Tap a category to read its complaints. One report may name several components.
When problems were reported
Mileage at the reported incident
1120–25K
7225–50K
7550–75K
6175–100K
72100–150K
39150K+
431 reports with mileage · 57 unknown
NHTSA’s mileage field refers to the reported incident, not necessarily the filing date. This shows report counts, not the likelihood of a failure.
What to inspect
Issues worth paying extra attention to based on owner reports.
Engine. Review the 105 owner reports in this category and discuss these concerns during a pre-purchase inspection. Read reports →
Power Train. Review the 57 owner reports in this category and discuss these concerns during a pre-purchase inspection. Read reports →
Vehicle Speed Control. Review the 54 owner reports in this category and discuss these concerns during a pre-purchase inspection. Read reports →
NHTSA owner reports · September 18, 2026 snapshot.
40 crash reports13 fire reports29 injury reports
What owners actually said
488 reports
80,500 miles · Apr 16, 2017
Vehicle Speed Control
DURING SHIFTING ON STREETS AND HWY'S MY RPMS RAMP UP TO 3000-5000. I HAVE BEEN DRIVING WHILE MAINTAINING SPEED AND THEN THE RPMS WILL RAMP UP THEN THE SPEED STEADILY DROPS WHILE MY FOOT IS STILL ON THE ACCELERATOR. TURNING THE OVERDRIVE OFF SEEMS TO HELP OCCASIONALLY. I HAVE ALSO ATTEMPTED TO BRAKE AT LIGHTS AND THE RPMS WILL…
Read full complaint
DURING SHIFTING ON STREETS AND HWY'S MY RPMS RAMP UP TO 3000-5000. I HAVE BEEN DRIVING WHILE MAINTAINING SPEED AND THEN THE RPMS WILL RAMP UP THEN THE SPEED STEADILY DROPS WHILE MY FOOT IS STILL ON THE ACCELERATOR. TURNING THE OVERDRIVE OFF SEEMS TO HELP OCCASIONALLY. I HAVE ALSO ATTEMPTED TO BRAKE AT LIGHTS AND THE RPMS WILL RAMP UP AND LURCH FORWARD ALMOST CAUSING ME TO REAR END OTHER VEHICLES. THIS IS A MAJOR SAFETY CONCERN AND I DONT UNDERSTAND WHY FORD HASN'T ISSUED A RECALL AND ADDRESSED THIS SAFETY HAZARD. MY O/D LIGHT OCCASIONALLY FLASHES AND WHEN IN "PARK" THEN PUTTING THE GEAR IN "REVERSE" IT WOULDN'T OPERATE AND WHERE MY DIGITAL MILEAGE IS SAID "TRANS FAULT". I TURNED THE VEHICLE OFF, THEN BACK ON AND THE O/D WAS OFF AND WAS ABLE TO BACK UP. NONE OF MY WARNING LIGHTS HAVE COME ON AT ALL. OCCASIONALLY AT A STOP SIGN WHEN I ATTEMPT TO ACCELERATE THERE'S A DELAY IN MOVEMENT. SPEED VARIES AT TIMES OF INCIDENTS.
NHTSA ODI #10978690
170,000 miles · Feb 22, 2017
Engine
SPARK PLUG BLEW OUT OF HEAD.
NHTSA ODI #10956278
113,000 miles · Feb 8, 2017
Fuel/propulsion System
THE FUEL PUMP DRIVER MODULE, WHICH IS LOCATED EXTERNAL TO TANK MOUNTED ON FRAME, FAILED BECAUSE IT CORRODED THRU TO THE INSIDE OF UNIT. AT THE TIME OF FAILURE CAR WAS PARKED, BUT WHAT WOULD HAPPEN IF ON HIGHWAY AND FUEL PUMP STOPPED WORKING? FORD WOULD NOT REPLACE THE PART EVEN THOUGH THEY KNEW THERE WAS A PROBLEM BECAUSE IT WA…
Read full complaint
THE FUEL PUMP DRIVER MODULE, WHICH IS LOCATED EXTERNAL TO TANK MOUNTED ON FRAME, FAILED BECAUSE IT CORRODED THRU TO THE INSIDE OF UNIT. AT THE TIME OF FAILURE CAR WAS PARKED, BUT WHAT WOULD HAPPEN IF ON HIGHWAY AND FUEL PUMP STOPPED WORKING? FORD WOULD NOT REPLACE THE PART EVEN THOUGH THEY KNEW THERE WAS A PROBLEM BECAUSE IT WAS REDESIGNED WITH STAND-OFFS TO PREVENT DISSIMILAR METAL REACTION.
NHTSA ODI #10950347
130,000 miles · Feb 1, 2017
Electrical System
TRUCK WOULDN'T START. UPON FURTHER INSPECTION FOUND THE FUEL PUMP DRIVER MODULE FAILED DUE TO CORROSION. THE PART WAS BOLTED TO THE CROSS MEMBER ON THE BACK OF THE FRAME. THE BOTTOM OF THE PART IS ALUMINUM AND THE CROSS MEMBER IS STEEL, AND THEY WERE BOLTED FLUSH TOGETHER. REPLACED THE PART AND TRUCK WORKS FINE. I WOULD LIKE FOR…
Read full complaint
TRUCK WOULDN'T START. UPON FURTHER INSPECTION FOUND THE FUEL PUMP DRIVER MODULE FAILED DUE TO CORROSION. THE PART WAS BOLTED TO THE CROSS MEMBER ON THE BACK OF THE FRAME. THE BOTTOM OF THE PART IS ALUMINUM AND THE CROSS MEMBER IS STEEL, AND THEY WERE BOLTED FLUSH TOGETHER. REPLACED THE PART AND TRUCK WORKS FINE. I WOULD LIKE FORD TO ACKNOWLEDGE THAT THEY HAVE AN ISSUE WITH THIS AND REIMBURSE ALL PARTIES WHO HAVE HAD THIS PROBLEM.01
NHTSA ODI #10948952
89,000 miles · Jan 29, 2017
Engine
A SPARK PLUG BACKED OUT. STRIPPED THE THREADS IN THE HEAD. THIS HAPPENED WHILE DRIVING THE TRUCK. *TR
NHTSA ODI #10948357
156,779 miles · Jan 26, 2017
Power TrainService BrakesCrashInjury
PUT TRUCK IN REVERSE, IT SPED UP AND BRAKES DID NOT WORK. STOPPED BY BACKING INTO A TREE, THEN DROVE FINE. THREE DAYS LATER CAME TO AN INTERSECTION AND WAS UNABLE TO STOP. HIT ANOTHER VEHICLE IN THE INTERSECTION.
NHTSA ODI #10947736
70,000 miles · Jan 19, 2017
Structure
TL* THE CONTACT OWNS A 2007 FORD F-150. AFTER THE CONTACT GRABBED THE SAFETY HANDLE ON THE DRIVER'S SIDE DOOR, IT DETACHED FROM THE VEHICLE. THE VEHICLE WAS TAKEN TO THE DEALER WHERE IT WAS CONFIRMED THAT THE HANDLE DETACHED AND NEEDED TO BE REPLACED. THE VEHICLE WAS NOT REPAIRED. THE MANUFACTURER WAS NOT NOTIFIED OF THE FAILURE…
Read full complaint
TL* THE CONTACT OWNS A 2007 FORD F-150. AFTER THE CONTACT GRABBED THE SAFETY HANDLE ON THE DRIVER'S SIDE DOOR, IT DETACHED FROM THE VEHICLE. THE VEHICLE WAS TAKEN TO THE DEALER WHERE IT WAS CONFIRMED THAT THE HANDLE DETACHED AND NEEDED TO BE REPLACED. THE VEHICLE WAS NOT REPAIRED. THE MANUFACTURER WAS NOT NOTIFIED OF THE FAILURE. THE FAILURE MILEAGE WAS APPROXIMATELY 70,000.
NHTSA ODI #10946476
102,890 miles · Nov 2, 2016
Engine
TL* THE CONTACT OWNS A 2007 FORD F-150. WHILE DRIVING APPROXIMATELY 20 MPH, THERE WAS A KNOCKING NOISE COMING FROM THE ENGINE AND THE VEHICLE STALLED. THE VEHICLE WAS TOWED TO A DEALER WHERE IT WAS DIAGNOSED THAT THE NUMBER THREE SPARK PLUG DETACHED AND NEEDED TO BE REPLACED THE VEHICLE WAS REPAIRED. THE MANUFACTURER WAS MADE A…
Read full complaint
TL* THE CONTACT OWNS A 2007 FORD F-150. WHILE DRIVING APPROXIMATELY 20 MPH, THERE WAS A KNOCKING NOISE COMING FROM THE ENGINE AND THE VEHICLE STALLED. THE VEHICLE WAS TOWED TO A DEALER WHERE IT WAS DIAGNOSED THAT THE NUMBER THREE SPARK PLUG DETACHED AND NEEDED TO BE REPLACED THE VEHICLE WAS REPAIRED. THE MANUFACTURER WAS MADE AWARE OF THE FAILURE. THE FAILURE MILEAGE WAS APPROXIMATELY 102,890. UPDATED 08/09/17*LJ *CN
NHTSA ODI #10923845
50,000 miles · Oct 31, 2016
Engine
CRACKED OR WARPED EXHAUST MANIFOLD. I'VE HAD IT LOOKED AT BY TWO AUTO MECHANICS AND HAVE READ ONLINE WITH THIS WIDESPREAD PROBLEM.
NHTSA ODI #10920158
130,000 miles · Sep 9, 2016
Engine
WHILE DRIVING MY TRUCK SUDDENLY LOST POWER AND SHIFTED INTO "LIMP HOME MODE" WHILE THE WRENCH AND CHECK ENGINE LIGHT CAME ON. THIS HAPPENED TO ME A FEW YEAR BACK AS WELL SO I IMMEDIATELY ASSUMED IT WAS THE THROTTLE BODY OR SENSOR GOING BAD. I BROUGHT INTO THE FORD DEALERSHIP WHO CONFIRMED TO ME IT WAS THE THROTTLE BODY THAT WE…
Read full complaint
WHILE DRIVING MY TRUCK SUDDENLY LOST POWER AND SHIFTED INTO "LIMP HOME MODE" WHILE THE WRENCH AND CHECK ENGINE LIGHT CAME ON. THIS HAPPENED TO ME A FEW YEAR BACK AS WELL SO I IMMEDIATELY ASSUMED IT WAS THE THROTTLE BODY OR SENSOR GOING BAD. I BROUGHT INTO THE FORD DEALERSHIP WHO CONFIRMED TO ME IT WAS THE THROTTLE BODY THAT WENT OUT. THIS IS NOW THE 3 THROTTLE BODY THAT MY TRUCK HAD HAD (9 YEARS OLD AND 130,000 MILES). AFTER DOING RESEARCH I SAW WHERE FORD HAD THIS SAME ISSUE WITH OTHER MODEL VEHICLES AND INSTEAD OF RECALLING EXTENDED WARRANTIES TO COVER THE COST OF REPLACEMENT. THIS IS EXTREMELY DANGEROUS AS IF IT OCCURS WHEN MERGING INTO TRAFFIC YOU LOSE ALL ABILITY TO ACCELERATE. I THINK FORD HAS A MAJOR ISSUE HERE THAT IT IS REFUSING TO ADDRESS.
ROUSH IS RECALLING 213 MY 2007-2008 FORD F-150 TRUCKS ALTERED TO OPERATE USING LIQUID PROPANE INJECTION. THE HYDRO-CARBON PAPER AFFIXED TO THE INSIDE OF THE AIRBOX LID WITH ADHESIVE MAY BECOME DISLODGED DURING OPERATION.
Consequence & remedy
Consequence: THIS FAILURE MAY RESULT IN A LOSS OF PERFORMANCE, ILLUMINATION OF THE MALFUNCTION INDICATOR LAMP (MIL) AND, IN EXTREME CASES, A STALLING OF THE VEHICLE DURING OPERATION WITHOUT NOTICE, WHICH COULD RESULT IN A CRASH.
Remedy: DEALERS WILL REPLACE THE AIRBOX LID WITH A NEW ONE THAT INCLUDES THE HYDRO-CARBON PAPER WHICH HAS BEEN AFFIXED USING AN ADHESIVE PROMOTER AND GREATER PRESSURE AS RECOMMENDED BY THE MANUFACTURER FREE OF CHARGE. THE RECALL BEGAN ON OCTOBER 21, 2008. OWNERS MAY CONTACT ROUSH AT 1-866-307-6788.
ON CERTAIN TRUCKS BUILT WITH 26 GALLON FUEL TANKS, THE FUEL TANK MAY HAVE A DEPRESSION AT THE SEAM BETWEEN THE TOP AND BOTTOM HALVES OF THE TANK (NOT VISIBLE FROM OUTSIDE THE FUEL TANK). IF A DEPRESSION IS LARGE ENOUGH, FUEL MAY PERMEATE THE FUEL TANK WALL RESULTING IN A FUEL ODOR, OR A "SERVICE ENGINE SOON" INDICATOR LIGHT.
Consequence & remedy
Consequence: IF LEFT UNCORRECTED, A FUEL LEAK COULD EVENTUALLY DEVELOP. A FUEL LEAK IN THE PRESENCE OF AN IGNITION SOURCE COULD RESULT IN A FIRE.
Remedy: DEALERS WILL REPLACE THE FUEL TANK FREE OF CHARGE. THE RECALL BEGAN ON JUNE 25, 2007. OWNERS MAY CONTACT FORD AT 1-866-436-7332.
Model-level recall history does not show whether a particular VIN is affected or has received a repair. Check a VIN with NHTSA ↗
NHTSA investigations
1
PE08060 · Tire Valve Cracking
Opened Oct 14, 2008 · Closed Apr 9, 2009
Status: closed (inferred from source dates) · Tires:valve
ON OCTOBER 14, 2008, ODI OPENED PE08-060 TO INVESTIGATE ALLEGATIONS OF CRACKED AND LEAKING SNAP-IN TIRE VALVES IN MODEL YEAR (MY) 2007 VEHICLES MANUFACTURED BY FORD MOTOR COMPANY.THE VALVES WERE SUPPLIED TO FORD BY TOPSEAL AUTO-PARTS, A SUBSIDIARY OF THE SHANGHAI BAOLONG AUTOMOTIVE CORPORATION IN CHINA.VALVES MADE BY TOPSEAL FOR AFTERMARKET SALE WERE THE SUBJECT OF TWO RECENT SAFETY RECALLS BY TECH INTERNATIONAL (08T-018) AND DILL AIR CONTROLS (08T-028), THE LATTER OF WHICH WAS INVESTIGATED BY ODI IN PE08-036 AND EA08-022.THE DEFECT CONDITIONS ADDRESSED BY THE AFTERMARKET TIRE VALVE RECALLS BOTH INVOLVED INADEQUATE RESISTANCE TO OZONE CRACKING DUE TO ISSUES WITH THE SUPPLY OF ANTI-OZONANT CHEMICALS TO TOPSEAL FOR A PERIOD FROM JULY TO MID-NOVEMBER 2006.THE AFTERMARKET VALVES WERE COMPOUNDED WITH A BLEND OF EPDM AND NATURAL RUBBER, USING A RELATIVELY LOW PERCENTAGE OF EPDM (EPDM PROVIDES INHERENT RESISTANCE TO OZONE CRACKING).HENCE, THE NEED FOR ANTI-OZONANT CHEMICALS AND THE PROBLEMS WITH CRACKING WHEN THOSE CHEMICALS WERE MISSING OR OUT OF SPECIFICATION IN SOME LOTS OF VALVES.BOTH RECALL CAMPAIGNS INVOLVED INSPECTION PROGRAMS TO IDENTIFY AND REPLACE VALVES WITH VISIBLE SURFACE CRACKING.ALTHOUGH THE TOPSEAL VALVES SUPPLIED TO FORD ALSO APPEAR TO HAVE BEEN AFFECTED BY THE ANTI-OZONANT SUPPLY ISSUES IN MID TO LATE-2006, FORD INDICATED THAT ITS VALVES WERE MADE AT A DIFFERENT TOPSEAL PRODUCTION LINE AND WERE COMPOUNDED WITH A HIGHER PERCENTAGE OF EPDM RUBBER TO MEET MORE STRINGENT SPECIFICATIONS FROM FORD.ODI'S ANALYSIS OF COMPLAINT AND WARRANTY DATA PROVIDED BY FORD SHOWED THAT PROBLEMS WITH CRACKED TIRE VALVES WERE SIGNIFICANTLY HIGHER FOR MY 2007 VEHICLES PRODUCED FROM DECEMBER 2006 THROUGH MARCH 2007.FORD RESPONDED BY IMPLEMENTING CHANGES IN ITS MATERIAL SPECIFICATIONS FOR SNAP-IN RUBBER TIRE VALVES AND ALSO INCREASING THE QUALITY AND ACCEPTANCE STANDARDS FOR VALVES IMPORTED FOR USE IN ITS VEHICLES.WHILE THE COMPLAINT AND WARRANTY CLAIM RATES ARE ELEVATED FOR SUBJECT VEHICLES PRODUCED FROM DECEMBER 2006 THROUGH MARCH 2007, THE RATES OF LEAKING VALVES ARE WELL BELOW ONE PERCENT OF PRODUCTION FOR EACH OF THE PEAK MONTHS FOR ALL OF THE AFFECTED MODELS.A SUBSTANTIAL MAJORITY OF THE SUBJECT VEHICLES ARE EQUIPPED WITH TIRE PRESSURE MONITORING SYSTEMS (TPMS) WHICH WARN THE DRIVER WHEN ANY TIRE PRESSURES DROPS BELOW 25 PERCENT OF RECOMMENDED INFLATION PRESSURE. AS OUTLINED IN A LETTER TO ODI DATED APRIL 6, 2009, FORD HAS AGREED TO SEND LETTERS TO OWNERS OF CERTAIN MY 2007 AND 2008 FORD, LINCOLN AND MERCURY VEHICLES TO PROVIDE INFORMATION ABOUT THE CRACKING CONCERN. LETTERS WILL BE SENT TO OWNERS OF VEHICLES BUILT FROM NOVEMBER 2006 THROUGH MAY 2007.OWNERS CAN OPT FOR A FREE DEALER INSPECTION.VALVES EXHIBITING SURFACE CRACKS OR AIR LEAKAGE RELATED TO OZONE ATTACK WILL BE REPLACED BY FORD UNDER ITS NORMAL WARRANTY TERMS.FORD EXPECTS TO SEND THE LETTER BY APPROXIMATELY MID-MAY 2009. BASED ON THE USE OF TPMS IN THE MAJORITY OF SUBJECT VEHICLES AND THE RELATIVELY LOW RATES OF REPAIRS ASSOCIATED WITH LEAKING VALVES AND RESULTANT TIRE DAMAGE, ODI BELIEVES THAT THE ACTIONS FORD HAS AGREED TO TAKE WILL PROVIDE EFFECTIVE AND EXPEDITIOUS RESOLUTION FOR VEHICLES THAT WERE BUILT DURING THE PERIOD WHEN VALVES WITH INADEQUATE RESISTANCE TO OZONE CRACKING WERE MOST LIKELY TO HAVE BEEN USED IN VEHICLE PRODUCTION.FURTHER INVESTIGATION OF THIS MATTER WOULD NOT BE AN EFFICIENT ALLOCATION OF AGENCY RESOURCES.ACCORDINGLY, THIS INVESTIGATION IS CLOSED.THE CLOSING OF THIS INVESTIGATION DOES NOT CONSTITUTE A FINDING BY NHTSA THAT A SAFETY-RELATED DEFECT DOES NOT EXIST.THE AGENCY WILL CONTINUE TO
2007 Ford F-150 Problems, Complaints & Recalls | Skip That Year
Illustration