Fuel System, Gasoline. Review the 231 owner reports in this category and discuss these concerns during a pre-purchase inspection. Read reports →
Electrical System. Review the 48 owner reports in this category and discuss these concerns during a pre-purchase inspection. Read reports →
Engine And Engine Cooling. Review the 37 owner reports in this category and discuss these concerns during a pre-purchase inspection. Read reports →

NHTSA owner reports · September 18, 2026 snapshot.

20 crash reports38 fire reports11 injury reports

Tires complaints

30 reports

Clear category filter

Mileage unknown · Sep 12, 2000

Tires

TIRE SHREDDED: IT IS A FIRESTONE FIREHAWK ATX 31X10.5X15. (CLAIM# 05-4520-234) *MW

NHTSA ODI #6900164

Mileage unknown · Sep 12, 2000

Tires

FIRESTONE TIRES INVOLVED. INSD. ADVISED TIRES ON VEHICLE WERE P235/75R15. (CLAIM# 43-R315-612) *MW

NHTSA ODI #6900151

Mileage unknown · Sep 12, 2000

Tires

I WAS ON MY WAY TO WORK WHEN THE FIRESTONE TIRE BLEW CAUSING DAMAGE TO THE WHEEL AREA. FIRESTONE TIRE BLEW OUT. NO ESTIMATE, AT THIS POINT, TIRE IS FIRESTONE ATX AND SIZE IS 235/75R15. I DID CALL FIRESTONE 800 NUMBER AND FILED A CLAIM. IF THERE'S ANYTHING ADDITIONAL WE NEED TO DO, PLEASE ADVISE. THANKS (CLAIM# 25-5427-055) *MW

NHTSA ODI #6900148

Mileage unknown · Sep 12, 2000

Tires

FIRESTONE PATHFINDER ATR 31X15 TIRE FAILURE AT APPROX 70-75MPH. TREAD CAME OFF THE TIRE AND WRAPPED AROUND THE AXEL, INSD HAS THE TIRE. (CLAIM# 23-1257-097) *MW

NHTSA ODI #6900141

Mileage unknown · Sep 8, 2000

Tires

MY TIRES FAILED A DIFFERENT WAY .THE RUBBER SEPARATED FROM THE BEAD THAT SEALS AGAINST THE WHEEL. I HAVEN' T HEARD OF THIS PROBLEM BEING MENTION DURING THIS RECALL. I HAD TO HAVE TWO FIRESTONE ATX TIRES REPLACED WITHIN THE LAST TWO YEARS. BOTH TIRES WERE REPLACED WITH THE SAME PROBLEM. THE PROBLEM I ENCURED IS AS DANGEROUS …

Read full complaint

NHTSA ODI #730722

Mileage unknown · Sep 5, 2000

Tires

Read full complaint

THE TRUCK DEVELOPED A SLIGHT VIBRATION THAT FELT LIKE IT WAS IN THE FRONT END. IT WAS. THE TIRE WAS STARTING TO SEPERATE. FIRESTONE WAS CONTACTED AND THEY SAID THEY WOULD HAVE TO LOOK AT THE TIRE. TO CONDENSE THE STORY, FIRESTONE SAID THEY COULD NOT MAKE AN ADJUSTMENT TO THE TIRE BECAUSE IT WAS OVER FIVE YEARS OLD. NOTE: THE TIRE(S) HAVE GOOD TREAD AND WERE NOT ABUSED. ALSO, THE TIRES ARE SITTING IN THE GARAGE (FOR MONTHS)STILL MOUNTED AND THAT ONE TIRE IS SELF-DESTRUCTING ON ITS OWN. THE TIRE IS NO LONGER TRUE (ROUND), LOOSING ITS TREAD AND EVEN THE BELT PLYS APPEAR TO BE PULLING APART. THE TIRE: FIRESTONE FIREHAWK ATX 31*10.5R15LT M/S LOAD RANGE B.( DOT NUMBER: VD60AXP235 TIRE SIZE: 31*10.5R15 )

NHTSA ODI #730294

Mileage unknown · Sep 1, 2000

TiresCrash

Read full complaint

TIME OF INCIDENT 07:30 AM; NO HEAVY LOAD; ENTIRE TREAD CAME OFF SEVERLY DAMAGING LEFT SIDE PANEL, PIPE TO GAS TANK, AND BED. TRUCK WAS YANKED AROUND, BUT GAINED CONTROL. TIRE CONTINUED TO HOLD AIR, AND WAS STILL HOLDING AIR UNTIL NEW TIRE WAS PURCHASED. I PURCHASED A COMPLETE NEW SET OF WILDERNESS TIRES ON THE SAME DAY DUE TO MILEAGE AND NOT WANTING MISMATCHED TIRES. NOW I AM STUCK WITH ANOTHER SET THAT COULD POTENTIALLY BE JUST AS DANGEROUS. THIS INCIDENT OCCURED PRIOR TO THE PUBLICITY ON FIRESTONE TIRES. OTHERWISE, I WOULD HAVE BOUGHT ANOTHER BRAND. I HAD NEVER HAD PROBLEMS WITH FIRESTONE TIRES BEFORE, AND THOUGHT THE PROBLEM I HAD WAS DUE TO MILEAGE OR JUST A SINGLE DEFECTIVE TIRE.( DOT NUMBER: VD60AXB506 TIRE SIZE: 31105R15 )

NHTSA ODI #729879

Mileage unknown · Aug 17, 2000

Tires

WHILE DRIVING HAD TREAD SEPARATION ON FIVE DIFFERENTS TIMES. FIRESTONE, ATX, P235/75R15. *AK

NHTSA ODI #868031

Mileage unknown · Aug 11, 2000

Tires

PE00020, ORIGINAL EQUIPMENT 1992 F150, TIRE SIZE P23575R15, IN JULY 1993, ABOUT 25,000 MILES, DRIVER'S REAR TIRE TREAD ABOUT 25% PEELED BACK WHICH ALMOST CAUSED A CRASH. 2ND INCIDENT, THE AFTERMARKET TIRE WITH THE SAME TIRE, PASSENGER REAR TREAD COMPLETELY CAME OFF WHICH ALMOST CAUSED A CRASH AND CAUSE DAMAGE TO THE REAR E…

Read full complaint

NHTSA ODI #867518

Mileage unknown · Aug 9, 2000

Tires

Read full complaint

EXPIERIENCED A HIGH SPEED BLOWOUT THAT DAMAGED THE BED OF TRUCK WHEEL WELL BODY SIDE PANEL AND GAS TANK. ADDITIONAL DAMAGE AS REPORTED TO STATE FARM. TREAD SEPERATED COMPLETLY FROM THE TIRE AND WRAPPED ITSELF AROUND THE AXLE WITH CORDING EXPOSED. I RETAIN POSSESION OF THE TIRE AND HAVE REPORTED IT TO INSURANCE COMPANY AND RECIEVED A PARTIAL PAYMENT FOR DAMAGES. TIRE CONTINUED TO HOLD AIR AFTER SEPARATION FOR AN ADDITIONAL FIVE MINUTES. THE TREAD APPEARED TO HAVE PULLED OFF AND COMPLETELY SEPERATED. IT IS NOTED THAT THIS TIRE WAS NOT LISTED IN THE RECALL OF 8/9/00 ANNOUNCED BY FORD AND BRIDGESTONE. LOSS OF CONTROL WAS MINIMAL AS IT WAS ON THE REAR DRIVER'S SIDE.( DOT NUMBER: TIRE SIZE: 31X10.50R1 )

NHTSA ODI #727281

Official recalls

94V169001 · Parking Brake:conventional

Sep 7, 1994

THE PARKING BRAKE CONTROL SELF-ADJUST PAWL DOES NOT LINE UP PROPERLY WITH THE SELF-ADJUST RACHET CAUSING THE PAWL TO SLIP OVER ONE OR MORE TEETH IN THE RACHET.

Consequence & remedy

Consequence: WHEN THE ABOVE OCCURS, IT CAN RESULT IN PARKING BRAKE SYSTEM INEFFECTIVENESS. THE PARKING BRAKE WILL NOT HOLD THE VEHICLE, CAUSING THE VEHICLE TO ROLL FREELY, IF THE TRANSMISSION IS NOT LEFT IN GEAR.

Remedy: A WEDGE WILL BE INSTALLED WHICH WILL SERVE TO LOCK THE PARKING BRAKE SELF-ADJUST MECHANISM PAWL INTO ENGAGEMENT WITH THE RACHET. ALSO, OWNERS WILL BE ADVISED TO RELEASE AND REAPPLY THE PARKING BRAKE WHENEVER TOOTH SKIP OCCURS AND WILL BE REMINDED TO ALWAYS TURN OFF THE ENGINE AND LEAVE THE VEHICLE IN GEAR WHEN THE VEHICLE IS PARKED.

93V125000 · Fuel System, Gasoline:storage:tank Assembly

Aug 2, 1993

A MALFUNCTIONING CHECK VALVE WITHIN THE FUEL PUMP ASSEMBLY CAUSES A PORTION OF THE UNUSED FUEL FROM ONE TANK TO BE RETURNED TO THE SECOND TANK. WHEN THIS OCCURS, THE CAPACITY OF THE SECOND TANK CAN BE EXCEEDED, CAUSING FUEL SPILLAGE.

Consequence & remedy

Consequence: SPILLED FUEL CAN RESULT IN A FIRE WHEN EXPOSED TO ASOURCE OF IGNITION.

Remedy: REPLACEMENT OF THE FUEL PRESSURE REGULATOR AND INSTALLATION OF REDUNDANT CHECK VALVES.

92V006000 · Structure:body:door

Jan 14, 1992

WATER CAN ENTER THE DOOR LATCH RELEASE CABLE. IF THE VEHICLE IS OPERATED IN BELOW FREEZING TEMPERATURES, THE WATER IN THE DOOR LATCH RELEASE CABLE CAN FREEZE AND CAUSE THE LATCH MECHANISM TO MALFUNCTION.

Consequence & remedy

Consequence: THE MALFUNCTION OF THE DOOR LATCH RELEASE CAN RESULT INTHREE DIFFERENT PROBLEMS: 1) THE DOOR WILL NOT BE ABLE TO BE RELATCHED, 2) THEINSIDE DOOR HANDLE CAN BECOME INOPERATIVE, AND 3) THE DOOR COULD APPEAR TO BELATCHED WHEN IT IS NOT, ALLOWING THE DOOR TO OPEN UNEXPECTEDLY IF IT IS JARRED,AND INCREASING THE RISK OF INJURY TO THE ADJACENT SEAT OCCUPANT.

Remedy: REVISED DOOR RELEASE CABLES AND WATER SHIELDS WILL BE INSTALLED.

Model-level recall history does not show whether a particular VIN is affected or has received a repair. Check a VIN with NHTSA ↗

NHTSA investigations

EA99032 · Dual Fuel Tank Crossflow/leakage

Opened Nov 4, 1999 · Closed Dec 6, 2001

Status: closed (inferred from source dates) · Vehicle Speed Control:linkages

ON JULY 14, 1993 FORD FILED A DEFECT INFORMATION REPORT CONCERNING FUEL TANK CROSS FLOW LEAKAGE ON F-SERIES LIGHT TRUCKS AND CAB CHASSIS BUILT FROM JULY 22, 1989 THROUGH DECEMBER 17, 1992.THE REMEDY WAS TO REPLACE THE FUEL PRESSURE REGULATOR AND INSTALL A CHECK VALVE BETWEEN EACH FUEL SUPPLY LINE AND FUEL TANK (2) TO REPAIR THE SUPPLY SIDE FUEL CROSS FLOW PROBLEM (RECALL 93V-125).ODI OPENED RQ98-008 ON MAY 29, 1998 BECAUSE OF THE LARGE NUMBER OF ALLEGED REMEDY FAILURES AND REPORTS OF FUEL CROSS FLOW ON VEHICLES OUTSIDE OF THE RECALL POPULATION.BASED ONTHE INFORMATION RECEIVED FROM FORD ON AUGUST 11, SEPTEMBER 30, AND DECEMBER 15, 1998, AND THE INCREASING TREND OF REMEDY FAILURES AND OUT OF SCOPE CROSSFLOW REPORTS, ODI OPENED EA99-032 ON NOVEMBER 4, 1999.THE ATTACHED ENGINEERING ANALYSIS CLOSING REPORT FULLY DESCRIBES THE RESULTS OF THIS INVESTIGATION AND REASON FOR CLOSING.THE SUBJECT VEHICLES CAN EXPERIENCE FUEL TRANSFER FROM ONE TANK TO THE OTHER DUE TO MALFUNCTIONS IN THE FUEL SYSTEM.WHEN FUEL IS PUMPED OR RETURNED TO THE NON-OPERATING TANK (CROSS FLOW), THE CAPACITY OF THE NON-OPERATING TANK CAN BE EXCEEDED, CAUSING FUEL TO OVERFLOW PAST THE FILLER CAP, CREATING A FIRE POTENTIAL.

Additional source detail variants (2)

Vehicle Speed Control:linkages

RQ98008 · Ford F-SERIES Dual Fuel Tank Leakage

Opened May 29, 1998 · Closed Nov 4, 1999

Status: closed (inferred from source dates) · Fuel System, Gasoline:storage:tank Assembly

THESE VEHICLES CAN EXPERIENCE FUEL TRANSFER FROM ONE TANK TO THE OTHER DUE TO A MALFUNCTIONING FUEL PUMP.FROM THE INFORMATION GATHERED TO DATE, IT APPEARS THAT THERE CAN BE MULTIPLE CAUSES AND/OR A COMBINATION OF CAUSES FOR FUEL CROSS FLOW AND THAT THE RECALL REMEDY MAY BE INADEQUATE.FURTHER INVESTIGATION IS NEEDED.THIS INVESTIGATION IS UPGRADED TO EA99-032.CLICK ON DOCUMENT SEARCH BUTTON FOR ADDITIONAL INFORMATION.