TL* THE CONTACT OWNS A 2006 FORD F-250. THE CONTACT STATED THAT WHILE DRIVING AT VARIOUS SPEEDS AND GOING OVER A BUMP ON THE ROAD, THE FRONT OF THE VEHICLE WOBBLED. THE VEHICLE WAS TAKEN TO THE DEALER WHERE A STABILIZATION BAR WAS INSTALLED HOWEVER, THE FAILURE PERSISTED. THE MANUFACTURER WAS MADE AWARE OF THE FAILURE. THE FAILU…
Read full complaint
TL* THE CONTACT OWNS A 2006 FORD F-250. THE CONTACT STATED THAT WHILE DRIVING AT VARIOUS SPEEDS AND GOING OVER A BUMP ON THE ROAD, THE FRONT OF THE VEHICLE WOBBLED. THE VEHICLE WAS TAKEN TO THE DEALER WHERE A STABILIZATION BAR WAS INSTALLED HOWEVER, THE FAILURE PERSISTED. THE MANUFACTURER WAS MADE AWARE OF THE FAILURE. THE FAILURE MILEAGE WAS 15,000.
NHTSA ODI #10819843
43,000 miles · Mar 4, 2012
Power Train
F250SD DIESEL ABOUT 65 MI.S.OF ELI,NV. THE CK ENGINE SYMBOL CAME ON,SO I PULLED OVER AND LOOKED UNDER THE HOOD. THERE WAS OIL ALL OVER THE TOP OF THE ENGINE,[MAYBE 1 GAL.]. OIL WAS COMING OUT OF PLASTIC COOLANT OVERFLOW BOX. NO OIL SHOWED ON CHECK STICK. I GOT 2 GAL OF OIL FROM SOMEONE PASSING BY AND LIMPED INTO ELI NV. TH…
Read full complaint
F250SD DIESEL ABOUT 65 MI.S.OF ELI,NV. THE CK ENGINE SYMBOL CAME ON,SO I PULLED OVER AND LOOKED UNDER THE HOOD. THERE WAS OIL ALL OVER THE TOP OF THE ENGINE,[MAYBE 1 GAL.]. OIL WAS COMING OUT OF PLASTIC COOLANT OVERFLOW BOX. NO OIL SHOWED ON CHECK STICK. I GOT 2 GAL OF OIL FROM SOMEONE PASSING BY AND LIMPED INTO ELI NV. THE PICKUP SEEMED TO RUN OK AND NO OTHER WARNINGS SHOWED. [I WATCHED TEMPS CLOSELY]. TURNED OUT THE OIL COOLER INTERNAL [UNDER THE INTAKE MANIFOLD] SPRUNG A LEAK AND FORCED OIL INTO THE COOLANT SYSTEM. MY TRUCK WAS BARELY OVER THE 5 YR. WARRANTY SO NO HELP THERE FROM FORD. I ALWAYS WANTED A FORD DIESEL BUT NOT ANYMORE. COST $2200. FOR REPAIRS, AND LOST 3 WEEKS WITH THE TRUCK. HAD TO HIRE A U-HAUL TO GET HOME TO BOISE AND COME BACK FOR MY PICKUP. MY QUESTION IS WHY NO HELP FROM FORD? I STILL HAVE THE BAD COOLER. *TR
NHTSA ODI #10450223
81,000 miles · Sep 13, 2011
Power Train
POWER TRAIN HAD REAR MAIN SEAL FAILURE AROUND THIS DATE. POWER TRAIN HAS ANOTHER FAILURE AND LEAK IN SEPTEMBER OF THE SAME YEAR WHICH FORD WILL NO LONGER FIX. VEHICLE HAS LESS THAN 100,000 MILES AND ONLY APPROX 81,000 WHEN THE POWER TRAIN BEGAN TO HAVE PROBLEMS. THIS VEHICLE HAS SEVERAL OTHER ISSUES WHICH FORD WILL NOT ADDRESS. …
Read full complaint
POWER TRAIN HAD REAR MAIN SEAL FAILURE AROUND THIS DATE. POWER TRAIN HAS ANOTHER FAILURE AND LEAK IN SEPTEMBER OF THE SAME YEAR WHICH FORD WILL NO LONGER FIX. VEHICLE HAS LESS THAN 100,000 MILES AND ONLY APPROX 81,000 WHEN THE POWER TRAIN BEGAN TO HAVE PROBLEMS. THIS VEHICLE HAS SEVERAL OTHER ISSUES WHICH FORD WILL NOT ADDRESS. THE CUSTOMER ASSISTANCE CENTER AND THE COMPANY REP WILL ONLY OFFER HALF OFF ON REPAIRS WHICH THEY CLAIM THEY ARE NOT RESPONSIBLE FOR AND WILL NOT ACKNOWLEDGE THE PAST OR OTHER CURRENT PROBLEMS THE VEHICLE IS HAVING. *TR
NHTSA ODI #10425288
17,000 miles · Jun 24, 2010
Power Train
TL* THE CONTACT OWNS A 2006 FORD F-250. THE CONTACT STATED WHEN DRIVING OVER AN UNEVEN ROAD SURFACE AT SPEEDS LESS THAN 70 MPH, THE FRONT END WOULD WOBBLE ABNORMALLY. THE DEALER REPLACED THE TRANSMISSION SHIFT AND INSTALLED A DAMPER ON THE FRONT END OF THE VEHICLE. THE FAILURE RECURRED WITHIN FOUR MONTHS. THE VEHICLE WAS NOT DIA…
Read full complaint
TL* THE CONTACT OWNS A 2006 FORD F-250. THE CONTACT STATED WHEN DRIVING OVER AN UNEVEN ROAD SURFACE AT SPEEDS LESS THAN 70 MPH, THE FRONT END WOULD WOBBLE ABNORMALLY. THE DEALER REPLACED THE TRANSMISSION SHIFT AND INSTALLED A DAMPER ON THE FRONT END OF THE VEHICLE. THE FAILURE RECURRED WITHIN FOUR MONTHS. THE VEHICLE WAS NOT DIAGNOSED OR FURTHER REPAIRED. THE FAILURE MILEAGE WAS 17,000 AND THE CURRENT MILEAGE WAS 47,000.
NHTSA ODI #10339848
6,000 miles · Aug 5, 2007
Power Train
MY F250 SUPERDUTY TRUCK AT LESS THAN 6,000 MILES STARTED SLIPPING GEARS BETWEEN 1 AND 2 WHEN TRYING TO GET INTO ONCOMING TRAFFIC TRUCK WOULD STALL. RETURN TO DEALER THEY REBUILT TRANSMISSION DIDN'T FIX PROBLEM! RETURNED 4 MORE TIMES STILL SAME PROBLEM. HAVING TO FILE A LEMON LAWSUIT! *TR
NHTSA ODI #10198533
18,832 miles · Jul 8, 2007
Power Train
I WAS COMING BACK HOME FROM VACTION IN LAS VAGAS AROUND JUST PASS STATE LINE,WHEN MY FORD F-250 HD 2006 WENT INTO 4X4 LOW ALL BY IT SELF.MY SPEED WAS AROUND 75 MILES PER HOUR WHEN THE TRUCK WENT INTO 4X4 LOW BY IT SELF.IF THIER WHOULD HAVE BEEN A CARS BEHIND ME THIS WOULD BEEN A MAJOR CRASH.MY SPEED WENT FROM 75 MPH TO 20 MPH I…
Read full complaint
I WAS COMING BACK HOME FROM VACTION IN LAS VAGAS AROUND JUST PASS STATE LINE,WHEN MY FORD F-250 HD 2006 WENT INTO 4X4 LOW ALL BY IT SELF.MY SPEED WAS AROUND 75 MILES PER HOUR WHEN THE TRUCK WENT INTO 4X4 LOW BY IT SELF.IF THIER WHOULD HAVE BEEN A CARS BEHIND ME THIS WOULD BEEN A MAJOR CRASH.MY SPEED WENT FROM 75 MPH TO 20 MPH IN ABOUT 10 -20 SECONDS,I HEARD SOMETHING LOUD FROM MY TRANSMISSION AND OR ENGINE.MY TRUCK IS AT THE DEALERSHIP,I GOT A CALL ABOUT MY TRUCK FROM THE DEALERSHIP THE SAID THE TRANSFER CASE WAS BAD ON THE 4X4 CONTROL AND THEY WERE GOING TO LOOK AT THE TRANSMISSION.*AK
NHTSA ODI #10195560
1,000 miles · Apr 3, 2007
Power Train
TL*THE CONTACT OWNS A 2006 FORD F250 SUPERCREW. THE CONTACT STATED THAT THE 4X4 HIGH DID NOT ENGAGE, THE ENTIRE FRONT END VIBRATED VIOLENTLY, AND THE 4X4 LOW WAS DIFFICULT TO DISENGAGE. THE VEHICLE WAS TAKEN TO A DEALER FIVE TIMES, AND THE FAILURE HAD NOT BEEN DIAGNOSED. THE VEHICLE HAD NOT BEEN REPAIRED. THE CURRENT MILEA…
Read full complaint
TL*THE CONTACT OWNS A 2006 FORD F250 SUPERCREW. THE CONTACT STATED THAT THE 4X4 HIGH DID NOT ENGAGE, THE ENTIRE FRONT END VIBRATED VIOLENTLY, AND THE 4X4 LOW WAS DIFFICULT TO DISENGAGE. THE VEHICLE WAS TAKEN TO A DEALER FIVE TIMES, AND THE FAILURE HAD NOT BEEN DIAGNOSED. THE VEHICLE HAD NOT BEEN REPAIRED. THE CURRENT MILEAGE IS 4,200 AND FAILURE MILEAGE WAS 1,000.*AK
NHTSA ODI #10186834
28,000 miles · Mar 6, 2007
Engine And Engine CoolingPower Train
TL* THE CONTACT OWNS A 2006 FORD F 250. THE TRANSMISSION WAS SLIPPING. ALSO, THE ENGINE AND THE 3RD CYLINDER FAILED. THE FAILURE MILEAGE WAS 28,000. THE CONTACT STATED THAT DUE TO THE YEAR OF THIS VEHICLE THE ENGINE AND TRANSMISSION SHOULD BE OPERATING NORMALLY. THE VEHICLE WAS REPAIRED. THE CURRENT MILEAGE WAS 34,00…
Read full complaint
TL* THE CONTACT OWNS A 2006 FORD F 250. THE TRANSMISSION WAS SLIPPING. ALSO, THE ENGINE AND THE 3RD CYLINDER FAILED. THE FAILURE MILEAGE WAS 28,000. THE CONTACT STATED THAT DUE TO THE YEAR OF THIS VEHICLE THE ENGINE AND TRANSMISSION SHOULD BE OPERATING NORMALLY. THE VEHICLE WAS REPAIRED. THE CURRENT MILEAGE WAS 34,000. *AK
NHTSA ODI #10184300
2,700 miles · Apr 13, 2006
Power Train
DT*: THE CONTACT STATED WHILE DRIVING 45 MPH THERE IS A VIBRATION IN THE VEHICLE. THE STEERING WHEEL DOES NOT VIBRATE HOWEVER THE TRUCKS FRAME AND BODY DOES. THE VEHICLE WAS TAKEN TO THE DEALER FOR REPAIRS ON 4 OCCASIONS. ON THE FIRST OCCASION THE LEFT FRONT TIRE WAS REPLACED AND ALL TIRES WERE BALANCED. THE SECOND TIME THE…
Read full complaint
DT*: THE CONTACT STATED WHILE DRIVING 45 MPH THERE IS A VIBRATION IN THE VEHICLE. THE STEERING WHEEL DOES NOT VIBRATE HOWEVER THE TRUCKS FRAME AND BODY DOES. THE VEHICLE WAS TAKEN TO THE DEALER FOR REPAIRS ON 4 OCCASIONS. ON THE FIRST OCCASION THE LEFT FRONT TIRE WAS REPLACED AND ALL TIRES WERE BALANCED. THE SECOND TIME THE DRIVE SHAFT WAS REPLACED. ON THE THIRD VISIT ALL FOUR TIRES WERE REPLACED. ON THE FOURTH OCCASION ANOTHER DRIVE SHAFT AND PINION GEAR WAS REPLACED. THE VEHICLE STILL HAS THE SAME PROBLEM AFTER ALL OF THE REPAIR ATTEMPTS. THE CONTACT BELIEVES THE PROBLEM IS WITH THE AUTOMATIC TRANSMISSION TORQUE CONVERTER. THE MANUFACTURER HAS BEEN ALERTED.
KNAPHEIDE IS RECALLING 108 MY 2006-2008 PRO SERIES TRUCK BEDS EQUIPPED WITH AN ICC BUMPER WHICH INCLUDED A PROVISION FOR A BALL HITCH. THERE MAY BE AN INSUFFICIENT WELD ATTACHING THE HITCH CHANNEL TO THE SUPPORTING STRUCTURE.
Consequence & remedy
Consequence: THIS COULD RESULT IN BENDING OF THE HITCH CHANNEL OR THE HITCH COULD BE PULLED OFF THE VEHICLE, INCREASING THE RISK OF A CRASH.
Remedy: KNAPHEIDE WILL OFFER TWO REMEDIES TO ITS CUSTOMERS: (1) FOR THOSE CUSTOMERS WHO DO NOT USE THE HITCH, THE HITCH WILL BE REMOVED FROM THE TRUCK BED AND REPLACED WITH AN ICC BUMPER; OR (2) FOR THOSE CUSTOMERS WHO NEED A HITCH, A RECEIVER HITCH ASSEMBLY WILL BE ADDED TO THE EXISTING HITCH ASSEMBLY AND ALL SUSPECT WELD JOINTS WILL BE RE WELDED. THE RECALL BEGAN ON AUGUST 15, 2008. OWNERS MAY CONTACT KNAPHEIDE AT 1-877-473-5763.
Model-level recall history does not show whether a particular VIN is affected or has received a repair. Check a VIN with NHTSA ↗
NHTSA investigations
2
EA08007 · Violent Front End Oscillation
Opened Mar 14, 2008 · Closed Mar 31, 2009
Status: closed (inferred from source dates) · Suspension; Suspension:front
THIS INVESTIGATION WAS OPENED BASED ON 78 CONSUMER COMPLAINTS OF SEVERE SUSPENSION AND STEERING WHEEL OSCILLATIONS AFTER THE SUBJECT VEHICLES TRAVELED OVER AN UNEVEN SURFACE.ODI WAS CONCERNED ABOUT THESE COMPLAINTS BECAUSE MANY OF THEM ALLEGED LOSS OF CONTROL AND THE LOSS OF CONTROL OCCURREDAT SPEEDS ABOVE 50 MILES PER HOUR.AT THE TIME THESE COMPLAINTS WERE RECEIVED, ODI WAS ALSO AWARE OF THE TSB 07-10-10 AND EARLY WARNING FIELD REPORTS THAT DISCUSSED THE SHIMMY CONDITION ON THE SUBJECT VEHICLES.SINCE OPENING THIS INVESTIGATION, ODI HAS CONFIRMED, BASED ON CONSUMER COMPLAINTS, WARRANTY DATA, TESTING CONDUCTED BY VRTC, AND ODI INSPECTION OF COMPLAINT VEHICLES, THAT THE OWNERS OF THE SUBJECT VEHICLES ARE EXPERIENCING SHIMMY EVENTS ON THEIR VEHICLES.HOWEVER, ODI HAS ALSO CONFIRMED THAT OWNERS TYPICALLY DO NOT MAINTAIN THEIR TIRES AT THE PRESSURES RECOMMENDED BY FORD ON THE TIRE LABEL.FURTHER, ODI HAS FOUND THAT IN ORDER FOR SHIMMY TO OCCUR, TIRE PRESSURES MUST BE SUBSTANTIALLY BELOW (AT LEAST 20%) THOSE SPECIFIED ON THE VEHICLE TIRE LABEL.ODI CONSIDERS THESE UNSAFE TIRE CONDITIONS TO BE THE RESULT OF ONE OF THREE TYPICAL SITUATIONS.THE TIRES ARE BEING IMPROPERLY MAINTAINED, THE OWNERS ARE INTENTIONALLY SETTING THE TIRE PRESSURES LOW TO ENHANCE RIDE QUALITY, OR AFTERMARKET TIRES (NOT DESIGNED FOR USE ON THE VEHICLE) ARE INSTALLED TO CHANGE THE APPEARANCE OR FUNCTION OF THE VEHICLE.THE SUBJECT VEHICLES ARE INTENDED AND DESIGNED TO BE USED AS HEAVY DUTY VEHICLES AND AS SUCH REQUIRE THAT THE TIRES BE CAPABLE OF HANDLING THE LOADS FOR WHICH THE VEHICLE IS DESIGNED AND MARKETED.IN ORDER FOR THE TIRES TO BE CAPABLE OF HANDLING THESE LOADS, THE PROPER TIRE PRESSURE MUST BE MAINTAINED.IN LIGHT OF THE INFORMATION GATHERED IN THIS INVESTIGATION AND FORD'S AGREEMENT TO NOTIFY SUBJECT VEHICLE OWNERS (NOW AND EVERY TWO YEARS UNTIL THE VEHICLES REACH TEN YEARS FROM THEIR PRODUCTION DATE) ABOUT THE IMPORTANCE OF MAINTAINING PROPER TIRE PRESSURES ON THEIR VEHICLES, FURTHER USE OF AGENCY RESOURCES DOES NOT APPEAR TO BE WARRANTED.THE CLOSING OF THIS INVESTIGATION DOES NOT CONSTITUTE A FINDING BY NHTSA THAT NO SAFETY-RELATED DEFECT EXISTS.THE AGENCY RESERVES THE RIGHT TO TAKE FURTHER ACTION IF WARRANTED BY THE CIRCUMSTANCES.FOR ADDITIONAL INFORMATION, SEE THE ATTACHED CLOSING REPORT.
Additional source detail variants (2)
Suspension
THIS INVESTIGATION WAS OPENED BASED ON 78 CONSUMER COMPLAINTS OF SEVERE SUSPENSION AND STEERING WHEEL OSCILLATIONS AFTER THE SUBJECT VEHICLES TRAVELED OVER AN UNEVEN SURFACE.ODI WAS CONCERNED ABOUT THESE COMPLAINTS BECAUSE MANY OF THEM ALLEGED LOSS OF CONTROL AND THE LOSS OF CONTROL OCCURREDAT SPEEDS ABOVE 50 MILES PER HOUR.AT THE TIME THESE COMPLAINTS WERE RECEIVED, ODI WAS ALSO AWARE OF THE TSB 07-10-10 AND EARLY WARNING FIELD REPORTS THAT DISCUSSED THE SHIMMY CONDITION ON THE SUBJECT VEHICLES.SINCE OPENING THIS INVESTIGATION, ODI HAS CONFIRMED, BASED ON CONSUMER COMPLAINTS, WARRANTY DATA, TESTING CONDUCTED BY VRTC, AND ODI INSPECTION OF COMPLAINT VEHICLES, THAT THE OWNERS OF THE SUBJECT VEHICLES ARE EXPERIENCING SHIMMY EVENTS ON THEIR VEHICLES.HOWEVER, ODI HAS ALSO CONFIRMED THAT OWNERS TYPICALLY DO NOT MAINTAIN THEIR TIRES AT THE PRESSURES RECOMMENDED BY FORD ON THE TIRE LABEL.FURTHER, ODI HAS FOUND THAT IN ORDER FOR SHIMMY TO OCCUR, TIRE PRESSURES MUST BE SUBSTANTIALLY BELOW (AT LEAST 20%) THOSE SPECIFIED ON THE VEHICLE TIRE LABEL.ODI CONSIDERS THESE UNSAFE TIRE CONDITIONS TO BE THE RESULT OF ONE OF THREE TYPICAL SITUATIONS.THE TIRES ARE BEING IMPROPERLY MAINTAINED, THE OWNERS ARE INTENTIONALLY SETTING THE TIRE PRESSURES LOW TO ENHANCE RIDE QUALITY, OR AFTERMARKET TIRES (NOT DESIGNED FOR USE ON THE VEHICLE) ARE INSTALLED TO CHANGE THE APPEARANCE OR FUNCTION OF THE VEHICLE.THE SUBJECT VEHICLES ARE INTENDED AND DESIGNED TO BE USED AS HEAVY DUTY VEHICLES AND AS SUCH REQUIRE THAT THE TIRES BE CAPABLE OF HANDLING THE LOADS FOR WHICH THE VEHICLE IS DESIGNED AND MARKETED.IN ORDER FOR THE TIRES TO BE CAPABLE OF HANDLING THESE LOADS, THE PROPER TIRE PRESSURE MUST BE MAINTAINED.IN LIGHT OF THE INFORMATION GATHERED IN THIS INVESTIGATION AND FORD'S AGREEMENT TO NOTIFY SUBJECT VEHICLE OWNERS (NOW AND EVERY TWO YEARS UNTIL THE VEHICLES REACH TEN YEARS FROM THEIR PRODUCTION DATE) ABOUT THE IMPORTANCE OF MAINTAINING PROPER TIRE PRESSURES ON THEIR VEHICLES, FURTHER USE OF AGENCY RESOURCES DOES NOT APPEAR TO BE WARRANTED.THE CLOSING OF THIS INVESTIGATION DOES NOT CONSTITUTE A FINDING BY NHTSA THAT NO SAFETY-RELATED DEFECT EXISTS.THE AGENCY RESERVES THE RIGHT TO TAKE FURTHER ACTION IF WARRANTED BY THE CIRCUMSTANCES.FOR ADDITIONAL INFORMATION, SEE THE ATTACHED CLOSING REPORT.
Suspension:front
THIS INVESTIGATION WAS OPENED BASED ON 78 CONSUMER COMPLAINTS OF SEVERE SUSPENSION AND STEERING WHEEL OSCILLATIONS AFTER THE SUBJECT VEHICLES TRAVELED OVER AN UNEVEN SURFACE.ODI WAS CONCERNED ABOUT THESE COMPLAINTS BECAUSE MANY OF THEM ALLEGED LOSS OF CONTROL AND THE LOSS OF CONTROL OCCURREDAT SPEEDS ABOVE 50 MILES PER HOUR.AT THE TIME THESE COMPLAINTS WERE RECEIVED, ODI WAS ALSO AWARE OF THE TSB 07-10-10 AND EARLY WARNING FIELD REPORTS THAT DISCUSSED THE SHIMMY CONDITION ON THE SUBJECT VEHICLES.SINCE OPENING THIS INVESTIGATION, ODI HAS CONFIRMED, BASED ON CONSUMER COMPLAINTS, WARRANTY DATA, TESTING CONDUCTED BY VRTC, AND ODI INSPECTION OF COMPLAINT VEHICLES, THAT THE OWNERS OF THE SUBJECT VEHICLES ARE EXPERIENCING SHIMMY EVENTS ON THEIR VEHICLES.HOWEVER, ODI HAS ALSO CONFIRMED THAT OWNERS TYPICALLY DO NOT MAINTAIN THEIR TIRES AT THE PRESSURES RECOMMENDED BY FORD ON THE TIRE LABEL.FURTHER, ODI HAS FOUND THAT IN ORDER FOR SHIMMY TO OCCUR, TIRE PRESSURES MUST BE SUBSTANTIALLY BELOW (AT LEAST 20%) THOSE SPECIFIED ON THE VEHICLE TIRE LABEL.ODI CONSIDERS THESE UNSAFE TIRE CONDITIONS TO BE THE RESULT OF ONE OF THREE TYPICAL SITUATIONS.THE TIRES ARE BEING IMPROPERLY MAINTAINED, THE OWNERS ARE INTENTIONALLY SETTING THE TIRE PRESSURES LOW TO ENHANCE RIDE QUALITY, OR AFTERMARKET TIRES (NOT DESIGNED FOR USE ON THE VEHICLE) ARE INSTALLED TO CHANGE THE APPEARANCE OR FUNCTION OF THE VEHICLE.THE SUBJECT VEHICLES ARE INTENDED AND DESIGNED TO BE USED AS HEAVY DUTY VEHICLES AND AS SUCH REQUIRE THAT THE TIRES BE CAPABLE OF HANDLING THE LOADS FOR WHICH THE VEHICLE IS DESIGNED AND MARKETED.IN ORDER FOR THE TIRES TO BE CAPABLE OF HANDLING THESE LOADS, THE PROPER TIRE PRESSURE MUST BE MAINTAINED.IN LIGHT OF THE INFORMATION GATHERED IN THIS INVESTIGATION AND FORD'S AGREEMENT TO NOTIFY SUBJECT VEHICLE OWNERS (NOW AND EVERY TWO YEARS UNTIL THE VEHICLES REACH TEN YEARS FROM THEIR PRODUCTION DATE) ABOUT THE IMPORTANCE OF MAINTAINING PROPER TIRE PRESSURES ON THEIR VEHICLES, FURTHER USE OF AGENCY RESOURCES DOES NOT APPEAR TO BE WARRANTED.THE CLOSING OF THIS INVESTIGATION DOES NOT CONSTITUTE A FINDING BY NHTSA THAT NO SAFETY-RELATED DEFECT EXISTS.THE AGENCY RESERVES THE RIGHT TO TAKE FURTHER ACTION IF WARRANTED BY THE CIRCUMSTANCES.FOR ADDITIONAL INFORMATION, SEE THE ATTACHED CLOSING REPORT.
PE07057 · Violent Front End Oscillation
Opened Nov 15, 2007 · Closed Mar 14, 2008
Status: closed (inferred from source dates) · Suspension; Suspension:front
ODI HAS RECEIVED 78 CONSUMER COMPLAINTS OF SEVERE SUSPENSION AND STEERING WHEEL SHIMMY AND OSCILLATIONS COMMENCING AFTER THE SUBJECT VEHICLES TRAVELED OVER AN UNEVEN ROAD SURFACE. THE MAJORITY OF THESE INCIDENTS OCCURRED AT SPEEDS OF 50 MPH OR GREATER.THIRTEEN OF THE COMPLAINTS RECEIVED BY ODI ALLEGE LOSS OF STEERING CONTROL AND THAT THE VEHICLE CHANGED DRIVING LANES UNCONTROLLABLY.FOUR OF THE COMPLAINTS RECEIVED BY ODI ALLEGE THAT THE VEHICLE LEFT THE ROAD SURFACE AS A RESULT OF THE VIOLENT SUSPENSION AND STEERING WHEEL OSCILLATIONS.IN ONE CASE THE CONSUMER ALLEGES THAT AFTER THE VEHICLE LEFT THE ROAD SURFACE, IT CRASHED INTO A WOODED AREA.ADDITIONALFACTORS CONTRIBUTING TO THE OPENING OF THIS EA WERE EARLY WARNING FIELD REPORTS,SUBMITTED BY FORD, DESCRIBING SUSPENSION SHIMMY / OSCILLATIONSAND A FORD TSB (07-10-10) DESCRIBING THE SUSPENSION SHIMMY ISSUE AND HOW TO REPAIR THE PROBLEM.FORD HAS DESCRIBED SHIMMY AS SELF-EXCITED OSCILLATION OF THE STEERING WHEELS WITH ACCOMPANYING WHEEL TRAMP.THIS PE HAS BEEN UPGRADED TO AN ENGINEERING ANALYSIS (EA) TO DETERMINE IF THE SHIMMY CONDITION THAT OCCURS ON THE SUBJECT VEHICLES CREATES A CONDITION WHERE THE VEHICLE BECOMES DIFFICULT TO CONTROL OR STARTLES THE DRIVER, THUS PRESENTING A SAFETY RISK.
Additional source detail variants (2)
Suspension
ODI HAS RECEIVED 78 CONSUMER COMPLAINTS OF SEVERE SUSPENSION AND STEERING WHEEL SHIMMY AND OSCILLATIONS COMMENCING AFTER THE SUBJECT VEHICLES TRAVELED OVER AN UNEVEN ROAD SURFACE. THE MAJORITY OF THESE INCIDENTS OCCURRED AT SPEEDS OF 50 MPH OR GREATER.THIRTEEN OF THE COMPLAINTS RECEIVED BY ODI ALLEGE LOSS OF STEERING CONTROL AND THAT THE VEHICLE CHANGED DRIVING LANES UNCONTROLLABLY.FOUR OF THE COMPLAINTS RECEIVED BY ODI ALLEGE THAT THE VEHICLE LEFT THE ROAD SURFACE AS A RESULT OF THE VIOLENT SUSPENSION AND STEERING WHEEL OSCILLATIONS.IN ONE CASE THE CONSUMER ALLEGES THAT AFTER THE VEHICLE LEFT THE ROAD SURFACE, IT CRASHED INTO A WOODED AREA.ADDITIONALFACTORS CONTRIBUTING TO THE OPENING OF THIS EA WERE EARLY WARNING FIELD REPORTS,SUBMITTED BY FORD, DESCRIBING SUSPENSION SHIMMY / OSCILLATIONSAND A FORD TSB (07-10-10) DESCRIBING THE SUSPENSION SHIMMY ISSUE AND HOW TO REPAIR THE PROBLEM.FORD HAS DESCRIBED SHIMMY AS SELF-EXCITED OSCILLATION OF THE STEERING WHEELS WITH ACCOMPANYING WHEEL TRAMP.THIS PE HAS BEEN UPGRADED TO AN ENGINEERING ANALYSIS (EA) TO DETERMINE IF THE SHIMMY CONDITION THAT OCCURS ON THE SUBJECT VEHICLES CREATES A CONDITION WHERE THE VEHICLE BECOMES DIFFICULT TO CONTROL OR STARTLES THE DRIVER, THUS PRESENTING A SAFETY RISK.
Suspension:front
ODI HAS RECEIVED 78 CONSUMER COMPLAINTS OF SEVERE SUSPENSION AND STEERING WHEEL SHIMMY AND OSCILLATIONS COMMENCING AFTER THE SUBJECT VEHICLES TRAVELED OVER AN UNEVEN ROAD SURFACE. THE MAJORITY OF THESE INCIDENTS OCCURRED AT SPEEDS OF 50 MPH OR GREATER.THIRTEEN OF THE COMPLAINTS RECEIVED BY ODI ALLEGE LOSS OF STEERING CONTROL AND THAT THE VEHICLE CHANGED DRIVING LANES UNCONTROLLABLY.FOUR OF THE COMPLAINTS RECEIVED BY ODI ALLEGE THAT THE VEHICLE LEFT THE ROAD SURFACE AS A RESULT OF THE VIOLENT SUSPENSION AND STEERING WHEEL OSCILLATIONS.IN ONE CASE THE CONSUMER ALLEGES THAT AFTER THE VEHICLE LEFT THE ROAD SURFACE, IT CRASHED INTO A WOODED AREA.ADDITIONALFACTORS CONTRIBUTING TO THE OPENING OF THIS EA WERE EARLY WARNING FIELD REPORTS,SUBMITTED BY FORD, DESCRIBING SUSPENSION SHIMMY / OSCILLATIONSAND A FORD TSB (07-10-10) DESCRIBING THE SUSPENSION SHIMMY ISSUE AND HOW TO REPAIR THE PROBLEM.FORD HAS DESCRIBED SHIMMY AS SELF-EXCITED OSCILLATION OF THE STEERING WHEELS WITH ACCOMPANYING WHEEL TRAMP.THIS PE HAS BEEN UPGRADED TO AN ENGINEERING ANALYSIS (EA) TO DETERMINE IF THE SHIMMY CONDITION THAT OCCURS ON THE SUBJECT VEHICLES CREATES A CONDITION WHERE THE VEHICLE BECOMES DIFFICULT TO CONTROL OR STARTLES THE DRIVER, THUS PRESENTING A SAFETY RISK.
2006 Ford F-250 Problems, Complaints & Recalls | Skip That Year
Illustration