NHTSA owner reports · September 18, 2026 snapshot.
What owners actually said
1,437 reports111,000 miles · May 31, 2023
Power Train
The contact owns a 2017 Ford F-150. The contact stated that while driving at an undisclosed speed, the transmission failed to shift as designed and the vehicle failed to accelerate as needed. The check engine warning light was illuminated. The vehicle was taken to an independent mechanic, who determined that the transmission ne…
Read full complaint
The contact owns a 2017 Ford F-150. The contact stated that while driving at an undisclosed speed, the transmission failed to shift as designed and the vehicle failed to accelerate as needed. The check engine warning light was illuminated. The vehicle was taken to an independent mechanic, who determined that the transmission needed to be replaced. Upon investigation, the contact related the failure to NHTSA Campaign Number: 17V671000 (Power Train). The vehicle was not repaired. The manufacturer was notified of the failure, but a case was not opened. The contact was referred to the NHTSA Hotline. The failure mileage was 111,000.
NHTSA ODI #11524673
Mileage unknown · May 17, 2023
Power Train
The transmission downshifts when you are cruising along at higher speeds and then won't shift back up. It is jerky when it shifts. It turns over for an extended period when starting. A part has been ordered by the dealership since Sep 2022.
NHTSA ODI #11522510
Mileage unknown · May 13, 2023
Power TrainVehicle Speed Control
Dtc p0707 transmssion would go into limp mode while driving in the freeway at highway speeds and drop down to 20-30 mph almost got rear ended common issue on ford f150 with the 6r80 transmssion for the module lead frame recall but only for earlier built but this are also having issues sane transmission same concern
NHTSA ODI #11521852
Mileage unknown · May 12, 2023
Engine
We bought this 2017 Truck from a privately owned car lot and their mechanic said the truck passed all inspections. There was a little rattle when we bought it and brought it to the car lot owners attention and he still said everything is good with the truck. This truck has giving up problems since we bought it , 1 year ago. and …
Read full complaint
We bought this 2017 Truck from a privately owned car lot and their mechanic said the truck passed all inspections. There was a little rattle when we bought it and brought it to the car lot owners attention and he still said everything is good with the truck. This truck has giving up problems since we bought it , 1 year ago. and the rattling noise we just found out yesterday 5-12-23 that its a phaser. Has to do with the engine. Its a lot of money to fix it. The customer care service person at Ford told us this truck is maturious for the phaser issues. Ok, if this is happening to a lot of Ford trucks why is this not a recall.
NHTSA ODI #11521744
Mileage unknown · May 11, 2023
Engine
This F150 needs cam phasers replaced (local Ford dealer has diagnosed the problem) and there is a recall on other 2017 F150 VINS but for some reason my VIN isn't coming up with as this issue being covered by a recall. Ford recommended that I submit my VIN to be included. The recall is Customer Satisfaction Program 21N03 https://…
Read full complaint
This F150 needs cam phasers replaced (local Ford dealer has diagnosed the problem) and there is a recall on other 2017 F150 VINS but for some reason my VIN isn't coming up with as this issue being covered by a recall. Ford recommended that I submit my VIN to be included. The recall is Customer Satisfaction Program 21N03 https://static.nhtsa.gov/odi/tsbs/2021/MC-10204046-0001.pdf. Please add my VIN to this recall as my it is experiencing the cam phaser issue and should be included in it. Thank you for your consideration.
NHTSA ODI #11521597
Mileage unknown · May 6, 2023
Power TrainInjury
On April 28th, 2023 at approx. 1800 this Ford F-150 malfunctioned yet again. While traveling east on Interstate I-70 in a construction zone near Saint Clairsville, OHIO, this F-150 was set on cruise speed for the construction zone. This F-150 shifted from 8th gear down to 3rd gear. This uncommanded and unprompted change of sp…
Read full complaint
On April 28th, 2023 at approx. 1800 this Ford F-150 malfunctioned yet again. While traveling east on Interstate I-70 in a construction zone near Saint Clairsville, OHIO, this F-150 was set on cruise speed for the construction zone. This F-150 shifted from 8th gear down to 3rd gear. This uncommanded and unprompted change of speed injured my neck and nearly ended my family's life and the lives of others. The 18 wheeler carrying thousands of gallons of fuel behind me NEARLY clipped my rear end. As this change in speed was did not included BRAKE LIGHTS, because I did not hit my brake pedal. This F-150 is a danger to society and will certainly kill a construction worker, police officer, or any one near it. Perhaps it will take out a critical bridge or other important infrastructure????? I just hope it doesn't kill a presidential motorcade. This truck is a hazard. I am NOT in control of the truck at highway speed. I will not be accountable for the impending disaster this truck will cause. YOU ARE! This F-150 does have the 10R80 transmission, so you are aware of the danger. What are you going to do???? My son has name this truck "MURDER TRUCK", he fears riding in it. He refuses to risk his life in this F150. Please contact me NOW. [XXX]. The corvair was recalled for far less. Simply driving this....is the danger/hazard. I know you don't give a [XXX]. So [XXX] you for doing nothing. INFORMATION Redacted PURSUANT TO THE FREEDOM OF INFORMATION ACT (FOIA), 5 U.S.C. 552(B)(6).
NHTSA ODI #11520781
67,000 miles · May 4, 2023
Air Bags
The contact's boss owns a 2017 Ford F-150. The contact stated that over a year ago the vehicle was taken to the dealer due to the driver’s side air bag developing a crack over the steering wheel label. Additionally, the contact stated that after the vehicle was started, an alarm symbol indicating “Park Aid” was illuminated on th…
Read full complaint
The contact's boss owns a 2017 Ford F-150. The contact stated that over a year ago the vehicle was taken to the dealer due to the driver’s side air bag developing a crack over the steering wheel label. Additionally, the contact stated that after the vehicle was started, an alarm symbol indicating “Park Aid” was illuminated on the instrument panel. The vehicle was taken to the dealer where it was diagnosed that the air bag needed to be replaced. The vehicle was repaired; however, the failure recurred. The dealer was notified of the failure however, the vehicle was not diagnosed or repaired. The manufacturer was notified of the failure and the contact was informed that the failure was not covered under warranty. The contact was advised to call the NHTSA Hotline to file a complaint. The failure mileage was approximately 67,000.
NHTSA ODI #11520443
Mileage unknown · May 3, 2023
Power Train
So my 2017 F-150 keeps having transmission problems. I've been to the dealer 3 different times in the last 2 months. I took it in the first time for the control module malfunction and a bang from under the driver seat. The dealership came back to me with a quote for 11K worth of repairs. EBS control module was the problem not t…
Read full complaint
So my 2017 F-150 keeps having transmission problems. I've been to the dealer 3 different times in the last 2 months. I took it in the first time for the control module malfunction and a bang from under the driver seat. The dealership came back to me with a quote for 11K worth of repairs. EBS control module was the problem not the transmission. Drove the truck around 150-200 miles and took it back for the transmission issue again. They came back this time with oh it's the valve body of the transmission. That get's fixed. Have the truck back 3 weeks or so and the WRENCH light comes on, which is a problem with the powertrain. I will never own another FORD vehicle again. I'm the only owner of this truck. I've paid 10K out of pocket to get it fixed and it's still not fixed. Even though the light is on they say there weren't any codes for that. Mechanics aren't like they used to be. If the laptop doesn't tell them what to do they are clueless and have no idea what to do. Really Pissed Off Customer.
NHTSA ODI #11520302
Mileage unknown · May 2, 2023
Electrical System
The vehicle was purchased back in March and was parked in my driveway for about a month between uses. When I drove it again, I had the "Charging System Service Now" alert pop up on the screen. This was not present when we left the dealership, and they were not willing to help me solve the problem. I checked it with a code reader…
Read full complaint
The vehicle was purchased back in March and was parked in my driveway for about a month between uses. When I drove it again, I had the "Charging System Service Now" alert pop up on the screen. This was not present when we left the dealership, and they were not willing to help me solve the problem. I checked it with a code reader at home, but it did not generate any codes. I put the battery on a charger, but it was fully charged in 5 minutes. I took the vehicle to an auto parts store to have them check the battery and alternator, and everything checked out. The serpentine belt is not warn and the fuse for the alternator was still intact. We tried discharging the PCM, but that did not solve the problem either. I am asking around at a few mechanic shops for possible solutions to try and avoid taking it to the dealer.
NHTSA ODI #11519958
52,000 miles · Apr 28, 2023
Engine
The contact owns a 2017 Ford F-150. The contact stated that upon starting the vehicle, the vehicle made an abnormal rattling sound. The vehicle was taken to an independent mechanic, where it was diagnosed and determined that the cam phaser needed to be replaced. The contact stated that the failure was related to TSB Number: 21N0…
Read full complaint
The contact owns a 2017 Ford F-150. The contact stated that upon starting the vehicle, the vehicle made an abnormal rattling sound. The vehicle was taken to an independent mechanic, where it was diagnosed and determined that the cam phaser needed to be replaced. The contact stated that the failure was related to TSB Number: 21N03-S4. The dealer was notified of the failure and the contact was informed that he would be charged for the repair since the TSB had expired. The vehicle was not repaired. The manufacturer was notified of the failure and referred the contact to the NHTSA Hotline for assistance. The failure mileage was approximately 52,000.
NHTSA ODI #11519477
Official recalls
17Jun 9, 2026
Ford Motor Company (Ford) is recalling certain 2017 F-150 vehicles previously repaired incorrectly under recall number 17V053. The instrument cluster may lose power after initial vehicle start-up in cold ambient temperatures. Several gauges, including the transmission gear position indicator, may not illuminate. As such, these vehicles fail to comply with the requirements of Federal Motor Vehicle Safety Standard number 102, "Transmission Shift Lever Sequence, Starter Interlock, and Transmission Braking Effect."
Consequence & remedy
Consequence: An instrument cluster that fails to display critical safety information, such as gear position or warning lights, increases the risk of a crash or injury.
Remedy: Dealers will update the Instrument Panel Cluster Assembly (IPC) software, free of charge. Owner notification letters were mailed July 17, 2026. Owners may contact Ford customer service at 1-866-436-7332. Ford's number for this recall is 26C26. Vehicle Identification Numbers (VINs) involved in this recall will become searchable on NHTSA.gov on July 6, 2026.
Apr 14, 2026
Ford Motor Company (Ford) is recalling certain 2015-2017 F-150 vehicles. A loss of signal between the transmission range sensor and the powertrain control module can cause the transmission to unexpectedly downshift into second gear.
Consequence & remedy
Consequence: Unexpectedly downshifting into second gear may result in a loss of vehicle control, increasing the risk of a crash.
Remedy: Dealers will update the powertrain control module software, free of charge. Owner notification letters were mailed July 24, 2026. Owners may contact Ford customer service at 1-866-436-7332. Ford's number for this recall is 26S28. Vehicle Identification Numbers (VINs) involved in this recall became searchable on NHTSA.gov on April 15, 2026.
Apr 11, 2025
Ford Motor Company (Ford) is recalling certain 2017-2018 F-150, Expedition, and Lincoln Navigator vehicles. The brake master cylinder may allow brake fluid to leak from the front wheel circuit into the brake booster.
Consequence & remedy
Consequence: A brake fluid leak can cause reduced brake function and extend the distance required to stop, increasing the risk of a crash.
Remedy: Dealers will replace the brake master cylinder. If the master cylinder is leaking, the brake booster will also be replaced. Repairs will be performed free of charge. Owner notification letters were mailed September 25, 2025. Owners may contact Ford customer service at 1-866-436-7332. Ford's number for this recall is 25S37. This recall is an expansion of NHTSA recall number 22V-150.
Additional source detail variants (2)
Service Brakes, Hydraulic:foundation Components:master Cylinder
Ford Motor Company (Ford) is recalling certain 2017-2018 F-150, Expedition, and Lincoln Navigator vehicles. The brake master cylinder may allow brake fluid to leak from the front wheel circuit into the brake booster.
Consequence: A brake fluid leak can cause reduced brake function and extend the distance required to stop, increasing the risk of a crash.
Remedy: Dealers will replace the brake master cylinder. If the master cylinder is leaking, the brake booster will also be replaced. Repairs will be performed free of charge. Owner notification letters were mailed September 25, 2025. Owners may contact Ford customer service at 1-866-436-7332. Ford's number for this recall is 25S37. This recall is an expansion of NHTSA recall number 22V-150.
Service Brakes, Hydraulic:power Assist
Ford Motor Company (Ford) is recalling certain 2017-2018 F-150, Expedition, and Lincoln Navigator vehicles. The brake master cylinder may allow brake fluid to leak from the front wheel circuit into the brake booster.
Consequence: A brake fluid leak can cause reduced brake function and extend the distance required to stop, increasing the risk of a crash.
Remedy: Dealers will replace the brake master cylinder. If the master cylinder is leaking, the brake booster will also be replaced. Repairs will be performed free of charge. Owner notification letters were mailed September 25, 2025. Owners may contact Ford customer service at 1-866-436-7332. Ford's number for this recall is 25S37. This recall is an expansion of NHTSA recall number 22V-150.
Mar 11, 2022
Ford Motor Company (Ford) is recalling certain 2016-2017 Ford Expedition, Lincoln Navigator, and 2016-2018 F-150 vehicles equipped with 3.5L Ecoboost engines. The brake master cylinder may allow brake fluid to leak from the front wheel circuit into the brake booster.
Consequence & remedy
Consequence: A loss of brake fluid may result in a change in brake pedal travel, increased pedal effort and reduced front brake function, requiring greater effort and distance to stop the vehicle. These conditions can increase the risk of a crash.
Remedy: Dealers will replace the brake master cylinder. If the master cylinder is leaking, the brake booster will also be replaced. Repairs will be performed free of charge. An interim owner notification letter notifying customers of the safety defect were mailed on April 29, 2022. Owner notification letters were mailed April 29, 2022. This recall is an expansion of NHTSA recall number 20V-332. Owners may contact Ford customer service at 1-866-436-7332. Ford's number for this recall is 22S11.
Additional source detail variants (2)
Service Brakes, Hydraulic:foundation Components:master Cylinder
Ford Motor Company (Ford) is recalling certain 2016-2017 Ford Expedition, Lincoln Navigator, and 2016-2018 F-150 vehicles equipped with 3.5L Ecoboost engines. The brake master cylinder may allow brake fluid to leak from the front wheel circuit into the brake booster.
Consequence: A loss of brake fluid may result in a change in brake pedal travel, increased pedal effort and reduced front brake function, requiring greater effort and distance to stop the vehicle. These conditions can increase the risk of a crash.
Remedy: Dealers will replace the brake master cylinder. If the master cylinder is leaking, the brake booster will also be replaced. Repairs will be performed free of charge. An interim owner notification letter notifying customers of the safety defect were mailed on April 29, 2022. Owner notification letters were mailed April 29, 2022. This recall is an expansion of NHTSA recall number 20V-332. Owners may contact Ford customer service at 1-866-436-7332. Ford's number for this recall is 22S11.
Service Brakes, Hydraulic:power Assist
Ford Motor Company (Ford) is recalling certain 2016-2017 Ford Expedition, Lincoln Navigator, and 2016-2018 F-150 vehicles equipped with 3.5L Ecoboost engines. The brake master cylinder may allow brake fluid to leak from the front wheel circuit into the brake booster.
Consequence: A loss of brake fluid may result in a change in brake pedal travel, increased pedal effort and reduced front brake function, requiring greater effort and distance to stop the vehicle. These conditions can increase the risk of a crash.
Remedy: Dealers will replace the brake master cylinder. If the master cylinder is leaking, the brake booster will also be replaced. Repairs will be performed free of charge. An interim owner notification letter notifying customers of the safety defect were mailed on April 29, 2022. Owner notification letters were mailed April 29, 2022. This recall is an expansion of NHTSA recall number 20V-332. Owners may contact Ford customer service at 1-866-436-7332. Ford's number for this recall is 22S11.
Jun 8, 2020
Ford Motor Company (Ford) is recalling certain 2014-2017 F-150 pickup trucks equipped with 3.5L Ecoboost engines. The brake master cylinder may leak brake fluid into the brake booster.
Consequence & remedy
Consequence: A loss of brake fluid may result in a change in brake pedal travel and feel, increased pedal effort and reduced front brake function, possibly requiring greater effort and distance to stop the vehicle. These conditions can increase the risk of a crash.
Remedy: Ford will notify owners, and dealers will replace the brake master cylinder and inspect the brake booster, replacing it as necessary, free of charge. Ford issued owners an interim notification on June 30, 2020. The recall began on October 28, 2020. Owners may contact Ford customer service at 1-866-436-7332. Ford's number for this recall is 20S31.
Additional source detail variants (2)
Service Brakes, Hydraulic:foundation Components:master Cylinder
Ford Motor Company (Ford) is recalling certain 2014-2017 F-150 pickup trucks equipped with 3.5L Ecoboost engines. The brake master cylinder may leak brake fluid into the brake booster.
Consequence: A loss of brake fluid may result in a change in brake pedal travel and feel, increased pedal effort and reduced front brake function, possibly requiring greater effort and distance to stop the vehicle. These conditions can increase the risk of a crash.
Remedy: Ford will notify owners, and dealers will replace the brake master cylinder and inspect the brake booster, replacing it as necessary, free of charge. Ford issued owners an interim notification on June 30, 2020. The recall began on October 28, 2020. Owners may contact Ford customer service at 1-866-436-7332. Ford's number for this recall is 20S31.
Service Brakes, Hydraulic:power Assist
Ford Motor Company (Ford) is recalling certain 2014-2017 F-150 pickup trucks equipped with 3.5L Ecoboost engines. The brake master cylinder may leak brake fluid into the brake booster.
Consequence: A loss of brake fluid may result in a change in brake pedal travel and feel, increased pedal effort and reduced front brake function, possibly requiring greater effort and distance to stop the vehicle. These conditions can increase the risk of a crash.
Remedy: Ford will notify owners, and dealers will replace the brake master cylinder and inspect the brake booster, replacing it as necessary, free of charge. Ford issued owners an interim notification on June 30, 2020. The recall began on October 28, 2020. Owners may contact Ford customer service at 1-866-436-7332. Ford's number for this recall is 20S31.
Apr 8, 2019
Ford Motor Company (Ford) is recalling certain 2015-2019 Ford F-150 and 2017-2019 Ford F-250 Super Duty, F-350 Super Duty, F-450 Super Duty, and F-550 Super Duty pick-up trucks equipped with an engine block heater and previously remedied under recall 18V894. During the previous repair, the block heater cable's splice connector may have been damaged.
Consequence & remedy
Consequence: A damaged cable could cause a resistive short, increasing the risk of overheated or melted wiring, increasing the risk of a fire.
Remedy: Ford will notify owners, and dealers will disable the engine block heater from being used. When replacement cables become available, a second notice will be mailed and dealers will replace the engine block heater cord, free of charge. The recall began May 31, 2019. Owners may contact Ford customer service at 1-866-436-7332. Ford's number for this recall is 19S11.
Additional source detail variants (2)
Engine
Ford Motor Company (Ford) is recalling certain 2015-2019 Ford F-150 and 2017-2019 Ford F-250 Super Duty, F-350 Super Duty, F-450 Super Duty, and F-550 Super Duty pick-up trucks equipped with an engine block heater and previously remedied under recall 18V894. During the previous repair, the block heater cable's splice connector may have been damaged.
Consequence: A damaged cable could cause a resistive short, increasing the risk of overheated or melted wiring, increasing the risk of a fire.
Remedy: Ford will notify owners, and dealers will disable the engine block heater from being used. When replacement cables become available, a second notice will be mailed and dealers will replace the engine block heater cord, free of charge. The recall began May 31, 2019. Owners may contact Ford customer service at 1-866-436-7332. Ford's number for this recall is 19S11.
Equipment:electrical
Ford Motor Company (Ford) is recalling certain 2015-2019 Ford F-150 and 2017-2019 Ford F-250 Super Duty, F-350 Super Duty, F-450 Super Duty, and F-550 Super Duty pick-up trucks equipped with an engine block heater and previously remedied under recall 18V894. During the previous repair, the block heater cable's splice connector may have been damaged.
Consequence: A damaged cable could cause a resistive short, increasing the risk of overheated or melted wiring, increasing the risk of a fire.
Remedy: Ford will notify owners, and dealers will disable the engine block heater from being used. When replacement cables become available, a second notice will be mailed and dealers will replace the engine block heater cord, free of charge. The recall began May 31, 2019. Owners may contact Ford customer service at 1-866-436-7332. Ford's number for this recall is 19S11.
Dec 18, 2018
Ford Motor Company (Ford) is recalling certain 2015-2019 Ford F-150 and 2017-2019 Ford F-250 Super Duty, F-350 Super Duty, F-450 Super Duty, and F-550 Super Duty pick-up trucks equipped with an engine block heater. Water and contaminants may get into the block heater cable's splice connector causing corrosion and damage.
Consequence & remedy
Consequence: When the heater is plugged in, prolonged corrosion could cause a resistive short, increasing the risk of overheated or melted wiring which can increase the risk of a fire.
Remedy: Ford will notify owners, and dealers will disable the block heater cable, free of charge. Once parts are available, Dealers will replace the engine block heater cable, free of charge. The recall began June 3, 2019. Owners may contact Ford customer service at 1-866-436-7332. Ford's number for this recall is 18S45.
Aug 31, 2018
Ford Motor Company (Ford) is recalling certain 2015-2018 Ford F-150 Regular Cab and SuperCrew Cab vehicles. If a front seat belt pretensioner deploys as the result of a crash, the sparks may ignite materials such as carpeting or insulation within the B-pillar area.
Consequence & remedy
Consequence: A vehicle fire could result if materials ignite inside the vehicle.
Remedy: Ford will notify owners, and dealers will remove the B-pillar insulation material and wiring harness tape, and install heat resistant tape, free of charge. The recall began September 28, 2018. Owners may contact Ford customer service at 1-866-436-7332. Ford's number for this recall is 18S27.
Additional source detail variants (2)
Seat Belts:pretensioner
Ford Motor Company (Ford) is recalling certain 2015-2018 Ford F-150 Regular Cab and SuperCrew Cab vehicles. If a front seat belt pretensioner deploys as the result of a crash, the sparks may ignite materials such as carpeting or insulation within the B-pillar area.
Consequence: A vehicle fire could result if materials ignite inside the vehicle.
Remedy: Ford will notify owners, and dealers will remove the B-pillar insulation material and wiring harness tape, and install heat resistant tape, free of charge. The recall began September 28, 2018. Owners may contact Ford customer service at 1-866-436-7332. Ford's number for this recall is 18S27.
Structure:body:roof And Pillars
Ford Motor Company (Ford) is recalling certain 2015-2018 Ford F-150 Regular Cab and SuperCrew Cab vehicles. If a front seat belt pretensioner deploys as the result of a crash, the sparks may ignite materials such as carpeting or insulation within the B-pillar area.
Consequence: A vehicle fire could result if materials ignite inside the vehicle.
Remedy: Ford will notify owners, and dealers will remove the B-pillar insulation material and wiring harness tape, and install heat resistant tape, free of charge. The recall began September 28, 2018. Owners may contact Ford customer service at 1-866-436-7332. Ford's number for this recall is 18S27.
Apr 4, 2018
Ford Motor Company (Ford) is recalling certain 2017-2018 Ford F-150 and 2018 Ford Expedition and Mustang and Lincoln Navigator vehicles equipped with 10-speed automatic transmissions. A roll pin may not have been installed in the transmission, potentially causing a loss of the "Park" function.
Consequence & remedy
Consequence: Despite the transmission shift lever being placed in 'Park' and the instrument panel display indicating 'Park,' the vehicle may roll away after it has been exited if the parking brake has not been applied, increasing the risk of injury or a crash.
Remedy: Ford will notify owners, and dealers will inspect the transmission to make sure it has the roll pin, installing one if it is missing, free of charge. The recall began on April 13, 2018. Owners may contact Ford customer service at 1-866-436-7332. Ford's number for this recall is 18S09.
Oct 24, 2017
Ford Motor Company (Ford) is recalling certain 2017 F-150 vehicles equipped with ten-speed transmissions. The pin that attaches the transmission shift linkage to the transmission may come out, preventing the transmission from responding to movement of the shift lever.
Consequence & remedy
Consequence: The disconnected linkage may cause the vehicle to not move forward or backward as selected by the driver with the shift lever. Additionally, despite selecting 'Park', if the parking brake is not applied, the vehicle may roll. Either scenario increases the risk of a crash.
Remedy: Ford will notify owners, and dealers will replace the roll pin with an updated part, free of charge. The recall is expected to begin December 2017. Owners may contact Ford customer service at 1-866-436-7332. Ford's number for this recall is 17S36.
Additional source detail variants (2)
Power Train:automatic Transmission:lever And Linkage:floor Shift
Ford Motor Company (Ford) is recalling certain 2017 F-150 vehicles equipped with ten-speed transmissions. The pin that attaches the transmission shift linkage to the transmission may come out, preventing the transmission from responding to movement of the shift lever.
Consequence: The disconnected linkage may cause the vehicle to not move forward or backward as selected by the driver with the shift lever. Additionally, despite selecting 'Park', if the parking brake is not applied, the vehicle may roll. Either scenario increases the risk of a crash.
Remedy: Ford will notify owners, and dealers will replace the roll pin with an updated part, free of charge. The recall is expected to begin December 2017. Owners may contact Ford customer service at 1-866-436-7332. Ford's number for this recall is 17S36.
Power Train:automatic Transmission:lever And Linkage:column Shift
Ford Motor Company (Ford) is recalling certain 2017 F-150 vehicles equipped with ten-speed transmissions. The pin that attaches the transmission shift linkage to the transmission may come out, preventing the transmission from responding to movement of the shift lever.
Consequence: The disconnected linkage may cause the vehicle to not move forward or backward as selected by the driver with the shift lever. Additionally, despite selecting 'Park', if the parking brake is not applied, the vehicle may roll. Either scenario increases the risk of a crash.
Remedy: Ford will notify owners, and dealers will replace the roll pin with an updated part, free of charge. The recall is expected to begin December 2017. Owners may contact Ford customer service at 1-866-436-7332. Ford's number for this recall is 17S36.
Oct 16, 2017
Ford Motor Company (Ford) is recalling certain 2015-2017 Ford F-150, and 2017 F-250, F-350, F-450, and F-550 Super Duty trucks. The doors on these vehicles may have a bent or kinked actuation cable or the door latches may freeze after water gets into the latch. Either condition can result in the doors opening while driving although they appear to be closed.
Consequence & remedy
Consequence: A door that opens while driving can increase the risk of injury.
Remedy: Ford will notify owners, and dealers will inspect the door latch actuation cables and repair if necessary, and install water shields over the door latches, free of charge. The recall began October 12, 2018. Owners may contact Ford customer service at 1-866-436-7332. Ford's number for this recall is 17S33.
Sep 25, 2017
Ford Motor Company (Ford) is recalling certain 2017 Ford F-150, F-250, F-350, F-450, and F-550 trucks with manually-adjusted front passenger seats. The seat belt anchor may not be adequately welded to the seat cushion frame. As such, these vehicles fail to comply with the requirements of Federal Motor Vehicle Safety Standard (FMVSS) number 210, "Seat Belt Assembly Anchorages," and 207, "Seating Systems."
Consequence & remedy
Consequence: The seat belt buckle weld may fail, preventing the occupants from being properly restrained in the event of a crash, increasing the risk of injury.
Remedy: Ford will notify owners, and dealers will replace the front passenger manual seat track, free of charge. The recall is expected to begin November 6, 2017. Owners may contact Ford customer service at 1-866-436-7332. Ford's number for this recall is 17C17.
Additional source detail variants (2)
Seats
Ford Motor Company (Ford) is recalling certain 2017 Ford F-150, F-250, F-350, F-450, and F-550 trucks with manually-adjusted front passenger seats. The seat belt anchor may not be adequately welded to the seat cushion frame. As such, these vehicles fail to comply with the requirements of Federal Motor Vehicle Safety Standard (FMVSS) number 210, "Seat Belt Assembly Anchorages," and 207, "Seating Systems."
Consequence: The seat belt buckle weld may fail, preventing the occupants from being properly restrained in the event of a crash, increasing the risk of injury.
Remedy: Ford will notify owners, and dealers will replace the front passenger manual seat track, free of charge. The recall is expected to begin November 6, 2017. Owners may contact Ford customer service at 1-866-436-7332. Ford's number for this recall is 17C17.
Seat Belts:front:anchorage
Ford Motor Company (Ford) is recalling certain 2017 Ford F-150, F-250, F-350, F-450, and F-550 trucks with manually-adjusted front passenger seats. The seat belt anchor may not be adequately welded to the seat cushion frame. As such, these vehicles fail to comply with the requirements of Federal Motor Vehicle Safety Standard (FMVSS) number 210, "Seat Belt Assembly Anchorages," and 207, "Seating Systems."
Consequence: The seat belt buckle weld may fail, preventing the occupants from being properly restrained in the event of a crash, increasing the risk of injury.
Remedy: Ford will notify owners, and dealers will replace the front passenger manual seat track, free of charge. The recall is expected to begin November 6, 2017. Owners may contact Ford customer service at 1-866-436-7332. Ford's number for this recall is 17C17.
Aug 28, 2017
Ford Motor Company (Ford) is recalling certain 2015-2017 F-150, and 2017 F-250 and F-350 trucks equipped with a crew cab. The left rear inflatable seat belt buckle assembly may be inadequately attached to its mounting bracket. As such, these vehicles fail to comply with the requirements of Federal Motor Vehicle Safety Standard (FMVSS) number 210, "Seat Belt Assembly Anchorages."
Consequence & remedy
Consequence: If the left rear inflatable seat belt buckle separates from it's mounting bracket, the seat occupant may not be adequately restrained, increasing their risk of injury.
Remedy: Ford will notify owners, and dealers will inspect the seat belt assembly, replacing the attaching rivet as necessary, free of charge. Interim notices informing owners of the safety risk were mailed October 18, 2017. Owners will receive a second notice when the remedy becomes available. Owners may contact Ford Customer Service at 1-866-436-7332. Ford's number for this recall is 17C12.
Aug 28, 2017
Ford Motor Company (Ford) is recalling certain 2017 F-150 and Mustang vehicles. The air bag inflator within the passenger frontal air bag module may rupture in the event of a crash.
Consequence & remedy
Consequence: An inflator rupture may result in metal fragments striking the vehicle occupants resulting in serious injury or death.
Remedy: Ford will notify owners, and dealers will replace the passenger frontal air bag module, free of charge. The recall began October 11, 2017. Owners may contact Ford customer service at 1-866-436-7332. Ford's number for this recall is 17S26.
May 22, 2017
Ford Motor Company (Ford) is recalling certain 2015-2017 F-150, and 2017 F-250, F-350, F-450, and F-550 vehicles originally produced with black or body colored exterior door handles that may have been subsequently equipped with a chrome exterior door handle cover accessory kit purchased from a Ford dealer. These accessory door handle covers may cause the doors to unlatch in a side impact collision. As such, these vehicles may fail to comply with the requirements of Federal Motor Vehicle Safety Standard (FMVSS) number 206, "Door Locks and Door Retention Components."
Consequence & remedy
Consequence: If the doors unlatch and open in a side impact collision, the occupants have an increased risk of injury.
Remedy: Ford will notify owners, and dealers will remove the accessory covers and refund the purchase price. The recall began July 13, 2017. Owners may contact Ford at 1-866-436-7332. Ford's number for the recall is 17C09.
Additional source detail variants (2)
Latches/locks/linkages:doors:latch
Ford Motor Company (Ford) is recalling certain 2015-2017 F-150, and 2017 F-250, F-350, F-450, and F-550 vehicles originally produced with black or body colored exterior door handles that may have been subsequently equipped with a chrome exterior door handle cover accessory kit purchased from a Ford dealer. These accessory door handle covers may cause the doors to unlatch in a side impact collision. As such, these vehicles may fail to comply with the requirements of Federal Motor Vehicle Safety Standard (FMVSS) number 206, "Door Locks and Door Retention Components."
Consequence: If the doors unlatch and open in a side impact collision, the occupants have an increased risk of injury.
Remedy: Ford will notify owners, and dealers will remove the accessory covers and refund the purchase price. The recall began July 13, 2017. Owners may contact Ford at 1-866-436-7332. Ford's number for the recall is 17C09.
Structure:body:door
Ford Motor Company (Ford) is recalling certain 2015-2017 F-150, and 2017 F-250, F-350, F-450, and F-550 vehicles originally produced with black or body colored exterior door handles that may have been subsequently equipped with a chrome exterior door handle cover accessory kit purchased from a Ford dealer. These accessory door handle covers may cause the doors to unlatch in a side impact collision. As such, these vehicles may fail to comply with the requirements of Federal Motor Vehicle Safety Standard (FMVSS) number 206, "Door Locks and Door Retention Components."
Consequence: If the doors unlatch and open in a side impact collision, the occupants have an increased risk of injury.
Remedy: Ford will notify owners, and dealers will remove the accessory covers and refund the purchase price. The recall began July 13, 2017. Owners may contact Ford at 1-866-436-7332. Ford's number for the recall is 17C09.
May 22, 2017
Ford Motor Company (Ford) is recalling certain 2017 Ford Explorer, F-150, F-250, F-350, F-450 and F-550 vehicles equipped with a manual driver's seat back recliner mechanism. In the event of a crash, the seat back frame may not restrain the occupant due to having inadequate welds. As such, these vehicles may not meet the requirements of Federal Motor Vehicle Safety Standard (FMVSS) numbers 202a, "Head Restraints" and 207, "Seating Systems."
Consequence & remedy
Consequence: If the occupant is not adequately restrained in the event of a crash, they have an increased risk of injury.
Remedy: Ford will notify owners, and dealers will inspect and, if necessary, replace the seat back frame, free of charge. The recall began on June 7, 2017. Owners may contact Ford at 1-866-436-7332. Ford's number for this recall is 17C08.
Additional source detail variants (2)
Seats:front Assembly:recliner
Ford Motor Company (Ford) is recalling certain 2017 Ford Explorer, F-150, F-250, F-350, F-450 and F-550 vehicles equipped with a manual driver's seat back recliner mechanism. In the event of a crash, the seat back frame may not restrain the occupant due to having inadequate welds. As such, these vehicles may not meet the requirements of Federal Motor Vehicle Safety Standard (FMVSS) numbers 202a, "Head Restraints" and 207, "Seating Systems."
Consequence: If the occupant is not adequately restrained in the event of a crash, they have an increased risk of injury.
Remedy: Ford will notify owners, and dealers will inspect and, if necessary, replace the seat back frame, free of charge. The recall began on June 7, 2017. Owners may contact Ford at 1-866-436-7332. Ford's number for this recall is 17C08.
Seats
Ford Motor Company (Ford) is recalling certain 2017 Ford Explorer, F-150, F-250, F-350, F-450 and F-550 vehicles equipped with a manual driver's seat back recliner mechanism. In the event of a crash, the seat back frame may not restrain the occupant due to having inadequate welds. As such, these vehicles may not meet the requirements of Federal Motor Vehicle Safety Standard (FMVSS) numbers 202a, "Head Restraints" and 207, "Seating Systems."
Consequence: If the occupant is not adequately restrained in the event of a crash, they have an increased risk of injury.
Remedy: Ford will notify owners, and dealers will inspect and, if necessary, replace the seat back frame, free of charge. The recall began on June 7, 2017. Owners may contact Ford at 1-866-436-7332. Ford's number for this recall is 17C08.
Jan 24, 2017
Ford Motor Company (Ford) is recalling certain 2017 F-150 trucks equipped with an eight-inch productivity screen. In these vehicles, the instrument cluster may lose power after the initial vehicle start-up in cold ambient temperatures. Several gauges, including the transmission gear position indicator, may not illuminate. As such, these vehicles fail to comply with the requirements of Federal Motor Vehicles Safety Standard (FMVSS) number 102, "Transmission shift position sequence, starter interlock, and transmission braking effect."
Consequence & remedy
Consequence: If the transmission gear position indicator fails to illuminate, the driver may be unable to tell the transmission shift position, increasing the risk of a crash or injury from unintended vehicle movement.
Remedy: Ford will notify owners, and dealers will reprogram the instrument cluster, free of charge. The recall began February 20, 2017. Owners may contact Ford customer service at 1-866-436-7332. Ford's number for this recall is 17C01.
Additional source detail variants (2)
Electrical System: Instrument Cluster/panel
Ford Motor Company (Ford) is recalling certain 2017 F-150 trucks equipped with an eight-inch productivity screen. In these vehicles, the instrument cluster may lose power after the initial vehicle start-up in cold ambient temperatures. Several gauges, including the transmission gear position indicator, may not illuminate. As such, these vehicles fail to comply with the requirements of Federal Motor Vehicles Safety Standard (FMVSS) number 102, "Transmission shift position sequence, starter interlock, and transmission braking effect."
Consequence: If the transmission gear position indicator fails to illuminate, the driver may be unable to tell the transmission shift position, increasing the risk of a crash or injury from unintended vehicle movement.
Remedy: Ford will notify owners, and dealers will reprogram the instrument cluster, free of charge. The recall began February 20, 2017. Owners may contact Ford customer service at 1-866-436-7332. Ford's number for this recall is 17C01.
Power Train:automatic Transmission:gear Position Indication (prndl)
Ford Motor Company (Ford) is recalling certain 2017 F-150 trucks equipped with an eight-inch productivity screen. In these vehicles, the instrument cluster may lose power after the initial vehicle start-up in cold ambient temperatures. Several gauges, including the transmission gear position indicator, may not illuminate. As such, these vehicles fail to comply with the requirements of Federal Motor Vehicles Safety Standard (FMVSS) number 102, "Transmission shift position sequence, starter interlock, and transmission braking effect."
Consequence: If the transmission gear position indicator fails to illuminate, the driver may be unable to tell the transmission shift position, increasing the risk of a crash or injury from unintended vehicle movement.
Remedy: Ford will notify owners, and dealers will reprogram the instrument cluster, free of charge. The recall began February 20, 2017. Owners may contact Ford customer service at 1-866-436-7332. Ford's number for this recall is 17C01.
Model-level recall history does not show whether a particular VIN is affected or has received a repair. Check a VIN with NHTSA ↗
NHTSA investigations
3EA26001 · Unintended Transmission Downshift And Rear Wheel Lock-up
Opened Jan 30, 2026 · No close date supplied
Status: open (inferred from source dates) · Power Train:automatic Transmission:control Module (tcm/pcm/tecm)
On March 21, 2025, NHTSA’s Office of Defects Investigation (ODI) opened a Preliminary Evaluation (PE25002) to investigate instances of unexpected transmission downshifting without driver input in model year (MY) 2015-2017 Ford F-150 vehicles (subject vehicles) manufactured by Ford Motor Company (Ford). The complaints allege that, without warning or driver input, the subject vehicles experienced a sudden and rapid deceleration often accompanied by temporary rear wheel lockup, seizure, or skidding, resulting in a loss of vehicle control that increases the risk of crash and injury to all motorists, including those not within the subject vehicles. The MY 2015 and MY 2016 F-150 vehicles were equipped with the “6R80” transmission, while the MY 2017 vehicles were equipped with either the “6R80” transmission or the “10R80” transmission. This investigation was limited to MY 2015-2017 Ford F-150 with the “6R80” transmission. ODI identified 329 Vehicle Owners Questionnaires (VOQs) related to this investigation and sixty percent of these consumers were interviewed to confirm the details of their allegations. Consumers reported that their vehicles’ transmission suddenly downshifted to a lower gear, often to 1st or 2nd gear, without driver input or advance warning. Consumers described the downshift events to be regular and repeated occurrences, with some consumers stating that they no longer drive the vehicle due to safety concerns. Forty-three percent of consumers reported experiencing at least one wheel lockup event, during which the rear tires locked, screeched, or skidded during the transmission downshift. ODI also found that 114 of the 329 consumers reported having their vehicle’s molded lead frame or valve body assembly (which comes with a molded lead frame) replaced, 80 of which were confirmed through consumer submitted repair invoices. In its response to ODI’s Information Request, Ford provided an assessment of potential root cause of failure for the subject vehicles and how this failure is different from the failure associated with MY 2011-2014 Ford F-150 vehicles that was addressed by four safety recalls (16V-248, 19V-075, 19V-433, and 24V-444). Ford has identified that the defect in the recalled vehicle population involved lead frame supplier production issues resulting in signal loss from the Output Shaft Speed (OSS) sensor. Ford has identified that the alleged defect in the subject vehicle population involved degradation of electrical connections within the lead frame due to thermal cycling and vibration over extended time in service resulting in signal loss from the Transmission Range Sensor (TRS). Signal loss from the TRS can result in an unintended shift to neutral, unintended upshift, or unintended downshift which are regulated by a gear “shift map” based on the vehicle’s speed at the time of signal loss. According to Ford’s “shift map”, at speeds between 35-64 mph, the maximum allowable downshift would be to 2nd gear (i.e. a 6th to 2nd gear downshift event) which Ford has designated to represent the worst-case scenario for subject vehicles. Ford has also acknowledged that the worst-case scenario may also involve temporary wheel lockup. However, Ford has stated that the failure mechanism in the MY 2011-2014 F-150 vehicles—previously addressed through recalls—primarily involved OSS sensor signal loss that could result in 6th to 1st gear downshift events. This OSS-related failure mode is distinct from the TRS-related signal loss identified in the subject vehicle population. ODI has identified an additional potential safety defect associated with the alleged defect in the subject vehicles. Preliminary testing performed by NHTSA’s Vehicle Research Test Center (VRTC) showed that when the TRS experiences an intermittent signal loss, one possible outcome is a change in vehicle direction. Specifically, if a vehicle is operating in reverse up an incline when the TRS signal loss occurs, then the vehicle may shift into neutral causing the vehicle to change directions and roll forward. ODI is opening this Engineering Analysis (EA) to, among other things, perform component-level testing and vehicle testing, as well as review additional technical information to better understand the alleged defect that has been identified. To review the reports cited in the Opening Resume ODI Report Identification Number document, go to NHTSA.gov.
PE25002 · Unintended Transmission Downshift And Rear Wheel Lock-up
Opened Mar 21, 2025 · Closed Jan 30, 2026
Status: closed (inferred from source dates) · Power Train:automatic Transmission:control Module (tcm/pcm/tecm)
On March 21, 2025, NHTSA’s Office of Defects Investigation (ODI) opened this Preliminary Evaluation (PE25002) to investigate instances of unexpected transmission downshifting without driver input in model year (MY) 2015-2017 Ford F-150 vehicles (subject vehicles) manufactured by Ford Motor Company (Ford). The complaints allege that, without warning or driver input, the subject vehicles experienced a sudden and rapid deceleration often accompanied by temporary rear wheel lockup, seizure, or skidding, resulting in a loss of vehicle control that increases the risk of crash and injury to all motorists, including those not within the subject vehicles. The MY 2015 and MY 2016 F-150 vehicles were equipped with the “6R80” transmission, while the MY 2017 vehicles were equipped with either the “6R80” transmission or the “10R80” transmission. This investigation was limited to MY 2015-2017 Ford F-150 with the “6R80” transmission. ODI identified 329 Vehicle Owners Questionnaires (VOQs) related to this investigation and sixty percent of these consumers were interviewed to confirm the details of their allegations. Consumers reported that their vehicles’ transmission suddenly downshifted to a lower gear, often to 1st or 2nd gear, without driver input or advance warning. Consumers described the downshift events to be regular and repeated occurrences, with some consumers stating that they no longer drive the vehicle due to safety concerns. Forty-three percent of consumers reported experiencing at least one wheel lockup event, during which the rear tires locked, screeched, or skidded during the transmission downshift. ODI also found that 114 of the 329 consumers reported having their vehicle’s molded lead frame or valve body assembly (which comes with a molded lead frame) replaced, 80 of which were confirmed through consumer submitted repair invoices. In its response to ODI’s Information Request, Ford provided an assessment of potential root cause of failure for the subject vehicles and how this failure is different from the failure associated with MY 2011-2014 Ford F-150 vehicles that was addressed by four safety recalls (16V-248, 19V-075, 19V-433, and 24V-444). Ford has identified that the defect in the recalled vehicle population involved lead frame supplier production issues resulting in signal loss from the Output Shaft Speed (OSS) sensor. Ford has identified that the alleged defect in the subject vehicle population involved degradation of electrical connections within the lead frame due to thermal cycling and vibration over extended time in service resulting in signal loss from the Transmission Range Sensor (TRS). Signal loss from the TRS can result in an unintended shift to neutral, unintended upshift, or unintended downshift which are regulated by a gear “shift map” based on the vehicle’s speed at the time of signal loss. According to Ford’s “shift map”, at speeds between 35-64 mph, the maximum allowable downshift would be to 2nd gear (i.e. a 6th to 2nd gear downshift event) which Ford has designated to represent the worst-case scenario for subject vehicles. Ford has also acknowledged that the worst-case scenario may also involve temporary wheel lockup. However, Ford has stated that the failure mechanism in the MY 2011-2014 F-150 vehicles—previously addressed through recalls—primarily involved OSS sensor signal loss that could result in 6th to 1st gear downshift events. This OSS-related failure mode is distinct from the TRS-related signal loss identified in the subject vehicle population. ODI has identified an additional potential safety defect associated with the alleged defect in the subject vehicles. Preliminary testing performed by NHTSA’s Vehicle Research Test Center (VRTC) showed that when the TRS experiences an intermittent signal loss, one possible outcome is a change in vehicle direction. Specifically, if a vehicle is operating in reverse up an incline when the TRS signal loss occurs, then the vehicle may shift into neutral causing the vehicle to change directions and roll forward. Based on NHTSA’s analysis of consumer data, information provided by Ford, and preliminary testing conducted by NHTSA’s VRTC, this Preliminary Evaluation is being upgraded to an Engineering Analysis (EA26001). During this Engineering Analysis, the agency plans to, among other things, perform component-level testing and vehicle testing, as well as review additional technical information to better understand the alleged defect that has been identified from this Preliminary Evaluation. To review the reports cited in the Closing Resume ODI Report Identification Number document, go to NHTSA.gov.
PE18008 · Seatbelt Pretensioner Fire
Opened Aug 3, 2018 · Closed Dec 17, 2018
Status: closed (inferred from source dates) · Seat Belts:pretensioner
On June 18, 2018, the Office of Defects Investigations (ODI) opened a Preliminary Evaluation (PE18-008) to investigate complaints alleging post-crash fires at the B pillar in the area of the seat belt pretensioners on MY 2014-2018 Ford F-150 Regular Cab, and Super Crew Cab Vehicles. On August 24, 2018, Ford Motor Company recalled (FSA 18S27 - NHTSA #18V568) the affected population. Ford's investigation found that some front seat belt pretensioners may generate sparks during deployment in excess of Ford's specification. Sparks in the pretensioner exhaust gases inside the lower portion of the B-pillar may subsequently ignite combustible components contained in the B-pillar, such as insulation or carpet, and may cause a subsequent vehicle fire. ODI also requested relevant information from other manufacturers to assess the potential scope of post-crash pretensioner fires. Ford will notify owners and require dealers to remove B-pillar insulation material and wiring harness tape, and install heat resistant tape, free of charge. The recall notification began September 28, 2018.Owners may contact Ford customer service at 1-866-436-7332.The VOQs associated with the closing of this investigation are: 11143035, 11130056, 11129828, 11128761, 11127993, 11127880, 11124717, 11123419, 11119651, 11119626, 11114065, 11113160, 11111822, 11097937, 11078447, 11014688
Illustration