IllustrationATTEMPTING TO START TRUCK, CLICKING NOISE, RUSTED CONNECTION FOR SOLENOID WIRE LUG. MUST CLEAN EVERY OTHER MONTH TO START VEHICLE. *TR
1992 Ford F-150
Owner reports · Recalls · Investigations
Similar to other model years
Owner complaints for the 1992 Ford F-150 do not stand out strongly from the model-year median of 676.
About this comparison →How this year compares
Owner complaints by model year
Compare all F-150 years →Counts vary with age, sales and reporting. They are not failure rates.
What owners reported most
All reported categories
Tap a category to read its complaints. One report may name several components.
When problems were reported
Mileage at the reported incident
Limited mileage data: 49 of 470 reports include usable mileage. There isn’t enough coverage to show a useful chart.
NHTSA’s mileage field refers to the reported incident, not necessarily the filing date. This shows report counts, not the likelihood of a failure.
What to inspect
Issues worth paying extra attention to based on owner reports.
- Fuel System, Gasoline. Review the 231 owner reports in this category and discuss these concerns during a pre-purchase inspection. Read reports →
- Electrical System. Review the 48 owner reports in this category and discuss these concerns during a pre-purchase inspection. Read reports →
- Engine And Engine Cooling. Review the 37 owner reports in this category and discuss these concerns during a pre-purchase inspection. Read reports →
NHTSA owner reports · September 18, 2026 snapshot.
20 crash reports38 fire reports11 injury reports
Electrical System complaints
48 reportsI WAS DRIVING MY FORD F-150 1992 AND I STOPPED AT LOWES. I CUT MY TRUCK OFF AND PROCEEDED INTO THE STORE. I COME BACK OUTSIDE AND MY TRUCK WAS ON FIRE. SEVERAL EMPLOYEES ATTEMPTED TO PUT OUT THE FIRE BUT IT DID NOT WORK. THE FIRE DEPARTMENT HAD TO COME AND PUT IT OUT. THEY THEN STATED THAT IT WAS DUE TO AN ELECTRICAL PROBLEM AND…
Read full complaint
I WAS DRIVING MY FORD F-150 1992 AND I STOPPED AT LOWES. I CUT MY TRUCK OFF AND PROCEEDED INTO THE STORE. I COME BACK OUTSIDE AND MY TRUCK WAS ON FIRE. SEVERAL EMPLOYEES ATTEMPTED TO PUT OUT THE FIRE BUT IT DID NOT WORK. THE FIRE DEPARTMENT HAD TO COME AND PUT IT OUT. THEY THEN STATED THAT IT WAS DUE TO AN ELECTRICAL PROBLEM AND FILLED IT AS THAT. MY WORK IS NOW GONE DUE TO THAT AND I DON'T KNOW WHAT TO DO. IF POSSIBLE PLEASE HELP ME BECAUSE I DON'T KNOW WHAT TO DO. MY TRUCK IS MY MONEY MAKER AND NOW IT IS GONE. *JB
WHILE PARKED FOR APPROXIMATELY 5 MINUTES WITH THE ENGINE RUNNING, THE VEHICLE CAUGHT ON FIRE FROM ENGINE. THE CAUSE OF WHY THIS HAPPENDED WAS UNDETERMINED.*AK *SB *NM
WIRNG HARNESS AND VOLTAGE REGULATOR SHORTED OUT,CAUSING MY ALTERNATOR TO CATCH ON FIRE ,AND WERE ALL MOTORCRAFT PARTS. AUTO PARTS STORE CLAIMS THAT ALOT OF THESE FIRES REPORTED IN FORD TRUCK ALTERNATOR ELECTRICAL SYSTEMS TO ALTERNATOR. *AK
ENGINE DIES AT SPEEDS OF UNDER 10MILES PER HOUR. HAVE JUST REPLACED THE ALTERNATOR IN THE LAST 5 DAYS AND NOW I'M HAVING ALL OF THIS TROUBLE. IS IT TRUE THAT THERE IS A RECALL ON THIS MODEL TRUCK BECAUSE OF THE PRESSURE REGULATOR ? THE TRANSMISSION SLAMS INTO GEAR RATHER THAN SMOOTHLY SHIFTING, ALSO ACTS LIKE IT IS TRYING…
Read full complaint
ENGINE DIES AT SPEEDS OF UNDER 10MILES PER HOUR. HAVE JUST REPLACED THE ALTERNATOR IN THE LAST 5 DAYS AND NOW I'M HAVING ALL OF THIS TROUBLE. IS IT TRUE THAT THERE IS A RECALL ON THIS MODEL TRUCK BECAUSE OF THE PRESSURE REGULATOR ? THE TRANSMISSION SLAMS INTO GEAR RATHER THAN SMOOTHLY SHIFTING, ALSO ACTS LIKE IT IS TRYING TO GET INTO TWO OR MORE GEARS AT THE SAME TIME. IF YOU CAN HELP PLEASE DO SO. THANKS.*AK
WHILE DRIVING SMELLED A BURNING ODOR. ENGINE CHECK LIGHT CAME ON. THERE WAS A LARGE UNDERHOOD FIRE.*AK
CONSUMER STATES WHIILE DRIVING, THE VEHICLE SURGED FORWARD, STEERING WHEEL WAS TURNED TO RIGHT AND THEN IT LOCKED. CONSUMER HAD APPLIED BRAKES BUT COULD NOT SLOW DOWN VEHICLE. IT KEPT GOING IN CIRCLES. PASSENGER'S DOOR OPENED, VEHICLE HIT ANOTHER VEHICLE. KEY CAME OUT OFF IGNITION AT THE BEGINNING, CONSUMER WAS ABLE TO PUT KEY B…
Read full complaint
CONSUMER STATES WHIILE DRIVING, THE VEHICLE SURGED FORWARD, STEERING WHEEL WAS TURNED TO RIGHT AND THEN IT LOCKED. CONSUMER HAD APPLIED BRAKES BUT COULD NOT SLOW DOWN VEHICLE. IT KEPT GOING IN CIRCLES. PASSENGER'S DOOR OPENED, VEHICLE HIT ANOTHER VEHICLE. KEY CAME OUT OFF IGNITION AT THE BEGINNING, CONSUMER WAS ABLE TO PUT KEY BACK IN IGNITION AND SHUT OFF VEHICLE. *AK ALSO THE IGNITION KEY CYLINDER WAS REPLACED.*YH
AFTER PARKING VEHICLE WITHIN 15 -20 MINUTES A FIRE STARTED IN ENGINE COMPARTMENT. DEALER AND MANUFACTURER WERE NOT NOTIFIED AT THIS TIME. FEEL FREE TO PROVIDE ANY FURTHER INFORMATION.*AK
WHILE DRIVING SMELLED SMOKE, PULLED OVER AND LIFTED HOOD AND SAW FLAMES. CAUSE WAS UNKNOWN. *AK CONSUMER STATES THAT THERE IS A SHORT WITHIN THE ELECTRICAL SYSTEM CAUSING THE ALTERNATOR TO FAIL, IN THE WINTER WHEN TURNING ON THE HEATER, THE HEATER FAN, LIGHTS AND OTHER ELECTRICAL COMPONENTS DIE, THE DEALER HAS REPLACED MANY AL…
Read full complaint
WHILE DRIVING SMELLED SMOKE, PULLED OVER AND LIFTED HOOD AND SAW FLAMES. CAUSE WAS UNKNOWN. *AK CONSUMER STATES THAT THERE IS A SHORT WITHIN THE ELECTRICAL SYSTEM CAUSING THE ALTERNATOR TO FAIL, IN THE WINTER WHEN TURNING ON THE HEATER, THE HEATER FAN, LIGHTS AND OTHER ELECTRICAL COMPONENTS DIE, THE DEALER HAS REPLACED MANY ALTERNATORS, A STARTER, 2 BATTERIES AND A U BELT. *SLC
ALTERNATOR ELECTRICAL CONNECTOR PLUG FAILED, RESULTING IN HIGH RESISTANCE HEAT AND CAUGHT FIRE.*AK
Official recalls
394V169001 · Parking Brake:conventional
Sep 7, 1994
THE PARKING BRAKE CONTROL SELF-ADJUST PAWL DOES NOT LINE UP PROPERLY WITH THE SELF-ADJUST RACHET CAUSING THE PAWL TO SLIP OVER ONE OR MORE TEETH IN THE RACHET.
Consequence & remedy
Consequence: WHEN THE ABOVE OCCURS, IT CAN RESULT IN PARKING BRAKE SYSTEM INEFFECTIVENESS. THE PARKING BRAKE WILL NOT HOLD THE VEHICLE, CAUSING THE VEHICLE TO ROLL FREELY, IF THE TRANSMISSION IS NOT LEFT IN GEAR.
Remedy: A WEDGE WILL BE INSTALLED WHICH WILL SERVE TO LOCK THE PARKING BRAKE SELF-ADJUST MECHANISM PAWL INTO ENGAGEMENT WITH THE RACHET. ALSO, OWNERS WILL BE ADVISED TO RELEASE AND REAPPLY THE PARKING BRAKE WHENEVER TOOTH SKIP OCCURS AND WILL BE REMINDED TO ALWAYS TURN OFF THE ENGINE AND LEAVE THE VEHICLE IN GEAR WHEN THE VEHICLE IS PARKED.
93V125000 · Fuel System, Gasoline:storage:tank Assembly
Aug 2, 1993
A MALFUNCTIONING CHECK VALVE WITHIN THE FUEL PUMP ASSEMBLY CAUSES A PORTION OF THE UNUSED FUEL FROM ONE TANK TO BE RETURNED TO THE SECOND TANK. WHEN THIS OCCURS, THE CAPACITY OF THE SECOND TANK CAN BE EXCEEDED, CAUSING FUEL SPILLAGE.
Consequence & remedy
Consequence: SPILLED FUEL CAN RESULT IN A FIRE WHEN EXPOSED TO ASOURCE OF IGNITION.
Remedy: REPLACEMENT OF THE FUEL PRESSURE REGULATOR AND INSTALLATION OF REDUNDANT CHECK VALVES.
92V006000 · Structure:body:door
Jan 14, 1992
WATER CAN ENTER THE DOOR LATCH RELEASE CABLE. IF THE VEHICLE IS OPERATED IN BELOW FREEZING TEMPERATURES, THE WATER IN THE DOOR LATCH RELEASE CABLE CAN FREEZE AND CAUSE THE LATCH MECHANISM TO MALFUNCTION.
Consequence & remedy
Consequence: THE MALFUNCTION OF THE DOOR LATCH RELEASE CAN RESULT INTHREE DIFFERENT PROBLEMS: 1) THE DOOR WILL NOT BE ABLE TO BE RELATCHED, 2) THEINSIDE DOOR HANDLE CAN BECOME INOPERATIVE, AND 3) THE DOOR COULD APPEAR TO BELATCHED WHEN IT IS NOT, ALLOWING THE DOOR TO OPEN UNEXPECTEDLY IF IT IS JARRED,AND INCREASING THE RISK OF INJURY TO THE ADJACENT SEAT OCCUPANT.
Remedy: REVISED DOOR RELEASE CABLES AND WATER SHIELDS WILL BE INSTALLED.
Model-level recall history does not show whether a particular VIN is affected or has received a repair. Check a VIN with NHTSA ↗
NHTSA investigations
8EA99032 · Dual Fuel Tank Crossflow/leakage
Opened Nov 4, 1999 · Closed Dec 6, 2001
Status: closed (inferred from source dates) · Vehicle Speed Control:linkages
ON JULY 14, 1993 FORD FILED A DEFECT INFORMATION REPORT CONCERNING FUEL TANK CROSS FLOW LEAKAGE ON F-SERIES LIGHT TRUCKS AND CAB CHASSIS BUILT FROM JULY 22, 1989 THROUGH DECEMBER 17, 1992.THE REMEDY WAS TO REPLACE THE FUEL PRESSURE REGULATOR AND INSTALL A CHECK VALVE BETWEEN EACH FUEL SUPPLY LINE AND FUEL TANK (2) TO REPAIR THE SUPPLY SIDE FUEL CROSS FLOW PROBLEM (RECALL 93V-125).ODI OPENED RQ98-008 ON MAY 29, 1998 BECAUSE OF THE LARGE NUMBER OF ALLEGED REMEDY FAILURES AND REPORTS OF FUEL CROSS FLOW ON VEHICLES OUTSIDE OF THE RECALL POPULATION.BASED ONTHE INFORMATION RECEIVED FROM FORD ON AUGUST 11, SEPTEMBER 30, AND DECEMBER 15, 1998, AND THE INCREASING TREND OF REMEDY FAILURES AND OUT OF SCOPE CROSSFLOW REPORTS, ODI OPENED EA99-032 ON NOVEMBER 4, 1999.THE ATTACHED ENGINEERING ANALYSIS CLOSING REPORT FULLY DESCRIBES THE RESULTS OF THIS INVESTIGATION AND REASON FOR CLOSING.THE SUBJECT VEHICLES CAN EXPERIENCE FUEL TRANSFER FROM ONE TANK TO THE OTHER DUE TO MALFUNCTIONS IN THE FUEL SYSTEM.WHEN FUEL IS PUMPED OR RETURNED TO THE NON-OPERATING TANK (CROSS FLOW), THE CAPACITY OF THE NON-OPERATING TANK CAN BE EXCEEDED, CAUSING FUEL TO OVERFLOW PAST THE FILLER CAP, CREATING A FIRE POTENTIAL.
Additional source detail variants (2)
Vehicle Speed Control:linkages
ON JULY 14, 1993 FORD FILED A DEFECT INFORMATION REPORT CONCERNING FUEL TANK CROSS FLOW LEAKAGE ON F-SERIES LIGHT TRUCKS AND CAB CHASSIS BUILT FROM JULY 22, 1989 THROUGH DECEMBER 17, 1992.THE REMEDY WAS TO REPLACE THE FUEL PRESSURE REGULATOR AND INSTALL A CHECK VALVE BETWEEN EACH FUEL SUPPLY LINE AND FUEL TANK (2) TO REPAIR THE SUPPLY SIDE FUEL CROSS FLOW PROBLEM (RECALL 93V-125).ODI OPENED RQ98-008 ON MAY 29, 1998 BECAUSE OF THE LARGE NUMBER OF ALLEGED REMEDY FAILURES AND REPORTS OF FUEL CROSS FLOW ON VEHICLES OUTSIDE OF THE RECALL POPULATION.BASED ONTHE INFORMATION RECEIVED FROM FORD ON AUGUST 11, SEPTEMBER 30, AND DECEMBER 15, 1998, AND THE INCREASING TREND OF REMEDY FAILURES AND OUT OF SCOPE CROSSFLOW REPORTS, ODI OPENED EA99-032 ON NOVEMBER 4, 1999.THE ATTACHED ENGINEERING ANALYSIS CLOSING REPORT FULLY DESCRIBES THE RESULTS OF THIS INVESTIGATION AND REASON FOR CLOSING.THE SUBJECT VEHICLES CAN EXPERIENCE FUEL TRANSFER FROM ONE TANK TO THE OTHER DUE TO MALFUNCTIONS IN THE FUEL SYSTEM.WHEN FUEL IS PUMPED OR RETURNED TO THE NON-OPERATING TANK (CROSS FLOW), THE CAPACITY OF THE NON-OPERATING TANK CAN BE EXCEEDED, CAUSING FUEL TO OVERFLOW PAST THE FILLER CAP, CREATING A FIRE POTENTIAL.
Vehicle Speed Control:linkages
ON JULY 14, 1993 FORD FILED A DEFECT INFORMATION REPORT CONCERNING FUEL TANK CROSS FLOW LEAKAGE ON F-SERIES LIGHT TRUCKS AND CAB CHASSIS BUILT FROM JULY 22, 1989 THROUGH DECEMBER 17, 1992.THE REMEDY WAS TO REPLACE THE FUEL PRESSURE REGULATOR AND INSTALL A CHECK VALVE BETWEEN EACH FUEL SUPPLY LINE AND FUEL TANK (2) TO REPAIR THE SUPPLY SIDE FUEL CROSS FLOW PROBLEM (RECALL 93V-125).ODI OPENED RQ98-008 ON MAY 29, 1998 BECAUSE OF THE LARGE NUMBER OF ALLEGED REMEDY FAILURES AND REPORTS OF FUEL CROSS FLOW ON VEHICLES OUTSIDE OF THE RECALL POPULATION.BASED ONTHE INFORMATION RECEIVED FROM FORD ON AUGUST 11, SEPTEMBER 30, AND DECEMBER 15, 1998, AND THE INCREASING TREND OF REMEDY FAILURES AND OUT OF SCOPE CROSSFLOW REPORTS, ODI OPENED EA99-032 ON NOVEMBER 4, 1999.THE ATTACHED ENGINEERING ANALYSIS CLOSING REPORT FULLY DESCRIBES THE RESULTS OF THIS INVESTIGATION AND REASON FOR CLOSING.THE SUBJECT VEHICLES CAN EXPERIENCE FUEL TRANSFER FROM ONE TANK TO THE OTHER DUE TO MALFUNCTIONS IN THE FUEL SYSTEM.WHEN FUEL IS PUMPED OR RETURNED TO THE NON-OPERATING TANK (CROSS FLOW), THE CAPACITY OF THE NON-OPERATING TANK CAN BE EXCEEDED, CAUSING FUEL TO OVERFLOW PAST THE FILLER CAP, CREATING A FIRE POTENTIAL.
RQ98008 · Ford F-SERIES Dual Fuel Tank Leakage
Opened May 29, 1998 · Closed Nov 4, 1999
Status: closed (inferred from source dates) · Fuel System, Gasoline:storage:tank Assembly
THESE VEHICLES CAN EXPERIENCE FUEL TRANSFER FROM ONE TANK TO THE OTHER DUE TO A MALFUNCTIONING FUEL PUMP.FROM THE INFORMATION GATHERED TO DATE, IT APPEARS THAT THERE CAN BE MULTIPLE CAUSES AND/OR A COMBINATION OF CAUSES FOR FUEL CROSS FLOW AND THAT THE RECALL REMEDY MAY BE INADEQUATE.FURTHER INVESTIGATION IS NEEDED.THIS INVESTIGATION IS UPGRADED TO EA99-032.CLICK ON DOCUMENT SEARCH BUTTON FOR ADDITIONAL INFORMATION.
EA93022 · Idle Air Spd Ctrl Vlv Malf
Opened Jul 30, 1993 · Closed Aug 31, 1994
Status: closed (inferred from source dates) · Engine And Engine Cooling
There is no summary currently available
EA93020 · Parking Brake Failure
Opened Jul 28, 1993 · Closed Sep 23, 1994
Status: closed (inferred from source dates) · Service Brakes, Hydraulic
There is no summary currently available
Additional source detail variants (2)
Service Brakes, Hydraulic
There is no summary currently available
Service Brakes, Hydraulic
There is no summary currently available
PE93015 · Parking Brake Failure
Opened Mar 9, 1993 · Closed Jul 27, 1993
Status: closed (inferred from source dates) · Service Brakes, Hydraulic
There is no summary currently available
PE93010 · Idle Air Spd Ctrl Vlv Malf
Opened Mar 2, 1993 · Closed Jul 30, 1993
Status: closed (inferred from source dates) · Engine And Engine Cooling
There is no summary currently available
EA93001 · Fuel Expulsion
Opened Jan 7, 1993 · Closed Aug 20, 1993
Status: closed (inferred from source dates) · Vehicle Speed Control:linkages
There is no summary currently available
PE92077 · Fuel Expulsion
Opened Sep 9, 1992 · Closed Jan 7, 1993
Status: closed (inferred from source dates) · Vehicle Speed Control:linkages
There is no summary currently available