TL* THE CONTACT OWNS A 2006 FORD F-250. THE CONTACT STATED THAT WHILE DRIVING APPROXIMATELY 65 MPH, THE VEHICLE STALLED. THE VEHICLE WAS TOWED TO THE DEALER WHERE THE CONTACT WAS ADVISED THAT THE FUEL PUMP, CIRCUIT AND THE FUEL INJECTORS WOULD HAVE TO BE REPLACED. THE VEHICLE WAS REPAIRED BUT TO NO AVAIL. THE MANUFACTURER WAS M…
Read full complaint
TL* THE CONTACT OWNS A 2006 FORD F-250. THE CONTACT STATED THAT WHILE DRIVING APPROXIMATELY 65 MPH, THE VEHICLE STALLED. THE VEHICLE WAS TOWED TO THE DEALER WHERE THE CONTACT WAS ADVISED THAT THE FUEL PUMP, CIRCUIT AND THE FUEL INJECTORS WOULD HAVE TO BE REPLACED. THE VEHICLE WAS REPAIRED BUT TO NO AVAIL. THE MANUFACTURER WAS MADE AWARE OF THE FAILURE. THE VEHICLE WAS NOT REPAIRED. THE APPROXIMATE FAILURE MILEAGE WAS 106,000. *TR
NHTSA ODI #10514140
400 miles · Dec 3, 2012
Electrical SystemEngineSuspension
I HAVE OVER 118 PAGES OF REPAIRS DEALING FROM ELECTRICAL, SUSPENSION, ENGINE FAILURE, TURBO, FLUID LEAKAGE, OIL COOLER FAILURE. EJECTORS, GLOW PLUGS AND COUNTING. THEY CONTINUE TO REOCCUR TIME AFTER TIME AND DEALER WILL NOT COVER. I MET ALOT OF CONSUMERS THAT HAS THE SAME VEHICLE AND THEY ALL ARE HAVING THE SAME PROBLEM. I KNOW …
Read full complaint
I HAVE OVER 118 PAGES OF REPAIRS DEALING FROM ELECTRICAL, SUSPENSION, ENGINE FAILURE, TURBO, FLUID LEAKAGE, OIL COOLER FAILURE. EJECTORS, GLOW PLUGS AND COUNTING. THEY CONTINUE TO REOCCUR TIME AFTER TIME AND DEALER WILL NOT COVER. I MET ALOT OF CONSUMERS THAT HAS THE SAME VEHICLE AND THEY ALL ARE HAVING THE SAME PROBLEM. I KNOW THAT FORD HAS SUED THE DESIGNER OF THE 6.0 ENGINE AND WON BILLIONS BUT WILL NOT ATTEMPT TO ASSIST THE CONSUMER. THE RIGHT THING TO DO IS, IF YOU KNOW THAT IF THERE'S A PROBLEM WITH A PROBLEM WHY NOT ASSIST THE CONSUMER IN CORRECTING INSTEAD OF DOING A PATCH JOB. THEY WILL NOT ATTEMPT TO DO THE RIGHT THING UNLESS SOMEONE FORCE THEM TO DO SO. THANKS *TR
NHTSA ODI #10487269
112,000 miles · Jan 26, 2012
Electrical SystemFuel System, Gasoline
THE FICM (FUEL INJECTOR CONTROL MODULE) ON THE 6.0L POWERSTROKES ARE A KNOWN ITEM TO FAIL. THEY LOSE VOLTAGE AND MAKE INJECTORS NOT WORK, WHICH SHUTS OFF THE VEHICLE. THIS CAN HAPPEN AT ANY TIME WHILE AT AN IDLE OR GOING DOWN THE HIGHWAY. ONCE THIS HAPPENS, THE TRUCK SHUTS OFF AND YOU LOSE POWER STEERING AND BRAKING ABILITY. MIN…
Read full complaint
THE FICM (FUEL INJECTOR CONTROL MODULE) ON THE 6.0L POWERSTROKES ARE A KNOWN ITEM TO FAIL. THEY LOSE VOLTAGE AND MAKE INJECTORS NOT WORK, WHICH SHUTS OFF THE VEHICLE. THIS CAN HAPPEN AT ANY TIME WHILE AT AN IDLE OR GOING DOWN THE HIGHWAY. ONCE THIS HAPPENS, THE TRUCK SHUTS OFF AND YOU LOSE POWER STEERING AND BRAKING ABILITY. MINE SHUT OFF WHILE GOING DOWN THE ROAD SEVERAL TIMES NOW, BUT FORD DOES NOT WANT TO WARRANTY IT. MY SMALL TOWN FORD DEALERSHIP REPLACES SEVERAL OF THESE PARTS A WEEK. DOES SOMEONE HAVE TO DIE FOR THEM TO ISSUE A RECALL ON THESE? *TR
NHTSA ODI #10445453
75,550 miles · Jun 24, 2010
Electrical SystemFire
TL* THE CONTACT OWNS A 2006 FORD F250. THE VEHICLE WAS SITTING IDLE WHEN THE CONTACT WENT TO START THE ENGINE. THE GEAR SHIFTER OPENING ERUPTED INTO FLAMES AND SMOKE. THE CONTACT REMOVED THE KEY FROM THE IGNITION AND WAS ABLE TO EXTINGUISH THE SMALL FIRE. A TOW TRUCK COMPANY ARRIVED TO TOW THE VEHICLE AND THE FAILURE RECURRED. T…
Read full complaint
TL* THE CONTACT OWNS A 2006 FORD F250. THE VEHICLE WAS SITTING IDLE WHEN THE CONTACT WENT TO START THE ENGINE. THE GEAR SHIFTER OPENING ERUPTED INTO FLAMES AND SMOKE. THE CONTACT REMOVED THE KEY FROM THE IGNITION AND WAS ABLE TO EXTINGUISH THE SMALL FIRE. A TOW TRUCK COMPANY ARRIVED TO TOW THE VEHICLE AND THE FAILURE RECURRED. THE FIRE WAS EXTINGUISHED A SECOND TIME AND THE VEHICLE WAS TOWED TO THE DEALER. THE DEALER ADVISED THE FAILURE WAS AN ELECTRICAL FAILURE. THE VEHICLE WAS LEFT WITH THE DEALER WHERE THE CONTACT WAS AWAITING UNKNOWN REPAIRS. THE FAILURE AND CURRENT MILEAGES WERE 75,550.
NHTSA ODI #10339837
93,000 miles · Jan 27, 2009
Electrical System
SPEEDOMETER AND TACHOMETER WOULD NOT INDICATE THE CORRECT SPEED OR RPM. DRIVING ON THE HIGHWAY THE SPEEDOMETER WILL DROP TO LOWER SPEED OR WILL GET STUCK ON CERTAIN SPEED. THE TACHOMETER WILL ALSO DROP TO ZERO WHILE YOU STILL HAVE POWER. *TR
NHTSA ODI #10256478
25,000 miles · Dec 1, 2008
Electrical SystemUnknown Or Other
TL*THE CONTACT OWNS A 2006 FORD F-250. WHILE DRIVING 65 MPH, THE VEHICLE SHOOK VIOLENTLY AND FELT AS IF IT WOULD FLIP OVER. IT TOOK A WHILE FOR THE CONTACT TO REGAIN CONTROL OF THE VEHICLE. THE DEALER TEST DROVE THE VEHICLE, BUT WAS UNABLE TO DUPLICATE THE FAILURE. A REPORT WAS FILED WITH THE MANUFACTURER AND THEY STATED THA…
Read full complaint
TL*THE CONTACT OWNS A 2006 FORD F-250. WHILE DRIVING 65 MPH, THE VEHICLE SHOOK VIOLENTLY AND FELT AS IF IT WOULD FLIP OVER. IT TOOK A WHILE FOR THE CONTACT TO REGAIN CONTROL OF THE VEHICLE. THE DEALER TEST DROVE THE VEHICLE, BUT WAS UNABLE TO DUPLICATE THE FAILURE. A REPORT WAS FILED WITH THE MANUFACTURER AND THEY STATED THAT THE DEALER WOULD CALL THE CONTACT WITHIN FOUR DAYS. THE FAILURE MILEAGE WAS 25,000 AND CURRENT MILEAGE WAS 30,000. UPDATED 12/30/08 *BF THE HORN WOULD RANDOMLY BLOW ON ITS OWN. UPDATED 01/05/09. *JB
NHTSA ODI #10250343
19,000 miles · Jul 21, 2006
Electrical System
DT*: THE CONTACT STATED WHILE DRIVING AT VARIOUS SPEEDS THE GAUGES MALFUNCTIONED AND THE VEHICLE STALLED. THE VEHICLE WAS TOWED TO THE DEALER. IN AN ATTEMPT TO CORRECT THE PROBLEM THE BATTERY WAS REPLACED WITH NO SUCCESS, THE INSTRUMENT PANEL CLUSTER WAS REPLACED WHICH CORRECTED THE PROBLEM.
NHTSA ODI #10163052
2,000 miles · Feb 6, 2006
Electrical SystemEngine And Engine CoolingCrash
F 250 2006 HD 4X4 LESS THAN 2000 MILES - DRIVING VEHICLE, WHILE TURNING AND GOING DOWN A HILL, STALLED OUT COMPLETELY:DASH BOARD LIGHTS ALL CAME ON. NO BRAKES OR STEERING. WENT OFF THE ROAD, INTO FRONT YARD OF HOME WHICH WAS FOR SALE, HIT FOR SALE SIGN, NICKED A TREE IN FRONT YARD AND INTO HANDICAP VAN IN DRIVEWAY, PUSHED VAN …
Read full complaint
F 250 2006 HD 4X4 LESS THAN 2000 MILES - DRIVING VEHICLE, WHILE TURNING AND GOING DOWN A HILL, STALLED OUT COMPLETELY:DASH BOARD LIGHTS ALL CAME ON. NO BRAKES OR STEERING. WENT OFF THE ROAD, INTO FRONT YARD OF HOME WHICH WAS FOR SALE, HIT FOR SALE SIGN, NICKED A TREE IN FRONT YARD AND INTO HANDICAP VAN IN DRIVEWAY, PUSHED VAN INTO NEIGHBORS YARD. HEAVY FRONT END DAMAGE SUSTAINED AND SIGHTED BY POLICE FOR "FAILURE TO CONTROL VEHICLE"!!! PURCHASING DEALER COULD FIND NO ISSUES. FIRST TIME THIS OCCURRED WAS 3 WEEKS AFTER NOV. 2005 PURCHASE. VEHICLE HAS BEEN REPAIRED, BUT DID IT AGAIN ON 2-3-2006. DEALER HAS BEEN NOTIFIED OF THIS AGAIN. STILL NO SOLUTION. OVER $10,000.00 DAMAGE TO BRAND NEW VEHICLE. FREE LOANER VEHICLE PROMISED WHEN PURCHASED "DOESNT APPLY TO BODY SHOP" OUT OF WORK WITH NO VEHICLE FOR 2.5 WEEKS. *JB
KNAPHEIDE IS RECALLING 108 MY 2006-2008 PRO SERIES TRUCK BEDS EQUIPPED WITH AN ICC BUMPER WHICH INCLUDED A PROVISION FOR A BALL HITCH. THERE MAY BE AN INSUFFICIENT WELD ATTACHING THE HITCH CHANNEL TO THE SUPPORTING STRUCTURE.
Consequence & remedy
Consequence: THIS COULD RESULT IN BENDING OF THE HITCH CHANNEL OR THE HITCH COULD BE PULLED OFF THE VEHICLE, INCREASING THE RISK OF A CRASH.
Remedy: KNAPHEIDE WILL OFFER TWO REMEDIES TO ITS CUSTOMERS: (1) FOR THOSE CUSTOMERS WHO DO NOT USE THE HITCH, THE HITCH WILL BE REMOVED FROM THE TRUCK BED AND REPLACED WITH AN ICC BUMPER; OR (2) FOR THOSE CUSTOMERS WHO NEED A HITCH, A RECEIVER HITCH ASSEMBLY WILL BE ADDED TO THE EXISTING HITCH ASSEMBLY AND ALL SUSPECT WELD JOINTS WILL BE RE WELDED. THE RECALL BEGAN ON AUGUST 15, 2008. OWNERS MAY CONTACT KNAPHEIDE AT 1-877-473-5763.
Model-level recall history does not show whether a particular VIN is affected or has received a repair. Check a VIN with NHTSA ↗
NHTSA investigations
2
EA08007 · Violent Front End Oscillation
Opened Mar 14, 2008 · Closed Mar 31, 2009
Status: closed (inferred from source dates) · Suspension; Suspension:front
THIS INVESTIGATION WAS OPENED BASED ON 78 CONSUMER COMPLAINTS OF SEVERE SUSPENSION AND STEERING WHEEL OSCILLATIONS AFTER THE SUBJECT VEHICLES TRAVELED OVER AN UNEVEN SURFACE.ODI WAS CONCERNED ABOUT THESE COMPLAINTS BECAUSE MANY OF THEM ALLEGED LOSS OF CONTROL AND THE LOSS OF CONTROL OCCURREDAT SPEEDS ABOVE 50 MILES PER HOUR.AT THE TIME THESE COMPLAINTS WERE RECEIVED, ODI WAS ALSO AWARE OF THE TSB 07-10-10 AND EARLY WARNING FIELD REPORTS THAT DISCUSSED THE SHIMMY CONDITION ON THE SUBJECT VEHICLES.SINCE OPENING THIS INVESTIGATION, ODI HAS CONFIRMED, BASED ON CONSUMER COMPLAINTS, WARRANTY DATA, TESTING CONDUCTED BY VRTC, AND ODI INSPECTION OF COMPLAINT VEHICLES, THAT THE OWNERS OF THE SUBJECT VEHICLES ARE EXPERIENCING SHIMMY EVENTS ON THEIR VEHICLES.HOWEVER, ODI HAS ALSO CONFIRMED THAT OWNERS TYPICALLY DO NOT MAINTAIN THEIR TIRES AT THE PRESSURES RECOMMENDED BY FORD ON THE TIRE LABEL.FURTHER, ODI HAS FOUND THAT IN ORDER FOR SHIMMY TO OCCUR, TIRE PRESSURES MUST BE SUBSTANTIALLY BELOW (AT LEAST 20%) THOSE SPECIFIED ON THE VEHICLE TIRE LABEL.ODI CONSIDERS THESE UNSAFE TIRE CONDITIONS TO BE THE RESULT OF ONE OF THREE TYPICAL SITUATIONS.THE TIRES ARE BEING IMPROPERLY MAINTAINED, THE OWNERS ARE INTENTIONALLY SETTING THE TIRE PRESSURES LOW TO ENHANCE RIDE QUALITY, OR AFTERMARKET TIRES (NOT DESIGNED FOR USE ON THE VEHICLE) ARE INSTALLED TO CHANGE THE APPEARANCE OR FUNCTION OF THE VEHICLE.THE SUBJECT VEHICLES ARE INTENDED AND DESIGNED TO BE USED AS HEAVY DUTY VEHICLES AND AS SUCH REQUIRE THAT THE TIRES BE CAPABLE OF HANDLING THE LOADS FOR WHICH THE VEHICLE IS DESIGNED AND MARKETED.IN ORDER FOR THE TIRES TO BE CAPABLE OF HANDLING THESE LOADS, THE PROPER TIRE PRESSURE MUST BE MAINTAINED.IN LIGHT OF THE INFORMATION GATHERED IN THIS INVESTIGATION AND FORD'S AGREEMENT TO NOTIFY SUBJECT VEHICLE OWNERS (NOW AND EVERY TWO YEARS UNTIL THE VEHICLES REACH TEN YEARS FROM THEIR PRODUCTION DATE) ABOUT THE IMPORTANCE OF MAINTAINING PROPER TIRE PRESSURES ON THEIR VEHICLES, FURTHER USE OF AGENCY RESOURCES DOES NOT APPEAR TO BE WARRANTED.THE CLOSING OF THIS INVESTIGATION DOES NOT CONSTITUTE A FINDING BY NHTSA THAT NO SAFETY-RELATED DEFECT EXISTS.THE AGENCY RESERVES THE RIGHT TO TAKE FURTHER ACTION IF WARRANTED BY THE CIRCUMSTANCES.FOR ADDITIONAL INFORMATION, SEE THE ATTACHED CLOSING REPORT.
Additional source detail variants (2)
Suspension
THIS INVESTIGATION WAS OPENED BASED ON 78 CONSUMER COMPLAINTS OF SEVERE SUSPENSION AND STEERING WHEEL OSCILLATIONS AFTER THE SUBJECT VEHICLES TRAVELED OVER AN UNEVEN SURFACE.ODI WAS CONCERNED ABOUT THESE COMPLAINTS BECAUSE MANY OF THEM ALLEGED LOSS OF CONTROL AND THE LOSS OF CONTROL OCCURREDAT SPEEDS ABOVE 50 MILES PER HOUR.AT THE TIME THESE COMPLAINTS WERE RECEIVED, ODI WAS ALSO AWARE OF THE TSB 07-10-10 AND EARLY WARNING FIELD REPORTS THAT DISCUSSED THE SHIMMY CONDITION ON THE SUBJECT VEHICLES.SINCE OPENING THIS INVESTIGATION, ODI HAS CONFIRMED, BASED ON CONSUMER COMPLAINTS, WARRANTY DATA, TESTING CONDUCTED BY VRTC, AND ODI INSPECTION OF COMPLAINT VEHICLES, THAT THE OWNERS OF THE SUBJECT VEHICLES ARE EXPERIENCING SHIMMY EVENTS ON THEIR VEHICLES.HOWEVER, ODI HAS ALSO CONFIRMED THAT OWNERS TYPICALLY DO NOT MAINTAIN THEIR TIRES AT THE PRESSURES RECOMMENDED BY FORD ON THE TIRE LABEL.FURTHER, ODI HAS FOUND THAT IN ORDER FOR SHIMMY TO OCCUR, TIRE PRESSURES MUST BE SUBSTANTIALLY BELOW (AT LEAST 20%) THOSE SPECIFIED ON THE VEHICLE TIRE LABEL.ODI CONSIDERS THESE UNSAFE TIRE CONDITIONS TO BE THE RESULT OF ONE OF THREE TYPICAL SITUATIONS.THE TIRES ARE BEING IMPROPERLY MAINTAINED, THE OWNERS ARE INTENTIONALLY SETTING THE TIRE PRESSURES LOW TO ENHANCE RIDE QUALITY, OR AFTERMARKET TIRES (NOT DESIGNED FOR USE ON THE VEHICLE) ARE INSTALLED TO CHANGE THE APPEARANCE OR FUNCTION OF THE VEHICLE.THE SUBJECT VEHICLES ARE INTENDED AND DESIGNED TO BE USED AS HEAVY DUTY VEHICLES AND AS SUCH REQUIRE THAT THE TIRES BE CAPABLE OF HANDLING THE LOADS FOR WHICH THE VEHICLE IS DESIGNED AND MARKETED.IN ORDER FOR THE TIRES TO BE CAPABLE OF HANDLING THESE LOADS, THE PROPER TIRE PRESSURE MUST BE MAINTAINED.IN LIGHT OF THE INFORMATION GATHERED IN THIS INVESTIGATION AND FORD'S AGREEMENT TO NOTIFY SUBJECT VEHICLE OWNERS (NOW AND EVERY TWO YEARS UNTIL THE VEHICLES REACH TEN YEARS FROM THEIR PRODUCTION DATE) ABOUT THE IMPORTANCE OF MAINTAINING PROPER TIRE PRESSURES ON THEIR VEHICLES, FURTHER USE OF AGENCY RESOURCES DOES NOT APPEAR TO BE WARRANTED.THE CLOSING OF THIS INVESTIGATION DOES NOT CONSTITUTE A FINDING BY NHTSA THAT NO SAFETY-RELATED DEFECT EXISTS.THE AGENCY RESERVES THE RIGHT TO TAKE FURTHER ACTION IF WARRANTED BY THE CIRCUMSTANCES.FOR ADDITIONAL INFORMATION, SEE THE ATTACHED CLOSING REPORT.
Suspension:front
THIS INVESTIGATION WAS OPENED BASED ON 78 CONSUMER COMPLAINTS OF SEVERE SUSPENSION AND STEERING WHEEL OSCILLATIONS AFTER THE SUBJECT VEHICLES TRAVELED OVER AN UNEVEN SURFACE.ODI WAS CONCERNED ABOUT THESE COMPLAINTS BECAUSE MANY OF THEM ALLEGED LOSS OF CONTROL AND THE LOSS OF CONTROL OCCURREDAT SPEEDS ABOVE 50 MILES PER HOUR.AT THE TIME THESE COMPLAINTS WERE RECEIVED, ODI WAS ALSO AWARE OF THE TSB 07-10-10 AND EARLY WARNING FIELD REPORTS THAT DISCUSSED THE SHIMMY CONDITION ON THE SUBJECT VEHICLES.SINCE OPENING THIS INVESTIGATION, ODI HAS CONFIRMED, BASED ON CONSUMER COMPLAINTS, WARRANTY DATA, TESTING CONDUCTED BY VRTC, AND ODI INSPECTION OF COMPLAINT VEHICLES, THAT THE OWNERS OF THE SUBJECT VEHICLES ARE EXPERIENCING SHIMMY EVENTS ON THEIR VEHICLES.HOWEVER, ODI HAS ALSO CONFIRMED THAT OWNERS TYPICALLY DO NOT MAINTAIN THEIR TIRES AT THE PRESSURES RECOMMENDED BY FORD ON THE TIRE LABEL.FURTHER, ODI HAS FOUND THAT IN ORDER FOR SHIMMY TO OCCUR, TIRE PRESSURES MUST BE SUBSTANTIALLY BELOW (AT LEAST 20%) THOSE SPECIFIED ON THE VEHICLE TIRE LABEL.ODI CONSIDERS THESE UNSAFE TIRE CONDITIONS TO BE THE RESULT OF ONE OF THREE TYPICAL SITUATIONS.THE TIRES ARE BEING IMPROPERLY MAINTAINED, THE OWNERS ARE INTENTIONALLY SETTING THE TIRE PRESSURES LOW TO ENHANCE RIDE QUALITY, OR AFTERMARKET TIRES (NOT DESIGNED FOR USE ON THE VEHICLE) ARE INSTALLED TO CHANGE THE APPEARANCE OR FUNCTION OF THE VEHICLE.THE SUBJECT VEHICLES ARE INTENDED AND DESIGNED TO BE USED AS HEAVY DUTY VEHICLES AND AS SUCH REQUIRE THAT THE TIRES BE CAPABLE OF HANDLING THE LOADS FOR WHICH THE VEHICLE IS DESIGNED AND MARKETED.IN ORDER FOR THE TIRES TO BE CAPABLE OF HANDLING THESE LOADS, THE PROPER TIRE PRESSURE MUST BE MAINTAINED.IN LIGHT OF THE INFORMATION GATHERED IN THIS INVESTIGATION AND FORD'S AGREEMENT TO NOTIFY SUBJECT VEHICLE OWNERS (NOW AND EVERY TWO YEARS UNTIL THE VEHICLES REACH TEN YEARS FROM THEIR PRODUCTION DATE) ABOUT THE IMPORTANCE OF MAINTAINING PROPER TIRE PRESSURES ON THEIR VEHICLES, FURTHER USE OF AGENCY RESOURCES DOES NOT APPEAR TO BE WARRANTED.THE CLOSING OF THIS INVESTIGATION DOES NOT CONSTITUTE A FINDING BY NHTSA THAT NO SAFETY-RELATED DEFECT EXISTS.THE AGENCY RESERVES THE RIGHT TO TAKE FURTHER ACTION IF WARRANTED BY THE CIRCUMSTANCES.FOR ADDITIONAL INFORMATION, SEE THE ATTACHED CLOSING REPORT.
PE07057 · Violent Front End Oscillation
Opened Nov 15, 2007 · Closed Mar 14, 2008
Status: closed (inferred from source dates) · Suspension; Suspension:front
ODI HAS RECEIVED 78 CONSUMER COMPLAINTS OF SEVERE SUSPENSION AND STEERING WHEEL SHIMMY AND OSCILLATIONS COMMENCING AFTER THE SUBJECT VEHICLES TRAVELED OVER AN UNEVEN ROAD SURFACE. THE MAJORITY OF THESE INCIDENTS OCCURRED AT SPEEDS OF 50 MPH OR GREATER.THIRTEEN OF THE COMPLAINTS RECEIVED BY ODI ALLEGE LOSS OF STEERING CONTROL AND THAT THE VEHICLE CHANGED DRIVING LANES UNCONTROLLABLY.FOUR OF THE COMPLAINTS RECEIVED BY ODI ALLEGE THAT THE VEHICLE LEFT THE ROAD SURFACE AS A RESULT OF THE VIOLENT SUSPENSION AND STEERING WHEEL OSCILLATIONS.IN ONE CASE THE CONSUMER ALLEGES THAT AFTER THE VEHICLE LEFT THE ROAD SURFACE, IT CRASHED INTO A WOODED AREA.ADDITIONALFACTORS CONTRIBUTING TO THE OPENING OF THIS EA WERE EARLY WARNING FIELD REPORTS,SUBMITTED BY FORD, DESCRIBING SUSPENSION SHIMMY / OSCILLATIONSAND A FORD TSB (07-10-10) DESCRIBING THE SUSPENSION SHIMMY ISSUE AND HOW TO REPAIR THE PROBLEM.FORD HAS DESCRIBED SHIMMY AS SELF-EXCITED OSCILLATION OF THE STEERING WHEELS WITH ACCOMPANYING WHEEL TRAMP.THIS PE HAS BEEN UPGRADED TO AN ENGINEERING ANALYSIS (EA) TO DETERMINE IF THE SHIMMY CONDITION THAT OCCURS ON THE SUBJECT VEHICLES CREATES A CONDITION WHERE THE VEHICLE BECOMES DIFFICULT TO CONTROL OR STARTLES THE DRIVER, THUS PRESENTING A SAFETY RISK.
Additional source detail variants (2)
Suspension
ODI HAS RECEIVED 78 CONSUMER COMPLAINTS OF SEVERE SUSPENSION AND STEERING WHEEL SHIMMY AND OSCILLATIONS COMMENCING AFTER THE SUBJECT VEHICLES TRAVELED OVER AN UNEVEN ROAD SURFACE. THE MAJORITY OF THESE INCIDENTS OCCURRED AT SPEEDS OF 50 MPH OR GREATER.THIRTEEN OF THE COMPLAINTS RECEIVED BY ODI ALLEGE LOSS OF STEERING CONTROL AND THAT THE VEHICLE CHANGED DRIVING LANES UNCONTROLLABLY.FOUR OF THE COMPLAINTS RECEIVED BY ODI ALLEGE THAT THE VEHICLE LEFT THE ROAD SURFACE AS A RESULT OF THE VIOLENT SUSPENSION AND STEERING WHEEL OSCILLATIONS.IN ONE CASE THE CONSUMER ALLEGES THAT AFTER THE VEHICLE LEFT THE ROAD SURFACE, IT CRASHED INTO A WOODED AREA.ADDITIONALFACTORS CONTRIBUTING TO THE OPENING OF THIS EA WERE EARLY WARNING FIELD REPORTS,SUBMITTED BY FORD, DESCRIBING SUSPENSION SHIMMY / OSCILLATIONSAND A FORD TSB (07-10-10) DESCRIBING THE SUSPENSION SHIMMY ISSUE AND HOW TO REPAIR THE PROBLEM.FORD HAS DESCRIBED SHIMMY AS SELF-EXCITED OSCILLATION OF THE STEERING WHEELS WITH ACCOMPANYING WHEEL TRAMP.THIS PE HAS BEEN UPGRADED TO AN ENGINEERING ANALYSIS (EA) TO DETERMINE IF THE SHIMMY CONDITION THAT OCCURS ON THE SUBJECT VEHICLES CREATES A CONDITION WHERE THE VEHICLE BECOMES DIFFICULT TO CONTROL OR STARTLES THE DRIVER, THUS PRESENTING A SAFETY RISK.
Suspension:front
ODI HAS RECEIVED 78 CONSUMER COMPLAINTS OF SEVERE SUSPENSION AND STEERING WHEEL SHIMMY AND OSCILLATIONS COMMENCING AFTER THE SUBJECT VEHICLES TRAVELED OVER AN UNEVEN ROAD SURFACE. THE MAJORITY OF THESE INCIDENTS OCCURRED AT SPEEDS OF 50 MPH OR GREATER.THIRTEEN OF THE COMPLAINTS RECEIVED BY ODI ALLEGE LOSS OF STEERING CONTROL AND THAT THE VEHICLE CHANGED DRIVING LANES UNCONTROLLABLY.FOUR OF THE COMPLAINTS RECEIVED BY ODI ALLEGE THAT THE VEHICLE LEFT THE ROAD SURFACE AS A RESULT OF THE VIOLENT SUSPENSION AND STEERING WHEEL OSCILLATIONS.IN ONE CASE THE CONSUMER ALLEGES THAT AFTER THE VEHICLE LEFT THE ROAD SURFACE, IT CRASHED INTO A WOODED AREA.ADDITIONALFACTORS CONTRIBUTING TO THE OPENING OF THIS EA WERE EARLY WARNING FIELD REPORTS,SUBMITTED BY FORD, DESCRIBING SUSPENSION SHIMMY / OSCILLATIONSAND A FORD TSB (07-10-10) DESCRIBING THE SUSPENSION SHIMMY ISSUE AND HOW TO REPAIR THE PROBLEM.FORD HAS DESCRIBED SHIMMY AS SELF-EXCITED OSCILLATION OF THE STEERING WHEELS WITH ACCOMPANYING WHEEL TRAMP.THIS PE HAS BEEN UPGRADED TO AN ENGINEERING ANALYSIS (EA) TO DETERMINE IF THE SHIMMY CONDITION THAT OCCURS ON THE SUBJECT VEHICLES CREATES A CONDITION WHERE THE VEHICLE BECOMES DIFFICULT TO CONTROL OR STARTLES THE DRIVER, THUS PRESENTING A SAFETY RISK.
2006 Ford F-250 Problems, Complaints & Recalls | Skip That Year
Illustration