Hello, I am reporting a safety issue involving my Ford F250 vehicle related to Safety Recall 25S75 (low-pressure fuel pump failure). Approximately one month ago, while driving on the freeway at approximately 65 mph, my vehicle experienced a sudden loss of power. This created a dangerous situation as I was traveling at highway speed and the vehicle became unable to maintain normal operation. The vehicle is now inoperable. The failure is consistent with the condition described in Recall 25S75. This is not a preventative concern — the defect has already occurred and has rendered the vehicle undrivable. I contacted Ford Customer Relations and explained that the failure matches the recall condition. However, my case was closed without resolution, without any determination of responsibility, and without conducting a repair or transportation support. Ford has indicated that the official recall remedy is not yet available. Despite this, I have been told I may be responsible for out-of-pocket repair costs, even though the failure is consistent with an active safety recall. This situation presents both a safety concern and an unreasonable financial burden, as the vehicle cannot be safely operated and no interim remedy or support has been provided. I am requesting that NHTSA review this matter, as the manufacturer is not addressing a recall-related failure that has already occurred and resulted in a loss of power at highway speed. If you need any additional details, please do not hesitate to reach out. Thanks, [XXX] INFORMATION REDACTED PURSUANT TO THE FREEDOM OF INFORMATION ACT (FOIA), 5 U.S.C. 552(B)(6)

NHTSA ODI #11729246

Mileage unknown · Feb 21, 2026

Fuel/propulsion System

Read full complaint

1. Fuel Pump failure occurred September 4th 2025 2. While towing a travel trailer from Raleigh NC to Surf City NC. When the truck stalled we lost all power and power steering and there was no clear path to pull off the single lane road with no shoulder. With a line of vehicle's behind us, including tractor trailers this created very serious safety situation not only for us but other travelers heading toward us and behind us. We were fortunate that the tractor trailer behind us was alert. I was able to restart the vehicle and drive to a safe location. We left the travel trailer at the coast, and returned vehicle to Capital Ford on or about September 9th. So yes, our safety and the safety of other was in serious risk. 3. No the problem has not been reproduced. 4. Yes the dealer, Capital Ford, Inc of Raleigh, NC has inspected and confirmed root cause to be fuel pump recall. 5. As I recall the truck hesitated, check engine light came on, and truck stalled ( unsure if light came on before or after stall) in a very short period of time. I do not recall the exact amount of time but I do recall the hesitation, I told my wife something is not right, engine stalled and we lost all power. Currently it has been 8 months since notification and, for the safety of the driver and other on the road, we have been unable to use vehicle for reason purchased since the incident.

NHTSA ODI #11719543

Official recalls

No recalls in this snapshot.

Model-level recall history does not show whether a particular VIN is affected or has received a repair. Check a VIN with NHTSA ↗

NHTSA investigations

PE24019 · Low-pressure Fuel Pump Failure

Opened Jul 29, 2024 · Closed Sep 19, 2025

Status: closed (inferred from source dates) · Fuel System, Gasoline:delivery:fuel Pump

On July 29, 2024, the Oﬃce of Defects Investigation (ODI) opened PE24019 to investigate complaints of low-pressure fuel pump failures in MY 2021 Ford Bronco vehicles. Some consumers reported that the failure occurred without warning while driving, resulting in a complete loss of motive power with no ability to restart the engine. Ford determined that several other vehicle models contain low-pressure fuel pumps substantially similar to the 2021 Ford Bronco, including the 2022-2023 Ford Bronco, 2018-2023 Ford F-150, 2022-2023 Ford Expedition, 2019-2023 Lincoln Navigator, 2020-2023 Ford F-250-F-550, 2024 Ford Super Duty Chassis Cab, 2024-2025 Ford Ranger, 2020-2023 Ford Explorer, 2020-2023 Lincoln Aviator, and 2021-2025 Ford Mustang. ODI's investigation found that the aﬀected vehicles may lose fuel pressure and ﬂow from the fuel delivery module (consisting of a low-pressure fuel pump, jet pump, reservoir, and other parts) due to a low-pressure pump failure. This can cause the engine to stall while driving. The root cause is reduced internal clearance in the fuel pump, increasing friction and sensitivity to vapor lock. Fuel blockage from contamination inside the jet pump also contributed to the failure. Ford stated that the contamination source was unknown. On July 7, 2025, Ford ﬁled recall 25V-455 for certain 2021-2023 Ford F-550 SD/F-450 SD/F-350 SD/F-250 SD, 2021-2022 Lincoln Navigator, 2021-2022 Ford Mustang, 2021-2022 Ford F-150, 2021-2023 Ford Explorer, 2022 Ford Expedition, and 2021-2023 Ford Bronco vehicles produced between July 1, 2021, and July 30, 2022. The recall also included certain 2021-2023 Lincoln Aviator produced between July 1, 2021, and December 21, 2022. Ford explained in its recall filingthat the production dates used for the recall were based on changes in the manufacturing process. Specifically, Ford determined that in June 2021, the supplier modified the jet pump manufacturing process, producing fuel pump chambers with a lower-than-specified internal clearance. In July 2022, the supplier implemented corrective actions to the manufacturing process by adding two additional vacuum pumps to reduce contamination during the production of the jet pump. ODI has identified approximately 1,000 reports involving vehicles covered in this investigation but excluded from recall 25V-455. However, even with such reports, these vehicles experienced comparatively lower failure rates than the vehicles that are subject to Recall 25V-455. Ford has explained that these vehicles were excluded from the recall population because they did not experience the manufacturing changes that prompted the recall. Specifically, according to Ford, vehicles built before July 1, 2021 (the recall production start date), were not affected by the supplier’s change to the jet pump manufacturing process. Even after closing this investigation, ODI will continue to monitor complaints for vehicles excluded from recall 25V-455 to consider whether they exhibit the same risks as the vehicles encompassed by the recall. The recall remedy is currently under development. In view of Ford’s recall action, ODI is closing this Preliminary Evaluation, but will continue to monitor the issue as a remedy is developed and implemented. ODI will take additional action if warranted by future circumstances. To review the reports cited in the Closing Resume ODI Report Identiﬁcation Number document, go to NHTSA.gov.