2018 Ford Explorer

While driving at highway speed on a 2-lane highway with three children under the age of [XXX] in the vehicle, my 2018 Ford Explorer experienced sudden complete engine failure with no prior warning. No warning lights, no temperature gauge change, no unusual sounds. The vehicle went from operating normally to catastrophic failure instantaneously, forcing me to sharply cross active traffic to exit the roadway. The vehicle came to rest near a train track. The root cause was internal water pump failure. Ford's design places the water pump inside the engine, causing coolant to leak internally with no external indicators and no dashboard warning until catastrophic damage has already occurred. Ford did not install a coolant level sensor in the reservoir, and the only coolant warning available is an overheating alert, which never triggered. I had taken every reasonable precaution. Two thousand miles prior, an oil change showed no coolant contamination. One week prior, I physically checked the coolant level and it was within safe range. Ford's design gave me zero opportunity to detect or prevent this failure. This is a known recurring issue. Over 86 engine complaints have been filed with NHTSA for this model year alone and Ford has been aware of this defect since at least 2007. Despite class action litigation in both Canada and the United States, Ford has not issued a U.S. recall. Repair costs exceed $9,000. I am requesting NHTSA open a formal investigation and compel Ford to issue a U.S. recall. INFORMATION REDACTED PURSUANT TO THE FREEDOM OF INFORMATION ACT (FOIA), 5 U.S.C. 552(B)(6)

The contact owns a 2018 Ford Explorer. The contact stated that while driving at approximately 30 MPH, the check engine warning light illuminated. The vehicle was driven to the residence and then to an independent mechanic shop, where a full diagnostic inspection was not performed; however, the mechanic suspected that coolant bubbled internally and the contact was informed that the head gasket might need to be replaced. The mechanic was unable to disassemble the engine for further inspection. The vehicle was then taken to a dealer, who diagnosed that the water pump needed to be replaced, and the vehicle was repaired. The manufacturer was not notified of the failure. The failure mileage was approximately 112,000.

The contact owns a 2018 Ford Explorer. The contact had received notification of NHTSA Campaign Number: 26V101000 (Suspension), and the recall repair was completed. The contact stated that immediately after the recall repair, while driving on several occasions at various speeds, the rear end of the vehicle fishtailed, and the contact lost control of the vehicle. The vehicle was taken to the same dealer on several occasions; however, the failure could not be duplicated. The contact was advised that the tires needed to be replaced. The contact purchased and replaced the tires and had a four-wheel alignment performed, but the failure persisted, although not as severe. While the vehicle was parked, the contact became aware that the tread on the rear tires was extremely worn. The manufacturer was notified of the failure. The failure mileage was approximately 118,000.

The contact owns a 2018 Ford Explorer. The contact received notification of NTHSA Campaign Number: 24V031000 (Structure); however, the part to do the recall repair was not yet available. The local dealer was contacted. The contact stated that the dealer had exceeded a reasonable amount of time for the recall repair. The manufacturer was not made aware of the issue. The contact had not experienced a failure.

Less that 100k miles and my transmission already needs replaced. Last year my engine was sputtering making my car jerk while driving went to shop they did a total transmission fluid changed but said my transmission is likely going bad it helped mostly and I had high hopes the problem was solved it was not fast forward to now my transmission went then caused the torque converter to go my car was shaking so bad while stopped and in drive in order to go i had to put my foot all the way to the floor and quickly move to the break sometimes my car would fly other times it would take so long to go that people would try to fly around me then my car would shoot forward and id have to slam on breaks and the rpm gage was all over the place while maintaining the same speed. My car should not need a new transmission at under 84000 miles. This was so dangerous. When I did a search so many reddit posts about 2018 explorers torque converters and Transmissions going bad. I'm livid. I don't have 8k to replace the transmission in a vehicle i still owe 10k on

Vehicle: 2018 Ford Explorer Mileage at Failure: 62,212 miles On [XXX] while driving my 2018 Ford Explorer, the wrench warning light suddenly illuminated on the dashboard. At the same time, the vehicle experienced a significant loss of power and became extremely sluggish in acceleration. When I pressed the accelerator pedal, the vehicle failed to respond normally and did not accelerate as expected. This condition created a serious safety hazard because the vehicle could not maintain or increase speed when needed in traffic. Had this occurred while entering a highway, crossing an intersection, or attempting to avoid another vehicle, it could have resulted in a crash. The vehicle has been inspected by McCarthy Ford. The dealership diagnosed transmission-related problems and provided a repair estimate of $6,384.94. Ford Motor Company previously issued Customer Satisfaction Programs 20B27 and 20N07 for certain Ford Explorer vehicles equipped with the 6F35 transmission. Ford's own documentation acknowledges that transmission torque converter overheating may result in low performance, lack of acceleration during launch, sluggish vehicle operation, vibration, shuddering, and related transmission concerns. These symptoms are consistent with the condition experienced in my vehicle. I reported the issue to Ford Motor Company and sent a certified letter to CEO James D. Farley, Jr. requesting assistance and a policy adjustment due to the known transmission and torque converter concerns. To date, I have not received a satisfactory response. I am submitting this complaint because the sudden loss of acceleration and reduced vehicle power created a significant safety risk while operating the vehicle on public roadways. INFORMATION REDACTED PURSUANT TO THE FREEDOM OF INFORMATION ACT (FOIA), 5 U.S.C. 552(B)(6)

The contact owns a 2018 Ford Explorer. The contact received notification of NHTSA Campaign Number: 24V031000 (Structure); however, the part to do the recall repair was not yet available. The contact stated that while driving 65 MPH, the front Driver-side A-pillar trim detached and struck a nearby vehicle. The contact pulled over to check on the vehicle that was struck by the front driver’s side A-pillar trim and retrieved the trim piece. The local dealer was contacted. The contact stated that the manufacturer had exceeded a reasonable amount of time for the recall repair. The manufacturer was made aware of the failure, but no assistance was provided. The failure mileage was approximately 45,000.

My vehicles transmission has been replaced 2 times already (3 years apart)- now it is overheating. Absolutely no warning lights have came on at any time in regards to any of my situations - My vehicle is available for inspection at any time. When the transmission went in my vehicle, I was traveling on an interstate with my child. The dealer has confirmed replaced the transmission as it was still under the 5 year warranty - my vehicle is set to go back into the shop today to be inspected as to why it is overheating.

The airbag light shown in the attached photo came on at an unknown period of time. We did not know when this came on that it was not a normal light. This is a safety issue as there are many causes for this light to come on, and with this light being on the airbag may not deploy properly or at all during a collision. We did take the vehicle to the Ford dealership for warranty work and they did not say anything about the light on the dash. Which adds to the reason why we did not know that the light meant there was a problem. There are other airbag lights that come on in the sinners console for the passenger side airbags that are orange as well.