NHTSA owner reports · September 18, 2026 snapshot.
What owners actually said
221 reports83,000 miles · Mar 27, 2015
Seat Belts
TL*THE CONTACT OWNS A 2006 FORD F-250. THE CONTACT STATED THAT WHILE DRIVING AT A VARIOUS SPEEDS, THE FRONT PASSENGER, FRONT MIDDLE AND REAR MIDDLE SEAT BELTS FAILED TO BUCKLE. THE VEHICLE WAS NOT DIAGNOSED OR REPAIRED. THE FAILURE RECURRED ON NUMEROUS OCCASIONS. THE MANUFACTURER WAS NOT NOTIFIED OF THE FAILURE. THE FAILURE MILE…
Read full complaint
TL*THE CONTACT OWNS A 2006 FORD F-250. THE CONTACT STATED THAT WHILE DRIVING AT A VARIOUS SPEEDS, THE FRONT PASSENGER, FRONT MIDDLE AND REAR MIDDLE SEAT BELTS FAILED TO BUCKLE. THE VEHICLE WAS NOT DIAGNOSED OR REPAIRED. THE FAILURE RECURRED ON NUMEROUS OCCASIONS. THE MANUFACTURER WAS NOT NOTIFIED OF THE FAILURE. THE FAILURE MILEAGE WAS 83,000.
NHTSA ODI #10702141
46,500 miles · Mar 15, 2015
Fuel/propulsion System
TRUCK STALLED AT INTERSECTION. COMPLETE POWER OUTAGE, NO BRAKES, ETC. MANAGES TO RESTART. PROBLEM RECURRED TWO ADDITIONAL TIMES. I LIMPED TO A LOCAL MECHANIC SHOP WHO SCANNED THE ENGINE CODES. HE TOLD ME IT WAS THE THROTTLE BODY AND CHARGED ME $550.00 TO REPLACE IT. TRUCK HAD 47,000 ON IT AT THE TIME. IN MY OPINION THIS PART SHO…
Read full complaint
TRUCK STALLED AT INTERSECTION. COMPLETE POWER OUTAGE, NO BRAKES, ETC. MANAGES TO RESTART. PROBLEM RECURRED TWO ADDITIONAL TIMES. I LIMPED TO A LOCAL MECHANIC SHOP WHO SCANNED THE ENGINE CODES. HE TOLD ME IT WAS THE THROTTLE BODY AND CHARGED ME $550.00 TO REPLACE IT. TRUCK HAD 47,000 ON IT AT THE TIME. IN MY OPINION THIS PART SHOULD LAST WELL INTO THE 100,000 MILE MARK. *TR
NHTSA ODI #10694333
160,000 miles · Jan 29, 2015
EngineEngine And Engine Cooling
TL*THE CONTACT OWNS A 2006 FORD F-250. THE CONTACT STATED THAT WHILE DRIVING AT 3 MPH, THE ACCELERATOR PEDAL WAS DEPRESSED BUT IT FAILED TO RESPOND. IN ADDITION, THE CONTACT NOTICED SMOKE COMING FROM THE EXHAUST PIPE. THE VEHICLE WAS TAKEN TO A DEALER. THE TECHNICIAN STATED THAT THE OIL COOLER, THE EXHAUST BACK PRESSURE SENSOR, …
Read full complaint
TL*THE CONTACT OWNS A 2006 FORD F-250. THE CONTACT STATED THAT WHILE DRIVING AT 3 MPH, THE ACCELERATOR PEDAL WAS DEPRESSED BUT IT FAILED TO RESPOND. IN ADDITION, THE CONTACT NOTICED SMOKE COMING FROM THE EXHAUST PIPE. THE VEHICLE WAS TAKEN TO A DEALER. THE TECHNICIAN STATED THAT THE OIL COOLER, THE EXHAUST BACK PRESSURE SENSOR, THE TURBO AND THE EGR VALVE NEEDED TO BE REPLACED. THE VEHICLE WAS REPAIRED HOWEVER, THE FAILURE RECURRED. THE MANUFACTURER WAS MADE AWARE OF THE FAILURE. THE FAILURE MILEAGE WAS 160,000.
NHTSA ODI #10679720
142,000 miles · Jan 26, 2015
Engine And Engine CoolingFuel/propulsion System
THE TRUCK WAS ON A MAJOR INTERSTATE (I-81 NEAR BLACKSBURG EXIT 118A,B,C) DRIVING UPHILL. WHILE TRYING TO MERGE INTO THE RIGHT LANE FROM THE MIDDLE LANE, WHILE LETTING OF THE ACCELERATOR THE ENGINE DIES. AT THIS POINT LOST ALL POWER INCLUDING BRAKES AND STEERING CONTROL. SINCE THERE WAS NO TRAFFIC IMMEDIATELY BEHIND THE TRUCK THE…
Read full complaint
THE TRUCK WAS ON A MAJOR INTERSTATE (I-81 NEAR BLACKSBURG EXIT 118A,B,C) DRIVING UPHILL. WHILE TRYING TO MERGE INTO THE RIGHT LANE FROM THE MIDDLE LANE, WHILE LETTING OF THE ACCELERATOR THE ENGINE DIES. AT THIS POINT LOST ALL POWER INCLUDING BRAKES AND STEERING CONTROL. SINCE THERE WAS NO TRAFFIC IMMEDIATELY BEHIND THE TRUCK THEN WAS ABLE TO PULL OVER TO THE FIRST LANE AND GET OFF THE SHOULDER. THE TRUCK DIED AND FORTUNATELY DUE TO LOW TRAFFIC ABLE TO MANEUVER TO THE SHOULDER. AT THAT POINT, TRIED TO START THE TRUCK AND IT WOULD NOT START SO HAD TO REMAIN ON THE SIDE OF INTERSTATE UNTIL HELP COULD ARRIVE. STRANDED ON THE SIDE OF THE INTERSTATE. TRUCK WAS TOWED TO DEALERSHIP. FORD BLOGS INDICATE THERE IS A KNOWN PROBLEM THAT HAS GONE UNADDRESSED. *TR
NHTSA ODI #10679037
118,000 miles · Jan 26, 2015
SteeringTiresWheels
HELLO, I HAVE A FORD F 250 SUPER DUTY KING RANCH 4X4 DIESEL THAT MY WIFE AND I ALWAYS WANTED. WE BOUGHT FROM A USED CAR/TRUCK LOT. THE RIMS AND TIRES ARE BRAND NEW AS IS ALIGNMENT WAS ALSO HAD DONE TO FIX THE PROBLEM RIGHT OUT OF THE GATE BUT IT DIDN'T.. WHEN THE TRUCK GETS TO 44 MILES AN HOUR AND UP TO 50 MPH MY F 250 HOPS LA…
Read full complaint
HELLO, I HAVE A FORD F 250 SUPER DUTY KING RANCH 4X4 DIESEL THAT MY WIFE AND I ALWAYS WANTED. WE BOUGHT FROM A USED CAR/TRUCK LOT. THE RIMS AND TIRES ARE BRAND NEW AS IS ALIGNMENT WAS ALSO HAD DONE TO FIX THE PROBLEM RIGHT OUT OF THE GATE BUT IT DIDN'T.. WHEN THE TRUCK GETS TO 44 MILES AN HOUR AND UP TO 50 MPH MY F 250 HOPS LAND I DON'T KNOW IF ITS FROM THE FRONT OR BACK BUT I THINK ITS HAPPENING IN THE FRONT THE WAY IT FEELS ON THE STEERING WHEEL.. MY TRUCK STEERING WHEEL DOES NOT MOVE BACK AND FORTH LIKE THE TIRES ARE WIGGLING RIGHT AND LEFT , IT IS MORE LIKE WHEN YOU HAVE A BAD RIM OR UNEVEN TIRE HOP, LIKE WHEN I WAS A KID AND COULDN'T AFFORD TIRES AND BOUGHT SOME USED ONES AND GET A BUM TIRE IN THE SET OR MAYBE A RIMS THAT I HAD TRADED FOR AND ONE WAS BAD.. WE LOVE THIS F 250 AND HAVE PUT A LOT OF MONEY INTO IT, NOT KNOWING ANYTHING ABOUT DIESEL TRUCKS, ONLY LOVING THE SOUND AND POWER OF THEM SO THE PROBLEMS THE DEALERSHIP FAILED TO POINT OUT OR MENTION TO US WE HAVE HAD ALL FIXED PROPERLY AND THIS HOP OR BOUNCE THAT MY F 250 IS EXPERIENCING IS REALLY A WORRY TO US SEEING HOW WE BOUGHT IT TO PULL A TRAVEL TRAILER WE PURCHASED TO EXPLORE THIS GREAT U.S.A. SO WE WILL BE CONSTANTLY DRIVING IT ATTACHED TO THE TRAILER OR NOT. I HAVE REPLACED RIMS, TIRES AND HAD AN ALIGNMENT AS STATED BEFORE AND WOULD REALLY LIKE TO SOLVE THIS PROBLEM WHICH IF YOU GOOGLED IT AND SEEING ALOT OFL OTHERS EXPERIENCING THIS SAME PROBLEM AND SOME EVEN LIFE THREATENING WHICH WORRIES ME ALSO IF WHATEVER THE PROBLEM IS, CAUSES SOMETHING TO BREAK OR HAPPEN. I THANK YOU FOR YOUR TIME AND CONCERNS TO REMEDY THIS SAFETY HAZARD ON FORD SUPER DUTY TRUCKS.. [XXX] INFORMATION REDACTED PURSUANT TO THE FREEDOM OF INFORMATION ACT (FOIA), 5 U.S.C. 552(B)(6). *TR
NHTSA ODI #10679011
Mileage unknown · Jan 26, 2015
Engine
TOWED ON SEPT/19/2014 KN MILEAGE DEALER SAID NO PROBLEM FOUND;. 2ND TOW 11/02/2014 MILEAGE 187190 EGR VALVE FAILED WILL NEED ENGINE REPLACED. DEALER WHERE BOUGHT DID NOT DISCLOSE. THE TRUCK HAD THE MOTOR REBUILD IN 2008. AND MANY CLASS ACTION SUITS HAVE BEEN FILED. ON 6.0L ENGINES. *TR
NHTSA ODI #10678993
21,000 miles · Jan 23, 2015
Visibility
TL*THE CONTACT OWNS A 2006 FORD F-250. THE CONTACT STATED THAT THE SUN ROOF WINDOW WAS DETACHING FROM THE VEHICLE. THE VEHICLE WAS TAKEN TO A DEALER. THE TECHNICIAN MADE THE CONTACT AWARE THAT THERE WAS A MANUFACTURER RECALL RELATED TO THE SUN ROOF FAILURE. THE SUN ROOF WAS REPAIRED. THE MANUFACTURER WAS NOTIFIED OF THE FAILURE.…
Read full complaint
TL*THE CONTACT OWNS A 2006 FORD F-250. THE CONTACT STATED THAT THE SUN ROOF WINDOW WAS DETACHING FROM THE VEHICLE. THE VEHICLE WAS TAKEN TO A DEALER. THE TECHNICIAN MADE THE CONTACT AWARE THAT THERE WAS A MANUFACTURER RECALL RELATED TO THE SUN ROOF FAILURE. THE SUN ROOF WAS REPAIRED. THE MANUFACTURER WAS NOTIFIED OF THE FAILURE. THE APPROXIMATE FAILURE MILEAGE WAS 21,000.
NHTSA ODI #10678572
31,800 miles · Nov 5, 2014
Electrical SystemEngineFuel/propulsion SystemFire
SMELLED SOMETHING AS TRAVELING DOWN THE ROAD AT 55 MPH. STOP THE VEHICLE ALONG SIDE THE ROAD. CHECKED THE TRAILER. CAME BACK TO THE TRUCK AND SMOKE WAS ROLLING OUT OF THE DASH VENTS, RIGHT REAR PASSENGER SIDE OF THE HOOD WAS BURNING THE PAINT, THEN FLAMES CAME OUT FROM UNER THE HOOD. *TR
NHTSA ODI #10652762
65,000 miles · Oct 20, 2014
Tires
TL* THE CONTACT OWNS A 2006 FORD F-250 EQUIPPED WITH CONTINENTAL CONTITRAC TR TIRES, SIZES LT275/70R/ 18, DOT NUMBER P515 46XB. THE CONTACT STATED THAT WHILE DRIVING APPROXIMATELY 55 MPH, THERE WAS VIBRATION AND THE LEFT REAR TIRE BLEW OUT. ALSO, THE TIRE EXHIBITED TREAD SEPARATION. THE TIRE HAD NOT BEEN REPLACED. THE MANUFACTU…
Read full complaint
TL* THE CONTACT OWNS A 2006 FORD F-250 EQUIPPED WITH CONTINENTAL CONTITRAC TR TIRES, SIZES LT275/70R/ 18, DOT NUMBER P515 46XB. THE CONTACT STATED THAT WHILE DRIVING APPROXIMATELY 55 MPH, THERE WAS VIBRATION AND THE LEFT REAR TIRE BLEW OUT. ALSO, THE TIRE EXHIBITED TREAD SEPARATION. THE TIRE HAD NOT BEEN REPLACED. THE MANUFACTURER WAS NOT MADE AWARE OF THE FAILURE. THE APPROXIMATE FAILURE MILEAGE WAS 65,000. ..UPDATED12/11/14 *BF UPDATED 12/19/14*CN THE CONSUMER STATED SOME OF THE VEHICLE'S FAILURES WERE REPAIRED PRIOR TO HAVING KNOWLEDGE OF THE RECALL. UPDATED 11/10/2015*JS
NHTSA ODI #10648898
190,050 miles · Sep 22, 2014
Electrical SystemExterior Lighting
DASHBOARD INSTRUMENT PANEL GAUGES AND LIGHTS STOP FUNCTIONING ALSO LOW FUEL LIGHT COMES ON WITH FULL TANK OF FUEL. *TR
NHTSA ODI #10638130
NHTSA investigations
2EA08007 · Violent Front End Oscillation
Opened Mar 14, 2008 · Closed Mar 31, 2009
Status: closed (inferred from source dates) · Suspension; Suspension:front
THIS INVESTIGATION WAS OPENED BASED ON 78 CONSUMER COMPLAINTS OF SEVERE SUSPENSION AND STEERING WHEEL OSCILLATIONS AFTER THE SUBJECT VEHICLES TRAVELED OVER AN UNEVEN SURFACE.ODI WAS CONCERNED ABOUT THESE COMPLAINTS BECAUSE MANY OF THEM ALLEGED LOSS OF CONTROL AND THE LOSS OF CONTROL OCCURREDAT SPEEDS ABOVE 50 MILES PER HOUR.AT THE TIME THESE COMPLAINTS WERE RECEIVED, ODI WAS ALSO AWARE OF THE TSB 07-10-10 AND EARLY WARNING FIELD REPORTS THAT DISCUSSED THE SHIMMY CONDITION ON THE SUBJECT VEHICLES.SINCE OPENING THIS INVESTIGATION, ODI HAS CONFIRMED, BASED ON CONSUMER COMPLAINTS, WARRANTY DATA, TESTING CONDUCTED BY VRTC, AND ODI INSPECTION OF COMPLAINT VEHICLES, THAT THE OWNERS OF THE SUBJECT VEHICLES ARE EXPERIENCING SHIMMY EVENTS ON THEIR VEHICLES.HOWEVER, ODI HAS ALSO CONFIRMED THAT OWNERS TYPICALLY DO NOT MAINTAIN THEIR TIRES AT THE PRESSURES RECOMMENDED BY FORD ON THE TIRE LABEL.FURTHER, ODI HAS FOUND THAT IN ORDER FOR SHIMMY TO OCCUR, TIRE PRESSURES MUST BE SUBSTANTIALLY BELOW (AT LEAST 20%) THOSE SPECIFIED ON THE VEHICLE TIRE LABEL.ODI CONSIDERS THESE UNSAFE TIRE CONDITIONS TO BE THE RESULT OF ONE OF THREE TYPICAL SITUATIONS.THE TIRES ARE BEING IMPROPERLY MAINTAINED, THE OWNERS ARE INTENTIONALLY SETTING THE TIRE PRESSURES LOW TO ENHANCE RIDE QUALITY, OR AFTERMARKET TIRES (NOT DESIGNED FOR USE ON THE VEHICLE) ARE INSTALLED TO CHANGE THE APPEARANCE OR FUNCTION OF THE VEHICLE.THE SUBJECT VEHICLES ARE INTENDED AND DESIGNED TO BE USED AS HEAVY DUTY VEHICLES AND AS SUCH REQUIRE THAT THE TIRES BE CAPABLE OF HANDLING THE LOADS FOR WHICH THE VEHICLE IS DESIGNED AND MARKETED.IN ORDER FOR THE TIRES TO BE CAPABLE OF HANDLING THESE LOADS, THE PROPER TIRE PRESSURE MUST BE MAINTAINED.IN LIGHT OF THE INFORMATION GATHERED IN THIS INVESTIGATION AND FORD'S AGREEMENT TO NOTIFY SUBJECT VEHICLE OWNERS (NOW AND EVERY TWO YEARS UNTIL THE VEHICLES REACH TEN YEARS FROM THEIR PRODUCTION DATE) ABOUT THE IMPORTANCE OF MAINTAINING PROPER TIRE PRESSURES ON THEIR VEHICLES, FURTHER USE OF AGENCY RESOURCES DOES NOT APPEAR TO BE WARRANTED.THE CLOSING OF THIS INVESTIGATION DOES NOT CONSTITUTE A FINDING BY NHTSA THAT NO SAFETY-RELATED DEFECT EXISTS.THE AGENCY RESERVES THE RIGHT TO TAKE FURTHER ACTION IF WARRANTED BY THE CIRCUMSTANCES.FOR ADDITIONAL INFORMATION, SEE THE ATTACHED CLOSING REPORT.
Additional source detail variants (2)
Suspension
THIS INVESTIGATION WAS OPENED BASED ON 78 CONSUMER COMPLAINTS OF SEVERE SUSPENSION AND STEERING WHEEL OSCILLATIONS AFTER THE SUBJECT VEHICLES TRAVELED OVER AN UNEVEN SURFACE.ODI WAS CONCERNED ABOUT THESE COMPLAINTS BECAUSE MANY OF THEM ALLEGED LOSS OF CONTROL AND THE LOSS OF CONTROL OCCURREDAT SPEEDS ABOVE 50 MILES PER HOUR.AT THE TIME THESE COMPLAINTS WERE RECEIVED, ODI WAS ALSO AWARE OF THE TSB 07-10-10 AND EARLY WARNING FIELD REPORTS THAT DISCUSSED THE SHIMMY CONDITION ON THE SUBJECT VEHICLES.SINCE OPENING THIS INVESTIGATION, ODI HAS CONFIRMED, BASED ON CONSUMER COMPLAINTS, WARRANTY DATA, TESTING CONDUCTED BY VRTC, AND ODI INSPECTION OF COMPLAINT VEHICLES, THAT THE OWNERS OF THE SUBJECT VEHICLES ARE EXPERIENCING SHIMMY EVENTS ON THEIR VEHICLES.HOWEVER, ODI HAS ALSO CONFIRMED THAT OWNERS TYPICALLY DO NOT MAINTAIN THEIR TIRES AT THE PRESSURES RECOMMENDED BY FORD ON THE TIRE LABEL.FURTHER, ODI HAS FOUND THAT IN ORDER FOR SHIMMY TO OCCUR, TIRE PRESSURES MUST BE SUBSTANTIALLY BELOW (AT LEAST 20%) THOSE SPECIFIED ON THE VEHICLE TIRE LABEL.ODI CONSIDERS THESE UNSAFE TIRE CONDITIONS TO BE THE RESULT OF ONE OF THREE TYPICAL SITUATIONS.THE TIRES ARE BEING IMPROPERLY MAINTAINED, THE OWNERS ARE INTENTIONALLY SETTING THE TIRE PRESSURES LOW TO ENHANCE RIDE QUALITY, OR AFTERMARKET TIRES (NOT DESIGNED FOR USE ON THE VEHICLE) ARE INSTALLED TO CHANGE THE APPEARANCE OR FUNCTION OF THE VEHICLE.THE SUBJECT VEHICLES ARE INTENDED AND DESIGNED TO BE USED AS HEAVY DUTY VEHICLES AND AS SUCH REQUIRE THAT THE TIRES BE CAPABLE OF HANDLING THE LOADS FOR WHICH THE VEHICLE IS DESIGNED AND MARKETED.IN ORDER FOR THE TIRES TO BE CAPABLE OF HANDLING THESE LOADS, THE PROPER TIRE PRESSURE MUST BE MAINTAINED.IN LIGHT OF THE INFORMATION GATHERED IN THIS INVESTIGATION AND FORD'S AGREEMENT TO NOTIFY SUBJECT VEHICLE OWNERS (NOW AND EVERY TWO YEARS UNTIL THE VEHICLES REACH TEN YEARS FROM THEIR PRODUCTION DATE) ABOUT THE IMPORTANCE OF MAINTAINING PROPER TIRE PRESSURES ON THEIR VEHICLES, FURTHER USE OF AGENCY RESOURCES DOES NOT APPEAR TO BE WARRANTED.THE CLOSING OF THIS INVESTIGATION DOES NOT CONSTITUTE A FINDING BY NHTSA THAT NO SAFETY-RELATED DEFECT EXISTS.THE AGENCY RESERVES THE RIGHT TO TAKE FURTHER ACTION IF WARRANTED BY THE CIRCUMSTANCES.FOR ADDITIONAL INFORMATION, SEE THE ATTACHED CLOSING REPORT.
Suspension:front
THIS INVESTIGATION WAS OPENED BASED ON 78 CONSUMER COMPLAINTS OF SEVERE SUSPENSION AND STEERING WHEEL OSCILLATIONS AFTER THE SUBJECT VEHICLES TRAVELED OVER AN UNEVEN SURFACE.ODI WAS CONCERNED ABOUT THESE COMPLAINTS BECAUSE MANY OF THEM ALLEGED LOSS OF CONTROL AND THE LOSS OF CONTROL OCCURREDAT SPEEDS ABOVE 50 MILES PER HOUR.AT THE TIME THESE COMPLAINTS WERE RECEIVED, ODI WAS ALSO AWARE OF THE TSB 07-10-10 AND EARLY WARNING FIELD REPORTS THAT DISCUSSED THE SHIMMY CONDITION ON THE SUBJECT VEHICLES.SINCE OPENING THIS INVESTIGATION, ODI HAS CONFIRMED, BASED ON CONSUMER COMPLAINTS, WARRANTY DATA, TESTING CONDUCTED BY VRTC, AND ODI INSPECTION OF COMPLAINT VEHICLES, THAT THE OWNERS OF THE SUBJECT VEHICLES ARE EXPERIENCING SHIMMY EVENTS ON THEIR VEHICLES.HOWEVER, ODI HAS ALSO CONFIRMED THAT OWNERS TYPICALLY DO NOT MAINTAIN THEIR TIRES AT THE PRESSURES RECOMMENDED BY FORD ON THE TIRE LABEL.FURTHER, ODI HAS FOUND THAT IN ORDER FOR SHIMMY TO OCCUR, TIRE PRESSURES MUST BE SUBSTANTIALLY BELOW (AT LEAST 20%) THOSE SPECIFIED ON THE VEHICLE TIRE LABEL.ODI CONSIDERS THESE UNSAFE TIRE CONDITIONS TO BE THE RESULT OF ONE OF THREE TYPICAL SITUATIONS.THE TIRES ARE BEING IMPROPERLY MAINTAINED, THE OWNERS ARE INTENTIONALLY SETTING THE TIRE PRESSURES LOW TO ENHANCE RIDE QUALITY, OR AFTERMARKET TIRES (NOT DESIGNED FOR USE ON THE VEHICLE) ARE INSTALLED TO CHANGE THE APPEARANCE OR FUNCTION OF THE VEHICLE.THE SUBJECT VEHICLES ARE INTENDED AND DESIGNED TO BE USED AS HEAVY DUTY VEHICLES AND AS SUCH REQUIRE THAT THE TIRES BE CAPABLE OF HANDLING THE LOADS FOR WHICH THE VEHICLE IS DESIGNED AND MARKETED.IN ORDER FOR THE TIRES TO BE CAPABLE OF HANDLING THESE LOADS, THE PROPER TIRE PRESSURE MUST BE MAINTAINED.IN LIGHT OF THE INFORMATION GATHERED IN THIS INVESTIGATION AND FORD'S AGREEMENT TO NOTIFY SUBJECT VEHICLE OWNERS (NOW AND EVERY TWO YEARS UNTIL THE VEHICLES REACH TEN YEARS FROM THEIR PRODUCTION DATE) ABOUT THE IMPORTANCE OF MAINTAINING PROPER TIRE PRESSURES ON THEIR VEHICLES, FURTHER USE OF AGENCY RESOURCES DOES NOT APPEAR TO BE WARRANTED.THE CLOSING OF THIS INVESTIGATION DOES NOT CONSTITUTE A FINDING BY NHTSA THAT NO SAFETY-RELATED DEFECT EXISTS.THE AGENCY RESERVES THE RIGHT TO TAKE FURTHER ACTION IF WARRANTED BY THE CIRCUMSTANCES.FOR ADDITIONAL INFORMATION, SEE THE ATTACHED CLOSING REPORT.
PE07057 · Violent Front End Oscillation
Opened Nov 15, 2007 · Closed Mar 14, 2008
Status: closed (inferred from source dates) · Suspension; Suspension:front
ODI HAS RECEIVED 78 CONSUMER COMPLAINTS OF SEVERE SUSPENSION AND STEERING WHEEL SHIMMY AND OSCILLATIONS COMMENCING AFTER THE SUBJECT VEHICLES TRAVELED OVER AN UNEVEN ROAD SURFACE. THE MAJORITY OF THESE INCIDENTS OCCURRED AT SPEEDS OF 50 MPH OR GREATER.THIRTEEN OF THE COMPLAINTS RECEIVED BY ODI ALLEGE LOSS OF STEERING CONTROL AND THAT THE VEHICLE CHANGED DRIVING LANES UNCONTROLLABLY.FOUR OF THE COMPLAINTS RECEIVED BY ODI ALLEGE THAT THE VEHICLE LEFT THE ROAD SURFACE AS A RESULT OF THE VIOLENT SUSPENSION AND STEERING WHEEL OSCILLATIONS.IN ONE CASE THE CONSUMER ALLEGES THAT AFTER THE VEHICLE LEFT THE ROAD SURFACE, IT CRASHED INTO A WOODED AREA.ADDITIONALFACTORS CONTRIBUTING TO THE OPENING OF THIS EA WERE EARLY WARNING FIELD REPORTS,SUBMITTED BY FORD, DESCRIBING SUSPENSION SHIMMY / OSCILLATIONSAND A FORD TSB (07-10-10) DESCRIBING THE SUSPENSION SHIMMY ISSUE AND HOW TO REPAIR THE PROBLEM.FORD HAS DESCRIBED SHIMMY AS SELF-EXCITED OSCILLATION OF THE STEERING WHEELS WITH ACCOMPANYING WHEEL TRAMP.THIS PE HAS BEEN UPGRADED TO AN ENGINEERING ANALYSIS (EA) TO DETERMINE IF THE SHIMMY CONDITION THAT OCCURS ON THE SUBJECT VEHICLES CREATES A CONDITION WHERE THE VEHICLE BECOMES DIFFICULT TO CONTROL OR STARTLES THE DRIVER, THUS PRESENTING A SAFETY RISK.
Additional source detail variants (2)
Suspension
ODI HAS RECEIVED 78 CONSUMER COMPLAINTS OF SEVERE SUSPENSION AND STEERING WHEEL SHIMMY AND OSCILLATIONS COMMENCING AFTER THE SUBJECT VEHICLES TRAVELED OVER AN UNEVEN ROAD SURFACE. THE MAJORITY OF THESE INCIDENTS OCCURRED AT SPEEDS OF 50 MPH OR GREATER.THIRTEEN OF THE COMPLAINTS RECEIVED BY ODI ALLEGE LOSS OF STEERING CONTROL AND THAT THE VEHICLE CHANGED DRIVING LANES UNCONTROLLABLY.FOUR OF THE COMPLAINTS RECEIVED BY ODI ALLEGE THAT THE VEHICLE LEFT THE ROAD SURFACE AS A RESULT OF THE VIOLENT SUSPENSION AND STEERING WHEEL OSCILLATIONS.IN ONE CASE THE CONSUMER ALLEGES THAT AFTER THE VEHICLE LEFT THE ROAD SURFACE, IT CRASHED INTO A WOODED AREA.ADDITIONALFACTORS CONTRIBUTING TO THE OPENING OF THIS EA WERE EARLY WARNING FIELD REPORTS,SUBMITTED BY FORD, DESCRIBING SUSPENSION SHIMMY / OSCILLATIONSAND A FORD TSB (07-10-10) DESCRIBING THE SUSPENSION SHIMMY ISSUE AND HOW TO REPAIR THE PROBLEM.FORD HAS DESCRIBED SHIMMY AS SELF-EXCITED OSCILLATION OF THE STEERING WHEELS WITH ACCOMPANYING WHEEL TRAMP.THIS PE HAS BEEN UPGRADED TO AN ENGINEERING ANALYSIS (EA) TO DETERMINE IF THE SHIMMY CONDITION THAT OCCURS ON THE SUBJECT VEHICLES CREATES A CONDITION WHERE THE VEHICLE BECOMES DIFFICULT TO CONTROL OR STARTLES THE DRIVER, THUS PRESENTING A SAFETY RISK.
Suspension:front
ODI HAS RECEIVED 78 CONSUMER COMPLAINTS OF SEVERE SUSPENSION AND STEERING WHEEL SHIMMY AND OSCILLATIONS COMMENCING AFTER THE SUBJECT VEHICLES TRAVELED OVER AN UNEVEN ROAD SURFACE. THE MAJORITY OF THESE INCIDENTS OCCURRED AT SPEEDS OF 50 MPH OR GREATER.THIRTEEN OF THE COMPLAINTS RECEIVED BY ODI ALLEGE LOSS OF STEERING CONTROL AND THAT THE VEHICLE CHANGED DRIVING LANES UNCONTROLLABLY.FOUR OF THE COMPLAINTS RECEIVED BY ODI ALLEGE THAT THE VEHICLE LEFT THE ROAD SURFACE AS A RESULT OF THE VIOLENT SUSPENSION AND STEERING WHEEL OSCILLATIONS.IN ONE CASE THE CONSUMER ALLEGES THAT AFTER THE VEHICLE LEFT THE ROAD SURFACE, IT CRASHED INTO A WOODED AREA.ADDITIONALFACTORS CONTRIBUTING TO THE OPENING OF THIS EA WERE EARLY WARNING FIELD REPORTS,SUBMITTED BY FORD, DESCRIBING SUSPENSION SHIMMY / OSCILLATIONSAND A FORD TSB (07-10-10) DESCRIBING THE SUSPENSION SHIMMY ISSUE AND HOW TO REPAIR THE PROBLEM.FORD HAS DESCRIBED SHIMMY AS SELF-EXCITED OSCILLATION OF THE STEERING WHEELS WITH ACCOMPANYING WHEEL TRAMP.THIS PE HAS BEEN UPGRADED TO AN ENGINEERING ANALYSIS (EA) TO DETERMINE IF THE SHIMMY CONDITION THAT OCCURS ON THE SUBJECT VEHICLES CREATES A CONDITION WHERE THE VEHICLE BECOMES DIFFICULT TO CONTROL OR STARTLES THE DRIVER, THUS PRESENTING A SAFETY RISK.
Illustration