IllustrationNO SUMMARY LISTED FOR ABOVE VEHICLE. *AK
1991 Ford F-150
Owner reports · Recalls · Investigations
Similar to other model years
Owner complaints for the 1991 Ford F-150 do not stand out strongly from the model-year median of 676.
About this comparison →How this year compares
Owner complaints by model year
Compare all F-150 years →Counts vary with age, sales and reporting. They are not failure rates.
What owners reported most
All reported categories
Tap a category to read its complaints. One report may name several components.
When problems were reported
Mileage at the reported incident
Limited mileage data: 39 of 304 reports include usable mileage. There isn’t enough coverage to show a useful chart.
NHTSA’s mileage field refers to the reported incident, not necessarily the filing date. This shows report counts, not the likelihood of a failure.
What to inspect
Issues worth paying extra attention to based on owner reports.
- Fuel System, Gasoline. Review the 149 owner reports in this category and discuss these concerns during a pre-purchase inspection. Read reports →
- Electrical System. Review the 50 owner reports in this category and discuss these concerns during a pre-purchase inspection. Read reports →
- Service Brakes, Hydraulic. Review the 23 owner reports in this category and discuss these concerns during a pre-purchase inspection. Read reports →
NHTSA owner reports · September 18, 2026 snapshot.
12 crash reports41 fire reports7 injury reports
Fuel System, Gasoline complaints
149 reportsRECALL 93V125000. A PORTION OF UNUSED FUEL FROM ONE TANK IS BEING RETURNED TO SECOND TANK, CAUSING SECOND TANK TO EXCEED THE CAPACITY, RESULTING IN FUEL SPILLAGE. MANUFACTURER HAS BEEN NOTIFIED, AND INFORMED COMSUMER THAT VEHICLE IS INCLUDED UNDER THE RECALL; HOWEVER, RECALL HAS EXPIRED.*AK RECALL ON FUEL TANK PREVIOUSL…
Read full complaint
RECALL 93V125000. A PORTION OF UNUSED FUEL FROM ONE TANK IS BEING RETURNED TO SECOND TANK, CAUSING SECOND TANK TO EXCEED THE CAPACITY, RESULTING IN FUEL SPILLAGE. MANUFACTURER HAS BEEN NOTIFIED, AND INFORMED COMSUMER THAT VEHICLE IS INCLUDED UNDER THE RECALL; HOWEVER, RECALL HAS EXPIRED.*AK RECALL ON FUEL TANK PREVIOUSLY FIXED IN 1993 BROKE IN 2000 DEALER NOT WILLING TO FIX IT. *YH
A MALFUNCTIONING CHECK VALVE ALLOWS A PORTION OF UNUSED FUEL TO TRANSFER TO THE SECOND TANK ,CAUSING FUEL SPILLAGE. VEHICLE NOT INCLUDED IN RECALL 93V125000. *AK THE REAR TANK DRAINS THE FUEL INTO THE FRONT TANK, AND THEN IT SPILLS OUT ONTO THE GROUND. *YH
A PROTION FROM OF UNUSED FUEL FROM ONE TANK IS RETURNING TO THE SECOND TANK, CAUSING FUEL SPILLAGE. A RECALL HAS BEEN ISSUED ON VEHICLE MAKE AND MODEL; HOIWEVER, THIS VEHICLE WAS NOT INCLUDED DUE TO VIN. MANUFACTURER WILL BE NOTIFIED.*AK
OWNER WAS HAVING TROUBLE WITH FUEL FLOWING FROM ONE TANK TO ANOTHER & OVERFLOWING ONTO THE GROUND. BROUGHT VEHICLE IN 10/10/95. SPOKE TO DEALERSHIP & WAS INFORMED THAT MANUFACTURER INDICATED THAT VEHICLE WAS REPAIRED IN 1996. OWNER HAS NOT TAKEN VEHICLE FOR REPAIRS OF FUEL TANK. TOOK TO DEALER & SERVICE MANAGER CHECKED FUEL TANK…
Read full complaint
OWNER WAS HAVING TROUBLE WITH FUEL FLOWING FROM ONE TANK TO ANOTHER & OVERFLOWING ONTO THE GROUND. BROUGHT VEHICLE IN 10/10/95. SPOKE TO DEALERSHIP & WAS INFORMED THAT MANUFACTURER INDICATED THAT VEHICLE WAS REPAIRED IN 1996. OWNER HAS NOT TAKEN VEHICLE FOR REPAIRS OF FUEL TANK. TOOK TO DEALER & SERVICE MANAGER CHECKED FUEL TANKS & DID NOT FIND ANY VISIBLE SIGNS OF REPAIRS. RECALL CAMPAIGN #93V125000.*AK
VEHICLE HAS A 116 WHEEL BASE SHORT BED W/ DUAL GAS TANKS. FUEL LINE WHICH WAS PLASTIC AND LOCATED TOO CLOSELY TO MUFFLER, MELTED UNDER HOT CONDITIONS AND SPRAYED GAS ALL OVER HIGHWAY. CONSUMER TOOK VEHICLE TO DEALER, AND THEY REPLACED THE FUEL LINE ESTZ9291AH AND COUPLING N8034341S. THIS IS COMMOM ON 1991 AND 1992 MODELS. CONS…
Read full complaint
VEHICLE HAS A 116 WHEEL BASE SHORT BED W/ DUAL GAS TANKS. FUEL LINE WHICH WAS PLASTIC AND LOCATED TOO CLOSELY TO MUFFLER, MELTED UNDER HOT CONDITIONS AND SPRAYED GAS ALL OVER HIGHWAY. CONSUMER TOOK VEHICLE TO DEALER, AND THEY REPLACED THE FUEL LINE ESTZ9291AH AND COUPLING N8034341S. THIS IS COMMOM ON 1991 AND 1992 MODELS. CONSUMER STATED THAT PASSENGER WAS INJURED TRYING TO EXIT VEHICLE. *AK CONSUMER FEELS THAT THE TANK NEEDS A HEAT SHIELD TO PROTECT IT FROM MUFFLER HEAT. *SLC
CONSUMER CONTACTED DEALER IN REFERENCE TO NHTSA RECALL 93V125000/ MANUFACTURER'S RECALL 93S68. DEALER REFUSED TO CORRECT RECALL PROBLEM STATED RECALL WORK WAS PREVIOUSLY CORRECTED. CONSUMER NOTED VEHICLE WAS NEVER TAKEN TO THE DEALER FOR RECALL PROBLEM. PLEASE PROVIDE ANY FURTHER DETAILS.*AK
THE TRUCK HAD BEEN SITTING TWO WEEKS,TODAY NOTICE A FUEL DRIPPING ( CONSTANT DRIP ACTION) FROM FRONT FUEL TANK. CALLED A DEALER BUT WAS UNABLE TO ASSIST OVER THE PHONE.
VEHICLE HAS DUAL TANK AND DUAL FUEL PUMPS. ONE IS PUMPING FUEL INTO FUEL PUMP TWO AND THERE IS AN OVERFLOW. *AK
FUEL SPILLS WHILE FILLING UP TANK, A MECHANIC STATED THAT THE VALVE FOR 2 GAS TANKS WERE NOT WORKING, THE GAS FROM THE FRONT TANK IS GOING TO THE BACK TANK AND GAS FROM THE BACK TANK TO THE FRONT, CAUSING IT TO SPILL, THERE IS A RECALL REGARDING THIS 93V125, HOWEVER FORD STATED TO CONSUMER THAT IT WAS NOT THEIR PROBLEM. *SLC
Official recalls
396V071000 · Electrical System:ignition
Apr 25, 1996
THE IGNITION SWITCH COULD EXPERIENCE AN INTERNAL SHORT CIRCUIT.
Consequence & remedy
Consequence: THIS CONDITION COULD CAUSE OVERHEATING, SMOKE, AND POSSIBLY FIRE IN THE STEERING COLUMN AREA OF THE VEHICLE.
Remedy: DEALERS WILL REPLACE THE IGNITION SWITCH.
93V125000 · Fuel System, Gasoline:storage:tank Assembly
Aug 2, 1993
A MALFUNCTIONING CHECK VALVE WITHIN THE FUEL PUMP ASSEMBLY CAUSES A PORTION OF THE UNUSED FUEL FROM ONE TANK TO BE RETURNED TO THE SECOND TANK. WHEN THIS OCCURS, THE CAPACITY OF THE SECOND TANK CAN BE EXCEEDED, CAUSING FUEL SPILLAGE.
Consequence & remedy
Consequence: SPILLED FUEL CAN RESULT IN A FIRE WHEN EXPOSED TO ASOURCE OF IGNITION.
Remedy: REPLACEMENT OF THE FUEL PRESSURE REGULATOR AND INSTALLATION OF REDUNDANT CHECK VALVES.
93V066000 · Steering: Steering Wheel/handle Bar
Apr 27, 1993
KEYS ATTACHED TO THE KEY RING OF AN IGNITION KEY WHILE IT IS IN THE VEHICLE IGNITION CAN BECOME LODGED IN THE STEERING LOCK RECEIVER AS THE STEERING WHEEL IS BEING TURNED.
Consequence & remedy
Consequence: THE LODGED KEYS CAN CAUSE LOSS OF STEERING CONTROL, WHICHCAN RESULT IN AN ACCIDENT WHEN THE VEHICLE IS BEING USED ON THE HIGHWAY.
Remedy: A SHIELD WILL BE POSITIONED BETWEEN THE STEERING WHEEL AND THE IGNITION SWITCH AND HELD IN PLACE BY THE STEERING LOCK BAND.
Model-level recall history does not show whether a particular VIN is affected or has received a repair. Check a VIN with NHTSA ↗
NHTSA investigations
12EA99032 · Dual Fuel Tank Crossflow/leakage
Opened Nov 4, 1999 · Closed Dec 6, 2001
Status: closed (inferred from source dates) · Vehicle Speed Control:linkages
ON JULY 14, 1993 FORD FILED A DEFECT INFORMATION REPORT CONCERNING FUEL TANK CROSS FLOW LEAKAGE ON F-SERIES LIGHT TRUCKS AND CAB CHASSIS BUILT FROM JULY 22, 1989 THROUGH DECEMBER 17, 1992.THE REMEDY WAS TO REPLACE THE FUEL PRESSURE REGULATOR AND INSTALL A CHECK VALVE BETWEEN EACH FUEL SUPPLY LINE AND FUEL TANK (2) TO REPAIR THE SUPPLY SIDE FUEL CROSS FLOW PROBLEM (RECALL 93V-125).ODI OPENED RQ98-008 ON MAY 29, 1998 BECAUSE OF THE LARGE NUMBER OF ALLEGED REMEDY FAILURES AND REPORTS OF FUEL CROSS FLOW ON VEHICLES OUTSIDE OF THE RECALL POPULATION.BASED ONTHE INFORMATION RECEIVED FROM FORD ON AUGUST 11, SEPTEMBER 30, AND DECEMBER 15, 1998, AND THE INCREASING TREND OF REMEDY FAILURES AND OUT OF SCOPE CROSSFLOW REPORTS, ODI OPENED EA99-032 ON NOVEMBER 4, 1999.THE ATTACHED ENGINEERING ANALYSIS CLOSING REPORT FULLY DESCRIBES THE RESULTS OF THIS INVESTIGATION AND REASON FOR CLOSING.THE SUBJECT VEHICLES CAN EXPERIENCE FUEL TRANSFER FROM ONE TANK TO THE OTHER DUE TO MALFUNCTIONS IN THE FUEL SYSTEM.WHEN FUEL IS PUMPED OR RETURNED TO THE NON-OPERATING TANK (CROSS FLOW), THE CAPACITY OF THE NON-OPERATING TANK CAN BE EXCEEDED, CAUSING FUEL TO OVERFLOW PAST THE FILLER CAP, CREATING A FIRE POTENTIAL.
Additional source detail variants (2)
Vehicle Speed Control:linkages
ON JULY 14, 1993 FORD FILED A DEFECT INFORMATION REPORT CONCERNING FUEL TANK CROSS FLOW LEAKAGE ON F-SERIES LIGHT TRUCKS AND CAB CHASSIS BUILT FROM JULY 22, 1989 THROUGH DECEMBER 17, 1992.THE REMEDY WAS TO REPLACE THE FUEL PRESSURE REGULATOR AND INSTALL A CHECK VALVE BETWEEN EACH FUEL SUPPLY LINE AND FUEL TANK (2) TO REPAIR THE SUPPLY SIDE FUEL CROSS FLOW PROBLEM (RECALL 93V-125).ODI OPENED RQ98-008 ON MAY 29, 1998 BECAUSE OF THE LARGE NUMBER OF ALLEGED REMEDY FAILURES AND REPORTS OF FUEL CROSS FLOW ON VEHICLES OUTSIDE OF THE RECALL POPULATION.BASED ONTHE INFORMATION RECEIVED FROM FORD ON AUGUST 11, SEPTEMBER 30, AND DECEMBER 15, 1998, AND THE INCREASING TREND OF REMEDY FAILURES AND OUT OF SCOPE CROSSFLOW REPORTS, ODI OPENED EA99-032 ON NOVEMBER 4, 1999.THE ATTACHED ENGINEERING ANALYSIS CLOSING REPORT FULLY DESCRIBES THE RESULTS OF THIS INVESTIGATION AND REASON FOR CLOSING.THE SUBJECT VEHICLES CAN EXPERIENCE FUEL TRANSFER FROM ONE TANK TO THE OTHER DUE TO MALFUNCTIONS IN THE FUEL SYSTEM.WHEN FUEL IS PUMPED OR RETURNED TO THE NON-OPERATING TANK (CROSS FLOW), THE CAPACITY OF THE NON-OPERATING TANK CAN BE EXCEEDED, CAUSING FUEL TO OVERFLOW PAST THE FILLER CAP, CREATING A FIRE POTENTIAL.
Vehicle Speed Control:linkages
ON JULY 14, 1993 FORD FILED A DEFECT INFORMATION REPORT CONCERNING FUEL TANK CROSS FLOW LEAKAGE ON F-SERIES LIGHT TRUCKS AND CAB CHASSIS BUILT FROM JULY 22, 1989 THROUGH DECEMBER 17, 1992.THE REMEDY WAS TO REPLACE THE FUEL PRESSURE REGULATOR AND INSTALL A CHECK VALVE BETWEEN EACH FUEL SUPPLY LINE AND FUEL TANK (2) TO REPAIR THE SUPPLY SIDE FUEL CROSS FLOW PROBLEM (RECALL 93V-125).ODI OPENED RQ98-008 ON MAY 29, 1998 BECAUSE OF THE LARGE NUMBER OF ALLEGED REMEDY FAILURES AND REPORTS OF FUEL CROSS FLOW ON VEHICLES OUTSIDE OF THE RECALL POPULATION.BASED ONTHE INFORMATION RECEIVED FROM FORD ON AUGUST 11, SEPTEMBER 30, AND DECEMBER 15, 1998, AND THE INCREASING TREND OF REMEDY FAILURES AND OUT OF SCOPE CROSSFLOW REPORTS, ODI OPENED EA99-032 ON NOVEMBER 4, 1999.THE ATTACHED ENGINEERING ANALYSIS CLOSING REPORT FULLY DESCRIBES THE RESULTS OF THIS INVESTIGATION AND REASON FOR CLOSING.THE SUBJECT VEHICLES CAN EXPERIENCE FUEL TRANSFER FROM ONE TANK TO THE OTHER DUE TO MALFUNCTIONS IN THE FUEL SYSTEM.WHEN FUEL IS PUMPED OR RETURNED TO THE NON-OPERATING TANK (CROSS FLOW), THE CAPACITY OF THE NON-OPERATING TANK CAN BE EXCEEDED, CAUSING FUEL TO OVERFLOW PAST THE FILLER CAP, CREATING A FIRE POTENTIAL.
RQ98008 · Ford F-SERIES Dual Fuel Tank Leakage
Opened May 29, 1998 · Closed Nov 4, 1999
Status: closed (inferred from source dates) · Fuel System, Gasoline:storage:tank Assembly
THESE VEHICLES CAN EXPERIENCE FUEL TRANSFER FROM ONE TANK TO THE OTHER DUE TO A MALFUNCTIONING FUEL PUMP.FROM THE INFORMATION GATHERED TO DATE, IT APPEARS THAT THERE CAN BE MULTIPLE CAUSES AND/OR A COMBINATION OF CAUSES FOR FUEL CROSS FLOW AND THAT THE RECALL REMEDY MAY BE INADEQUATE.FURTHER INVESTIGATION IS NEEDED.THIS INVESTIGATION IS UPGRADED TO EA99-032.CLICK ON DOCUMENT SEARCH BUTTON FOR ADDITIONAL INFORMATION.
EA93022 · Idle Air Spd Ctrl Vlv Malf
Opened Jul 30, 1993 · Closed Aug 31, 1994
Status: closed (inferred from source dates) · Engine And Engine Cooling
There is no summary currently available
PE93010 · Idle Air Spd Ctrl Vlv Malf
Opened Mar 2, 1993 · Closed Jul 30, 1993
Status: closed (inferred from source dates) · Engine And Engine Cooling
There is no summary currently available
EA93001 · Fuel Expulsion
Opened Jan 7, 1993 · Closed Aug 20, 1993
Status: closed (inferred from source dates) · Vehicle Speed Control:linkages
There is no summary currently available
PE92077 · Fuel Expulsion
Opened Sep 9, 1992 · Closed Jan 7, 1993
Status: closed (inferred from source dates) · Vehicle Speed Control:linkages
There is no summary currently available
EA92029 · Front Seat Back Failure
Opened Aug 27, 1992 · Closed Oct 29, 1993
Status: closed (inferred from source dates) · Seats
There is no summary currently available
PE92042 · Fnt Reclning Seat Bck Fail
Opened Apr 17, 1992 · Closed Aug 27, 1992
Status: closed (inferred from source dates) · Seats:front Assembly:recliner
There is no summary currently available
EA91044 · Loss Of Brake Effectivenes
Opened Oct 30, 1991 · Closed Oct 30, 1992
Status: closed (inferred from source dates) · Service Brakes, Hydraulic
===
EA91031 · Fuel Expulsion
Opened Jun 26, 1991 · Closed Nov 1, 1991
Status: closed (inferred from source dates) · Vehicle Speed Control:linkages
There is no summary currently available
PE91077 · Loss Of Brake Effectivenes
Opened May 23, 1991 · Closed Oct 31, 1991
Status: closed (inferred from source dates) · Service Brakes, Hydraulic
There is no summary currently available
PE91064 · Transmission Fluid Fires
Opened Apr 9, 1991 · Closed Jul 5, 1991
Status: closed (inferred from source dates) · Power Train
There is no summary currently available