2021 Ford F-150 Hybrid

The contact owns a 2021 Ford F-150. The contact stated that while the vehicle was parked, a week after it had rained and twelve hours after it was last driven, there was an abnormal mildew odor inside the vehicle. The contact stated that there was condensation entering the vehicle from an unknown location and the carpet on the passenger’s side floor was wet. The contact stated that the sunroof was properly closed while it was raining. The vehicle was not diagnosed or repaired. The manufacturer was not notified of the failure. The failure mileage was 33,000.

2021 f150 POWERBOOST [XXX] Loss of engine power. Major electrical failure display on dash coast to a stop. Unable to restart, lock in park unable to be move from location. After 45 mins. of pushing restart button every 60 seconds get a restart, take to dealer unable to find problem.[XXX] Loss of engine power. Major electrical failure display on dash coast to a stop. Unable to restart, lock in park unable to be move from location. After 45 mins. of pushing restart button every 60 seconds get a restart. Notified dealer appt set for 20Jan2024 Special order pump was order for trans. {XXX] Truck was drop for the pump to be replace. [XXX] Dealership called, while the Tech was on a test drive, after the pump was installed, the Tech. had a Loss of engine power. Major electrical failure display on dash coast to a stop .Unable to restart , lock in park unable to be move from location. Dealer ship contacted Ford and and engineer has handle the repairs. The truck has been on the lot now for over 30days with now a needing a special order part on National back order. Have contacted Ford case # [XXX] with 2 attempts with no return phone calls. INFORMATION REDACTED PURSUANT TO THE FREEDOM OF INFORMATION ACT (FOIA), 5 U.S.C. 552(B)(6)

The contact owns a 2021 Ford F-150. The contact stated that while her husband was driving 15-20 MPH, the gears locked up. The contact stated that the check engine warning light was illuminated. The vehicle was restarted, and the check engine warning light was flashing. The vehicle was taken to the local dealer, where it was diagnosed that the cam phaser needed to be replaced. The vehicle was not repaired. The manufacturer was contacted and offered to cover 70 percent of the cost of the repair. The failure mileage was approximately 77,000.

The contact owns a 2021 Ford F-150. The contact stated that while her husband was driving at an undisclosed speed, he became aware that the windshield wipers were not functioning. No warning lights were illuminated. The vehicle was taken to the dealer, who diagnosed a failure with the windshield wiper motor. The vehicle was not repaired. After investigating the failure, the contact related the failure to NHTSA Campaign Number: 22V142000 (Visibility). The VIN was included, and the vehicle was repaired, but the failure occurred. The manufacturer was notified of the failure but did not assist. The failure mileage was 69,000.

My 2021 F-150 Powerboost randomly shuts down on the highway and while pulling out into traffic. When it shuts down the steering and brakes work but the engine is off/no acceleration and the truck displays a warning telling me to "Stop Safely Now". Truck has been look at many times by Ford and every time they give it back to me it happens again. There appears to be either and electrical or software issue but after 3 months Ford doesn't seem to know what's wrong with the truck even though they have reproduced the problem. It has happened over 20 times putting me and my family at risk of getting in an accident.

3.6.2021 - Ford F150 purchased at Battlefield Ford (Ourisman Ford), Manassus VA / registered in CT 7.27.21 – inspected by Torrington Ford, Torrington CT for rubbing sound front left side, nothing found / 6,325 miles 2.10.22 – inspected for same issue / nothing found / 16,000 miles 7.27.22 – inspected for same issue / nothing found / 24,000 miles 12.24.2022 – “Catastrophic failure” of front differential / 34,369 miles. On Christmas Eve 2022 myself, husband and son were driving to family in NY when the truck very quickly started to make a severe grinding sound, became unable to steer, loss of control, and started to produce smoke & fire under the hood. We immediately stopped and got out unharmed. Fire was dripping out of the bottom of the truck and smoke/fire under the hood. We were lucky. Firetrucks came but were unable to do anything. The truck's wheels completely seized up - the tow truck had to skid it onto the flatbed. Repaired at Simmons-Rockwell Ford, Hallstead, PA. Complete new front differential and damaged parts in proximity to the failure (pinion gear, axle shaft, etc). 12.16.2023 – Again hearing a sound in front left side while driving; bring to the shop for inspection. Shop confirms front differential is failing again, per Torrington Ford, (where all maintenance and repairs were completed, except for the first failed front differential in PA). Advise not to drive for safety reasons. 52,922 miles. With both front differential failures - no warning lights or messages. Symptoms - a slight rubbing/grinding noise in the front left side of vehicle; “rough” sound while driving. 1st front differential – inspected at 6,000 miles, 16,000 miles, and 24,000 miles. Failed at 34,369 miles. 2nd front differential – inspected at 52,922 miles, failing differential, advised not to drive. Dec 2023 – Buy-back claim filed with Ford Motor Co. Denied - "outside of the 18-month warranty period for VA Lemon Law". Clearly, safety is not a guiding tenet for Ford Motor Co.

On November 29, 2023 I took my 2021 F150 to Larry Miller Ford for servicing and repairs related to Recalls 22S71 and 23S35. When the tech was rotating the wheels he discovered that the axle shaft bolts were sheered off on both the left and right rear wheels. The service manager called to tell me that this was a serious safety issue and that only the brake rotors were preventing the wheels from falling off the truck. The service manager told me there was a "Customer Satisfaction Program 22B34" issued by Ford, but no Ford Recall relating to the problem. Larry Miller Ford has replaced both axles and axle bolts. I am waiting to find out if there is damage to the rotors, calipers or brake pads, a concern since the sheered off bolts were rattling around within that area since breaking off apparently between service visits. I strongly believe Ford should be required to issue a recall on this problem. I never received a notification on CSP 22B34. Had it not been for my tire rotation, the wheels could have fallen off at highway speed.

When making 90° turns such as an immediate right turn or a left turn across one lane, gas pedal becomes completly unresponsive halfway through the turn for approx 3 seconds. Occurs about 1% of the time but drastic when it occurs. Almost multiple accidents have occured with oncoming traffic almost t-boning me when making left turns or being rear ended on right turns: people don't anticipate a vehicle stalling and slowing down when entering traffic and people have swerved into other lanes or the shoulder to avoid a collision. When this occurs, it is like the vehicle goes brain dead, the gas pedal can be pushed to any threshold including floored with no change to speed; rpms dont even increase. Vehicle has been through Ford troubleshooting multiple times and at one point early on, had a Ford engineering/ specialist working remotely with the dealership. Findings from this specialist: two upcoming ota updates will be released that will resolve this concern. One of the updates was in regards to the trailer brake module and the other something else as equally ridiculous as not pertaining to my issue. OTA updates came and issue never went away. Years later, multiple appointments with techs saying unable to duplicate. Dealer now saying they have no record of working with a specialist even though I have the service records from them stating this and electronic communications from Ford regarding this. The issue is not resolved and still occurring. Vehicle now out of warranty so likely will never be repaired. Not faithful in thinking NHTSA will care, they didn't care when this vehicle had complete brake failure at 7k miles which was later found to be due to incomplete or bad programming, but maybe this will help others know they are not alone if experiencing this issue.

Radio started blasting a boom/ static sound from the rear speakers and subwoofer; extremely loud and has occurred multiple times. It had previously made a similiar sound occasionally at start up which when under warranty was always diagnosed as unable to duplicate but is now occuring while driving and I am out of warranty. Very startling and distracting when it occurs. Has occured multiple times and lasts upto an hour before I gave up an parked my vehicle. Have a special needs minimally verbal disabled child who is very sensitive to noise (rear speakers are always turned off via fade to front) who was very impacted by this loud explosion of chaos/ noise when it occured with him in the car. Ford response: since out of warranty can pay for diagnostic and repairs. Don't expect NHTSA to care as they weren't concerned with my complaint regarding complete loss of brakes (incomplete or bad programming) with this truck but maybe this will let others know they arent alone if they have this issue.

Console lid with integrated work table. Will not stay open and will slam shut because the springs are not strong enough to hold lid open. This has been present since the vehicle was purchased new. Several members of my family including me have had the lid slam on my fingers. The lid is heavy and it hurts. Local ford dealer said that the console in all the F150 do it and there is no fix from ford. I’m concerned that a grand child may open the lid and it slam down on their fingers and cause serious injury. Ive read multiply f150 complaints about this issue, and even a possible fix. the truck is still under warranty . Ive been dealing with issue from a month after the purchase. It’s a virtual mouse or rat trap to who ever opens the lid! I know this is not your typical safety issue, but it is a safety issue! Thank you