT REPORTED THAT THE FUEL RAIL WAS DAMAGED AND REPLACED AFTER ONE OF THE SPARK PLUGS EJECTED FROM THE ENGINE; HOWEVER, THE COMPLAINANT REPORTED THAT THE DAMAGE DID NOT RESULT IN ANY TYPE OF FUEL LEAK OR FIRE.IN ANOTHER INCIDENT, THE ONLY INCIDENT WHERE A FIRE WAS ALLEGED, THE COMPLAINANT REPORTED THAT NO FLUID LEAK WAS OBSERVED, BUT THAT A FIRE RESULTED AFTER THE SPARK PLUG HAD EJECTED FROM THE ENGINE AND HE HAD RESTARTED THE VEHICLE AND DRIVEN TO ANOTHER LOCATION.NONE OF THE COMPLAINANTS REPORTED ANY DAMAGE TO THE VEHICLE HOOD.(6) ONLY TWO COMPLAINANTS REPORTED THAT THEY OBSERVED WHAT APPEARED TO BE SOME DROPS OF FUEL COMING FROM THE CYLINDER WHERE THE SPARK PLUG HAD FAILED OR ON THE SPARK PLUG ITSELF; HOWEVER, EACH OF THESE COMPLAINANTS REPORTED THAT THERE WAS NO SMOKE OR FLAMES AS A RESULT OF HIS INCIDENT.AS THE PETITIONER NOTED, AND ODI?S ANALYSIS SHOWED, IT IS POSSIBLE FOR A SPARK PLUG TO DETACH FROM THE ENGINE CYLINDER THREADS IN THE SUBJECT VEHICLES.HOWEVER, ODI?S ANALYSIS OF 474 COMPLAINTS DESCRIBING SUCH INCIDENTS FOUND ONLY A VERY FEW ALLEGED ANY SAFETY-RELATED CONSEQUENCES.NONE OF THESE SHOWED ANY EVIDENCE OF A SERIOUS SAFETY CONSEQUENCE.GIVEN THE LARGE POPULATION AND RELATIVELY LONG EXPOSURE TIME OF THE SUBJECT VEHICLES, THE COMPLAINT ANALYSIS INDICATES THAT THE RISK TO MOTOR VEHICLE SAFETY FROM THE ALLEGED DEFECT IS VERY LOW.IN VIEW OF THE FOREGOING, IT IS UNLIKELY THAT NHTSA WOULD ISSUE AN ORDER FOR THE NOTIFICATION AND REMEDY OF THE ALLEGED DEFECT AT THE CONCLUSION OF THE INVESTIGATION REQUESTED IN THE PETITION.THEREFORE, IN VIEW OF THE NEED TO ALLOCATE AND PRIORITIZE NHTSA?S LIMITED RESOURCES TO BEST ACCOMPLISH THE AGENCY?S SAFETY MISSION, THE PETITION IS DENIED.
Engine And Engine Cooling:engine:gasoline
ON SEPTEMBER 6, 2005, ODI RECEIVED A PETITION REQUESTING THAT THE AGENCY INVESTIGATE ALLEGATIONS OF ENGINE SPARK PLUG EJECTION IN CERTAIN MODEL YEAR 1997 THROUGH 2004 FORD VEHICLES WITH TRITON V-8 AND V-10 ENGINES.ODI RECEIVED A TOTAL OF 474 NON-DUPLICATIVE COMPLAINTS ON THE SUBJECT VEHICLES WHERE THE COMPLAINANT, OR THE DEALER REPAIRING THE VEHICLE, REPORTED THAT A SPARK PLUG DETACHED FROM THE CYLINDER AND/OR EJECTED FROM THE ENGINE.AS OF DECEMBER 8, 2005, ODI IS NOT AWARE OF ANY ALLEGATIONS WHERE THE ALLEGED DEFECT RESULTED IN A LOSS OF VEHICLE CONTROL, A CRASH, AN INJURY, OR A FATALITY IN ANY OF THE 10,319,810 SUBJECT VEHICLES.IN ADDITION, ODI IS AWARE OF ONLY TWO INCIDENTS WHERE THE VEHICLE STALLED WITHOUT RESTART.INFORMATION CONTAINED IN THE ODI CONSUMER COMPLAINTS AND OBTAINED FROM 72 TELEPHONE INTERVIEWS WITH COMPLAINANTS SHOWED THE FOLLOWING:(1) 99% OF THE COMPLAINTS WERE ON MY 1997 TO 2002 SUBJECT VEHICLES.(2) MOST THE COMPLAINANTS REPORTED HEARING A LOUD POP WHILE DRIVING OR UPON STARTING UP THE VEHICLE FOLLOWED BY A LOUD, REPETITIVE CLICKING OR POPPING SOUND.(3) MANY OF THE COMPLAINANTS REPORTED THAT THE POPPING SOUND WAS ACCOMPANIED BY SOME LOSS OF VEHICLE POWER; HOWEVER, IN 99% OF THE INCIDENTS REPORTED, THE VEHICLE DID NOT STALL.IN THE VERY FEW INCIDENTS WHERE THE VEHICLE DID STALL, MOST VEHICLES COULD BE RESTARTED.(4) ONLY A SMALL PERCENTAGE OF THE COMPLAINANTS CITED THAT THEY SMELLED GAS OR A SLIGHT BURNING SMELL WHEN THE INCIDENT OCCURRED.(5) IN ALL BUT A VERY FEW INCIDENTS, VEHICLE DAMAGE WAS LIMITED TO THE ENGINE.IN ONE INCIDENT, THE COMPLAINT REPORTED THAT THE FUEL RAIL WAS DAMAGED AND REPLACED AFTER ONE OF THE SPARK PLUGS EJECTED FROM THE ENGINE; HOWEVER, THE COMPLAINANT REPORTED THAT THE DAMAGE DID NOT RESULT IN ANY TYPE OF FUEL LEAK OR FIRE.IN ANOTHER INCIDENT, THE ONLY INCIDENT WHERE A FIRE WAS ALLEGED, THE COMPLAINANT REPORTED THAT NO FLUID LEAK WAS OBSERVED, BUT THAT A FIRE RESULTED AFTER THE SPARK PLUG HAD EJECTED FROM THE ENGINE AND HE HAD RESTARTED THE VEHICLE AND DRIVEN TO ANOTHER LOCATION.NONE OF THE COMPLAINANTS REPORTED ANY DAMAGE TO THE VEHICLE HOOD.(6) ONLY TWO COMPLAINANTS REPORTED THAT THEY OBSERVED WHAT APPEARED TO BE SOME DROPS OF FUEL COMING FROM THE CYLINDER WHERE THE SPARK PLUG HAD FAILED OR ON THE SPARK PLUG ITSELF; HOWEVER, EACH OF THESE COMPLAINANTS REPORTED THAT THERE WAS NO SMOKE OR FLAMES AS A RESULT OF HIS INCIDENT.AS THE PETITIONER NOTED, AND ODI?S ANALYSIS SHOWED, IT IS POSSIBLE FOR A SPARK PLUG TO DETACH FROM THE ENGINE CYLINDER THREADS IN THE SUBJECT VEHICLES.HOWEVER, ODI?S ANALYSIS OF 474 COMPLAINTS DESCRIBING SUCH INCIDENTS FOUND ONLY A VERY FEW ALLEGED ANY SAFETY-RELATED CONSEQUENCES.NONE OF THESE SHOWED ANY EVIDENCE OF A SERIOUS SAFETY CONSEQUENCE.GIVEN THE LARGE POPULATION AND RELATIVELY LONG EXPOSURE TIME OF THE SUBJECT VEHICLES, THE COMPLAINT ANALYSIS INDICATES THAT THE RISK TO MOTOR VEHICLE SAFETY FROM THE ALLEGED DEFECT IS VERY LOW.IN VIEW OF THE FOREGOING, IT IS UNLIKELY THAT NHTSA WOULD ISSUE AN ORDER FOR THE NOTIFICATION AND REMEDY OF THE ALLEGED DEFECT AT THE CONCLUSION OF THE INVESTIGATION REQUESTED IN THE PETITION.THEREFORE, IN VIEW OF THE NEED TO ALLOCATE AND PRIORITIZE NHTSA?S LIMITED RESOURCES TO BEST ACCOMPLISH THE AGENCY?S SAFETY MISSION, THE PETITION IS DENIED.
Engine And Engine Cooling
ON SEPTEMBER 6, 2005, ODI RECEIVED A PETITION REQUESTING THAT THE AGENCY INVESTIGATE ALLEGATIONS OF ENGINE SPARK PLUG EJECTION IN CERTAIN MODEL YEAR 1997 THROUGH 2004 FORD VEHICLES WITH TRITON V-8 AND V-10 ENGINES.ODI RECEIVED A TOTAL OF 474 NON-DUPLICATIVE COMPLAINTS ON THE SUBJECT VEHICLES WHERE THE COMPLAINANT, OR THE DEALER REPAIRING THE VEHICLE, REPORTED THAT A SPARK PLUG DETACHED FROM THE CYLINDER AND/OR EJECTED FROM THE ENGINE.AS OF DECEMBER 8, 2005, ODI IS NOT AWARE OF ANY ALLEGATIONS WHERE THE ALLEGED DEFECT RESULTED IN A LOSS OF VEHICLE CONTROL, A CRASH, AN INJURY, OR A FATALITY IN ANY OF THE 10,319,810 SUBJECT VEHICLES.IN ADDITION, ODI IS AWARE OF ONLY TWO INCIDENTS WHERE THE VEHICLE STALLED WITHOUT RESTART.INFORMATION CONTAINED IN THE ODI CONSUMER COMPLAINTS AND OBTAINED FROM 72 TELEPHONE INTERVIEWS WITH COMPLAINANTS SHOWED THE FOLLOWING:(1) 99% OF THE COMPLAINTS WERE ON MY 1997 TO 2002 SUBJECT VEHICLES.(2) MOST THE COMPLAINANTS REPORTED HEARING A LOUD POP WHILE DRIVING OR UPON STARTING UP THE VEHICLE FOLLOWED BY A LOUD, REPETITIVE CLICKING OR POPPING SOUND.(3) MANY OF THE COMPLAINANTS REPORTED THAT THE POPPING SOUND WAS ACCOMPANIED BY SOME LOSS OF VEHICLE POWER; HOWEVER, IN 99% OF THE INCIDENTS REPORTED, THE VEHICLE DID NOT STALL.IN THE VERY FEW INCIDENTS WHERE THE VEHICLE DID STALL, MOST VEHICLES COULD BE RESTARTED.(4) ONLY A SMALL PERCENTAGE OF THE COMPLAINANTS CITED THAT THEY SMELLED GAS OR A SLIGHT BURNING SMELL WHEN THE INCIDENT OCCURRED.(5) IN ALL BUT A VERY FEW INCIDENTS, VEHICLE DAMAGE WAS LIMITED TO THE ENGINE.IN ONE INCIDENT, THE COMPLAINT REPORTED THAT THE FUEL RAIL WAS DAMAGED AND REPLACED AFTER ONE OF THE SPARK PLUGS EJECTED FROM THE ENGINE; HOWEVER, THE COMPLAINANT REPORTED THAT THE DAMAGE DID NOT RESULT IN ANY TYPE OF FUEL LEAK OR FIRE.IN ANOTHER INCIDENT, THE ONLY INCIDENT WHERE A FIRE WAS ALLEGED, THE COMPLAINANT REPORTED THAT NO FLUID LEAK WAS OBSERVED, BUT THAT A FIRE RESULTED AFTER THE SPARK PLUG HAD EJECTED FROM THE ENGINE AND HE HAD RESTARTED THE VEHICLE AND DRIVEN TO ANOTHER LOCATION.NONE OF THE COMPLAINANTS REPORTED ANY DAMAGE TO THE VEHICLE HOOD.(6) ONLY TWO COMPLAINANTS REPORTED THAT THEY OBSERVED WHAT APPEARED TO BE SOME DROPS OF FUEL COMING FROM THE CYLINDER WHERE THE SPARK PLUG HAD FAILED OR ON THE SPARK PLUG ITSELF; HOWEVER, EACH OF THESE COMPLAINANTS REPORTED THAT THERE WAS NO SMOKE OR FLAMES AS A RESULT OF HIS INCIDENT.AS THE PETITIONER NOTED, AND ODI?S ANALYSIS SHOWED, IT IS POSSIBLE FOR A SPARK PLUG TO DETACH FROM THE ENGINE CYLINDER THREADS IN THE SUBJECT VEHICLES.HOWEVER, ODI?S ANALYSIS OF 474 COMPLAINTS DESCRIBING SUCH INCIDENTS FOUND ONLY A VERY FEW ALLEGED ANY SAFETY-RELATED CONSEQUENCES.NONE OF THESE SHOWED ANY EVIDENCE OF A SERIOUS SAFETY CONSEQUENCE.GIVEN THE LARGE POPULATION AND RELATIVELY LONG EXPOSURE TIME OF THE SUBJECT VEHICLES, THE COMPLAINT ANALYSIS INDICATES THAT THE RISK TO MOTOR VEHICLE SAFETY FROM THE ALLEGED DEFECT IS VERY LOW.IN VIEW OF THE FOREGOING, IT IS UNLIKELY THAT NHTSA WOULD ISSUE AN ORDER FOR THE NOTIFICATION AND REMEDY OF THE ALLEGED DEFECT AT THE CONCLUSION OF THE INVESTIGATION REQUESTED IN THE PETITION.THEREFORE, IN VIEW OF THE NEED TO ALLOCATE AND PRIORITIZE NHTSA?S LIMITED RESOURCES TO BEST ACCOMPLISH THE AGENCY?S SAFETY MISSION, THE PETITION IS DENIED.
EA05003 · Engine Stalling
Opened Feb 15, 2005 · Closed Nov 2, 2005
Status: closed (inferred from source dates) · Electrical System:wiring:front Underhood; Engine And Engine Cooling; Engine And Engine Cooling:engine:diesel
IN A JUNE 7, 2005 LETTER, FORD NOTIFIED ODI THAT IT WOULD BE CONDUCTING A SAFETY RECALL OF APPROXIMATELY 180,000 FORD F-SUPER DUTY, EXCURSION AND E-SERIES VEHICLES EQUIPPED WITH 6.0L DIESEL ENGINES TO CORRECT TWO WIRING RELATED CONDITIONS THAT COULD RESULT IN ENGINE STALL (NHTSA RECALL NO. 05V-270, FORD NO. 05S34).THE AFFECTED VEHICLES WERE BUILT BETWEEN SEPTEMBER 29, 2003 AND MAY 31, 2004.ACCORDING TO FORD, VEHICLES WITH THE CONDITIONS MAY STALL WITHOUT WARNING AND MAY OR MAY NOT RESTART.FORD WILL INSTRUCT OWNERS OF VEHICLES INCLUDED IN THE RECALL TO TAKE THEIR VEHICLES TO A DEALER TO HAVE THE FUEL INJECTOR CONTROL MODULE WIRE HARNESS UPGRADED OR REPLACED AND OR HAVE A NEW INJECTION CONTROL PRESSURE SENSOR CONNECTOR INSTALLED.DURING A MAY 2005 PRESENTATION TO ODI, FORD IDENTIFIED A NUMBER OF POTENTIAL FAILURE MECHANISMS THAT COULD AFFECT ENGINE PERFORMANCE IN VARIOUS SEGMENTS OF THE SUBJECT VEHICLE POPULATION, INCLUDING THE WIRING CONDITIONS ADDRESSED BY 05V-270.THE WIRING CONDITIONS, WHICH BOTH AFFECT ENGINE FUELING, WERE THE MOST LIKELY CONDITIONS TO RESULT IN ENGINE STALL.THE RECALLED VEHICLES COMPRISE APPROXIMATELY 43% OF THE SUBJECT VEHICLE POPULATION AND ACCOUNT FOR 75 OF THE 113 ODI REPORTS THAT HAVE A VALID VIN (66%).THE VOQ COMPLAINT RATE FOR THE RECALL POPULATION IS 45/100K WHILE THE RATE FOR VEHICLES OUTSIDE THE RECALL POPULATION IS 17/100K AND THEIR TREND (BY DATE OF RECEIPT) IS DECLINING.BASED ON THE ANALYSIS, ODI BELIEVES FORD?S ACTIONS ARE SUFFICIENT TO ADDRESS THE CURRENT SAFETY RISKS AND THE INVESTIGATION IS THUS CLOSED.THE CLOSING OF THIS INVESTIGATION DOES NOT CONSTITUTE A FINDING BY NHTSA THAT A SAFETY RELATED DEFECT DOES NOT EXIST.FURTHER ACTION WILL BE TAKEN IF WARRANTED BY FUTURE CIRCUMSTANCES.
Additional source detail variants (3)
Electrical System:wiring:front Underhood
IN A JUNE 7, 2005 LETTER, FORD NOTIFIED ODI THAT IT WOULD BE CONDUCTING A SAFETY RECALL OF APPROXIMATELY 180,000 FORD F-SUPER DUTY, EXCURSION AND E-SERIES VEHICLES EQUIPPED WITH 6.0L DIESEL ENGINES TO CORRECT TWO WIRING RELATED CONDITIONS THAT COULD RESULT IN ENGINE STALL (NHTSA RECALL NO. 05V-270, FORD NO. 05S34).THE AFFECTED VEHICLES WERE BUILT BETWEEN SEPTEMBER 29, 2003 AND MAY 31, 2004.ACCORDING TO FORD, VEHICLES WITH THE CONDITIONS MAY STALL WITHOUT WARNING AND MAY OR MAY NOT RESTART.FORD WILL INSTRUCT OWNERS OF VEHICLES INCLUDED IN THE RECALL TO TAKE THEIR VEHICLES TO A DEALER TO HAVE THE FUEL INJECTOR CONTROL MODULE WIRE HARNESS UPGRADED OR REPLACED AND OR HAVE A NEW INJECTION CONTROL PRESSURE SENSOR CONNECTOR INSTALLED.DURING A MAY 2005 PRESENTATION TO ODI, FORD IDENTIFIED A NUMBER OF POTENTIAL FAILURE MECHANISMS THAT COULD AFFECT ENGINE PERFORMANCE IN VARIOUS SEGMENTS OF THE SUBJECT VEHICLE POPULATION, INCLUDING THE WIRING CONDITIONS ADDRESSED BY 05V-270.THE WIRING CONDITIONS, WHICH BOTH AFFECT ENGINE FUELING, WERE THE MOST LIKELY CONDITIONS TO RESULT IN ENGINE STALL.THE RECALLED VEHICLES COMPRISE APPROXIMATELY 43% OF THE SUBJECT VEHICLE POPULATION AND ACCOUNT FOR 75 OF THE 113 ODI REPORTS THAT HAVE A VALID VIN (66%).THE VOQ COMPLAINT RATE FOR THE RECALL POPULATION IS 45/100K WHILE THE RATE FOR VEHICLES OUTSIDE THE RECALL POPULATION IS 17/100K AND THEIR TREND (BY DATE OF RECEIPT) IS DECLINING.BASED ON THE ANALYSIS, ODI BELIEVES FORD?S ACTIONS ARE SUFFICIENT TO ADDRESS THE CURRENT SAFETY RISKS AND THE INVESTIGATION IS THUS CLOSED.THE CLOSING OF THIS INVESTIGATION DOES NOT CONSTITUTE A FINDING BY NHTSA THAT A SAFETY RELATED DEFECT DOES NOT EXIST.FURTHER ACTION WILL BE TAKEN IF WARRANTED BY FUTURE CIRCUMSTANCES.
Engine And Engine Cooling:engine:diesel
IN A JUNE 7, 2005 LETTER, FORD NOTIFIED ODI THAT IT WOULD BE CONDUCTING A SAFETY RECALL OF APPROXIMATELY 180,000 FORD F-SUPER DUTY, EXCURSION AND E-SERIES VEHICLES EQUIPPED WITH 6.0L DIESEL ENGINES TO CORRECT TWO WIRING RELATED CONDITIONS THAT COULD RESULT IN ENGINE STALL (NHTSA RECALL NO. 05V-270, FORD NO. 05S34).THE AFFECTED VEHICLES WERE BUILT BETWEEN SEPTEMBER 29, 2003 AND MAY 31, 2004.ACCORDING TO FORD, VEHICLES WITH THE CONDITIONS MAY STALL WITHOUT WARNING AND MAY OR MAY NOT RESTART.FORD WILL INSTRUCT OWNERS OF VEHICLES INCLUDED IN THE RECALL TO TAKE THEIR VEHICLES TO A DEALER TO HAVE THE FUEL INJECTOR CONTROL MODULE WIRE HARNESS UPGRADED OR REPLACED AND OR HAVE A NEW INJECTION CONTROL PRESSURE SENSOR CONNECTOR INSTALLED.DURING A MAY 2005 PRESENTATION TO ODI, FORD IDENTIFIED A NUMBER OF POTENTIAL FAILURE MECHANISMS THAT COULD AFFECT ENGINE PERFORMANCE IN VARIOUS SEGMENTS OF THE SUBJECT VEHICLE POPULATION, INCLUDING THE WIRING CONDITIONS ADDRESSED BY 05V-270.THE WIRING CONDITIONS, WHICH BOTH AFFECT ENGINE FUELING, WERE THE MOST LIKELY CONDITIONS TO RESULT IN ENGINE STALL.THE RECALLED VEHICLES COMPRISE APPROXIMATELY 43% OF THE SUBJECT VEHICLE POPULATION AND ACCOUNT FOR 75 OF THE 113 ODI REPORTS THAT HAVE A VALID VIN (66%).THE VOQ COMPLAINT RATE FOR THE RECALL POPULATION IS 45/100K WHILE THE RATE FOR VEHICLES OUTSIDE THE RECALL POPULATION IS 17/100K AND THEIR TREND (BY DATE OF RECEIPT) IS DECLINING.BASED ON THE ANALYSIS, ODI BELIEVES FORD?S ACTIONS ARE SUFFICIENT TO ADDRESS THE CURRENT SAFETY RISKS AND THE INVESTIGATION IS THUS CLOSED.THE CLOSING OF THIS INVESTIGATION DOES NOT CONSTITUTE A FINDING BY NHTSA THAT A SAFETY RELATED DEFECT DOES NOT EXIST.FURTHER ACTION WILL BE TAKEN IF WARRANTED BY FUTURE CIRCUMSTANCES.
Engine And Engine Cooling
IN A JUNE 7, 2005 LETTER, FORD NOTIFIED ODI THAT IT WOULD BE CONDUCTING A SAFETY RECALL OF APPROXIMATELY 180,000 FORD F-SUPER DUTY, EXCURSION AND E-SERIES VEHICLES EQUIPPED WITH 6.0L DIESEL ENGINES TO CORRECT TWO WIRING RELATED CONDITIONS THAT COULD RESULT IN ENGINE STALL (NHTSA RECALL NO. 05V-270, FORD NO. 05S34).THE AFFECTED VEHICLES WERE BUILT BETWEEN SEPTEMBER 29, 2003 AND MAY 31, 2004.ACCORDING TO FORD, VEHICLES WITH THE CONDITIONS MAY STALL WITHOUT WARNING AND MAY OR MAY NOT RESTART.FORD WILL INSTRUCT OWNERS OF VEHICLES INCLUDED IN THE RECALL TO TAKE THEIR VEHICLES TO A DEALER TO HAVE THE FUEL INJECTOR CONTROL MODULE WIRE HARNESS UPGRADED OR REPLACED AND OR HAVE A NEW INJECTION CONTROL PRESSURE SENSOR CONNECTOR INSTALLED.DURING A MAY 2005 PRESENTATION TO ODI, FORD IDENTIFIED A NUMBER OF POTENTIAL FAILURE MECHANISMS THAT COULD AFFECT ENGINE PERFORMANCE IN VARIOUS SEGMENTS OF THE SUBJECT VEHICLE POPULATION, INCLUDING THE WIRING CONDITIONS ADDRESSED BY 05V-270.THE WIRING CONDITIONS, WHICH BOTH AFFECT ENGINE FUELING, WERE THE MOST LIKELY CONDITIONS TO RESULT IN ENGINE STALL.THE RECALLED VEHICLES COMPRISE APPROXIMATELY 43% OF THE SUBJECT VEHICLE POPULATION AND ACCOUNT FOR 75 OF THE 113 ODI REPORTS THAT HAVE A VALID VIN (66%).THE VOQ COMPLAINT RATE FOR THE RECALL POPULATION IS 45/100K WHILE THE RATE FOR VEHICLES OUTSIDE THE RECALL POPULATION IS 17/100K AND THEIR TREND (BY DATE OF RECEIPT) IS DECLINING.BASED ON THE ANALYSIS, ODI BELIEVES FORD?S ACTIONS ARE SUFFICIENT TO ADDRESS THE CURRENT SAFETY RISKS AND THE INVESTIGATION IS THUS CLOSED.THE CLOSING OF THIS INVESTIGATION DOES NOT CONSTITUTE A FINDING BY NHTSA THAT A SAFETY RELATED DEFECT DOES NOT EXIST.FURTHER ACTION WILL BE TAKEN IF WARRANTED BY FUTURE CIRCUMSTANCES.
Illustration