NHTSA owner reports · September 18, 2026 snapshot.
Power Train complaints
7 reportsClear category filterMileage unknown · Feb 11, 2026
EnginePower Train
I was on an overpass in the left hand lane doing 40-45mpg getting ready to make a left hand turn on an expressway on ramp. I coasted for just a bit and applied the brakes gently, then a little more. The truck was not slowing down like it should have so I applied alot more brake pedal pressure and it slowed down some then it down…
Read full complaint
I was on an overpass in the left hand lane doing 40-45mpg getting ready to make a left hand turn on an expressway on ramp. I coasted for just a bit and applied the brakes gently, then a little more. The truck was not slowing down like it should have so I applied alot more brake pedal pressure and it slowed down some then it down shifted several times and the engine was roaring, I'm guessing around 3K rpms or more and pulling me forwards. I put as much pressure as I could on the brake pedal and got it down to 4-5 mph and then as it was almost at a stop, still with the motor roaring, I slammed it into park and turned the key off. The motor turned off thank goodness. I sat there for about 20 seconds or so, luckily no one was behind me, then I turned it on again and it was idling just fine. I crept through the intersection and proceeded down the on ramp at 10mph or so and pulled over. Turned it off again and called the wife and a few friends about it. It ran ok, albeit I was super cautious, to my destination 25 minutes on down the highway. Something freaked out big time in the computer. Had there been traffic or someone in front of me it would have lead to a serious crash.
NHTSA ODI #11717225
Mileage unknown · May 6, 2025
Power TrainSuspension
When shifting into drive from reverse it will shift very hard into drive. This happens about 4 times a month and it is very forceful. Suspension is very ruff. Very different from other Ford trucks I driven. Rear suspension makes a noise going over bumps and dips.
NHTSA ODI #11659164
Mileage unknown · Oct 15, 2024
EnginePower Train
Ford Has yet to update VIN Lists for 24B27 engine update.
NHTSA ODI #11619866
Mileage unknown · Sep 13, 2024
Power Train
What component or system failed or malfunctioned, and is it available for inspection upon request? The Variable Displacement Oil Pump delivers oil to the engine at low pressure/capacity during idle conditions. Routine occurrences of prolonged idle time may result in excess wear to the engine camshaft lobes and valve tappet surfa…
Read full complaint
What component or system failed or malfunctioned, and is it available for inspection upon request? The Variable Displacement Oil Pump delivers oil to the engine at low pressure/capacity during idle conditions. Routine occurrences of prolonged idle time may result in excess wear to the engine camshaft lobes and valve tappet surfaces due to reduced lubrication. Overtime, the engine may progressively run rough due to cylinder misfire. Additionally, customers may hear engine tapping noises and the Check Engine Light may illuminate. This causes delamination of the lifters and camshaft which sends metal throughout the engine causing total engine failure and this requires a completely new engine. How was your safety or the safety of others put at risk? Beyond the financial implications, A sudden breakdown on a busy road can lead to dangerous situations, putting both me and other drivers at risk. Additionally, driving a vehicle with a compromised engine can result in further damage and potentially cause accidents. Has the problem been reproduced or confirmed by a dealer or independent service center? Yes there are many forums and videos online about this issue in the 7.3 Godzilla engine produced by ford. Has the vehicle or component been inspected by the manufacturer, police, insurance representatives or others? My vehicle is currently at the dealership for repairs which they said they are unable to do so I will be taking it to another dealership next week. Were there any warning lamps, messages or other symptoms of the problem prior to the failure, and when did they first appear? In my vehicle there was no CEL but in other customers vehicles the CEL will appear if the problem is not caught soon enough.
NHTSA ODI #11614517
Mileage unknown · Mar 19, 2024
Power Train
I had my truck inspected for this recall on October 26, 2023 and as of today they are telling me that the parts are on backorder so the recall has not been completed. Manufacturer Recall Number23S49 NHTSA Recall Number23V595 Recall StatusRecall Incomplete
NHTSA ODI #11578284
Mileage unknown · Mar 15, 2024
Electrical SystemPower TrainService Brakes
there hasn't been an incident per say and these might not be a safety concern. however i would like to list my grievances here just so there's documentation. my radio has some type of glitch where the phone calls get static like its digital, also the mirrors don't fold in all the time when locked with the key fob, the brakes hav…
Read full complaint
there hasn't been an incident per say and these might not be a safety concern. however i would like to list my grievances here just so there's documentation. my radio has some type of glitch where the phone calls get static like its digital, also the mirrors don't fold in all the time when locked with the key fob, the brakes have squeaked since day 1 and the grab handle in the tailgate just slides right out when the steps are pulled out. again i don't think this really qualifies for dangerous
NHTSA ODI #11577583
Mileage unknown · Feb 9, 2024
Power TrainService Brakes
During the 1st 20 min or so of operation the truck tries to "high idle" when in gear. This forces the operator use excessive brake pressure to keep the vehicle stopped. There have been several times my leg gets tired of holding the brake pedal down so hard the truck will creep forward unintentionally. The brakes grunt due to exc…
Read full complaint
During the 1st 20 min or so of operation the truck tries to "high idle" when in gear. This forces the operator use excessive brake pressure to keep the vehicle stopped. There have been several times my leg gets tired of holding the brake pedal down so hard the truck will creep forward unintentionally. The brakes grunt due to excessive force trying to keep the truck stopped. The dealer blows it off as normal, saying the truck is doing what its supposed to. I don't think the truck should be allowed to high idle in gear. I am afraid that I am going to accidently roll forward and hit someone. I have driven other 3/4 ton trucks and the ford 7.3 engine this is the only one that does this. I called ford and they said there is nothing to do if the dealership says the truck is operating properly.
NHTSA ODI #11571060
Official recalls
16Jul 28, 2026
Ford Motor Company (Ford) is recalling certain 2021-2023 F-150 and 2023-2026 F-250 SD vehicles equipped with 8-inch SYNC infotainment screens. A software error may cause the rearview camera image to be obstructed by the infotainment home screen menu when the vehicle is placed in reverse. As such, these vehicles fail to comply with the requirements of Federal Motor Vehicle Safety Standard (FMVSS) number 111, "Rear Visibility."
Consequence & remedy
Consequence: An obstructed rearview camera image can reduce the driver's rear visibility, increasing the risk of a crash.
Remedy: The accessory protocol interface module (APIM) software will be updated by a dealer or through an over-the-air (OTA) update, free of charge. Interim letters, notifying owners of the safety risk, were mailed August 7, 2026. Additional letters will be sent once the remedy is available, anticipated in September 2026. Owners may contact Ford customer service at 1-866-436-7332. Ford's number for this recall is 26C37. Vehicle Identification Numbers (VINs) involved in this recall became searchable on NHTSA.gov on July 31, 2026.
Additional source detail variants (2)
Back Over Prevention:display Function
Ford Motor Company (Ford) is recalling certain 2021-2023 F-150 and 2023-2026 F-250 SD vehicles equipped with 8-inch SYNC infotainment screens. A software error may cause the rearview camera image to be obstructed by the infotainment home screen menu when the vehicle is placed in reverse. As such, these vehicles fail to comply with the requirements of Federal Motor Vehicle Safety Standard (FMVSS) number 111, "Rear Visibility."
Consequence: An obstructed rearview camera image can reduce the driver's rear visibility, increasing the risk of a crash.
Remedy: The accessory protocol interface module (APIM) software will be updated by a dealer or through an over-the-air (OTA) update, free of charge. Interim letters, notifying owners of the safety risk, were mailed August 7, 2026. Additional letters will be sent once the remedy is available, anticipated in September 2026. Owners may contact Ford customer service at 1-866-436-7332. Ford's number for this recall is 26C37. Vehicle Identification Numbers (VINs) involved in this recall became searchable on NHTSA.gov on July 31, 2026.
Back Over Prevention:software
Ford Motor Company (Ford) is recalling certain 2021-2023 F-150 and 2023-2026 F-250 SD vehicles equipped with 8-inch SYNC infotainment screens. A software error may cause the rearview camera image to be obstructed by the infotainment home screen menu when the vehicle is placed in reverse. As such, these vehicles fail to comply with the requirements of Federal Motor Vehicle Safety Standard (FMVSS) number 111, "Rear Visibility."
Consequence: An obstructed rearview camera image can reduce the driver's rear visibility, increasing the risk of a crash.
Remedy: The accessory protocol interface module (APIM) software will be updated by a dealer or through an over-the-air (OTA) update, free of charge. Interim letters, notifying owners of the safety risk, were mailed August 7, 2026. Additional letters will be sent once the remedy is available, anticipated in September 2026. Owners may contact Ford customer service at 1-866-436-7332. Ford's number for this recall is 26C37. Vehicle Identification Numbers (VINs) involved in this recall became searchable on NHTSA.gov on July 31, 2026.
Mar 31, 2026
Ford Motor Company (Ford) is recalling certain 2021-2023 Lincoln Navigator, Expedition, and 2022-2023 F-250 SD, F-350 SD, F-450 SD, F-550 SD, and F-600 SD vehicles. The windshield wiper arms may break, causing the wipers to fail.
Consequence & remedy
Consequence: Windshield wiper failure can reduce visibility, increasing the risk of a crash.
Remedy: Dealers will inspect and replace the wiper arms, as necessary, free of charge. Owner notification letters were mailed August 5, 2026. Owners may contact Ford customer service at 1-866-436-7332. Ford's number for this recall is 26S24.Vehicle Identification Numbers (VINs) involved in this recall became searchable on NHTSA.gov on April 1, 2026.
Feb 20, 2026
Ford Motor Company (Ford) is recalling certain 2021-2026 F-150, 2022-2026 F-250 SD, F-350 SD, F-450 SD, F-550 SD, Maverick, 2024-2026 Ranger, 2023-2026 F-600 SD, 2022-2027 Lincoln Navigator, Expedition, and 2026 E-Transit vehicles. When towing a trailer, the integrated trailer module (ITRM) may lose communication with the vehicle, possibly causing a loss of brake and turn signal lights, or a loss of brake function. As such, these vehicles fail to comply with the requirements of Federal Motor Vehicle Safety Standard number 108, " Lamps, Reflective Devices, and Associated Equipment."
Consequence & remedy
Consequence: Trailer lights or brakes that do not function can reduce the driver’s ability to control the trailer and decrease the trailers visibility to other road users, increasing the risk of a crash.
Remedy: The integrated trailer module software will be updated by a dealer, or through an over-the-air (OTA) update, free of charge. Owner notification letters were mailed March 25, 2026. Owners may contact Ford customer service at 1-866-436-7332. Ford's number for this recall is 26C10. Vehicle Identification Numbers (VINs) involved in this recall will be searchable on NHTSA.gov beginning March 17, 2026.
Additional source detail variants (2)
Exterior Lighting:tail Lights
Ford Motor Company (Ford) is recalling certain 2021-2026 F-150, 2022-2026 F-250 SD, F-350 SD, F-450 SD, F-550 SD, Maverick, 2024-2026 Ranger, 2023-2026 F-600 SD, 2022-2027 Lincoln Navigator, Expedition, and 2026 E-Transit vehicles. When towing a trailer, the integrated trailer module (ITRM) may lose communication with the vehicle, possibly causing a loss of brake and turn signal lights, or a loss of brake function. As such, these vehicles fail to comply with the requirements of Federal Motor Vehicle Safety Standard number 108, " Lamps, Reflective Devices, and Associated Equipment."
Consequence: Trailer lights or brakes that do not function can reduce the driver’s ability to control the trailer and decrease the trailers visibility to other road users, increasing the risk of a crash.
Remedy: The integrated trailer module software will be updated by a dealer, or through an over-the-air (OTA) update, free of charge. Owner notification letters were mailed March 25, 2026. Owners may contact Ford customer service at 1-866-436-7332. Ford's number for this recall is 26C10. Vehicle Identification Numbers (VINs) involved in this recall will be searchable on NHTSA.gov beginning March 17, 2026.
Electrical System: Integrated Trailer Brake Control
Ford Motor Company (Ford) is recalling certain 2021-2026 F-150, 2022-2026 F-250 SD, F-350 SD, F-450 SD, F-550 SD, Maverick, 2024-2026 Ranger, 2023-2026 F-600 SD, 2022-2027 Lincoln Navigator, Expedition, and 2026 E-Transit vehicles. When towing a trailer, the integrated trailer module (ITRM) may lose communication with the vehicle, possibly causing a loss of brake and turn signal lights, or a loss of brake function. As such, these vehicles fail to comply with the requirements of Federal Motor Vehicle Safety Standard number 108, " Lamps, Reflective Devices, and Associated Equipment."
Consequence: Trailer lights or brakes that do not function can reduce the driver’s ability to control the trailer and decrease the trailers visibility to other road users, increasing the risk of a crash.
Remedy: The integrated trailer module software will be updated by a dealer, or through an over-the-air (OTA) update, free of charge. Owner notification letters were mailed March 25, 2026. Owners may contact Ford customer service at 1-866-436-7332. Ford's number for this recall is 26C10. Vehicle Identification Numbers (VINs) involved in this recall will be searchable on NHTSA.gov beginning March 17, 2026.
Jul 7, 2025
Ford Motor Company (Ford) is recalling certain 2021-2023 Bronco, Explorer, Lincoln Aviator, F-250 SD, F-350 SD, F-450 SD, F-550 SD, 2021-2022 Lincoln Navigator, Mustang, F-150, and 2022 Expedition vehicles. The low-pressure fuel pump may fail, which can result in an engine stall while driving.
Consequence & remedy
Consequence: An engine stall increases the risk of a crash.
Remedy: Dealers will replace the low pressure fuel pump on super duty vehicles and update the powertrain control module (PCM) software on all other affected vehicles, free of charge. Owner notification letters were mailed July 27, 2026. Owners may contact Ford customer service at 1-866-436-7332. Ford's number for this recall is 25S75.
May 9, 2025
Ford Motor Company (Ford) is recalling certain 2021-2024 Bronco, F-150, 2021-2024 Edge, 2022-2025 Escape, F-250, F-350, F-450, F-550, F-600, 2022-2024 Expedition, 2022-2025 Transit, 2021-2023 Mach-E, 2024 Ranger, Mustang, 2021-2023 Lincoln Nautilus, 2022-2024 Navigator, and 2023-2024 Corsair vehicles. A software error may cause the rearview camera image to delay, freeze, or not display when the vehicle is in reverse.
Consequence & remedy
Consequence: A frozen or missing rearview camera image can reduce the driver's view behind the vehicle, increasing the risk of a crash.
Remedy: The accessory protocol interface module (APIM) software will be updated by a dealer or through an over-the-air update, free of charge. This will be a phased campaign, with the remedy becoming available in different phases based on model and model years. Interim letters notifying owners of the safety risk were mailed on June 26, 2025. Additional letters will be mailed once the final remedy is available on each phase. Owner notification letters were sent on October 8, 2025. Owners may contact Ford customer service at 1-866-436-7332. Ford's number for this recall is 25S49.
Mar 14, 2025
Ford Motor Company (Ford) is recalling certain 2023 Super Duty F-250 and F-350 vehicles previously repaired incorrectly under recall number 23V-507. The driver and front passenger windows may fail to detect an obstacle while closing and not reverse direction as intended.
Consequence & remedy
Consequence: A window that does not automatically reverse when an obstruction is encountered increases the risk of injury.
Remedy: Dealers will update the software, free of charge. Owner notification letters were mailed April 18, 2025. Owners may contact Ford customer service at 1-866-436-7332. Ford's number for this recall is 25S25.
Feb 28, 2025
Ford Motor Company (Ford) is recalling certain 2023 F-Super Duty F-250, F-350, and F-450 vehicles previously repaired incorrectly under recall number 23V-573. The default rearview camera image may not be displayed when using the Pro Trailer Hitch Assist feature.
Consequence & remedy
Consequence: An incorrect rearview camera image can reduce the driver's view of what is behind the vehicle, increasing the risk of a crash or injury.
Remedy: Dealers will update the Advanced Drive Assistance System (ADAS) module software, free of charge. Owner notification letters were mailed April 4, 2025. Owners may contact Ford customer service at 1-866-436-7332. Ford's number for this recall is 25S17.
Oct 25, 2024
Ford Motor Company (Ford) is recalling certain 2023-2024 F-250, F-350, and F-450 vehicles. Water may enter the Tailgate Park Assist Sensor Interface Module (TPASIM) and cause the rearview camera image to display intermittently or appear blue or black.
Consequence & remedy
Consequence: A rearview camera image that does not display can decrease the driver's visibility, increasing the risk of injury or crash.
Remedy: Dealers will replace the tailgate top camera, wire harness, TPASIM module, and update the Image Processing Module A (IPMA) software, free of charge. Owner notification letters were mailed August 6, 2025. Owners may contact Ford customer service at 1-866-436-7332. Ford's number for this recall is 24S66.
Additional source detail variants (2)
Back Over Prevention: Sensing System: Camera
Ford Motor Company (Ford) is recalling certain 2023-2024 F-250, F-350, and F-450 vehicles. Water may enter the Tailgate Park Assist Sensor Interface Module (TPASIM) and cause the rearview camera image to display intermittently or appear blue or black.
Consequence: A rearview camera image that does not display can decrease the driver's visibility, increasing the risk of injury or crash.
Remedy: Dealers will replace the tailgate top camera, wire harness, TPASIM module, and update the Image Processing Module A (IPMA) software, free of charge. Owner notification letters were mailed August 6, 2025. Owners may contact Ford customer service at 1-866-436-7332. Ford's number for this recall is 24S66.
Structure:body:tailgate
Ford Motor Company (Ford) is recalling certain 2023-2024 F-250, F-350, and F-450 vehicles. Water may enter the Tailgate Park Assist Sensor Interface Module (TPASIM) and cause the rearview camera image to display intermittently or appear blue or black.
Consequence: A rearview camera image that does not display can decrease the driver's visibility, increasing the risk of injury or crash.
Remedy: Dealers will replace the tailgate top camera, wire harness, TPASIM module, and update the Image Processing Module A (IPMA) software, free of charge. Owner notification letters were mailed August 6, 2025. Owners may contact Ford customer service at 1-866-436-7332. Ford's number for this recall is 24S66.
Dec 15, 2023
Ford Motor Company (Ford) is recalling certain 2023 F-150 and Ford SD F250, F350, F450, F550, and F600 vehicles. The steering wheel clock spring may have an insufficient weld, causing a loss of electrical connection to the driver's frontal air bag.
Consequence & remedy
Consequence: A deactivated air bag will not deploy during a crash, increasing the risk of injury.
Remedy: Dealers will inspect and replace the clock spring as necessary, free of charge. Owner notification letters were mailed on May 3, 2024. Owners may contact Ford customer service at 1-866-436-7332.
Additional source detail variants (2)
Steering:column
Ford Motor Company (Ford) is recalling certain 2023 F-150 and Ford SD F250, F350, F450, F550, and F600 vehicles. The steering wheel clock spring may have an insufficient weld, causing a loss of electrical connection to the driver's frontal air bag.
Consequence: A deactivated air bag will not deploy during a crash, increasing the risk of injury.
Remedy: Dealers will inspect and replace the clock spring as necessary, free of charge. Owner notification letters were mailed on May 3, 2024. Owners may contact Ford customer service at 1-866-436-7332.
Air Bags:frontal:driver Clockspring/spiral Cassette
Ford Motor Company (Ford) is recalling certain 2023 F-150 and Ford SD F250, F350, F450, F550, and F600 vehicles. The steering wheel clock spring may have an insufficient weld, causing a loss of electrical connection to the driver's frontal air bag.
Consequence: A deactivated air bag will not deploy during a crash, increasing the risk of injury.
Remedy: Dealers will inspect and replace the clock spring as necessary, free of charge. Owner notification letters were mailed on May 3, 2024. Owners may contact Ford customer service at 1-866-436-7332.
Aug 25, 2023
Ford Motor Company (Ford) is recalling certain 2023 Super Duty F250 and F350 vehicles equipped with single rear wheels and a 10.5-inch rear axle shaft. The left rear axle shaft may have been improperly heat-treated during manufacturing and may break.
Consequence & remedy
Consequence: A broken rear axle shaft can result in a loss of drive power or vehicle rollaway when the vehicle is placed in park. Either of these scenarios can increase the risk of a crash.
Remedy: Dealers will inspect the left rear axle shaft date code and replace the axle shaft as necessary, free of charge. Owner notification letters were mailed October 17, 2023. Owners may contact Ford customer service at 1-866-436-7332. Ford's number for this recall is 23S49.
Aug 11, 2023
Ford Motor Company (Ford) is recalling certain 2023 F-Super Duty F250, F350, and F450 vehicles equipped with the Pro Trailer Hitch Assist feature. The default rearview camera image may not be displayed when using the Pro Trailer Hitch Assist feature.
Consequence & remedy
Consequence: An incorrect rearview camera image can reduce the driver's view of what is behind the vehicle, increasing the risk of a crash or injury.
Remedy: Dealers will update the Advanced Drive Assistance System (ADAS) module software, free of charge. Owner notification letters were mailed December 5, 2023. Owners may contact Ford customer service at 1-866-436-7332. Ford's number for this recall is 23S46.
Jul 21, 2023
Ford Motor Company (Ford) is recalling certain 2023 Escape, Super Duty F-250, Super Duty F-350, Super Duty F-450, and Super Duty F-550 vehicles equipped with a digital instrument panel cluster. The module may have been improperly soldered, preventing the instrument panel from illuminating. As such, these vehicles fail to comply with the requirements of Federal Motor Vehicle Safety Standard number 101, "Control and Displays."
Consequence & remedy
Consequence: An inoperable instrument panel cannot show critical safety information, such as the speedometer or warning lights, which may increase the risk of a crash.
Remedy: Dealers will replace the module or instrument panel as necessary, free of charge. Owner notification letters were mailed on November 4, 2023. Owners may contact Ford customer service at 1-866-436-7332. Ford's number for this recall is 23C25.
Jul 21, 2023
Ford Motor Company (Ford) is recalling certain 2023 Super Duty F250, F350, F450, and F550 vehicles. If the driver and front passenger door module experiences a low power condition and resets while the window is moving, the anti-pinch function may not detect an obstacle near the top edge and may not automatically reverse direction.
Consequence & remedy
Consequence: A window that does not automatically reverse when an obstruction is encountered increases the risk of injury.
Remedy: Dealers will update the software, free of charge. Owner notification letters were mailed August 28, 2023. Owners may contact Ford customer service at 1-866-436-7332. Ford's number for this recall is 23S37.
Jun 9, 2023
Ford Motor Company (Ford) is recalling certain 2018-2023 Expedition and Lincoln Navigator vehicles equipped with third-row seating; and 2019-2023 F-Super Duty F-250, F-350, F-450, and F-550 SuperCab vehicles. The owner's manual does not include instructions for adjusting or removing certain head restraints. As such, these vehicles fail to comply with the requirements of Federal Motor Vehicle Safety Standard number 202, "Head Restraints."
Consequence & remedy
Consequence: Without instructions, the head restraints may be improperly adjusted, increasing the risk of injury in the event of a crash.
Remedy: Ford will mail the Owner's Manual addendums that describe how to adjust and remove the head restraints for the center seating positions, free of charge. Owner notification letters were mailed July 21, 2023. Owners may contact Ford customer service at 1-866-436-7332. Ford's number for this recall is 23C20.
May 26, 2023
Ford Motor Company (Ford) is recalling certain 2022-2023 Bronco, 2023 Super Duty F-250, and 2019-2023 Ranger vehicles. The Tire and Loading Information (TREAD) label states the incorrect load carrying capacity, which can result in an overloaded vehicle. As such, these vehicles fail to comply with the requirements of Federal Motor Vehicle Safety Standard number 110, "Tire Selection and Rims."
Consequence & remedy
Consequence: An overloaded vehicle increases the risk of a crash.
Remedy: Ford will mail a new TREAD label to install over the existing label, free of charge. Owners will also have the option to take their vehicle to a Ford or Lincoln dealer to have the new label installed, free of charge. Owner notification letters were mailed July 21, 2023. Owners may contact Ford customer service at 1-866-436-7332. Ford's number for this recall is 23C18.
May 12, 2023
Ford Motor Company (Ford) is recalling certain 2023 Super Duty F-250, F-350, and F-450 vehicles. The steering column upper shaft bolts may be missing or improperly tightened, resulting in possible separation of the steering column from the adjoining components.
Consequence & remedy
Consequence: A disconnected steering column can result in a loss of steering control, increasing the risk of a crash.
Remedy: Dealers will inspect and tighten the steering column upper shaft coupler bolts, or install any missing bolts, as necessary, free of charge. Owner notification letters were mailed June 1, 2023. Owners may contact Ford customer service at 1-866-436-7332. Ford's number for this recall is 23S22.
Model-level recall history does not show whether a particular VIN is affected or has received a repair. Check a VIN with NHTSA ↗
Illustration