2021 Ford F-150 Hybrid

The contact owns a 2021 Ford F-150. The contact stated while driving approximately 65-70 MPH, the contact was flagged down by a nearby driver and advised to pull the vehicle over to the shoulder of the road. The contact stated that the vehicle was driven to the shoulder of the road. The contact exited the vehicle and proceeded to inspect the vehicle. The contact noticed that the rear driver's side rim cap had detached. The contact stated that the center axle bolt was still attached to the rim cap. The vehicle was towed to the dealer where it was diagnosed with a failed rear axle half shaft and hub and the rear axle half shaft and hub needed to be replaced. The vehicle was repaired. The contact stated that the driver's side rear axle bolt had previously been replaced and was under an unknown recall. In addition, the contact stated that the failure had occurred on five occasions within two years and that the vehicle was unsafe to be driven. The manufacturer was made aware of the failure and a case was filed. The failure mileage was approximately 20,000.

There hasn't been an incident yet. But, I want a record of this somewhere. I'm assuming there may be an incident in the future; and, I'm concerned about that. Either an incident with my truck or an incident with the 100s of thousands of Ford and Lincoln vehicles from 2017-2023 that have this issue. The issue is Ford SSM 51939 - a whining noise coming from the bellhousing and the front of the transmission fluid pan. I have taken my truck to a dealership. I have called Ford about this. I have researched extensively online. I have called NHTSA. I have emailed the Office of Vehicle Safety Compliance. I am now filing this report online. The safety issue? For me, I'm now having to wear EARPLUGS when driving my vehicle. For others, they have been told to turn up the radio. I am now hearing the noise all the time -- believe it or not, even sometimes when I'm not even in my truck. Ford needs to address this. They send me to you. I don't have the 'option' of TRADING IN MY VEHICLE...others don't either. What am I to do? When something serious happens because people are remedying this themselves...it will be a very sad day. But, maybe only then will Ford do something. I don't know what else to do other than call Ford everyday, and email every agency that may be able to apply some pressure. Sadly, I have a full-time job...and this is really frustrating for me, in more ways that one. Hope you have a nice day! [XXX] [XXX] [XXX] INFORMATION REDACTED PURSUANT TO THE FREEDOM OF INFORMATION ACT (FOIA), 5 U.S.C. 552(B)(6)

If you pull onto a road and try to accelerate, the vehicle is unresponsive. The RPMs will increase, yet the vehicle drive train (10 Speed Transmission) is unresponsive for several seconds. This has been an ongoing issue with the vehicle since new and was first reported to Ford Customer service on Jan 2022. Ford has made several attempts to fix this issue, yet the transmission continues to fail with the same issue. This is a critical safety issue that jeopardizes the passengers in the vehicle. Vehicle parking brake engages without notice. At any given time, the electronic parking brake engages without warning and you have to manually release. While sitting at a controlled intersection, on an inclined street, waiting for traffic light to change, with vehicle in Drive, foot on the brake, the electric parking brake engaged. Vehicle shift lever moved to the park position on its own. Vehicle engages it's parking brake and moves shift lever into Park while sitting in traffic is very dangerous. Vehicle shift column failed in drive and vehicle would not move or run. This caused drive train to lock in place, freezing all four tires. Ford had to drag truck onto flat bed with tires locked. It had to be dragged off flatbed when delivered to Ford dealer for repair. They had to put grease down on the flatbed so truck would slide off without tires rolling. While at the dealership, the mechanic had to manually disconnect the calipers in order to move vehicle. The safety backup features failed and would not release wheels (lever under steering column).

2021 f150 POWERBOOST [XXX] Loss of engine power. Major electrical failure display on dash coast to a stop. Unable to restart, lock in park unable to be move from location. After 45 mins. of pushing restart button every 60 seconds get a restart, take to dealer unable to find problem.[XXX] Loss of engine power. Major electrical failure display on dash coast to a stop. Unable to restart, lock in park unable to be move from location. After 45 mins. of pushing restart button every 60 seconds get a restart. Notified dealer appt set for 20Jan2024 Special order pump was order for trans. {XXX] Truck was drop for the pump to be replace. [XXX] Dealership called, while the Tech was on a test drive, after the pump was installed, the Tech. had a Loss of engine power. Major electrical failure display on dash coast to a stop .Unable to restart , lock in park unable to be move from location. Dealer ship contacted Ford and and engineer has handle the repairs. The truck has been on the lot now for over 30days with now a needing a special order part on National back order. Have contacted Ford case # [XXX] with 2 attempts with no return phone calls. INFORMATION REDACTED PURSUANT TO THE FREEDOM OF INFORMATION ACT (FOIA), 5 U.S.C. 552(B)(6)

The contact owns a 2021 Ford F-150. The contact stated that while her husband was driving 15-20 MPH, the gears locked up. The contact stated that the check engine warning light was illuminated. The vehicle was restarted, and the check engine warning light was flashing. The vehicle was taken to the local dealer, where it was diagnosed that the cam phaser needed to be replaced. The vehicle was not repaired. The manufacturer was contacted and offered to cover 70 percent of the cost of the repair. The failure mileage was approximately 77,000.

My 2021 F-150 Powerboost randomly shuts down on the highway and while pulling out into traffic. When it shuts down the steering and brakes work but the engine is off/no acceleration and the truck displays a warning telling me to "Stop Safely Now". Truck has been look at many times by Ford and every time they give it back to me it happens again. There appears to be either and electrical or software issue but after 3 months Ford doesn't seem to know what's wrong with the truck even though they have reproduced the problem. It has happened over 20 times putting me and my family at risk of getting in an accident.

3.6.2021 - Ford F150 purchased at Battlefield Ford (Ourisman Ford), Manassus VA / registered in CT 7.27.21 – inspected by Torrington Ford, Torrington CT for rubbing sound front left side, nothing found / 6,325 miles 2.10.22 – inspected for same issue / nothing found / 16,000 miles 7.27.22 – inspected for same issue / nothing found / 24,000 miles 12.24.2022 – “Catastrophic failure” of front differential / 34,369 miles. On Christmas Eve 2022 myself, husband and son were driving to family in NY when the truck very quickly started to make a severe grinding sound, became unable to steer, loss of control, and started to produce smoke & fire under the hood. We immediately stopped and got out unharmed. Fire was dripping out of the bottom of the truck and smoke/fire under the hood. We were lucky. Firetrucks came but were unable to do anything. The truck's wheels completely seized up - the tow truck had to skid it onto the flatbed. Repaired at Simmons-Rockwell Ford, Hallstead, PA. Complete new front differential and damaged parts in proximity to the failure (pinion gear, axle shaft, etc). 12.16.2023 – Again hearing a sound in front left side while driving; bring to the shop for inspection. Shop confirms front differential is failing again, per Torrington Ford, (where all maintenance and repairs were completed, except for the first failed front differential in PA). Advise not to drive for safety reasons. 52,922 miles. With both front differential failures - no warning lights or messages. Symptoms - a slight rubbing/grinding noise in the front left side of vehicle; “rough” sound while driving. 1st front differential – inspected at 6,000 miles, 16,000 miles, and 24,000 miles. Failed at 34,369 miles. 2nd front differential – inspected at 52,922 miles, failing differential, advised not to drive. Dec 2023 – Buy-back claim filed with Ford Motor Co. Denied - "outside of the 18-month warranty period for VA Lemon Law". Clearly, safety is not a guiding tenet for Ford Motor Co.

On November 29, 2023 I took my 2021 F150 to Larry Miller Ford for servicing and repairs related to Recalls 22S71 and 23S35. When the tech was rotating the wheels he discovered that the axle shaft bolts were sheered off on both the left and right rear wheels. The service manager called to tell me that this was a serious safety issue and that only the brake rotors were preventing the wheels from falling off the truck. The service manager told me there was a "Customer Satisfaction Program 22B34" issued by Ford, but no Ford Recall relating to the problem. Larry Miller Ford has replaced both axles and axle bolts. I am waiting to find out if there is damage to the rotors, calipers or brake pads, a concern since the sheered off bolts were rattling around within that area since breaking off apparently between service visits. I strongly believe Ford should be required to issue a recall on this problem. I never received a notification on CSP 22B34. Had it not been for my tire rotation, the wheels could have fallen off at highway speed.

I heard a scratchy rattling sound around 35-36k miles at very low speeds. Eventually narrowed it down to the passenger rear wheel area. I took off the wheel to inspect the area and the head of the axle bolt fell out. It looked to have been yielded from over torquing or something. But I was shocked! I have no idea the actual period of failure. If I hadn’t rolled my windows down for the nice weather, I probably wouldn’t have heard it. I checked and there has been no recall or anything sent to me that this is a problem. I tow a camper with the family and if the axle failed while doing so, it could of killed us. Very unhappy that Ford has not recalled this. There are many others on a Facebook group that have had the same issue. It needs to be Remedied.

Vehicle came to complete stop in traffic with warning light "stop vehicle" would not restart. Taken to dealership. Dealership replaced ecu and some switches to power bank and wiring harness behind headlight. Vehicle was returned 1 week later Drove it 2 days later for 10 miles same thing happened, Ford towed it to another dealership where they cleared codes, and they said they can't replicate, Vehicle was returned after a week. 2 days later I drove yo work and again iy happened stopped in middle of road blocking traffic. Was towed by Ford to dealership where they found over 20 codes, said they can't fix. Ford and selling dealer towed to selling dealer, where they cleared codes and said they can't replicate. I refused yo take Vehicle on fear of getting in severe crash when Vehicle stalls and dies in heavy traffic again. I signed title and sent it to selling dealer, they told me that fordwill not let them buy it back. Do I don't have my money or a truck now