IllustrationWHILE DRIVING TRANSMISSION MALFUNCTIONED. PRESSURE FROM TRANSMISSION CAUSED TRANSMISSION FUILD TO BLOW OUT ONTO THE CATALYTIC CONVERTER DUE TO THE AUTOMATIC ELECTRICAL OVERDRIVE. PLEASE GIVE ANY FURTHER DETAILS. *AK
1992 Ford F-150
Owner reports · Recalls · Investigations
Similar to other model years
Owner complaints for the 1992 Ford F-150 do not stand out strongly from the model-year median of 676.
About this comparison →How this year compares
Owner complaints by model year
Compare all F-150 years →Counts vary with age, sales and reporting. They are not failure rates.
What owners reported most
All reported categories
Tap a category to read its complaints. One report may name several components.
When problems were reported
Mileage at the reported incident
Limited mileage data: 49 of 470 reports include usable mileage. There isn’t enough coverage to show a useful chart.
NHTSA’s mileage field refers to the reported incident, not necessarily the filing date. This shows report counts, not the likelihood of a failure.
What to inspect
Issues worth paying extra attention to based on owner reports.
- Fuel System, Gasoline. Review the 231 owner reports in this category and discuss these concerns during a pre-purchase inspection. Read reports →
- Electrical System. Review the 48 owner reports in this category and discuss these concerns during a pre-purchase inspection. Read reports →
- Engine And Engine Cooling. Review the 37 owner reports in this category and discuss these concerns during a pre-purchase inspection. Read reports →
NHTSA owner reports · September 18, 2026 snapshot.
20 crash reports38 fire reports11 injury reports
What owners actually said
470 reportsRECALL 93V125000. DUE TO A DEFECTIVE FUEL PRESSURE REGULATOR AND CHECK VALVE, THE DUAL FUEL TANK MAY MALFUNCTIONED, WHICH MAY CAUSE A FUEL SPILLAGE. THERE IS A RECALL, BUT THIS VEHICLE IS NOT INCLUDED FOR THE SAME EXACT PROBLEM. PLEASE PROVIDE FURTHER INFORMATION. *AK
THIS IS IN RESPONSE TO CAMPAIGN ID NUMBER: 93V125000. MY TRUCK WAS REPAIRED FOR THIS PROBLEM THE FIRST TIME 6/94. THE PROBLEM HAS ONCE AGAIN RETURNED. I FILLED THE TWO TANKS AND HAD AN OVERFLOW WHEN ONE TANK WAS PUMPED INTO THE OTHER. THIS OCCURS WHEN THE SELECTION SWITCH IS SET ON THE FRONT OR THE REAR TANK RENDERING THE TRUCK…
Read full complaint
THIS IS IN RESPONSE TO CAMPAIGN ID NUMBER: 93V125000. MY TRUCK WAS REPAIRED FOR THIS PROBLEM THE FIRST TIME 6/94. THE PROBLEM HAS ONCE AGAIN RETURNED. I FILLED THE TWO TANKS AND HAD AN OVERFLOW WHEN ONE TANK WAS PUMPED INTO THE OTHER. THIS OCCURS WHEN THE SELECTION SWITCH IS SET ON THE FRONT OR THE REAR TANK RENDERING THE TRUCK UNDRIVEABLE, AND A MAJOR SAFTY HAZARD. IT IS MY UNDERSTANDING FROM THE NHTSA NOTICE THAT THIS PROBLEM MUST ONCE AGAIN BE FIXED BY FORD BECAUSE THE REMEDY DID NOT CORRECT THE PROBLEM. GRANTED THE REPAIR LASTED 4.5 YEARS BUT IT WAS FIXED WITH FAULTY PARTS BECAUSE IT HAS ONCE AGAIN MALFUNCTIONED. I FEEL THAT MY LIFE HAS BEEN PUT IN JEOPARDY DUE TO THIS MALFUNCTION AND IT SHOULD BE CORRECTED BY FORD AT NO COST TO ME. *AK
WHEN BOTH TANKS ARE FILLED AND CONSUMER SWITCHES TO THE REAR TANK, THE FUEL OVERLFOWS OUT OF THE FRONT TANK. THE DEALER IS AWARE OF THE SITUATION. THE TRUCK WAS NOT INCLUDED IN THE RECALL. THE PROBLEM HAS NOT BEEN CORRECTED. *AK
UNUSED FUEL FROM ONE TANK IS RETURNED TO SECOND TANK, WHEN THIS OCCURS, THE SECOND TANK CAN RUN OVER IF THE CAPACITY OF TANK IS EXCEEDED. (NHTSA CAMPAIGN ID NO. 93V125000 FORD RECALL # 93S68 KIT AA. *AK
RECALL 93V125000; WHILE DRIVING APPROXIMATELY 40MPH NOTICED THAT THE FUEL WAS LEAKING OUT. HAD SET SWITCH TO REAR TANK & FUEL WOULD BE LEAKING OUTOF FRONT TANK. TOOK VEHICLE TO DEALER & INFORMED THE PROBLEM WAS REPAIRED. OWNER SAID PROBLEM STILL EXISTS. *AK
WHEN THE FRONT GAS TANK IS SELECTED ALL THE UNUSED GAS IS RETURNED TO THE REAR TANK, WHICH THEN OVERFLOWS ON TO THE ROADWAY. HAZARD OF FIRE.
IN MARCH 1998 I SPENT OVER $1000 WITH MY LOCAL FORD DEALER TO REPLACE BOTH MY FRONT AND REAR FUEL PUMPS (AFTER THEY FAILED ON ME WHILE I WAS DRIVING ON THE FREEWAY). THE MILEAGE ON MY TRUCK WAS 70,700. ON JANUARY 13, 1999 (10 MONTHS LATER) I WAS TOLD THAT MY REAR FUEL PUMP NEEDS REPLACING AGAIN. THE MILEAGE ON MY TRUCK WAS 84,09…
Read full complaint
IN MARCH 1998 I SPENT OVER $1000 WITH MY LOCAL FORD DEALER TO REPLACE BOTH MY FRONT AND REAR FUEL PUMPS (AFTER THEY FAILED ON ME WHILE I WAS DRIVING ON THE FREEWAY). THE MILEAGE ON MY TRUCK WAS 70,700. ON JANUARY 13, 1999 (10 MONTHS LATER) I WAS TOLD THAT MY REAR FUEL PUMP NEEDS REPLACING AGAIN. THE MILEAGE ON MY TRUCK WAS 84,095. WHY IS IT THAT THE ORIGINAL FORD PART LASTS 70,700 MILES AND THE NEW FORD PART (SUPPOSEDLY THE SAME ONE) ONLY LASTS 13,395 MILES? *AK
FUEL REGULATOR FAILED CAUSING FUEL FROM REAR TANK TO BE PUMPED INTO THE FRONT TANK CAUSING FRONT TANK TO OVERFLOW. THIS WAS FIXED ONCE PER RECALL BUT HAS FAILED AGAIN.
THE VEHICLE HAS DUAL FUEL TANKS. ONE OF THEM HAS BEEN OVERFLOWING ONTO THE GROUND, AND HAS HAD SPARKS COMING OUT OF IT. DEALER HAS NOT SEEN. *AK
Official recalls
394V169001 · Parking Brake:conventional
Sep 7, 1994
THE PARKING BRAKE CONTROL SELF-ADJUST PAWL DOES NOT LINE UP PROPERLY WITH THE SELF-ADJUST RACHET CAUSING THE PAWL TO SLIP OVER ONE OR MORE TEETH IN THE RACHET.
Consequence & remedy
Consequence: WHEN THE ABOVE OCCURS, IT CAN RESULT IN PARKING BRAKE SYSTEM INEFFECTIVENESS. THE PARKING BRAKE WILL NOT HOLD THE VEHICLE, CAUSING THE VEHICLE TO ROLL FREELY, IF THE TRANSMISSION IS NOT LEFT IN GEAR.
Remedy: A WEDGE WILL BE INSTALLED WHICH WILL SERVE TO LOCK THE PARKING BRAKE SELF-ADJUST MECHANISM PAWL INTO ENGAGEMENT WITH THE RACHET. ALSO, OWNERS WILL BE ADVISED TO RELEASE AND REAPPLY THE PARKING BRAKE WHENEVER TOOTH SKIP OCCURS AND WILL BE REMINDED TO ALWAYS TURN OFF THE ENGINE AND LEAVE THE VEHICLE IN GEAR WHEN THE VEHICLE IS PARKED.
93V125000 · Fuel System, Gasoline:storage:tank Assembly
Aug 2, 1993
A MALFUNCTIONING CHECK VALVE WITHIN THE FUEL PUMP ASSEMBLY CAUSES A PORTION OF THE UNUSED FUEL FROM ONE TANK TO BE RETURNED TO THE SECOND TANK. WHEN THIS OCCURS, THE CAPACITY OF THE SECOND TANK CAN BE EXCEEDED, CAUSING FUEL SPILLAGE.
Consequence & remedy
Consequence: SPILLED FUEL CAN RESULT IN A FIRE WHEN EXPOSED TO ASOURCE OF IGNITION.
Remedy: REPLACEMENT OF THE FUEL PRESSURE REGULATOR AND INSTALLATION OF REDUNDANT CHECK VALVES.
92V006000 · Structure:body:door
Jan 14, 1992
WATER CAN ENTER THE DOOR LATCH RELEASE CABLE. IF THE VEHICLE IS OPERATED IN BELOW FREEZING TEMPERATURES, THE WATER IN THE DOOR LATCH RELEASE CABLE CAN FREEZE AND CAUSE THE LATCH MECHANISM TO MALFUNCTION.
Consequence & remedy
Consequence: THE MALFUNCTION OF THE DOOR LATCH RELEASE CAN RESULT INTHREE DIFFERENT PROBLEMS: 1) THE DOOR WILL NOT BE ABLE TO BE RELATCHED, 2) THEINSIDE DOOR HANDLE CAN BECOME INOPERATIVE, AND 3) THE DOOR COULD APPEAR TO BELATCHED WHEN IT IS NOT, ALLOWING THE DOOR TO OPEN UNEXPECTEDLY IF IT IS JARRED,AND INCREASING THE RISK OF INJURY TO THE ADJACENT SEAT OCCUPANT.
Remedy: REVISED DOOR RELEASE CABLES AND WATER SHIELDS WILL BE INSTALLED.
Model-level recall history does not show whether a particular VIN is affected or has received a repair. Check a VIN with NHTSA ↗
NHTSA investigations
8EA99032 · Dual Fuel Tank Crossflow/leakage
Opened Nov 4, 1999 · Closed Dec 6, 2001
Status: closed (inferred from source dates) · Vehicle Speed Control:linkages
ON JULY 14, 1993 FORD FILED A DEFECT INFORMATION REPORT CONCERNING FUEL TANK CROSS FLOW LEAKAGE ON F-SERIES LIGHT TRUCKS AND CAB CHASSIS BUILT FROM JULY 22, 1989 THROUGH DECEMBER 17, 1992.THE REMEDY WAS TO REPLACE THE FUEL PRESSURE REGULATOR AND INSTALL A CHECK VALVE BETWEEN EACH FUEL SUPPLY LINE AND FUEL TANK (2) TO REPAIR THE SUPPLY SIDE FUEL CROSS FLOW PROBLEM (RECALL 93V-125).ODI OPENED RQ98-008 ON MAY 29, 1998 BECAUSE OF THE LARGE NUMBER OF ALLEGED REMEDY FAILURES AND REPORTS OF FUEL CROSS FLOW ON VEHICLES OUTSIDE OF THE RECALL POPULATION.BASED ONTHE INFORMATION RECEIVED FROM FORD ON AUGUST 11, SEPTEMBER 30, AND DECEMBER 15, 1998, AND THE INCREASING TREND OF REMEDY FAILURES AND OUT OF SCOPE CROSSFLOW REPORTS, ODI OPENED EA99-032 ON NOVEMBER 4, 1999.THE ATTACHED ENGINEERING ANALYSIS CLOSING REPORT FULLY DESCRIBES THE RESULTS OF THIS INVESTIGATION AND REASON FOR CLOSING.THE SUBJECT VEHICLES CAN EXPERIENCE FUEL TRANSFER FROM ONE TANK TO THE OTHER DUE TO MALFUNCTIONS IN THE FUEL SYSTEM.WHEN FUEL IS PUMPED OR RETURNED TO THE NON-OPERATING TANK (CROSS FLOW), THE CAPACITY OF THE NON-OPERATING TANK CAN BE EXCEEDED, CAUSING FUEL TO OVERFLOW PAST THE FILLER CAP, CREATING A FIRE POTENTIAL.
Additional source detail variants (2)
Vehicle Speed Control:linkages
ON JULY 14, 1993 FORD FILED A DEFECT INFORMATION REPORT CONCERNING FUEL TANK CROSS FLOW LEAKAGE ON F-SERIES LIGHT TRUCKS AND CAB CHASSIS BUILT FROM JULY 22, 1989 THROUGH DECEMBER 17, 1992.THE REMEDY WAS TO REPLACE THE FUEL PRESSURE REGULATOR AND INSTALL A CHECK VALVE BETWEEN EACH FUEL SUPPLY LINE AND FUEL TANK (2) TO REPAIR THE SUPPLY SIDE FUEL CROSS FLOW PROBLEM (RECALL 93V-125).ODI OPENED RQ98-008 ON MAY 29, 1998 BECAUSE OF THE LARGE NUMBER OF ALLEGED REMEDY FAILURES AND REPORTS OF FUEL CROSS FLOW ON VEHICLES OUTSIDE OF THE RECALL POPULATION.BASED ONTHE INFORMATION RECEIVED FROM FORD ON AUGUST 11, SEPTEMBER 30, AND DECEMBER 15, 1998, AND THE INCREASING TREND OF REMEDY FAILURES AND OUT OF SCOPE CROSSFLOW REPORTS, ODI OPENED EA99-032 ON NOVEMBER 4, 1999.THE ATTACHED ENGINEERING ANALYSIS CLOSING REPORT FULLY DESCRIBES THE RESULTS OF THIS INVESTIGATION AND REASON FOR CLOSING.THE SUBJECT VEHICLES CAN EXPERIENCE FUEL TRANSFER FROM ONE TANK TO THE OTHER DUE TO MALFUNCTIONS IN THE FUEL SYSTEM.WHEN FUEL IS PUMPED OR RETURNED TO THE NON-OPERATING TANK (CROSS FLOW), THE CAPACITY OF THE NON-OPERATING TANK CAN BE EXCEEDED, CAUSING FUEL TO OVERFLOW PAST THE FILLER CAP, CREATING A FIRE POTENTIAL.
Vehicle Speed Control:linkages
ON JULY 14, 1993 FORD FILED A DEFECT INFORMATION REPORT CONCERNING FUEL TANK CROSS FLOW LEAKAGE ON F-SERIES LIGHT TRUCKS AND CAB CHASSIS BUILT FROM JULY 22, 1989 THROUGH DECEMBER 17, 1992.THE REMEDY WAS TO REPLACE THE FUEL PRESSURE REGULATOR AND INSTALL A CHECK VALVE BETWEEN EACH FUEL SUPPLY LINE AND FUEL TANK (2) TO REPAIR THE SUPPLY SIDE FUEL CROSS FLOW PROBLEM (RECALL 93V-125).ODI OPENED RQ98-008 ON MAY 29, 1998 BECAUSE OF THE LARGE NUMBER OF ALLEGED REMEDY FAILURES AND REPORTS OF FUEL CROSS FLOW ON VEHICLES OUTSIDE OF THE RECALL POPULATION.BASED ONTHE INFORMATION RECEIVED FROM FORD ON AUGUST 11, SEPTEMBER 30, AND DECEMBER 15, 1998, AND THE INCREASING TREND OF REMEDY FAILURES AND OUT OF SCOPE CROSSFLOW REPORTS, ODI OPENED EA99-032 ON NOVEMBER 4, 1999.THE ATTACHED ENGINEERING ANALYSIS CLOSING REPORT FULLY DESCRIBES THE RESULTS OF THIS INVESTIGATION AND REASON FOR CLOSING.THE SUBJECT VEHICLES CAN EXPERIENCE FUEL TRANSFER FROM ONE TANK TO THE OTHER DUE TO MALFUNCTIONS IN THE FUEL SYSTEM.WHEN FUEL IS PUMPED OR RETURNED TO THE NON-OPERATING TANK (CROSS FLOW), THE CAPACITY OF THE NON-OPERATING TANK CAN BE EXCEEDED, CAUSING FUEL TO OVERFLOW PAST THE FILLER CAP, CREATING A FIRE POTENTIAL.
RQ98008 · Ford F-SERIES Dual Fuel Tank Leakage
Opened May 29, 1998 · Closed Nov 4, 1999
Status: closed (inferred from source dates) · Fuel System, Gasoline:storage:tank Assembly
THESE VEHICLES CAN EXPERIENCE FUEL TRANSFER FROM ONE TANK TO THE OTHER DUE TO A MALFUNCTIONING FUEL PUMP.FROM THE INFORMATION GATHERED TO DATE, IT APPEARS THAT THERE CAN BE MULTIPLE CAUSES AND/OR A COMBINATION OF CAUSES FOR FUEL CROSS FLOW AND THAT THE RECALL REMEDY MAY BE INADEQUATE.FURTHER INVESTIGATION IS NEEDED.THIS INVESTIGATION IS UPGRADED TO EA99-032.CLICK ON DOCUMENT SEARCH BUTTON FOR ADDITIONAL INFORMATION.
EA93022 · Idle Air Spd Ctrl Vlv Malf
Opened Jul 30, 1993 · Closed Aug 31, 1994
Status: closed (inferred from source dates) · Engine And Engine Cooling
There is no summary currently available
EA93020 · Parking Brake Failure
Opened Jul 28, 1993 · Closed Sep 23, 1994
Status: closed (inferred from source dates) · Service Brakes, Hydraulic
There is no summary currently available
Additional source detail variants (2)
Service Brakes, Hydraulic
There is no summary currently available
Service Brakes, Hydraulic
There is no summary currently available
PE93015 · Parking Brake Failure
Opened Mar 9, 1993 · Closed Jul 27, 1993
Status: closed (inferred from source dates) · Service Brakes, Hydraulic
There is no summary currently available
PE93010 · Idle Air Spd Ctrl Vlv Malf
Opened Mar 2, 1993 · Closed Jul 30, 1993
Status: closed (inferred from source dates) · Engine And Engine Cooling
There is no summary currently available
EA93001 · Fuel Expulsion
Opened Jan 7, 1993 · Closed Aug 20, 1993
Status: closed (inferred from source dates) · Vehicle Speed Control:linkages
There is no summary currently available
PE92077 · Fuel Expulsion
Opened Sep 9, 1992 · Closed Jan 7, 1993
Status: closed (inferred from source dates) · Vehicle Speed Control:linkages
There is no summary currently available