2018 Ford Explorer

The contact owns a 2018 Ford Explorer. The contact stated while driving 73 MPH, the front driver's side window exterior trim where the keyless entry keypad was located, had detached, and was hanging by the electrical wiring. The vehicle was taken to the dealer, but the vehicle was not diagnosed or repaired. Additionally, the contact received notification of NHTSA Campaign Number: 24V031000 (Structure); however, the part to do the recall repair was not yet available. The local dealer was contacted. The contact stated that the manufacturer had exceeded a reasonable amount of time for the recall repair. The manufacturer was not made aware of the failure. The failure mileage was approximately 60,950. Parts distribution disconnect.

My cars B Pillar (security pad) became unattached from my car while simply driving down the road. This part detaching caused my liftgate to lock and make me unable to open my truck for anyone and also the part could have fallen into the road way and caused a disturbance or accident to cars behind me. There was no indication of my security pad going to detach from my car and with the current recall on the A Pillars it is safe to believe that manufacturing caused this issue as well with the B Pillars as other Explorer owners have had this similar experience with the vehicles.

Ford EcoBoost 2.0 engine failure at 66,000 miles as coolant has leaked into the engine compartment and oil pan. Known issue by Ford as design defect on the EcoBoost engines. Current class action lawsuit over this [XXX] et al., v. Ford Motor Company, Case No. [XXX], filed in the United States District Court for the District of Delaware. Plaintiffs have experienced the exact same failures on the EcoBoost engines. Ford issued multiple technical service bulletins (TSBs) and other service messages for vehicles equipped with EcoBoost engines. Luckily, the failure occurred at home and not while driving at highway speeds as there have been reports of fires occurring if vehicle is moving during failure. Vehicle began rough idling 7-10 days ago and check engine light showed a code for misfire of cylinder. Had plugs changed but check engine light returned and then as of today, after overheating light came on dash upon startup with clouds of white smoke coming from exhaust, checked coolant levels and it was empty and drained down into the oil pan showing milky colored oil. Again... Ford knows about this issue with EcoBoost and has since 2017 and has failed to issue recall for customer safety due to cost factors and continues to address on case by case basis with most common offer to cover partial cost of engine replacement. Most consumers don't have the financial resources to sue Ford, so they continue to take advantage of their size and financial power to abuse customers. Please take action about this known issue and review the above class action case before Ford's negligence results in consumer death or serious injury. INFORMATION REDACTED PURSUANT TO THE FREEDOM OF INFORMATION ACT (FOIA), 5 U.S.C. 552(B)(6)

The contact owns a 2018 Ford Explorer. The contact received notification of NHTSA Campaign Number: 24V031000 (Structure) however, the part to do the recall repair was not yet available. The contact stated that the manufacturer had exceeded a reasonable amount of time for the recall repair. The contact stated that while the vehicle was parked, the contact's husband noticed that the passenger's side front windshield trim had detached. In addition, the contact stated that the passenger's side front windshield trim clips had fractured. The dealer was made aware of the failure but confirmed that parts were not yet available for the recall repair. The vehicle was not repaired. The manufacturer was not made aware of the failure. The failure mileage was approximately 80,000. VIN tool confirms parts not available.

The contact owns a 2018 Ford Explorer. The contact received notification of NHTSA Campaign Number: 21V316000 (Structure); however, the part to do the recall repair was not yet available. The contact stated that the manufacturer had exceeded a reasonable amount of time for the recall repair. The dealer was made aware of the issue and confirmed that parts were not yet available. The manufacturer was made aware of the issue and confirmed that parts were not yet available. The contact had not experienced a failure. Parts distribution disconnect.

Power Steering Assist Fault warning flashed briefly on 6/1/2024, everything has been fine until 6/8/2024 I went out and started my car the Power Steering Assist Fault warning came on again so I turned the car off and turned it back on the warning was still there. My husband came out and did the same thing, still there. He noticed that the steering wheel was locked and would not turn easily. So we took it down to the Ford Dealership and it is the steering rack needs replaced. My car has 21,000 miles on it. Going to be in shop for 4 days to fix.

The contact owns a 2018 Ford Explorer The contact received notification of NHTSA Campaign Number: 24V031000 (Structure); however, the part to do the recall repair was not yet available. The local dealer was contacted and confirmed that parts were not yet available. The contact stated that the manufacturer had exceeded a reasonable amount of time for the recall repair. The manufacturer was not made aware of the issue. The contact had not experienced a failure. VIN tool confirms parts not available.

The contact owns a 2018 Ford Explorer. The contact received notification of NHTSA Campaign Number: 24V031000 (Structure) however, the part to do the recall repair was not yet available. The contact stated that while at a complete stop and attempting to turn left, the steering wheel seized, and the vehicle veered to the right. The vehicle was taken to an independent mechanic who diagnosed the vehicle with a fractured steering column. The contact was informed that the steering column needed to be replaced. The vehicle was repaired. The manufacturer was made aware of the failure and referred the contact to the NHTSA Hotline. The failure mileage was approximately 20,261.

I own a 2018 Ford Explorer there has been an issue when it’s cold out the APIM is not responding and turning on the reverse camera when vehicle is put into reverse. When it is above 70 degrees Fahrenheit the APIM works intermittently. The problem with this is out of the blue when it decides to work at times it turns the radio on with volume at max level This has startled me not knowing it’s going to come on and it won’t let you turn the radio down or power it off. Ford says there is no recall on the issue.