NHTSA owner reports · September 18, 2026 snapshot.
Air Bags complaints
38 reportsClear category filter83,465 miles · May 3, 2023
Air BagsService Brakes, AirCrashInjury
The contact owns a 2018 Ford F-150. The contact stated that prior to the crash he had driven into some mud and the ABS and engine lights were illuminated. The contact stated that while driving in snow at approximately 40 mph, the accelerator pedal became stuck. The brake pedal was applied but failed to respond. The driver made…
Read full complaint
The contact owns a 2018 Ford F-150. The contact stated that prior to the crash he had driven into some mud and the ABS and engine lights were illuminated. The contact stated that while driving in snow at approximately 40 mph, the accelerator pedal became stuck. The brake pedal was applied but failed to respond. The driver made a sharp U-turn into a patch of grass and crashed into a fence, hydroplaned, and crashed into a dumpster. The contact sustained injuries to his back and neck that required medical attention. The passenger sustained unknown injuries and received medical attention. A police report was filed. There were no reported fires. The air bags did not deploy. The vehicle was towed to a collision center. The insurance company evaluated the vehicle and towed it to another repair shop. The local dealer was not contacted. The vehicle was not diagnosed or repaired. The contact called the manufacturer who referred him to the dealer for diagnostic testing, but no additional assistance was provided. The failure mileage was approximately 83,465.
NHTSA ODI #11520216
Mileage unknown · Jan 20, 2023
Air BagsCrashInjury
i WAS DRIVING AND SLID OFF THE ROAD AT A CORNER, WHEN I IMPACTED A TREE, THE AIRBAG DIDNT DEPLOY, ALTHOUGH THE VEHICLE IMMEDIATELY CALLED 911. CURERNTLY THE VEHICLE IS AT A CHEVY DEALER WAITING FOR INSURANCE TO FINALIZE PAPERWORK FOR A TOTAL LOSS. IT CAN BE INSPECTED IF REQUESTED. i CANNOT FIND SOMEONE TO LOOK AT THE FAILURE WIT…
Read full complaint
i WAS DRIVING AND SLID OFF THE ROAD AT A CORNER, WHEN I IMPACTED A TREE, THE AIRBAG DIDNT DEPLOY, ALTHOUGH THE VEHICLE IMMEDIATELY CALLED 911. CURERNTLY THE VEHICLE IS AT A CHEVY DEALER WAITING FOR INSURANCE TO FINALIZE PAPERWORK FOR A TOTAL LOSS. IT CAN BE INSPECTED IF REQUESTED. i CANNOT FIND SOMEONE TO LOOK AT THE FAILURE WITHOUT COST TO MYSELF. I FEEL THAT THE AIRBAG SHOULD HAVE DEPLOYED DUE TO THE FACT THAT THE BUMPER WAS SHOVED INTO THE ENGINE , AND THE FRONT OF THE VEHICLE WAS DESTROYED ON IMPACT. THE INSURANCE LOOKED AT VEHICLE, AND DID NOT FEEL THE AIRBAG DEPLOYMENT WAS WORTHY OF INVESTIGATING. THE POLICE DID NOT INSPECT ANYTHING. NO WARNING LAMPS OR SERVICE INDICATORS WERE LIT PRIOR TO IMPACT. I CONTACTED THE MANUFACTURER, AND THEY STATED ID HAVE TO TAKE THE VEHICLE TO A DEALER FOR DIAGNOSTIC. THE INSURANCE REFUSED TO SEND THE VEHICLE TO FORD. i HAVE NECK STRAIN AND PAIN AFTER THE ACCIDENT, AND FEEL THAT HAD IT DEPLOYED, I WOULD BE IN MUCH BETTER SHAPE. IF THE AIRBAG DEPLOYMENT IS SET TOO HIGH FOR IMPACTS, THEN THEY ARE USELESS TO PREVENT INJURY.
NHTSA ODI #11502734
Mileage unknown · Nov 1, 2022
Air BagsSteering
The steering wheel has cracked in the center area housing the AIR BAG and HORN. I believe this is a safety hazard. With the crack going over half of the way through the steering wheel, there is a chance of the AIR BAG DEPLOYING without cause.
NHTSA ODI #11491833
36,667 miles · Jun 22, 2022
Air BagsSeat BeltsCrash
The contact's husband owned a 2018 Ford F-150. The contact stated that while her husband was driving at 62 MPH, he hit the back of the semi-truck on the front driver which sent the vehicle to tailspin and caused her husband to hit the semi-truck for a second time. The second collision sent the vehicle into another tailspin befor…
Read full complaint
The contact's husband owned a 2018 Ford F-150. The contact stated that while her husband was driving at 62 MPH, he hit the back of the semi-truck on the front driver which sent the vehicle to tailspin and caused her husband to hit the semi-truck for a second time. The second collision sent the vehicle into another tailspin before coming to a complete halt. A police report was filed. According to the police department investigation, the airbag inflator had deployed which struck her husband's forehead. The investigation also determined that her husband's injuries were not consistent with proper airbag deployment. The report also noticed that both the air bag and air bag inflator were found on the floor near the rear passenger side seat. In addition, the report showed bruising constant with the lower lap belt locking but the driver did not have any bruising/burns from the upper seatbelt. The contact was pronounced dead on the scene and was taken to a moratorium. The vehicle was taken to an independent tow yard and deemed a total loss by insurance. The dealer nor the manufacturer had yet to be notified of the failure. The failure mileage was 36,667.
NHTSA ODI #11470483
Mileage unknown · Jun 17, 2022
Air BagsForward Collision AvoidanceSeat BeltsCrash
I had a front end collision with my truck. The damage was a direct hit on the airbag sensor, and my airbags nor my seatbelts deployed. I was going about 45 to 50. The pre-collision warning appeared right before I hit the vehicle but no automatic braking. The body shop that has my vehicle had safety concerns because my vehicle…
Read full complaint
I had a front end collision with my truck. The damage was a direct hit on the airbag sensor, and my airbags nor my seatbelts deployed. I was going about 45 to 50. The pre-collision warning appeared right before I hit the vehicle but no automatic braking. The body shop that has my vehicle had safety concerns because my vehicle took the brunt of the crash right on the airbag sensor. No airbags or anything deployed, but the sensor was broken in the accident. The concern is if the sensor was hit directly, why didn't it send a signal to through the system to deploy safety restraint systems. I called Ford to inform them of my concerns. After going through several people, I was finally given a case number CAS37213430 after days of trying to get them to take me seriously. They told me to take it to a Ford dealer to have it checked, but it is wrecked so how will they check it. My concern is that it didn't deploy the restraints because obviously wasn't working properly. I couldn't get all my pics to load so have more.
NHTSA ODI #11469732
Mileage unknown · Apr 6, 2022
Air BagsCrash
This vehicle was involved in an offset rear-end collision with a semi-trailer, with the driver's side making the primary impact. The crash resulted in the death of the driver and only occupant. Both the driver's airbag and left passenger curtain airbags deployed. During the police investigation of the crash, it was determined th…
Read full complaint
This vehicle was involved in an offset rear-end collision with a semi-trailer, with the driver's side making the primary impact. The crash resulted in the death of the driver and only occupant. Both the driver's airbag and left passenger curtain airbags deployed. During the police investigation of the crash, it was determined that the steering wheel-mounted airbag assembly completely dislodged from the steering wheel, with the airbag and its assembly being located in the rear floorboard post-impact. The driver sustained a head injury possibly consistent with the airbag assembly striking their forehead area. Two out of three of the plastic retaining tabs were found to have sheered off, likely leading to the airbag assembly being ejected from the steering wheel. Police investigators documented this incident with photographs and have taken the airbag assembly as evidence.
NHTSA ODI #11459916
Mileage unknown · Feb 12, 2022
Air BagsCrashInjury
02/08/2022 Complaint Airbag steering wheel assembly when deployed detached like a rocket into my face and then blew out the rear window i am assuming or it was from the collision. Front end collision into the wall of the 101 southbound fwy in Mesa arizona all airbags deployed. i suffered air bag burns and bruising and my glasses…
Read full complaint
02/08/2022 Complaint Airbag steering wheel assembly when deployed detached like a rocket into my face and then blew out the rear window i am assuming or it was from the collision. Front end collision into the wall of the 101 southbound fwy in Mesa arizona all airbags deployed. i suffered air bag burns and bruising and my glasses frame were broken in half cutting my right eye lid. My concern is the steering wheel airbag deployed and the whole steering wheel airbag assembly detached from the steering wheel struck my face and possibly blew out the rear window. My investigation when steering wheel air bag deploys the airbag assembly remains attached to the steering wheel. i uploaded pictures of steering wheel airbag assembly notice the back was melted. in the collision the battery was damaged and post was severed possibly saving me from a electrical fire.
NHTSA ODI #11451678
Mileage unknown · Feb 3, 2022
Air Bags
I pushed my horn and the cover that goes over horn and airbag broke/cracked. You are able to see the white from the airbag.
NHTSA ODI #11450256
Mileage unknown · Jan 5, 2022
Air BagsSteering
The steering wheel horn button, where the airbag is behind it, is cracked. This is the second time it’s cracked since I’ve on the vehicle. The first time it was fixed by Mike Castrucci Ford April 22, 2019. I actually spoke to someone at Kings Ford named Tricia just a couple of days ago, and she told me that it was not under warr…
Read full complaint
The steering wheel horn button, where the airbag is behind it, is cracked. This is the second time it’s cracked since I’ve on the vehicle. The first time it was fixed by Mike Castrucci Ford April 22, 2019. I actually spoke to someone at Kings Ford named Tricia just a couple of days ago, and she told me that it was not under warranty. I tried to explain to her that this has happened before when it was under warranty and fixed already, and this was the second time, but she refused to help me. It looks like it’s called the AB module - airbag on this invoice I’m holding. At times, it seems to leak some sort of liquid slightly from the cracks, and the horn does not always work when I push on the button itself. I have included a picture of the invoice when it was fixed once before, and I’ll try to include pictures I took today of the horn button.
NHTSA ODI #11446327
55,000 miles · Dec 30, 2021
Air BagsElectrical SystemFire
The contact owns a 2018 Ford F-150. The contact stated that while driving approximately 45 mph when the vehicle's side air bags on the driver-side, front and rear, suddenly deployed without impact. The contact then noticed that a small fire had sparked on the floorboard near their feet. The contact had pulled over to the side of…
Read full complaint
The contact owns a 2018 Ford F-150. The contact stated that while driving approximately 45 mph when the vehicle's side air bags on the driver-side, front and rear, suddenly deployed without impact. The contact then noticed that a small fire had sparked on the floorboard near their feet. The contact had pulled over to the side of the road where an observer was able to retrieve a fire extinguisher from their home and put out the fire. The contact was unable to verify if a fire report was made. There were no injuries. The vehicle was towed to the dealer who had not diagnosed or repaired the vehicle as of yet. The manufacturer was not made aware of the failure. The approximate failure mileage was 55,000.
NHTSA ODI #11445558
Official recalls
18Jun 9, 2026
Ford Motor Company (Ford) is recalling certain 2018-2020 F-150 vehicles previously repaired incorrectly under recall number 20V097. When the headlight switch is turned from "Autolamps" to "Headlamps On," the Daytime Running Lamps (DRLs) may remain fully bright instead of dimming to parking lamps as intended. As such, these vehicles fail to comply with the requirements of Federal Motor Vehicle Safety Standard (FMVSS) number 108, "Lamps, Reflective Devices and Associated Equipment."
Consequence & remedy
Consequence: Daytime Running Lamps that do not dim may reduce the visibility of other drivers, increasing the risk of a crash.
Remedy: ,Dealers will reprogram the body control module software, free of charge. Owner notification letters were mailed July 17, 2026. Owners may contact customer service at 1-866-436-7332. Ford's number for this recall is 26C28. Vehicle Identification Numbers (VINs) involved in this recall will become searchable on NHTSA.gov on July 6, 2026.
Jun 9, 2026
Ford Motor Company (Ford) is recalling certain 2018 F-150 vehicles previously repaired incorrectly under recall number 17V669. Quickly moving the shift lever from Park to Drive may cause a loss of gear indication on the instrument cluster display and a momentary selection of an unintended gear, such as Reverse or Neutral.
Consequence & remedy
Consequence: Unintended gear selection may cause the vehicle to move in an unexpected direction, increasing the risk of crash or injury.
Remedy: Dealers will update the powertrain control module software, free of charge. Owner notification letters were mailed July 9, 2026. Owners may contact customer service at 1-866-436-7332. Ford's number for this recall is 26S42. Vehicle Identification Numbers (VINs) involved in this recall will become searchable on NHTSA.gov on July 6, 2026.
Apr 11, 2025
Ford Motor Company (Ford) is recalling certain 2017-2018 F-150, Expedition, and Lincoln Navigator vehicles. The brake master cylinder may allow brake fluid to leak from the front wheel circuit into the brake booster.
Consequence & remedy
Consequence: A brake fluid leak can cause reduced brake function and extend the distance required to stop, increasing the risk of a crash.
Remedy: Dealers will replace the brake master cylinder. If the master cylinder is leaking, the brake booster will also be replaced. Repairs will be performed free of charge. Owner notification letters were mailed September 25, 2025. Owners may contact Ford customer service at 1-866-436-7332. Ford's number for this recall is 25S37. This recall is an expansion of NHTSA recall number 22V-150.
Additional source detail variants (2)
Service Brakes, Hydraulic:foundation Components:master Cylinder
Ford Motor Company (Ford) is recalling certain 2017-2018 F-150, Expedition, and Lincoln Navigator vehicles. The brake master cylinder may allow brake fluid to leak from the front wheel circuit into the brake booster.
Consequence: A brake fluid leak can cause reduced brake function and extend the distance required to stop, increasing the risk of a crash.
Remedy: Dealers will replace the brake master cylinder. If the master cylinder is leaking, the brake booster will also be replaced. Repairs will be performed free of charge. Owner notification letters were mailed September 25, 2025. Owners may contact Ford customer service at 1-866-436-7332. Ford's number for this recall is 25S37. This recall is an expansion of NHTSA recall number 22V-150.
Service Brakes, Hydraulic:power Assist
Ford Motor Company (Ford) is recalling certain 2017-2018 F-150, Expedition, and Lincoln Navigator vehicles. The brake master cylinder may allow brake fluid to leak from the front wheel circuit into the brake booster.
Consequence: A brake fluid leak can cause reduced brake function and extend the distance required to stop, increasing the risk of a crash.
Remedy: Dealers will replace the brake master cylinder. If the master cylinder is leaking, the brake booster will also be replaced. Repairs will be performed free of charge. Owner notification letters were mailed September 25, 2025. Owners may contact Ford customer service at 1-866-436-7332. Ford's number for this recall is 25S37. This recall is an expansion of NHTSA recall number 22V-150.
Nov 8, 2024
Ford Motor Company (Ford) is recalling certain 2020-2025 Explorer, Lincoln Aviator, 2020-2024 Escape, Lincoln Corsair, 2018-2024 F-150, Expedition and Lincoln Navigator vehicles. The air bag warning label may be missing from the dashboard. As such, these vehicles fail to comply with the requirement Federal Motor Vehicle Safety Standard number 208, "Occupant Crash Protection."
Consequence & remedy
Consequence: Without a label that shows the proper restraint usage guidelines, the occupants may have an increased risk of injury in the event of a crash.
Remedy: Ford will mail owners the warning labels, free of charge. Owner notification letters were mailed December 19, 2024. Owners may call Ford customer service at 1-866-436-7332. Ford's number for this recall is 24C39.
Mar 11, 2022
Ford Motor Company (Ford) is recalling certain 2016-2017 Ford Expedition, Lincoln Navigator, and 2016-2018 F-150 vehicles equipped with 3.5L Ecoboost engines. The brake master cylinder may allow brake fluid to leak from the front wheel circuit into the brake booster.
Consequence & remedy
Consequence: A loss of brake fluid may result in a change in brake pedal travel, increased pedal effort and reduced front brake function, requiring greater effort and distance to stop the vehicle. These conditions can increase the risk of a crash.
Remedy: Dealers will replace the brake master cylinder. If the master cylinder is leaking, the brake booster will also be replaced. Repairs will be performed free of charge. An interim owner notification letter notifying customers of the safety defect were mailed on April 29, 2022. Owner notification letters were mailed April 29, 2022. This recall is an expansion of NHTSA recall number 20V-332. Owners may contact Ford customer service at 1-866-436-7332. Ford's number for this recall is 22S11.
Additional source detail variants (2)
Service Brakes, Hydraulic:foundation Components:master Cylinder
Ford Motor Company (Ford) is recalling certain 2016-2017 Ford Expedition, Lincoln Navigator, and 2016-2018 F-150 vehicles equipped with 3.5L Ecoboost engines. The brake master cylinder may allow brake fluid to leak from the front wheel circuit into the brake booster.
Consequence: A loss of brake fluid may result in a change in brake pedal travel, increased pedal effort and reduced front brake function, requiring greater effort and distance to stop the vehicle. These conditions can increase the risk of a crash.
Remedy: Dealers will replace the brake master cylinder. If the master cylinder is leaking, the brake booster will also be replaced. Repairs will be performed free of charge. An interim owner notification letter notifying customers of the safety defect were mailed on April 29, 2022. Owner notification letters were mailed April 29, 2022. This recall is an expansion of NHTSA recall number 20V-332. Owners may contact Ford customer service at 1-866-436-7332. Ford's number for this recall is 22S11.
Service Brakes, Hydraulic:power Assist
Ford Motor Company (Ford) is recalling certain 2016-2017 Ford Expedition, Lincoln Navigator, and 2016-2018 F-150 vehicles equipped with 3.5L Ecoboost engines. The brake master cylinder may allow brake fluid to leak from the front wheel circuit into the brake booster.
Consequence: A loss of brake fluid may result in a change in brake pedal travel, increased pedal effort and reduced front brake function, requiring greater effort and distance to stop the vehicle. These conditions can increase the risk of a crash.
Remedy: Dealers will replace the brake master cylinder. If the master cylinder is leaking, the brake booster will also be replaced. Repairs will be performed free of charge. An interim owner notification letter notifying customers of the safety defect were mailed on April 29, 2022. Owner notification letters were mailed April 29, 2022. This recall is an expansion of NHTSA recall number 20V-332. Owners may contact Ford customer service at 1-866-436-7332. Ford's number for this recall is 22S11.
Dec 16, 2021
Ford Motor Company (Ford) is recalling certain 2018 F-150 vehicles with manual and power release tailgates. The tailgate latches may unlatch unexpectedly while driving.
Consequence & remedy
Consequence: Unexpected tailgate opening may allow unrestrained cargo to fall out of the truck bed and become a road hazard, increasing the risk of a crash.
Remedy: Dealers will replace the left-hand and right-hand tailgate latches, free of charge. An interim notification letter was mailed January 31, 2022. Owner notification letters were mailed on May 31, 2022. Owners may contact Ford customer service at 1-866-436-7332. Ford's number for this recall is 21S53.
Mar 10, 2021
Ford Motor Company (Ford) is recalling certain 2018 F-150, 2018-2020 F-250, F-350, and 2019 Escape vehicles equipped with Continental tires. On the affected vehicles, it is possible that one or more tires were cured for too long during tire production.
Consequence & remedy
Consequence: Over cured tires may develop a break in the sidewall, resulting in sudden air loss or belt edge separation which could lead to tread/belt loss. Either condition can cause a loss of vehicle control, increasing the risk of a crash.
Remedy: Ford will notify owners, and dealers will inspect the tires, and replace them as necessary, free of charge. The recall began on March 27, 2021. Owners may contact Ford customer service at 1-866-436-7332. Ford's number for this recall is 21S10.
Feb 21, 2020
Ford Motor Company (Ford) is recalling certain 2018-2020 F-150 trucks equipped with high series LED headlamps with Autolamp (On/Off) functionality. The Daytime Running Lamps (DRL) may remain activated instead of dimming to parking lamps when the Master Lighting Switch (MLS) is manually rotated from the "Autolamps" switch position to "Headlamps On." As such, these vehicles fail to comply with the requirements of Federal Motor Vehicle Safety Standard (FMVSS) number 108, "Lamps, Reflective Devices and Associated Equipment."
Consequence & remedy
Consequence: DRL that cannot dim may reduce the visibility of other drivers, increasing the risk of a crash.
Remedy: Ford will notify owners, and dealers will reprogram the body control module, free of charge. The recall began March 10, 2020. Owners may contact Ford customer service at 1-866-436-7332. Ford's number for this recall is 20C03.
Aug 28, 2019
Ford Motor Company (Ford) is recalling certain 2018-2020 F-150 and 2019-2020 F-250, F-350, F-450, and F-550 Super Duty pickup trucks, and 2018-2019 Ford Explorer, 2019-2020 Expedition, and 2020 Escape vehicles equipped with driver and/or passenger's manual front seat back recliner mechanisms. Also included are certain 2020 Ford Explorer and Lincoln Aviator vehicles equipped with rear outboard seats and manual seat back recliner mechanisms. The recliner mechanisms may be missing the third pawl required for seat back strength, resulting in a loose seat back. As such, these vehicles fail to comply with the requirements of Federal Motor Vehicle Safety Standard (FMVSS) numbers 202, "Head Restraints" and 207, "Seating Systems."
Consequence & remedy
Consequence: A seat back with an improperly assembled recliner mechanism may have reduced strength and may not adequately restrain an occupant in a crash, increasing the risk of injury.
Remedy: Ford will notify owners, and Ford and Lincoln dealers will inspect the seat structure and replace them, as necessary, free of charge. The recall began October 21, 2019. Owners may contact Ford customer service at 1-866-436-7332. Ford's number for this recall is 19C07.
Additional source detail variants (2)
Seats:mid/rear Assembly
Ford Motor Company (Ford) is recalling certain 2018-2020 F-150 and 2019-2020 F-250, F-350, F-450, and F-550 Super Duty pickup trucks, and 2018-2019 Ford Explorer, 2019-2020 Expedition, and 2020 Escape vehicles equipped with driver and/or passenger's manual front seat back recliner mechanisms. Also included are certain 2020 Ford Explorer and Lincoln Aviator vehicles equipped with rear outboard seats and manual seat back recliner mechanisms. The recliner mechanisms may be missing the third pawl required for seat back strength, resulting in a loose seat back. As such, these vehicles fail to comply with the requirements of Federal Motor Vehicle Safety Standard (FMVSS) numbers 202, "Head Restraints" and 207, "Seating Systems."
Consequence: A seat back with an improperly assembled recliner mechanism may have reduced strength and may not adequately restrain an occupant in a crash, increasing the risk of injury.
Remedy: Ford will notify owners, and Ford and Lincoln dealers will inspect the seat structure and replace them, as necessary, free of charge. The recall began October 21, 2019. Owners may contact Ford customer service at 1-866-436-7332. Ford's number for this recall is 19C07.
Seats:front Assembly:recliner
Ford Motor Company (Ford) is recalling certain 2018-2020 F-150 and 2019-2020 F-250, F-350, F-450, and F-550 Super Duty pickup trucks, and 2018-2019 Ford Explorer, 2019-2020 Expedition, and 2020 Escape vehicles equipped with driver and/or passenger's manual front seat back recliner mechanisms. Also included are certain 2020 Ford Explorer and Lincoln Aviator vehicles equipped with rear outboard seats and manual seat back recliner mechanisms. The recliner mechanisms may be missing the third pawl required for seat back strength, resulting in a loose seat back. As such, these vehicles fail to comply with the requirements of Federal Motor Vehicle Safety Standard (FMVSS) numbers 202, "Head Restraints" and 207, "Seating Systems."
Consequence: A seat back with an improperly assembled recliner mechanism may have reduced strength and may not adequately restrain an occupant in a crash, increasing the risk of injury.
Remedy: Ford will notify owners, and Ford and Lincoln dealers will inspect the seat structure and replace them, as necessary, free of charge. The recall began October 21, 2019. Owners may contact Ford customer service at 1-866-436-7332. Ford's number for this recall is 19C07.
Apr 8, 2019
Ford Motor Company (Ford) is recalling certain 2015-2019 Ford F-150 and 2017-2019 Ford F-250 Super Duty, F-350 Super Duty, F-450 Super Duty, and F-550 Super Duty pick-up trucks equipped with an engine block heater and previously remedied under recall 18V894. During the previous repair, the block heater cable's splice connector may have been damaged.
Consequence & remedy
Consequence: A damaged cable could cause a resistive short, increasing the risk of overheated or melted wiring, increasing the risk of a fire.
Remedy: Ford will notify owners, and dealers will disable the engine block heater from being used. When replacement cables become available, a second notice will be mailed and dealers will replace the engine block heater cord, free of charge. The recall began May 31, 2019. Owners may contact Ford customer service at 1-866-436-7332. Ford's number for this recall is 19S11.
Additional source detail variants (2)
Engine
Ford Motor Company (Ford) is recalling certain 2015-2019 Ford F-150 and 2017-2019 Ford F-250 Super Duty, F-350 Super Duty, F-450 Super Duty, and F-550 Super Duty pick-up trucks equipped with an engine block heater and previously remedied under recall 18V894. During the previous repair, the block heater cable's splice connector may have been damaged.
Consequence: A damaged cable could cause a resistive short, increasing the risk of overheated or melted wiring, increasing the risk of a fire.
Remedy: Ford will notify owners, and dealers will disable the engine block heater from being used. When replacement cables become available, a second notice will be mailed and dealers will replace the engine block heater cord, free of charge. The recall began May 31, 2019. Owners may contact Ford customer service at 1-866-436-7332. Ford's number for this recall is 19S11.
Equipment:electrical
Ford Motor Company (Ford) is recalling certain 2015-2019 Ford F-150 and 2017-2019 Ford F-250 Super Duty, F-350 Super Duty, F-450 Super Duty, and F-550 Super Duty pick-up trucks equipped with an engine block heater and previously remedied under recall 18V894. During the previous repair, the block heater cable's splice connector may have been damaged.
Consequence: A damaged cable could cause a resistive short, increasing the risk of overheated or melted wiring, increasing the risk of a fire.
Remedy: Ford will notify owners, and dealers will disable the engine block heater from being used. When replacement cables become available, a second notice will be mailed and dealers will replace the engine block heater cord, free of charge. The recall began May 31, 2019. Owners may contact Ford customer service at 1-866-436-7332. Ford's number for this recall is 19S11.
Dec 18, 2018
Ford Motor Company (Ford) is recalling certain 2015-2019 Ford F-150 and 2017-2019 Ford F-250 Super Duty, F-350 Super Duty, F-450 Super Duty, and F-550 Super Duty pick-up trucks equipped with an engine block heater. Water and contaminants may get into the block heater cable's splice connector causing corrosion and damage.
Consequence & remedy
Consequence: When the heater is plugged in, prolonged corrosion could cause a resistive short, increasing the risk of overheated or melted wiring which can increase the risk of a fire.
Remedy: Ford will notify owners, and dealers will disable the block heater cable, free of charge. Once parts are available, Dealers will replace the engine block heater cable, free of charge. The recall began June 3, 2019. Owners may contact Ford customer service at 1-866-436-7332. Ford's number for this recall is 18S45.
Aug 31, 2018
Ford Motor Company (Ford) is recalling certain 2015-2018 Ford F-150 Regular Cab and SuperCrew Cab vehicles. If a front seat belt pretensioner deploys as the result of a crash, the sparks may ignite materials such as carpeting or insulation within the B-pillar area.
Consequence & remedy
Consequence: A vehicle fire could result if materials ignite inside the vehicle.
Remedy: Ford will notify owners, and dealers will remove the B-pillar insulation material and wiring harness tape, and install heat resistant tape, free of charge. The recall began September 28, 2018. Owners may contact Ford customer service at 1-866-436-7332. Ford's number for this recall is 18S27.
Additional source detail variants (2)
Seat Belts:pretensioner
Ford Motor Company (Ford) is recalling certain 2015-2018 Ford F-150 Regular Cab and SuperCrew Cab vehicles. If a front seat belt pretensioner deploys as the result of a crash, the sparks may ignite materials such as carpeting or insulation within the B-pillar area.
Consequence: A vehicle fire could result if materials ignite inside the vehicle.
Remedy: Ford will notify owners, and dealers will remove the B-pillar insulation material and wiring harness tape, and install heat resistant tape, free of charge. The recall began September 28, 2018. Owners may contact Ford customer service at 1-866-436-7332. Ford's number for this recall is 18S27.
Structure:body:roof And Pillars
Ford Motor Company (Ford) is recalling certain 2015-2018 Ford F-150 Regular Cab and SuperCrew Cab vehicles. If a front seat belt pretensioner deploys as the result of a crash, the sparks may ignite materials such as carpeting or insulation within the B-pillar area.
Consequence: A vehicle fire could result if materials ignite inside the vehicle.
Remedy: Ford will notify owners, and dealers will remove the B-pillar insulation material and wiring harness tape, and install heat resistant tape, free of charge. The recall began September 28, 2018. Owners may contact Ford customer service at 1-866-436-7332. Ford's number for this recall is 18S27.
Jun 12, 2018
Ford Motor Company (Ford) is recalling certain 2018 Ford Expedition, F-150, and Lincoln Navigator vehicles equipped with 3.5L GTDI V6 engines. These vehicles have high pressure fuel pump assemblies with welds that can fracture, which may cause an oil or fuel leak.
Consequence & remedy
Consequence: A fuel leak in the presence of an ignition source may increase the risk of a fire.
Remedy: Ford will notify owners, and dealers will replace the high pressure fuel pump and associated components, free of charge. The recall began July 17, 2018. Owners may contact Ford customer service at 1-866-436-7332. Ford's number for this recall is 18S17.
Apr 4, 2018
Ford Motor Company (Ford) is recalling certain 2017-2018 Ford F-150 and 2018 Ford Expedition and Mustang and Lincoln Navigator vehicles equipped with 10-speed automatic transmissions. A roll pin may not have been installed in the transmission, potentially causing a loss of the "Park" function.
Consequence & remedy
Consequence: Despite the transmission shift lever being placed in 'Park' and the instrument panel display indicating 'Park,' the vehicle may roll away after it has been exited if the parking brake has not been applied, increasing the risk of injury or a crash.
Remedy: Ford will notify owners, and dealers will inspect the transmission to make sure it has the roll pin, installing one if it is missing, free of charge. The recall began on April 13, 2018. Owners may contact Ford customer service at 1-866-436-7332. Ford's number for this recall is 18S09.
Apr 4, 2018
Ford Motor Company (Ford) is recalling certain 2018 F-650 and F-750 vehicles equipped with 6-speed automatic transmissions and 2018 Ford F-150 and Expedition vehicles equipped with 10-speed automatic transmissions (excluding Expedition vehicles with a Rotary Gear Shift Dial on the console). The gear shift cable clip may not be properly seated, allowing the transmission to be in a different gear than indicated by the gear shift lever position.
Consequence & remedy
Consequence: If the gear shift cable clip becomes unseated or dislodged, the gear shift lever position may indicate that the transmission is in 'Park' when it may be in a different gear. Additionally, despite selecting 'Park', if the parking brake is not applied before the vehicle is exited, the vehicle may roll. Either scenario increases the risk of a crash.
Remedy: Ford will notify owners, and dealers will inspect the shift cable locking clip and properly seat it, if necessary, free of charge. The recall began on April 13, 2018. Owners may contact Ford customer service at 1-866-436-7332. Ford's number for the recall is 18S10.
Additional source detail variants (2)
Power Train:automatic Transmission:gear Position Indication (prndl)
Ford Motor Company (Ford) is recalling certain 2018 F-650 and F-750 vehicles equipped with 6-speed automatic transmissions and 2018 Ford F-150 and Expedition vehicles equipped with 10-speed automatic transmissions (excluding Expedition vehicles with a Rotary Gear Shift Dial on the console). The gear shift cable clip may not be properly seated, allowing the transmission to be in a different gear than indicated by the gear shift lever position.
Consequence: If the gear shift cable clip becomes unseated or dislodged, the gear shift lever position may indicate that the transmission is in 'Park' when it may be in a different gear. Additionally, despite selecting 'Park', if the parking brake is not applied before the vehicle is exited, the vehicle may roll. Either scenario increases the risk of a crash.
Remedy: Ford will notify owners, and dealers will inspect the shift cable locking clip and properly seat it, if necessary, free of charge. The recall began on April 13, 2018. Owners may contact Ford customer service at 1-866-436-7332. Ford's number for the recall is 18S10.
Power Train:automatic Transmission
Ford Motor Company (Ford) is recalling certain 2018 F-650 and F-750 vehicles equipped with 6-speed automatic transmissions and 2018 Ford F-150 and Expedition vehicles equipped with 10-speed automatic transmissions (excluding Expedition vehicles with a Rotary Gear Shift Dial on the console). The gear shift cable clip may not be properly seated, allowing the transmission to be in a different gear than indicated by the gear shift lever position.
Consequence: If the gear shift cable clip becomes unseated or dislodged, the gear shift lever position may indicate that the transmission is in 'Park' when it may be in a different gear. Additionally, despite selecting 'Park', if the parking brake is not applied before the vehicle is exited, the vehicle may roll. Either scenario increases the risk of a crash.
Remedy: Ford will notify owners, and dealers will inspect the shift cable locking clip and properly seat it, if necessary, free of charge. The recall began on April 13, 2018. Owners may contact Ford customer service at 1-866-436-7332. Ford's number for the recall is 18S10.
Oct 23, 2017
Ford Motor Company (Ford) is recalling certain 2018 F-150 vehicles equipped with a 3.3L engine, a 6-speed transmission and a column mounted shift lever. Quickly moving the shift lever from Park to Drive may cause a loss of gear indication on the instrument cluster display and a momentary selection of an unintended gear, such as Reverse or Neutral before the vehicle achieves Drive function.
Consequence & remedy
Consequence: Unidentified or unintended gear selection may cause the vehicle to move in a way that was not intended by the driver, increasing the risk of crash or injury.
Remedy: Ford will notify owners, and dealers will reprogram the powertrain control module, free of charge. Owners may contact Ford Customer Service at 1-866-436-7332. Ford's number for this recall is 17S35.
Additional source detail variants (2)
Power Train:automatic Transmission:lever And Linkage:column Shift
Ford Motor Company (Ford) is recalling certain 2018 F-150 vehicles equipped with a 3.3L engine, a 6-speed transmission and a column mounted shift lever. Quickly moving the shift lever from Park to Drive may cause a loss of gear indication on the instrument cluster display and a momentary selection of an unintended gear, such as Reverse or Neutral before the vehicle achieves Drive function.
Consequence: Unidentified or unintended gear selection may cause the vehicle to move in a way that was not intended by the driver, increasing the risk of crash or injury.
Remedy: Ford will notify owners, and dealers will reprogram the powertrain control module, free of charge. Owners may contact Ford Customer Service at 1-866-436-7332. Ford's number for this recall is 17S35.
Power Train:automatic Transmission:control Module (tcm/pcm/tecm)
Ford Motor Company (Ford) is recalling certain 2018 F-150 vehicles equipped with a 3.3L engine, a 6-speed transmission and a column mounted shift lever. Quickly moving the shift lever from Park to Drive may cause a loss of gear indication on the instrument cluster display and a momentary selection of an unintended gear, such as Reverse or Neutral before the vehicle achieves Drive function.
Consequence: Unidentified or unintended gear selection may cause the vehicle to move in a way that was not intended by the driver, increasing the risk of crash or injury.
Remedy: Ford will notify owners, and dealers will reprogram the powertrain control module, free of charge. Owners may contact Ford Customer Service at 1-866-436-7332. Ford's number for this recall is 17S35.
Oct 23, 2017
Ford Motor Company (Ford) is recalling certain 2018 F-150 vehicles equipped with 3.5L engines. The cylinder heads may have been machined without lubrication supply holes for the camshaft bearing journals.
Consequence & remedy
Consequence: Without a proper supply of lubrication, the engine will fail, causing a stall and increasing the risk of a crash.
Remedy: Ford is not aware of any affected vehicles outside of dealer control. Should owner contact subsequently be required, arrangements will be made to transport their vehicle to a Ford or Lincoln dealer to have the engine replaced.The recall began October 24, 2017. Owners may contact Ford customer service at 1-866-436-7332. Ford's number for this recall is 17S37.
Sep 25, 2017
Ford Motor Company (Ford) is recalling certain 2018 Ford F-150 Raptor Super Cab pick-up trucks not equipped with a moonroof. The structural roof braces may be missing rivets at the attachment of the roof rail, thereby reducing the structural integrity.
Consequence & remedy
Consequence: If the structural integrity is reduced, in the event of a rollover crash, there may be an increased risk of injury .
Remedy: Ford will notify owners, and dealers will install the rivets for the roof brace attachments, free of charge. The recall began October 17, 2017. Owners may contact Ford customer service at 1-866-436-7332. Ford's number for this recall is 17S29.
Model-level recall history does not show whether a particular VIN is affected or has received a repair. Check a VIN with NHTSA ↗
NHTSA investigations
2PE24019 · Low-pressure Fuel Pump Failure
Opened Jul 29, 2024 · Closed Sep 19, 2025
Status: closed (inferred from source dates) · Fuel System, Gasoline:delivery:fuel Pump
On July 29, 2024, the Office of Defects Investigation (ODI) opened PE24019 to investigate complaints of low-pressure fuel pump failures in MY 2021 Ford Bronco vehicles. Some consumers reported that the failure occurred without warning while driving, resulting in a complete loss of motive power with no ability to restart the engine. Ford determined that several other vehicle models contain low-pressure fuel pumps substantially similar to the 2021 Ford Bronco, including the 2022-2023 Ford Bronco, 2018-2023 Ford F-150, 2022-2023 Ford Expedition, 2019-2023 Lincoln Navigator, 2020-2023 Ford F-250-F-550, 2024 Ford Super Duty Chassis Cab, 2024-2025 Ford Ranger, 2020-2023 Ford Explorer, 2020-2023 Lincoln Aviator, and 2021-2025 Ford Mustang. ODI's investigation found that the affected vehicles may lose fuel pressure and flow from the fuel delivery module (consisting of a low-pressure fuel pump, jet pump, reservoir, and other parts) due to a low-pressure pump failure. This can cause the engine to stall while driving. The root cause is reduced internal clearance in the fuel pump, increasing friction and sensitivity to vapor lock. Fuel blockage from contamination inside the jet pump also contributed to the failure. Ford stated that the contamination source was unknown. On July 7, 2025, Ford filed recall 25V-455 for certain 2021-2023 Ford F-550 SD/F-450 SD/F-350 SD/F-250 SD, 2021-2022 Lincoln Navigator, 2021-2022 Ford Mustang, 2021-2022 Ford F-150, 2021-2023 Ford Explorer, 2022 Ford Expedition, and 2021-2023 Ford Bronco vehicles produced between July 1, 2021, and July 30, 2022. The recall also included certain 2021-2023 Lincoln Aviator produced between July 1, 2021, and December 21, 2022. Ford explained in its recall filingthat the production dates used for the recall were based on changes in the manufacturing process. Specifically, Ford determined that in June 2021, the supplier modified the jet pump manufacturing process, producing fuel pump chambers with a lower-than-specified internal clearance. In July 2022, the supplier implemented corrective actions to the manufacturing process by adding two additional vacuum pumps to reduce contamination during the production of the jet pump. ODI has identified approximately 1,000 reports involving vehicles covered in this investigation but excluded from recall 25V-455. However, even with such reports, these vehicles experienced comparatively lower failure rates than the vehicles that are subject to Recall 25V-455. Ford has explained that these vehicles were excluded from the recall population because they did not experience the manufacturing changes that prompted the recall. Specifically, according to Ford, vehicles built before July 1, 2021 (the recall production start date), were not affected by the supplier’s change to the jet pump manufacturing process. Even after closing this investigation, ODI will continue to monitor complaints for vehicles excluded from recall 25V-455 to consider whether they exhibit the same risks as the vehicles encompassed by the recall. The recall remedy is currently under development. In view of Ford’s recall action, ODI is closing this Preliminary Evaluation, but will continue to monitor the issue as a remedy is developed and implemented. ODI will take additional action if warranted by future circumstances. To review the reports cited in the Closing Resume ODI Report Identification Number document, go to NHTSA.gov.
PE18008 · Seatbelt Pretensioner Fire
Opened Aug 3, 2018 · Closed Dec 17, 2018
Status: closed (inferred from source dates) · Seat Belts:pretensioner
On June 18, 2018, the Office of Defects Investigations (ODI) opened a Preliminary Evaluation (PE18-008) to investigate complaints alleging post-crash fires at the B pillar in the area of the seat belt pretensioners on MY 2014-2018 Ford F-150 Regular Cab, and Super Crew Cab Vehicles. On August 24, 2018, Ford Motor Company recalled (FSA 18S27 - NHTSA #18V568) the affected population. Ford's investigation found that some front seat belt pretensioners may generate sparks during deployment in excess of Ford's specification. Sparks in the pretensioner exhaust gases inside the lower portion of the B-pillar may subsequently ignite combustible components contained in the B-pillar, such as insulation or carpet, and may cause a subsequent vehicle fire. ODI also requested relevant information from other manufacturers to assess the potential scope of post-crash pretensioner fires. Ford will notify owners and require dealers to remove B-pillar insulation material and wiring harness tape, and install heat resistant tape, free of charge. The recall notification began September 28, 2018.Owners may contact Ford customer service at 1-866-436-7332.The VOQs associated with the closing of this investigation are: 11143035, 11130056, 11129828, 11128761, 11127993, 11127880, 11124717, 11123419, 11119651, 11119626, 11114065, 11113160, 11111822, 11097937, 11078447, 11014688
Illustration