2022 Ford F-150 Hybrid

I am reporting a safety-related transmission problem I experienced with my 2022 Ford F-150 equipped with the 10R80 automatic transmission. While driving normally, the transmission suddenly did not engage when I turned a corner when in 2nd gear it disengaged and I coasted to side of road safely good thing there was no traffic. I then noticed that the transmission would slip (not hard just slightly 1st-5th gears). This has happened a few times especially when I first start moving. This is creating a potentially dangerous situation because the truck did not respond as expected when I needed predictable acceleration or propulsion. I believe this incident may be related to the known 10R80 CDF clutch-cylinder/sleeve problem. Ford technical information identifies axial movement of the CDF sleeve that can cause hydraulic-circuit leaks and harsh or delayed engagement and shifting. This result in slipping, RPM flares, delayed engagement, unexpected gear changes, harsh downshifts, lurching, or loss of propulsion. This is a safety concern, not merely a transmission quality or reliability issue. Unexpected loss of propulsion or unpredictable shifting while merging, accelerating into traffic, crossing an intersection, turning, or traveling at highway speed can create a collision hazard. Because I personally experienced this unexpected transmission event, I request that NHTSA investigate the 10R80 CDF clutch-cylinder sleeve condition in Fords f150s. Please review Fords warranty claims, dealer repair records, transmission replacements, consumer complaints and field failure data to determine whether this is a safety defect requiring a recall. I believe owners should not have to wait for a potentially dangerous transmission failure before this known condition is addressed. Thank you [XXX] INFORMATION REDACTED PURSUANT TO THE FREEDOM OF INFORMATION ACT (FOIA), 5 U.S.C. 552(B)(6)

Vehicle in drive under normal daily driving conditions and vehicle suddenly lost power and stopped. Unable to restart vehicle and shifter is stuck in drive and does not shift to park. Similar to recall 22S43. According to dealership, they thought the issue occurred due to towing and assumed it was a electronic issue with the vehicle shifter. Prior to this incident, there was a strange type of kick back in the shifter but it never kicked out of gear though it seemed like it might. There were also warning dings that did not have any kind of message on the dash - it wasn't clear if this was tied to the shifter.

In April 2026 the recall on this truck was done to correct a fault for the Trailer Disconnect. I hooked up my travel trailer for the 1st time here in June and the false warning still came on 5 times during my trip. The software update that was done is not solving the problem. Warning light comes on, says trailer disconnected while the trailer is still connected and all connections are plugged in.

Day time running lamps on the side of the headlight have burnt out. First time it was the passenger side that died, had it replaced under warranty. then a few month later after my warranty was up, the driver side has now died as well. The fact I have had this truck 2 and a half year and both have failed is unacceptable. I see every single F150 on the road with THE EXACT SAME ISSUE! This isn't a fluke or bad luck on my vehicle. From my research online, tons of others are complaining about it too. The dealership wanted $2400.00 to replace it, with what is likely another faulty light that would have the same issue in a few years. This is a hazard to myself and others because my vehicle isn't lit up like it should be so that I am visible to others on the road. Also I have had 4 or 5 water leaks in the brief time of owning this truck that ford has blamed on me. Water gets in and collects on the passenger side floorboard under the carpet. I have been without my vehicle multiple times while they attempted to get a specialist to find the issue. Had to pay for my own rental vehicle for a week because they " dont give out loaners" even when you are under warranty.

NHTSA states to file a complaint if there has been no remedy in reference to a safety recall in a timely manner. As of to date there is still an open recall on my truck and Ford has stated the recall is incomplete due to no remedy yet available. This recall has been in place since 12/22/23. My truck did have a broken hub bolt and I believe the dealership replaced the passenger rear axle hub. The dealership told me that this is only a temporary repair until Ford comes up with a remedy.

There is a problem with the heating controls. The temperature will be set at 72 and is stable for awhile, even days, then will spontaneously heat until it's unbearably hot. This is a huge distraction while driving to having to keep messing with the controls. Safety issue! After numerous complaints to Ford's service department with no results as the technicians cannot duplicate issue and there are no codes. Purchased a thermal imaging camera: 97.8 dash vents, 55.1 at knees and 80 degrees at feet (driver's side). This is not a situation where the heating system is just trying to bring the cab up to temperature as this occurs when the truck has already been on the road for over an hour at a comfortable temperature and then it just erratically starts spewing out unbearable temperatures. I have thermal imaging pictures as high as 153 degrees Fahrenheit while the set temperature is 70. Something definitely wrong. I am submitting this complaint as I am tired of turning the truck in for repairs. Maybe if enough people say something, Ford will do something.

When at a signal light with the brake pushed, we are experiencing an issue where the whole vehicle will unexpectedly lurch forward as if hit from behind after coming to a stop. This could possibly result in the truck hitting the vehicle in front of you if you are in tight traffic. Our local dealer inspected but could not find a solution.

This is the 3rd time this has happened since purchasing this vehicle. Purchased on 7/27/24. The previous 2 times it resolved itself and the vehicle started and ran with no apparent issues afterwards.1st was on 8/05/24, 2nd was on 10/14/24. On this 3rd and current time I went to start the vehicle and vehicle would not start. The lights and radio work but the vehicle did not start. Only displayed a stop safely now message on the instrument panel. This is one of my worse fears happening as I type this. I'm stranded with a vehicle that will not start and my father is on his death bed with no way to get to him....