NHTSA owner reports · September 18, 2026 snapshot.
What owners actually said
728 reportsMileage unknown · Jan 24, 2024
Structure
On the exterior this car has a plastic A-pillar cover on both sides of the windshield, i already had one fly off on expressway ( luckily didnt hit anyone or cause an accident) i replaced the one, but now the other side is coming loose as well, not sure if its a defect in the clips or the design , but the dealer doesnt acknowledg…
Read full complaint
On the exterior this car has a plastic A-pillar cover on both sides of the windshield, i already had one fly off on expressway ( luckily didnt hit anyone or cause an accident) i replaced the one, but now the other side is coming loose as well, not sure if its a defect in the clips or the design , but the dealer doesnt acknowledge this to be a problem, there happily charging 600.00 to replace each A-pillar and they keep coming loose
NHTSA ODI #11567624
Mileage unknown · Jan 24, 2024
Structure
Was driving on the high way and the B pillar trim detached and was hanging by the wire. No damage was done to this area prior and appears the adhesive gave out. Due to incident back lift gate is inoperable and displays as open.
NHTSA ODI #11567529
Mileage unknown · Jan 13, 2024
StructureCrash
I was driving on the freeway when one of my A pillers flew off and cause the person behind me to loose control of their car. About 5 min later the other a piller flew off almost causing an accident with a semi and trailer.
NHTSA ODI #11565318
Mileage unknown · Jan 11, 2024
Electrical System
My screen went black for my Ford Explorer. I have no access to climate controls, backup Camera, radio, GPS, etc. My local Ford dealership said there was a recall pending but that’s been a few months now. It’s very dangerous driving like that with my 4 and 2 year old in the car.
NHTSA ODI #11564788
Mileage unknown · Jan 11, 2024
Structure
The passenger windshield trim piece blew off my vehicle on the interstate yesterday and caused the vehicle behind me to swerve to try to avoid it. Looking through my rear view mirror, the driver appeared to lose control due to over correction. The driver avoided a collision and crash, but it looked hairy for a few moments. Th…
Read full complaint
The passenger windshield trim piece blew off my vehicle on the interstate yesterday and caused the vehicle behind me to swerve to try to avoid it. Looking through my rear view mirror, the driver appeared to lose control due to over correction. The driver avoided a collision and crash, but it looked hairy for a few moments. The driver's side trim piece blew off my vehicle last year. After Googling, I see that this is a very common problem that should be addressed, in my opinion, with a recall due to safety.
NHTSA ODI #11564780
Mileage unknown · Jan 10, 2024
Power Train
January 2023 - vehicle shifts hard, revs high between shift points, almost jumps between shifts. Trouble code p0757- shift solenoid “b” stuck open. 85,000 miles. Cost to fix $900. December 2023 - same code, same symptoms. Now entire transmission needs to be replaced at a cost of $6600. 100,000 miles.
NHTSA ODI #11564701
Mileage unknown · Jan 6, 2024
Suspension
After dealer inspection of my 2018 Ford Explorer, I was informed that the rear knuckles needed replacement due to cracked bushing. I was informed that this is a safety issue that needs to be addressed immediately, at a cost of $2400.00. After some cursory research I found that there was a recall for 2011-2017 Ford Explorers wi…
Read full complaint
After dealer inspection of my 2018 Ford Explorer, I was informed that the rear knuckles needed replacement due to cracked bushing. I was informed that this is a safety issue that needs to be addressed immediately, at a cost of $2400.00. After some cursory research I found that there was a recall for 2011-2017 Ford Explorers with the same issue, but not for 2018. This is obviously a known problem and should be addressed for 2018 vehicles.
NHTSA ODI #11563921
99,800 miles · Jan 2, 2024
Structure
The contact owns a 2018 Ford Explorer. The contact stated that while driving approximately 55 MPH, the passenger’s side trim detached from the vehicle. The trim struck the front windshield of another vehicle, causing the other driver to lose control of the vehicle and the vehicle spun out. The contact was unsure if the front win…
Read full complaint
The contact owns a 2018 Ford Explorer. The contact stated that while driving approximately 55 MPH, the passenger’s side trim detached from the vehicle. The trim struck the front windshield of another vehicle, causing the other driver to lose control of the vehicle and the vehicle spun out. The contact was unsure if the front windshield was cracked due to the impact. There were no reported injuries. The contact called the local dealer and was referred to a Collision Center for assistance. The vehicle was not diagnosed or repaired. The Collision Center was contacted and provided an estimate for the repair. The manufacturer was contacted, opened a case, and referred the contact to the NHTSA Hotline. The failure mileage was approximately 99,800. The VIN was not available.
NHTSA ODI #11562975
Mileage unknown · Dec 22, 2023
Structure
Windshield cowl (trim) had deteriorated, possibly due to common heat and sun damage. 1. We do not know whether or not the deteriorated cowl will affect windshield stability or water leaks. If windshield stability is affected, it would affect safety. 2. Other complaints have noted that pieces of deteriorated cowl/trim have imp…
Read full complaint
Windshield cowl (trim) had deteriorated, possibly due to common heat and sun damage. 1. We do not know whether or not the deteriorated cowl will affect windshield stability or water leaks. If windshield stability is affected, it would affect safety. 2. Other complaints have noted that pieces of deteriorated cowl/trim have impacted safety of nearby vehicles. 3. The vibration, humming, and buzzing are irritating to drivers and passengers. // This observed deterioration occurred when the vehicle was 5 years old, however, we know of the same problem occurring in a 2019 Explorer at about 3 years. // The local Ford dealer stated it would cost over $650 to replace the cowl.
NHTSA ODI #11561590
115,631 miles · Dec 19, 2023
Power Train
The contact owns a 2018 Ford Explorer. The contact stated while driving at various speeds and depressing the accelerator pedal, the vehicle shuddered and hesitated to respond. There was no warning light illuminated. The contact stated that the failure also occurred while driving with Adaptive Cruise Control mode engaged. The veh…
Read full complaint
The contact owns a 2018 Ford Explorer. The contact stated while driving at various speeds and depressing the accelerator pedal, the vehicle shuddered and hesitated to respond. There was no warning light illuminated. The contact stated that the failure also occurred while driving with Adaptive Cruise Control mode engaged. The vehicle was taken to the dealer, where the transmission fluid was flushed. The contact stated that the failure recurred increasingly after 4,000 miles. The contact stated while at a complete stop and depressing the brake pedal, the vehicle shuddered significantly as if the vehicle was attempting to drive forward. The contact stated that he applied more pressure on the brake pedal. The vehicle was taken back to the dealer, where it was diagnosed and determined that the transmission needed to be replaced. The vehicle was not repaired. The manufacturer was notified of the failure, but no assistance was provided. The failure mileage was 115,631.
NHTSA ODI #11560925
Official recalls
7Jul 14, 2026
Ford Motor Company (Ford) is recalling certain 2016-2019 Explorer vehicles. The roof rail covers may come loose and detach from the vehicle.
Consequence & remedy
Consequence: A detached roof rail cover can create a road hazard, increasing the risk of a crash.
Remedy: Dealers will inspect the roof rail covers and as necessary, repair or replace the push-pins, rail clips, or roof rail covers, free of charge. Interim letters, notifying owners of the safety risk, were mailed August 28, 2026. Additional letters will be sent once the remedy is available, anticipated in January 2027. Owners may contact Ford customer service at 1-866-436-7332. Ford's number for this recall is 26S54. This recall expands previous NHTSA recall number 21V316. Vehicle Identification Numbers (VINs) involved in this recall became searchable on NHTSA.gov on July 16, 2026.
Feb 20, 2026
Ford Motor Company (Ford) is recalling certain 2017-2019 Explorer vehicles. The rear suspension toe links may fracture.
Consequence & remedy
Consequence: A rear toe link fracture can result in a loss of steering control, increasing the risk of a crash.
Remedy: Dealers will replace the toe links, free of charge. Owner notification letters were mailed on March 16, 2026. Owners may contact Ford Customer Service at 1-866-436-7332. Ford's number for this recall is 26S08. This recall is an expansion of previous NHTSA recall number 21V537. Vehicle Identification Numbers (VINs) involved in this recall will be searchable on NHTSA.gov beginning February 25, 2026.
Oct 10, 2025
Ford Motor Company (Ford) is recalling certain 2016-2019 Lincoln MKC, 2016-2023 Explorer, 2019-2020 Fusion, 2019-2024 Ranger, 2020-2022 Lincoln Corsair, Escape, 2021-2024 Bronco, Bronco Sport, and 2022-2024 Maverick vehicles. The engine block heater may crack and develop a coolant leak, causing it to short circuit when the block heater is plugged in.
Consequence & remedy
Consequence: An electrical short circuit can increase the risk of a fire.
Remedy: Owners are advised not to plug in their block heater until the vehicle is remedied. Dealers will replace the block heater, free of charge. Owners will also have a alternative option to replace engine block heater element with a threaded blanking plug, and remove the block heater electrical cord. Interim letters, notifying owners of the safety risk, were mailed December 3, 2025. Additional letters will be sent once the final remedy is available, anticipated September 2026. Owners may contact Ford customer service at 1-866-436-7332. Ford's number for this recall is 25SA4. Vehicle Identification Numbers (VINs) involved in this recall became searchable on NHTSA.gov on October 15, 2025.
Jan 19, 2024
Ford Motor Company (Ford) is recalling certain 2011-2019 Explorer vehicles. The A-pillar trim retention clips may not be properly engaged, allowing the trim to detach.
Consequence & remedy
Consequence: A detached trim piece can fall off the vehicle, becoming a road hazard and increasing the risk of a crash.
Remedy: Dealers will inspect and replace the A-pillar trim as necessary, free of charge. This will be a phased campaign, with the remedy becoming available in different phases based on model years. Owner notification letters were mailed between July 18, 2024 and December 16, 2025. Owners may contact Ford customer service at 1-866-436-7332. Ford's number for this recall is 24S02.
May 5, 2021
Ford Motor Company (Ford) is recalling certain 2016-2019 Explorer vehicles. The retention pins could loosen and allow the roof rail covers to detach from the vehicle.
Consequence & remedy
Consequence: A detached roof rail cover can create a road hazard, increasing the risk of a crash.
Remedy: Dealers will install push-pins and replace any damaged rail clips and roof rail covers, as necessary, free of charge. The interim owner notification letter was mailed on June 22, 2021. Owner notification letters (remedy available) were mailed on October 1, 2021. Owners may contact Ford customer service at 1-866-436-7332. Ford's number for this recall is 21S22.
Aug 28, 2019
Ford Motor Company (Ford) is recalling certain 2018-2020 F-150 and 2019-2020 F-250, F-350, F-450, and F-550 Super Duty pickup trucks, and 2018-2019 Ford Explorer, 2019-2020 Expedition, and 2020 Escape vehicles equipped with driver and/or passenger's manual front seat back recliner mechanisms. Also included are certain 2020 Ford Explorer and Lincoln Aviator vehicles equipped with rear outboard seats and manual seat back recliner mechanisms. The recliner mechanisms may be missing the third pawl required for seat back strength, resulting in a loose seat back. As such, these vehicles fail to comply with the requirements of Federal Motor Vehicle Safety Standard (FMVSS) numbers 202, "Head Restraints" and 207, "Seating Systems."
Consequence & remedy
Consequence: A seat back with an improperly assembled recliner mechanism may have reduced strength and may not adequately restrain an occupant in a crash, increasing the risk of injury.
Remedy: Ford will notify owners, and Ford and Lincoln dealers will inspect the seat structure and replace them, as necessary, free of charge. The recall began October 21, 2019. Owners may contact Ford customer service at 1-866-436-7332. Ford's number for this recall is 19C07.
Additional source detail variants (2)
Seats:mid/rear Assembly
Ford Motor Company (Ford) is recalling certain 2018-2020 F-150 and 2019-2020 F-250, F-350, F-450, and F-550 Super Duty pickup trucks, and 2018-2019 Ford Explorer, 2019-2020 Expedition, and 2020 Escape vehicles equipped with driver and/or passenger's manual front seat back recliner mechanisms. Also included are certain 2020 Ford Explorer and Lincoln Aviator vehicles equipped with rear outboard seats and manual seat back recliner mechanisms. The recliner mechanisms may be missing the third pawl required for seat back strength, resulting in a loose seat back. As such, these vehicles fail to comply with the requirements of Federal Motor Vehicle Safety Standard (FMVSS) numbers 202, "Head Restraints" and 207, "Seating Systems."
Consequence: A seat back with an improperly assembled recliner mechanism may have reduced strength and may not adequately restrain an occupant in a crash, increasing the risk of injury.
Remedy: Ford will notify owners, and Ford and Lincoln dealers will inspect the seat structure and replace them, as necessary, free of charge. The recall began October 21, 2019. Owners may contact Ford customer service at 1-866-436-7332. Ford's number for this recall is 19C07.
Seats:front Assembly:recliner
Ford Motor Company (Ford) is recalling certain 2018-2020 F-150 and 2019-2020 F-250, F-350, F-450, and F-550 Super Duty pickup trucks, and 2018-2019 Ford Explorer, 2019-2020 Expedition, and 2020 Escape vehicles equipped with driver and/or passenger's manual front seat back recliner mechanisms. Also included are certain 2020 Ford Explorer and Lincoln Aviator vehicles equipped with rear outboard seats and manual seat back recliner mechanisms. The recliner mechanisms may be missing the third pawl required for seat back strength, resulting in a loose seat back. As such, these vehicles fail to comply with the requirements of Federal Motor Vehicle Safety Standard (FMVSS) numbers 202, "Head Restraints" and 207, "Seating Systems."
Consequence: A seat back with an improperly assembled recliner mechanism may have reduced strength and may not adequately restrain an occupant in a crash, increasing the risk of injury.
Remedy: Ford will notify owners, and Ford and Lincoln dealers will inspect the seat structure and replace them, as necessary, free of charge. The recall began October 21, 2019. Owners may contact Ford customer service at 1-866-436-7332. Ford's number for this recall is 19C07.
Nov 14, 2018
Ford Motor Company (Ford) is recalling certain 2018 Ford Explorer vehicles equipped with 2.3L or 3.5L GTDI engine. Due to an assembly error, the fuel pressure sensor may leak fuel.
Consequence & remedy
Consequence: A fuel leak in the presence of an ignition source can increase the risk of a fire.
Remedy: Ford will notify owners, and dealers will replace the fuel line assembly, free of charge. The recall began December 7, 2018. Owners may contact Ford customer service at 1-866-436-7332. Ford's number for this recall is 18S35.
Model-level recall history does not show whether a particular VIN is affected or has received a repair. Check a VIN with NHTSA ↗
NHTSA investigations
2PE23001 · Windshield Trim Molding Item Detachment
Opened Jan 27, 2023 · Closed Feb 8, 2024
Status: closed (inferred from source dates) · Structure:body:roof And Pillars
On January 27, 2023, the Office of Defects Investigation (ODI) opened PE23-001 to investigate allegations of A-pillar trim panel detachment on model year (MY) 2011-2019 Ford Explorer vehicles. At the time of opening, the office had received 164 Vehicle Owner Questionnaires (VOQs) reporting this failure. ODI has received 671 VOQs regarding this failure, including 1 alleged crash and 2 alleged injuries. Some consumers have reported that the failure occurred while they were driving at highway speeds, with the detached trim panel entering the path of travel of the vehicle behind them, requiring the driver of the following vehicle to take evasive action. It is noteworthy that motorists who experience this type of road hazard are less likely to accurately identify the subject vehicle the item detached from and report the event to the NHTSA. In its April 17, 2023 response to ODI’s information request, Ford provided 175 consumer complaints (including field reports) and 14,162 warranty claims related to A-pillar trim panel detachment. Ford relayed that the subject vehicles utilize a plastic A-pillar bracket, which is bolted to the vehicle structure during assembly. The A-pillar trim panel is attached to the bracket utilizing 7 plastic clips. Contributory factors which have been identified by Ford as leading to the subject defect include incomplete installation at the assembly plant, inadequate part stack up, damage to fasteners during installation, and failure to follow proper repair procedure during windshield replacements or other services. On January 19, 2024, Ford filed safety recall 24V-031 for MY 2011-2019 Ford Explorer vehicles to address the subject defect. In the Part 573 Safety Recall Report, Ford identified that a detached A-pillar trim panel can create a road hazard for other road users, increasing the risk of a crash. The recall remedy includes an inspection of the existing A-pillar trim panel and, if necessary, the replacement of the component. The remedy A-pillar trim panels will be installed with an additional adhesive for robustness and utilize an inspection procedure to ensure full engagement of all the retention clips during installation. In view of the recall action being taken by Ford, ODI is closing this Preliminary Evaluation. The agency reserves the right to take additional action if warranted by future circumstances. To review the reports cited in the Closing Resume ODI Report Identification Number document, go to NHTSA.gov.
AQ22003 · Hertz/vehicles Rented With Open Recalls
Opened Dec 16, 2022 · No close date supplied
Status: open (inferred from source dates) · Latches/locks/linkages:hood:latch
NHTSA is opening this audit query to investigate whether The Hertz Corporation (Hertz) has complied with the requirements of the National Traffic and Motor Vehicle Safety Act (Safety Act). The Safety Act requires, among other things, that a rental company shall not rent a vehicle subject to a safety recall unless the recall remedy has been performed. 49 U.S.C. § 30120(i).NHTSA is in receipt of information that indicates Hertz rented vehicles to customers without having performed required recall repairs. Accordingly, we are opening this audit query to seek additional information concerning this issue.
Illustration