1992 F150 XLT LARIAT 302. DUEL TANKS. I USE THE REAR TANK AND NOT THE FRONT ONE. THIS WEEKEND MY TRUCK IS RUNNING GAS WILL POUR OUT OF THE FRONT TANK AT THE GAS CAP. I TOOK BOTH CAPS OFF SO THERE WAS NO PRESSURE BUILD UP AND IT MADE NO DIFFERENCE THE GAS STILL POURED OUT THE FRONT TANK REALLY BAD. WHEN YOU'RE ON THE HIGHWAY IT …
Read full complaint
1992 F150 XLT LARIAT 302. DUEL TANKS. I USE THE REAR TANK AND NOT THE FRONT ONE. THIS WEEKEND MY TRUCK IS RUNNING GAS WILL POUR OUT OF THE FRONT TANK AT THE GAS CAP. I TOOK BOTH CAPS OFF SO THERE WAS NO PRESSURE BUILD UP AND IT MADE NO DIFFERENCE THE GAS STILL POURED OUT THE FRONT TANK REALLY BAD. WHEN YOU'RE ON THE HIGHWAY IT ACTS LIKE IT WANTS TO SHUT OFF. THEN WHEN YOU PARK IT GAS GUSHES OUT THE TANK AND THE VAPOR CANISTER UP UNDER THE HOOD I HAVE HAD THE TRUCK FOR TWO MONTHS, IT HAD A LITTLE OVER 92,000 ORIGINAL MILES WHEN I PURCHASE IT AND NOW A LITTLE OVER 94,000.. THERE WAS A RECALL ON THIS TRUCK IN JULY 9, 2001 "ORIGINAL RECALL FROM THE NHTSA" "NHTSA ACTION NUMBER EA99032 POTENTIAL NUMBER OF UNITS AFFECTED 1,556,221
NHTSA ODI #11021458
110,000 miles · Feb 22, 2017
Fuel/propulsion System
I HAVE NOTICED A STRONG SMELL OF GAS WHEN EXITING VEHICLE AFTER USE. A FEW DAYS LATER SAW GAS COMING FROM FRONT TANK FILLER. CHECKED CAP WAS ON PROPERLY. THEN I NOTICED THAN FUEL CONTINUED TO SPILL REGARDLESS OF TRUCK RUNNING OR NOT. DOES NOT DO IT EVERY TIME. GAS DISAPPEARS FROM REAR TANK. I SUSPECT GAS IS BEING PUMPED…
Read full complaint
I HAVE NOTICED A STRONG SMELL OF GAS WHEN EXITING VEHICLE AFTER USE. A FEW DAYS LATER SAW GAS COMING FROM FRONT TANK FILLER. CHECKED CAP WAS ON PROPERLY. THEN I NOTICED THAN FUEL CONTINUED TO SPILL REGARDLESS OF TRUCK RUNNING OR NOT. DOES NOT DO IT EVERY TIME. GAS DISAPPEARS FROM REAR TANK. I SUSPECT GAS IS BEING PUMPED FROM REAR TANK TO FRONT TANK UNTIL IT OVER FLOWS. ONE FAMILY TRUCK, BOUGHT NEW BY MY SON IN LAW I HAVE HAD IT AROUND 3 YEARS. 110,000 ACTUAL MILEAGE. OLD BUT LOW MILEAGE. SERIOUS SAFETY ISSUE. COULDN,T FIND ANY RECALLS PAST 1999.
NHTSA ODI #10956425
170,000 miles · Sep 8, 2016
Fuel/propulsion System
FUEL FROM REAR TANK PUMPS TO FRONT TANK AND OVER FILLS FRONT TANK SPILLING ON GROUND
NHTSA ODI #10904630
145,121 miles · Mar 31, 2016
Fuel/propulsion System
REAR FUEL TANK DUMPING GAS INTO FRONT TANK CAUSING THE FRONT TANK TO OVER FLOW
NHTSA ODI #10852682
194,000 miles · Aug 10, 2015
Fuel/propulsion System
TL* THE CONTACT OWNS A 1992 FORD F-150. THE CONTACT STATED THAT WHILE DRIVING AT 40 MPH, FUEL FUMES EMITTED INTO THE VEHICLE. AFTER INSPECTING THE VEHICLE, THE CONTACT NOTICED THAT OIL WAS LEAKING FROM THE REAR OF THE VEHICLE. THE MANUFACTURER WAS MADE AWARE OF THE ISSUE. THE APPROXIMATE FAILURE MILEAGE WAS 194,000. THE VIN WAS …
Read full complaint
TL* THE CONTACT OWNS A 1992 FORD F-150. THE CONTACT STATED THAT WHILE DRIVING AT 40 MPH, FUEL FUMES EMITTED INTO THE VEHICLE. AFTER INSPECTING THE VEHICLE, THE CONTACT NOTICED THAT OIL WAS LEAKING FROM THE REAR OF THE VEHICLE. THE MANUFACTURER WAS MADE AWARE OF THE ISSUE. THE APPROXIMATE FAILURE MILEAGE WAS 194,000. THE VIN WAS NOT AVAILABLE.
NHTSA ODI #10747458
100,000 miles · Jan 2, 2015
Fuel/propulsion System
TL* THE CONTACT OWNS A 1992 FORD F-150. THE CONTACT STATED THAT WHILE DRIVING AT APPROXIMATELY 30 MPH, THERE WAS A FUEL ODOR EMITTING FROM THE INSIDE OF THE VEHICLE AND STALLED. THE VEHICLE WAS RESTARTED. THE FAILURE RECURRED ON A DAILY BASIS. THE VEHICLE WAS NOT DIAGNOSED OR REPAIRED. THE MANUFACTURER WAS MADE AWARE OF THE FAIL…
Read full complaint
TL* THE CONTACT OWNS A 1992 FORD F-150. THE CONTACT STATED THAT WHILE DRIVING AT APPROXIMATELY 30 MPH, THERE WAS A FUEL ODOR EMITTING FROM THE INSIDE OF THE VEHICLE AND STALLED. THE VEHICLE WAS RESTARTED. THE FAILURE RECURRED ON A DAILY BASIS. THE VEHICLE WAS NOT DIAGNOSED OR REPAIRED. THE MANUFACTURER WAS MADE AWARE OF THE FAILURE. THE FAILURE MILEAGE WAS 100,000.
NHTSA ODI #10669620
200,000 miles · Jan 21, 2014
Fuel/propulsion System
FUEL PUMPS FROM TANK TO TANK AND OVERFLOWS. *TR
NHTSA ODI #10560853
140,000 miles · Jun 21, 2012
Fuel/propulsion System
TL* THE CONTACT OWNS A 1992 FORD F150. THE CONTACT STATED THAT THERE WAS A LEAK IN THE GASOLINE TANK. THE CONTACT STATED THAT AS HE WOULD REFUEL, FUEL WOULD SPEW OUT FROM THE FILLER NECK VALVE. THE CONTACT STATED THAT THE VEHICLE WAS TAKEN FOR INSPECTION BY THE DEALER WHERE THEY INFORMED THE CONTACT THAT THE VIN WAS NOT INCLUDED…
Read full complaint
TL* THE CONTACT OWNS A 1992 FORD F150. THE CONTACT STATED THAT THERE WAS A LEAK IN THE GASOLINE TANK. THE CONTACT STATED THAT AS HE WOULD REFUEL, FUEL WOULD SPEW OUT FROM THE FILLER NECK VALVE. THE CONTACT STATED THAT THE VEHICLE WAS TAKEN FOR INSPECTION BY THE DEALER WHERE THEY INFORMED THE CONTACT THAT THE VIN WAS NOT INCLUDED IN NHTSA CAMPAIGN ID NUMBER: 93V125000 (FUEL SYSTEM, GASOLINE:STORAGE:TANK ASSEMBLY). THE VEHICLE WAS NOT REPAIRED. THE MANUFACTURER WAS NOTIFIED AND INFORMED THE CONTACT THAT THE VEHICLE WAS NOT UNDER RECALL AND HE WOULD HAVE TO PAY FOR REPAIRS. THE FAILURE MILEAGE WAS 140,000.
THE PARKING BRAKE CONTROL SELF-ADJUST PAWL DOES NOT LINE UP PROPERLY WITH THE SELF-ADJUST RACHET CAUSING THE PAWL TO SLIP OVER ONE OR MORE TEETH IN THE RACHET.
Consequence & remedy
Consequence: WHEN THE ABOVE OCCURS, IT CAN RESULT IN PARKING BRAKE SYSTEM INEFFECTIVENESS. THE PARKING BRAKE WILL NOT HOLD THE VEHICLE, CAUSING THE VEHICLE TO ROLL FREELY, IF THE TRANSMISSION IS NOT LEFT IN GEAR.
Remedy: A WEDGE WILL BE INSTALLED WHICH WILL SERVE TO LOCK THE PARKING BRAKE SELF-ADJUST MECHANISM PAWL INTO ENGAGEMENT WITH THE RACHET. ALSO, OWNERS WILL BE ADVISED TO RELEASE AND REAPPLY THE PARKING BRAKE WHENEVER TOOTH SKIP OCCURS AND WILL BE REMINDED TO ALWAYS TURN OFF THE ENGINE AND LEAVE THE VEHICLE IN GEAR WHEN THE VEHICLE IS PARKED.
A MALFUNCTIONING CHECK VALVE WITHIN THE FUEL PUMP ASSEMBLY CAUSES A PORTION OF THE UNUSED FUEL FROM ONE TANK TO BE RETURNED TO THE SECOND TANK. WHEN THIS OCCURS, THE CAPACITY OF THE SECOND TANK CAN BE EXCEEDED, CAUSING FUEL SPILLAGE.
Consequence & remedy
Consequence: SPILLED FUEL CAN RESULT IN A FIRE WHEN EXPOSED TO ASOURCE OF IGNITION.
Remedy: REPLACEMENT OF THE FUEL PRESSURE REGULATOR AND INSTALLATION OF REDUNDANT CHECK VALVES.
WATER CAN ENTER THE DOOR LATCH RELEASE CABLE. IF THE VEHICLE IS OPERATED IN BELOW FREEZING TEMPERATURES, THE WATER IN THE DOOR LATCH RELEASE CABLE CAN FREEZE AND CAUSE THE LATCH MECHANISM TO MALFUNCTION.
Consequence & remedy
Consequence: THE MALFUNCTION OF THE DOOR LATCH RELEASE CAN RESULT INTHREE DIFFERENT PROBLEMS: 1) THE DOOR WILL NOT BE ABLE TO BE RELATCHED, 2) THEINSIDE DOOR HANDLE CAN BECOME INOPERATIVE, AND 3) THE DOOR COULD APPEAR TO BELATCHED WHEN IT IS NOT, ALLOWING THE DOOR TO OPEN UNEXPECTEDLY IF IT IS JARRED,AND INCREASING THE RISK OF INJURY TO THE ADJACENT SEAT OCCUPANT.
Remedy: REVISED DOOR RELEASE CABLES AND WATER SHIELDS WILL BE INSTALLED.
Model-level recall history does not show whether a particular VIN is affected or has received a repair. Check a VIN with NHTSA ↗
NHTSA investigations
8
EA99032 · Dual Fuel Tank Crossflow/leakage
Opened Nov 4, 1999 · Closed Dec 6, 2001
Status: closed (inferred from source dates) · Vehicle Speed Control:linkages
ON JULY 14, 1993 FORD FILED A DEFECT INFORMATION REPORT CONCERNING FUEL TANK CROSS FLOW LEAKAGE ON F-SERIES LIGHT TRUCKS AND CAB CHASSIS BUILT FROM JULY 22, 1989 THROUGH DECEMBER 17, 1992.THE REMEDY WAS TO REPLACE THE FUEL PRESSURE REGULATOR AND INSTALL A CHECK VALVE BETWEEN EACH FUEL SUPPLY LINE AND FUEL TANK (2) TO REPAIR THE SUPPLY SIDE FUEL CROSS FLOW PROBLEM (RECALL 93V-125).ODI OPENED RQ98-008 ON MAY 29, 1998 BECAUSE OF THE LARGE NUMBER OF ALLEGED REMEDY FAILURES AND REPORTS OF FUEL CROSS FLOW ON VEHICLES OUTSIDE OF THE RECALL POPULATION.BASED ONTHE INFORMATION RECEIVED FROM FORD ON AUGUST 11, SEPTEMBER 30, AND DECEMBER 15, 1998, AND THE INCREASING TREND OF REMEDY FAILURES AND OUT OF SCOPE CROSSFLOW REPORTS, ODI OPENED EA99-032 ON NOVEMBER 4, 1999.THE ATTACHED ENGINEERING ANALYSIS CLOSING REPORT FULLY DESCRIBES THE RESULTS OF THIS INVESTIGATION AND REASON FOR CLOSING.THE SUBJECT VEHICLES CAN EXPERIENCE FUEL TRANSFER FROM ONE TANK TO THE OTHER DUE TO MALFUNCTIONS IN THE FUEL SYSTEM.WHEN FUEL IS PUMPED OR RETURNED TO THE NON-OPERATING TANK (CROSS FLOW), THE CAPACITY OF THE NON-OPERATING TANK CAN BE EXCEEDED, CAUSING FUEL TO OVERFLOW PAST THE FILLER CAP, CREATING A FIRE POTENTIAL.
Additional source detail variants (2)
Vehicle Speed Control:linkages
ON JULY 14, 1993 FORD FILED A DEFECT INFORMATION REPORT CONCERNING FUEL TANK CROSS FLOW LEAKAGE ON F-SERIES LIGHT TRUCKS AND CAB CHASSIS BUILT FROM JULY 22, 1989 THROUGH DECEMBER 17, 1992.THE REMEDY WAS TO REPLACE THE FUEL PRESSURE REGULATOR AND INSTALL A CHECK VALVE BETWEEN EACH FUEL SUPPLY LINE AND FUEL TANK (2) TO REPAIR THE SUPPLY SIDE FUEL CROSS FLOW PROBLEM (RECALL 93V-125).ODI OPENED RQ98-008 ON MAY 29, 1998 BECAUSE OF THE LARGE NUMBER OF ALLEGED REMEDY FAILURES AND REPORTS OF FUEL CROSS FLOW ON VEHICLES OUTSIDE OF THE RECALL POPULATION.BASED ONTHE INFORMATION RECEIVED FROM FORD ON AUGUST 11, SEPTEMBER 30, AND DECEMBER 15, 1998, AND THE INCREASING TREND OF REMEDY FAILURES AND OUT OF SCOPE CROSSFLOW REPORTS, ODI OPENED EA99-032 ON NOVEMBER 4, 1999.THE ATTACHED ENGINEERING ANALYSIS CLOSING REPORT FULLY DESCRIBES THE RESULTS OF THIS INVESTIGATION AND REASON FOR CLOSING.THE SUBJECT VEHICLES CAN EXPERIENCE FUEL TRANSFER FROM ONE TANK TO THE OTHER DUE TO MALFUNCTIONS IN THE FUEL SYSTEM.WHEN FUEL IS PUMPED OR RETURNED TO THE NON-OPERATING TANK (CROSS FLOW), THE CAPACITY OF THE NON-OPERATING TANK CAN BE EXCEEDED, CAUSING FUEL TO OVERFLOW PAST THE FILLER CAP, CREATING A FIRE POTENTIAL.
Vehicle Speed Control:linkages
ON JULY 14, 1993 FORD FILED A DEFECT INFORMATION REPORT CONCERNING FUEL TANK CROSS FLOW LEAKAGE ON F-SERIES LIGHT TRUCKS AND CAB CHASSIS BUILT FROM JULY 22, 1989 THROUGH DECEMBER 17, 1992.THE REMEDY WAS TO REPLACE THE FUEL PRESSURE REGULATOR AND INSTALL A CHECK VALVE BETWEEN EACH FUEL SUPPLY LINE AND FUEL TANK (2) TO REPAIR THE SUPPLY SIDE FUEL CROSS FLOW PROBLEM (RECALL 93V-125).ODI OPENED RQ98-008 ON MAY 29, 1998 BECAUSE OF THE LARGE NUMBER OF ALLEGED REMEDY FAILURES AND REPORTS OF FUEL CROSS FLOW ON VEHICLES OUTSIDE OF THE RECALL POPULATION.BASED ONTHE INFORMATION RECEIVED FROM FORD ON AUGUST 11, SEPTEMBER 30, AND DECEMBER 15, 1998, AND THE INCREASING TREND OF REMEDY FAILURES AND OUT OF SCOPE CROSSFLOW REPORTS, ODI OPENED EA99-032 ON NOVEMBER 4, 1999.THE ATTACHED ENGINEERING ANALYSIS CLOSING REPORT FULLY DESCRIBES THE RESULTS OF THIS INVESTIGATION AND REASON FOR CLOSING.THE SUBJECT VEHICLES CAN EXPERIENCE FUEL TRANSFER FROM ONE TANK TO THE OTHER DUE TO MALFUNCTIONS IN THE FUEL SYSTEM.WHEN FUEL IS PUMPED OR RETURNED TO THE NON-OPERATING TANK (CROSS FLOW), THE CAPACITY OF THE NON-OPERATING TANK CAN BE EXCEEDED, CAUSING FUEL TO OVERFLOW PAST THE FILLER CAP, CREATING A FIRE POTENTIAL.
THESE VEHICLES CAN EXPERIENCE FUEL TRANSFER FROM ONE TANK TO THE OTHER DUE TO A MALFUNCTIONING FUEL PUMP.FROM THE INFORMATION GATHERED TO DATE, IT APPEARS THAT THERE CAN BE MULTIPLE CAUSES AND/OR A COMBINATION OF CAUSES FOR FUEL CROSS FLOW AND THAT THE RECALL REMEDY MAY BE INADEQUATE.FURTHER INVESTIGATION IS NEEDED.THIS INVESTIGATION IS UPGRADED TO EA99-032.CLICK ON DOCUMENT SEARCH BUTTON FOR ADDITIONAL INFORMATION.
EA93022 · Idle Air Spd Ctrl Vlv Malf
Opened Jul 30, 1993 · Closed Aug 31, 1994
Status: closed (inferred from source dates) · Engine And Engine Cooling
There is no summary currently available
EA93020 · Parking Brake Failure
Opened Jul 28, 1993 · Closed Sep 23, 1994
Status: closed (inferred from source dates) · Service Brakes, Hydraulic
There is no summary currently available
Additional source detail variants (2)
Service Brakes, Hydraulic
There is no summary currently available
Service Brakes, Hydraulic
There is no summary currently available
PE93015 · Parking Brake Failure
Opened Mar 9, 1993 · Closed Jul 27, 1993
Status: closed (inferred from source dates) · Service Brakes, Hydraulic
There is no summary currently available
PE93010 · Idle Air Spd Ctrl Vlv Malf
Opened Mar 2, 1993 · Closed Jul 30, 1993
Status: closed (inferred from source dates) · Engine And Engine Cooling
There is no summary currently available
EA93001 · Fuel Expulsion
Opened Jan 7, 1993 · Closed Aug 20, 1993
Status: closed (inferred from source dates) · Vehicle Speed Control:linkages
There is no summary currently available
PE92077 · Fuel Expulsion
Opened Sep 9, 1992 · Closed Jan 7, 1993
Status: closed (inferred from source dates) · Vehicle Speed Control:linkages
There is no summary currently available
1992 Ford F-150 Problems, Complaints & Recalls | Skip That Year
Illustration