IllustrationCONSUMER IS THE THIRD OWNER OF VEHICLE WHO STATED THAT RECALL 93V125000 REPAIRS WAS NEVER PREFORMED. DEALER REFUSED TO CORRECT PROBLEM WITHOUT CHARGE. CLAIMED THAT PART WAS PUT IN. THAT WOULD MEAN THE PART WAS CHANGED 4 TIMES. *AK
1991 Ford F-150
Owner reports · Recalls · Investigations
Similar to other model years
Owner complaints for the 1991 Ford F-150 do not stand out strongly from the model-year median of 676.
About this comparison →How this year compares
Owner complaints by model year
Compare all F-150 years →Counts vary with age, sales and reporting. They are not failure rates.
What owners reported most
All reported categories
Tap a category to read its complaints. One report may name several components.
When problems were reported
Mileage at the reported incident
Limited mileage data: 39 of 304 reports include usable mileage. There isn’t enough coverage to show a useful chart.
NHTSA’s mileage field refers to the reported incident, not necessarily the filing date. This shows report counts, not the likelihood of a failure.
What to inspect
Issues worth paying extra attention to based on owner reports.
- Fuel System, Gasoline. Review the 149 owner reports in this category and discuss these concerns during a pre-purchase inspection. Read reports →
- Electrical System. Review the 50 owner reports in this category and discuss these concerns during a pre-purchase inspection. Read reports →
- Service Brakes, Hydraulic. Review the 23 owner reports in this category and discuss these concerns during a pre-purchase inspection. Read reports →
NHTSA owner reports · September 18, 2026 snapshot.
12 crash reports41 fire reports7 injury reports
Fuel System, Gasoline complaints
149 reportsFUEL TANK LEAKING A SEAM WHERE WELDED TOGETHER. *MJS
EA990032, DUAL FUEL TANK CROSSFLOW /LEAKAGE; THE REAR FUEL TANK LEAKS AT THE SEAM WHEN THE TANK IS HALF FULL OR MORE. CUSTOMER SERVICE WAS CALLED ABOUT THE PROBLEM. THE PROBLEM HAS NOT BEEN CORRECTED. *AK
WHEN THE GAS TANKS IS FULL FRONT TANK OVERFLOWS THE REAR TANK, CAUSING THE FUEL TO RUN OUT DOWN THE SIDE OF THE TRUCK. DEALER HAS BEEN CONTACTED. *AK
POSSIBLE FUEL SYSTEM FAILURE RESULTED IN FIRE TO COME UPM FROM BETWEEN THE CAB AND THE BED OF THE TRUCK. NLM
A CHECK VALVE IN THE FRONT FUEL TANK HAS GONE BAD SENDING THE FUEL TO THE SECOND TANK, RESULTING IN FUEL SPILLAGE. A RECALL HAS BEEN ISSUED ON THE VEHICLE'S MAKE AND MODEL. HOWEVER, THIS VEHICLE IS NOT INCLUDED IN THE RECALL DUE TO VIN. *AK AFTER RECALL 93S68 WAS DONE, FUEL WAS STILL GOING FROM A REAR FUEL TANK TO FRONT TA…
Read full complaint
A CHECK VALVE IN THE FRONT FUEL TANK HAS GONE BAD SENDING THE FUEL TO THE SECOND TANK, RESULTING IN FUEL SPILLAGE. A RECALL HAS BEEN ISSUED ON THE VEHICLE'S MAKE AND MODEL. HOWEVER, THIS VEHICLE IS NOT INCLUDED IN THE RECALL DUE TO VIN. *AK AFTER RECALL 93S68 WAS DONE, FUEL WAS STILL GOING FROM A REAR FUEL TANK TO FRONT TANKS OVER FLOWING A FRONT TANK. CONSUMER CONTACTS THE DEALER AND TOLD FRONT FUEL PUMP WAS THE CAUSE . DEALER IS NOT WILLING TO FIX IT. *YH
FUEL LEAKAGE - AFTER RECALL WAS PERFORMED APX. TWO TIMES PER YEAR FUEL WOULD CROSS FLOW BETWEEN TANKS - 3 FUEL PUMP , ONE TANK, PRESSURE RELIEF VALVE, FUEL LINE VALVES REPLACED - CHECK VALVES THAT WERE INSTALLED AS PART OF RECALL REMOVED AS BEING PART OF PROBLEM WITH EXCESSIVE TANK PRESSURE - MANUFACTURER HAS OVER 50 PAGES OF …
Read full complaint
FUEL LEAKAGE - AFTER RECALL WAS PERFORMED APX. TWO TIMES PER YEAR FUEL WOULD CROSS FLOW BETWEEN TANKS - 3 FUEL PUMP , ONE TANK, PRESSURE RELIEF VALVE, FUEL LINE VALVES REPLACED - CHECK VALVES THAT WERE INSTALLED AS PART OF RECALL REMOVED AS BEING PART OF PROBLEM WITH EXCESSIVE TANK PRESSURE - MANUFACTURER HAS OVER 50 PAGES OF TECHNICAL BULLETINS RELATED TO FUEL LINE + PUMP PROBLEMS. *AK
AFTER FILLING THE GAS TANKS THE FRONT TANK WILL LEAK GAS OUT ON TO THE GARAGE FLOOR. THIS CAUSES FUME WHICH ARE DANGEROUS. THE LOCAL FORD DEALER SAYS THERE IS NO RECALL ON THIS SITUATION. OUR LOCAL NEWSPAPER THE STAR TELEGRAM OF FT. WORTH RAN AN ARTICLE CONCERNING THIS PROBLEM SEVERAL WEEKS BACK. AS I RECALL IT STATED THAT FO…
Read full complaint
AFTER FILLING THE GAS TANKS THE FRONT TANK WILL LEAK GAS OUT ON TO THE GARAGE FLOOR. THIS CAUSES FUME WHICH ARE DANGEROUS. THE LOCAL FORD DEALER SAYS THERE IS NO RECALL ON THIS SITUATION. OUR LOCAL NEWSPAPER THE STAR TELEGRAM OF FT. WORTH RAN AN ARTICLE CONCERNING THIS PROBLEM SEVERAL WEEKS BACK. AS I RECALL IT STATED THAT FORD HAD RECALLED SOME 1990 TO 1993 FORD PICKUPS WITH THE DUAL TANKS FOR THIS PROBLEM. I AM TRYING TO LOCATE THE ARTICLE AND WILL INFORM YOU IF I AM ABLE TO FIND IT. I WAS GOING TO HAVE THIS REPAIRED THE FORD DEALER PAYTON WRIGHT SAYS THAT THERE IS NO RECALL ON IT AND THAT IT WILL COST OVER $1,000.00 TO REPAIR IT. IT IS MY BELIEF THAT THIS IS A MANUFACTURING DEFECT AND SHOULD BE CORRECTED BY FORD MOTOR COMPANY. I WILL HAVE TO HAVE IT REPAIRED AS IT COLD VERY EASILY CAUSE A FIRE. *AK
WHILE TRAVELING ON HIGHWAY NOTICED FUEL LEAKING FROM FULE LINE. DLR HAS BEEN NOTIFIED. PLEASE PROVIDE FURTHER INFORMATON. *AK
WHILE TRAVELING ON HIGHWAY NOTICED FUEL LEAKING FROM FUEL LINE. DEALER HAS BEEN NOTIFIED. *AK
Official recalls
396V071000 · Electrical System:ignition
Apr 25, 1996
THE IGNITION SWITCH COULD EXPERIENCE AN INTERNAL SHORT CIRCUIT.
Consequence & remedy
Consequence: THIS CONDITION COULD CAUSE OVERHEATING, SMOKE, AND POSSIBLY FIRE IN THE STEERING COLUMN AREA OF THE VEHICLE.
Remedy: DEALERS WILL REPLACE THE IGNITION SWITCH.
93V125000 · Fuel System, Gasoline:storage:tank Assembly
Aug 2, 1993
A MALFUNCTIONING CHECK VALVE WITHIN THE FUEL PUMP ASSEMBLY CAUSES A PORTION OF THE UNUSED FUEL FROM ONE TANK TO BE RETURNED TO THE SECOND TANK. WHEN THIS OCCURS, THE CAPACITY OF THE SECOND TANK CAN BE EXCEEDED, CAUSING FUEL SPILLAGE.
Consequence & remedy
Consequence: SPILLED FUEL CAN RESULT IN A FIRE WHEN EXPOSED TO ASOURCE OF IGNITION.
Remedy: REPLACEMENT OF THE FUEL PRESSURE REGULATOR AND INSTALLATION OF REDUNDANT CHECK VALVES.
93V066000 · Steering: Steering Wheel/handle Bar
Apr 27, 1993
KEYS ATTACHED TO THE KEY RING OF AN IGNITION KEY WHILE IT IS IN THE VEHICLE IGNITION CAN BECOME LODGED IN THE STEERING LOCK RECEIVER AS THE STEERING WHEEL IS BEING TURNED.
Consequence & remedy
Consequence: THE LODGED KEYS CAN CAUSE LOSS OF STEERING CONTROL, WHICHCAN RESULT IN AN ACCIDENT WHEN THE VEHICLE IS BEING USED ON THE HIGHWAY.
Remedy: A SHIELD WILL BE POSITIONED BETWEEN THE STEERING WHEEL AND THE IGNITION SWITCH AND HELD IN PLACE BY THE STEERING LOCK BAND.
Model-level recall history does not show whether a particular VIN is affected or has received a repair. Check a VIN with NHTSA ↗
NHTSA investigations
12EA99032 · Dual Fuel Tank Crossflow/leakage
Opened Nov 4, 1999 · Closed Dec 6, 2001
Status: closed (inferred from source dates) · Vehicle Speed Control:linkages
ON JULY 14, 1993 FORD FILED A DEFECT INFORMATION REPORT CONCERNING FUEL TANK CROSS FLOW LEAKAGE ON F-SERIES LIGHT TRUCKS AND CAB CHASSIS BUILT FROM JULY 22, 1989 THROUGH DECEMBER 17, 1992.THE REMEDY WAS TO REPLACE THE FUEL PRESSURE REGULATOR AND INSTALL A CHECK VALVE BETWEEN EACH FUEL SUPPLY LINE AND FUEL TANK (2) TO REPAIR THE SUPPLY SIDE FUEL CROSS FLOW PROBLEM (RECALL 93V-125).ODI OPENED RQ98-008 ON MAY 29, 1998 BECAUSE OF THE LARGE NUMBER OF ALLEGED REMEDY FAILURES AND REPORTS OF FUEL CROSS FLOW ON VEHICLES OUTSIDE OF THE RECALL POPULATION.BASED ONTHE INFORMATION RECEIVED FROM FORD ON AUGUST 11, SEPTEMBER 30, AND DECEMBER 15, 1998, AND THE INCREASING TREND OF REMEDY FAILURES AND OUT OF SCOPE CROSSFLOW REPORTS, ODI OPENED EA99-032 ON NOVEMBER 4, 1999.THE ATTACHED ENGINEERING ANALYSIS CLOSING REPORT FULLY DESCRIBES THE RESULTS OF THIS INVESTIGATION AND REASON FOR CLOSING.THE SUBJECT VEHICLES CAN EXPERIENCE FUEL TRANSFER FROM ONE TANK TO THE OTHER DUE TO MALFUNCTIONS IN THE FUEL SYSTEM.WHEN FUEL IS PUMPED OR RETURNED TO THE NON-OPERATING TANK (CROSS FLOW), THE CAPACITY OF THE NON-OPERATING TANK CAN BE EXCEEDED, CAUSING FUEL TO OVERFLOW PAST THE FILLER CAP, CREATING A FIRE POTENTIAL.
Additional source detail variants (2)
Vehicle Speed Control:linkages
ON JULY 14, 1993 FORD FILED A DEFECT INFORMATION REPORT CONCERNING FUEL TANK CROSS FLOW LEAKAGE ON F-SERIES LIGHT TRUCKS AND CAB CHASSIS BUILT FROM JULY 22, 1989 THROUGH DECEMBER 17, 1992.THE REMEDY WAS TO REPLACE THE FUEL PRESSURE REGULATOR AND INSTALL A CHECK VALVE BETWEEN EACH FUEL SUPPLY LINE AND FUEL TANK (2) TO REPAIR THE SUPPLY SIDE FUEL CROSS FLOW PROBLEM (RECALL 93V-125).ODI OPENED RQ98-008 ON MAY 29, 1998 BECAUSE OF THE LARGE NUMBER OF ALLEGED REMEDY FAILURES AND REPORTS OF FUEL CROSS FLOW ON VEHICLES OUTSIDE OF THE RECALL POPULATION.BASED ONTHE INFORMATION RECEIVED FROM FORD ON AUGUST 11, SEPTEMBER 30, AND DECEMBER 15, 1998, AND THE INCREASING TREND OF REMEDY FAILURES AND OUT OF SCOPE CROSSFLOW REPORTS, ODI OPENED EA99-032 ON NOVEMBER 4, 1999.THE ATTACHED ENGINEERING ANALYSIS CLOSING REPORT FULLY DESCRIBES THE RESULTS OF THIS INVESTIGATION AND REASON FOR CLOSING.THE SUBJECT VEHICLES CAN EXPERIENCE FUEL TRANSFER FROM ONE TANK TO THE OTHER DUE TO MALFUNCTIONS IN THE FUEL SYSTEM.WHEN FUEL IS PUMPED OR RETURNED TO THE NON-OPERATING TANK (CROSS FLOW), THE CAPACITY OF THE NON-OPERATING TANK CAN BE EXCEEDED, CAUSING FUEL TO OVERFLOW PAST THE FILLER CAP, CREATING A FIRE POTENTIAL.
Vehicle Speed Control:linkages
ON JULY 14, 1993 FORD FILED A DEFECT INFORMATION REPORT CONCERNING FUEL TANK CROSS FLOW LEAKAGE ON F-SERIES LIGHT TRUCKS AND CAB CHASSIS BUILT FROM JULY 22, 1989 THROUGH DECEMBER 17, 1992.THE REMEDY WAS TO REPLACE THE FUEL PRESSURE REGULATOR AND INSTALL A CHECK VALVE BETWEEN EACH FUEL SUPPLY LINE AND FUEL TANK (2) TO REPAIR THE SUPPLY SIDE FUEL CROSS FLOW PROBLEM (RECALL 93V-125).ODI OPENED RQ98-008 ON MAY 29, 1998 BECAUSE OF THE LARGE NUMBER OF ALLEGED REMEDY FAILURES AND REPORTS OF FUEL CROSS FLOW ON VEHICLES OUTSIDE OF THE RECALL POPULATION.BASED ONTHE INFORMATION RECEIVED FROM FORD ON AUGUST 11, SEPTEMBER 30, AND DECEMBER 15, 1998, AND THE INCREASING TREND OF REMEDY FAILURES AND OUT OF SCOPE CROSSFLOW REPORTS, ODI OPENED EA99-032 ON NOVEMBER 4, 1999.THE ATTACHED ENGINEERING ANALYSIS CLOSING REPORT FULLY DESCRIBES THE RESULTS OF THIS INVESTIGATION AND REASON FOR CLOSING.THE SUBJECT VEHICLES CAN EXPERIENCE FUEL TRANSFER FROM ONE TANK TO THE OTHER DUE TO MALFUNCTIONS IN THE FUEL SYSTEM.WHEN FUEL IS PUMPED OR RETURNED TO THE NON-OPERATING TANK (CROSS FLOW), THE CAPACITY OF THE NON-OPERATING TANK CAN BE EXCEEDED, CAUSING FUEL TO OVERFLOW PAST THE FILLER CAP, CREATING A FIRE POTENTIAL.
RQ98008 · Ford F-SERIES Dual Fuel Tank Leakage
Opened May 29, 1998 · Closed Nov 4, 1999
Status: closed (inferred from source dates) · Fuel System, Gasoline:storage:tank Assembly
THESE VEHICLES CAN EXPERIENCE FUEL TRANSFER FROM ONE TANK TO THE OTHER DUE TO A MALFUNCTIONING FUEL PUMP.FROM THE INFORMATION GATHERED TO DATE, IT APPEARS THAT THERE CAN BE MULTIPLE CAUSES AND/OR A COMBINATION OF CAUSES FOR FUEL CROSS FLOW AND THAT THE RECALL REMEDY MAY BE INADEQUATE.FURTHER INVESTIGATION IS NEEDED.THIS INVESTIGATION IS UPGRADED TO EA99-032.CLICK ON DOCUMENT SEARCH BUTTON FOR ADDITIONAL INFORMATION.
EA93022 · Idle Air Spd Ctrl Vlv Malf
Opened Jul 30, 1993 · Closed Aug 31, 1994
Status: closed (inferred from source dates) · Engine And Engine Cooling
There is no summary currently available
PE93010 · Idle Air Spd Ctrl Vlv Malf
Opened Mar 2, 1993 · Closed Jul 30, 1993
Status: closed (inferred from source dates) · Engine And Engine Cooling
There is no summary currently available
EA93001 · Fuel Expulsion
Opened Jan 7, 1993 · Closed Aug 20, 1993
Status: closed (inferred from source dates) · Vehicle Speed Control:linkages
There is no summary currently available
PE92077 · Fuel Expulsion
Opened Sep 9, 1992 · Closed Jan 7, 1993
Status: closed (inferred from source dates) · Vehicle Speed Control:linkages
There is no summary currently available
EA92029 · Front Seat Back Failure
Opened Aug 27, 1992 · Closed Oct 29, 1993
Status: closed (inferred from source dates) · Seats
There is no summary currently available
PE92042 · Fnt Reclning Seat Bck Fail
Opened Apr 17, 1992 · Closed Aug 27, 1992
Status: closed (inferred from source dates) · Seats:front Assembly:recliner
There is no summary currently available
EA91044 · Loss Of Brake Effectivenes
Opened Oct 30, 1991 · Closed Oct 30, 1992
Status: closed (inferred from source dates) · Service Brakes, Hydraulic
===
EA91031 · Fuel Expulsion
Opened Jun 26, 1991 · Closed Nov 1, 1991
Status: closed (inferred from source dates) · Vehicle Speed Control:linkages
There is no summary currently available
PE91077 · Loss Of Brake Effectivenes
Opened May 23, 1991 · Closed Oct 31, 1991
Status: closed (inferred from source dates) · Service Brakes, Hydraulic
There is no summary currently available
PE91064 · Transmission Fluid Fires
Opened Apr 9, 1991 · Closed Jul 5, 1991
Status: closed (inferred from source dates) · Power Train
There is no summary currently available