2022 Ford F-150 Hybrid

Two times the wheel end hub bolt on my left rear axle broke off. The first time the car was under warranty before the recall and the dealer provided a car for me to use while the truck was in the shop. This past week no vehicle or rental car was provided. The repair will take over one week to be completed. Since this is an ongoing problem without the final repair and parts until next year, Ford should be required to provide a vehicle to the customer.

What component or system failed or malfunctioned, and is it available for inspection upon request? The rear backup camera fails to show in the display and/or freezes. This happens inconsistently so it is not easy to reproduce. How was your safety or the safety of others put at risk? When backing up and using the camera, when the camera feed freezes it could look like nothing is behind the vehicle. Has the problem been reproduced or confirmed by a dealer or independent service center? No Has the vehicle or component been inspected by the manufacturer, police, insurance representatives or others? No Were there any warning lamps, messages or other symptoms of the problem prior to the failure, and when did they first appear? No. The problem has been happening since the vehicle was purchased.

PASSENGER SIDE REAR AXLE BOLT BROKE. Ford says the broken bolt could result in loss of drive power putting drivers or others at risk. Local Ford dealer confirmed axle failure and asked me to not drive the vehicle until they could get a replacement axle assembly installed which could take 1-4 weeks. There were no warning lamps or messages. I thought I could hear an unusual sound from the rear of the vehicle. The unusual sound occurred at around 57000 miles on the odometer.

The contact owns a 2022 Ford F-150. The contact stated while driving 65 MPH at midnight, there was an abnormally loud grinding and clunking sound coming from the rear of the vehicle. The contact was able to veer to the side of the road. The contact inspected the vehicle, but could not determine the cause of the failure. The vehicle was towed to the nearest dealer, where it was diagnosed that the rear axle hub bolt had fractured, causing the rear axle to be damaged. The dealer determined that the rear axle assembly and the rear axle hub bolt needed to be replaced. Additionally, the dealer determined that the failure was related to NHTSA Campaign Number: 23V896000(Power Train); however, the part to do the recall repair was not yet available. The dealer sent a diagnostic report to the manufacturer and ordered the same parts for the repair. The vehicle was not repaired. The contact notified the manufacturer of the failure and a case was opened. The failure mileage was approximately 52,000.

Loss of Acceleration in 2022 Ford F-150 PowerBoost Hybrid I am writing to report a safety issue with my 2022 Ford F-150 PowerBoost Hybrid, which has been experiencing acceleration lag and loss of power during regular driving conditions. Component/System that Failed: The powertrain system, specifically related to the integration between the electric motor and gasoline engine, appears to be malfunctioning. This issue primarily affects the vehicle's ability to accelerate after a stop or during turns. Safety Risk: The loss of acceleration poses a significant safety risk to both myself and others on the road. The delay in throttle response has caused the truck to remain in a low gear for several seconds, even with the accelerator fully pressed. This issue has occurred while merging onto highways, when moving through intersections, where quick acceleration is necessary to avoid collisions and a simply stop signs taking a turn where I'm not able to accelerate after. The delay increases the likelihood of rear-end collisions and creates dangerous situations, especially in heavy traffic. The problem has been reproduced by a dealer and many other owners have reported the same issue. I'm hoping that Ford has releases Powertrain Control Module (PCM) update aimed at addressing this, but the issue persists for many, including myself after recent PCM updates. The vehicle has been formally inspected by my local Ford dealership. They will be applying a PCM update on 10/10/2024. There were no warning lamps or error messages that appeared before or during the incidents. The problem occurs unexpectedly, usually when I press the accelerator, particularly in Eco or Normal driving modes. The issue has been less frequent in Sport and Tow/Haul modes, but this results in increased fuel consumption, which negates the advantages of the hybrid system.

When traveling at low speeds, 10-15 mph, and coasting (no accelerator input) then pressing the accelerator there is no response. The engine will not rev up and the truck will not accelerate for a good 6-8 seconds. It happens usually in parking lots or when making low speed turns onto street intersections or pulling out of driveways. This is dangerous, as pulling in front of traffic then having no acceleration for several seconds could cause a rear-ending accident. It also happens often when going over steep small speed bumps in the parking garage at my office. It's very annoying and in some situations very dangerous. This has been happening since I bought the truck in January 2023. It is now Sept 2024.

On 14 September, at approximately 11am, I rear ended another vehicle a Honda Pilot. I anticipated the vehicle in front of me pulling out into the intersection and took my eyes off that vehicle to look at vehicles approaching from my left. The vehicle in front of me stopped and I hit them moving less than 10 mph. The airbags didn't deploy and the people in both vehicles were fine. However, my 2022 Ford F-150 Platinum is equipped with emergency braking and pre-collision safety features. They did not engage and I hit the vehicle. People cannot rely on these systems protecting them.

I started my 2022 F150 with B/O Audio and an extremely loud blast that sounded like a cannon shot out of the speakers. My volume dial didn't work and loud crackling and popping sounds were coming out of the tweeter speakers. This has been reported many times already. Turning the audio and the entire vehicle off did nothing. Crackling actually would continue when vehicle was turned all the way off for at least 2 minutes, which would indicate some power was still being fed to the speakers for some reason. No warning lamps/messages appeared.

My vehicle lurches forward at low speeds which presents a collision risk. The check engine light illuminated and I received the following alert in the FordPass app: The powertrain control system has detected the transmission fluid auxiliary pump motor did not come on when commanded. The vehicle’s Start/Stop feature may not be active when this condition is present.

Another Ford F150 Supercrew leak from the front cowling area into the passenger floorboards. This is a 2022 Hybrid F150 Supercrew built during COVID and purchased March 9, 2022. There are too many reports online of leaks due to lack of sealing components where large aluminum parts meet. For example the fender and the cowling area. This particular leak is having a dealership spend 17 book hours at $215 per hour plus parts to fix a defect in workmanship. Ford is offering to partailly pay for the fix since the vehicle is 6000 miles out of warranty. The fact it is a defect in workmanship is not a consideration. It was never sealed. Thank you