Electrical System. Review the 10 owner reports in this category and discuss these concerns during a pre-purchase inspection. Read reports →
Power Train. Review the 6 owner reports in this category and discuss these concerns during a pre-purchase inspection. Read reports →
Service Brakes. Review the 5 owner reports in this category and discuss these concerns during a pre-purchase inspection. Read reports →

NHTSA owner reports · September 18, 2026 snapshot.

2 crash reports1 fire reports1 injury reports

Power Train complaints

6 reports

Clear category filter

Mileage unknown · Aug 12, 2025

Power Train

Read full complaint

Slight vibration at highway speed accompanied by faint grinding noise. Ford installed front auto locker to only one front wheel and a dummy full time locker to right front wheel in non trimmer 2024 f250 and f350s. They know the problem because they issued a tsb 52423 but do not contact truck owners of issue. Having only one locker makes the right side front axel spin at highway speeds and cause noise, vibration and unequal drag on the two front wheels causing the vehicle to drift to the right. Ford knows this, as evident by them going back to two locking auto hubs on 2025 models. My bigger concern is what happens in 100k k miles when the front differential being warn out by the highway speeds fails and locks up the front differential and suddenly locks the front right wheel and potentially sends the 7000 lb vehicle in an uncontrollable right turn. I am currently working with walker Ford to correct this issue with my truck. In my opion, this is a huge safety issue because Ford is aware of this problem but is not notifying owners of the issue with an official recall. Needed fix, replace right dummy locker hub with functional hub like the left side ( part number HC3Z3B396A $260), instal replacement volume line (part number HC3Z3C124B $51) if said truck does not already have one, and finally install 6 in vacume line (part number HC323C125C $6) to the front right hub. In my opion, Ford should be held fully liable for the human safety implications down the road if they continue to ignore this proplem.

NHTSA ODI #11680075

18,000 miles · Aug 4, 2025

Fuel System, GasolinePower Train

Read full complaint

The contact owns a 2024 Ford F-250 SD. The contact stated that while the dealer was performing a routine service on the vehicle, the dealer informed the contact that the vehicle was designed with 2 different 4-Wheel Drive hubs, a driver's side automatic hub and a passenger's side dummy hub. The contact was concerned that the design could reduce fuel efficiency. The vehicle was not repaired. The manufacturer was made aware of the failure, but no assistance was provided. The failure mileage was approximately 18,000. The VIN was not available.

NHTSA ODI #11678164

Mileage unknown · Jul 7, 2025

EnginePower TrainUnknown Or Other

Read full complaint

I purchased my new 2024 Ford F250 on [XXX] with less than 30 miles on the odometer. It includes a 10-speed automatic transmission. I have noticed erratic up shifting and down shifting of the transmission. The problem started at approximately 700 miles on the vehicle. Additionally I have noticed that after initial starting the vehicle, when placed into drive or reverse, the transmission appears to slam into gear as noticed by a large jerk and loud sound. The vehicle continues to sound like there is a mismatch between the engine revving up and transmission lagging behind for some time, or as if the transmission is slipping gears. The new vehicle was taken into the dealership on 6/9/2025 at 7:00AM and work was reportedly completed and vehicle ready for pickup on [XXX]. I was informed that the service technician performed a break-in procedure and that everything was okay. Within 30 minutes of picking up the vehicle the same problem started reoccurring. I called my service advisor (Michael Garcia) the follow day, [XXX] to report the same issue. I spoke with the service agent and was not able to get a loaner vehicle until 6/28/2025. At this point the vehicle has less that 3,000 miles on it. I dropped off the vehicle at 7:00 AM on the 24th for repair. Today is the 7th of July, 2025, and I am still waiting for the dealership to give me the status. INFORMATION REDACTED PURSUANT TO THE FREEDOM OF INFORMATION ACT (FOIA), 5 U.S.C. 552(B)(6)

NHTSA ODI #11671742

Mileage unknown · Mar 24, 2025

Power Train

Transmission switching gears while driving. From 3 down to 1 or 6 down to 1. And not engaging gears. Sudden strong jerks, as if something fell off from under the hood.

NHTSA ODI #11650237

Mileage unknown · Feb 21, 2025

Power Train

Read full complaint

While on an incline with the front-end facing up-hill, in 2WD mode, the truck rolls backward after placed in "Park." The truck will continue rolling until application of the brakes. This happens every time. When in 4WD (H) mode, the truck does not roll when in "Park." This has occurred since we purchased the truck on 23 December 2024; however, until yesterday, we thought the truck was only sliding on our icy driveway. On 20 February 2025, we confirmed without a doubt that the truck is actually rolling while in "Park." To ensure the truck does not roll, after placing in "Park," we also apply the parking/emergency brake. This was reported to our local Ford dealer on 21 February 2025. A service appointment has been made.

NHTSA ODI #11644178

Mileage unknown · Jan 1, 2025

Electrical SystemFuel/propulsion SystemPower TrainCrash

On numerous times when you start the truck there is a delay from when you engage drive and the drivetrain gets power. To the point that 1 time the truck rolled back into another destroying their bumper.

NHTSA ODI #11633538

Official recalls

26V489000 · Back Over Prevention:display Function; Back Over Prevention:software

Jul 28, 2026

Ford Motor Company (Ford) is recalling certain 2021-2023 F-150 and 2023-2026 F-250 SD vehicles equipped with 8-inch SYNC infotainment screens. A software error may cause the rearview camera image to be obstructed by the infotainment home screen menu when the vehicle is placed in reverse. As such, these vehicles fail to comply with the requirements of Federal Motor Vehicle Safety Standard (FMVSS) number 111, "Rear Visibility."

Consequence & remedy

Consequence: An obstructed rearview camera image can reduce the driver's rear visibility, increasing the risk of a crash.

Remedy: The accessory protocol interface module (APIM) software will be updated by a dealer or through an over-the-air (OTA) update, free of charge. Interim letters, notifying owners of the safety risk, were mailed August 7, 2026. Additional letters will be sent once the remedy is available, anticipated in September 2026. Owners may contact Ford customer service at 1-866-436-7332. Ford's number for this recall is 26C37. Vehicle Identification Numbers (VINs) involved in this recall became searchable on NHTSA.gov on July 31, 2026.

Additional source detail variants (2)

Back Over Prevention:display Function

Consequence: An obstructed rearview camera image can reduce the driver's rear visibility, increasing the risk of a crash.

Remedy: The accessory protocol interface module (APIM) software will be updated by a dealer or through an over-the-air (OTA) update, free of charge. Interim letters, notifying owners of the safety risk, were mailed August 7, 2026. Additional letters will be sent once the remedy is available, anticipated in September 2026. Owners may contact Ford customer service at 1-866-436-7332. Ford's number for this recall is 26C37. Vehicle Identification Numbers (VINs) involved in this recall became searchable on NHTSA.gov on July 31, 2026.

Back Over Prevention:software

Consequence: An obstructed rearview camera image can reduce the driver's rear visibility, increasing the risk of a crash.

26V104000 · Electrical System: Integrated Trailer Brake Control; Exterior Lighting:tail Lights

Feb 20, 2026

Ford Motor Company (Ford) is recalling certain 2021-2026 F-150, 2022-2026 F-250 SD, F-350 SD, F-450 SD, F-550 SD, Maverick, 2024-2026 Ranger, 2023-2026 F-600 SD, 2022-2027 Lincoln Navigator, Expedition, and 2026 E-Transit vehicles. When towing a trailer, the integrated trailer module (ITRM) may lose communication with the vehicle, possibly causing a loss of brake and turn signal lights, or a loss of brake function. As such, these vehicles fail to comply with the requirements of Federal Motor Vehicle Safety Standard number 108, " Lamps, Reflective Devices, and Associated Equipment."

Consequence & remedy

Consequence: Trailer lights or brakes that do not function can reduce the driver’s ability to control the trailer and decrease the trailers visibility to other road users, increasing the risk of a crash.

Remedy: The integrated trailer module software will be updated by a dealer, or through an over-the-air (OTA) update, free of charge. Owner notification letters were mailed March 25, 2026. Owners may contact Ford customer service at 1-866-436-7332. Ford's number for this recall is 26C10. Vehicle Identification Numbers (VINs) involved in this recall will be searchable on NHTSA.gov beginning March 17, 2026.

Additional source detail variants (2)

Exterior Lighting:tail Lights

Consequence: Trailer lights or brakes that do not function can reduce the driver’s ability to control the trailer and decrease the trailers visibility to other road users, increasing the risk of a crash.

Remedy: The integrated trailer module software will be updated by a dealer, or through an over-the-air (OTA) update, free of charge. Owner notification letters were mailed March 25, 2026. Owners may contact Ford customer service at 1-866-436-7332. Ford's number for this recall is 26C10. Vehicle Identification Numbers (VINs) involved in this recall will be searchable on NHTSA.gov beginning March 17, 2026.

Electrical System: Integrated Trailer Brake Control

25V315000 · Back Over Prevention:software

May 9, 2025

Ford Motor Company (Ford) is recalling certain 2021-2024 Bronco, F-150, 2021-2024 Edge, 2022-2025 Escape, F-250, F-350, F-450, F-550, F-600, 2022-2024 Expedition, 2022-2025 Transit, 2021-2023 Mach-E, 2024 Ranger, Mustang, 2021-2023 Lincoln Nautilus, 2022-2024 Navigator, and 2023-2024 Corsair vehicles. A software error may cause the rearview camera image to delay, freeze, or not display when the vehicle is in reverse.

Consequence & remedy

Consequence: A frozen or missing rearview camera image can reduce the driver's view behind the vehicle, increasing the risk of a crash.

Remedy: The accessory protocol interface module (APIM) software will be updated by a dealer or through an over-the-air update, free of charge. This will be a phased campaign, with the remedy becoming available in different phases based on model and model years. Interim letters notifying owners of the safety risk were mailed on June 26, 2025. Additional letters will be mailed once the final remedy is available on each phase. Owner notification letters were sent on October 8, 2025. Owners may contact Ford customer service at 1-866-436-7332. Ford's number for this recall is 25S49.

24V806000 · Back Over Prevention: Sensing System: Camera; Structure:body:tailgate

Oct 25, 2024

Ford Motor Company (Ford) is recalling certain 2023-2024 F-250, F-350, and F-450 vehicles. Water may enter the Tailgate Park Assist Sensor Interface Module (TPASIM) and cause the rearview camera image to display intermittently or appear blue or black.

Consequence & remedy

Consequence: A rearview camera image that does not display can decrease the driver's visibility, increasing the risk of injury or crash.

Remedy: Dealers will replace the tailgate top camera, wire harness, TPASIM module, and update the Image Processing Module A (IPMA) software, free of charge. Owner notification letters were mailed August 6, 2025. Owners may contact Ford customer service at 1-866-436-7332. Ford's number for this recall is 24S66.

Additional source detail variants (2)

Back Over Prevention: Sensing System: Camera

Consequence: A rearview camera image that does not display can decrease the driver's visibility, increasing the risk of injury or crash.

Remedy: Dealers will replace the tailgate top camera, wire harness, TPASIM module, and update the Image Processing Module A (IPMA) software, free of charge. Owner notification letters were mailed August 6, 2025. Owners may contact Ford customer service at 1-866-436-7332. Ford's number for this recall is 24S66.

Structure:body:tailgate

Consequence: A rearview camera image that does not display can decrease the driver's visibility, increasing the risk of injury or crash.

Model-level recall history does not show whether a particular VIN is affected or has received a repair. Check a VIN with NHTSA ↗

NHTSA investigations

No exact-year investigations in this snapshot.