NHTSA owner reports · September 18, 2026 snapshot.
Fuel/propulsion System complaints
28 reportsClear category filterMileage unknown · Feb 27, 2025
Fuel/propulsion System
Driving down freeway truck started to shutter knock and sqaul making noise and wouldn’t accept any throttle , truck died and coasted to shoulder , hauled to shop on wrecker had mechanic diagnose issue resulting in several fuel system codes all stating correlating cylinder imbalance Low fuel pressure on all circuits etc , pics w…
Read full complaint
Driving down freeway truck started to shutter knock and sqaul making noise and wouldn’t accept any throttle , truck died and coasted to shoulder , hauled to shop on wrecker had mechanic diagnose issue resulting in several fuel system codes all stating correlating cylinder imbalance Low fuel pressure on all circuits etc , pics were to large to upload below but could send via email if needed
NHTSA ODI #11645435
Mileage unknown · Jan 14, 2025
Fuel/propulsion System
Code P221C code stating that the DEF reductant heater is malfunctioning during cold weather
NHTSA ODI #11635790
Mileage unknown · Jan 1, 2025
Fuel/propulsion System
My truck started having the extended start a couple of years ago. It seems when it's warmer outside, sometimes, it will crank for an excessive amount of time before it will start. It was very intermittent and hard to determine exactly when this would occur. Someone told me it was the fuel pump and that the fuel pumps in certa…
Read full complaint
My truck started having the extended start a couple of years ago. It seems when it's warmer outside, sometimes, it will crank for an excessive amount of time before it will start. It was very intermittent and hard to determine exactly when this would occur. Someone told me it was the fuel pump and that the fuel pumps in certain Ford Super Duty models were just faulty. A couple of weeks ago, I was pulling onto the highway from a stop. My check engine light came on and the truck almost stalled. There was a vehicle that had to brake suddenly to avoid this. Now I notice that when I give the truck gas when it's in a higher gear, it hesitates and starts jerking back and forth. I can't drive it now. I know it's the fuel pump. I also have a neighbor that has a 2019 F-250 truck and his truck is doing the exact same thing right now. He said he's had the extended crank for a few years occur to him as well. He contacted the dealership and they told him it's a known issue with the fuel pumps in the Super Duty trucks. There are many videos online of folks reporting the exact same thing as my truck and my neighbors truck. However, we have gas engines and not the diesel engines. I feel the recent recall should be extended to all Super Duty trucks and don't just think it's an issue with the diesel trucks. I'm just wondering if anyone has looked into all the fuel pumps Ford is putting into their Super Duty trucks. It's crazy how so many people are having problems with them whether they have the gas engine or the diesel engines. Thanks!
NHTSA ODI #11633484
Mileage unknown · Jun 9, 2023
Fuel/propulsion System
Evaporator purge valve Ford part number LC3Z-9B325-A. It has been changed by local Ford dealer once, inspected twice more in a 7 month period by the same dealer. Causing erratic idle and engine pause during accelerating. Engine warning light repeatedly appears, during dealer inspection, dealer reports passing test and turns eng…
Read full complaint
Evaporator purge valve Ford part number LC3Z-9B325-A. It has been changed by local Ford dealer once, inspected twice more in a 7 month period by the same dealer. Causing erratic idle and engine pause during accelerating. Engine warning light repeatedly appears, during dealer inspection, dealer reports passing test and turns engine warning light off.
NHTSA ODI #11526278
Mileage unknown · Jan 6, 2023
Fuel/propulsion System
While driving on the highway at approximately 70 mph the truck's check engine light came on followed by a message "reduced power" on the dash cluster. The truck shut off almost instantly after this.
NHTSA ODI #11500536
Mileage unknown · Feb 18, 2022
Fuel/propulsion SystemPower Train
Going down road cruise set in a 4 lane heavy traffic my truck dies like a light comes on and cars are bumper to bumper I’m trying to pull over my children are in the vehicle they go to crying scared finally I got half way off the road and got out and with few good peoples help pushed it out of the road I switched on and off the …
Read full complaint
Going down road cruise set in a 4 lane heavy traffic my truck dies like a light comes on and cars are bumper to bumper I’m trying to pull over my children are in the vehicle they go to crying scared finally I got half way off the road and got out and with few good peoples help pushed it out of the road I switched on and off the truck I could hear the pump near the tank making all kinds of noises I new then my fuel pump had went out
NHTSA ODI #11452800
150 miles · Apr 23, 2021
EngineFuel/propulsion SystemPower Train
MOTOR HAS A NKOCKING TAPPING SOUND LIKE AND OLD SCHOOL TYPE WRITER AND GETS LOUD AT TIMES WHEN IDELING AND SOME TIME REALLY LOUD ANFTER DRIVING IT FO RW WHLLE, (DIESEL ENGINE DOESN'T SOUND LIKE THAT),FORD ENGINEERING AT FACTORY KNOWS WHAT THE PROBLEM IS BUT REFUSES TO ALLOW DEALERSHIP TO REPAIR IT AND REPLACE THE PARTS. TRANSMI…
Read full complaint
MOTOR HAS A NKOCKING TAPPING SOUND LIKE AND OLD SCHOOL TYPE WRITER AND GETS LOUD AT TIMES WHEN IDELING AND SOME TIME REALLY LOUD ANFTER DRIVING IT FO RW WHLLE, (DIESEL ENGINE DOESN'T SOUND LIKE THAT),FORD ENGINEERING AT FACTORY KNOWS WHAT THE PROBLEM IS BUT REFUSES TO ALLOW DEALERSHIP TO REPAIR IT AND REPLACE THE PARTS. TRANSMISSION HAD SNECOR AND VALVE BODY GO OUT CAUSED TRANSMISSION TO LOCK UP IN 10TH GEAR AND STALLING OUT. DEALERSHIP REPLACED THE PARTS WITH NEW ONES, BU TDID NOT CORRECT THE PROBLEM AND NOW STALLES AND SLIPPES WHEN SHIFTING GEARS, OR SOMETIMES SHIFTS SO HARD IT SHAKES THE TRUCK (F250 DIESEL). HAS A GRINDING NOISE WHEN DOWN SHIFTING FROM 5,4,3 GEARS. WHEN DRIVINING THE TRUCK AND GO TO PASS AROUND ANOTHER VEHICLE IS SLIPS GEARS ARE STALLES DOWN UNTIL IT CAN CATCH ITS GEAR TO GO HAPPENED SEVERAL TIMES. VEHICLE ONLY HAS 6,500 MILES ON IT AND WAS PURCHASED AUGUST 26, 2020 AND SHOULD NOT HAVE THESE ISSUES AND PROBLEMS. MOST OF ALL THE FACTORY ENGINEERS SHOULD NOT DENY THE DEALERSHIP TO FIX AND REPLACE WHAT IS WRONG AND CAUUSING THE LOUND AND UPNOGCHIS KNOCKING TICKING SOUND EVEN AFTER DOING A BLACK BOX FLIGHT RECORDER TO DETERMINE WHERE THE PROBLEM IS COMING FROM. THEY SAID TO KEEP DRIVING UNTIL ENOUGH COMPLAINTS COM IN TO HAVE A RECALL SENT OUR ARE UNTIL IT BRAKES AND GOES OUT. THIS IS A SAFETY HAZARD TO EVERYONE ON THE ROAD AND COULD POSSIBLY CAUSE HARM TO INISANT PEOPLE, SUCH AS MYSELF, MY FAMILY, AND OTHERS OUT ON THE ROAD. PLEASE HAVE THIS LOOKED INTO AND HELP GET IT TAKEN CARE OF.
NHTSA ODI #11413605
7,448 miles · Nov 24, 2020
Fuel/propulsion System
ON AUGUST 28, 2020, THE ENGINE IN MY VIRTUALLY BRAND NEW 2020 FORD F-250 TRUCK (EQUIPPED WITH A DIESEL ENGINE) SUDDENLY AND WITHOUT ANY ADVANCED WARNING WHATSOEVER SHUT OFF WHILE THE VEHICLE WAS IN MOTION. I HAD JUST TURNED FROM STATE HIGHWAY 10 INTO THE LEFT LANE OF A FOUR-LANE CITY STREET IN 5 O'CLOCK TRAFFIC ON A FRIDAY EVEN…
Read full complaint
ON AUGUST 28, 2020, THE ENGINE IN MY VIRTUALLY BRAND NEW 2020 FORD F-250 TRUCK (EQUIPPED WITH A DIESEL ENGINE) SUDDENLY AND WITHOUT ANY ADVANCED WARNING WHATSOEVER SHUT OFF WHILE THE VEHICLE WAS IN MOTION. I HAD JUST TURNED FROM STATE HIGHWAY 10 INTO THE LEFT LANE OF A FOUR-LANE CITY STREET IN 5 O'CLOCK TRAFFIC ON A FRIDAY EVENING. WITHOUT EITHER POWER BRAKES OR POWER STEERING, I WAS ABLE TO GET THE TRUCK OUT OF THE ROADWAY AND INTO THE PARKING LOT OF AN ADJACENT BUSINESS. I TRIED TO RESTART THE VEHICLE NUMEROUS TIMES. WHILE THE ENGINE WOULD CRANK, IT SIMPLY WOULD NOT RESTART. I CONTACTED MY LOCAL FORD DEALERSHIP THE NEXT MORNING AND THEY ARRANGED TO HAVE THE TRUCK TOWED TO THEIR PLACE OF BUSINESS. AFTER THE FORD DEALERSHIP HAD MY TRUCK FOR NEARLY A MONTH, THEY DETERMINED THAT THE CAUSE FOR THE SUDDEN SHUTDOWN OF MY ENGINE WAS A FAILED BOSCH CP4 HIGH PRESSURE FUEL PUMP, WHICH FAILURE CONTAMINATED MY ENTIRE FUEL DELIVERY SYSTEM WITH METAL SHAVINGS. I AM NOW AWARE THAT THERE ARE CLASS ACTION LAWSUITS AGAINST EACH OF THE MAJOR US MANUFACTURERS RELATING TO FAILURES OF THE BOSCH CP4 HIGH PRESSURE FUEL PUMP AS A RESULT OF THE LACK OF LUBRICATION PROVIDED BY LOW-SULFUR DIESEL FUEL GENERALLY AVAILABLE IN THE US, WHICH FAILURES RESULT IN SUBSTANTIAL REPAIR COSTS TO REPLACE THE ENTIRE FUEL DELIVERY SYSTEM.
NHTSA ODI #11376143
Official recalls
14Mar 17, 2026
Ford Motor Company (Ford) is recalling certain 2020-2022 F-Super Duty F250, F350, F450, F550, 2021-2022 F600, and 2022 F750 vehicles previously repaired incorrectly under recall number 24V957. Biodiesel deposits may form on the pump drivetrain roller components, which could lead to failure of the high pressure fuel pump.
Consequence & remedy
Consequence: High pressure fuel pump failure can cause a loss of drive power, increasing the risk of a crash.
Remedy: Dealers will update the powertrain control module (PCM) software, free of charge. Owner notification letters were mailed mailed April 7, 2026. Owners may contact Ford customer service at 1-866-436-7332. Ford's number for this recall is 26S17. Vehicle Identification Numbers (VINs) involved in this recall became searchable on NHTSA.gov on March 18, 2026.
Oct 10, 2025
Ford Motor Company (Ford) is recalling certain 2020-2022 F-250 SD, F-350 SD, and F-450 SD vehicles. The 360-degree view camera system may not display a rearview image properly in certain lighting conditions.
Consequence & remedy
Consequence: A rearview camera image that does not display properly can reduce the driver’s view behind the vehicle, increasing the risk of a crash.
Remedy: Dealers will update the image processing module software, free of charge.This will be a phased campaign, with the remedy becoming available in different phases based on model years. Interim letters notifying owners of the safety risk were mailed on October 30, 2025. Additional letters will be mailed once the remedy is available on each phase. Owner notification letters were mailed May 19, 2026. Owners may contact Ford customer service at 1-866-436-7332. Ford's number for this recall is 25SA8. Vehicle Identification Numbers (VINs) involved in this recall became searchable on NHTSA.gov on October 13, 2025.
Sep 19, 2025
Ford Motor Company (Ford) is recalling certain 2020-2021 F-250, F-350, and F-450 vehicles. The steering column upper shaft may detach from the steering column and result in a loss of steering control.
Consequence & remedy
Consequence: A loss of steering control increases the risk of a crash.
Remedy: Dealers will inspect the steering column, and repair or replace the upper shaft as necessary, free of charge. Owner notification letters were mailed February 20, 2026. Owners may contact Ford customer service at 1-866-436-7332. Ford's number for this recall is 25S94. Vehicle Identification Numbers (VINs) involved in this recall will be searchable on NHTSA.gov beginning September 23, 2025.
Jun 27, 2025
Ford Motor Company (Ford) is recalling certain 2018-2022 Transit Connect, 2019-2020 MKZ, MKX, Edge, Continental, F-150, Nautilus, Fusion, 2019-2023 Ranger, Mustang, 2020-2021 EcoSport, Expedition, Navigator, 2020-2022 Escape, F-250 SD, Corsair, 2020-2023 Aviator, Transit, 2020-2024 Explorer, 2021-2024 Bronco Sport, and 2022-2024 Maverick vehicles. A software error may cause the rearview camera to display a blank image, or the image may remain on the display after the backing event has ended.
Consequence & remedy
Consequence: A rearview camera that displays a blank image can reduce the driver's view behind the vehicle. A rearview image that continues to be displayed after the vehicle is shifted out of reverse may distract the driver. Both of these situations can increase the risk of a crash.
Remedy: Dealers will update the rearview camera software, free of charge. Owner notification letters were mailed September 4, 2025. Owners may contact Ford customer service at 1-866-436-7332. Ford's number for this recall is 25S72.
Dec 20, 2024
Ford Motor Company (Ford) is recalling certain 2020-2022 F-Super Duty F250, F350, F450, F550, F600, and 2021-2022 F-650, F750 vehicles. Biodiesel deposits may form on the pump drivetrain roller components, which could lead to failure of the high pressure fuel pump.
Consequence & remedy
Consequence: High pressure fuel pump failure can cause a loss of drive power, increasing the risk of a crash.
Remedy: Dealers will update the powertrain control module (PCM) and Transmission Control Module (TCM) software, free of charge. Owner notification letters were mailed January 23, 2026. Owners may contact Ford customer service at 1-866-436-7332. Ford's number for this recall is 24S78.
Jun 9, 2023
Ford Motor Company (Ford) is recalling certain 2018-2023 Expedition and Lincoln Navigator vehicles equipped with third-row seating; and 2019-2023 F-Super Duty F-250, F-350, F-450, and F-550 SuperCab vehicles. The owner's manual does not include instructions for adjusting or removing certain head restraints. As such, these vehicles fail to comply with the requirements of Federal Motor Vehicle Safety Standard number 202, "Head Restraints."
Consequence & remedy
Consequence: Without instructions, the head restraints may be improperly adjusted, increasing the risk of injury in the event of a crash.
Remedy: Ford will mail the Owner's Manual addendums that describe how to adjust and remove the head restraints for the center seating positions, free of charge. Owner notification letters were mailed July 21, 2023. Owners may contact Ford customer service at 1-866-436-7332. Ford's number for this recall is 23C20.
Aug 26, 2022
Ford Motor Company (Ford) is recalling certain 2017-2020 F-Super Duty F-250, F-350, F-450, and 2017-2020 Lincoln Continental vehicles equipped with the 360-degree camera system. Degradation of the camera's anit-reflective lens coating can lead to a foggy or cloudy rearview camera image.
Consequence & remedy
Consequence: Lack of a clear rearview camera image can reduce the driver's visibility of what is behind the vehicle, increasing the risk of a crash.
Remedy: Dealers will replace the rearview camera, free of charge. Owner notification letters were mailed July 14, 2023. Owners may contact Ford customer service at 1-800-1-866-436-7332. Ford's number for this recall is 22S51.
Apr 14, 2022
Ford Motor Company (Ford) is recalling certain 2020-2021 F-150, Expedition, 2020-2022 Super Duty F-250, F-350, F-450, F-550, and 2020-2021 Lincoln Navigator vehicles. The windshield wiper arms may break, causing the windshield wipers to fail.
Consequence & remedy
Consequence: Inoperative windshield wipers can reduce visibility in certain driving conditions, increasing the risk of a crash.
Remedy: Dealers will replace both front windshield wiper arms, free of charge. Interim owner notification letters, informing owners of the safety risk, were mailed on May 24, 2022. Remedy parts are expected to be available 3rd Quarter 2022. Owner notification letters were mailed on October 21, 2022. Owners may contact Ford customer service at 1-866-436-7332. Ford's number for this recall is 22S26.
Apr 14, 2022
Ford Motor Company (Ford) is recalling certain 2020 Super Duty F-250, F-350, F-450, and F-550 vehicles equipped with 6.7L diesel engines. A washer within the vehicle's transmission can disintegrate, causing metallic debris to become lodged in the 'Park' mechanism.
Consequence & remedy
Consequence: Debris lodged within the 'Park' mechanism may prevent the vehicle from achieving or holding 'Park,' increasing the risk of a vehicle rollaway and a crash.
Remedy: Dealers will replace a gearset within the transmission, free of charge. Owner notification letters were mailed on April 19, 2023. Owners may contact Ford customer service at 1-866-436-7332. Ford's number for this recall is 22S22.
Feb 16, 2022
Ford Motor Company (Ford) is recalling certain 2017-2022 F-250 and F-350 Super Duty vehicles equipped with gasoline engines and aluminum driveshafts. Underbody heat and noise insulators may loosen and contact the aluminum driveshaft, which could damage the driveshaft and cause it to fracture.
Consequence & remedy
Consequence: A fractured driveshaft can cause a loss of drive power, or a loss of vehicle control if the driveshaft contacts the ground. Additionally, unintended movement could occur while parked if the parking brake is not engaged. Any of these scenarios can increase the risk of a crash.
Remedy: Dealers will inspect and repair the driveshaft as necessary, and properly attach the underbody insulators, free of charge. Owner notification letters were mailed on April 7, 2022. Owners may contact Ford customer service at 1-866-436-7332. Ford's number for this recall is 22S09.
Additional source detail variants (2)
Structure:frame And Members:underbody Shields
Ford Motor Company (Ford) is recalling certain 2017-2022 F-250 and F-350 Super Duty vehicles equipped with gasoline engines and aluminum driveshafts. Underbody heat and noise insulators may loosen and contact the aluminum driveshaft, which could damage the driveshaft and cause it to fracture.
Consequence: A fractured driveshaft can cause a loss of drive power, or a loss of vehicle control if the driveshaft contacts the ground. Additionally, unintended movement could occur while parked if the parking brake is not engaged. Any of these scenarios can increase the risk of a crash.
Remedy: Dealers will inspect and repair the driveshaft as necessary, and properly attach the underbody insulators, free of charge. Owner notification letters were mailed on April 7, 2022. Owners may contact Ford customer service at 1-866-436-7332. Ford's number for this recall is 22S09.
Power Train:driveline:driveshaft
Ford Motor Company (Ford) is recalling certain 2017-2022 F-250 and F-350 Super Duty vehicles equipped with gasoline engines and aluminum driveshafts. Underbody heat and noise insulators may loosen and contact the aluminum driveshaft, which could damage the driveshaft and cause it to fracture.
Consequence: A fractured driveshaft can cause a loss of drive power, or a loss of vehicle control if the driveshaft contacts the ground. Additionally, unintended movement could occur while parked if the parking brake is not engaged. Any of these scenarios can increase the risk of a crash.
Remedy: Dealers will inspect and repair the driveshaft as necessary, and properly attach the underbody insulators, free of charge. Owner notification letters were mailed on April 7, 2022. Owners may contact Ford customer service at 1-866-436-7332. Ford's number for this recall is 22S09.
Mar 10, 2021
Ford Motor Company (Ford) is recalling certain 2018 F-150, 2018-2020 F-250, F-350, and 2019 Escape vehicles equipped with Continental tires. On the affected vehicles, it is possible that one or more tires were cured for too long during tire production.
Consequence & remedy
Consequence: Over cured tires may develop a break in the sidewall, resulting in sudden air loss or belt edge separation which could lead to tread/belt loss. Either condition can cause a loss of vehicle control, increasing the risk of a crash.
Remedy: Ford will notify owners, and dealers will inspect the tires, and replace them as necessary, free of charge. The recall began on March 27, 2021. Owners may contact Ford customer service at 1-866-436-7332. Ford's number for this recall is 21S10.
Feb 18, 2021
Ford Motor Company (Ford) is recalling certain 2021 F-150 and 2020-2021 F-250, F-350, F-450, and F-550 Super Duty vehicles. During manufacturing, the windshield may not have been properly bonded to the vehicle, allowing it to detach in a crash. As such, these vehicles fail to comply with the requirements of Federal Motor Vehicle Safety Standard (FMVSS) number 212, "Windshield Mounting."
Consequence & remedy
Consequence: In the event of a crash, if the windshield separates from the vehicle, it can increase the risk of injury.
Remedy: Ford will notify owners, and dealers will remove and reinstall the windshield, free of charge. The recall began April 16, 2021. Owners may contact Ford customer service at 1-866-436-7332. Ford's number for this recall is 21C06.
Additional source detail variants (2)
Visibility:windshield:critical Fasteners
Ford Motor Company (Ford) is recalling certain 2021 F-150 and 2020-2021 F-250, F-350, F-450, and F-550 Super Duty vehicles. During manufacturing, the windshield may not have been properly bonded to the vehicle, allowing it to detach in a crash. As such, these vehicles fail to comply with the requirements of Federal Motor Vehicle Safety Standard (FMVSS) number 212, "Windshield Mounting."
Consequence: In the event of a crash, if the windshield separates from the vehicle, it can increase the risk of injury.
Remedy: Ford will notify owners, and dealers will remove and reinstall the windshield, free of charge. The recall began April 16, 2021. Owners may contact Ford customer service at 1-866-436-7332. Ford's number for this recall is 21C06.
Visibility:windshield
Ford Motor Company (Ford) is recalling certain 2021 F-150 and 2020-2021 F-250, F-350, F-450, and F-550 Super Duty vehicles. During manufacturing, the windshield may not have been properly bonded to the vehicle, allowing it to detach in a crash. As such, these vehicles fail to comply with the requirements of Federal Motor Vehicle Safety Standard (FMVSS) number 212, "Windshield Mounting."
Consequence: In the event of a crash, if the windshield separates from the vehicle, it can increase the risk of injury.
Remedy: Ford will notify owners, and dealers will remove and reinstall the windshield, free of charge. The recall began April 16, 2021. Owners may contact Ford customer service at 1-866-436-7332. Ford's number for this recall is 21C06.
Sep 23, 2020
Ford Motor Company (Ford) is recalling certain 2020 Ford F-150, F-250, F-350, F-450, F-550, Explorer, Mustang, Transit, Expedition, Escape, Ranger and Edge, and Lincoln Nautilus and Corsair vehicles. Due to a poor electrical connection, the rearview camera may intermittently display a blank or distorted image. As such, these vehicles fail to comply with the requirements of Federal Motor Vehicle Safety Standard (FMVSS) number 111, "Rear Visibility."
Consequence & remedy
Consequence: Reduced rearward visibility can increase the risk of a crash.
Remedy: Ford will notify owners, and dealers will replace the rearview camera, free of charge. The recall began November 17, 2020. Remedy became available on February 1, 2021. Owner notification letters were mailed on February 1, 2021. Owners may contact Ford customer service at 1-866-436-7332. Ford's number for this recall is 20C19.
Jun 23, 2020
Ford Motor Company (Ford) is recalling certain 2020 Super-Duty F-250, F-350, and F-550 diesel pickups. The transmission torque converter damper plate was not tempered, resulting in a brittle damper plate that may fracture and cause the engine to stall or require increased brake pedal effort in order to stop the vehicle.
Consequence & remedy
Consequence: An engine stall or requiring additional braking effort to stop the vehicle can increase the risk of a crash.
Remedy: Ford will notify owners, and dealers will replace the transmission assembly, free of charge. This recall began July 6, 2020. Owners may contact Ford customer service at 1-866-436-7332. Ford's number for this recall is 20S33.
Additional source detail variants (2)
Power Train:automatic Transmission:torque Converter
Ford Motor Company (Ford) is recalling certain 2020 Super-Duty F-250, F-350, and F-550 diesel pickups. The transmission torque converter damper plate was not tempered, resulting in a brittle damper plate that may fracture and cause the engine to stall or require increased brake pedal effort in order to stop the vehicle.
Consequence: An engine stall or requiring additional braking effort to stop the vehicle can increase the risk of a crash.
Remedy: Ford will notify owners, and dealers will replace the transmission assembly, free of charge. This recall began July 6, 2020. Owners may contact Ford customer service at 1-866-436-7332. Ford's number for this recall is 20S33.
Power Train:automatic Transmission
Ford Motor Company (Ford) is recalling certain 2020 Super-Duty F-250, F-350, and F-550 diesel pickups. The transmission torque converter damper plate was not tempered, resulting in a brittle damper plate that may fracture and cause the engine to stall or require increased brake pedal effort in order to stop the vehicle.
Consequence: An engine stall or requiring additional braking effort to stop the vehicle can increase the risk of a crash.
Remedy: Ford will notify owners, and dealers will replace the transmission assembly, free of charge. This recall began July 6, 2020. Owners may contact Ford customer service at 1-866-436-7332. Ford's number for this recall is 20S33.
Model-level recall history does not show whether a particular VIN is affected or has received a repair. Check a VIN with NHTSA ↗
NHTSA investigations
3PE24014 · Sogefi Secondary Diesel Fuel Filter Leak
Opened May 9, 2024 · No close date supplied
Status: open (inferred from source dates) · Fuel System, Diesel; Fuel System, Other:fuel Filter
The Office of Defect Investigations (ODI) has received 27 complaints alleging diesel fuel leaks due to a fracture in the secondary fuel filter housing in model year (MY) 2015-2021 Ford Motor Company (Ford) F-250, 350, 450, and 550 Super Duty vehicles equipped with 6.7L diesel engines. Of these complaints, 12 describe an engine compartment fire. The proximity of the secondary fuel filter to high heat sources creates a potential for autoignition thermal events and fires. ODI has contacted the vehicle manufacturer, Ford, and the filter manufacturer, Allevard Sogefi USA (Sogefi), and learned that the low-pressure fuel system is capable of a maximum operating pressure of 8.5 Bar, while the secondary fuel filter is only tested to seven (7) Bar during the manufacturing process. Additionally, changes starting in 2022 by both Ford and Sogefi align with a lack of similar complaints on MY 2022 and newer vehicles. ODI is opening this Preliminary Evaluation (PE) to evaluate the severity of the potential problem and to fully assess the potential safety-related problems. To review the ODI reports cited in the Opening Resume ODI Report Identification Number document, go to NHTSA.gov.
Additional source detail variants (2)
Fuel System, Diesel
The Office of Defect Investigations (ODI) has received 27 complaints alleging diesel fuel leaks due to a fracture in the secondary fuel filter housing in model year (MY) 2015-2021 Ford Motor Company (Ford) F-250, 350, 450, and 550 Super Duty vehicles equipped with 6.7L diesel engines. Of these complaints, 12 describe an engine compartment fire. The proximity of the secondary fuel filter to high heat sources creates a potential for autoignition thermal events and fires. ODI has contacted the vehicle manufacturer, Ford, and the filter manufacturer, Allevard Sogefi USA (Sogefi), and learned that the low-pressure fuel system is capable of a maximum operating pressure of 8.5 Bar, while the secondary fuel filter is only tested to seven (7) Bar during the manufacturing process. Additionally, changes starting in 2022 by both Ford and Sogefi align with a lack of similar complaints on MY 2022 and newer vehicles. ODI is opening this Preliminary Evaluation (PE) to evaluate the severity of the potential problem and to fully assess the potential safety-related problems. To review the ODI reports cited in the Opening Resume ODI Report Identification Number document, go to NHTSA.gov.
Fuel System, Other:fuel Filter
The Office of Defect Investigations (ODI) has received 27 complaints alleging diesel fuel leaks due to a fracture in the secondary fuel filter housing in model year (MY) 2015-2021 Ford Motor Company (Ford) F-250, 350, 450, and 550 Super Duty vehicles equipped with 6.7L diesel engines. Of these complaints, 12 describe an engine compartment fire. The proximity of the secondary fuel filter to high heat sources creates a potential for autoignition thermal events and fires. ODI has contacted the vehicle manufacturer, Ford, and the filter manufacturer, Allevard Sogefi USA (Sogefi), and learned that the low-pressure fuel system is capable of a maximum operating pressure of 8.5 Bar, while the secondary fuel filter is only tested to seven (7) Bar during the manufacturing process. Additionally, changes starting in 2022 by both Ford and Sogefi align with a lack of similar complaints on MY 2022 and newer vehicles. ODI is opening this Preliminary Evaluation (PE) to evaluate the severity of the potential problem and to fully assess the potential safety-related problems. To review the ODI reports cited in the Opening Resume ODI Report Identification Number document, go to NHTSA.gov.
RQ21002 · Rearview Camera Fmvss 111 Noncompliance
Opened Aug 3, 2021 · No close date supplied
Status: open (inferred from source dates) · Back Over Prevention: Sensing System: Camera
On September 23, 2020, Ford Motor Company (Ford) filed a noncompliance recall report under 49 CFR Part 573 (NHTSA Recall No. 20V-575), recalling 620,246 Model Year (MY) 2020 Ford F-150, F-250, F-350, F-450, F-550, Explorer, Mustang, Transit, Expedition, Escape, Ranger and Edge, and Lincoln Nautilus and Corsair vehicles for a noncompliance with Federal Motor Vehicle Safety Standard (FMVSS) 111, Rear Visibility. Ford's recall described the noncompliance as insufficient electrical conductivity within the printed circuit board (PCB) internal to the camera leading to intermittent rearview camera operation. The supplier of the cameras was Magna Electronics.According to Ford's chronology in the Part 573, during the period February-April 2020, Ford identified and monitored warranty claims pertaining to intermittent or inoperative rearview cameras. Ford reviewed supplier product changes, focusing on changes introduced by the supplier in the October-November 2019 time frame. The Part 573 stated that the issue was brought to Ford's Critical Concerns Review Group (CCRG) for review on May 12, 2020.On July 7, 2020, NHTSA's Vehicle Research and Testing Center (VRTC) informed the Office of Defects Investigation (ODI) of a trend of MY 2020 Escape vehicles with rearview camera malfunctions. ODI contacted Ford the next day, providing five Vehicle Owner Questionnaires (VOQs) alleging inoperative rearview cameras. On July 15, 2020, Ford met with NHTSA to discuss the rearview camera issue. In a subsequent August 24, 2020 meeting, ODI and NHTSA's Office of Vehicle Safety Compliance (OVSC) met with Ford to discuss the recall status and additional VOQs. Ford presented rate and scope data for many of its MY 2020 products during the August 2020 meeting indicating high failure rates for certain models.This RQ is being opened to investigate both the timeliness and scope of Ford's rearview camera recall (20V-575), and Ford's compliance with reporting requirements.The subject reports referenced in the opening resume are identified by the following ODI reference numbers which can be reviewed at NHTSA.gov: 11349813, 11344126, 11342696, 11341486, 11340254, 11337274, 11331444, 11330875, 11329235, 11316960, 11343521, 11341884, 11337226, 11344018, and 11339573.
RQ21001 · Power Tailgate Release Systems
Opened Jan 15, 2021 · Closed Jan 10, 2024
Status: closed (inferred from source dates) · Structure:body:door ; Structure:body:tailgate ; Structure:body:tailgate:hinge And Attachments
In January 2021, the Office of Defects Investigation (ODI) opened a Recall Query (RQ21-001) to assess allegations of post-recall remedy uncommanded tailgate openings in model year (MY) 2017-2019 F-250/350/450 Ford trucks. Besides the recall remedy launched in January 2020, Ford also implemented a production update in November 2019. At the time of the RQ opening, ODI had received eleven (11) Vehicle Owner Questionnaires (VOQs). ODI sent an Information Request (IR) to Ford in February 2021. In numerous meetings after receiving their IR response, Ford highlighted the drop in claims since the recall and production update and communicated how they were unable to verify the owners’ complaints or replicate the concern. Despite this, Ford began developing ways to prevent uncommanded tailgate openings from various human, mechanical or electrical causes. Based on testing, Ford issued a Customer Satisfaction program, 21M05-S1/S2/S3, to further address the potential of unintended tailgate openings. This work was applied to vehicles being produced as of December 20, 2021. The program began for already delivered vehicles on July 22, 2022. The covered models include 2017-2022 F-250, 350, 450, 550, 650 and 750 Super Duty and 2020-2022 F-600 Super Duty trucks. ODI has received 39 VOQs between February 24, 2020, and December 15, 2023, alleging uncommanded tailgate openings. In a detailed analysis, none of the vehicles in the VOQs were found to have received the Customer Satisfaction update. Since ODI has not received any complaints of post-Customer Satisfaction program tailgate openings, this office is closing this Recall Query. The closing of this investigation does not constitute a finding by NHTSA that a safety-related defect does not exist. The Agency reserves the right to take additional action if warranted by future circumstances. To review the ODI reports cited in the Closing Resume ODI Report Identification Number document, go to NHTSA.gov.
Additional source detail variants (3)
Structure:body:door
In January 2021, the Office of Defects Investigation (ODI) opened a Recall Query (RQ21-001) to assess allegations of post-recall remedy uncommanded tailgate openings in model year (MY) 2017-2019 F-250/350/450 Ford trucks. Besides the recall remedy launched in January 2020, Ford also implemented a production update in November 2019. At the time of the RQ opening, ODI had received eleven (11) Vehicle Owner Questionnaires (VOQs). ODI sent an Information Request (IR) to Ford in February 2021. In numerous meetings after receiving their IR response, Ford highlighted the drop in claims since the recall and production update and communicated how they were unable to verify the owners’ complaints or replicate the concern. Despite this, Ford began developing ways to prevent uncommanded tailgate openings from various human, mechanical or electrical causes. Based on testing, Ford issued a Customer Satisfaction program, 21M05-S1/S2/S3, to further address the potential of unintended tailgate openings. This work was applied to vehicles being produced as of December 20, 2021. The program began for already delivered vehicles on July 22, 2022. The covered models include 2017-2022 F-250, 350, 450, 550, 650 and 750 Super Duty and 2020-2022 F-600 Super Duty trucks. ODI has received 39 VOQs between February 24, 2020, and December 15, 2023, alleging uncommanded tailgate openings. In a detailed analysis, none of the vehicles in the VOQs were found to have received the Customer Satisfaction update. Since ODI has not received any complaints of post-Customer Satisfaction program tailgate openings, this office is closing this Recall Query. The closing of this investigation does not constitute a finding by NHTSA that a safety-related defect does not exist. The Agency reserves the right to take additional action if warranted by future circumstances. To review the ODI reports cited in the Closing Resume ODI Report Identification Number document, go to NHTSA.gov.
Structure:body:tailgate
In January 2021, the Office of Defects Investigation (ODI) opened a Recall Query (RQ21-001) to assess allegations of post-recall remedy uncommanded tailgate openings in model year (MY) 2017-2019 F-250/350/450 Ford trucks. Besides the recall remedy launched in January 2020, Ford also implemented a production update in November 2019. At the time of the RQ opening, ODI had received eleven (11) Vehicle Owner Questionnaires (VOQs). ODI sent an Information Request (IR) to Ford in February 2021. In numerous meetings after receiving their IR response, Ford highlighted the drop in claims since the recall and production update and communicated how they were unable to verify the owners’ complaints or replicate the concern. Despite this, Ford began developing ways to prevent uncommanded tailgate openings from various human, mechanical or electrical causes. Based on testing, Ford issued a Customer Satisfaction program, 21M05-S1/S2/S3, to further address the potential of unintended tailgate openings. This work was applied to vehicles being produced as of December 20, 2021. The program began for already delivered vehicles on July 22, 2022. The covered models include 2017-2022 F-250, 350, 450, 550, 650 and 750 Super Duty and 2020-2022 F-600 Super Duty trucks. ODI has received 39 VOQs between February 24, 2020, and December 15, 2023, alleging uncommanded tailgate openings. In a detailed analysis, none of the vehicles in the VOQs were found to have received the Customer Satisfaction update. Since ODI has not received any complaints of post-Customer Satisfaction program tailgate openings, this office is closing this Recall Query. The closing of this investigation does not constitute a finding by NHTSA that a safety-related defect does not exist. The Agency reserves the right to take additional action if warranted by future circumstances. To review the ODI reports cited in the Closing Resume ODI Report Identification Number document, go to NHTSA.gov.
Structure:body:tailgate:hinge And Attachments
In January 2021, the Office of Defects Investigation (ODI) opened a Recall Query (RQ21-001) to assess allegations of post-recall remedy uncommanded tailgate openings in model year (MY) 2017-2019 F-250/350/450 Ford trucks. Besides the recall remedy launched in January 2020, Ford also implemented a production update in November 2019. At the time of the RQ opening, ODI had received eleven (11) Vehicle Owner Questionnaires (VOQs). ODI sent an Information Request (IR) to Ford in February 2021. In numerous meetings after receiving their IR response, Ford highlighted the drop in claims since the recall and production update and communicated how they were unable to verify the owners’ complaints or replicate the concern. Despite this, Ford began developing ways to prevent uncommanded tailgate openings from various human, mechanical or electrical causes. Based on testing, Ford issued a Customer Satisfaction program, 21M05-S1/S2/S3, to further address the potential of unintended tailgate openings. This work was applied to vehicles being produced as of December 20, 2021. The program began for already delivered vehicles on July 22, 2022. The covered models include 2017-2022 F-250, 350, 450, 550, 650 and 750 Super Duty and 2020-2022 F-600 Super Duty trucks. ODI has received 39 VOQs between February 24, 2020, and December 15, 2023, alleging uncommanded tailgate openings. In a detailed analysis, none of the vehicles in the VOQs were found to have received the Customer Satisfaction update. Since ODI has not received any complaints of post-Customer Satisfaction program tailgate openings, this office is closing this Recall Query. The closing of this investigation does not constitute a finding by NHTSA that a safety-related defect does not exist. The Agency reserves the right to take additional action if warranted by future circumstances. To review the ODI reports cited in the Closing Resume ODI Report Identification Number document, go to NHTSA.gov.
Illustration